Effect of biotin on currently used Beckman thyroglobulin assay and newly reformulated thyroglobulin assay not affected by biotin.

OBJECTIVES: Biotin causes negative interference with thyroglobulin measurement using the Access thyroglobulin assay. Recently, Beckman reformulated the thyroglobulin assay to overcome biotin interference. We investigated the effect of biotin on both current and newly formulated assays. METHODS: Four serum pools were prepared using specimens containing various amounts of thyroglobulin. Then aliquots of each pool were supplemented with various amounts of biotin, and thyroglobulin concentrations were measured by both the current and the new assays. In addition, 3 volunteers ingested 10 mg biotin, and specimens were drawn before and 2 hours after taking biotin. Thyroglobulin concentrations before and 2 hours after taking biotin were measured by both assays. RESULTS: In the presence of biotin, thyroglobulin concentrations were reduced significantly using the current assay, but no significant change was observed using the newly formulated assay. We observed similar results in vivo. CONCLUSIONS: The newly formulated thyroglobulin assay by Beckman is free from biotin interference.

Elevated free thyroxine and free triiodothyronine probably caused by high-dose biotin intake in a patient with Graves' disease: a case report.

Biotin is a water-soluble vitamin that acts as a cofactor for carboxylase, and is often used as a component in several immunoassays. We present a case of a 46-year-old male with Graves' disease (GD) who revealed elevated free thyroxine (FT4) and free triiodothyronine (FT3) levels after high-dose biotin intake. Levels of these hormones had been within the reference range when he was on thiamazole 5 mg/day for 7 years; however, the levels increased from 1.04 to 2.20 ng/dL and from 3.05 to 9.84 pg/mL for FT4 and FT3, respectively, after he started taking biotin 72 mg/day. Despite these high levels, his symptoms and the other laboratory results, including the thyroid-stimulating hormone level, did not suggest GD relapse. His thyroid hormone data was decreased and returned within the reference range immediately after the laboratory assays for FT3 and FT4 had been coincidentally changed from those containing streptavidin-biotin complexes to biotin-free ones. Biotin interference, which is caused by high-dose biotin intake and immunoassays using some form of streptavidin-biotin complex, is sometimes clinically problematic, giving high or low results. To our knowledge, this is the first case report of a patient with GD on high-dose biotin receiving high thyroid hormone level results that were initially misunderstood as an aggravation of the disease; there are some reports of misdiagnosis of hyperthyroidism due to biotin administration. Unexpected fluctuations in thyroid function test results in patients with GD should be checked for biotin intake, immunoassays and the limiting concentration of biotin to avoid misdiagnosis of relapse.

Biotin induced biochemical hyperthyroidism: a case report and review of the literature.

BACKGROUND: Biotin is a commonly used supplement for hair, nail, and skin. Recent literature suggests that high-dose biotin therapy for neurological diseases like Multiple sclerosis can interfere with lab results that use biotin/streptavidin immunoassay, called biotin interference. Biotin interference can affect thyroid lab results, giving biochemical hyperthyroidism. CASE PRESENTATION: Our patient, a 64-year-old white man with a known history of multiple sclerosis, presented with elevated free T3, free T4, and low TSH that resembled hyperthyroidism. He had no symptoms of hyperthyroidism except some fatigue and tachycardia on the first encounter. He was started on anti-thyroid medications. He was then re-evaluated since his lab results remained the same after two months of anti-thyroid medications. It was found that he was on biotin, 10000mcg/day, for his multiple sclerosis. Biotin was discontinued, and five days later his lab results returned to normal values. CONCLUSION: The lack of knowledge of biotin use by patients can lead to misdiagnosis of patients' thyroid lab results and improper management. Awareness about biotin interference and abnormal thyroid lab values should be a priority among clinicians and the public. If the biotin is discontinued on time, such misdiagnosis can be avoided.

Development and Evaluation of an Anti-Biotin Interference Method in Biotin-Streptavidin Immunoassays.

The strong non-covalent interaction between biotin and streptavidin places streptavidin-based assays, used by many laboratories, at an increased risk of interference by biotin. At present, a few manufacturers have developed fully automated anti-biotin interference methods, although compared with many detection platforms, these remain insufficient. Additionally, there is a need for more methods that can achieve fully automated anti-biotin interference. We sought to develop and evaluate a new biotin interference-resisting method based on a biotin-streptavidin chemiluminescence immunoassay. Streptavidin-coated magnetic microparticles (M) of different concentrations were prepared and tested for their biotin-resistance capabilities in an automated setting (Cobas e 601). The precision, accuracy, and detection capability were also assessed. Higher concentrations of M were found to have a stronger ability to resist biotin interference. A 2.16 mg/mL concentration of M was able to resist 500 ng/mL of biotin in samples while simultaneously having a relatively weak shielding effect on the optical signals. Moreover, the total precision and accuracy of this method, designated as M3, met acceptable standards. M3 has an improved ability to resist biotin interference, can achieve full automation, and its detection performance can meet the general laboratory quality requirements.

Serum biotin interference: A troublemaker in hormone immunoassays.

OBJECTIVES: Biotin therapy can affect the results of many immunoassay procedures. The present study investigates biotin's interference on 25-hydroxy vitamin D (25-OHD), parathyroidhormone (PTH) and thyroid-stimulating hormone (TSH) tests using four different assay systems and biotin neutralization. DESIGN AND METHODS: Enrolled in the study were 50 children diagnosed with biotinidase deficiency (BTD) undergoing treatment with biotin (5-20 mg/day) who were subjected to a series of analyses involving 25-OHD (Roche Diagnostics assays, Beckman Coulter assays, HPLC, LC/MS-MS), TSH, PTH (Roche Diagnostics assays, Beckman Coulter assays) and biotin (LC/MS-MS), before and after biotin neutralization with Streptavidin-coated magnetic particles (SMP). RESULTS: The median biotin concentration was found to be 175.2 [94.0-307.1] µg/L. There was no significant difference in the 25-OHD results before and after neutralization with the Beckman Coulter, HPLC and LC-MS/MS assays. In contrast, the median 25-OHD level was seen to decrease from 90.2 [35.9-105.3] ng/mL to 29.1 [22.6-37.6] ng/mL after neutralization with the Roche assay (p < 0.0001). While there was no statistically significant difference in the values recorded before and after neutralization in PTH analysis using Beckman assay, the median PTH levels increased from 7.8 [1.6-21.6] pg/mL to 28.2 [22.5-41.9] pg/mL after neutralization with the Roche assay (p < 0.0001). The cut-off values at which serum biotin interfered in the Roche assay PTH test, with 25-OHD levels determined as 51.4 µg/L and 62.9 µg/L, respectively. A significant increase was detected in the TSH levels analyzed with a Roche assay after neutralization (from 2.36 [1.85-3.00] mIU/L to 2.74 [1.93-3.70] mIU/L, p < 0.0001). CONCLUSIONS: The PTH, 25-OHD and TSH results were found to be affected by high biotin concentrations in Roche assays, leading to a risk of misdiagnosis, although SMP neutralization can suppress any such interference efficiently.

Pseudo-hyperthyroidism: Biotin interference in a case with renal failure.

Introduction: Biotin treatment causes false-low or false-high results in some immunoassays methods. This phenomenon is called as biotin interference. In the present article, a seven-month-old male, with renal failure and laboratory hyperthyroidism due to biotin interference is presented. Case report: High free T4 (fT4), free T3 (fT3), anti-thyroid peroxidase antibody (anti-TPO), anti-thyroglobulin antibody (anti-TG) and low thyroid stimulating hormone (TSH) levels were detected in a seven-month-old male patient who has metabolic acidosis, renal failure, and suspected of metabolic disease. Anti-thyroid drug therapy was started. However, when he was re-evaluated due to the absence of euthyroidism with anti-thyroid therapy (methimazole 0.8 mg/kg /day), it was found that the patient had been given 20 mg/day biotin for acidosis for two months. Biotin interference was considered in hormone measurement. Thyroid function tests were found to be normal 12 days after discontinuation of biotin therapy. Conclusion: Immunoassay measurements which use biotin should be done 2-7days after the last dose of biotin in patients under biotin treatment, but this time may need be much longer in renal failure patients. During this period or if the biotin therapy cannot be stopped, alternative methods should be preferred for analysis.

Evaluating the performance of an updated high-sensitivity troponin T assay with increased tolerance to biotin.

OBJECTIVES: Biotin >20 ng/mL may interfere with the Elecsys® Troponin T-high sensitive assay (cTnT-hs; Roche Diagnostics International Ltd). We evaluated the performance of an updated assay, cTnT-hs*, which was designed to reduce biotin interference. METHODS: cTnT-hs* assay performance was assessed using up to two applications (18 min/9 min) on three analyzers (cobas e 411/cobas e 601/cobas e 801). Biotin interference was determined by measuring recovery in an 11-sample series dilution with biotin ranging from 0-3600 ng/mL. Repeatability/reproducibility were evaluated in five serum sample pools (n=75 each). Method comparisons tested: cTnT-hs* vs. cTnT-hs (18 min/cobas e 601); cTnT-hs* assay 18 vs. 9 min (cobas e 601); cTnT-hs* (18 min) on cobas e 601 vs. cobas e 411 and cobas e 601 vs. cobas e 801. Concordance at the 99th percentile decision limit between cTnT-hs* and cTnT-hs (9 min/cobas e 601) was calculated using 300 lithium-heparin plasma samples and a 14 ng/L assay cutoff. RESULTS: cTnT-hs* assay (18 min/cobas e 601) recovery was ≥96% for biotin ≤1250 ng/mL. Across all applications/analyzers, coefficients of variation for repeatability/reproducibility with the cTnT-hs* assay were <5% in most serum sample pools (mean cardiac troponin T: 8.528-9484 ng/L). High correlation (Pearson's r=1.000) was demonstrated for all method comparisons. Concordance at the 99th percentile decision limit was high between the cTnT-hs* and cTnT-hs assays. CONCLUSIONS: The updated cTnT-hs* assay may provide greater tolerance to biotin interference, and shows good analytical and clinical agreement/concordance with the previous cTnT-hs assay.

AACC Guidance Document on Biotin Interference in Laboratory Tests.

BACKGROUND: Laboratory tests that use streptavidin-biotin binding mechanisms have the potential to be affected by high circulating biotin concentrations, which would produce positive and negative interference in biotinylated competitive and noncompetitive (sandwich) immunoassays, respectively. Consumption of high-dose biotin supplements for cosmetic or health-related reasons has drawn attention to biotin interference in clinical laboratory tests. Case reports and in vivo studies show that ingestion of supplemental biotin can cause clinically significant errors in select biotinylated immunoassays. CONTENT: This AACC Academy document is intended to provide guidance to laboratorians and clinicians for preventing, identifying, and dealing with biotin interference. In vivo and in vitro spiking studies have demonstrated that biotin concentrations required to cause interference vary by test and by manufacturer. This document includes discussion of biotin's mechanisms for interference in immunoassays, pharmacokinetics, and results of in vitro and in vivo studies and cites examples of assays known to be affected by high biotin concentrations. This document also provides guidance recommendations intended to assist laboratories and clinicians in identifying and addressing biotin interference in laboratory testing. SUMMARY: The recent increase in the use of high-dose biotin supplements requires laboratorians and clinicians to be mindful of the potential for biotin interference in biotinylated immunoassay-based laboratory tests. Laboratories, clinicians, regulators, and patients should work together to ensure accurate laboratory results. Laboratories have several options for identifying suspected biotin interference in specimens. Alternatively, the relatively fast elimination of biotin allows the potential for rapid follow-up specimen analysis if necessary.

Biotin supplementation causes erroneous elevations of results in some commercial serum 25-hydroxyvitamin d (25OHD) assays.

The Vitamin D External Quality Assessment Scheme (DEQAS) distributes serum samples globally, on a quarterly basis, to assess participants' performance of specific methods for 25-hydroxyvitamin D (25OHD) and 1,25-dihydroxyvitamin D (1,25-(OH)2D). DEQAS occasionally circulates samples containing high levels of substances found in certain clinical situations e.g. 25-OHD2, 24,25-(OH)2D3, hypertriglyceridemia. The increased availability and use of health supplements containing biotin has led to case reports of assay interference in methods utilizing a biotin-streptavidin detection system. In October 2018, DEQAS included a serum sample (545) containing exogenous biotin (concentration =586 µg/L) which was analyzed by a total of 683 laboratories using 35 different methods. The same serum sample (544) without exogenous biotin was also included in the 5-sample set. All methods (760 laboratories) performed satisfactorily on sample 544 giving an All-Laboratory Trimmed Mean = 50.2 ± 6.5 nmol/L (±SD, CV = 12.9 %). The target value for this sample 544 (& 555) was 47.4 nmol/L as determined by Centers for Disease Control and Prevention (CDC) Atlanta, Georgia using their LC-MS/MS reference method. In contrast, #545 containing the exogenous biotin was reported by only 683 laboratories and gave an All-Laboratory Trimmed Mean = 66.8 ± 37.6 nmol/L (±SD, CV = 56.3 %). As expected, LC-MS/MS methods (143 labs) reported similar results for both 544 = 48.9 ± 4.4 nmol/L (±SD) and 545 = 48.3 ± 4.5 nmol/L (±SD) showing that assays involving chromatographic steps are unaffected by the presence of biotin. Several of the antibody-based assays including Abbott Architect, DiaSorin Liaison, Beckman Unicel and Siemens Centaur are also unaffected by the addition of biotin. Two assays, IDS-iSYS and Roche Total 25OHD, both of which use biotin-streptavidin, exhibit biotin interference yielding values with a significant positive bias for 545 of 102.6 nmol/L ± 78.7 nmol/L (±SD) and 517.8 nmol/L ± 209.8 nmol/L (±SD) respectively. Interestingly, the failure to report sample 545 data from 77 laboratories is due solely to those running Roche Total 25OHD or Roche Vitamin D Total II assays. Given the prevalence of the adversely affected assays (25 % of DEQAS users) and the high volume of 25OHD testing, clinicians using these assays should, where possible, only measure 25OHD when patients are off biotin.

Best practices in mitigating the risk of biotin interference with laboratory testing.

Dietary biotin intake does not typically result in blood biotin concentrations that exceed interference thresholds for in vitro diagnostic tests. However, recent trends of high-dose biotin supplements and clinical trials of very high biotin doses for patients with multiple sclerosis have increased concerns about biotin interference with immunoassays. Estimates of the prevalence of high biotin intake vary, and patients may be unaware that they are taking biotin. Since 2016, 92 cases of suspected biotin interference have been reported to the US Food and Drug Administration. Immunoassays at greatest risk from biotin interference include thyroid and reproductive hormones, cardiac, and immunosuppressive drug tests. Several case studies have highlighted the challenge of biotin interference with thyroid hormone assays and the potential misdiagnosis of Graves' disease. Biotin interference should be suspected when immunoassay test results are inconsistent with clinical information; a clinically relevant biotin interference happens when the blood biotin concentration is high and the assay is sensitive to biotin. We propose a best practice workflow for laboratory scientists to evaluate discrepant immunoassay results, comprising: (1) serial dilution; (2) retesting after biotin clearance and/or repeat testing on an alternate platform; and (3) confirmation of the presence of biotin using depletion protocols or direct measurement of biotin concentrations. Efforts to increase awareness and avoid patient misdiagnosis should focus on improving guidance from manufacturers and educating patients, healthcare professionals, and laboratory staff. Best practice guidance for laboratory staff and healthcare professionals would also provide much-needed information on the prevention, detection, and management of biotin interference.

Biotin interference in immunoassays based on biotin-strept(avidin) chemistry: An emerging threat.

Biotinylated antibodies/antigens are currently used in many immunoassay formats in clinical settings for diversified analytes and biomarkers to offer high detection selectivity and sensitivity. Biotin cannot be synthesized by mammals and must be taken as an essential supplement. Normal intake of biotin from various foods and milk causes no effect on the streptavidin/biotin-based immunoassays. However, overconsumption of biotin (daily doses 100-300 mg) poses a significant problem for immunoassays using the biotin-strept(avidin) pair. Biotin interferences are noted in immunoassays of thyroid markers, drugs, hormones, cancer markers, the biomarker for cardiac function (ß-human chorionic gonadotropin), etc. The biotin level required for serious interference in test results varies significantly from test to test and cannot easily be predicted. Immunoassay manufacturers with technologies based on strept(avidin)-biotin binding must investigate the interference from biotin (up to at least 1200 ng/mL or 4.9 µM of biotin) in various formats. There is no concrete solution to circumvent the biotin interference encountered in blood samples, short of biotin removal. Considering the short half-life of biotin in the human body, patients must stop taking biotin supplements for >48 h before the test. However, this scenario is not considered for patients in emergency situations or those with biotinidase deficiency, mitochondrial metabolic disorders or multiple sclerosis. Apparently, a rapid analytical procedure for biotin is urgently needed to quantify for its interference in immunoassays using strep(avidin)-biotin chemistry. To date, there is no quick and reliable procedure for the detection of biotin at below nanomolar levels in blood and biological samples. Traditional lab-based techniques including HPLC/MS-MS cannot process an enormous number of public samples. Biosensors with high detection sensitivity, miniaturization, low cost, and multiplexing have the potential to address this issue.

Suspected Testosterone-Producing Tumor in a Patient Taking Biotin Supplements.

A perimenopausal woman presented with palpitations, hirsutism, and inability to lose weight. Laboratory tests revealed an unusual endocrine hormonal profile including pituitary hormones (TSH, ACTH, and prolactin) below reference intervals and gonadal (testosterone) and adrenal (cortisol) hormones above reference intervals. Ultimately, after a comprehensive workup including a scheduled surgical procedure, abnormal laboratories were determined due to biotin interference. Biotin (vitamin B7) is a water-soluble vitamin and essential cofactor for the metabolism of fatty acids, glucose, and amino acids. The recommended daily intake of biotin for adults is 30 µg/d. Many over-the-counter products, particularly those marketed for hair, skin, and nail growth, contain biotin 100-fold of recommended daily intake. This case is unique due to the abnormalities observed not only in the well-described TSH "sandwich" immunoassay, but also in tests for gonadal steroids, adrenal, and pituitary hormones. Falsely high as well as falsely low results can be ascribed to biotin. Competitive immunoassays (Fig. 1A)- in this case, tests used initially for serum cortisol and testosterone- can demonstrate falsely high results. Interference falsely lowers the immunometric "sandwich" immunoassay (Fig. 1B)-in this case, TSH. Biotin effect on our patient's endocrine testing led to decidedly abnormal findings, unnecessary medical referrals and diagnostic studies, and comprehensible psychological distress. Interference with one immunoassay, TSH, persisted a full 2 weeks after discontinuation of biotin; indeed, some tests demonstrate sensitivity to lesser quantities of biotin. Improved communication between patients, health care providers, and laboratory professionals is required concerning the likelihood of biotin interference with immunoassays.