Structural basis for plastic glycolipid recognition of the C-type lectin Mincle.

Mincle (macrophage-inducible C-type lectin, CLEC4E) is a C-type lectin immune-stimulatory receptor for cord factor, trehalose dimycolate (TDM), which serves as a potent component of adjuvants. The recognition of glycolipids by Mincle, especially their lipid parts, is poorly understood. Here, we performed nuclear magnetic resonance analysis, revealing that titration of trehalose harboring a linear short acyl chain showed a chemical shift perturbation of hydrophobic residues next to the Ca-binding site. Notably, there were split signals for Tyr201 upon complex formation, indicating two binding modes for the acyl chain. In addition, most Mincle residues close to the Ca-binding site showed no observable signals, suggesting their mobility on an ∼ ms scale even after complex formation. Mutagenesis study supported two putative lipid-binding modes for branched acyl-chain TDM binding. These results provide novel insights into the plastic-binding modes of Mincle toward a wide range of glycol- and glycerol-lipids, important for rational adjuvant development.

Mycobacterial membrane protein Large 3-like-family proteins in bacteria, protozoa, fungi, plants, and animals: A bioinformatics and structural investigation.

Lipid transporters play an important role in most if not all organisms, ranging from bacteria to humans. For example, in Mycobacterium tuberculosis, the trehalose monomycolate transporter MmpL3 is involved in cell wall biosynthesis, while in humans, cholesterol transporters are involved in normal cell function as well as in disease. Here, using structural and bioinformatics information, we propose that there are proteins that also contain "MmpL3-like" (MMPL) transmembrane (TM) domains in many protozoa, including Trypanosoma cruzi, as well as in the bacterium Staphylococcus aureus, where the fatty acid transporter FarE has the same set of "active-site" residues as those found in the mycobacterial MmpL3s, and in T. cruzi. We also show that there are strong sequence and predicted structural similarities between the TM proton-translocation domain seen in the X-ray structures of mycobacterial MmpL3s and several human as well as fungal lipid transporters, leading to the proposal that there are similar proteins in apicomplexan parasites, and in plants. The animal, fungal, apicomplexan, and plant proteins have larger extra-membrane domains than are found in the bacterial MmpL3, but they have a similar TM domain architecture, with the introduction of a (catalytically essential) Phe > His residue change, and a Ser/Thr H-bond network, involved in H+ -transport. Overall, the results are of interest since they show that MMPL-family proteins are present in essentially all life forms: archaea, bacteria, protozoa, fungi, plants and animals and, where known, they are involved in "lipid" (glycolipid, phospholipid, sphingolipid, fatty acid, cholesterol, ergosterol) transport, powered by transmembrane molecular pumps having similar structures.

The liposome of trehalose dimycolate extracted from M. bovis BCG induces antitumor immunity via the activation of dendritic cells and CD8+ T cells.

Intravesical Bovis bacillus Calmette-Guérin (BCG) therapy is the most effective immunotherapy for bladder cancer, but it sometime causes serious side effects because of its inclusion of live bacteria. It is necessary to develop a more active but less toxic immunotherapeutic agent. Trehalose 6,6'-dimycolate (TDM), the most abundant hydrophobic glycolipid of the BCG cell wall, has been reported to show various immunostimulatory activities such as granulomagenesis and adjuvant activity. Here, we developed cationic liposomes incorporating TDM purified from Mycobacterium bovis BCG Connaught, and we investigated the antitumor effect of the cationic liposome TDM (Lip-TDM). Lip-TDM exerted an antitumor effect in bladder cancer, colon cancer, and melanoma-bearing mouse models that was comparable or even superior to that of BCG, with no body weight loss or granuloma formation. The antitumor effect of Lip-TDM disappeared in two types of mice: those with depletion of CD8+ T cells, and those with knockout of macrophage-inducible C-type lectin (Mincle) which recognize TDM. Lip-TDM treatment enhanced the maturation and migration of dendritic cells in the tumor microenvironment in a Mincle-dependent manner. Our results elucidate mechanisms that underlie Lip-TDM treatment and suggest that Lip-TDM has potential as a safe and effective treatment for various cancers.

Unveiling the biodiversity of lipid species in Corynebacteria- characterization of the uncommon lipid families in C. glutamicum and pathogen C. striatum by mass spectrometry.

Uncommon lipids in biotechnologically important Corynebacterium glutamicum and pathogen Corynebacterium striatum in genus Corynebacterium are isolated and identified by linear ion-trap multiple stage mass spectrometry (LIT MSn) with high resolution mass measurement. We redefined several lipid structures that were previously mis-assigned or not defined, including cytidine diphosphate diacylglycerol (CDP-DAG), glucuronosyl diacylglycerol (GlcA-DAG), (α-d-mannopyranosyl)-(1 â†’ 4)-(α-D-glucuronyl diacyglycerol (Man-GlcA-DAG), 1-mycolyl-2-acyl-phosphatidylglycerol (MA-PG), acyl trehalose monomycolate (acyl-TMM). We also report the structures of mycolic acid, phosphatidylglycerol, phosphatidylinositol, cardiolipin, trehalose dimycolate lipids in which many isomeric structures are present. The LIT MSn approaches afford identification of the functional group, the fatty acid substituents and their regiospecificity in the molecules, revealing the biodiversities of the lipid species in two Corynebacterium strains that have played very different and important roles in human nutrition and health.

The crystal structure of the mycobacterial trehalose monomycolate transport factor A, TtfA, reveals an atypical fold.

Trehalose monomycolate (TMM) represents an essential element of the mycobacterial envelope. While synthesized in the cytoplasm, TMM is transported across the inner membrane by MmpL3 but, little is known regarding the MmpL3 partners involved in this process. Recently, the TMM transport factor A (TtfA) was found to form a complex with MmpL3 and to participate in TMM transport, although its biological role remains to be established. Herein, we report the crystal structure of the Mycobacterium smegmatis TtfA core domain. The phylogenetic distribution of TtfA homologues in non-mycolate containing bacteria suggests that TtfA may exert additional functions.

Species-Specific Structural Requirements of Alpha-Branched Trehalose Diester Mincle Agonists.

Despite the ever present need for an effective Mycobacterium tuberculosis (Mtb) vaccine, efforts for development have been largely unsuccessful. Correlates of immune protection against Mtb are not wholly defined, but Th1 and likely Th17 adaptive immune responses have been demonstrated to be necessary for vaccine-mediated protection. Unfortunately, no approved adjuvants are able to drive a Th17 response, though recent clinical trials with CAF01 have demonstrated proof of concept. Herein we present the discovery and characterization of a new class of potential Th17-inducing vaccine adjuvants, alpha-branched trehalose diester molecules (αTDE). Based off the Mtb immunostimulatory component trehalose dimycolate (TDM), we synthesized and evaluated the immunostimulatory capacity of a library of structural derivatives. We evaluated the structure activity relationship of the compounds in relation to chain length and engagement of the Mincle receptor, production of innate cytokines from human and murine cells, and a pro-Th17 cytokine profile from primary human peripheral blood mononuclear cells. Murine cells displayed more structural tolerance, engaging and responding to a wide array of compound chain lengths. Interestingly, human cells displayed a unique specificity for ester chains between 5 and 14 carbons for maximal immune stimulating activity. Evaluation of two distinct αTDEs, B16 and B42, in concert with a recombinant Mtb antigen demonstrated their ability to augment a Th17 immune response against a Mtb antigen in vivo. Collectively this data describes the species-specific structural requirements for maximal human activity of alpha-branched trehalose diester compounds and demonstrates their capacity to serve as potent Th17-inducing adjuvants.

Engineering the Mycomembrane of Live Mycobacteria with an Expanded Set of Trehalose Monomycolate Analogues.

Mycobacteria and related organisms in the Corynebacterineae suborder are characterized by a distinctive outer membrane referred to as the mycomembrane. Biosynthesis of the mycomembrane occurs through an essential process called mycoloylation, which involves antigen 85 (Ag85)-catalyzed transfer of mycolic acids from the mycoloyl donor trehalose monomycolate (TMM) to acceptor carbohydrates and, in some organisms, proteins. We recently described an alkyne-modified TMM analogue (O-AlkTMM-C7) which, in conjunction with click chemistry, acted as a chemical reporter for mycoloylation in intact cells and allowed metabolic labeling of mycoloylated components of the mycomembrane. Here, we describe the synthesis and evaluation of a toolbox of TMM-based reporters bearing alkyne, azide, trans-cyclooctene, and fluorescent tags. These compounds gave further insight into the substrate tolerance of mycoloyltransferases (e.g., Ag85s) in a cellular context and they provide significantly expanded experimental versatility by allowing one- or two-step cell labeling, live cell labeling, and rapid cell labeling via tetrazine ligation. Such capabilities will facilitate research on mycomembrane composition, biosynthesis, and dynamics. Moreover, because TMM is exclusively metabolized by Corynebacterineae, the described probes may be valuable for the specific detection and cell-surface engineering of Mycobacterium tuberculosis and related pathogens. We also performed experiments to establish the dependence of probe incorporation on mycoloyltransferase activity, results from which suggested that cellular labeling is a function not only of metabolic incorporation (and likely removal) pathway(s), but also accessibility across the envelope. Thus, whole-cell labeling experiments with TMM reporters should be carefully designed and interpreted when envelope permeability may be compromised. On the other hand, this property of TMM reporters can potentially be exploited as a convenient way to probe changes in envelope integrity and permeability, facilitating drug development studies.

Adjuvants Based on Synthetic Mycobacterial Cord Factor Analogues: Biophysical Properties of Neat Glycolipids and Nanoself-Assemblies with DDA.

Synthetic mycobacterial cord factor analogues, e.g., trehalose 6,6'-dibehenate (TDB), are highly promising adjuvants due to their strong immunopotentiating capabilities, but their biophysical properties have remained poorly characterized. Here, we report the synthesis of an array of synthetic TDB analogues varying in acyl chain length, degree of acylation, and headgroup display, which was subjected to biophysical characterization of neat nondispersed self-assembled nanostructures in excess buffer and as aqueous dispersions with cationic dimethyldioctadecylammonium (DDA) bromide. The array comprised trehalose mono- (TMX) and diester (TDX) analogues with symmetrically shortened acyl chains [denoted by X: arachidate (A), stearate (S), palmitate (P), myristate (Myr), and laurate (L)] and an analogue with a short hydrophilic polyethylene glycol (PEG) linker inserted between the trehalose headgroup of TDS and the acyl chains (PEG-TDS). All dispersions were liposomes, but in contrast to the colloidally stable and highly cationic TDX-containing liposomes, the zeta-potential was significantly reduced for DDA/TMX and DDA/PEG-TDS liposomes, suggesting a charge-shielding effect, which compromises the colloidal stability. An increased d-spacing was observed for the lamellar phase of neat TDB analogues in excess buffer (TDS < TMS < PEG-TDS), confirming that the charge shielding is caused by an extended molecular configuration of the more flexible headgroup. Differential scanning calorimetry showed highly cooperative phase transitions for all tested dispersions albeit the monoesters destabilized the lipid bilayers. Langmuir experiments demonstrated that incorporation of TDXs and PEG-TDS stabilized DDA monolayers due to improved hydrogen bonding and reduced intermolecular repulsions. In conclusion, data suggest that the DDA/TDS dispersions exhibit favorable physicochemical properties rendering these DDA/TDS liposomes an attractive vaccine adjuvant, and they emphasize that not only the receptor binding and immune activation but also the biophysical properties of immunopotentiator formulations should be collectively considered when designing adjuvants with optimal safety, efficacy, and storage stability.

Rational design of adjuvants targeting the C-type lectin Mincle.

The advances in subunit vaccines development have intensified the search for potent adjuvants, particularly adjuvants inducing cell-mediated immune responses. Identification of the C-type lectin Mincle as one of the receptors underlying the remarkable immunogenicity of the mycobacterial cell wall, via recognition of trehalose-6,6'-dimycolate (TDM), has opened avenues for the rational design of such molecules. Using a combination of chemical synthesis, biological evaluation, molecular dynamics simulations, and protein mutagenesis, we gained insight into the molecular bases of glycolipid recognition by Mincle. Unexpectedly, the fine structure of the fatty acids was found to play a key role in the binding of a glycolipid to the carbohydrate recognition domain of the lectin. Glucose and mannose esterified at O-6 by a synthetic α-ramified 32-carbon fatty acid showed agonist activity similar to that of TDM, despite their much simpler structure. Moreover, they were seen to stimulate proinflammatory cytokine production in primary human and murine cells in a Mincle-dependent fashion. Finally, they were found to induce strong Th1 and Th17 immune responses in vivo in immunization experiments in mice and conferred protection in a murine model of Mycobacterium tuberculosis infection. Here we describe the rational development of new molecules with powerful adjuvant properties.

A chemical reporter strategy for detecting and identifying O-mycoloylated proteins in Corynebacterium.

Protein O-mycoloylation is a unique post-translational lipidation that was recently discovered in Corynebacterium. We describe an alkyne-modified trehalose monomycolate chemical reporter that can metabolically tag O-mycoloylated proteins in C. glutamicum, enabling their detection and identification through click chemistry.

Contribution of MINCLE-SYK Signaling to Activation of Primary Human APCs by Mycobacterial Cord Factor and the Novel Adjuvant TDB.

Trehalose-6,6-dimycolate (TDM), the mycobacterial cord factor, is an abundant cell wall glycolipid and major virulence factor of Mycobacterium tuberculosis. Its synthetic analog trehalose-6,6-dibehenate (TDB) is a new adjuvant currently in phase I clinical trials. In rodents, the C-type lectin receptors Mincle and Mcl bind TDB/TDM and activate macrophages and dendritic cells (DC) through the Syk-Card9 pathway. However, it is unknown whether these glycolipids activate human innate immune cells through the same mechanism. We performed in vitro analysis of TDB/TDM-stimulated primary human monocytes, macrophages, and DC; determined C-type lectin receptor expression; and tested the contribution of SYK, MINCLE, and MCL by small interfering RNA knockdown and genetic complementation. We observed a robust chemokine and cytokine release in response to TDB or TDM. MCSF-driven macrophages secreted higher levels of IL-8, IL-6, CCL3, CCL4, and CCL2 after stimulation with TDM, whereas DC responded more strongly to TDB and GM-CSF-driven macrophages were equally responsive to TDB and TDM. SYK kinase and the adaptor protein CARD9 were essential for glycolipid-induced IL-8 production. mRNA expression of MINCLE and MCL was high in monocytes and macrophages, with MINCLE and MCL proteins localized intracellularly under resting conditions. Small interfering RNA-mediated MINCLE or MCL knockdown caused on average reduced TDB- or TDM-induced IL-8 production. Conversely, retroviral expression in murine Mincle-deficient DC revealed that human MINCLE, but not MCL, was sufficient to confer responsiveness to TDB/TDM. Our study demonstrates that SYK-CARD9 signaling plays a key role in TDB/TDM-induced activation of innate immune cells in man as in mouse, likely by engagement of MINCLE.

Differential control of Mincle-dependent cord factor recognition and macrophage responses by the transcription factors C/EBPß and HIF1α.

Trehalose-6,6-dimycolate (TDM), the mycobacterial cord factor, and its synthetic analog Trehalose-6,6-dibehenate (TDB) bind to the C-type lectin receptors macrophage-inducible C-type lectin (Mincle) and Mcl to activate macrophages. Genetically, the transcriptional response to TDB/TDM has been defined to require FcRγ-Syk-Card9 signaling. However, TDB/TDM-triggered kinase activation has not been studied well, and it is largely unknown which transcriptional regulators bring about inflammatory gene expression. In this article, we report that TDB/TDM caused only weak Syk-phosphorylation in resting macrophages, consistent with low basal Mincle expression. However, LPS-priming caused MYD88-dependent upregulation of Mincle, resulting in enhanced TDB/TDM-induced kinase activation and more rapid inflammatory gene expression. TLR-induced Mincle expression partially circumvented the requirement for Mcl in the response to TDB/TDM. To dissect transcriptional responses to TDB/TDM, we mined microarray data and identified early growth response (Egr) family transcription factors as direct Mincle target genes, whereas upregulation of Cebpb and Hif1a required new protein synthesis. Macrophages and dendritic cells lacking C/EBPß showed nearly complete abrogation of TDB/TDM responsiveness, but also failed to upregulate Mincle. Retroviral rescue of Mincle expression in Cebpb-deficient cells restored induction of Egr1, but not of G-CSF. This pattern of C/EBPß dependence was also observed after stimulation with the Dectin-1 ligand Curdlan. Inducible expression of hypoxia-inducible factor 1α (HIF1α) also required C/EBPß. In turn, HIF1α was not required for Mincle expression, kinase activation, and Egr1 or Csf3 expression, but critically contributed to NO production. Taken together, we identify C/EBPß as central hub in Mincle expression and inflammatory gene induction, whereas HIF1α controls Nos2 expression. C/EBPß also connects TLR signals to cord factor responsiveness through MYD88-dependent upregulation of Mincle.

Combining cationic liposomal delivery with MPL-TDM for cysteine protease cocktail vaccination against Leishmania donovani: evidence for antigen synergy and protection.

BACKGROUND: With the paucity of new drugs and HIV co-infection, vaccination remains an unmet research priority to combat visceral leishmaniasis (VL) requiring strong cellular immunity. Protein vaccination often suffers from low immunogenicity and poor generation of memory T cells for long-lasting protection. Cysteine proteases (CPs) are immunogenic proteins and key mediators of cellular functions in Leishmania. Here, we evaluated the vaccine efficacies of CPs against VL, using cationic liposomes with Toll like receptor agonists for stimulating host immunity against L. donovani in a hamster model. METHODOLOGY/PRINCIPAL FINDINGS: Recombinant CPs type I (cpb), II (cpa) and III (cpc) of L. donovani were tested singly and in combination as a triple antigen cocktail for antileishmanial vaccination in hamsters. We found the antigens to be highly immunoreactive and persistent anti-CPA, anti-CPB and anti-CPC antibodies were detected in VL patients even after cure. The liposome-entrapped CPs with monophosphoryl lipid A-Trehalose dicorynomycolate (MPL-TDM) induced significantly high nitric oxide (up to 4 fold higher than controls) mediated antileishmanial activity in vitro, and resulted in strong in vivo protection. Among the three CPs, CPC emerged as the most potent vaccine candidate in combating the disease. Interestingly, a synergistic increase in protection was observed with liposomal CPA, CPB and CPC antigenic cocktail which reduced the organ parasite burden by 1013-1016 folds, and increased the disease-free survival of >80% animals at least up to 6 months post infection. Robust secretion of IFN-γ and IL-12, along with concomitant downregulation of Th2 cytokines, was observed in cocktail vaccinates, even after 3 months post infection. CONCLUSION/SIGNIFICANCE: The present study is the first report of a comparative efficacy of leishmanial CPs and their cocktail using liposomal formulation with MPL-TDM against L. donovani. The level of protection attained has not been reported for any other subcutaneous single or polyprotein vaccination against VL.

Defining the conformation of human mincle that interacts with mycobacterial trehalose dimycolate.

Trehalose dimycolate, an unusual glycolipid in the outer membrane of Mycobacterium tuberculosis, stimulates macrophages by binding to the macrophage receptor mincle. This stimulation plays an important role both in infection by mycobacteria and in the use of derivatives of mycobacteria as adjuvants to enhance the immune response. The mechanism of trehalose dimycolate binding to the C-type carbohydrate-recognition domain in human mincle has been investigated using a series of synthetic analogs of trehalose dimycolate and site-directed mutagenesis of the human protein. The results support a mechanism of binding acylated trehalose derivatives to human mincle that is very similar to the mechanism of binding to bovine mincle, in which one glucose residue in the trehalose headgroup of the glycolipid is ligated to the principle Ca(2+)-binding site in the carbohydrate-recognition domain, with specificity for the disaccharide resulting from interactions with the second glucose residue. Acyl chains attached to the 6-OH groups of trehalose enhance affinity, with the affinity dependent on the length of the acyl chains and the presence of a hydrophobic groove adjacent to the sugar-binding sites. The results indicate that the available crystal structure of the carbohydrate-recognition domain of human mincle is unlikely to be in a fully active conformation. Instead, the ligand-binding conformation probably resembles closely the structure observed for bovine mincle in complex with trehalose. These studies provide a basis for targeting human mincle as a means of inhibiting interactions with mycobacteria and as an approach to harnessing the ability of mincle to stimulate the immune response.

Isolation, structural elucidation and biosynthesis of 3-hydroxy-6-dimethylallylindolin-2-one, a novel prenylated indole derivative from Actinoplanes missouriensis.

Many prenylated indole derivatives are widely distributed in nature. Recently, two Streptomyces prenyltransferases, IptA and its homolog SCO7467, were identified in the biosynthetic pathways for 6-dimethylallylindole (DMAI)-3-carbaldehyde and 5-DMAI-3-acetonitrile, respectively. Here, we isolated a novel prenylated indole derivative, 3-hydroxy-6-dimethylallylindolin (DMAIN)-2-one, based on systematic purification of metabolites from a rare actinomycete, Actinoplanes missouriensis NBRC 102363. The structure of 3-hydroxy-6-DMAIN-2-one was determined by HR-MS and NMR analyses. We found that A. missouriensis produced not only 3-hydroxy-6-DMAIN-2-one but also 6-dimethylallyltryptophan (DMAT) and 6-DMAI when grown in PYM (peptone-yeast extract-MgSO4) medium. We searched the complete genome of A. missouriensis for biosynthesis genes of these compounds and found a gene cluster composed of an iptA homolog (AMIS_22580, named iptA-Am) and a putative tryptophanase gene (AMIS_22590, named tnaA-Am). We constructed a tnaA-Am-deleted (ΔtnaA-Am) strain and found that it produced 6-DMAT but did not produce 6-DMAI or 3-hydroxy-6-DMAIN-2-one. Exogenous addition of 6-DMAI to mutant ΔtnaA-Am resulted in the production of 3-hydroxy-6-DMAIN-2-one. Furthermore, in vitro enzyme assays using recombinant proteins produced by Escherichia coli demonstrated that 6-DMAI was synthesized from tryptophan and dimethylallyl pyrophosphate in the presence of both IptA-Am and TnaA-Am, and that IptA-Am preferred tryptophan to indole as the substrate. From these results, we concluded that the iptA-Am-tnaA-Am gene cluster is responsible for the biosynthesis of 3-hydroxy-6-DMAIN-2-one. Presumably, tryptophan is converted into 6-DMAT by IptA-Am and 6-DMAT is then converted into 6-DMAI by TnaA-Am. 6-DMAI appears to be converted into 3-hydroxy-6-DMAIN-2-one by the function of some unknown oxidases in A. missouriensis.

Structural analysis for glycolipid recognition by the C-type lectins Mincle and MCL.

Mincle [macrophage inducible Ca(2+)-dependent (C-type) lectin; CLEC4E] and MCL (macrophage C-type lectin; CLEC4D) are receptors for the cord factor TDM (trehalose-6,6'-dimycolate), a unique glycolipid of mycobacterial cell-surface components, and activate immune cells to confer adjuvant activity. Although it is known that receptor-TDM interactions require both sugar and lipid moieties of TDM, the mechanisms of glycolipid recognition by Mincle and MCL remain unclear. We here report the crystal structures of Mincle, MCL, and the Mincle-citric acid complex. The structures revealed that these receptors are capable of interacting with sugar in a Ca(2+)-dependent manner, as observed in other C-type lectins. However, Mincle and MCL uniquely possess shallow hydrophobic regions found adjacent to their putative sugar binding sites, which reasonably locate for recognition of fatty acid moieties of glycolipids. Functional studies using mutant receptors as well as glycolipid ligands support this deduced binding mode. These results give insight into the molecular mechanism of glycolipid recognition through C-type lectin receptors, which may provide clues to rational design for effective adjuvants.

Cord factor (trehalose 6,6'-dimycolate) forms fully stable and non-permeable lipid bilayers required for a functional outer membrane.

Cord factor (trehalose 6,6'-dimycolate, TDM) is the major lipid in the outer membrane of Corynebacteria and Mycobacteria. Although its role is well recognized in the immune response phenomena, its membrane biophysical properties remained largely unexplored and TDM has often been described as a detergent. We purified the main components of the outer membrane from Corynebacterium glutamicum and analyzed their membrane forming properties. In mixture with endogenous cardiolipin, but not alone, the spontaneous hydration of TDM produces liposomes. As a pure component, TDM formed vesicles only by the detergent dialysis method. Perdeuterated cardiolipin-TDM mixtures were shown by deuterium nuclear magnetic resonance (NMR) to exhibit a gel to liquid crystalline phase transition over a 273-295K temperature range, for cells grown at 303K, and thus to be in a liquid crystalline state at physiological temperature. Molecular dynamics simulations of hydrated TDM bilayers provided the trehalose average orientation and conformation, the chain order parameters, the area per lipid and the bilayer thickness which was confirmed by electron microscopy. Finally the Porin A-Porin H ion channel from the Corynebacterial outer membrane was reconstituted in TDM liposomes. With properly mycoloylated proteins, it manifested the typical voltage dependent ion channel properties of an outer membrane porin.

The Mincle-activating adjuvant TDB induces MyD88-dependent Th1 and Th17 responses through IL-1R signaling.

Successful vaccination against intracellular pathogens requires the generation of cellular immune responses. Trehalose-6,6-dibehenate (TDB), the synthetic analog of the mycobacterial cord factor trehalose-6,6-dimycolate (TDM), is a potent adjuvant inducing strong Th1 and Th17 immune responses. We previously identified the C-type lectin Mincle as receptor for these glycolipids that triggers the FcRγ-Syk-Card9 pathway for APC activation and adjuvanticity. Interestingly, in vivo data revealed that the adjuvant effect was not solely Mincle-dependent but also required MyD88. Therefore, we dissected which MyD88-dependent pathways are essential for successful immunization with a tuberculosis subunit vaccine. We show here that antigen-specific Th1/Th17 immune responses required IL-1 receptor-mediated signals independent of IL-18 and IL-33-signaling. ASC-deficient mice had impaired IL-17 but intact IFNγ responses, indicating partial independence of TDB adjuvanticity from inflammasome activation. Our data suggest that the glycolipid adjuvant TDB triggers Mincle-dependent IL-1 production to induce MyD88-dependent Th1/Th17 responses in vivo.

Exposure to a cutinase-like serine esterase triggers rapid lysis of multiple mycobacterial species.

Mycobacteria are shaped by a thick envelope made of an array of uniquely structured lipids and polysaccharides. However, the spatial organization of these molecules remains unclear. Here, we show that exposure to an esterase from Mycobacterium smegmatis (Msmeg_1529), hydrolyzing the ester linkage of trehalose dimycolate in vitro, triggers rapid and efficient lysis of Mycobacterium tuberculosis, Mycobacterium bovis BCG, and Mycobacterium marinum. Exposure to the esterase immediately releases free mycolic acids, while concomitantly depleting trehalose mycolates. Moreover, lysis could be competitively inhibited by an excess of purified trehalose dimycolate and was abolished by a S124A mutation affecting the catalytic activity of the esterase. These findings are consistent with an indispensable structural role of trehalose mycolates in the architectural design of the exposed surface of the mycobacterial envelope. Importantly, we also demonstrate that the esterase-mediated rapid lysis of M. tuberculosis significantly improves its detection in paucibacillary samples.

Development of vizantin, a safe immunostimulant, based on the structure-activity relationship of trehalose-6,6'-dicorynomycolate.

Vizantin, 6,6'-bis-O-(3-nonyldodecanoyl)-α,α'-trehalose, was developed as a safe immunostimulator on the basis of a structure-activity relationship (SAR) study with trehalose 6,6'-dicorynomycolate (TDCM). It was possible to synthesize vizantin on a large scale more easily than in the case of TDCM, and the compound exhibited more potent prophylactic effect on experimental lung metastasis of B16-F0 melanoma cells. Because vizantin stimulated human macrophages, it is a promising candidate for clinical application.