RESUMO
IMPORTANCE: Acetobacter pasteurianus, an industrial vinegar-producing strain, is suffered by fermentation stress such as fermentation heat and/or high concentrations of acetic acid. By an experimental evolution approach, we have obtained a stress-tolerant strain, exhibiting significantly increased growth and acetic acid fermentation ability at higher temperatures. In this study, we report that only the three gene mutations of ones accumulated during the adaptation process, ansP, dctD, and glnD, were sufficient to reproduce the increased thermotolerance of A. pasteurianus. These mutations resulted in cell envelope modification, including increased phospholipid and lipopolysaccharide synthesis, increased respiratory activity, and cell size reduction. The phenotypic changes may cooperatively work to make the adapted cell thermotolerant by enhancing cell surface integrity, nutrient or oxygen availability, and energy generation.
Assuntos
Acetobacter , Termotolerância , Ácido Acético/metabolismo , Acetobacter/genética , Acetobacter/metabolismo , Fermentação , Aminoácidos/metabolismoRESUMO
2-Oxoglutarate (2-OG) is a tricarboxylate cycle intermediate that can be biologically converted into several industrially important compounds. However, studies on the fermentative production of compounds synthesized from 2-OG, but not via glutamate (defined as 2-OG derivatives), have been limited. Herein, a system that can efficiently produce 2-hydroxyglutarate (2-HG), a 2-OG derivative biosynthesized by the hgdH-encoded NADH-dependent 2-HG dehydrogenase of Acidaminococcus fermentans, was developed as a model using Corynebacterium glutamicum. First, the D3 strain, which lacked the two NADH-consuming enzymes, lactate dehydrogenase and malate dehydrogenase, as well as isocitrate lyase, was constructed as a starting strain. Next, the growth conditions that induced the accumulation of 2-OG were investigated, and it was found that the biotin- and nitrogen-limited (B/N-limited) aerobic growth conditions were suitable for this purpose. Finally, the hgdH gene of A. fermentans became overexpressed in the D3 strain by inserting it into the intergenic regions with the strong constitutive promoter of the tuf gene of C. glutamicum; the engineered strain was cultured under the B/N-limited aerobic growth conditions. The engineered strain produced 80.1 mM 2-HG with a yield of 0.390 mol/mol glucose, which are the highest titer and yield reported thus far, to the best of our knowledge. Furthermore, reverse genetics showed that the produced 2-HG was partially exported via the YggB protein (NCgl1221 protein, a mechanosensitive channel) known as an exporter for glutamate under the conditions used herein. KEY POINTS: ⢠An efficient 2-HG production system was developed with Corynebacterium glutamicum. ⢠Biotin- and nitrogen-limited aerobic growth conditions induced 2-OG production. ⢠Produced 2-HG was partially excreted via the glutamate exporter, YggB.
Assuntos
Corynebacterium glutamicum , Corynebacterium glutamicum/metabolismo , Biotina/metabolismo , NAD/metabolismo , Ácido Glutâmico/metabolismo , Nitrogênio/metabolismoRESUMO
Corynebacterium glutamicum was metabolically engineered to produce phenylalanine, a valuable aromatic amino acid that can be used as a raw material in the food and pharmaceutical industries. First, a starting phenylalanine-producer was constructed by overexpressing tryptophan-sensitive 3-deoxy-D-arabino-heptulosonate-7-phosphate synthase and phenylalanine- and tyrosine-insensitive bifunctional enzyme chorismate mutase prephenate dehydratase from Escherichia coli, followed by the inactivation of enzymes responsible for the formation of dihydroxyacetone and the consumption of shikimate pathway-related compounds. Second, redirection of the carbon flow from tyrosine to phenylalanine was attempted by deleting of the tyrA gene encoding prephenate dehydrogenase, which catalyzes the committed step for tyrosine biosynthesis from prephenate. However, suppressor mutants were generated, and two mutants were isolated and examined for phenylalanine production and genome sequencing. The suppressor mutant harboring an amino acid exchange (L180R) on RNase J, which was experimentally proven to lead to a loss of function of the enzyme, showed significantly enhanced production of phenylalanine. Finally, modifications of phosphoenolpyruvate-pyruvate metabolism were investigated, revealing that the inactivation of either phosphoenolpyruvate carboxylase or pyruvate carboxylase, which are enzymes of the anaplerotic pathway, is an effective means for improving phenylalanine production. The resultant strain, harboring a phosphoenolpyruvate carboxylase deficiency, synthesized 50.7 mM phenylalanine from 444 mM glucose. These results not only provided new insights into the practical mutations in constructing a phenylalanine-producing C. glutamicum but also demonstrated the creation of a potential strain for the biosynthesis of phenylalanine-derived compounds represented by plant secondary metabolites.
Assuntos
Corynebacterium glutamicum , Fenilalanina , Fenilalanina/genética , Fenilalanina/metabolismo , Corynebacterium glutamicum/genética , Corynebacterium glutamicum/metabolismo , Engenharia Metabólica , Tirosina , Escherichia coli/genéticaRESUMO
5-Ketogluconate (5KGA) is a precursor for synthesizing tartrate, a valuable compound used in several industries. In a previous study, Gluconobacter japonicus NBRC 3271 mutant strain D2, which lacks two membranous gluconate 2-dehydrogenases, was shown to produce 5KGA but not 2-ketogluconate from a mixture of glucose and gluconate. In this study, we aimed to develop an efficient 5KGA production system using G. japonicus D2 as the parental strain. D2 produced 5KGA from glucose in a jar fermentor culture; however, 5KGA levels were reduced during the late phase of cultivation. To increase the potential of D2 for 5KGA production, the cytoplasmic metabolism related to the utilization of 5KGA and gluconate was modified; the gno and gntK genes encoding 5KGA reductase and gluconokinase, respectively, were deleted from D2, generating D4. Improved 5KGA production was observed in D4 compared to that in D2, but a significant amount of gluconate remained at the end of cultivation, leading to an unsatisfied yield of 0.83 mol (mol glucose)-1. The conversion of gluconate to 5KGA is catalyzed by pyrroloquinoline quinone (PQQ)-dependent glycerol dehydrogenase (GLDH), which easily forms an apoenzyme by releasing PQQ and calcium ions. Thus, the effects of CaCl2 addition to the culture medium on 5KGA production by D4 were investigated. We demonstrated that 1 mM CaCl2 addition positively affected the maintenance of the PQQ-GLDH activity toward gluconate and consequently enhanced 5KGA production, and the yield reached 0.97 mol (mol glucose)-1. KEY POINTS: ⢠An efficient 5KGA production system was developed with Gluconobacter japonicus. ⢠Deleting the gno and gntK genes blocked the catabolism of 5KGA and gluconate. ⢠The addition of 1 mM CaCl2 efficiently improved the conversion of glucose to 5KGA.
Assuntos
Gluconobacter , Cloreto de Cálcio , Gluconatos/metabolismo , Cofator PQQ/metabolismo , Glucose/metabolismoRESUMO
Histamine (HIST) and other biogenic amines found in fish and fishery products accumulated by the action of bacterial amino acid decarboxylase cannot be decomposed and eliminated by heating or other chemical methods. A simple method for HIST elimination is proposed by a coupling reaction of the fungal amine oxidase (FAO) and bacterial aldehyde oxidase (ALOX) of acetic acid bacteria. As a model reaction, FAO oxidized benzylamine to benzaldehyde, which in turn was oxidized spontaneously to benzoic acid with ALOX. Likely, in HIST elimination, FAO coupled well with ALOX to produce imidazole 4-acetic acid from HIST with an apparent yield of 100%. Imidazole 4-acetaldehyde was not detected in the reaction mixture. In the absence of ALOX, the coupling reaction was incomplete given a number of unidentified substances in the reaction mixture. The proposed coupling enzymatic method may be highly effective to eliminate toxic amines from fish and fishery products.
Assuntos
Carboxiliases , Histamina , Aldeído Oxidase , Aminoácidos , Animais , Bactérias/metabolismo , Benzaldeídos , Ácido Benzoico , Benzilaminas , Aminas Biogênicas/metabolismo , Peixes , Histamina/metabolismoRESUMO
D-Mannose isomerase (EC 5.3.1.7) catalyzing reversible conversion between D-mannose and D-fructose was found in acetic acid bacteria. Cell fractionation confirmed the enzyme to be a typical membrane-bound enzyme, while all sugar isomerases so far reported are cytoplasmic. The optimal enzyme activity was found at pH 5.5, which was clear contrast to the cytoplasmic enzymes having alkaline optimal pH. The enzyme was heat stable and the optimal reaction temperature was observed at around 40 to 60ËC. Purified enzyme after solubilization from membrane fraction showed the total molecular mass of 196 kDa composing of identical four subunits of 48 kDa. Washed cells or immobilized cells were well functional at nearly 80% of conversion ratio from D-mannose to D-fructose and reversely 20-25% of D-fructose to D-mannose. Catalytic properties of the enzyme were discussed with respect to the biotechnological applications to high fructose syrup production from konjac taro.
RESUMO
Protocatechuate (3,4-dihydroxybenzoate) has antioxidant properties and is a raw material for the production of muconic acid, which is a key compound in the synthesis of polymers such as nylon and polyethylene terephthalate. Gluconobacter oxydans strain NBRC3244 has a periplasmic system for oxidation of quinate to produce 3-dehydroquinate. Previously, a periplasmic 3-dehydroshikimate production system was constructed by heterologously expressing Gluconacetobacter diazotrophicus dehydroquinate dehydratase in the periplasm of G. oxydans strain NBRC3244. 3-Dehydroshikimate is converted to protocatechuate by dehydration. In this study, we constructed a G. oxydans strain that expresses the Acinetobacter baylyi quiC gene, which encodes a dehydroshikimate dehydratase of which the subcellular localization is likely the periplasm. We attempted to produce protocatechuate by co-cultivation of two recombinant G. oxydans strains-one expressing the periplasmically targeted dehydroquinate dehydratase and the other expressing A. baylyi dehydroshikimate dehydratase. The co-cultivation system produced protocatechuate from quinate in a nearly quantitative manner.
Assuntos
Gluconobacter oxydans , Gluconobacter oxydans/genética , Hidroliases/genética , Hidroliases/metabolismo , Oxirredução , Periplasma/metabolismo , Ácido QuínicoRESUMO
An acetic acid bacterium, Komagataeibacter medellinensis NBRC 3288, was adapted to higher growth temperatures through an experimental evolution approach in acetic acid fermentation conditions, in which the cells grew under high concentrations of ethanol and acetic acid. The thermally adapted strains were shown to exhibit significantly increased growth and fermentation ability, compared to the wild strain, at higher temperatures. Although the wild cells were largely elongated and exhibited a rough cell surface, the adapted strains repressed the elongation and exhibited a smaller cell size and a smoother cell surface than the wild strain. Among the adapted strains, the ITO-1 strain isolated during the initial rounds of adaptation was shown to have three indel mutations in the genes gyrB, degP, and spoT. Among these, two dispensable genes, degP and spoT, were further examined in this study. Rough cell surface morphology related to degP mutation suggested that membrane vesicle-like structures were increased on the cell surface of the wild-type strain but repressed in the ITO-1 strain under high-temperature acetic acid fermentation conditions. The ΔdegP strain could not grow at higher temperatures and accumulated a large amount of membrane vesicles in the culture supernatant when grown even at 30°C, suggesting that the degP mutation is involved in cell surface stability. As the spoT gene of ITO-1 lost a 3'-end of 424 bp, which includes one (Act-4) of the possible two regulatory domains (TGS and Act-4), two spoT mutant strains were created: one (ΔTGSAct) with a drug cassette in between the 5'-half catalytic domain and 3'-half regulatory domains of the gene, and the other (ΔAct-4) in between TGS and Act-4 domains of the regulatory domain. These spoT mutants exhibited different growth responses; ΔTGSAct grew better in both the fermentation and non-fermentation conditions, whereas ΔAct-4 did only under fermentation conditions, such as ITO-1 at higher temperatures. We suggest that cell elongation and/or cell size are largely related to these spoT mutations, which may be involved in fermentation stress and thermotolerance.
RESUMO
We identified a novel flavoprotein-cytochrome c complex d-gluconate dehydrogenase (GADH) encoded by gndXYZ of Gluconobacter oxydans NBRC 3293, which is phylogenetically distinct from previously reported GADHs encoded by gndFGH and gndSLC of Gluconobacter spp. To analyze the biochemical properties of respective GADHs, Gluconobacter japonicus NBRC 3271 mutant strain lacking membranous d-gluconate dehydrogenase activity was constructed. All GADHs (GndFGH, GndSLC, and GndXYZ) were successfully overexpressed in the constructed strain. The optimal pH and KM value at that pH of GndFGH, GndSLC, and GndXYZ were 5, 6, and 4, and 8.82 ± 1.15, 22.9 ± 5.0, and 11.3 ± 1.5 m m, respectively. When the mutants overexpressing respective GADHs were cultured in d-glucose-containing medium, all of them produced 2-keto-d-gluconate, revealing that GndXYZ converts d-gluconate to 2-keto-d-gluconate as well as other GADHs. Among the recombinants, the gndXYZ-overexpressing strain accumulated the highest level of 2-keto-d-gluconate, suggesting its potential for 2-keto-d-gluconate production.
Assuntos
Gluconobacter oxydans , Gluconobacter , Gluconatos/química , Gluconobacter/genética , Gluconobacter oxydans/genética , OxirredutasesRESUMO
Acetic acid bacteria catalyze the two-step oxidation of ethanol to acetic acid using the membrane-bound enzymes pyrroloquinoline quinone-dependent alcohol dehydrogenase and molybdopterin-dependent aldehyde dehydrogenase (ALDH). Although the reducing equivalents from the substrate are transferred to ubiquinone in the membrane, intramolecular electron transport in ALDH is not understood. Here, we purified the AldFGH complex, the membrane-bound ALDH that is physiologically relevant to acetic acid fermentation in Gluconacetobacter diazotrophicus strain PAL5. The purified AldFGH complex showed acetaldehyde:ubiquinone (Q2) oxidoreductase activity. c-type cytochromes of the AldFGH complex (in the AldF subunit) were reduced by acetaldehyde. Next, we genetically dissected the AldFGH complex into AldGH and AldF units and reconstituted them. The AldGH subcomplex showed acetaldehyde:ferricyanide oxidoreductase activity but not Q2 reductase activity. The ALDH activity of AldGH was not found in membranes but was found in the soluble fraction of the recombinant strain, suggesting that the AldF subunit is responsible for membrane binding of the AldFGH complex. The absorption spectra of the purified AldGH subcomplex suggested the presence of an [Fe-S] cluster, which can be reduced by acetaldehyde. The AldFGH complex reconstituted from the AldGH subcomplex and AldF showed Q2 reductase activity. We propose a model in which electrons from the substrate are abstracted by a molybdopterin in the AldH subunit and transferred to the [Fe-S] cluster(s) in the AldG subunit, followed by electron transport to c-type cytochrome centers in the AldF subunit, which is the site of ubiquinone reduction in the membrane. IMPORTANCE Two membrane-bound enzymes of acetic acid bacteria, pyrroloquinoline quinone-dependent alcohol dehydrogenase and molybdopterin-dependent aldehyde dehydrogenase (ALDH), are responsible for vinegar production. Upon the oxidation of acetaldehyde, ALDH reduces ubiquinone in the cytoplasmic membrane. ALDH is an enzyme complex of three subunits. Here, we tried to understand how ALDH works by using a classical biochemical approach and genetic engineering to dissect the enzyme complex into soluble and membrane-bound parts. The soluble part had limited activity in vitro and did not reduce ubiquinone. However, the enzyme complex reconstituted from the soluble and membrane-bound parts showed ubiquinone reduction activity. The proposed working model of ALDH provides a better understanding of how the enzyme works in the vinegar fermentation process.
Assuntos
Álcool Desidrogenase , Aldeído Desidrogenase , Acetaldeído , Ácido Acético/metabolismo , Álcool Desidrogenase/metabolismo , Aldeído Desidrogenase/genética , Aldeído Desidrogenase/metabolismo , Aldeídos , Citocromos/metabolismo , Transporte de Elétrons , Gluconacetobacter , Cofator PQQ/metabolismo , Ubiquinona/metabolismoRESUMO
Corynebacterium glutamicum, a gram-positive bacterium, can produce amino acids such as glutamic acid and lysine. The heat generated during cell growth and/or glutamate fermentation disturbs both the cell growth and fermentation. To overcome such a negative effect of the fermentation heat, we have tried to establish a high temperature fermentation. One of the approach is to create a thermotolerant strains, while the other is to create an optimum culture conditions able for the strain to grow at higher temperatures. In this study, we focused on the latter approach, where we examined the effect of potassium ion on cell growth at high growth temperatures of C. glutamicum. The supplementation of high concentrations of potassium chloride (300 mM) (or sorbitol, an osmolyte) mitigated the repressed cell growth induced by high temperature at 39 °C or 40 °C. The intracellular potassium concentration declines from 300 mM to â¼150 mM by increasing the growth temperature but not by supplementing potassium chloride or sorbitol. Furthermore, in vitro experiments revealed that the potassium ion leakage occurs at high temperatures, which was mitigated in the presence of high concentrations of extracellular potassium chloride. This suggested that the presence of high osmolyte in the culture medium could inhibit the potassium ion leakage induced by high temperature and subsequently support cell growth at high temperatures.
Assuntos
Corynebacterium glutamicum , Termotolerância , Corynebacterium glutamicum/metabolismo , Fermentação , Lisina/metabolismo , PotássioRESUMO
3-Dehydroshikimate (3-DHS) is a key intermediate for the synthesis of various compounds, including the antiviral drug oseltamivir. The Gluconobacter oxydans strain NBRC3244 intrinsically oxidizes quinate to produce 3-dehydroquinate (3-DHQ) in the periplasmic space. Even though a considerable activity is detected in the recombinant G. oxydans homologously overexpressing type II dehydroquinate dehydratase (DHQase) encoded in the aroQ gene at a pH where it grows, an alkaline shift of the culture medium is required for 3-DHS production in the middle of cultivation. Here, we attempted to adopt type I DHQase encoded in the aroD gene of Gluconacetobacter diazotrophicus strain PAL5 because the type I DHQase works optimally at weak acid, which is preferable for growth conditions of G. oxydans. In addition, we anticipated that subcellular localization of DHQase is the cytoplasm, and therefore, transports of 3-DHQ and 3-DHS across the cytoplasmic membrane are rate-limiting steps in the biotransformation. The Sec- and TAT-dependent signal sequences for secretion were attached to the N terminus of AroD to change the subcellular localization. G. oxydans that expresses the TAT-AroD derivative achieved 3-DHS production at a tenfold higher rate than the reference strain that expresses wild-type AroD even devoid of alkaline shift. Enzyme activity with the intact cell suspension and signal sequence cleavage supported the relocation of AroD to the periplasmic space. The present study suggests that the relocation of DHQase improves 3-DHS production in G. oxydans and represents a proof of concept for the potential of enzyme relocation in metabolic engineering. KEY POINTS: ⢠Type-I dehydroquinate dehydratase (DHQase) was expressed in Gluconobacter oxydans. ⢠Cytoplasmic DHQase was relocated to the periplasmic space in G. oxydans. ⢠Relocation of DHQase in G. oxydans improved 3-dehydroshikimate production.
Assuntos
Gluconacetobacter , Gluconobacter oxydans , Gluconobacter oxydans/genética , Hidroliases/genética , PeriplasmaRESUMO
In contrast to D-glyceric acid (D-GA) production with 99% enantiomeric excess (ee) by Acetobacter tropicalis NBRC 16470, Gluconobacter sp. CHM43 produced 19.6 g L-1 of D-GA with 73.7% ee over 4 days of incubation in flask culture. To investigate the reason for this enantiomeric composition of GA, the genes encoding membrane-bound alcohol dehydrogenase (mADH) of A. tropicalis NBRC 16470, composed of three subunits (adhA, adhB, and adhS), were cloned using the broad-host-range vector pBBR1MCS-2 and heterologously expressed in Gluconobacter sp. CHM43 and its ΔadhAB ΔsldBA derivative TORI4. Reverse-transcription quantitative real-time polymerase chain reaction demonstrated that adhABS genes from A. tropicalis were expressed in TORI4 transformants, and their membrane fraction exhibited mADH activities of 0.13 and 0.31 U/mg with or without AdhS, respectively. Compared with the GA production of TORI4-harboring pBBR1MCS-2 (1.23 g L-1), TORI4 transformants expressing adhABS and adhAB showed elevated GA production of 2.46 and 3.67 g L-1, respectively, suggesting a negative effect of adhS gene expression on GA production as well as mADH activity in TORI4. Although TORI4 was found to produce primarily L-GA with 42.5% ee, TORI4 transformants expressing adhABS and adhAB produced D-GA with 27.6% and 49.0% ee, respectively, demonstrating that mADH of A. tropicalis causes a sharp increase in the enantiomeric composition of D-GA. These results suggest that one reason for D-GA production with 73.7% ee in Gluconobacter spp. might be a property of the host, which possibly produces L-GA intracellularly. KEY POINTS: ⢠Membrane-bound ADH from Acetobacter tropicalis showed activity in Gluconobacter sp. ⢠D-GA production from glycerol was performed using recombinant Gluconobacter sp. ⢠Enantiomeric excess of D-GA was affected by both membrane and intracellular ADHs.
Assuntos
Gluconobacter , Acetobacter , Álcool Desidrogenase , Gluconobacter/genética , Ácidos GlicéricosRESUMO
Gluconobacter sp. strain CHM43 oxidizes mannitol to fructose and then oxidizes fructose to 5-keto-d-fructose (5KF) in the periplasmic space. Since NADPH-dependent 5KF reductase was found in the soluble fraction of Gluconobacter spp., 5KF might be transported into the cytoplasm and metabolized. Here, we identified the GLF_2050 gene as the kfr gene encoding 5KF reductase (KFR). A mutant strain devoid of the kfr gene showed lower KFR activity and no 5KF consumption. The crystal structure revealed that KFR is similar to NADP+-dependent shikimate dehydrogenase (SDH), which catalyzes the reversible NADP+-dependent oxidation of shikimate to 3-dehydroshikimate. We found that several amino acid residues in the putative substrate-binding site of KFR were different from those of SDH. Phylogenetic analyses revealed that only a subclass in the SDH family containing KFR conserved such a unique substrate-binding site. We constructed KFR derivatives with amino acid substitutions, including replacement of Asn21 in the substrate-binding site with Ser that is found in SDH. The KFR-N21S derivative showed a strong increase in the Km value for 5KF but a higher shikimate oxidation activity than wild-type KFR, suggesting that Asn21 is important for 5KF binding. In addition, the conserved catalytic dyad Lys72 and Asp108 were individually substituted for Asn. The K72N and D108N derivatives showed only negligible activities without a dramatic change in the Km value for 5KF, suggesting a catalytic mechanism similar to that of SDH. With these data taken together, we suggest that KFR is a new member of the SDH family. IMPORTANCE A limited number of species of acetic acid bacteria, such as Gluconobacter sp. strain CHM43, produce 5-ketofructose, a potential low-calorie sweetener, at a high yield. Here, we show that an NADPH-dependent 5-ketofructose reductase (KFR) is involved in 5-ketofructose degradation, and we characterize this enzyme with respect to its structure, phylogeny, and function. The crystal structure of KFR was similar to that of shikimate dehydrogenase, which is functionally crucial in the shikimate pathway in bacteria and plants. Phylogenetic analysis suggested that KFR is positioned in a small subgroup of the shikimate dehydrogenase family. Catalytically important amino acid residues were also conserved, and their relevance was experimentally validated. Thus, we propose KFR as a new member of shikimate dehydrogenase family.
Assuntos
Proteínas de Bactérias/metabolismo , Desidrogenases de Carboidrato/metabolismo , Gluconobacter/enzimologia , Proteínas de Bactérias/genética , Desidrogenases de Carboidrato/classificação , Desidrogenases de Carboidrato/genética , Regulação Bacteriana da Expressão Gênica , Regulação Enzimológica da Expressão Gênica , Gluconobacter/genética , Gluconobacter/metabolismo , Modelos Moleculares , Filogenia , Conformação ProteicaRESUMO
We characterized the pyrroloquinoline quinone (PQQ)-dependent dehydrogenase 9 (PQQ-DH9) of Gluconobacter sp. strain CHM43, which is a homolog of PQQ-dependent glycerol dehydrogenase (GLDH). We used a plasmid construct to express PQQ-DH9. The expression host was a derivative strain of CHM43, which lacked the genes for GLDH and the membrane-bound alcohol dehydrogenase and consequently had minimal ability to oxidize primary and secondary alcohols. The membranes of the transformant exhibited considerable d-arabitol dehydrogenase activity, whereas the reference strain did not, even if it had PQQ-DH9-encoding genes in the chromosome and harbored the empty vector. This suggests that PQQ-DH9 is not expressed in the genome. The activities of the membranes containing PQQ-DH9 and GLDH suggested that similar to GLDH, PQQ-DH9 oxidized a wide variety of secondary alcohols but had higher Michaelis constants than GLDH with regard to linear substrates such as glycerol. Cyclic substrates such as cis-1,2-cyclohexanediol were readily oxidized by PQQ-DH9.
Assuntos
Gluconobacter/metabolismo , Oxirredutases/metabolismo , Cofator PQQ/metabolismo , Álcool Desidrogenase/metabolismo , Genoma Bacteriano , Plasmídeos , Álcoois Açúcares/metabolismoRESUMO
Thermotolerant microorganisms are useful for high-temperature fermentation. Several thermally adapted strains were previously obtained from Acetobacter pasteurianus in a nutrient-rich culture medium, while these adapted strains could not grow well at high temperature in the nutrient-poor practical culture medium, "rice moromi." In this study, A. pasteurianus K-1034 originally capable of performing acetic acid fermentation in rice moromi was thermally adapted by experimental evolution using a "pseudo" rice moromi culture. The adapted strains thus obtained were confirmed to grow well in such the nutrient-poor media in flask or jar-fermentor culture up to 40 or 39 °C; the mutation sites of the strains were also determined. The high-temperature fermentation ability was also shown to be comparable with a low-nutrient adapted strain previously obtained. Using the practical fermentation system, "Acetofermenter," acetic acid production was compared in the moromi culture; the results showed that the adapted strains efficiently perform practical vinegar production under high-temperature conditions.
Assuntos
Ácido Acético/metabolismo , Acetobacter/genética , Adaptação Fisiológica/genética , Etanol/metabolismo , Fermentação/genética , Termotolerância/genética , Acetobacter/metabolismo , Reatores Biológicos , Genoma Bacteriano , Temperatura Alta , Mutação , Oryza/química , Oxigênio/metabolismo , Extratos Vegetais/química , Extratos Vegetais/metabolismoRESUMO
Gene expression in the obligately aerobic acetic acid bacterium Gluconobacter oxydans responds to oxygen limitation, but the regulators involved are unknown. In this study, we analyzed a transcriptional regulator named GoxR (GOX0974), which is the only member of the fumarate-nitrate reduction regulator (FNR) family in this species. Evidence that GoxR contains an iron-sulfur cluster was obtained, suggesting that GoxR functions as an oxygen sensor similar to FNR. The direct target genes of GoxR were determined by combining several approaches, including a transcriptome comparison of a ΔgoxR mutant with the wild-type strain and detection of in vivo GoxR binding sites by chromatin affinity purification and sequencing (ChAP-Seq). Prominent targets were the cioAB genes encoding a cytochrome bd oxidase with low O2 affinity, which were repressed by GoxR, and the pnt operon, which was activated by GoxR. The pnt operon encodes a transhydrogenase (pntA1A2B), an NADH-dependent oxidoreductase (GOX0313), and another oxidoreductase (GOX0314). Evidence was obtained for GoxR being active despite a high dissolved oxygen concentration in the medium. We suggest a model in which the very high respiration rates of G. oxydans due to periplasmic oxidations cause an oxygen-limited cytoplasm and insufficient reoxidation of NAD(P)H in the respiratory chain, leading to inhibited cytoplasmic carbohydrate degradation. GoxR-triggered induction of the pnt operon enhances fast interconversion of NADPH and NADH by the transhydrogenase and NADH reoxidation by the GOX0313 oxidoreductase via reduction of acetaldehyde formed by pyruvate decarboxylase to ethanol. In fact, small amounts of ethanol were formed by G. oxydans under oxygen-restricted conditions in a GoxR-dependent manner.IMPORTANCEGluconobacter oxydans serves as a cell factory for oxidative biotransformations based on membrane-bound dehydrogenases and as a model organism for elucidating the metabolism of acetic acid bacteria. Surprisingly, to our knowledge none of the more than 100 transcriptional regulators encoded in the genome of G. oxydans has been studied experimentally until now. In this work, we analyzed the function of a regulator named GoxR, which belongs to the FNR family. Members of this family serve as oxygen sensors by means of an oxygen-sensitive [4Fe-4S] cluster and typically regulate genes important for growth under anoxic conditions by anaerobic respiration or fermentation. Because G. oxydans has an obligatory aerobic respiratory mode of energy metabolism, it was tempting to elucidate the target genes regulated by GoxR. Our results show that GoxR affects the expression of genes that support the interconversion of NADPH and NADH and the NADH reoxidation by reduction of acetaldehyde to ethanol.
Assuntos
Ácido Acético/metabolismo , Proteínas de Bactérias/genética , Regulação Bacteriana da Expressão Gênica , Gluconobacter oxydans/genética , Fatores de Transcrição/genética , Aerobiose , Proteínas de Bactérias/metabolismo , Gluconobacter oxydans/metabolismo , Oxirredução , Fatores de Transcrição/metabolismoRESUMO
Acetic acid fermentation involves the oxidation of ethanol to acetic acid via acetaldehyde as the intermediate and is catalyzed by the membrane-bound alcohol dehydrogenase (ADH) and aldehyde dehydrogenase (ALDH) of acetic acid bacteria. Although ADH depends on pyrroloquinoline quinone (PQQ), the prosthetic group associated with ALDH remains a matter of debate. This study aimed to address the dependency of ALDH of Gluconacetobacter diazotrophicus strain PAL5 on PQQ and the physiological role of ALDH in acetic acid fermentation. We constructed deletion mutant strains for both the ALDH gene clusters of PAL5, aldFGH and aldSLC. In addition, the adhAB operon for ADH was eliminated, since it shows ALDH activity. The triple-deletion derivative ΔaldFGH ΔaldSLC ΔadhAB failed to show ALDH activity, which suggested that ALDH activity in PAL5 is derived from these three enzyme complexes. Since the single-gene cluster deletion derivative ΔaldFGH lost most ALDH activity, and accumulated much higher acetaldehyde than wild type under acetic acid fermentation conditions, we concluded that AldFGH functions as the major ALDH in PAL5. Furthermore, deletion of the PQQ biosynthesis gene cluster (pqqABCDE) abolished ADH activity completely, but did not affect ALDH activity. Instead, the molybdopterin biosynthesis gene deletion derivatives lost ALDH activity. Thus, we concluded that the AldFGH and AldSLC complexes of Ga. diazotrophicus PAL5 require a form of molybdopterin but not PQQ for ALDH activity. KEY POINTS: ⢠AldFGH is the major aldehyde dehydrogenase in Gluconacetobacter diazotrophicus PAL5. ⢠Acetaldehyde accumulated from ethanol in the absence of AldFGH. ⢠Molybdopterin, rather than pyrroloquinoline quinone, is required for AldFGH.
Assuntos
Gluconacetobacter , Cofator PQQ , Ácido Acético , Álcool Desidrogenase/genética , Álcool Desidrogenase/metabolismo , Aldeído Desidrogenase/genética , Aldeído Desidrogenase/metabolismo , Coenzimas , Fermentação , Gluconacetobacter/genética , Gluconacetobacter/metabolismo , Metaloproteínas , Cofatores de Molibdênio , Cofator PQQ/metabolismo , PteridinasRESUMO
Dihydroxyacetone (DHA), a chemical suntan agent, is produced by the regiospecific oxidation of glycerol with Gluconobacter thailandicus NBRC3255. However, this microorganism consumes DHA produced in the culture medium. Here, we attempted to understand the pathway for DHA metabolism in NBRC3255 to minimize DHA degradation. The two gene products, NBRC3255_2003 (DhaK) and NBRC3255_3084 (DerK), have been annotated as DHA kinases in the NBRC 3255 draft genome. Because the double deletion derivative for dhaK and derK showed ATP-dependent DHA kinase activity similar to that of the wild type, we attempted to purify DHA kinase from ∆dhaK ∆derK cells to identify the gene for DHA kinase. The identified gene was NBRC3255_0651, of which the product was annotated as glycerol kinase (GlpK). Mutant strains with several combinations of deletions for the dhaK, derK, and glpK genes were constructed. The single deletion strain ∆glpK showed approximately 10% of wild-type activity and grew slower on glycerol than the wild type. The double deletion strain ∆derK ∆glpK and the triple deletion strain ∆dhaK ∆derK ∆glpK showed DHA kinase activity less than a detection limit and did not grow on glycerol. In addition, although ΔderK ΔglpK consumed a small amount of DHA in the late phase of growth, ∆dhaK ΔderK ΔglpK did not show DHA consumption on glucose-glycerol medium. The transformants of the ∆dhaK ΔderK ΔglpK strain that expresses one of the genes from plasmids showed DHA kinase activity. We concluded that all three DHA kinases, DhaK, DerK, and GlpK, are involved in DHA metabolism of G. thailandicus. KEY POINTS: ⢠Dihydroxyacetone (DHA) is produced but degraded by Gluconobacter thailandicus. ⢠Phosphorylation rather than reduction is the first committed step in DHA metabolism. ⢠Three kinases are involved in DHA metabolism with the different properties.
Assuntos
Di-Hidroxiacetona , Gluconobacter , Trifosfato de Adenosina , GlicerolRESUMO
Gluconobacter oxydans has the unique property of a glucose oxidation system in the periplasmic space, where glucose is oxidized incompletely to ketogluconic acids in a nicotinamide cofactor-independent manner. Elimination of the gdhM gene for membrane-bound glucose dehydrogenase, the first enzyme for the periplasmic glucose oxidation system, induces a metabolic change whereby glucose is oxidized in the cytoplasm to acetic acid. G. oxydans strain NBRC3293 possesses two molecular species of type II NADH dehydrogenase (NDH), the primary and auxiliary NDHs that oxidize NAD(P)H by reducing ubiquinone in the cell membrane. The substrate specificities of the two NDHs are different from each other: primary NDH (p-NDH) oxidizes NADH specifically but auxiliary NDH (a-NDH) oxidizes both NADH and NADPH. We constructed G. oxydans NBRC3293 derivatives defective in the ndhA gene for a-NDH, in the gdhM gene, and in both. Our ΔgdhM derivative yielded higher cell biomass on glucose, as reported previously, but grew at a lower rate than the wild-type strain. The ΔndhA derivative showed growth behavior on glucose similar to that of the wild type. The ΔgdhM ΔndhA double mutant showed greatly delayed growth on glucose, but its cell biomass was similar to that of the ΔgdhM strain. The double mutant accumulated intracellular levels of NAD(P)H and thus shifted the redox balance to reduction. Accumulated NAD(P)H levels might repress growth on glucose by limiting oxidative metabolisms in the cytoplasm. We suggest that a-NDH plays a crucial role in redox homeostasis of nicotinamide cofactors in the absence of the periplasmic oxidation system in G. oxydansIMPORTANCE Nicotinamide cofactors NAD+ and NADP+ mediate redox reactions in metabolism. Gluconobacter oxydans, a member of the acetic acid bacteria, oxidizes glucose incompletely in the periplasmic space-outside the cell. This incomplete oxidation of glucose is independent of nicotinamide cofactors. However, if the periplasmic oxidation of glucose is abolished, the cells oxidize glucose in the cytoplasm by reducing nicotinamide cofactors. Reduced forms of nicotinamide cofactors are reoxidized by NADH dehydrogenase (NDH) on the cell membrane. We found that two kinds of NDH in G. oxydans have different substrate specificities: the primary enzyme is NADH specific, and the auxiliary one oxidizes both NADH and NADPH. Inactivation of the latter enzyme in G. oxydans cells in which we had induced cytoplasmic glucose oxidation resulted in elevated intracellular levels of NAD(P)H, limiting cell growth on glucose. We suggest that the auxiliary enzyme is important if G. oxydans grows independently of the periplasmic oxidation system.