Inducible Synthetic Growth Regulation Using the ClpXP Proteasome Enhances cis,cis-Muconic Acid and Glycolic Acid Yields in Saccharomyces cerevisiae.

Engineered microbial cells can produce sustainable chemistry, but the production competes for resources with growth. Inducible synthetic control over the resource use would enable fast accumulation of sufficient biomass and then divert the resources to production. We developed inducible synthetic resource-use control overSaccharomyces cerevisiae by expressing a bacterial ClpXP proteasome from an inducible promoter. By individually targeting growth-essential metabolic enzymes Aro1, Hom3, and Acc1 to the ClpXP proteasome, cell growth could be efficiently repressed during cultivation. The ClpXP proteasome was specific to the target proteins, and there was no reduction in the targets when ClpXP was not induced. The inducible growth repression improved product yields from glucose (cis,cis-muconic acid) and per biomass (cis,cis-muconic acid and glycolic acid). The inducible ClpXP proteasome tackles uncertainties in strain optimization by enabling model-guided repression of competing, growth-essential, and metabolic enzymes. Most importantly, it allows improving production without compromising biomass accumulation when uninduced; therefore, it is expected to mitigate strain stability and low productivity challenges.

Use of ambr®250 to assess mucic acid production in fed-batch cultures of a marine Trichoderma sp. D-221704.

Mucic acid, a diacid with potential use in the food, cosmetic, chemical and pharmaceutical industries, can be produced by microbial conversion of D-galacturonic acid, which is abundant in pectin. Using the ambr®250 bioreactor system, we found that a recently generated transformant (D-221704, formerly referred to as T2) of a marine Trichoderma species produced up to 53 g L-1 mucic acid in glucose-limited fed-batch culture with D-galacturonic acid in the feed at pH 4, with a yield of 0.99 g mucic acid per g D-galacturonic acid consumed. Yeast extract was not essential for high production, but increased the initial production rate. Reducing the amount of glucose as the co-substrate reduced the amount of mucic acid produced to 31 g L-1. Mucic acid could also be produced at pH values less than 4.0 (3.5 and 3.0), but the amount produced was less than at pH 4.0. Furthermore, the yield of mucic acid on D-galacturonic acid at the end of the cultivations (0.5 to 0.7 g g-1) at these low pH levels suggested that recovery may be more difficult at lower pH on account of the high level of crystal formation. Another strain engineered to produce mucic acid, Trichoderma reesei D-161646, produced only 31 g L-1 mucic acid under the conditions used with D-221704.

Lager Yeast Design Through Meiotic Segregation of a Saccharomyces cerevisiae × Saccharomyces eubayanus Hybrid.

Yeasts in the lager brewing group are closely related and consequently do not exhibit significant genetic variability. Here, an artificial Saccharomyces cerevisiae × Saccharomyces eubayanus tetraploid interspecies hybrid was created by rare mating, and its ability to sporulate and produce viable gametes was exploited to generate phenotypic diversity. Four spore clones obtained from a single ascus were isolated, and their brewing-relevant phenotypes were assessed. These F1 spore clones were found to differ with respect to fermentation performance under lager brewing conditions (15°C, 15 °Plato), production of volatile aroma compounds, flocculation potential and temperature tolerance. One spore clone, selected for its rapid fermentation and acetate ester production was sporulated to produce an F2 generation, again comprised of four spore clones from a single ascus. Again, phenotypic diversity was introduced. In two of these F2 clones, the fermentation performance was maintained and acetate ester production was improved relative to the F1 parent and the original hybrid strain. Strains also performed well in comparison to a commercial lager yeast strain. Spore clones varied in ploidy and chromosome copy numbers, and faster wort fermentation was observed in strains with a higher ploidy. An F2 spore clone was also subjected to 10 consecutive wort fermentations, and single cells were isolated from the resulting yeast slurry. These isolates also exhibited variable fermentation performance and chromosome copy numbers, highlighting the instability of polyploid interspecific hybrids. These results demonstrate the value of this natural approach to increase the phenotypic diversity of lager brewing yeast strains.

Engineering marine fungi for conversion of D-galacturonic acid to mucic acid.

BACKGROUND: Two marine fungi, a Trichoderma sp. and a Coniochaeta sp., which can grow on D-galacturonic acid and pectin, were selected as hosts to engineer for mucic acid production, assessing the suitability of marine fungi for production of platform chemicals. The pathway for biotechnologcial production of mucic (galactaric) acid from D-galacturonic acid is simple and requires minimal modification of the genome, optimally one deletion and one insertion. D-Galacturonic acid, the main component of pectin, is a potential substrate for bioconversion, since pectin-rich waste is abundant. RESULTS: Trichoderma sp. LF328 and Coniochaeta sp. MF729 were engineered using CRISPR-Cas9 to oxidize D-galacturonic acid to mucic acid, disrupting the endogenous pathway for D-galacturonic acid catabolism when inserting a gene encoding bacterial uronate dehydrogenase. The uronate dehydrogenase was expressed under control of a synthetic expression system, which fucntioned in both marine strains. The marine Trichoderma transformants produced 25 g L-1 mucic acid from D-galacturonic acid in equimolar amounts: the yield was 1.0 to 1.1 g mucic acid [g D-galacturonic acid utilized]-1. D-Xylose and lactose were the preferred co-substrates. The engineered marine Trichoderma sp. was more productive than the best Trichoderma reesei strain (D-161646) described in the literature to date, that had been engineered to produce mucic acid. With marine Coniochaeta transformants, D-glucose was the preferred co-substrate, but the highest yield was 0.82 g g-1: a portion of D-galacturonic acid was still metabolized. Coniochaeta sp. transformants produced adequate pectinases to produce mucic acid from pectin, but Trichoderma sp. transformants did not. CONCLUSIONS: Both marine species were successfully engineered using CRISPR-Cas9 and the synthetic expression system was functional in both species. Although Coniochaeta sp. transformants produced mucic acid directly from pectin, the metabolism of D-galacturonic acid was not completely disrupted and mucic acid amounts were low. The D-galacturonic pathway was completely disrupted in the transformants of the marine Trichoderma sp., which produced more mucic acid than a previously constructed T. reesei mucic acid producing strain, when grown under similar conditions. This demonstrated that marine fungi may be useful as production organisms, not only for native enzymes or bioactive compounds, but also for other compounds.

Diacetyl control during brewery fermentation via adaptive laboratory engineering of the lager yeast Saccharomyces pastorianus.

Diacetyl contributes to the flavor profile of many fermented products. Its typical buttery flavor is considered as an off flavor in lager-style beers, and its removal has a major impact on time and energy expenditure in breweries. Here, we investigated the possibility of lowering beer diacetyl levels through evolutionary engineering of lager yeast for altered synthesis of α-acetolactate, the precursor of diacetyl. Cells were exposed repeatedly to a sub-lethal level of chlorsulfuron, which inhibits the acetohydroxy acid synthase responsible for α-acetolactate production. Initial screening of 7 adapted isolates showed a lower level of diacetyl during wort fermentation and no apparent negative influence on fermentation rate or alcohol yield. Pilot-scale fermentation was carried out with one isolate and results confirmed the positive effect of chlorsulfuron adaptation. Diacetyl levels were over 60% lower at the end of primary fermentation relative to the non-adapted lager yeast and no significant change in fermentation performance or volatile flavor profile was observed due to the adaptation. Whole-genome sequencing revealed a non-synonymous SNP in the ILV2 gene of the adapted isolate. This mutation is known to confer general tolerance to sulfonylurea compounds, and is the most likely cause of the improved tolerance. Adaptive laboratory evolution appears to be a natural, simple and cost-effective strategy for diacetyl control in brewing.

Trans-regulation and localization of orthologous maltose transporters in the interspecies lager yeast hybrid.

In the interspecies lager yeast hybrid there are MAL loci involved in maltose and maltotriose utilization derived from each parent (Saccharomyces cerevisiae and Saccharomyces eubayanus). We show that trans-regulation across hybrid subgenomes occurs for MAL genes. However, gene expression is less efficient with non-native activators (trans-activation) compared to native activators (cis-activation). MAL genes were induced by maltose and repressed by glucose irrespective of host. Despite the strong expression of S. cerevisiae-type genes in the S. eubayanus host, a very low amount of transporter protein was actually observed in cells. This suggests that proper formation and configuration of the S. cerevisiae transporters is not efficient in S. eubayanus. The S. eubayanus-type Malx1 transporter was present in the plasma membrane in high amounts in all hosts (S. cerevisiae, S. eubayanus and Saccharomyces pastorianus) at all times. However, the S. cerevisiae-type transporters appeared sequentially in the plasma membrane; scMalx1 was localized in the plasma membrane during early to late linear growth and subsequently withdrawn to intracellular compartments. In contrast, the scAgt1 transporter was found in the plasma membrane mainly in the stationary phase of growth. Different localization patterns may explain why certain transporter orthologues in natural S. pastorianus strains were lost to mutation.

Overexpressed maltose transporters in laboratory and lager yeasts: Localization and competition with endogenous transporters.

Plain and fluorescently tagged versions of Agt1, Mtt1 and Malx1 maltose transporters were overexpressed in two laboratory yeasts and one lager yeast. The plain and tagged versions of each transporter supported similar transport activities, indicating that they are similarly trafficked and have similar catalytic activities. When they were expressed under the control of the strong constitutive PGK1 promoter only minor proportions of the fluorescent transporters were associated with the plasma membrane, the rest being found in intracellular structures. Transport activity of each tagged transporter in each host was roughly proportional to the plasma membrane-associated fluorescence. All three transporters were subject to glucose-triggered inactivation when the medium glucose concentration was abruptly raised. Results also suggest competition between endogenous and overexpressed transporters for access to the plasma membrane.

Improved cider fermentation performance and quality with newly generated Saccharomyces cerevisiae × Saccharomyces eubayanus hybrids.

Yeast cryotolerance may be advantageous for cider making, where low temperatures are usually employed. Here, we crossed the cryotolerant S. eubayanus with a S. cerevisiae wine strain and assessed the suitability of the hybrids for low-temperature cider fermentation. All strains fermented the juice to 5% ABV, but at different rates; hybrid strains outperformed S. cerevisiae, which was sensitive to low temperatures. The best hybrid fermented similarly to S. eubayanus. S. eubayanus produced sulphurous off flavours which masked a high concentration of fruity ester notes. This phenotype was absent in the hybrid strains, resulting in distinctly fruitier ciders. Aroma was assessed by an independent consumer panel, which rated the hybrid ciders as identical to the wine strain cider. Both were significantly more pleasant than the S. eubayanus cider. Interspecific hybridization can apparently be used effectively to improve low-temperature fermentation performance without compromising product quality.

Novel brewing yeast hybrids: creation and application.

The natural interspecies Saccharomyces cerevisiae × Saccharomyces eubayanus hybrid yeast is responsible for global lager beer production and is one of the most important industrial microorganisms. Its success in the lager brewing environment is due to a combination of traits not commonly found in pure yeast species, principally low-temperature tolerance, and maltotriose utilization. Parental transgression is typical of hybrid organisms and has been exploited previously for, e.g., the production of wine yeast with beneficial properties. The parental strain S. eubayanus has only been discovered recently and newly created lager yeast strains have not yet been applied industrially. A number of reports attest to the feasibility of this approach and artificially created hybrids are likely to have a significant impact on the future of lager brewing. De novo S. cerevisiae × S. eubayanus hybrids outperform their parent strains in a number of respects, including, but not restricted to, fermentation rate, sugar utilization, stress tolerance, and aroma formation. Hybrid genome function and stability, as well as different techniques for generating hybrids and their relative merits are discussed. Hybridization not only offers the possibility of generating novel non-GM brewing yeast strains with unique properties, but is expected to aid in unraveling the complex evolutionary history of industrial lager yeast.

Maltose and maltotriose utilisation by group I strains of the hybrid lager yeast Saccharomyces pastorianus.

Brewer's wort is a challenging environment for yeast as it contains predominantly α-glucoside sugars. There exist two subgroups of the lager yeast Saccharomyces pastorianus which differ in sugar utilisation. We performed wort fermentations and compared representative strains from both groups with respect to their ability to transport and ferment maltose and maltotriose. Additionally, we mapped the transporters MALx1, AGT1, MPHx and MTT1 by Southern blotting. Contrary to previous observations, group I comprises a diverse set of strains, with varying ability to transport and ferment maltotriose. Of the eight group I strains, three efficiently utilised maltotriose, a property enabled by the presence of transmembrane transporters SeAGT1 and MTT1 A58, a variant of the group I type strain (CBS1513) performed particularly well, taking up maltotriose at a higher rate than maltose and retaining significant transport activity at temperatures as low as 0°C. Analysis of transporter distribution in this strain revealed an increased copy number of the MTT1 gene, which encodes the only permease known with higher affinity for maltotriose than maltose and low temperature dependence for transport. We propose that much of the variation in lager yeast fermentation behaviour is determined by the presence or absence of specific transmembrane transporters.

Ploidy influences the functional attributes of de novo lager yeast hybrids.

The genomes of hybrid organisms, such as lager yeast (Saccharomyces cerevisiae × Saccharomyces eubayanus), contain orthologous genes, the functionality and effect of which may differ depending on their origin and copy number. How the parental subgenomes in lager yeast contribute to important phenotypic traits such as fermentation performance, aroma production, and stress tolerance remains poorly understood. Here, three de novo lager yeast hybrids with different ploidy levels (allodiploid, allotriploid, and allotetraploid) were generated through hybridization techniques without genetic modification. The hybrids were characterized in fermentations of both high gravity wort (15 °P) and very high gravity wort (25 °P), which were monitored for aroma compound and sugar concentrations. The hybrid strains with higher DNA content performed better during fermentation and produced higher concentrations of flavor-active esters in both worts. The hybrid strains also outperformed both the parent strains. Genome sequencing revealed that several genes related to the formation of flavor-active esters (ATF1, ATF2¸ EHT1, EEB1, and BAT1) were present in higher copy numbers in the higher ploidy hybrid strains. A direct relationship between gene copy number and transcript level was also observed. The measured ester concentrations and transcript levels also suggest that the functionality of the S. cerevisiae- and S. eubayanus-derived gene products differs. The results contribute to our understanding of the complex molecular mechanisms that determine phenotypes in lager yeast hybrids and are expected to facilitate targeted strain development through interspecific hybridization.

Novel transporters from Kluyveromyces marxianus and Pichia guilliermondii expressed in Saccharomyces cerevisiae enable growth on L-arabinose and D-xylose.

Genes encoding L-arabinose transporters in Kluyveromyces marxianus and Pichia guilliermondii were identified by functional complementation of Saccharomyces cerevisiae whose growth on L-arabinose was dependent on a functioning L-arabinose transporter, or by screening a differential display library, respectively. These transporters also transport D-xylose and were designated KmAXT1 (arabinose-xylose transporter) and PgAXT1, respectively. Transport assays using L-arabinose showed that KmAxt1p has K(m) 263 mM and V(max) 57 nM/mg/min, and PgAxt1p has K(m) 0.13 mM and V(max) 18 nM/mg/min. Glucose, galactose and xylose significantly inhibit L-arabinose transport by both transporters. Transport assays using D-xylose showed that KmAxt1p has K(m) 27 mM and V(max) 3.8 nM/mg/min, and PgAxt1p has K(m) 65 mM and V(max) 8.7 nM/mg/min. Neither transporter is capable of recovering growth on glucose or galactose in a S. cerevisiae strain deleted for hexose and galactose transporters. Transport kinetics of S. cerevisiae Gal2p showed K(m) 371 mM and V(max) 341 nM/mg/min for L-arabinose, and K(m) 25 mM and V(max) 76 nM/mg/min for galactose. Due to the ability of Gal2p and these two newly characterized transporters to transport both L-arabinose and D-xylose, one scenario for the complete usage of biomass-derived pentose sugars would require only the low-affinity, high-throughput transporter Gal2p and one additional high-affinity general pentose transporter, rather than dedicated D-xylose or L-arabinose transporters. Additionally, alignment of these transporters with other characterized pentose transporters provides potential targets for substrate recognition engineering.

New lager yeast strains generated by interspecific hybridization.

The interspecific hybrid Saccharomyces pastorianus is the most commonly used yeast in brewery fermentations worldwide. Here, we generated de novo lager yeast hybrids by mating a domesticated and strongly flocculent Saccharomyces cerevisiae ale strain with the Saccharomyces eubayanus type strain. The hybrids were characterized with respect to the parent strains in a wort fermentation performed at temperatures typical for lager brewing (12 °C). The resulting beers were analysed for sugar and aroma compounds, while the yeasts were tested for their flocculation ability and α-glucoside transport capability. These hybrids inherited beneficial properties from both parent strains (cryotolerance, maltotriose utilization and strong flocculation) and showed apparent hybrid vigour, fermenting faster and producing beer with higher alcohol content (5.6 vs 4.5 % ABV) than the parents. Results suggest that interspecific hybridization is suitable for production of novel non-GM lager yeast strains with unique properties and will help in elucidating the evolutionary history of industrial lager yeast.

Variation in α-acetolactate production within the hybrid lager yeast group Saccharomyces pastorianus and affirmation of the central role of the ILV6 gene.

A screen of 14 S. pastorianus lager-brewing strains showed as much as a nine-fold difference in wort total diacetyl concentration at equivalent stages of fermentation of 15°Plato brewer's wort. Two strains (A153 and W34), with relatively low and high diacetyl production, respectively, but which did not otherwise differ in fermentation performance, growth or flavour production, were selected for further investigation. Transcriptional analysis of key genes involved in valine biosynthesis showed differences between the two strains that were consistent with the differences in wort diacetyl concentration. In particular, the ILV6 gene, encoding a regulatory subunit of acetohydroxy acid synthase, showed early transcription (only 6 h after inoculation) and up to five-fold greater expression in W34 compared to A153. This earlier transcription was observed for both orthologues of ILV6 in the S. pastorianus hybrid (S. cerevisiae × S. eubayanus), although the S. cerevisiae form of ILV6 in W34 also showed a consistently higher transcript level throughout fermentation relative to the same gene in A153. Overexpression of either form of ILV6 (by placing it under the control of the PGK1 promoter) resulted in an identical two-fold increase in wort total diacetyl concentration relative to a control. The results confirm the role of the Ilv6 subunit in controlling α-acetolactate/diacetyl concentration and indicate no functional divergence between the two forms of Ilv6. The greater contribution of the S. cerevisiae ILV6 to acetolactate production in natural brewing yeast hybrids appears rather to be due to higher levels of transcription relative to the S. eubayanus form.

Three Agt1 transporters from brewer's yeasts exhibit different temperature dependencies for maltose transport over the range of brewery temperatures (0­20 °C).

Zero-trans rates of maltose transport by brewer's yeasts exert strong control over fermentation rates and are strongly temperature-dependent over the temperature range (20­0 °C) of brewery fermentations. Three α-glucoside transporters, ScAgt1(A60) (a Saccharomyces cerevisiae version of Agt1 from an ale strain), ScAgt1-A548V (a variant of ScAgt1(A60) with a single amino acid change in a transmembrane domain), and SbAgt1 (a Saccharomyces (eu)bayanus version from a lager strain), were compared. When expressed in the same laboratory yeast, grown at 24 °C and assayed at 0, 10, and 20 °C, SbAgt1 had the lowest absolute maltose uptake activity at 20 °C but smallest temperature dependence, ScAgt1-A548V had the highest activity but greatest temperature dependence, and ScAgt1(A60) had intermediate properties. ScAgt1(A60) exhibited higher absolute rates and smaller temperature dependencies when expressed in laboratory rather than brewer's strains. Absolute rates closely reflected the amounts of GFP-tagged ScAgt1(A60) transporter in each host's plasma membrane. Growth at 15 °C instead of 24 °C decreased the absolute activities of strains expressing ScAgt1(A60) by two- to threefold. Evidently, the kinetic characteristics of at least ScAgt1(A60) depended on the nature of the host plasma membrane. However, no consistent correlation was observed between transport activities and fatty acid or ergosterol compositions.

Comparative physiology and fermentation performance of Saaz and Frohberg lager yeast strains and the parental species Saccharomyces eubayanus.

Two distinct genetic groups (Saaz and Frohberg) exist within the hybrid Saccharomyces pastorianus (S. cerevisiae × S. eubayanus) taxon. However, physiological/technological differences that exist between the two groups are not known. Fermentative capability of the parental S. eubayanus has likewise never been studied. Here, 58 lager strains were screened to determine which hybrid group they belonged to, and selected strains were characterized to determine salient characteristics. In 15 °P all-malt wort fermentations at 22 °C, Frohberg strains showed greater growth and superior fermentation (80% apparent attenuation, 6.5% alcohol by volume in 3-4 days) compared to all other strains and maintained highest viability values (>93%). Fermentation with S. eubayanus was poor at the same temperature (33% apparent attenuation, 2.7% alcohol by volume at 6 days and viability reduced to 75%). Saaz strains and S. eubayanus were the least sensitive to cold (10 °C), though this did not translate to greater fermentation performance. Fermentation with S. eubayanus was poor at 10 °C but equal to or greater than that of the Saaz strains. Performance of Saaz yeast/S. eubayanus was limited by an inability to use wort maltotriose. [(14)C]-Maltotriose transport assays also showed negligible activity in these strains (≤0.5 µmol min(-1) g(-1) dry yeast). Beers from Saaz fermentations were characterized by two- to sixfold lower production of the flavour compounds methyl butanol, ethyl acetate and 3-methylbutyl acetate compared to Frohberg strains. Higher alcohol and ester production by S. eubayanus was similar to that of Frohberg strains.

Adaptive evolution of the lager brewing yeast Saccharomyces pastorianus for improved growth under hyperosmotic conditions and its influence on fermentation performance.

An adaptive evolution method to obtain stable Saccharomyces pastorianus brewing yeast variants with improved fermentation capacity is described. The procedure involved selection for rapid growth resumption at high osmotic strength. It was applied to a lager strain and to a previously isolated ethanol-tolerant strain. Fermentation performance of strains was compared at 15 °P wort strength. A selected osmotolerant variant of the ethanol-tolerant strain showed significantly shorter fermentation time than the parent strain, producing 6.45% alcohol by volume beer in 4-5 days with mostly similar organoleptic properties to the original strain. Diacetyl and pentanedione contents were 50-75% and 3-methylbutyl acetate and 2-phenylethyl acetate 50% higher than with the original strain, leading to a small flavour change. The variant contained significantly less intracellular trehalose and glycogen than the parent. Transcriptional analysis of selected genes at 24 h revealed reduced transcription of hexose transport genes and increased transcription of the MALx1 and MALx2 genes, responsible for α-glucoside uptake and metabolism. It is suggested that an attenuated stress response contributes to the improved fermentation performance. Results show that sequential selection for both ethanol tolerance and rapid growth at high osmotic strength can provide strains with enhanced fermentation speed with acceptable product quality.

Identification of regulatory elements in the AGT1 promoter of ale and lager strains of brewer's yeast.

Agt1 is an interesting α-glucoside transporter for the brewing industry, as it efficiently transports maltotriose, a sugar often remaining partly unused during beer fermentation. It has been shown that on maltose the expression level of AGT1 is much higher in ale strains than in lager strains, and that glucose represses the expression, particularly in the ale strains. In the present study the regulatory elements of the AGT1 promoter of one ale and two lager strains were identified by computational methods. Promoter regions up to 1.9 kbp upstream of the AGT1 gene were sequenced from the three brewer's yeast strains and the laboratory yeast strain CEN.PK-1D. The promoter sequence of the laboratory strain was identical to the AGT1 promoter of strain S288c of the Saccharomyces Genome Database, whereas the promoter sequences of the industrial strains diverged markedly from the S288c strain. The AGT1 promoter regions of the ale and lager strains were for the most part identical to each other, except for one 22 bp deletion and two 94 and 95 bp insertions in the ale strain. Computational analyses of promoter elements revealed that the promoter sequences contained several Mig1- and MAL-activator binding sites, as was expected. However, some of the Mig1 and MAL-activator binding sites were located on the two insertions of the ale strain, and thus offered a plausible explanation for the different expression pattern of the AGT1 gene in the ale strains. Accordingly, functional analysis of A60 ale and A15 lager strain AGT1 promoters fused to GFP (encoding the green fluorescent protein) showed a significant difference in the ability of these two promoters to drive GFP expression. Under the control of the AGT1 promoter of the ale strain the emergence of GFP was strongly induced by maltose, whereas only a low level of GFP was detected with the construct carrying the AGT1 promoter of the lager strain. Thus, the extra MAL-activator binding element, present in the AGT1 promoter of the ale strain, appears to be necessary to reach a high level of induction by maltose. Both AGT1 promoters were repressed by glucose but their derepression was different, possibly due to a distinct distribution of Mig1 elements in these two promoters.

The temperature dependence of maltose transport in ale and lager strains of brewer's yeast.

Lager beers are traditionally made at lower temperatures (6-14 degrees C) than ales (15-25 degrees C). At low temperatures, lager strains (Saccharomyces pastorianus) ferment faster than ale strains (Saccharomyces cerevisiae). Two lager and two ale strains had similar maltose transport activities at 20 degrees C, but at 0 degrees C the lager strains had fivefold greater activity. AGT1, MTT1 and MALx1 are major maltose transporter genes. In nine tested lager strains, the AGT1 genes contained premature stop codons. None of five tested ale strains had this defect. All tested lager strains, but no ale strain, contained MTT1 genes. When functional AGT1 from an ale strain was expressed in a lager strain, the resultant maltose transport activity had the high temperature dependence characteristic of ale yeasts. Lager yeast MTT1 and MALx1 genes were expressed in a maltose-negative laboratory strain of S. cerevisiae. The resultant Mtt1 transport activity had low temperature dependence and the Malx1 activity had high temperature dependence. Faster fermentation at low temperature by lager strains than ale strains may result from their different maltose transporters. The loss of Agt1 transporters during the evolution of lager strains may have provided plasma membrane space for the Mtt1 transporters that perform better at a low temperature.

Selection from industrial lager yeast strains of variants with improved fermentation performance in very-high-gravity worts.

There are economic and other advantages if the fermentable sugar concentration in industrial brewery fermentations can be increased from that of currently used high-gravity (ca. 14 to 17 degrees P [degrees Plato]) worts into the very-high-gravity (VHG; 18 to 25 degrees P) range. Many industrial strains of brewer's yeast perform poorly in VHG worts, exhibiting decreased growth, slow and incomplete fermentations, and low viability of the yeast cropped for recycling into subsequent fermentations. A new and efficient method for selecting variant cells with improved performance in VHG worts is described. In this new method, mutagenized industrial yeast was put through a VHG wort fermentation and then incubated anaerobically in the resulting beer while maintaining the alpha-glucoside concentration at about 10 to 20 g.liter(-1) by slowly feeding the yeast maltose or maltotriose until most of the cells had died. When survival rates fell to 1 to 10 cells per 10(6) original cells, a high proportion (up to 30%) of survivors fermented VHG worts 10 to 30% faster and more completely (residual sugars lower by 2 to 8 g.liter(-1)) than the parent strains, but the sedimentation behavior and profiles of yeast-derived flavor compounds of the survivors were similar to those of the parent strains.