A thermostable glucose oxidase from Aspergillus heteromophus CBS 117.55 with broad pH stability and digestive enzyme resistance.

In this study, the heterologous expression of an engineered thermostablle glucose oxidase from Aspergillus heteromophus CBS 117.55 was achieved in P. pastoris. This recombinant GoxAh was thermostable, with an optimal temperature range 25 °C-65 °C, and it was capable of retaining greater than 90% of its initial activity following a 10-min incubation at 75 °C. This enzyme had an optimum pH of 6.0, and it could retain above 80% of its initial activity following a 2-h incubation at a broad pH range (2.0-8.0). Moreover, GoxAh displayed excellent pepsin and trypsin resistance, and highly resistant to a range of tested metal ions and chemical reagents. These good properties make GoxAh a promising candidate for feed additive. The Km and kcat/Km values of GoxAh were 187 mM and 1.09/mM/s, which limited its widespread application to some degree. However, due to its excellent characteristics, GoxAh is still of potential economic value for high value-added areas, as well as a good initial enzyme for developing applicable feed enzyme by protein engineering.

In silico and in vivo analysis of signal peptides effect on recombinant glucose oxidase production in nonconventional yeast Yarrowia lipolytica.

Signal peptide (SP) is an important factor and biobrick in the production and secretion of recombinant proteins. The aim of this study was in silico and in vivo analysis of SPs effect on the production of recombinant glucose oxidase (GOX) in Yarrowia lipolytica. Several in silico softwares, namely SignalP4, Signal-CF, Phobius, WolfPsort 0.2, SOLpro and ProtParam, were used to analyse the potential of 15 endogenous and exogenous SPs for the secretion of recombinant GOX in Y. lipolytica. According to in silico results, the SP of GOX was predicted as suitable in terms of high secretory potential and of protein solubility and stability which is chosen for in vivo analysis. The recombinant Y. lipolytica strain produced 280 U/L of extracellular GOX after 7 days in YPD medium. The results show that the SP of GOX can be applied to efficient production of extracellular heterologous proteins and metabolic engineering in Y. lipolytica.

High-content screening of Aspergillus niger with both increased production and high secretion rate of glucose oxidase.

OBJECTIVES: To develop a rapid, dual-parameter, plate-based screening process to improve production and secretion rate of glucose oxidase simultaneously in Aspergillus niger. RESULTS: A morphology engineering based on CaCO3 was implemented, where the yield of GOD by A. niger was increased by up to 50%. Analysis of extracellular GOD activity was achieved in 96-well plates. There was a close negative correlation between the total GOD activity and its residual glucose of the fermentation broth. Based on this, a rapid, plate-based, qualitative analysis method of the total GOD activity was developed. Compared with the conventional analysis method using o-dianisidine, a correlation coefficient of -0.92 by statistical analysis was obtained. CONCLUSION: Using this dual-parameter screening method, we acquired a strain with GOD activity of 3126 U l-1, which was 146% higher than the original strain. Its secretion rate of GOD was 83, 32% higher than the original strain.

Extremely low frequency magnetic field enhances glucose oxidase expression in Pichia pastoris GS115.

In this study attempts were made to investigate the effect of extremely low frequency magnetic field (ELF-MF) on expression of glucose oxidase gene from Aspergillus niger Z-25 in Pichia pastoris GS115 at optimal environmental conditions. GOX encoding gene from A. niger was expressed in P. pastoris GS115 employing methanol inducible AOX1 promoter. From resistant transformants to high zeocin concentrations, maximum GOX expressing transformant was isolated and used throughout the study. Optimal environmental conditions for achieving maximum glucose oxidase (GOX) production was determined by varying temperature (20-30°C) and final methanol concentration from 0.25-1% (v/v). Maximum GOX production was obtained at 20°C and 0.25% (v/v) final methanol concentration. Exposure carried out at extremely low frequencies ranging from 1 to 5Hz and the field strength of 30-100mT unceasingly. Biomass, GOX, protease productions and cell viability were examined in exposed and non-exposed groups every 12h up to 96h. Among different exposure conditions, the frequency of 2.8Hz significantly increased GOX production and cell viability, decreased non-specific protease activity and improved biomass production regardless of changes in field intensity. Overall, supported by results, P. pastoris exposure to ELF-MF in certain circumstances could effectively further increase maximum production of GOX as achieved by optimized preliminary environmental parameters.

[High-level production of glucose oxidase by recombinant Pichia pastoris using a combined strategy].

To enhance the production of glucose oxidase by recombinant Pichia pastoris, two strategies were developed, which were namely co-feeding of methanol and sorbitol and co-expressing of the protein disulfide isomerase (PDI) and Vitreoscialla hemoglobin (VHb). The volumetric activity reached 456 U/mL by using the strain X33/pPIC9k-GOD, in 5 liter fermentator, with the co-feeding of methanol and sorbitol, it was 0.2 fold higher than that only feeding by methanol. The improved strain was obtained by co-expressing PDI-VHb with GOD. While fermented in a 5 liter fermentator by feeding methanol and sorbitol, the activity of the improved strain reached 716 U/mL with a yield of 7 400 mg/L total soluble protein concentration. These results indicated that heterologous protein expression level can be enhanced by optimizing fermentation condition and co-expression molecular chaperon in Pichia pastoris.

Biocontrol of tomato plant diseases caused by Fusarium solani using a new isolated Aspergillus tubingensis CTM 507 glucose oxidase.

The present study focuses on the potential of glucose oxidase (GOD) as a promising biocontrol agent for fungal plant pathogens. In fact, a new GOD producing fungus was isolated and identified as an Aspergillus tubingensis. GOD (125 AU) has been found to inhibit Fusarium solani growth and spore production. Indeed, GOD caused the reduction of spores, the formation of chlamydospores, the induction of mycelial cords and the vacuolization of mycelium. In vivo assays, GOD acted as a curative treatment capable of protecting the tomato plants against F. solani diseases. In fact, the incidence was null in the curative treatment with GOD and it is around 45% for the preventive treatment. The optimization of media composition and culture conditions led to a 2.6-fold enhancement in enzyme activity, reaching 81.48U/mL. This study has demonstrated that GOD is a potent antifungal agent that could be used as a new biofungicide to protect plants from diseases.

Quantitative Collection and Enzymatic Activity of Glucose Oxidase Nanotubes Fabricated by Templated Layer-by-Layer Assembly.

We report on the fabrication of enzyme nanotubes in nanoporous polycarbonate membranes via the layer-by-layer (LbL) alternate assembly of polyethylenimine (PEI) and glucose oxidase (GOX), followed by dissolution of the sacrificial template in CH2Cl2, collection, and final dispersion in water. An adjuvant-assisted filtration methodology is exploited to extract quantitatively the nanotubes without loss of activity and morphology. Different water-soluble CH2Cl2-insoluble adjuvants are tested for maximal enzyme activity and nanotube stability; whereas NaCl disrupts the tubes by screening electrostatic interactions, the high osmotic pressure created by fructose also contributes to loosening the nanotubular structures. These issues are solved when using neutral, high molar mass dextran. The enzymatic activity of intact free nanotubes in water is then quantitatively compared to membrane-embedded nanotubes, showing that the liberated nanotubes have a higher catalytic activity in proportion to their larger exposed surface. Our study thus discloses a robust and general methodology for the fabrication and quantitative collection of enzymatic nanotubes and shows that LbL assembly provides access to efficient enzyme carriers for use as catalytic swarming agents.

Electrochemical Glucose Biosensor Based on Glucose Oxidase Displayed on Yeast Surface.

The conventional enzyme-based biosensor requires chemical or physical immobilization of purified enzymes on electrode surface, which often results in loss of enzyme activity and/or fractions immobilized over time. It is also costly. A major advantage of yeast surface display is that it enables the direct utilization of whole cell catalysts with eukaryote-produced proteins being displayed on the cell surface, providing an economic alternative to traditional production of purified enzymes. Herein, we describe the details of the display of glucose oxidase (GOx) on yeast cell surface and its application in the development of electrochemical glucose sensor. In order to achieve a direct electrochemistry of GOx, the entire cell catalyst (yeast-GOx) was immobilized together with multiwalled carbon nanotubes on the electrode, which allowed sensitive and selective glucose detection.

High-level extracellular production of glucose oxidase by recombinant Pichia pastoris using a combined strategy.

In this work, a combined strategy was developed to improve the production of glucose oxidase (GOD) (EC 1.1.3.4) in Pichia pastoris. One of the main challenges facing protein production by the high-density fermentation of P. pastoris is the high demand for oxygen. Another challenge is how to balance a reduction in oxygen consumption and its effects on protein production. Herein, a combined strategy involving mannitol co-feeding, two-stage methanol induction, and the co-expression of the transcriptional activator general control non-derepressible 4 (GCN4) from P. pastoris was used. A two-stage, co-feeding strategy, based on a mannitol/methanol mixture in a 3-L fermentor was used to enhance cell viability and protein production. This resulted in an increased GOD yield of 1208.2 U/mL compared with a control strain (427.6 U/mL). An increase in the copy number of the GCN4 gene enhanced the GOD yield (1634.7 U/mL) by 2.8-fold and the protein concentration (19.55 g/L) by 1.58-fold compared with the control (7.59 g/L). This strategy illustrates a way to overcome the high oxygen requirement during high-density fermentation of P. pastoris and balances the reduction of oxygen consumption and protein production. Moreover, the series of strategies presented in this work provide valuable and novel information for the industrial production of GOD.

Multivariate modular engineering of the protein secretory pathway for production of heterologous glucose oxidase in Pichia pastoris.

Limitations in protein production and secretion have been attributed to the inefficient folding rate of overexpressed proteins and the cellular response to the presence of overexpressed proteins in the endoplasmic reticulum (ER). In this study, we improved the yield of glucose oxidase (GOD) by manipulating genes involved in protein folding machinery and abnormal folding stress responses. First, genes with folding and secretion functions were used to modulate the folding rate of GOD in the ER and its secretion level in the cytoplasm. Next, the potential benefits of the ERAD elements were determined. Cellular resistance to ER derived stress was then strengthened by overexpressing the stress response gene GCN4. Furthermore, a module combination strategy, which co-expressed the SEC53, CNE1 and GCN4 genes, was employed to construct the Pichia pastoris strain S17. This increased the yield of GOD to 21.81g/L, with an activity of 1972.9U/mL, which were 2.53- and 5.11-fold higher, respectively, than the control strain. The work described here improved GOD production significantly, and the strategies employed in this study provide novel information for the large-scale production of heterologous proteins.

Production and characterization of recombinant glucose oxidase from Aspergillus niger expressed in Pichia pastoris.

UNLABELLED: Recombinant glucose oxidase from Aspergillus niger expressed in Pichia pastoris by fed-batch fermentation was purified and assessed with 1·26 purification fold to homogeneity using Q-Sepharose F.F. chromatography. The enzyme was determined by SDS-PAGE and gradient PAGE, which showed a dimeric form of 150 kDa. The purified rGOD was proved to be a glycoprotein, and the content of which was estimated to be 36·7 and 25·14% by phenol-sulfuric acid and anthrone-sulfuric acid methods. Characteristics demonstrated that the highest activity was in pH 6·0 at 40°C and was stable at a broad pH range from 4·0 to 9·0 at 55°C or below. The optimum substrate for this enzyme was d-glucose, and the Km was 21·06 mmol l(-1) as well as the Vmax was 359 µmol min(-1) mg(-1). rGOD possessed high resistance to various chemicals except for Hg(2+), Fe(2+), Ag(+), Cu(2+), 1,4-dithiothreitol, sodium dodecyl sulfate and ascorbic acid. In addition, the inhibitors also exhibited intensive fluorescence quenching effect on rGOD. SIGNIFICANCE AND IMPACT OF THE STUDY: Glucose oxidase is a very important enzyme produced by several species. However, large-scale applications have always been postponed by its complexity in fermentation and purification. Our research focused on developing new purification strategy of recombinant GOD from A. niger expressed in P. pastoris. Here, we described this novel one-step purification method and subsequent research in the characteristics of rGOD which showed different results from previous work. These can open new opportunities to increase its application.

Cloning, heterologous expression, purification and characterization of M12 mutant of Aspergillus niger glucose oxidase in yeast Pichia pastoris KM71H.

Aspergillus niger glucose oxidase (GOx) genes for wild-type (GenBank accession no. X16061, swiss-Prot; P13006) and M12 mutant (N2Y, K13E, T30 V, I94 V, K152R) were cloned into pPICZαA vector for expression in Pichia pastoris KM71H strain. The highest expression level of 17.5 U/mL of fermentation media was obtained in 0.5 % (v/v) methanol after 9 days of fermentation. The recombinant GOx was purified by cross-flow ultrafiltration using membranes of 30 kDa molecular cutoff and DEAE ion-exchange chromatography at pH 6.0. Purified wt GOx had k cat of 189.4 s⁻¹ and K(m) of 28.26 mM while M12 GOx had k cat of 352.0 s⁻¹ and K m of 13.33 mM for glucose at pH 5.5. Specificity constants k(cat)/K(m) of wt (6.70 mM⁻¹ s⁻¹) and M12 GOx (26.7 mM⁻¹ s⁻¹) expressed in P. pastoris KM71H were around three times higher than for the same enzymes previously expressed in Saccharomyces cerevisiae InvSc1 strain. The pH optimum and sugar specificity of M12 mutant of GOx remained similar to the wild-type form of the enzyme, while thermostability was slightly decreased. M12 GOx expressed in P. pastoris showed three times higher activity compared to the wt GOx toward redox mediators like N,N-dimethyl-nitroso-aniline used for glucose strips manufacturing. M12 mutant of GOx produced in P. pastoris KM71H could be useful for manufacturing of glucose biosensors and biofuel cells.

[Effects of mixed carbon sources on glucose oxidase production by recombinant Pichia pastoris].

Glucose oxidase (GOD) is an important industrial enzyme with many potential applications. In order to increase the production and productivity of GOD by recombinant Pichia pastoris GS115, we investigated the feeding strategies of mixed carbon sources during induction phase, based on results of the optimization of initial cell and methanol concentration on GOD production. The optimal initial cell and methanol concentration were 100 g/L and 18 g/L. During induction phase, the mixed-carbon-sources strategies showed that glycerol, sorbitol or mannitol co-feeding with methanol could enhance GOD production. With mannitol co-feeding (20:1(W/W)), the maximum GOD production and maximum GOD productivity reached 711.3 U/mL and 4.60 U/(mL x h) after an induction period of 156 h. Compared to the control, the enhancements of GOD production and productivity were 66.3% and 67.9%, respectively. Meanwhile, we found an appropriate mannitol co-feeding strategy that would not inhibit the expression of promote. The activity of alcohol oxidase was 8.8 U/g, which was enhanced by 69.2% compared to the control (5.2 U/g). We can use the same optimization process to improve the production of other proteins from recombinant Pichia pastoris by changing the fermentation parameters.

Optimization of complex fermentation media for glucose oxidase production using statistical approach.

Production cost of enzyme is largely determined by the type of the strain and raw material used to propagate the strain. Hence, selection of the strain and raw materials is crucial in enzyme production. For Glucose oxidase (GOx), previous studies showed Aspergillus terreus UniMAP AA-1 offers a better alternative to the existing sources. Thus, a lower production cost could be logically anticipated by growing the strain in a cheaper complex media such as molasses. In this work, sugar cane molasses, supplemented with urea and carbonate salt and a locally isolated strain Aspergillus terreus UniMAP AA-1 were used to produce a crude GOx enzyme in a small scale. A statistical optimization approach namely Response Surface Methodology (RSM) was used to optimize the media components for highest GOx activity. It was found that the highest GOx activity was achieved using a combination of molasses, carbonate salt and urea at concentration 32.51, 4.58 and 0.93% (w/v), respectively. This study provides an alternative optimized media conditions for GOx production using locally available raw materials.

Protein-carbon nanotube sensors: single platform integrated micro clinical lab for monitoring blood analytes.

Design of a unique, single-platform, integrated, multichannel sensor based on carbon nanotube (CNT)-protein adducts specific to each one of the major analytes of blood, glucose, cholesterol, triglyceride, and Hb1AC is presented. The concept underlying the sensor, amperometric detection, is applicable to various disease-monitoring strategies. There is an urgent need to enhance the sensitivity of glucometers to <5% level instead of greater than the present 15% standard in these detectors. CNTs enhance the signals derived from the interaction of the enzymes with the different analytes in blood. Fabricated sensors using the new methodology is a point-of-care device that is targeted for home, clinical, and emergency use and can be redesigned for continuous monitoring for critical care patients.

Utilization of ram horn peptone in the production of glucose oxidase by a local isolate Aspergillus niger OC-3.

Glucose oxidase (GO) is an enzyme that is used in many fields. In this study, ram horn peptone (RHP) was utilized as the nitrogen source and compared with other nitrogen sources in the production of GO by Aspergillus niger. To obtain higher GO activity, 14 A. niger strains were isolated from soil samples around Erzurum, Turkey. Among these strains, the isolate that was named A. niger OC-3 achieved the highest GO production. The production of GO was carried out in 100 mL scaled batch culture. The fermentation conditions such as initial pH, temperature, agitation speed, and time were investigated in order to improve GO production. The results showed that the cultivation conditions would significantly affect the formation of GO, and the utilization of the RHP achieved the highest enzyme production (48.6 U/mL) if compared to other nitrogen sources. On the other hand, the maximum biomass was obtained by using the fish peptone (7.2 g/L), while RHP yielded 6.4 g/L. These results suggest that RHP from waste ram horns could effectively be used in the production of GO by A. niger OC-3.

Diet-specific salivary gene expression and glucose oxidase activity in Spodoptera exigua (Lepidoptera: Noctuidae) larvae.

Saliva secreted during caterpillar feeding contains enzymes to initiate digestion or detoxify noxious plant compounds. Activity of some salivary enzymes is diet-dependent and may be transcriptionally regulated. In this study, cDNA-amplified fragment length polymorphism was used to identify beet armyworm, Spodoptera exigua Hübner, labial salivary genes that are differentially expressed in response to diet. In addition, SeGOX was sequenced based on homology and characterized to confirm that the transcript encodes a functional enzyme. Three labial salivary transcripts, encoding glucose oxidase (GOX) and two proteins of unknown function (Se1H and Se2J), were expressed in a diet-specific manner. Since diet, particularly the protein to digestible carbohydrate levels and ratio, may affect labial salivary enzyme activity, the influence of nutritional quality on gene expression was determined. Transcript levels of the labial salivary genes Se1H, Se2J and SeGOX increased with dietary carbohydrate levels, regardless of protein concentrations. In contrast GOX enzymatic activity increased with increasing dietary carbohydrates when caterpillars were fed protein-rich diets, but not when caterpillars were fed protein-poor diets. Our results suggest that dietary carbohydrates affect SeGOX, Se1H and Se2J transcription, but dietary protein or amino acid levels affect translational and/or post-translational regulation of the enzyme GOX.

Spores of Aspergillus niger as reservoir of glucose oxidase synthesized during solid-state fermentation and their use as catalyst in gluconic acid production.

AIMS: To exploit conidiospores of Aspergillus niger as a vector for glucose oxidase extraction from solid media, and their direct use as biocatalyst in the bioconversion of glucose to gluconic acid. METHODS AND RESULTS: Spores of A. niger (200 h old) were shown to fully retain all the glucose oxidase synthesized by the mycelium during solid-state fermentation (SSF). They acted as catalyst and carried out the bioconversion reaction effectively, provided they were permeabilized by freezing and thawing. Glucose oxidase activity was found retained in the spores even after repeated washings. Average rate of reaction was 1.5 g l(-1) h(-1) with 102 g l(-1) of gluconic acid produced out of 100 g l(-1) glucose consumed after approx. 100 h reaction, which corresponded to a molar yield close to 93%. These results were obtained with permeabilized spores in the presence of a germination inhibitor, sodium azide. CONCLUSIONS: Spores of A. niger served as efficient catalyst in the model bioconversion reaction after permeabilization. SIGNIFICANCE AND IMPACT OF THE STUDY: To our knowledge, this is the first detailed study on the ability of A. niger spores to act as reservoir of enzyme synthesized during SSF without its release into solid media. Use of this material served as an innovative concept for enzyme extraction and purification from a solid medium. Moreover, this approach could compete efficiently with the conventional use of mycelial form of the fungus in gluconic acid production.

Variations in protein glycosylation in Hansenula polymorpha depending on cell culture stage.

A simple way to prevent protein hyperglycosylation in Hansenula polymorpha was found. When glucose oxidase from Aspergillus niger and carboxymethyl cellulase from Bacillus subtilis were expressed under the control of an inducible methanol oxidase (MOX) promoter using methanol as a carbon source, hyperglycosylated forms occurred. In contrast, MOX-repressing carbon sources (e.g., glucose, sorbitol, and glycerol) greatly reduced the extent of hyperglycosylation. Carbon source starvation of the cells also reduced the level of glycosylation, which was reversed to hyperglycosylation by the resumption of cell growth. It was concluded that the proteins expressed under actively growing conditions are produced as hyperglycosylated forms, whereas those under slow or nongrowing conditions are as short-glycosylated forms. The prevention of hyperglycosylation in the Hansenula polymorpha expression system constitutes an additional advantage over the traditional Saccharomyces cerevisiae system in recombinant production of glycosylated proteins.