Improvement of the drying quality of blueberries by catalytic infrared blanching combined with ultrasound pretreatment.

This paper investigated the effect of catalytic infrared blanching combined with ultrasound pretreatment on quality and waxy structure of blueberries. Different blueberry samples were prepared, including control (untreated) and samples treated by hot water blanching (HB), catalytic infrared blanching (CIB), ultrasound-catalytic infrared blanching (US-CIB), and catalytic infrared blanching-ultrasound (CIB-US). The effect of different pretreatments on the microstructure of blueberry epidermis was studied. The drying time of blueberries after HB, US-CIB, and CIB-US was decreased by 11.61%, 17.54%, and 17.27%, respectively, compared with control (33.75 h), and drying efficiency was significantly improved. Blueberries after pretreatments had higher content of polyphenol and anthocyanin, with an increase of 29.51-44.21% in phenol and 8.81-20.80% in anthocyanin, the antioxidant capacity of blueberries was also better than control and CIB enhanced the antioxidant capacity of blueberries. CIB-US can be used as an efficient pretreatment method for blueberry drying.

The Effect of Germination and Fermentation on the Physicochemical, Nutritional, and Functional Quality Attributes of Samh Seeds.

This study investigated the effects of fermentation and germination on the physicochemical, nutritional, functional, and bioactive quality attributes of samh seeds. Regardless of the processing treatment, samh seeds were found to be a rich source of phenolic compounds, namely gallic acid (79.6-96.36 mg/100 g DW), catechol (56.34-77.34 mg/100 g DW), and catechin (49.15-84.93 mg/100 g DW), and they possessed high DPPH antiradical activity (65.27-78.39%). They also contained high protein content (19.29-20.41%), essential amino acids content (39.07-44.16% of total amino acids), and unsaturated fatty acid content (81.95-83.46% of total fatty acids) and a low glycemic index (39.61-41.43). Fermentation and germination increased L*, b*, foaming capacity, oil absorption capacity (OAC), water absorption capacity (WAC), swelling power, microbial counts, antioxidant activity, total flavonoid content (TFC), total phenolic content (TPC), in vitro protein digestibility, protein efficiency ratio, and total essential amino acids and reduced water solubility, emulsion stability, tannin, and phytate contents compared to raw samh seeds (p < 0.05). The highest levels of pH, ash, carbohydrate, fiber, and glycemic index were observed in raw samh seeds, and both germination and fermentation processes reduced these attributes to various degrees (p < 0.05). Germination increased the redness (a*), moisture content, essential and non-essential amino acids, potassium, zinc, phosphorous, stearic acid, and oleic and unsaturated fatty acids and reduced total solids, fat content, iron, zinc, calcium, magnesium, sodium, palmitic acid, and total saturated fatty acids of the samh seeds compared to the raw ones. Fermentation increased the total solid, acidity, fat, protein, calcium, magnesium, sodium, phosphorous, iron, zinc, palmitic acid, and total saturated fatty acids and reduced the a* value, moisture, non-essential amino acids, and total unsaturated fatty acids of the samh seeds compared to the raw ones. In conclusion, samh seeds are a rich source of nutrients that could generally be enhanced by germination and fermentation processes. The reported information facilitates strategies towards the application of these underutilized seeds in foods.

Ultrasound, infrared and its assisted technology, a promising tool in physical food processing: A review of recent developments.

Traditional food processing techniques can no longer meet the ever increasing demand for high quality food across the globe due to its low process efficiency, high energy consumption and low product yield. This review article is focused on the mechanism and application of Infrared (IR) and ultrasound (US) technologies in physical processing of food. We herein present the individual use of IR and US (both mono-frequency and multi-frequency levels) as well as IR and US supported with other thermal and non-thermal technologies to improve their food processing performance. IR and US are recent thermal and non-thermal technologies which have now been successfully used in food industries to solve the demerits of conventional processing technologies. These environmentally-friendly technologies are characterized by low energy consumption, reduced processing time, high mass-transfer rates, better nutrient retention, better product quality, less mechanical damage and improved shelf life. This work could be, with no doubt, useful to the scientific world and food industries by providing insights on recent advances in the use of US and IR technology, which can be applied to improve food processing technologies for better quality and safer products.

Effect of dialysate type on ultrasound-assisted self-assembly Zein nanocomplexes: Fabrication, characterization, and physicochemical stability.

This study aims to investigate the effect of the dialysate type on the properties of nanocomplexes. Nanocomplexes of zein-sodium caseinate-curcumin (ZNC) and zein-gum arabic-curcumin (Z-G-C) were prepared by ultrasound-assisted dialysis using salt solutions of different concentrations (Na+ and Ca2+; 2 - 10 mM). With increasing Na+ concentration, the overall particle size of ZNC and Z-G-C decreased first and then increased. The Ca2+ concentration did not affect the particle size of ZNC and Z-G-C, with good storage stability. The encapsulation efficiency of ZNC decreased significantly from 72.3 ±â€¯6.2 % to 59.8 ±â€¯8.6 % with increasing Na+ concentration, while that of Z-G-C increased first and then decreased. The encapsulation efficiency of Ca2+ treated ZNC nanoparticles was higher than that of Na+ induced nanoparticles. Ca2+ did not affect the encapsulation efficiency of Z-G-C nanoparticles. Fluorescence spectroscopy analyses, CD, FTIR, and XRD showed Na + and Ca2+ dialysis modified the secondary structure of ZNC and Z-G-C through adding hydrogen bonding and electrostatic interactions. Na+ and Ca2+ improved the thermal stability of Z-G-C and reduced the thermal stability of ZNC. After encapsulating curcumin, the crystallinity of ZNC and Z-G-C induced by Na+ and Ca2+ decreased to 45.9 % - 63.9 %, and the amorphous area increased. The above results indicated that Ca2+ dialysis could increase the encapsulation efficiency and thermal stability of the nanoparticles, and improve the loading characteristics of zein nanoparticles. The Z-G-C nanoparticles induced by Na+ and Ca2+ showed better thermal and storage stability.

Liquorice root extract and isoliquiritigenin attenuate high-fat diet-induced hepatic steatosis and damage in rats by regulating AMPK.

Objective: This study compared the ability of Liquorice roots aqueous extract (LRE) and its ingredient, isoliquiritigenin (ISL), in alleviating high-fat diet (HFD)-induced hepatic steatosis and examined if this effect involves activation of AMPK.Materials and methods: Control or HFD-fed rats were treated with the vehicle, LRE (200 mg/kg), or ISL (30 mg/kg) for 8 weeks orally.Results: ISL and LRE reduced HFD-induced hyperglycaemia, improved liver structure, lowered serum and hepatic lipids, and attenuated hepatic oxidative stress and inflammation. In the control and HFD-fed rats, ISL and LRE significantly stimulated the muscular and hepatic mRNA and protein levels of AMPK, improved oral glucose tolerance, reduced hepatic mRNA levels of SREBP1/2, and upregulated hepatic levels of PPARα and Bcl2. These effects were comparable for ISL and LRE and were prevented by co-administration of compound C, an AMPK inhibitor.Discussion and conclusion: ISL and LRE provide an effective theory to alleviate hepatic steatosis through activating AMPK.

Ultrasound-assisted probiotics fermentation suspension treatment under mild heat to improve the storage quality of freshly cut lotus root.

Ultrasound-assisted probiotic fermentation suspension treatment under mild heat was applied to freshly cut lotus root. Combined treatment significantly (p < 0.05) improved the bactericidal effect: S. aureus, E. coli O157:H7, A. flavus spores, and yeast were completely killed at 55℃ for 6 min, morphological and structural changes of cells were observed. Combined treatment inhibited enzymatic browning via decreasing the activities of PPO, POD, PAL, and decreasing TPC, soluble quinone content. The decrease of external resistance, capacitance and the increase of internal resistance reflected the loss of structural integrity of cells after combined treatment. For combined treatment samples, no obvious color change was observed during 12 days of storage but weight loss rate, total acid increased significantly (p < 0.05) and hardness decreased, the shelf life was extended to 12 d. Ultrasound-assisted probiotic fermentation suspension treatment under mild heat had the dual effects of sterilization and inhibition of browning.

Camel milk protein hydrosylate alleviates hepatic steatosis and hypertension in high fructose-fed rats.

CONTEXT: Camel milk is used in traditional medicine to treat diabetes mellitus hypertension and other metabolic disorders. OBJECTIVE: This study evaluated the antisteatotic and antihypertensive effects of camel milk protein hydrolysate (CMH) in high fructose (HF)-fed rats and compared it with the effects afforded by the intact camel milk protein extract (ICM). MATERIALS AND METHODS: Adult male Wistar rats were divided into 6 groups (n = 8 each) as 1) control, 2) ICM (1000 mg/kg), 3) CMH (1000 mg/kg), 4) HF (15% in drinking water), 5) HF (15%) + ICM (1000 mg/kg), and 6) HF (15%) + CMH (1000 mg/kg). All treatments were given orally for 21 weeks, daily. RESULTS: Both ICM and CMH reduced fasting glucose and insulin levels, serum and hepatic levels of cholesterol and triglycerides, and serum levels of ALT and AST, angiotensin II, ACE, endothelin-1, and uric acid in HF-fed rats. In addition, both ICM and CMH reduced hepatic fat deposition in the hepatocytes and reduced hepatocyte damage. This was associated with an increase in the hepatic activity of AMPK, higher PPARα mRNA, reduced expression of fructokinase C, SREBP1, SREBP2, fatty acid synthase, and HMG-CoA-reductase. Both treatments lowered systolic and diastolic blood pressure. However, the effects of CMH on all these parameters were greater as compared to ICM. DISCUSSION AND CONCLUSIONS: The findings of this study encourage the use of CMH in a large-scale population and clinical studies to treat metabolic steatosis and hypertension.

Effect of molecular weight of chitosan on the formation and properties of zein-nisin-chitosan nanocomplexes.

This study evaluated the effect of molecular weight of chitosan (3 kDa,150 kDa, 400 kDa, and 600 kDa) on zein-nisin-chitosan nanocomplexes. The formation mechanism, physicochemical and antibacterial properties of the nanocomplexes (ZNC0.3, ZNC15, ZNC40, and ZNC60) were assessed. The nanocomplexes were characterized by DLS, ζ-potential, atomic force microscopy, scanning electron microscopy, circular dichroism, fourier transform infrared and UV-Vis spectroscopy. The results showed that the lowest molecular weight chitosan (LMWC, 3 kDa) formed nanocomplexes with nisin and zein structurally differed from the higher molecular weights chitosan (HMWC, >3 kDa). LMWC was doped on the surface of the nanocomplexes. HMWC linked and formed a network to adsorb zein and nisin. The antibacterial activity against Staphylococcus aureus showed that the minimum inhibitory concentration of ZNC0.3, ZNC15, ZNC40, and ZNC60 was 7.0625, 14.125, 14.125, and 28.25 µg/mL. ZNC0.3 could be a suitable nisin delivery system for its high encapsulation efficiency (85.38%) and antibacterial properties.

Anti-Hyperlipidemia, Hypoglycemic, and Hepatoprotective Impacts of Pearl Millet (Pennisetum glaucum L.) Grains and Their Ethanol Extract on Rats Fed a High-Fat Diet.

This study tested the anti-hyperlipidemic, hypoglycemic, hepatoprotective, and anti-inflammatory effects of whole pearl millet grain powder (MPG) and its ethanol extract (MPGethaolE) in obese rats fed a high-fat diet. The rats were divided into eight groups based on the treatments they received: control, high fat diet (HFD), HFD + MGE (25 mg/Kg), HFD + MPGethaolE (50 mg/Kg), HFD + MPGethaolE (100 mg/Kg), HFD + MPG (10%), HFD + MPG (20%), and HFD + MPG (30%). The final body weight, visceral, epididymal fat pads, and the liver weight were significantly decreased, in a dose-dependent manner, in HFD fed rats that were co-administered either the MPG powder or MPGethaolE. In the same line, serum levels of triglycerides (TGs), cholesterol (CHOL), and low-density lipoprotein-cholesterol (LDL-c), as well as fasting glucose, insulin, HOMA-IR, and serum levels of lipopolysaccharides (LPS), interleukine-6 (IL-6), interleukine-10 (IL-10), C-reactive protein (CRP), tumor necrosis factor (TNF-α), and adiponectin were progressively decreased while serum levels of high-density lipoproteins (HDL-c) were significantly increased when increasing the doses of both treatments. In conclusion, both the raw powder and ethanolic extract of MP have a comparative dose-dependent anti-obesity, hypoglycemic, hypolipidemic, anti-inflammatory, and anti-steatotic in HFD-fed rats.

Effect of vacuum impregnation assisted probiotics fermentation suspension on shelf life quality of freshly cut lotus root.

Probiotic fermentation suspension was used to extend the shelf life of freshly cut lotus root for the first time, which played a dual role of biological protection and quality maintenance. Fermentation suspension contained lactic acid bacteria (8-9 log CFU/mL) was prepared from juice of lotus root and used to immerse samples under atmospheric pressure and vacuum. Probiotic fermentation suspension inhibited microorganism and the activity of polyphenol oxidase (PPO), peroxidase (POD) and phenylalanine ammonia lyase (PAL), which slowed down the physiological reaction and was beneficial to maintain the color and hardness of tissues. Lactic acid bacteria antagonized other microorganisms, and metabolic acid production played a continuous role in preservation during storage. The vacuum was helpful for the fermentation suspension to be fully impregnated into samples. The probiotic fermentation suspension had a significant inhibitory effect on E.coli O157:H7, and extended lotus root shelf life from 3 to 9 days.

Role of thermal and non-thermal drying techniques on drying kinetics and the physicochemical properties of shiitake mushroom.

BACKGROUND: Fresh shiitake mushrooms are rich in nutrients, but have high water content, a fast metabolism after harvest, and deteriorate extremely easily. Therefore, the drying of shiitake mushrooms has become a research direction. However, the role of different drying techniques on shiitake mushroom quality is limited. Therefore, the purpose of this study was to investigate the effect of thermal and non-thermal drying on the drying kinetics, and the physicochemical properties of the end product. RESULTS: Results showed that shiitake mushroom treated with non-thermal drying (vacuum freeze-drying) had an attractive color, low shrinkage, and uniform honeycomb structure, while the drying time was the longest and not conducive to the formation of shiitake mushroom aroma. But shiitake mushroom treated with thermal drying presents an attractive fragrance. In thermal processing technology, compared with hot air convection drying (HAD), infrared hot air convection drying (IRHAD) shortens the drying time by 37.5%, and had the highest oxidation resistance, polysaccharide content and the lowest color change. Relative-humidity drying (RHD) samples had the lowest shrinkage compared with other thermal processing technology. The five polysaccharides exhibited similar preliminary structural characteristics, but the polysaccharides obtained by IRHAD have the highest antioxidant properties. CONCLUSION: These results showed that compared with thermal drying technology, non-thermal drying technology is not suitable for shiitake mushroom processing. In thermal processing technology, IRHAD is a potential drying method to obtain high-quality dried shiitake mushrooms and shiitake mushroom polysaccharide (SMP). However, it is necessary to increase the pretreatment technology to achieve the attractive appearance of non-thermal drying technology. © 2021 Society of Chemical Industry.

Effects of low frequency multi-mode ultrasound and it's washing solution's interface properties on freshly cut cauliflower.

This study investigated the effect of single and dual frequency ultrasound washing on freshly cut cauliflower, by pulsed and sweep frequency modes, with or without the addition of zinc acetate (ZA), tea saponin (TS) and ethanol (ET). Results showed that the surface microorganisms were efficiently decreased by sweep dual frequency ultrasound washing. Moreover, the use of 0.5% ZA, or 0.06% TS or 5% ET as washing solution improved the bacterial reduction efficiency. Reducing the interfacial tension, viscosity and contact angle of washing solution may strengthen ultrasound cavitation. Nearly 2.0 log CFU/g natural microorganisms were decreased, and shelf life was extended from 2 to 4-8 days under 4 °C. Physicochemical parameters of bioactive compounds content, enzyme activity, antioxidant ability, freshness were analyzed. Results showed that 0.5% ZA as washing solution of ultrasound washing was beneficial to the quality maintenance during storage period.

Inhibition of Lipid Accumulation and Adipokine Levels in Maturing Adipocytes by Bauhinia rufescens (Lam.) Stem Bark Extract Loaded Titanium Oxide Nanoparticles.

The present study reports a cost-effective, environmentally friendly method to increase the bioavailability and bio-efficacy of B. rufescens stem bark extract in the biological system via functional modification as B. rufescens stem bark nanoparticles (BR-TO2-NPs). The biosynthesis of BR- -NPs was confirmed by UV-visible (UV-vis) and Fourier-transform infrared (FT-IR) spectroscopy, transmission electron microscopy (TEM), and X-ray diffraction analyses. The shifts in FT-IR stretching vibrations of carboxylic and nitro groups (1615 cm-1), the O-H of phenolics or carboxylic acids (3405 cm-1), alkanes, and alkyne groups (2925 and 2224 cm-1) of the plant extract and lattice (455) indicated successful biosynthesis of BR- -NPs. Compared with the stem bark extract, 40 ng/dL dose of BR- -NPs led to a reduction in adipogenesis and an increase in mitochondrial biogenesis-related gene expressions, adiponectin-R1, PPARγC1α, UCP-1, and PRDM16, in maturing-adipocytes. This confirmed the intracellular uptake, bioavailability, and bio-efficiency of BR-TiO2-NPs. The lipid-lowering capacity of BR-TiO2-NPs effectively inhibited the metabolic inflammation-related gene markers, IL-6, TNF-α, LTB4-R, and Nf-κb. Further, BR-TiO2-NPs stimulating mitochondrial thermogenesis capacity was proven by the significantly enhanced CREB-1 and AMPK protein levels in adipocytes. In conclusion, BR-TiO2-NPs effectively inhibited lipid accumulation and proinflammatory adipokine levels in maturing adipocytes; it may help to overcome obesity-associated comorbidities.

Quercetin alleviates cadmium chloride-induced renal damage in rats by suppressing endoplasmic reticulum stress through SIRT1-dependent deacetylation of Xbp-1s and eIF2α.

Endoplasmic reticulum (ER) stress plays a key role in cadmium chloride (CdCl2)-induced nephrotoxicity. Sirtuin-1 (SIRT1) is a potent inhibitor of ER stress. In this study, we examined whether the protective effect of quercetin (QUR) against CdCl2-induced nephrotoxicity in rats involved modulation of SIRT1 and/or ER stress. Adult male rats were divided into five groups (n = 8, each) and treated for eight weeks as follows: control, control + QUR, CdCl2, CdCl2 + QUR, and CdCl2 + QUR + EX-527 (a SIRT1 inhibitor). Treatment of rats with QUR preserved the glomerulus and tubule structure, attenuated interstitial fibrosis, increased creatinine excretion, and reduced urinary levels of albumin, N-acetyl-ß-D-glucosaminidase, and ß2-microglobulin in CdCl2-treated rats. Concomitantly, QUR increased renal levels of Bcl-2, reduced mRNA levels of CHOP, and protein levels of Bax, caspase-3, and cleaved caspase-3, but failed to reduce the mRNA levels of GRP78, PERK, eIf2α, ATF-6, and xbp-1. QUR also reduced the renal levels of reactive oxygen species, tumour necrosis factor, and interleukin-6 and the nuclear activity of NF-κB in the control and CdCl2-treated rats but increased the nuclear activity of Nrf2 and levels of glutathione and manganese superoxide dismutase. Additionally, QUR increased the total levels and nuclear activity of SIRT1 and reduced the acetylation of eIf2α and xbp-1. The nephroprotective effects of QUR were abrogated by treatment with EX-527. Thus, QUR ameliorated CdCl2-induced nephrotoxicity through antioxidant and anti-inflammatory effects and suppressed ER stress mediated by the upregulation or activation of SIRT1-induced deacetylation of Nrf2, NF-κB p65, eIF2α, and xbp-1.

Intensive pulsed light pretreatment combined with controlled temperature and humidity for convection drying to reduce browning and improve quality of dried shiitake mushrooms.

BACKGROUND: The change of surface color caused by browning during the drying process of shiitake mushrooms seriously affects its market circulation. Intensive pulsed light (IPL) as a non-heat-treatment method can reduce enzyme activity by changing the enzyme structure. Therefore, in this study, the use of IPL pretreatment before drying was aimed to reduce the adverse reactions caused by the browning reaction during the drying processing of shiitake mushrooms. RESULTS: Shiitake mushrooms pretreated with 25 pulses of IPL energy of 400 J reduced the initial polyphenol oxidase enzyme activity, the browning index, and browning degree values by 42.83%, 43.02%, and 47.54% respectively. The IPL pretreatment enhanced the polysaccharides and reducing sugars contents and it reduced 5-hydroxymethylfurfural generation in the dried shiitake mushrooms. The pretreatment also improved the surface color, the antioxidant activity, and retained the umami taste characteristics in the dried shiitake mushroom. CONCLUSION: The IPL pretreatment combined with controlled temperature and humidity for convection drying could be a suitable method to improve the quality of dried shiitake mushrooms. Therefore, this study provides a new pretreatment method for materials that are prone to browning during drying. © 2021 Society of Chemical Industry.

Effect of ultrasonic pretreatment monitored by real-time online technologies on dried preparation time and yield during extraction process of okra pectin.

BACKGROUND: Ultrasonic pretreatment is a novel physical method that can be used in the extraction process of okra pectin. Real-time online monitoring technologies were introduced in time and frequency domains when okra was pretreated. Preparation time of dried okra and yield of okra pectin were studied; and physicochemical properties of okra pectin were analyzed at the optimum ultrasonic parameter. RESULTS: Results showed that ultrasonic intensity of sweeping-frequency ultrasonic (SFU) pretreatment was stronger than that of fixed-frequency ultrasonic pretreatment (FFU). SFU pretreatment (60 ± 1 kHz) at 30 min had a strong ultrasonic voltage peak of 0.05387 V and signal power peak of -6.62 dBm. The preparation time of dried okra was 160 ± 14.14 min in the pretreated group, 44.83% lower than control without SFU pretreatment. The intercellular space was 56.03% higher than control. Water diffusion coefficient increased from 1.41 × 10-9 to 2.14 × 10-9  m2  s-1 . Monobasic quadratic equations were developed for the monitored ultrasonic intensity and pectin yield. Compared to control, extraction yield (16.70%), pectin content (0.564 mg mg-1 ), solubility (0.8187 g g-1 ) and gel strength (30.91 g) were improved in the pretreated group. Viscosity decreased, and values of G' and G″ crossing at 63 rad s-1 revealed the viscoelastic behavior and the beginning of viscous behavior with a sol state. CONCLUSION: Decrement of dried preparation time and increment of yield were achieved by ultrasonic pretreatment during the extraction process of okra pectin, and the relationship of ultrasonic intensity monitored by real-time online technologies and yield was given. © 2021 Society of Chemical Industry.

Multimode-ultrasound and microwave assisted natural ternary deep eutectic solvent sequential pretreatments for corn straw biomass deconstruction under mild conditions.

Mild and effective pretreatments are essential to deconstruct lignocellulosic biomass so as to reuse cellulose content for value-added products. In this study, sequential multimode-ultrasound and microwave with natural ternary deep eutectic solvent (NATDES) pretreatments were used to deconstruct corn straw and optimized factors such as NATDES, ultrasonic, and microwave parameters. Results indicated that the ultrasound-NATDES or microwave-NATDES pretreatment could remove 37.86% and 52.36% lignin, respectively. When using sequential multimode-ultrasound and microwave assisted NATDES pretreatment, the delignification efficiency increased to 61.50%, and the cellulose content increased from 34.70% to 76.08%. In addition, the delignification of sequential multimode-ultrasound and microwave assisted NATDES pretreatment (under the mild conditions of microwave heating at 60 °C and 60 min) increased to 57.39%, and the cellulose content increased to 59.98%, too. This highlighted the effect of the combined ultrasound and microwave technology. Finally, the microstructural changes of mercury intrusion porosimeters, scanning electron microscopy, thermogravimetric, X-ray diffraction and Fourier transform mid-infrared spectroscopy were conducted to confirm the effectiveness of this method to deconstruct corn straw. A mechanism of the deconstruction of corn straw biomass in NATDES with the assistance of the sequential multimode-ultrasound and microwave heating was proposed. This research could open a window for future use of biomass energy by deconstructing lignocellulosic biomasses using environmentally friendly pretreatment methods.

Ultrasound freeze-thawing style pretreatment to improve the efficiency of the vacuum freeze-drying of okra (Abelmoschus esculentus (L.) Moench) and the quality characteristics of the dried product.

Vacuum freeze-drying is a new and high technology on agricultural product dehydrating dry, but it faces the high cost problem caused by high energy consumption. This study investigated the effect of ultrasound (US), freeze-thawing (including the freeze-air thawing (AT), freeze-water thawing (WT), freeze-ultrasound thawing (UST), and freeze-air ultrasound thawing (AT + US)) pretreatments on the vacuum freeze-drying efficiency and the quality of dried okra. The results indicated that the application of ultrasound and different freeze-thawing pretreatments reduced the drying time by 25.0%-62.50% and the total energy consumption was 24.28%-62.35% less. The AT pretreatment reduced the time by of okra slices by 62.50% and the total energy consumption was 62.35% less. The significant decrease in drying time was due to a change in the microstructure caused by pretreatment. Besides, the okra pretreated with the US retained most of the quality characteristics (flavor, color, hardness, and frangibility) among all methods, while, AT + US had the most changeable characteristics in quality, which is deprecated in our study. The okra pretreated with the US and AT, separately, had the best dry matter content loss (9.008%, 5.602%), lower chlorophyll degradation (5.05%, 5.44% less), and higher contents of total phenolics, total flavonoids, and pectin, with strong antioxidant capacity, compared to other methods. The pretreatments did not have a large effect on the functional groups and the structure of pectin, but slightly affected the viscosity. It can be concluded that AT and US pretreatment methods are better than others.

Effects of single- and tri-frequency ultrasound on self-assembly and characterizations of bionic dynamic rat stomach digestion of pepsin-soluble collagen from chicken leg skin.

Chicken feet, aplenty by-products in the chicken industry, are rich in collagen and contain abundant amino acids so that it can be used as an important source for the collagen market. Pepsin-soluble collagen (PSC) was extracted from chicken leg skin and explored the effects of single- and tri-frequency ultrasound on the self-assembly and vitro digestion characteristics. By the diverging and tri-frequency ultrasound reactor, PSC was treated with 20 kHz/270w (C20H5m), 40 kHz/270w (C40H5m), 60 kHz/270w (C60H5m), 20/40/60 kHz/90w × 3 (CtH5m) for 5 min. Results showed that ultrasound could accelerate the process of collagen self-assembly, and 60 kHz/270w was the fastest. Microfiber diameters of C60H5m were 65-89 nm, which was significantly lower than the control without ultrasound (80-161 nm). The digestion results indicated polypeptides with relative molecular weights founded in the range 200-5000 Da were exceeded 85%. The final digested product had the highest content of oligopeptide, consistent rheological properties, and elastic behavior. The cavitation and mechanical of ultrasound have effects on the self-assembly process and collagen gel structure and digestion characteristics, which is of great significance for the development of the chicken industry and collagen market.

Effects of high power ultrasound on the enzymolysis and structures of sweet potato starch.

BACKGROUND: The general enzymatic method for producing reducing sugar is liquefaction followed by saccharification of starch. This method results in lower yields, consuming high energy and time. Therefore, the present study evaluated a new approach for producing reducing sugar from sweet potato starch (SPS), including simultaneous liquefaction (by α-amylase) and saccharification (by glucoamylase) of SPS pretreated with high power ultrasound. The effects of ultrasound parameters on the conversion rate of SPS and mechanism were investigated. RESULTS: The optimum ultrasound pretreatment conditions were a frequency of 20 kHz, SPS concentration of 125 g L-1 , temperature of 30 °C, pulsed on-time of 3 s, pulsed off-time of 5 s, power density of 8 W mL-1 and sonication time of 15 min. The ultrasound assisted enzymolysis resulted in a SPS conversion rate of 59.10%, which was improved by 56.35% compared to the control. The results of pasting properties and thermal analysis showed that ultrasound pretreatment decreased the peak viscosity, breakdown temperature, setback viscosity, gelatinization range (TC - TO ) and enthalpy of gelatinization (ΔH) of SPS significantly (P < 0.05) by 12.1%, 7.6%, 6.6%, 18.8% and 44.4%, respectively. Fourier-transform infrared spectroscopy indicated that ultrasound damaged the ordered structures and crystallization zone. This was confirmed by X-ray diffraction analysis, which showed that the relative crystallinity was reduced by 15.0%. Scanning electron microscopy showed that ultrasound destroyed the surfaces and the linkages between starch granules. CONCLUSION: Prior to simultaneous liquefaction and saccharification of SPS, high power ultrasound pretreatment is a promising method for improving the conversion rate of starch. © 2020 Society of Chemical Industry.