Application of spray drying, spray chilling and the combination of both methods to produce tucumã oil microparticles: characterization, stability, and ß-carotene bioaccessibility.

The aim of this work was to produce tucumã oil (PO) microparticles using different encapsulation methods, and to evaluate their properties, storage stability and bioaccessibility of the encapsulated ß-carotene. Gum Arabic was used as carrier for spray drying (SD), while vegetable fat was the wall material for spray chilling (SC) and the combination of the methods (SDC). Powders were yellow (hue angle around 80°) and presented particles with small mean diameters (1.57-2.30 µm). PO and the microparticles possess high ß-carotene contents (∼0.35-22 mg/g). However, some carotenoid loss was observed in the particles after encapsulation by SD and SDC (around 20%). After 90 days of storage, SDC particles presented the lowest degradation of total carotenoids (∼5%), while SD samples showed the highest loss (∼21%). Yet, the latter had the lowest contents of conjugated dienes (4.1-5.3 µmol/g) among treatments. At the end of simulated digestion, PO and the microparticles provided low ß-carotene bioaccessibility (<10%), and only SC increased this parameter compared to the pure oil. In conclusion, carotenoid-rich microparticles with attractive color were obtained through microencapsulation of PO by SD, SC and SDC, revealing their potential as natural additives for the development of food products with improved nutritional properties. The SC method stood out for providing microparticles with high carotenoid content and retention, high oxidative stability, and improved ß-carotene bioaccessibility.

Bioaccessibility of minerals in combinations of biofortified foods with Fe, Zn and vitamin A.

Initiatives to improve the nutritional quality of staple foods, such as beans and cassava by bio fortification should be encouraged as an alternative to overcome the deficiencies of iron and vitamin A. The evaluation of the bio accessibility of the minerals in these foods is also important, since the composition of nutrients does not necessarily correspond to the amount absorbed and metabolized in the body. Thus, the present work aims to evaluate the bio accessibility of iron (Fe) and zinc (Zn) in the presence of ß-carotene in combinations of bio fortified food sources of Fe and Zn (cowpea cooked with and without maceration: CM/CW, respectively) and ß-carotene (cooked cassava and cassava flour: CC/CF, respectively). The mixtures, after cooking, were analyzed for the centesimal composition and minerals, phytates, the percentage of iron and zinc bio accessibility by in vitro method and molar ratio. The mixtures presented significant amounts of proteins, carbohydrates and fibers. The ß-carotene content showed no statistical difference in processing methods. The Fe content showed lower levels in the controls with cassava flour and its bio accessibility was also lower for treatment with cassava flour with CM, while for Zn or higher content it was used for treatment CW/CF, differing only from the treatment CW/CC, although their bio accessibilities were not different, except to iron in CMCC treatment. Both the IP6 fraction and the IP5 fraction did not show a significant difference (p > 0.05) between the treatments, it suggests no interference in bio accessibility. A diet rich in iron and vitamin A in adequate amounts with minimal content of absorption inhibitors can be effective in controlling iron deficiency. Bio fortified mixtures must be encouraged in different forms of consumption.