Impact of dietary regime on the metabolomic profile of bovine buttermilk and whole milk powder.

INTRODUCTION: Bovine milk contains a rich matrix of nutrients such as carbohydrates, fat, protein and various vitamins and minerals, the composition of which is altered by factors including dietary regime. OBJECTIVES: The objective of this research was to investigate the impact of dietary regime on the metabolite composition of bovine whole milk powder and buttermilk. METHODS: Bovine whole milk powder and buttermilk samples were obtained from spring-calving cows, consuming one of three diets. Group 1 grazed outdoors on perennial ryegrass which was supplemented with 5% concentrates; group 2 were maintained indoors and consumed a total mixed ration diet; and group 3 consumed a partial mixed ration diet consisting of perennial ryegrass during the day and total mixed ration maintained indoors at night. RESULTS: Metabolomic analysis of the whole milk powder (N = 27) and buttermilk (N = 29) samples was preformed using liquid chromatography-tandem mass spectrometry, with 504 and 134 metabolites identified in the samples respectively. In whole milk powder samples, a total of 174 metabolites from various compound classes were significantly different across dietary regimes (FDR adjusted p-value ≤ 0.05), including triglycerides, of which 66% had their highest levels in pasture-fed samples. Triglycerides with highest levels in pasture-fed samples were predominantly polyunsaturated with high total carbon number. Regarding buttermilk samples, metabolites significantly different across dietary regimes included phospholipids, sphingomyelins and an acylcarnitine. CONCLUSION: In conclusion the results reveal a significant impact of a pasture-fed dietary regime on the metabolite composition of bovine dairy products, with a particular impact on lipid compound classes.

Whole milk dairy foods and cardiometabolic health: dairy fat and beyond.

Bovine dairy milk is a nutrient-rich matrix, but consumption of full-fat dairy food varieties has been claimed historically to be associated with poorer cardiometabolic health, a notion often attributed to the saturated fat content. However, continued investigation that includes observational studies and randomized controlled trials (RCTs) provide evidence that favorably supports full-fat dairy foods and their bioactive components on cardiometabolic health. This review addresses this controversy by examining the evidence surrounding full-fat dairy foods and their implications for human health. Dairy foods are heterogeneous, not just in their fat content but also in other compositional aspects within and between fermented (e.g., yogurt, cheese) and nonfermented products (e.g., milk) that could differentially influence cardiometabolic health. Drawing from complementary lines of evidence from epidemiological studies and RCTs, this review describes the health effects of dairy foods regarding their fat content, as well as their polar lipids that are concentrated in the milk fat globule fraction. Observational studies have limitedly supported the consumption of full-fat dairy to protect against cardiometabolic disorders. However, this framework has been disputed by RCTs indicating that dairy foods, regardless of their fat content or fermentation, are not detrimental to cardiometabolic health and may instead alleviate certain cardiometabolic risk factors. As dietary recommendations evolve, which currently indicate to avoid full-fat dairy foods, it is essential to consider the totality of evidence, especially from RCTs, while also recognizing that investigation is needed to evaluate the complexity of dairy foods within diverse dietary patterns and their impacts on cardiometabolic health.

"Milk on Ice": A detailed analysis of Ernest Shackleton's century-old whole milk powder in comparison with modern counterparts.

Whole milk powder (WMP) manufactured in New Zealand in 1907 was sent to the Antarctic continent with the Shackleton-led British Antarctic Expedition from 1907 to 1909. This powder was stored at ambient conditions at Shackleton's Hut at Cape Royds, Antarctica, for over 100 yr before a sample was collected on behalf of Fonterra by the Antarctic Heritage Trust. Having spent most of its existence both dried and in frozen storage, any deleterious reactions within the WMP would have been markedly retarded. The composition and some properties of the roller-dried Shackleton's WMP are reported along with those of 2 modern spray-dried New Zealand WMP. The Shackleton powder was less white and more yellow than the modern WMP and was composed of flakes rather than agglomerated particles, consistent with that expected of a roller-dried powder. Headspace analysis showed lipolytic and oxidative volatile compounds were present in the Shackleton WMP, indicting some deterioration of the milk either before powder manufacture or on storage of the finished product. On a moisture-free basis, the Shackleton WMP had higher protein, higher fat (with a markedly higher free fat level), higher ash, and a lower lactose level than the modern WMP. The lysine level was lower in the Shackleton WMP compared with the spray-dried powders, whereas the fatty acid composition was relatively similar. The sodium level was markedly higher in the Shackleton WMP compared with the spray-dried powder, which is probably due to the addition of an alkaline sodium salt to adjust the pH of the milk before roller drying. Lead, iron, and tin levels were markedly higher in the Shackleton WMP compared with the spray-dried powders, possibly due to the equipment used in powder manufacture and the tin-plated cases used for storage. The proteins in the Shackleton WMP were more lactosylated than in the spray-dried powders. The Shackleton WMP had a higher ratio of κ-casein A to B variants and a higher ratio of ß-lactoglobulin B to A variants than the spray-dried powders, whereas the αS1-casein, ß-casein, αS2-casein, and α-lactalbumin protein variants were similar in all powders. The total phospholipid content was markedly lower in the Shackleton WMP than the spray-dried powders, primarily due to a lower phosphatidylethanolamine concentration. The molecular species distributions within the phospholipid classes were generally similar in the 3 powders. Claims are sometimes encountered that the milk of today is different from that consumed by previous generations. However, this comparative study has shown that the Shackleton WMP was generally similar to modern WMP. Although differences in some components and properties were observed, these were attributable to the manufacturing equipment and processes used in the pioneering years of WMP manufacture.

Impact of the lipid phase composition and state on the in vitro digestibility and chlorophyllin bioaccessibility of W1/O/W2 emulsions into whole milk.

Water-in-oil-in-water (W1/O/W2) emulsions offer the potential to deliver hydrophilic bioactive compounds into foods, yet their application remains limited due to their instability. Thus, the impact of lipid phase composition and state on the colloidal stability, in vitro lipid digestibility and chlorophyllin (CHL) bioaccessibility of W1/O/W2 emulsions before and after incorporation into whole milk was studied. Medium-chain triglyceride oil (MCT) was used as a liquid lipid phase and MCT with glyceryl stearate (GS) or pure hydrogenated palm oil (HPO) as gelled lipid phases. The lipid phase composition was crucial to forming W1/O/W2 emulsions. MCT or MCT+GS allowed the successful formation of W1/O/W2 emulsions, being more stable upon gastric conditions those formulated with MCT+GS than pure MCT. In contrast, the use of HPO led to phase separation, which was maintained after the gastric conditions. Regarding their lipid digestibility, W1/O/W2 emulsions formulated with MCT or MCT+GS were fully digested, whereas only 40% of the lipid was digested using HPO. In accordance, the CHL bioaccessibility was higher using MCT or MCT+GS than HPO. When co-digested with whole milk, the colloidal stability and lipid digestibility of the W1/O/W2 emulsions with MCT or MCT+GS were not altered, whereas the W1/O/W2 emulsion-HPO showed enhanced colloidal stability and lipid digestibility (57.71 ± 3.06%), due to the surface-active properties of milk protein. The present study provides useful information to develop stable functional foods enriched with hydrophilic bioactive compounds by using W1/O/W2 emulsions.

The Relationship between Whole-Milk Dairy Foods and Metabolic Health Highlights an Opportunity for Dietary Fat Recommendations to Evolve with the State of the Science.

The science of dietary fats has evolved, and a body of evidence indicates they are complex bioactive nutrients that have different effects on health depending on their food source, chain length, degree of saturation, and other factors that can be affected by food processing, handling, and storage. As such, it is becoming increasingly clear that the effects of foods on obesity and metabolic health cannot be predicted simply with their fat content. The aim of this opinion article is to provide a brief overview of select recent research on the effects of whole-milk dairy foods on body composition and indicators of metabolic health across the lifespan to show the gap between current knowledge and dietary guidance. As the state of the science on dietary fats and human health evolves to consider the complexity of food matrices, the total nutrient package they deliver, and the health impacts associated with dietary patterns, so too must guidelines for dietary fat.

Enzymatic production of a suite of human milk oligosaccharides directly in milk.

Human milk oligosaccharides (HMOs) denote specific glycans in human breast milk. They function as prebiotics, immune modulating, and antimicrobial agents in the gut of breastfed infants, and certain HMOs even promote the cognitive development of the baby. HMOs are virtually absent in cow's milk and hence in infant formula, which provides a huge incentive for identifying ways in which HMOs can be produced to improve infant formulas. Here, we show that different sialylated and fucosylated HMOs can be generated in cow's milk via different simultaneous enzymatic transglycosylation reactions catalyzed by an engineered sialidase (EC 3.2.1.18, from Trypanosoma rangeli) and an 1,2-α-L-fucosidase (EC 3.2.1.63, from Tannerella forsinthia) acting on the lactose in the milk and on casein glycomacropeptide, two types of commercially available HMOs, i.e. 2'-fucosyllactose and lacto-N-neotetraose, added to the milk. We also outline the details of the individual reactions in aqueous systems, demonstrate that the enzymatic reactions can be accomplished at 5 °C, and validate the products formed by LC-MS and NMR analysis. Enzymatic production of HMOs directly in milk provides opportunities for enriching milk and infant formulas and extends the use of enzymatic transglycosylation reactions to synthesis of HMOs in milk and eventually in other beverages.

Inactivation of B. cereus spores in whole milk and almond milk by serpentine path coiled tube UV-C system: Numerical simulation of flow field, lipid peroxidation and volatiles analysis.

A novel continuous thin-film (1.59 mm) serpentine path coiled tube (SPCT) UV system operating at 254 nm wavelength was designed and compared with flow field distribution of whole milk with helical path coiled tube (HPCT) UV system using computational fluid dynamics. The results revealed efficient velocity magnitude distribution at serpentine bend geometric locations of the SPCT UV system. Further in this study, we evaluatedBacillus cereusSpores inactivation in whole milk (WM) and almond milk (AM) using the developed SPCT UV system. Experimental data showed that > 4 log reduction of spores was achieved after six and ten passes of WM and AM at a flow rate of 70 and 162 mL/min, respectively. The bio-dosimetry method was used to verify the delivered reduction equivalent fluence (REF) and reported as 33 ± 0.73 and 36.5 ± 1.9 mJ/cm2. We noticed no significant effect on lipid oxidation and volatiles profile (p > 0.05) up to delivered REF of 60 mJ/cm2. This study demonstrated that high levels of inactivation ofB. cereusspores could be feasible with minimal impact on product quality by UV-C processing of dairy and non-dairy opaque scattering fluids.

The impact of pasture and non-pasture diets on the sensory and volatile properties of whole milk powder.

This study evaluated the impact of three distinct diets; perennial ryegrass (GRS), perennial ryegrass/white clover (CLV) and total mixed ration (TMR), on the sensory properties and volatile profile of whole milk powder (WMP). The samples were evaluated using a hedonic sensory acceptance test (n = 99 consumers) and by optimised descriptive profiling (ODP) using trained assessors (n = 33). Volatile profiling was achieved by gas chromatography mass spectrometry using three different extraction techniques; headspace solid phase micro-extraction, thermal desorption and high capacity sorptive extraction. Significant differences were evident in both sensory perception and the volatile profiles of the WMP based on the diet, with WMP from GRS and CLV more similar than WMP from TMR. Consumers scored WMP from CLV diets highest for overall acceptability, flavour and quality, and WMP from TMR diets highest for cooked flavour and aftertaste. ODP analysis found that WMP from TMR diets had greater caramelised flavour, sweet aroma and sweet taste, and that WMP from GRS diets had greater cooked aroma and cooked flavour, with WMP derived from CLV diets having greater scores for liking of colour and creamy aroma. Sixty four VOCs were identified, twenty six were found to vary significantly based on diet and seventeen of these were derived from fatty acids; lactones, alcohols, aldehydes, ketones and esters. The abundance of δ-decalactone and δ-dodecalactone was very high in WMP derived from CLV and GRS diets as was γ-dodecalactone derived from a TMR diet. These lactones appeared to influence sweet, creamy, and caramelised attributes in the resultant WMP samples. The differences in these VOC derived from lipids due to diet are probably further exacerbated by the thermal treatments used in WMP manufacture.

Fatty acid profile characterization in colostrum, transition milk, and mature milk of primi- and multiparous cows during the first week of lactation.

The specific fatty acid (FA) profile of colostrum may indicate a biological requirement for neonatal calves. The objective of this study was to characterize the FA profile and yields in colostrum, transition milk, and mature milk in primiparous (PP) and multiparous (MP) cows. Colostrum was milked from 10 PP and 10 MP Holstein cows fed the same pre- and postpartum rations. Milkings (M) 2 to 5 and 12 were respectively termed transition and mature milk. Overall, short-chain FA (C4:0 and C6:0) were 61 and 50% lower in colostrum than mature milk, respectively. A parity by milking interaction was also present, with higher C4:0 for PP cows at M2 and for MP cows at M12. Additionally, higher concentrations of C6:0 were present for PP cows at M2 through M4 and for MP cows at M12. Palmitic (C16:0) and myristic (C14:0) acids were 38% and 19% higher in colostrum than mature milk, respectively. However, total saturated FA remained relatively stable. Branched-chain FA were 13% lower in colostrum than mature milk and higher in PP than MP cows throughout the milking period. The proportion of trans-monounsaturated FA (MUFA) was 72% higher in PP cows throughout the milking period, as well as 13% lower in colostrum than mature milk. In contrast, cis-MUFA and total MUFA were not affected by milking nor parity. Linoleic acid (LA) was 25% higher in colostrum than transition and mature milks, but α-linolenic acid (ALA) did not differ. Consequently, the ratio of LA to ALA was 29% higher in colostrum than mature milk and 33% higher in MP cows. Linoleic acid was also 15% higher in MP cows, whereas ALA was 15% higher in PP cows. Conjugated linoleic acid (CLA, cis-9,trans-11) was 2.7-fold higher in PP cows, and no differences between colostrum and mature milk were detected. Overall, polyunsaturated FA (PUFA) from the n-6 and n-3 series were over 40% higher in colostrum compared with transition and mature milk. Milking by parity interactions were present for arachidonic acid (ARA), eicosapentaenoic acid (EPA), docosapentaenoic acid (DPA), docosahexaenoic acid (DHA), and total n-3 PUFA, translating to higher proportions in PP cows in M1 to M3, whereas proportions remained relatively stable throughout the milking period in MP cows. Despite increasing milk yields throughout the subsequent milkings, higher yields of EPA, ARA, DPA, and DHA were present in colostrum than in mature milk. Greater proportions and yields of n-3 and n-6 FA in colostrum may translate to specific requirements for newborn calves. Differences were also observed between PP and MP cows and may reflect different nutrient requirements and partitioning.

Milk Replacer Ingredients: What and Why?

CMR's should be composed primarily of milk proteins, lactose as the sole carbohydrate source, lipids composed of edible grade tallow or lard with consideration for medium-chain fatty acids derived from coconut oil that mimic those in milk fat and adequate vitamin and mineral nutrition. Spray-dried bovine plasma provides antibodies shown to reduce diarrhea and calf mortality and to effectively replace a significant portion of milk protein in the diet. Whole milk pasteurization must be intensely monitored to ensure it is consistently wholesome. Milk is deficient in vitamins and trace minerals.

Fatty acid profile characterization in colostrum, transition milk, and mature milk of primi- and multiparous cows during the first week of lactation.

The specific fatty acid (FA) profile of colostrum may indicate a biological requirement for neonatal calves. The objective of this study was to characterize the FA profile and yields in colostrum, transition milk, and mature milk in primiparous (PP) and multiparous (MP) cows. Colostrum was milked from 10 PP and 10 MP Holstein cows fed the same pre- and postpartum rations. Milkings (M) 2 to 5 and 12 were respectively termed transition and mature milk. Overall, short-chain FA (C4:0 and C6:0) were 61 and 50% lower in colostrum than mature milk, respectively. A parity by milking interaction was also present, with higher C4:0 for PP cows at M2 and for MP cows at M12. Additionally, higher concentrations of C6:0 were present for PP cows at M2 through M4 and for MP cows at M12. Palmitic (C16:0) and myristic (C14:0) acids were 16% and 27% higher in colostrum than mature milk, respectively. However, total saturated FA remained relatively stable. Branched-chain FA were 13% lower in colostrum than mature milk and higher in PP than MP cows throughout the milking period. The proportion of trans-monounsaturated FA (MUFA) was 42% higher in PP cows throughout the milking period, as well as 15% lower in colostrum than mature milk. In contrast, cis-MUFA and total MUFA were not affected by milking nor parity. Linoleic acid (LA) was 13% higher in colostrum than transition and mature milks, but α-linolenic acid (ALA) did not differ. Consequently, the ratio of LA to ALA was 23% higher in colostrum than mature milk and 25% higher in MP cows. Linoleic acid was also 13% higher in MP cows, whereas ALA was 15% higher in PP cows. Conjugated linoleic acid (CLA, cis-9,trans-11) was 63% higher in PP cows, and no differences between colostrum and mature milk were detected. Overall, polyunsaturated FA (PUFA) from the n-6 and n-3 series were over 25% higher in colostrum compared with transition and mature milk. Milking by parity interactions were present for arachidonic acid (ARA), eicosapentaenoic acid (EPA), docosapentaenoic acid (DPA), docosahexaenoic acid (DHA), and total n-3 PUFA, translating to higher proportions in PP cows in M1 to M3, whereas proportions remained relatively stable throughout the milking period in MP cows. Despite increasing milk yields throughout the subsequent milkings, higher yields of EPA, ARA, DPA, and DHA were present in colostrum than in mature milk. Greater proportions and yields of n-3 and n-6 FA in colostrum may translate to specific requirements for newborn calves. Differences were also observed between PP and MP cows and may reflect different nutrient requirements and partitioning.

Explore Gastric Lipolysis and Lipid Oxidation of Conventional versus Pasture-Based Milk by a Semi-dynamic In Vitro Digestion Model.

Research on gastric lipolysis of commercial cow's milk with different fatty acid (FA) compositions is scarce. Gastric lipase exhibits specificity for the sn-3 chain position of triacylglycerols, whose structure is influenced by milk FA composition. Therefore, during gastric digestion of conventional (C) vs pasture-based (P) milk, differences may occur on lipolysis, which has impact on free FA available, influencing their absorption/metabolism rate and physiological hormonal responses. Those two milk types were subjected to the INFOGEST semi-dynamic digestion model. Five gastric emptying points were analyzed for oxidative degradation of polyunsaturated fatty acids (PUFA) and individual free FA. The relative release of medium-chain FA (C8:0-C12:0) was higher than that of longer-chain FA (C14:0-C18:0), and a linear increase in markers of PUFA oxidative degradation occurred along gastric digestion. Quantitatively, C8:0, C18:2n-6, C18:3n-3, and CLAc9t11 were higher (P < 0.001) in P milk when compared with C milk.

Comparison of Automated Extraction Techniques for Volatile Analysis of Whole Milk Powder.

Volatile profiling of whole milk powder is valuable for obtaining information on product quality, adulteration, legislation, shelf life, and aroma. For routine analysis, automated solventless volatile extraction techniques are favored due their simplicity and versatility, however no single extraction technique can provide a complete volatile profile due to inherent chemical bias. This study was undertaken to compare and contrast the performance of headspace solid phase microextraction, thermal desorption, and HiSorb (a sorptive extraction technique in both headspace and direct immersion modes) for the volatile analysis of whole milk powder by gas chromatography mass spectrometry. Overall, 85 unique volatiles were recovered and identified, with 80 extracted and identified using a non-polar gas chromatography column, compared to 54 extracted, and identified using a polar gas chromatography column. The impact of salting out was minimal in comparison to gas chromatography column polarity and the differences between the extraction techniques. HiSorb extracted the most and greatest abundance of volatiles, but was heavily influenced by the number and volume of lactones extracted in comparison to the other techniques. HiSorb extracted significantly more volatiles by direct immersion than by headspace. The differences in volatile selectivity was evident between the techniques and highlights the importance of using multiple extraction techniques in order to obtain a more complete volatile profile. This study provides valuable information on the volatile composition of whole milk powder and on differences between extraction techniques under different conditions, which can be extrapolated to other food and beverages.

Effect of bovine feeding system (pasture or concentrate) on the oxidative and sensory shelf life of whole milk powder.

Correlating volatile compounds with the sensory attributes of whole milk powder (WMP) is fundamental for appreciating the effect of lipid oxidation (LO) on sensory perception. LO compounds can adversely affect the sensory perception of WMP by imparting rancid, metallic, and painty notes. Whole milk powders derived from milk produced by cows maintained on a pasture diet (grass and grass-clover mix) versus a nonpasture diet [total mixed ration (TMR); concentrates and silage] were stored at room temperature 21°C (ambient storage) and 37°C (accelerated storage) and analyzed for volatile compounds and sensory attributes every 2 mo for a total of 6 mo. Thirteen volatile compounds originating from LO were chosen to track the volatile profile of the WMP during storage. Color, composition, total fatty acid, and free fatty acid profiling were also carried out. Significant variations in the concentrations of 14 fatty acids were observed in WMP based on diet. Concentrations of free fatty acids increased in all sample types during storage. Similar trends in sensory attributes were observed with an increase in painty attributes, corresponding to an increase in hexanal. Buttery/toffee attributes were found to be more closely correlated with TMR WMP. Those WMP derived from pasture diets were found to be more susceptible to LO from a volatile perspective, particularly in relation to aldehyde development, which is likely due to increased concentrations of conjugated linoleic acid and α-linolenic acid found in these samples.

Enzymatic production of 3'-sialyllactose in milk.

Human milk oligosaccharides (HMOs) are lactose-based glycan molecules present in human breast milk. HMOs are essentially not present in cow's milk and hence not naturally available in infant formulas. HMOs possess several health and developmentally beneficial properties, and the sialylated HMOs are thought to play a particularly important role for infant brain development. Enzymatic transsialylation directly in cow's milk, involving enzyme catalyzed transfer of sialic acid from a sialic acid donor to an acceptor, is a novel route for producing sialylated HMOs for e.g. infant formulas. The transsialidase (EC 2.4.1.-) of Trypanosoma cruzi is linked to trypanosomatid pathogenicity, but certain hydrolytic sialidases (neuraminidases), EC 3.2.1.18, from non-pathogenic organisms, can actually catalyze transsialylation. Here, we report enzymatic production of the HMO compound 3'-sialyllactose directly in cow's milk using engineeredsialidases, Tr15 and Tr16, originating from the nonpathogenic Trypanosoma rangeli. Both Tr15 and Tr16 readily catalyzed transsialylation in milk at 5 °C-40 °C using κ(kappa)-casein glycomacropeptide (cGMP) as sialyl donor substrate. Tr15 was the most efficient as this enzyme produced 1160 mg/L (1.8 mM) 3'-sialyllactose in whole milk during 10 min of reaction at 5 °C. The activation energy values, Ea, of the enzymatic transsialylation reactions were similar in milk and in buffer solutions containing cGMP and lactose. The Ea of the Tr15 catalyzed transialylation reaction in milk was 16.5 kJ/mol, which was three times lower than the Ea of Tr16 (66 kJ/mol) and of T. cruzi transsialidase (50 kJ/mol), corroborating that Tr15 was the fastest of the three enzymes and a promising candidate for potential industrial production of 3'-sialyllactose in milk. 3'sialyllactose was stable during pasteurization (30 min. at 62.5 °C) and freeze-drying.

Heating of milk powders at low water activity to 95°C for 15 minutes using hot air-assisted radio frequency processing achieved pasteurization.

Salmonella persistence in milk powders has caused several multistate foodborne disease outbreaks. Therefore, ways to deliver effective thermal treatment need to be identified and validated to ensure the microbial safety of milk powders. In this study, a process of hot air-assisted radio frequency (HARF) followed by holding at high temperatures in a convective oven was developed for pasteurization of milk powders. Heating times were compared between HARF and a convection oven for heating milk powders to a pasteurization temperature, and HARF has been shown to considerably reduce the come-up time. Whole milk powder (WMP) and nonfat dry milk (NFDM) were inoculated with a 5-serotype Salmonella cocktail and equilibrated to a water activity of 0.10 to simulate the worst case for the microbial challenge study. After heating the sample to 95°C using HARF, followed by 10 and 15 min of holding in the oven, more than 5 log reduction of Salmonella was achieved in WMP and NFDM. This study validated a HARF-assisted thermal process for pasteurization of milk powder based on previously collected microbial inactivation kinetics data and provides valuable insights to process developers to ensure microbial safety of milk powder. This HARF process may be implemented in the dairy industry to enhance the microbial safety of milk powders.

Safety and quality aspects of whole and skimmed milk powders.

BACKGROUND: Nowadays, dried milk products are highly traded and consumed all over the world, so we aimed in this study to evaluate to what extent whole and skim milk powders are safe and comply with Egyptian standards. METHODS: Eighty samples of dried milk (50 whole milk powder and 30 skim milk powder) were gathered from several retailers and supermarkets for evaluation of their differing quality and safety parameters. RESULTS: The most frequent off-flavors recovered from whole milk powder samples were cooked ones and, in the case of skim milk powder samples, flat ones. Five samples of whole milk powder were of fair quality and three samples of poor quality, according to the sensory evaluation. The compositional parameters, moisture, %, fat, %, protein, %, and acidity, %, were measured as mean values of 3.90 ±0.15, 26.90 ±0.19, 25.53 ±0.27, and 0.99 ±0.03% in the examined whole milk powder samples and 3.77 ±0.08, 1.11 ±0.05, 34.62 ±0.29, and 1.22 ±0.03% in the examined skimmed milk powder samples, respectively. These results were within the range of component requirements set by the Egyptian Standard (2014; ES: 1780/2014) for dried milk products. Also, the microbiological safety of the milk powder samples was analyzed by assessment of the total viable count, total yeast and mold count, Coliforms count, Enterobacteriaceae, E. coli, C. sakazakii, Staphylococcus aureus, Salmonella, and Listeria monocytogenes. Staphylococcus aureus was the most prevalent isolate (36.00% and 6.67%) followed by Enterobacteriaceae (20.00% and 3.33%), of whole and skim milk powder, respectively. Enterobacteriaceae isolates included Enterobacter cloacae ssp. Cloacae, and Pantoea spp., which were specified by traditional biochemical tests and Vitek2 system. All Enterobacteriaceae isolated spp. were resistant to cephalothin, neomycin, tobramycin and colistin sulphate, and sensitive to chloramphenicol, gentamycin and nalidixic acid. E. coli, C. sakazakii, Salmonella, and Listeria monocytogenes couldn't be isolated from all the tested samples. By using Inductive Coupled Plasma - Mass Spectrometer (ICP-MS), we could measure lead and mercury as mean values of 0.243 ±0.069 and 0.261 ±0.052 mg/kg for whole milk powder samples at a percentage of 68.00 and 34.00%, while for the skim milk powder samples they were 0.150 ±0.037, and 0.347 ±0.110 mg/kg at a percentage of 66.67 and 40.00%, respectively. CONCLUSIONS: Finally, thirty-four whole milk powder and twelve skimmed milk powder samples didn't comply with Egyptian standards, so it is necessary for authorities to put more attention on this and regular monitor it.

Profiles of initial, intermediate, and advanced stages of harmful Maillard reaction products in whole-milk powders pre-treated with different heat loads during 18 months of storage.

This study evaluated the chemical changes in five types of whole-milk powders (WMP) with different heating loads during storage. The WMP was preheated using low-heat [low-temperature long-time (LTLT), high-temperature short-time pasteurization (HTST)] and high-heat process [ultra-pasteurization (ESL), ultra-high-temperature (UHT) treatments, and in-bottle sterilization (BS)]. Furosine increased by 2.5-3.0 times in high-heat WMP and 5.7-8.4 times in low-heat WMP during storage. 5-(hydroxymethyl)furfural (HMF) content in high-heat WMP was on average 1.4- to 2.4-fold higher than in low-heat WMP during storage. The increases in the amount of Nε-(carboxymethyl)lysine (CML) and Nε-(carboxyethyl)lysine (CEL) in high-heat WMP were more than that in low-heat WMP (CML, 3.4-4.9 vs 3.1-3.4 times; CEL, 3.4-4.2 vs 2.7-3.0 times). Pyrraline in high-heat WMP increased by 1.8- to 2.1-fold. 2-Furaldehyde, CML, and CEL increased slowly with 12 months of storage and then accelerated. Storage time significantly contributed to more furosine, HMF, CML, and CEL contents in high-heat WMP.

Assessment of the production of Bacillus cereus protease and its effect on the quality of ultra-high temperature-sterilized whole milk.

Bacillus cereus is one of the most important spoilage microorganisms in milk. The heat-resistant protease produced is the main factor that causes rotten, bitter off-flavors and age gelation during the shelf-life of milk. In this study, 55 strains of B. cereus were evaluated, of which 25 strains with protease production ability were used to investigate proteolytic activity and protease heat resistance. The results showed that B. cereus C58 had strong protease activity, and its protease also had the highest thermal stability after heat treatment of 70°C (30 min) and 100°C (10 min). The protease was identified as protease HhoA, with a molecular mass of 43.907 kDa. The protease activity of B. cereus C58 in UHT-sterilized whole milk (UHT milk) showed an increase with the growth of bacteria, especially during the logarithmic growth phase. In addition, the UHT milk incubated with protease from B. cereus C58 at 28°C (24 h) and 10°C (6 d) were used to evaluate the effects of protease on the quality of UHT milk, including protein hydrolysis and physical stability. The results showed that the hydrolysis of casein was κ-CN, ß-CN, and αS-CN successively, whereas whey protein was not hydrolyzed. The degree of protein hydrolysis, viscosity, and particle size of the UHT milk increased. The changes in protein and fat contents indicated that fat globules floated at 28°C and settled at 10°C, respectively. Meanwhile, confocal laser scanning microscopy images revealed that the protease caused the stability of UHT milk to decrease, thus forming age gelation.

Nucleotide Supplementation to Whole Milk Has Beneficial Effects on Post-Weaning Holstein Calf Performance.

The positive effects of nucleotide (NU) supplementation in milk replacer have been elucidated in infants and in dairy calves; however, NU addition to whole milk has not been evaluated previously. This study aimed to assess NU supplementation in the whole milk on calf growth and health. Thirty Holstein calves (body weight: 39.1 ± 1.0 kg; 3 d after birth) were randomly assigned to the following treatments: whole milk without any supplementation (NU0), whole milk + 0.5 g/d added a NU-containing supplement to whole milk (NUCS0.5), and whole milk + 1 g/d added a NU-containing supplement to whole milk (NUCS1). Calves were weaned at d 55 and stayed on study until d 75. Calves had free access to feed and water throughout the study. Dry matter intakes (DMI) were similar among treatments (p > 0.05) during the pre-weaning period; however, increasing NU resulted in a linear (p < 0.05) increase in DMI during the post weaning period (2158, 2432, and 2518 g/d for NU0, NUCS0.5, and NUCS1, respectively). Treatments did not affect body weight (BW) at the first and second month of study, but final BW linearly increased as NU was added (87.1, 90.6, and 95.4 kg for NU0, NUCS0.5, and NUCS1, respectively). Neither pre-weaning average daily gain nor post-weaning average daily gain was affected by treatments; accordingly, feed efficiency was similar among treatment groups. Days with loose fecal score were linearly decreased as NU was added to whole milk during the first month of life, while the fecal score did not differ among treatments until the end of the study. No difference was observed in the skeletal growth of calves in the current study. Therefore, it can be concluded that NU supplementation in the whole milk has some beneficial effects on calf performance in terms of final BW, post-weaning DMI, and less days with loose feces.