Development and validation of a green and sustainable procedure for the preparation of Perilla frutescens extracts.

A procedure combining supercritical CO2 and ultrasound-assisted (USC-CO2) extraction was developed to obtain rosmarinic acid (RA)-rich extracts from Perilla frutescens. Based on extraction yields and efficiencies, USC-CO2 was considered the best extraction method among the methods studied for obtaining RA from P. frutescens. The constant extraction rate period and the falling extraction rate period for USC-CO2 extraction of P. frutescens were 45 and 96 min long, respectively, and they were significantly shorter than those of traditional SC-CO2 (TSC-CO2) extraction. Furthermore, mass transfer coefficients were derived using the Sovová model for the fluid and solid phases from USC-CO2 extraction, with values of 9.752 × 10-3 and 4.203 × 10-3 min-1, respectively, which were obviously higher than those for TSC-CO2 extraction. Consequently, the theoretical solubilities of RA in the supercritical solvents used in dynamic USC-CO2 and TSC-CO2 extractions were estimated and found to be well correlated using three density-based models.

A green approach for the extraction and characterization of oridonin and ursolic and oleanolic acids from Rabdosia rubescens and its kinetic behavior.

An ultrasound-assisted supercritical carbon dioxide (USC-CO2) procedure was developed for the extraction of ursolic acid, oleanolic acid and oridonin from Rabdosia rubescens, with yields that were 9.84-10.46 and 15.43-21.10% higher than those of the conventional SC-CO2 and heat-reflux extractions, respectively. USC-CO2 uses a shorter extraction time (1.83-2.09 times) and less organic solvent (3.39-173.25 times) to operate at a lower extraction temperature (5-16 °C). The dominant component in the extract was oridonin, which may indicate that the kinetic behavior in the extraction system is predominated by that of oridonin. Furthermore, the USC-CO2 and conventional SC-CO2 dynamic extraction kinetics of oridonin from R. rubescens were well described by the second-order rate and Fick's second law models. The extraction rate constant, energy of activation for diffusion, Biot number and thermodynamic parameters were deduced from the data obtained. These results provide valuable insights into the USC-CO2 and conventional SC-CO2 procedures.

Development and characterization of a green procedure for apigenin extraction from Scutellaria barbata D. Don.

This study compared the use of ultrasound-assisted supercritical CO2 (USC-CO2) extraction to obtain apigenin-rich extracts from Scutellaria barbata D. Don with that of conventional supercritical CO2 (SC-CO2) extraction and heat-reflux extraction (HRE), conducted in parallel. This green procedure yielded 20.1% and 31.6% more apigenin than conventional SC-CO2 extraction and HRE, respectively. Moreover, the extraction time required by the USC-CO2 procedure, which used milder conditions, was approximately 1.9 times and 2.4 times shorter than that required by conventional SC-CO2 extraction and HRE, respectively. Furthermore, the theoretical solubility of apigenin in the supercritical fluid system was obtained from the USC-CO2 dynamic extraction curves and was in good agreement with the calculated values for the three empirical density-based models. The second-order kinetics model was further applied to evaluate the kinetics of USC-CO2 extraction. The results demonstrated that the selected model allowed the evaluation of the extraction rate and extent of USC-CO2 extraction.

Regulatory Efficacy of Brown Seaweed Lessonia nigrescens Extract on the Gene Expression Profile and Intestinal Microflora in Type 2 Diabetic Mice.

SCOPE: In this study, the antidiabetic activity of Lessonia nigrescens ethanolic extract (LNE) is investigated in streptozotocin (SZT)-induced type 2 diabetic mice fed with a high-sucrose/high-fat diet. METHODS AND RESULTS: Ultra high performance liquid chromatography coupled with photo-DAD and electospray ionization-mass spectrometry (ESI-MS) is employed to analyze the major compounds in LNE. The components of the intestinal microflora in type 2 diabetic mice are analyzed by high-throughput next-generation 16S rRNA gene sequencing. Fasting blood glucose levels in diabetic mice are significantly decreased after LNE administration. The histology reveals that LNE could protect the cellular architecture of liver and kidney. LNE treatment significantly increases Bacteroidetes and decreases Firmicutes populations in intestinal microflora. Specifically, It could selectively enrich the amounts of beneficial bacteria, Barnesiella, as well as reduce the abundances of Clostridium and Alistipes. The increased gene and protein expression levels of phosphatidylinositol 3-kinase (PI3K) in the liver are observed in LNE treatment groups, while the expressions of c-Jun N-terminal kinase (JNK) are significantly downregulated. CONCLUSION: The above findings suggest that LNE could be considered as a functional food for reducing blood glucose and regulating intestinal microflora.

Hepatoprotective effects of raspberry (Rubus coreanus Miq.) seed oil and its major constituents.

Raspberry seed is a massive byproduct of raspberry juice and wine but usually discarded. The present study employed a microwave-assisted method for extraction of raspberry seed oil (RSO). The results revealed that omega-6 fatty acids (linoleic acid and γ-linolenic acid) were the major constituents in RSO. Cellular antioxidant enzyme activity such as superoxide dismutase (SOD), glutathione peroxidase (GPx), and catalase (CAT) were investigated in HepG2 cells treated with RSO. Induction of the synthesis of several antioxidants in H2O2-exposed HepG2 cells was found. RSO increased the enzyme activity of SOD, CAT, and GPx in H2O2-exposed HepG2. Furthermore, RSO inhibited the phosphorylation of upstream mitogen-activated protein kinases (MAPK) such as c-Jun N-terminal kinase (c-JNK) and extracellular signal-regulated kinase (ERK). Taken together, the possible mechanisms to increase antioxidant enzyme activities in HepG2 may through the suppression of ERK and JNK phosphorylation. Raspberry seed oil exhibited good effects on the activities of the intracellular antioxidant enzymes and seems to protect the liver from oxidative stress through the inhibition of MAPKs.

Evaluation of occupation hot exposure in industrial workplaces in a subtropical country.

OBJECTIVES: The objective of this study has been to evaluate the occupational heat exposure of 12 workers at 5 plants in a subtropical country. MATERIAL AND METHODS: The heat stresses and strain on workers in 5 plants were assessed by the International Organization for Standardization (ISO) 7243 index (wet bulb globe temperature - WBGT) and the ISO 7933 index (maximum allowable exposure time - Dlim). RESULTS: Results indicated that 42% of the subjects (5 workers) surpassed the WBGT limits. According to the Dlim, 42% of the subjects could not continue working in the hot environments. The relationships between the various heat stress indices and the WBGT index were also correlated. However, further studies from different heat environments and more subjects should be performed. CONCLUSIONS: The sensitive dependence of skin temperature on meteorological and physiological indices for each subject was clearly observed. Obviously, the heart rate response to metabolic rate was much greater than that caused by environmental heat alone. The exponential relationship between workers' duration-limited exposure time, predicted by various estimated criteria, and WBGT were also found. Int J Occup Med Environ Health 2017;30(3):379-395.

Production of oridonin-rich extracts from Rabdosia rubescens using hyphenated ultrasound-assisted supercritical carbon dioxide extraction.

BACKGROUND: Among active components in Rabdosia rubescens, oridonin has been considered a key component and the most valuable compound because it has a wide range of activities beneficial to human health. To produce a high-quality oridonin extract, an alternative hyphenated procedure involving an ultrasound-assisted and supercritical carbon dioxide (HSC-CO2 ) extraction method to extract oridonin from R. rubescens was developed in this study. Fictitious solubilities of oridonin in supercritical CO2 (SC-CO2 ) with ultrasound assistance were measured by using the dynamic method at temperatures ranging from 305.15 K to 342.15 K over a pressure range of 11.5 to 33.5 MPa. RESULTS: Fictitious solubilities of oridonin at different temperatures and pressures were over the range of 2.13 × 10-6 to 10.09 × 10-6 (mole fraction) and correlated well with the density-based models, including the Bartle model, the Chrastil model, the Kumar and Johnston model and the Mendez-Santiago and Teja model, with overall average absolute relative deviations (AARDs) of 6.29%, 4.39%, 3.12% and 5.07%, respectively. CONCLUSION: Oridonin exhibits retrograde solubility behaviour in the supercritical state. Fictitious solubility data were further determined and obtained a good fit with four semi-empirical models. Simultaneously, the values of the total heat of solution, vaporisation and solvation of oridonin were estimated. © 2016 Society of Chemical Industry.

Extraction of α-humulene-enriched oil from clove using ultrasound-assisted supercritical carbon dioxide extraction and studies of its fictitious solubility.

Clove buds are used as a spice and food flavoring. In this study, clove oil and α-humulene was extracted from cloves using supercritical carbon dioxide extraction with and without ultrasound assistance (USC-CO2 and SC-CO2, respectively) at different temperatures (32-50°C) and pressures (9.0-25.0MPa). The results of these extractions were compared with those of heat reflux extraction and steam distillation methods conducted in parallel. The extracts obtained using these four techniques were analyzed using gas chromatography and gas chromatography/mass spectrometry (GC/MS). The results demonstrated that the USC-CO2 extraction procedure may extract clove oil and α-humulene from clove buds with better yields and shorter extraction times than conventional extraction techniques while utilizing less severe operating parameters. Furthermore, the experimental fictitious solubility data obtained using the dynamic method were well correlated with density-based models, including the Chrastil model, the Bartle model and the Kumar and Johnston model.

5-Fluorouracil-Induced Apoptosis Changes in Cultured Corneal Epithelial Cells.

PURPOSE: Repeated subconjunctival injections with 5-fluorouracil (5-FU) after trabeculectomy are used in glaucoma patients for the inhibition of overproliferation in wound site. Thus, a certain amount of the drug may penetrate into epithelial layer, where it causes toxicity to corneal epithelial cells. The aim of this study was to evaluate the toxic effects of 5-FU and mechanisms of drug-induced apoptosis in cultured corneal epithelial cells. METHODS: Cellular damage and the caspase pathway were estimated with a 3-(4,5-dimethylthiazol-2-yl)-2,5-diphenyltetrazolium bromide (MTT) assay. The apoptotic characteristics were detected by flow cytometry, a TUNEL test, and western blotting in cultured corneal epithelial cells. RESULTS: The results indicated that 5-FU was toxic to corneal epithelial cells in a time- and dose-dependent manner. Pretreatment with a general caspase inhibitor (Z-VAD-FMK), a caspase-8 inhibitor (Z-IETD-FMK), and a caspase-9 inhibitor (Z-LEHD-FMK) reversed 5-FU-induced cellular damage. Following exposure to 5-FU, a flow cytometric assay with MitoLight dye demonstrated the significant loss of mitochondrial membrane potential. A positive TUNEL test revealed that cellular DNA apoptosis occurred following exposure to 0.5, 1, and 5 mg/mL 5-FU for 15 h. Positive annexin V-FITC and negative propidium iodide (PI) staining indicated that the cell membrane exhibited apoptosis upon exposure to 1 and 5 mg/mL 5-FU for 15 h. The western blot assay demonstrated upregulation of the p21 protein but downregulation of the Bcl-2 proteins induced by 5-FU. CONCLUSION: These data reveal that 5-FU-induced cellular apoptosis in corneal epithelial cells may be mediated through caspase-8, caspase-9, and mitochondria-regulated pathways, as well as by upregulation of p21 and downregulation of Bcl-2-dependent signal transduction pathways.

Determination of Oleanolic and Ursolic Acids in Hedyotis diffusa Using Hyphenated Ultrasound-Assisted Supercritical Carbon Dioxide Extraction and Chromatography.

Oleanolic acid (OA) and ursolic acid (UA) were extracted from Hedyotis diffusa using a hyphenated procedure of ultrasound-assisted and supercritical carbon dioxide (HSC-CO2) extraction at different temperatures, pressures, cosolvent percentages, and SC-CO2 flow rates. The results indicated that these parameters significantly affected the extraction yield. The maximal yields of OA (0.917 mg/g of dry plant) and UA (3.540 mg/g of dry plant) were obtained at a dynamic extraction time of 110 min, a static extraction time of 15 min, 28.2 MPa, and 56°C with a 12.5% (v/v) cosolvent (ethanol/water = 82/18, v/v) and SC-CO2 flowing at 2.3 mL/min (STP). The extracted yields were then analyzed by high performance liquid chromatography (HPLC) to quantify the OA and UA. The present findings revealed that H. diffusa is a potential source of OA and UA. In addition, using the hyphenated procedure for extraction is a promising and alternative process for recovering OA and UA from H. diffusa at high concentrations.

Toona sinensis leaf extract has antinociceptive effect comparable with non-steroidal anti-inflammatory agents in mouse writhing test.

BACKGROUND: The antinociceptive effect of an aqueous extract from the leaves of Toona sinensis (TS, [A. Juss., M. Roem.]) was studied using the writhing test in mice. METHODS: Different extraction fractions from TS leaf extracts (TSL1 to TSL5) were administered orally 1 h before intraperitoneal injection of acetic acid. RESULTS: After treatment with TSL1, TSL2, TSL3, TSL4, and TSL5 at a dose of 1 g/kg, the respective writhing responses were 39.9% (P < 0.001), 19.9% (P < 0.05), 11.7% (P = 0.052), 8.1% (P = 0.188), and 11.4% (P = 0.057) lower than the control group. Mice treated with TSL1 at 1 g/kg (39.9%, P < 0.001), 0.3 g/kg (38.0%, P < 0.001), 0.1 g/kg (46.9%, P < 0.001), and 0.03 g/kg (31.1%, P < 0.001) had significantly lower writhing responses compared with control mice. A time-course experiment was performed, which involved oral administration of TSL1 (0.1 g/kg) at 0, 0.5, 1, 2, and 6 h before acetic acid intraperitoneal injection. The most effective dose of TSL1 was 0.1 g/kg orally, with the effect beginning 30 min before treatment and persisting until 6 h. CONCLUSIONS: This study showed that TS has anti-visceral pain properties comparable with those of rofecoxib (a cyclooxygenase-2 inhibitor) and diclofenac, which suggests promise for the treatment of intractable visceral pain in humans.

Ultrasound-assisted extraction and quantitation of oils from Syzygium aromaticum flower bud (clove) with supercritical carbon dioxide.

This study evaluated ultrasound-assisted supercritical carbon dioxide (USC-CO2) extraction for determining the extraction yields of oils and the contents of eugenol, ß-caryophyllene, eugenyl acetate and α-humulene from clove buds. Compared to traditional SC-CO2 extraction, USC-CO2 extraction might provide a 13.5% increase in the extraction yield for the oil while utilizing less severe operating parameters, such as temperature, pressure, CO2 flow rate and the time consumed by the process. Our results were comparable to those obtained using the heat reflux extraction method, though the yield was improved by 20.8% using USC-CO2. In kinetic studies, the USC-CO2 extraction of clove oil followed second-order kinetics. The activation energy for the oil extraction was 76.56kJ/mol. The USC-CO2 procedure facilitated the use of mild extraction conditions, improved extraction efficiency and the quality of products and is a potential method for industry.

Development of a hyphenated procedure of heat-reflux and ultrasound-assisted extraction followed by RP-HPLC separation for the determination of three flavonoids content in Scutellaria barbata D. Don.

A hyphenated procedure of heat-reflux and ultrasound-assisted extraction (HUAE), and an accurate high-performance liquid chromatographic (HPLC) method were developed for the determination of apigenin, baicalin and luteolin content in Scutellaria barbara D. Don. The suitable HUAE conditions for the extraction of target compounds from the herb were identified as an ultrasonic frequency of 40kHz, power of 185W, duty cycle of 75% (intermittent sonication), mean particle size of 0.355mm, extraction temperature of 50°C, ratio of solvent to raw material of 12:1 (mL/g), ethanol concentration of 60% (v/v), extraction time of 30min and three cycles. Compared with a traditional heat-reflux extraction method, the proposed method reduced the extraction time, extraction temperature and solvent consumption. Also, this HUAE method achieved superior apigenin, baicalin and luteolin yields. Furthermore, the developed HUAE-HPLC method was applied successfully for the simultaneous evaluation of three bioactive compounds in five samples of S. barbara D. Don obtained from different geographical regions. These results clearly demonstrated that the combined HUAE-HPLC process is feasible in the future commercialized manufacture of this highly valuable Chinese herbal medicine.

Development and validation of a modified ultrasound-assisted extraction method and a HPLC method for the quantitative determination of two triterpenic acids in Hedyotis diffusa.

In the present study, the oleanolic acid (OA) and ursolic acid (UA) contents ofHedyotis diffusa and H. corymbosa were determined by a rapid, selective and accurate method combining modified ultrasound-assisted extraction (MUAE) and HPLC. Compared with traditional extraction methods, MUAE reduced the extraction time, the extraction temperature and the solvent consumption and maximized the extraction yields of OA and UA. Furthermore, the combined MUAE-HPLC method was applied to quantitate OA and UA in plant samples and exhibited good repeatability, reproducibility and stability. The mean recovery studies (one extraction cycle) for OA and UA were between 91.3 and 91.7% with RSD values less than 4.5%. The pioneer method was further applied to quantitate OA and UA in six samples of H. diffusa and five samples of H. corymbosa. The results showed that the OA and UA content in the samples from different sources were significantly different. This report is valuable for the application of H. diffusa and H. corymbosa obtained from different regions in clinical research and pharmacology.

Optimisation of an ultrasound-assisted extraction followed by RP-HPLC separation for the simultaneous determination of oleanolic acid, ursolic acid and oridonin content in Rabdosia rubescens.

INTRODUCTION: Rabdosia rubescens is a commonly used herb in traditional Chinese medicine and contains diterpenoids, triterpenoids and various other compounds. Among these components, oridonin, oleanolic acid and ursolic acid have gained considerable interest concerning anti-cancer activities. However, there is no suitable currently available method for the simultaneous evaluation of these three bioactive compounds in R. rubescens. OBJECTIVE: To develop an optimised ultrasound-assisted extraction (UAE) method and an efficient HPLC method for the simultaneous evaluation of the three bioactive compounds in R. rubescens. METHODOLOGY: Various parameters that can potentially affect the UAE process were investigated and optimised. HPLC operating conditions were also optimised, and the chromatographic separation was performed on a C(18) -column with an acetonitrile-water gradient as the mobile phase. RESULTS: Validation of the HPLC technique developed showed that the method has good linearity, sensitivity, precision and accuracy. The combined UAE-HPLC method was applied to quantitate the amount of oridonin, oleanolic acid and ursolic acid in the plant sample and exhibited good repeatability (RSD (%) < 3.9), reproducibility (RSD (%) < 5.9), stability (RE (%) < 1.4) and recovery (mean (%) > 92.4). Furthermore, the combined UAE-HPLC method was applied successfully to the extraction and determination of oridonin, oleanolic acid and ursolic acid content in samples obtained from different geographical regions, which is the first time that this comparison has been investigated. CONCLUSION: The combined UAE-HPLC process is a fast, convenient and appropriate method for the quantitative analysis of these three compounds in R. rubescens.

B1, a novel topoisomerase II inhibitor, induces apoptosis and cell cycle G1 arrest in lung adenocarcinoma A549 cells.

In our previous studies, we demonstrated that 2,6-bis-(2-chloroacetamido) anthraquinone (B1) showed a highly significant cytotoxic effect. However, its influence in the cell cycle and apoptotic induction effects has not been investigated yet. Here we report the antiproliferative effect of B1, for which IC50 values were 0.57 µmol/l for lung cancer A549 cells, 0.63 µmol/l for colon cancer HT-29 cells, and 0.53 µmol/l for breast cancer MCF-7 cells. DNA topoisomerase II (Topo II), an essential enzyme in DNA synthesis and meiotic division, is highly expressed in cancer cells. Some currently used clinical anticancer drugs (doxorubicin and mitoxantrone) targeting Topo II are very effective antineoplastic agents. B1, sharing the basic structure of known Topo II inhibitors, demonstrated a significant inhibitory effect on Topo II bioactivity. In A549 cells, B1 increased apoptotic cell population with induction of Fas, Bax, and cleaved poly(ADP-ribose) polymerase and by reduction of Bcl-2 expression. Moreover, cell cycle analysis indicated that B1 induced G1 phase arrest through modulation of G1 cell cycle regulatory proteins, such as the downregulation of cyclin D1 and upregulation of Cip/p21, Kip1/p27, and p53. Thus, our study suggests that B1, with the ability to inhibit Topo II activity and cause cell cycle G1 arrest and apoptosis, has potential as a novel anticancer agent.

Effects of Toona sinensis leaf extract on lipolysis in differentiated 3T3-L1 adipocytes.

The effect of substances extracted from Toona sinensis leaves with 50% alcohol solution on lipolysis was investigated in cultured 3T3-L1 differentiated adipocytes. The amount of glycerol released from cells into culture medium was used to measure lipolysis activity. Glycerol release was increased by Toona sinensis leaf extract in a dose-dependent and time-dependent manner. Following treatment of 3T3-L1 adipocyte cells with various concentrations of Toona sinensis leaf extract (0.001, 0.01, and 0.1 mg/mL) for 6 hours, the amounts of glycerol released from 3T3-L1 cells increased from a control value of 99 nmol/mg protein to 127, 144, and 154 nmol/mg protein, respectively. The lipolytic effect of Toona sinensis leaf extract was not inhibited by pretreatment of cells with cycloheximide, econazole, baicalein, or indomethacin. However, the lipolytic activity induced by Toona sinensis leaf extract was diminished by dibutyryl cyclic adenosine-5'-monophosphate (dibutyryl cAMP) and the protein kinase C inhibitor calphostin C. These results indicate that the lipolytic effect induced by Toona sinensis leaf substances may be involved in the protein kinase C pathway and may be down-regulated by cAMP.

Enhancement of glucose uptake in 3T3-L1 adipocytes by Toona sinensis leaf extract.

The effects of substances extracted from Toona sinensis leaves, using 50% alcohol/water, on cellular [3H]-2-deoxyglucose uptake in differentiated cultured 3T3-L1 adipocytes were investigated. Following treatment of cells with 0.001, 0.01, or 0.1 mg/mL extracts for 60 minutes, [3H]-2-deoxyglucose uptake increased from a basal value of 0.23 nmol/min/mg protein to 0.30, 0.33, and 0.38 nmol/min/mg protein, respectively. In insulin-stimulated cells, cellular [3H]-2-deoxyglucose uptake was enhanced by Toona sinensis leaf extract from a basal value of 0.35 nmol/min/mg protein to 0.41, 0.46, and 0.52 nmol/min/mg protein, respectively. Cellular glucose uptake was also enhanced by Toona sinensis leaf extract after incubation of cells with 20 mM glucose for 48 hours. Cellular glucose uptake with a combination of Toona sinensis leaf extract and insulin was significantly inhibited by pretreatment of cells with the protein synthesis inhibitor cycloheximide and the protein kinase C inhibitor calphostin C in normal-, medium- and high-glucose media. However, the glucose uptake-enhancing effect of Toona sinensis leaf extract was not diminished by cycloheximide and calphostin C in the absence of insulin. These results indicate that enhancement of cellular glucose uptake by Toona sinensis leaf extract in basal and insulin-stimulated 3T3-L1 adipocytes may be mediated by distinct mechanisms.