RESUMO
The discovery of eco-friendly, rapid, and cost-effective compounds to control diseases caused by microbes and insects are the main challenges. Herein, the magnesium oxide nanoparticles (MgO-NPs) are successfully fabricated by harnessing the metabolites secreted by Penicillium chrysogenum. The fabricated MgO-NPs were characterized using UV-Vis, XRD, TEM, DLS, EDX, FT-IR, and XPS analyses. Data showed the successful formation of crystallographic, spherical, well-dispersed MgO-NPs with sizes of 7-40 nm at a maximum wavelength of 250 nm. The EDX analysis confirms the presence of Mg and O ions as the main components with weight percentages of 13.62% and 7.76%, respectively. The activity of MgO-NPs as an antimicrobial agent was investigated against pathogens Staphylococcus aureus, Bacillus subtilis, Pseudomonas aeruginosa, Escherichia coli, and Candida albicans, and exhibited zone of inhibitions of 12.0 ± 0.0, 12.7 ± 0.9, 23.3 ± 0.8, 17.7 ± 1.6, and 14.7 ± 0.6 mm respectively, at 200 µg mL-1. The activity is decreased by decreasing the MgO-NPs concentration. The biogenic MgO-NPs exhibit high efficacy against different larvae instar and pupa of Anopheles stephensi, with LC50 values of 12.5-15.5 ppm for I-IV larvae instar and 16.5 ppm for the pupa. Additionally, 5 mg/cm2 of MgO-NPs showed the highest protection percentages against adults of Anopheles stephensi, with values of 100% for 150 min and 67.6% ± 1.4% for 210 min.
Assuntos
Anopheles/efeitos dos fármacos , Anti-Infecciosos/farmacologia , Inseticidas/farmacologia , Óxido de Magnésio/farmacologia , Penicillium chrysogenum/crescimento & desenvolvimento , Animais , Anti-Infecciosos/química , Anti-Infecciosos/isolamento & purificação , Bacillus subtilis/efeitos dos fármacos , Candida albicans/efeitos dos fármacos , Cristalografia por Raios X , Escherichia coli/efeitos dos fármacos , Química Verde , Inseticidas/química , Inseticidas/isolamento & purificação , Larva/efeitos dos fármacos , Óxido de Magnésio/química , Óxido de Magnésio/isolamento & purificação , Metabolômica , Nanopartículas Metálicas/química , Nanopartículas Metálicas/ultraestrutura , Testes de Sensibilidade Microbiana , Tamanho da Partícula , Penicillium chrysogenum/química , Pseudomonas aeruginosa/efeitos dos fármacos , Pupa/efeitos dos fármacos , Staphylococcus aureus/efeitos dos fármacosRESUMO
AIMS: This paper aims to quantify the growth and organic acid production of Aspergillus niger, Penicillium chrysogenum and Penicillium simplicissimum when these fungi are exposed to varying levels of lithium (Li) and cobalt (Co). The study also tests whether pre-exposing the fungi to these metals enables the fungi to develop tolerance to Li or Co. METHODS AND RESULTS: When cultures of A. niger, P. chrysogenum or P. simplicissimum were exposed to 250 mg l-1 of Li or Co, biomass production and excretion of organic acids were significantly inhibited after 5 days of growth compared to cultures grown in the absence of these metals. Pre-exposing cultures of A. niger to 250 mg l-1 of Li or Co for 20 days significantly increased biomass production when the fungus was subsequently sub-cultured into 250 or 500 mg l-1 of Li or Co. However, pre-exposure of P. chrysogenum or P. simplicissimum to 250 mg l-1 of Li or Co for 20 days did not increase biomass production. CONCLUSIONS: Aspergillus niger, but not the Penicillium species, developed tolerance to Li and to Co during the 20-day pre-exposure period. Therefore, processes that utilize fungal bioleaching with A. niger to mobilize and recover valuable metals such as Li or Co should consider a pre-exposure step for fungi to improve their tolerance to metal toxicity. SIGNIFICANCE AND IMPACT OF THE STUDY: Fungi may have the ability to extract valuable metals such as Li and Co from spent rechargeable batteries. However, the toxicity of the extracted metals can inhibit fungal growth and organic acid production. Pre-exposure to metals may alleviate toxicity for some fungal species. This knowledge can be used to improve the design of bioleaching protocols, increasing the potential for fungal bioleaching to become an economical and environmentally friendly method of recovering Li and Co from spent batteries.
Assuntos
Cobalto/toxicidade , Fungos/efeitos dos fármacos , Lítio/toxicidade , Ácidos , Aspergillus niger/efeitos dos fármacos , Aspergillus niger/crescimento & desenvolvimento , Aspergillus niger/metabolismo , Biomassa , Fontes de Energia Elétrica , Íons , Compostos Orgânicos/metabolismo , Penicillium/efeitos dos fármacos , Penicillium/crescimento & desenvolvimento , Penicillium/metabolismo , Penicillium chrysogenum/efeitos dos fármacos , Penicillium chrysogenum/crescimento & desenvolvimento , Penicillium chrysogenum/metabolismoRESUMO
This study examined the toxicity and antimicrobial effects of ethanol and aqueous extracts from Amaranthus caudatus grown on soils formulated from parent particles of silt, sand and clay in a glasshouse. Four different soils namely; sandy clay loam, loam, clayey loam and silty clay loam from were formulated were used for cultivation with the unfractionated soil which was the control. Crude extracts obtained from the plant shoots harvested at different growth stages were tested on some certain gram-negative and gram-positive bacteria and some fungi via agar dilution assay. The toxicity of the water and ethanol extracts was also examined via Artemia salina assay and the level of lethality was measured against Clarkson's lethality scale. All aqueous samples, as well as ethanol extracts of flowering and pre-flowering harvests of control soil tested, were non-toxic (LC50 > 1 mg/mL). At post flowering, the ethanolic extracts were highly toxic mostly in clayey loam, control, sandy-clayey loam soils (LC50 < 0.5 mg/mL). Also, antifungal effects of the plant revealed that extracts inhibited the growth of Candida albicans significantly with mild effect on Candida glabrata, Penicillium chrysogenum and Penicillium aurantiogriseum suggesting that the plant is a promising pharmacological candidate in the treatment of candidiasis. For an optimal yield of non-toxic supplement for household consumption which may also serve as pharmacological precursors, clayey loam soil is recommended for cultivation and harvesting may occur at pre-flowering or flowering stage using ethanol and water as solvents of extraction.
Assuntos
Agricultura/métodos , Amaranthus , Antibacterianos/farmacologia , Antifúngicos/farmacologia , Candida albicans/efeitos dos fármacos , Penicillium/efeitos dos fármacos , Solo , Amaranthus/crescimento & desenvolvimento , Candida albicans/crescimento & desenvolvimento , Argila , Flores , Penicillium/crescimento & desenvolvimento , Penicillium chrysogenum/efeitos dos fármacos , Penicillium chrysogenum/crescimento & desenvolvimento , Extratos Vegetais/farmacologia , Brotos de Planta , AreiaRESUMO
Epigenetic regulation plays a critical role in controlling fungal secondary metabolism. Here, we report the pleiotropic effects of the epigenetic regulator HdaA (histone deacetylase) on secondary metabolite production and the associated biosynthetic gene clusters (BGCs) expression in the plant endophytic fungus Penicillium chrysogenum Fes1701. Deletion of the hdaA gene in strain Fes1701 induced a significant change of the secondary metabolite profile with the emergence of the bioactive indole alkaloid meleagrin. Simultaneously, more meleagrin/roquefortine-related compounds and less chrysogine were synthesized in the ΔhdaA strain. Transcriptional analysis of relevant gene clusters in ΔhdaA and wild strains indicated that disruption of hdaA had different effects on the expression levels of two BGCs: the meleagrin/roquefortine BGC was upregulated, while the chrysogine BGC was downregulated. Interestingly, transcriptional analysis demonstrated that different functional genes in the same BGC had different responses to the disruption of hdaA. Thereinto, the roqO gene, which encodes a key catalyzing enzyme in meleagrin biosynthesis, showed the highest upregulation in the ΔhdaA strain (84.8-fold). To our knowledge, this is the first report of the upregulation of HdaA inactivation on meleagrin/roquefortine alkaloid production in the endophytic fungus P. chrysogenum. Our results suggest that genetic manipulation based on the epigenetic regulator HdaA is an important strategy for regulating the productions of secondary metabolites and expanding bioactive natural product resources in endophytic fungi.
Assuntos
Ficus/microbiologia , Deleção de Genes , Histona Desacetilases/genética , Alcaloides Indólicos/metabolismo , Família Multigênica , Penicillium chrysogenum/metabolismo , Metabolismo Secundário , Produtos Biológicos/metabolismo , Células HL-60 , Histona Desacetilases/química , Histona Desacetilases/metabolismo , Humanos , Células K562 , Penicillium chrysogenum/genética , Penicillium chrysogenum/crescimento & desenvolvimentoRESUMO
Mineral building materials are porous materials. The volume of pores connected is the active volume of pores or the effective volume. The volume of all pores is the total volume of the pores. The properties of the individual pores are different. Their dimensions and shape can influence the properties of materials. Materials are modified with different admixtures to improve their properties. However, additives or admixtures can cause corrosion. Although building materials do not provide food for microorganisms, they are very often inhabited by them. As a result of their presence and the action of metabolic products, biodeterioration occurs. One of the products of metabolism is water. In this paper we investigated how the modified structure of biodeterioration caused by mould fungi affects the moisture content of cement-polymer mortar with the admixture of polysiloxane latex.
Assuntos
Materiais de Construção/microbiologia , Fungos/crescimento & desenvolvimento , Polímeros/química , Cladosporium/crescimento & desenvolvimento , Umidade , Penicillium chrysogenum/crescimento & desenvolvimento , Porosidade , Água/químicaRESUMO
Natamycin is a polyene macrolide antibiotic and widely used as a natural food preservative. Fungal elicitor had positive effects on the natamycin biosynthesis in Streptomyces natalensis HW-2. However, the global gene expression in response to fungal elicitor is not still reported. In the study, RNA-Seq was used to check the change of transcriptome by fungal elicitor in S. natalensis HW-2. The results showed that there were 1265 differential expression genes (DEGs) at 40 h and 2196 DEGs at 80 h. Most of the genes involved in natamycin biosynthesis were upregulated. KEGG pathway analysis showed that fungal elicitor had strong effects on the transcriptional levels of genes related to branch-chained amino acid (BCAA) metabolism. There were 23 upregulated or downregulated DEGs involved in BCAA biosynthesis and degradation at 40 h and 80 h. To confirm whether the improvement of BCAA biosynthesis could produce more natamycin, metabolic engineering was used to homologously overexpress the gene ilvH which encoded the regulatory subunit of acetolactate synthase (ALS) in S. natalensis. The results showed that overexpression of ilvH in S. natalensis HW-2 increased natamycin production to 1.25 g/L in the flask, which was a 32% increase compared with that of the parent strain. Real-time quantitative PCR analysis showed that the transcriptional level of ilvH in mutant strain S. natalensis ZS101 was significantly increased. Acetyl-CoA content was also raised. The results suggested that the fungal elicitor enhanced natamycin biosynthesis by improving precursor supply via BCAA metabolism. This study will open a new avenue for enhancing natamycin production by metabolic engineering and adding fungal elicitor. KEY POINTS: ⢠The fungal elicitor had strong effects on the transcriptional levels of genes related to branch-chained amino acid metabolism by RNA-Seq. ⢠The homologous overexpression of gene ilvH increased natamycin production by 32% and acetyl-CoA content was raised in mutant strain S. natalensis ZS101.
Assuntos
Aminoácidos de Cadeia Ramificada/metabolismo , Vias Biossintéticas/genética , Fungos/metabolismo , Regulação Bacteriana da Expressão Gênica , Natamicina/biossíntese , Streptomyces/genética , Antibacterianos/biossíntese , Vias Biossintéticas/efeitos dos fármacos , Meios de Cultura , Fermentação , Engenharia Metabólica , Penicillium chrysogenum/crescimento & desenvolvimento , Penicillium chrysogenum/metabolismo , RNA-Seq , Streptomyces/efeitos dos fármacos , Streptomyces/metabolismoRESUMO
BACKGROUND: Biomass growth of Pencillium chrysogenum is characterised by a distinct pellet morphology consisting of compact hyphal agglomerates. Fungal pellets are advantageous in industrial process control due to rheological advantages but lead to biomass degradation due to diffusional limitations of oxygen and substrate in the pellet's core. Several fermentation parameters are known to affect key pellet characteristics regarding morphology, viability and productivity. Pellet morphology and size are affected by agitation. Biomass viability and productivity are tightly interlinked with substrate uptake and dissolved oxygen concentration. RESULTS: The goal of this study was to study the impact of the fermentation parameters power input, dissolved oxygen content and specific substrate uptake rate on morphology, biomass viability and productivity. A design of experiments (DoE) approach was conducted and corresponding responses were analysed using novel morphological descriptors analysed by a previously established flow cytometry method. Results clearly display inverse correlations between power input and pellet size, specific morphological parameters related to pellet density can be increased in direct proportion to power input. Biomass viability and productivity are negatively affected by high specific substrate uptake rates. CONCLUSIONS: Based upon multiple linear regression, it was possible to obtain an optimal design space for enhanced viability and productivity at beneficial morphological conditions. We could maintain a high number of pellets with favourable morphology at a power input of 1500 W/m3. A sound compromise between viability and high productivity is possible at a specific glucose uptake rate of 0.043 g/g/h at dissolved oxygen levels of 40% minimum.
Assuntos
Técnicas de Cultura Celular por Lotes/métodos , Reatores Biológicos , Fermentação , Penicillium chrysogenum/crescimento & desenvolvimento , Oxigênio/metabolismo , ReologiaRESUMO
Real-time measurements and adjustments of critical process parameters are essential for the precise control of fermentation processes and thus for increasing both quality and yield of the desired product. However, the measurement of some crucial process parameters such as biomass, product, and product precursor concentrations usually requires time-consuming offline laboratory analysis. In this work, we demonstrate the in-line monitoring of biomass, penicillin (PEN), and phenoxyacetic acid (POX) in a Penicilliumchrysogenum fed-batch fermentation process using low-cost microspectrometer technology operating in the near-infrared (NIR). In particular, NIR reflection spectra were taken directly through the glass wall of the bioreactor, which eliminates the need for an expensive NIR immersion probe. Furthermore, the risk of contaminations in the reactor is significantly reduced, as no direct contact with the investigated medium is required. NIR spectra were acquired using two sensor modules covering the spectral ranges 1350-1650 nm and 1550-1950 nm. Based on offline reference analytics, partial least squares (PLS) regression models were established for biomass, PEN, and POX either using data from both sensors separately or jointly. The established PLS models were tested on an independent validation fed-batch experiment. Root mean squared errors of prediction (RMSEP) were 1.61 g/L, 1.66 g/L, and 0.67 g/L for biomass, PEN, and POX, respectively, which can be considered an acceptable accuracy comparable with previously published results using standard process spectrometers with immersion probes. Altogether, the presented results underpin the potential of low-cost microspectrometer technology in real-time bioprocess monitoring applications. Graphical abstract.
Assuntos
Acetatos/metabolismo , Penicilinas/metabolismo , Penicillium chrysogenum/metabolismo , Espectroscopia de Luz Próxima ao Infravermelho/métodos , Acetatos/análise , Técnicas de Cultura Celular por Lotes/instrumentação , Técnicas de Cultura Celular por Lotes/métodos , Biomassa , Reatores Biológicos , Desenho de Equipamento , Fermentação , Análise dos Mínimos Quadrados , Penicilinas/análise , Penicillium chrysogenum/química , Penicillium chrysogenum/crescimento & desenvolvimento , Espectroscopia de Luz Próxima ao Infravermelho/instrumentaçãoRESUMO
Filamentous fungi are well-established production hosts that feature a strong interconnection between morphology, physiology, and productivity. For penicillin production in Penicillium chrysogenum, industrial processes frequently favor a pellet morphology comprising compact hyphal agglomerates. Inherently these tightly packed entanglements lead to inactive, degrading sections within the pellet's core because of limitations. Optimal process design requires detailed knowledge of the nature of the limitations and localization of productive zones in the biomass, which is generally obtainable through modeling and complex analytical methods such as oxygen microelectrode and histological investigations. Methods that combine physiological and morphological insight are crucial yet scarce for filamentous fungi. In this study, we used time-of-flight secondary ion mass spectrometry in combination with oxygen and glucose tracer substrates, requiring little effort for sample preparation and measurement. Our method is capable of analyzing oxygen and substrate uptake in various morphological structures by the use of 18O as a tracer. In parallel, we can assess productive biomass regions through identification of penicillin mass fragments to simultaneously study oxygen diffusion, substrate incorporation, and productive biomass sections.
Assuntos
Penicillium chrysogenum/metabolismo , Biomassa , Fungos/crescimento & desenvolvimento , Fungos/metabolismo , Glucose/metabolismo , Oxigênio/metabolismo , Penicilinas/metabolismo , Penicillium chrysogenum/crescimento & desenvolvimento , Espectrometria de Massa de Íon SecundárioRESUMO
BACKGROUND: This study investigates the efficacy of short peptides secreted by Bacillus subtilis for fungal inhibition in fresh-cut pumpkin and for maintaining its shelf life. RESULTS: Low-molecular-weight filtrate (LC < 1000 Da) of B. subtilis culture (BC) significantly lowered the total number of molds on fresh-cut pumpkin compared with the untreated control and a BC group after storage. Low-molecular-weight filtrate prevented the deterioration of sensory quality in a pumpkin incision, and reduced pectinase activity. It also inhibited the growth of Phytophthora capsici and Penicillium chrysogenum, and the activity of ß-1,3-glucan synthase (GS) secreted by both molds. Fifty-seven GS-inhibiting peptides were screened from 95 LC peptides with two to five amino acid residues. The two most potent peptides, AWYW and HWWY, had strongly suppressive effects on the growth of P. capsici and P. chrysogenum. CONCLUSION: Our study demonstrated that short peptides present in B. subtilis culture can play an important role in the maintenance of fresh-cut pumpkin by suppressing fungal growth. © 2019 Society of Chemical Industry.
Assuntos
Bacillus subtilis/química , Cucurbita/microbiologia , Fungos/efeitos dos fármacos , Fungicidas Industriais/farmacologia , Peptídeos/farmacologia , Bacillus subtilis/metabolismo , Frutas/microbiologia , Fungos/crescimento & desenvolvimento , Fungicidas Industriais/química , Fungicidas Industriais/metabolismo , Penicillium chrysogenum/efeitos dos fármacos , Penicillium chrysogenum/crescimento & desenvolvimento , Peptídeos/química , Peptídeos/metabolismo , Phytophthora/efeitos dos fármacos , Phytophthora/crescimento & desenvolvimento , Doenças das Plantas/microbiologiaRESUMO
Targeted, quantitative metabolomics can, in principle, provide precise information on intracellular metabolite levels, which can be applied to accurate modeling of intracellular processes required in systems biology and metabolic engineering. However, quantitative metabolite profiling is often hampered by biased mass spectrometry-based analyses caused by matrix effects, the degradation of metabolites and metabolite leakage during sample preparation, and unexpected variation in instrument responses. Isotope Dilution Mass Spectrometry (IDMS) has been proven as the most accurate method for high-throughput detection of intracellular metabolite concentrations, and the key has been the acquisition of the corresponding fully uniformly (U) -13C-labeled metabolites to be measured. Here, we have prepared U-13C-labeled cell extracts by cultivating P. chrysogenum in a fed-batch fermentation with fully U-13C-labeled substrates. Towards this goal, a dynamic fed-batch model describing P. chrysogenum growth and penicillin production was used to simulate the fermentation process and design the fed-batch fermentation media. Further, a case study with extensive intracellular metabolomics data from glucose-limited cultivation of Penicillium chrysogenum under both single and repetitive glucose pulses was illustrated by using the IDMS methods with the prepared U-13C-labeled cell extracts as internal standards. In conclusion, the IDMS method can be incorporated into well-established fast sampling and quenching protocols to obtain dynamic quantitative in vivo metabolome data at the timescales of (tens of) seconds and elucidate the underlying regulatory architecture. The case study revealed gross differences between single and repeated pulses, which suggests that single pulse studies have limited value for understanding of metabolic responses in large-scale bioreactors. Instead, intermittent feeding should be favored.
Assuntos
Isótopos de Carbono/metabolismo , Glucose/metabolismo , Metabolômica/métodos , Penicillium chrysogenum/crescimento & desenvolvimento , Técnicas de Cultura Celular por Lotes , Fermentação , Espectrometria de Massas , Penicillium chrysogenum/metabolismoRESUMO
During glucose-limited growth, a substantial input of adenosine triphosphate (ATP) is required for the production of ß-lactams by the filamentous fungus Penicillium chrysogenum. Formate dehydrogenase has been confirmed in P. chrysogenum for formate oxidation allowing an extra supply of ATP, and coassimilation of glucose and formate has the potential to increase penicillin production and biomass yield. In this study, the steady-state metabolite levels and fluxes in response to cofeeding of formate as an auxiliary substrate in glucose-limited chemostat cultures at the dilution rates (D) of both 0.03 h-1 and 0.05 h-1 are determined to evaluate the quantitative impact on the physiology of a high-yielding P. chrysogenum strain. It is observed that an equimolar addition of formate is conducive to an increase in both biomass yield and penicillin production at D = 0.03 h-1 , while this is not the case at D = 0.05 h-1 . In addition, a higher cytosolic redox status (NADH/NAD+ ), a higher intracellular glucose level, and lower penicillin productivity are only observed upon formate addition at D = 0.05 h-1 , which are virtually absent at D = 0.03 h-1 . In conclusion, the results demonstrate that the effect of formate as an auxiliary substrate on penicillin productivity in the glucose-limited chemostat cultivations of P. chrysogenum is not only dependent on the formate/glucose ratio as published before but also on the specific growth rate. The results also imply that the overall process productivity and quality regarding the use of formate should be further explored in an actual industrial-scale scenario.
Assuntos
Reatores Biológicos/microbiologia , Metabolômica/métodos , Penicillium chrysogenum/crescimento & desenvolvimento , Formiato Desidrogenases/metabolismo , Formiatos/metabolismo , Proteínas Fúngicas/metabolismo , Glucose/metabolismo , Hidrogenase/metabolismo , Complexos Multienzimáticos/metabolismo , Penicilinas/metabolismo , Penicillium chrysogenum/química , Estresse FisiológicoRESUMO
Multi-strain mixed fermentation can provide a relatively complete lignocellulosic enzyme system compared with single-strain fermentation. This study was firstly to screen strains which have a strong ability to hydrolyse rice straw (RS) enzymatically and enrich true protein (TP). Then, the conditions in the process of SSF, including the optimum inoculum size of mixed strains, inoculation ratio, and different inoculation time of N. crassa 14-8, were optimized. The experimental results showed that the highest TP content could be obtained by using N. crassa 14-8, C. utilis, and P. chrysosporium as mixed strains, and 5 mM Mn2+ and 50 mM veratryl alcohol were used as inducers of lignin peroxidase (LiP) to improve the efficiency of enzymatic hydrolysis. When N. crassa 14-8 was inoculated 1 day later than P. chrysosporium, the total inoculum size was 10%, and the optimum ratio of N. crassa 14-8 to P. chrysosporium was 1:2, the maximum TP yield (8.89%) was obtained, with 123.37% of its increase rate. This work proposed a technique with potential application in large-scale feedstuff protein conversion.
Assuntos
Candida/crescimento & desenvolvimento , Proteínas Fúngicas/biossíntese , Neurospora crassa/crescimento & desenvolvimento , Oryza/química , Penicillium chrysogenum/crescimento & desenvolvimentoRESUMO
Calcium ions (Ca2+) play an important role in the toxicity of the cysteine-rich and cationic antifungal protein PAF from Penicillium chrysogenum: high extracellular Ca2+ levels reduce the toxicity of PAF in the sensitive model fungus Neurospora crassa in a concentration dependent way. However, little is known about the mechanistic details of the Ca2+ ion impact and the Ca2+ binding capabilities of PAF outside the fungal cell, which might be the reason for the activity loss. Using nuclear magnetic resonance (NMR), isothermal titration calorimetry and molecular dynamics (MD) simulations we demonstrated that PAF weakly, but specifically binds Ca2+ ions. MD simulations of PAF predicted one major Ca2+ binding site at the C-terminus involving Asp53 and Asp55, while Asp19 was considered as putative Ca2+ binding site. The exchange of Asp19 to serine had little impact on the Ca2+ binding, however caused the loss of antifungal activity, as was shown in our recent study. Now we replaced the C-terminal aspartates and expressed the serine variant PAFD53S/D55S. The specific Ca2+ binding affinity of PAFD53S/D55S decreased significantly if compared to PAF, whereas the antifungal activity was retained. To understand more details of Ca2+ interactions, we investigated the NMR and MD structure/dynamics of the free and Ca2+-bound PAF and PAFD53S/D55S. Though we found some differences between these protein variants and the Ca2+ complexes, these effects cannot explain the observed Ca2+ influence. In conclusion, PAF binds Ca2+ ions selectively at the C-terminus; however, this Ca2+ binding does not seem to play a direct role in the previously documented modulation of the antifungal activity of PAF.
Assuntos
Cálcio/metabolismo , Proteínas Fúngicas/química , Proteínas Fúngicas/metabolismo , Penicillium chrysogenum/crescimento & desenvolvimento , Sítios de Ligação , Calorimetria , Proteínas Fúngicas/genética , Proteínas Fúngicas/toxicidade , Espectroscopia de Ressonância Magnética , Modelos Moleculares , Simulação de Dinâmica Molecular , Mutação , Neurospora crassa/efeitos dos fármacos , Penicillium chrysogenum/metabolismo , Ligação ProteicaRESUMO
In a 54 m3 large-scale penicillin fermentor, the cells experience substrate gradient cycles at the timescales of global mixing time about 20-40 s. Here, we used an intermittent feeding regime (IFR) and a two-compartment reactor (TCR) to mimic these substrate gradients at laboratory-scale continuous cultures. The IFR was applied to simulate substrate dynamics experienced by the cells at full scale at timescales of tens of seconds to minutes (30 s, 3 min and 6 min), while the TCR was designed to simulate substrate gradients at an applied mean residence time (τc) of 6 min. A biological systems analysis of the response of an industrial high-yielding P. chrysogenum strain has been performed in these continuous cultures. Compared to an undisturbed continuous feeding regime in a single reactor, the penicillin productivity (qPenG ) was reduced in all scale-down simulators. The dynamic metabolomics data indicated that in the IFRs, the cells accumulated high levels of the central metabolites during the feast phase to actively cope with external substrate deprivation during the famine phase. In contrast, in the TCR system, the storage pool (e.g. mannitol and arabitol) constituted a large contribution of carbon supply in the non-feed compartment. Further, transcript analysis revealed that all scale-down simulators gave different expression levels of the glucose/hexose transporter genes and the penicillin gene clusters. The results showed that qPenG did not correlate well with exposure to the substrate regimes (excess, limitation and starvation), but there was a clear inverse relation between qPenG and the intracellular glucose level.
Assuntos
Reatores Biológicos/microbiologia , Meios de Cultura/química , Penicilinas/biossíntese , Penicillium chrysogenum/crescimento & desenvolvimento , Metabolismo dos Carboidratos , Carbono/metabolismo , FermentaçãoRESUMO
In the present work, by performing chemostat experiments at 400 and 600 RPM, two typical power inputs representative of industrial penicillin fermentation (P/V, 1.00 kW/m3 in more remote zones and 3.83 kW/m3 in the vicinity of the impellers, respectively) were scaled-down to bench-scale bioreactors. It was found that at 400 RPM applied in prolonged glucose-limited chemostat cultures, the previously reported degeneration of penicillin production using an industrial Penicillium chrysogenum strain was virtually absent. To investigate this, the cellular response was studied at flux (stoichiometry), residual glucose, intracellular metabolite and transcript levels. At 600 RPM, 20% more cell lysis was observed and the increased degeneration of penicillin production was accompanied by a 22% larger ATP gap and an unexpected 20-fold decrease in the residual glucose concentration (Cs,out ). At the same time, the biomass specific glucose consumption rate (qs ) did not change but the intracellular glucose concentration was about sixfold higher, which indicates a change to a higher affinity glucose transporter at 600 RPM. In addition, power input differences cause differences in the diffusion rates of glucose and the calculated Batchelor diffusion length scale suggests the presence of a glucose diffusion layer at the glucose transporting parts of the hyphae, which was further substantiated by a simple proposed glucose diffusion-uptake model. By analysis of calculated mass action ratios (MARs) and energy consumption, it indicated that at 600 RPM glucose sensing and signal transduction in response to the low Cs,out appear to trigger a gluconeogenic type of metabolic flux rearrangement, a futile cycle through the pentose phosphate pathway (PPP) and a declining redox state of the cytosol. In support of the change in glucose transport and degeneration of penicillin production at 600 RPM, the transcript levels of the putative high-affinity glucose/hexose transporter genes Pc12g02880 and Pc06g01340 increased 3.5- and 3.3-fold, respectively, and those of the pcbC gene encoding isopenicillin N-synthetase (IPNS) were more than twofold lower in the time range of 100-200 hr of the chemostat cultures. Summarizing, changes at power input have unexpected effects on degeneration and glucose transport, and result in significant metabolic rearrangements. These findings are relevant for the industrial production of penicillin, and other fermentations with filamentous microorganisms.
Assuntos
Antibacterianos/biossíntese , Reatores Biológicos/microbiologia , Penicilinas/biossíntese , Penicillium chrysogenum/crescimento & desenvolvimento , Penicillium chrysogenum/metabolismo , Fatores Biológicos/metabolismo , Fermentação , Glucose/metabolismo , Análise de SistemasRESUMO
An important parameter in filamentous bioreactor cultivations is the morphology of the fungi, due to its interlink to productivity and its dependency on process conditions. Filamentous fungi show a large variety of morphological forms in submerged cultures. These range from dispersed hyphae, to interwoven mycelial aggregates, to denser hyphal aggregates, the so-called pellets. Depending on the objective function of the bioprocess, different characteristics of the morphology are favorable and need to be quantified accurately. The most common method to quantitatively characterize morphology is image analysis based on microscopy. This method is work intensive and time consuming. Therefore, we developed a faster, at-line applicable, alternative method based on flow cytometry. Within this contribution, this novel method is compared to microscopy for a penicillin production process. Both methods yielded in comparable distinction of morphological sub-populations and described their morphology in more detail. In addition to the appropriate quantification of size parameters and the description of the hyphal region around pellets, the flow cytometry method even revealed a novel compactness parameter for fungal pellets which is not accessible via light microscopy. Hence, the here presented flow cytometry method for morphological analysis is a fast and reliable alternative to common tools with some new insights in the pellet morphology, enabling at-line use in production environments.
Assuntos
Reatores Biológicos/microbiologia , Citometria de Fluxo/métodos , Técnicas Microbiológicas/métodos , Penicillium chrysogenum/citologia , Microscopia/métodos , Imagem Óptica/métodos , Penicilinas/biossíntese , Penicillium chrysogenum/crescimento & desenvolvimento , Penicillium chrysogenum/metabolismo , Fatores de TempoRESUMO
Quaternary ammonium compounds (QACs) are a group of compounds of great economic significance. They are widely used as emulsifiers, detergents, solubilizers and corrosion inhibitors in household and industrial products. Due to their excellent antimicrobial activity QACs have also gained a special meaning as antimicrobials in hospitals, agriculture and the food industry. The main representatives of the microbiocidal QACs are the benzalkonium chlorides (BACs), which exhibit biocidal activity against most bacteria, fungi, algae and some viruses. However, the misuses of QACs, mainly at sublethal concentrations, can lead to an increasing resistance of microorganisms. One of the ways to avoid this serious problem is the introduction and use of new biocides with modified structures instead of the biocides applied so far. Therefore new BAC analogues P13-P18 with pyridine rings were synthesized. The new compounds were characterized by NMR, FT-IR and ESI-MS methods. PM3 semiempirical calculations of molecular structures and the heats of formation of compounds P13-P18 were also performed. Critical micellization concentrations (CMCs) were determined to characterize the aggregation behavior of the new BAC analogues. The antimicrobial properties of novel QACs were examined by determining their minimal inhibitory concentration (MIC) values against the fungi Aspergillus niger, Candida albicans, Penicillium chrysogenum and bacteria Staphylococcus aureus, Bacillus subtilis, Escherichia coli and Pseudomonas aeruginosa. The MIC values of N,N-dimethyl-N-(4-methylpyridyl)-N-alkylammonium chlorides for fungi range from 0.1 to 12 mM and for bacteria, they range from 0.02 to 6 mM.
Assuntos
Anti-Infecciosos/síntese química , Compostos de Benzalcônio/síntese química , Desenho de Fármacos , Piridinas/química , Anti-Infecciosos/farmacologia , Aspergillus niger/efeitos dos fármacos , Aspergillus niger/crescimento & desenvolvimento , Bacillus subtilis/efeitos dos fármacos , Bacillus subtilis/crescimento & desenvolvimento , Compostos de Benzalcônio/farmacologia , Candida albicans/efeitos dos fármacos , Candida albicans/crescimento & desenvolvimento , Escherichia coli/efeitos dos fármacos , Escherichia coli/crescimento & desenvolvimento , Micelas , Testes de Sensibilidade Microbiana , Estrutura Molecular , Penicillium chrysogenum/efeitos dos fármacos , Penicillium chrysogenum/crescimento & desenvolvimento , Pseudomonas aeruginosa/efeitos dos fármacos , Pseudomonas aeruginosa/crescimento & desenvolvimento , Staphylococcus aureus/efeitos dos fármacos , Staphylococcus aureus/crescimento & desenvolvimento , Relação Estrutura-AtividadeRESUMO
In this study, we analyzed the expression of the structural genes encoding the five enzymes comprising the Leloir pathway of D-galactose catabolism in the industrial cell factory Penicillium chrysogenum on various carbon sources. The genome of P. chrysogenum contains a putative galactokinase gene at the annotated locus Pc13g10140, the product of which shows strong structural similarity to yeast galactokinase that was expressed on lactose and D-galactose only. The expression profile of the galactose-1-phosphate uridylyl transferase gene at annotated locus Pc15g00140 was essentially similar to that of galactokinase. This is in contrast to the results from other fungi such as Aspergillus nidulans, Trichoderma reesei and A. niger, where the ortholog galactokinase and galactose-1-phosphate uridylyl transferase genes were constitutively expressed. As for the UDP-galactose-4-epimerase encoding gene, five candidates were identified. We could not detect Pc16g12790, Pc21g12170 and Pc20g06140 expression on any of the carbon sources tested, while for the other two loci (Pc21g10370 and Pc18g01080) transcripts were clearly observed under all tested conditions. Like the 4-epimerase specified at locus Pc21g10370, the other two structural Leloir pathway genes - UDP-glucose pyrophosphorylase (Pc21g12790) and phosphoglucomutase (Pc18g01390) - were expressed constitutively at high levels as can be expected from their indispensable function in fungal cell wall formation.
Assuntos
Proteínas de Bactérias/metabolismo , Enzimas/metabolismo , Galactose/metabolismo , Penicillium chrysogenum/enzimologia , Proteínas de Bactérias/genética , Enzimas/genética , Fermentação , Galactoquinase/genética , Galactoquinase/metabolismo , Regulação Bacteriana da Expressão Gênica , Regulação Enzimológica da Expressão Gênica , Nucleotidiltransferases/genética , Nucleotidiltransferases/metabolismo , Penicillium chrysogenum/genética , Penicillium chrysogenum/crescimento & desenvolvimento , Fosfoglucomutase/genética , Fosfoglucomutase/metabolismo , Especificidade por Substrato , Fatores de Tempo , UDPglucose 4-Epimerase/genética , UDPglucose 4-Epimerase/metabolismo , UTP-Glucose-1-Fosfato Uridililtransferase/genética , UTP-Glucose-1-Fosfato Uridililtransferase/metabolismoRESUMO
Spore inoculum quality in filamentous bioprocesses is a critical parameter associated with viable spore concentration (1) and spore germination (2). It influences pellet morphology and, consequently, process performance. The state-of-the-art method to measure viable spore concentration is tedious, associated with significant inherent bias, and not applicable in real-time. Therefore, it is not usable as process analytical technology (PAT). Spore germination has so far been monitored using image analysis, which is hampered by complex medium background often observed in filamentous bioprocesses. The method presented here is based on the combination of viability staining and large-particle flow cytometry which enables measurements in real-time and hence aims to be applicable as a PAT tool. It is compatible with the complex media background and allows the quantification of metabolically active spores and the monitoring of spore germination. A distinction of germinated spores and not germinated spores was based on logistic regression, using multiparameteric data from flow cytometry. In a first step, a significant correlation between colony-forming unit (CFU) counts and viable spore concentration (1) in an industrially relevant model bioprocess was found. Spore germination (2) was followed over the initial process phase with close temporal resolution. The validation of the method showed an error below 5 %. Differences in spore germination for various spore inocula ages and spore inoculum concentrations were monitored. The real-time applicability of the method suggests the implementation as a PAT tool in filamentous bioprocesses.