Effects of oil substrate supplementation on production of prodigiosin by Serratia nematodiphila for dye-sensitized solar cell.

Bacterial pigments are potential substitute of chemical photosensitizer for dye-sensitized solar cell (DSSC) due to its non-toxic property and cost-effective production from microbial fermentation. Serratia nematodiphila YO1 was isolated from waterfall in Malaysia and identified using 16S ribosomal RNA. Characterization of the red pigment produced by the bacteria has confirmed the pigment as prodigiosin. Prodigiosin was produced from the fermentation of the bacteria in the presence of different oil substrates. Palm oil exhibited the best performance of cell growth and equivalent prodigiosin yield compared to olive oil and peanut oil. Prodigiosin produced with palm oil supplementation was 93 mg/l compared to 7.8 mg/l produced without supplementation, which recorded 11.9 times improvement. Specific growth rate of the cells improved 1.4 times when palm oil was supplemented in the medium. The prodigiosin pigment produced showed comparable performance as a DSSC sensitizer by displaying an open circuit voltage of 336.1 mV and a maximum short circuit current of 0.098 mV/cm2. This study stands a novelty in proving that the production of prodigiosin is favorable in the presence of palm oil substrate with high saturated fat content, which has not been studied before. This is also among the first bacterial prodigiosin tested as photosensitizer for DSSC application.

Stable Isotope Labeling of Prodiginines and Serratamolides Produced by Serratia marcescens Directly on Agar and Simultaneous Visualization by Matrix-Assisted Laser Desorption/Ionization Imaging High-Resolution Mass Spectrometry.

Matrix-assisted laser desorption/ionization imaging high-resolution mass spectrometry (MALDI-imaging-HRMS) is an important technique for visualizing the spatial distribution of compounds directly on the surface of organisms such as microorganisms, insects, plants, animals, and human tissues. However, MALDI-imaging-HRMS and the stable isotope labeling approach have never been combined for the detection and simultaneous visualization of labeled and unlabeled compounds, their analogues and derivatives, as well as their precursors. Herein, we present a methodology that labels microbial secondary metabolites directly on agar with stable isotopes and allows concurrent spatial distribution analyses by MALDI-imaging-HRMS. Using a thin film of labeled agar supplemented with [1-13C]-l-proline, [methyl-D3]-l-methionine, 15NH4Cl, or [15N]-l-serine overlaid on unlabeled agar, we demonstrate the incorporation of labeled precursors into prodiginines and serratamolides produced by an endophytic bacterium, Serratia marcescens, by MALDI-imaging-HRMS and HPLC-HRMS. Further, we show the incorporation of CD3 into prodigiosin as well as its characteristic fragments directly by MALDI-imaging-HRMS2. Our methodology has several advantages over currently existing techniques. First, both labeled and unlabeled compounds can be visualized simultaneously in high spatial resolution along with their labeled and unlabeled precursors. Second, by using a thin film of labeled agar, we utilize minimum amounts of expensive labeled compounds (1-3 mg) ensuring a cost-effective method for investigating biosynthetic pathways. Finally, our method allows in situ visualization and identification of target and nontarget compounds without the need of isolating the compounds. This is important for compounds that are produced by microorganisms in low, physiologically, or ecologically relevant concentrations.

Spatial-temporal profiling of prodiginines and serratamolides produced by endophytic Serratia marcescens harbored in Maytenus serrata.

An endophytic bacterium, Serratia marcescens MSRBB2, isolated from inner bark of a Cameroonian Maytenus serrata plant, was subjected to the OSMAC (One Strain Many Compounds) approach and metabolic profiling using HPLC-HRMSn. We identified 7 prodiginines along with 26 serratamolides. Their biosynthetic pathways were elucidated by feeding with labeled precursors in combination with HRMSn. Dual-culture confrontation/restriction assays of the bacterial endophyte were devised with coexisting fungal endophytes (Pestalotiopsis virgatula, Aspergillus caesiellus and Pichia spp.) as well as with unrelated, non-endophytic fungi belonging to the same genera. The assays were combined with scanning electron microscopy (SEM) as well as matrix-assisted laser desorption ionization imaging high-resolution mass spectrometry (MALDI-imaging-HRMS) for visualizing, both in high spatial and temporal resolution, the distribution and interplay of the compounds during microbial interactions. We demonstrated the effect of prodigiosin produced by endophytic S. marcescens MSRBB2 as an allelochemical that specifically inhibits coexisting endophytic fungi. Our results provide new insights into the physiological and ecological relevance of prodiginines and serratamolides within the context of allelopathy and chemical defense interaction occurring between coexisting endophytes harbored in M. serrata.

Comparative analysis of prodigiosin isolated from endophyte Serratia marcescens.

Extraction of pigments from endophytes is an uphill task. Up till now, there are no efficient methods available to extract the maximum amount of prodigiosin from Serratia marcescens. This is one of the important endophytes of Beta vulgaris L. The present work was carried out for the comparative study of six different extraction methods such as homogenization, ultrasonication, freezing and thawing, heat treatment, organic solvents and inorganic acids to evaluate the efficiency of prodigiosin yield. Our results demonstrated that highest extraction was observed in ultrasonication (98·1 ± 1·7%) while the lowest extraction by freezing and thawing (31·8 ± 3·8%) methods. However, thin layer chromatography, high-performance liquid chromatography and Fourier transform infrared data suggest that bioactive pigment in the extract was prodigiosin. To the best of our knowledge, this is the first comprehensive study of extraction methods and identification and purification of prodigiosin from cell biomass of Ser. marcescens isolated from Beta vulgaris L. SIGNIFICANCE AND IMPACT OF THE STUDY: The prodigiosin family is a potent drug with anticancer, antimalarial, antibacterial, antifungal, antiproliferative and immunosuppressive activities. Moreover, it has immense potential in pharmaceutical, food and textile industries. For the industrial perspective, it is essential to achieve purified, high yield and cost-effective extraction of prodigiosin. To the best of our knowledge, this is the first comprehensive study on prodigiosin extraction and also the first report on endophyte Serratia marcescens isolated from Beta vulgaris L. The significance of our results is to extract high amount and good quality prodigiosin for commercial application.

Studies on production and biological potential of prodigiosin by Serratia marcescens.

Efficacy of Serratia marcescens for pigment production and biological activity was investigated. Natural substrates like sweet potato, mahua flower extract (Madhuca latifolia L.), and sesam at different concentrations were taken. As a carbon source microorganism favored potato powder was followed by sesam and mannitol, and as nitrogen source casein hydrolysate was followed by yeast and malt extract. The effect of inorganic salts on pigment production was also studied. At final optimized composition of suitable carbon, nitrogen source, and trace materials and at suitable physiological conditions, prodigiosin production was 4.8 g L(-1). The isolated pigment showed antimicrobial activity against different pathogenic bacteria and fungi. Extracted pigment was characterized by spectroscopy, Fourier transform infrared (FTIR), and thin layer chromatography (TLC) which confirm production of biological compound prodigiosin. This study suggests that use of sweet potato powder and casein can be a potential alternative bioresource for commercial production of pigment prodigiosin.

Use of red autofluorescence for monitoring prodiginine biosynthesis.

Prodigiosin-like pigments or prodiginines (PdGs) are promising drugs owing to their reported antitumor, antibiotic, and immunosuppressive activities. These natural compounds are produced by several bacteria, including Streptomyces coelicolor and Serratia marcescens as most commonly studied models. The bright red color of these tripyrrole pigments made them excellent reporter molecules for studies aimed at understanding the molecular mechanisms that control secondary metabolite production in microorganisms. However, the natural red fluorescence of PdGs has only been rarely used as a biophysical parameter for detection and assessment of PdG biosynthesis. In this work, we used S. coelicolor in order to exemplify how intrinsic red fluorescence could be utilized for rapid, low-cost, sensitive, specific and accurate semi-quantitative analyses of PdG biosynthesis. Additionally, and contrary to the colorimetric-based approach, the fluorescence-based method allows in situ spatio-temporal visualization of PdG synthesis throughout a solid culture of S. coelicolor. As PdG production is related to cell differentiation, their red autofluorescence could be exploited, by means of confocal microscopy, as a natural marker of the entrance into a crucial developmental stage in the course of the S. coelicolor life cycle.

Characterization and localization of prodiginines from Streptomyces lividans suppressing Verticillium dahliae in the absence or presence of Arabidopsis thaliana.

The ascomycete Verticillium dahliae causes worldwide vascular wilt of many field and horticultural plants. The melanized resting structures of this fungus, so-called microsclerotia, survive for many years in soils and continuously re-infect plants. Due to the absence of known fungicides, Verticillium wilt causes immense crop losses. We discovered that the Gram-positive, spore-forming soil bacterium Streptomyces lividans expresses members of the prodiginine family during co-cultivation with V. dahliae. Using HPLC and LC-MS analysis of cultures containing S. lividans alone or grown together with V. dahliae, we found that undecylprodigiosin [394.4 M+H](+) is highly abundant, and streptorubin B [392.4 M+H](+) is present in smaller amounts. Within co-cultures, the quantity of undecylprodigiosin increased considerably and pigment concentrated at and within fungal hyphae. The addition of purified undecylprodigiosin to growing V. dahliae hyphae strongly reduced microsclerotia formation. Undecylprodigiosin was also produced when S. lividans grew on the roots of developing Arabidopsis thaliana plants. Furthermore, the presence of the undecylprodigiosin producer led to an efficient reduction of V. dahliae hyphae and microsclerotia on plant-roots. Based on these novel findings and previous knowledge, we deduce that the prodiginine investigated leads to multiple cellular effects, which ultimately impair specific pathways for signal transduction and apoptosis of the fungal plant pathogen.

Prodigiosin produced by Serratia marcescens NMCC46 as a mosquito larvicidal agent against Aedes aegypti and Anopheles stephensi.

Microbial control agents offer alternatives to chemical pest control as they can be more selective than chemical insecticides. The present study evaluates the mosquito larvicidal potential of microbial pigment prodigiosin produced by Serratia marcescens NMCC46 against Aedes aegypti and Anopheles stephensi. The pigment of S. marcescens NMCC46 was extracted after 24 h from mannitol containing nutrient broth media. The effects of crude extracted pigment on the growth, survival, development, and other life cycle aspects were studied. The LC(50) and LC(90) values of second, third, and fourth instars of A. aegypti (LC(50) = 41.65, 139.51, 103.95; LC(90) = 117.81, 213.68, 367.82) and A. stephensi (LC(50) = 51.12, 105.52, 133.07; LC(90) = 134.81, 204.45, 285.35) were determined. At higher concentration (500 ppm), mortality starts within first 6 h of exposure. More than 50% mortality occurs within the first 24 h. The overall observed effects against A. aegypti and A. stephensi larvae after 48 h were increasing percent survival larvae, survival pupation, adult emergence with decreasing crude pigment extract concentration. These ensure that the resultant mosquito population reduction is substantial even where the larvicidal potential is minimal. The UV (λ (max) = 536 nm), TLC (Rf = 0.9), HPLC, and FTIR analysis of crude pigment shows the presence of prodigiosin as active compound. Thus, the active compound produced by this species would be more useful against vectors responsible for diseases of public health importance. This is the first report on mosquito larvicidal activity of prodigiosin produced by Serratia species.

Characterization of Serratia marcescens isolates from subgingival biofilm, extraoral infections and environment by prodigiosin production, serotyping, and genotyping.

INTRODUCTION: Serratia marcescens is widely distributed in nature, and has emerged in the last years as an important nosocomial pathogen. The organism may also be found in subgingival biofilm in periodontitis patients. This study aimed to verify the subgingival prevalence of S. marcescens in different periodontal conditions and to evaluate whether the oral cavity would harbor strains similar to those causing infectious diseases. METHODS: The subgingival occurrence of S. marcescens was determined in 334 subjects. The phenotypic and genotypic diversity of 23 isolates from subgingival biofilm, 22 from extra-oral infections and 10 environmental strains, was compared by prodigiosin production, O and H serotyping and genotyping using polymorphic GC-rich repetitive sequences-polymerase chain reaction. RESULTS: S. marcescens was found more frequently in severe periodontitis patients (4.1%) than in gingivitis (3.2%) and healthy subjects (2.5%), but these differences were not statistically significant. Analysis of serotype distribution, prodigiosin production, and genotyping revealed that environmental strains were markedly different from most human isolates, either oral or extraoral. CONCLUSION: These data suggest that S. marcescens isolates from subgingival biofilm are not just contaminants from the environment, but that the oral cavity may act as a reservoir of strains able to promote human infections. However, further studies are needed to elucidate the role of this bacterium in the pathogenesis of periodontal diseases.

Enhanced production of prodigiosin-like pigment from Serratia marcescens SMdeltaR by medium improvement and oil-supplementation strategies.

Serratia marcescens SMdeltaR, an SpnR-defective isogenic mutant of S. marcescens SS-1, was used to produce a prodigiosin-like pigment (PLP). Luria-Bertani (LB) broth, frequently used for prodigiosin biosynthesis with S. marcescens strains, was modified by increasing the concentrations of tryptone and yeast extract while completely removing NaCl from the medium. The resulting modified LB (MLB) medium achieved an almost 3.0-fold increase in PLP yield (152 mg l(-1)) when compared with the original LB broth. The addition of vegetable oils (2-6% [v/v]) to the fermentation broth markedly enhanced PLP production. PLP yields of 525, 579, and 790 mg l(-1) were obtained when the MLB medium was supplemented with 4% soybean oil, 4% olive oil and 6% sunflower oil, respectively. PLP production was found to be positively correlated with extracellular surface emulsification activity, suggesting a link between the PLP production and the presence of biosurfactant. This work shows that the optimal medium for PLP yield was sunflower oil (6%)-supplemented MLB medium, which resulted in an approximately 14-fold higher PLP yield than that in LB broth. Mass spectrometry and NMR analysis indicated that the PLP product is a prodigiosin derivative, called undecylprodigiosin.

A stationary-phase acyl-coenzyme A synthetase of Streptomyces coelicolor A3(2) is necessary for the normal onset of antibiotic production.

The fadD1 and macs1 genes of Streptomyces coelicolor are part of a two-gene operon. Both genes encode putative acyl coenzyme A synthetases (ACSs). The amino acid sequence of FadD1 has high homology with those of several ACSs, while MACS1 has the closest homology with medium-chain ACSs, broadly known as SA proteins. Like FadD of Escherichia coli, FadD1 also has a broad substrate specificity, although saturated long-chain fatty acids appears to be the preferred substrate. fadD1 is a growth-phase-regulated gene, and its mRNA is detected only during the stationary phase of growth. Interestingly, a mutation in fadD1 alters the levels of another ACS or ACSs, both at the stationary phase and at the exponential phase of growth, at least when glucose is used as a main carbon source. The mutant also shows a severe deficiency in antibiotic production, and at least for Act biosynthesis, this deficiency seems to be related to delayed expression of the Act biosynthetic genes. Antibiotic production is restored by the introduction of a wt fadD1 allele into the cell, demonstrating a strict link between ACS activity and the biosynthesis of secondary metabolites. The results of this study indicate that the ACSs may be useful targets for the design of rational approaches to improving antibiotic production.

Diversity of antifungal and plant-associated Serratia plymuthica strains.

A total of 21 plant-associated Serratia plymuthica strains were characterized phenotypically by their nutritional patterns, susceptibility to antibiotics, antifungal and haemolytic properties, and genotypically by denaturing gradient gel electrophoresis (DGGE) of PCR-amplified 16S rDNA, PCR fingerprints using BOX primers (BOX-PCR) and pulsed-field gel electrophoresis (PFGE) after digestion with SpeI. All of the investigated strains demonstrated antifungal activity in vitro against fungal pathogens while only six strains produced the antifungal antibiotic prodigiosin. Haemolytic activity and antibiotic resistance patterns were investigated to assess the risk associated with the use of isolates in plant protection. The strains were haemolytic at human-relevant temperatures. The level of resistance to antibiotics was low. This work shows that BOX-PCR and PFGE are useful fingerprinting methods to characterize Ser. plymuthica strains, although the discriminatory effect between the two methods differed. Computer-assisted analysis of phenotypic and genotypic features demonstrated relationships between the origin of isolation, the production of prodigiosin and the molecular fingerprint.

Separation of the prodigiosin-localizing crude vesicles which retain the activity of protease and nuclease in Serratia marcescens.

Crude vesicles in which prodigiosin is localized were separated from pigmented Serratia marcescens. The bacteria were grown on peptone-glycerol agar plate, suspended in saline, and fractionated into cells, vesicles, and supernatant by differential centrifugation. Electron microscopic observations showed that the fractionation was conducted properly and the separated vesicles were lysed in distilled water. The vesicles suspended in saline retained 100 kilodalton protein of which amount is correlated with prodigiosin level, but the 100 kDa protein was found in the supernatant when the vesicles were lysed in distilled water. The vesicle fraction retained few colony-forming units and little detectable activity of NADH oxidase, but showed much higher activities of protease and nuclease than the cell fraction. The profiles of the activities of the protease and the nuclease in the fractions were different from each other, that is, the protease activity in the vesicle fraction was lower than that in the supernatant fraction, whereas the nuclease activity in the vesicle fraction was higher than that in the supernatant fraction, suggesting that the two extracellular enzymes were released from the pigmented bacteria by different mechanisms.

Prodigiosin, a component of kappa phage receptor complex in Serratia marcescens.

Studies on kappa phage inactivation with isolated pigments from Serratia marcescens were carried out. Kappa phage is sensitive to inactivation with diethyl ether, petroleum ether, acetone and methanol, but is quite stable in chloroform and dimethyl sulphoxide. The pigment extract dissolved in chloroform inactivates about 50% of the total suspended phages. The pigment dissolved in acetone and dimethyl sulphoxide inactivates about 96.50% and 64.10% of the phages, respectively. High inactivation values with acetone were partially due to direct inactivation rather than the pigment itself.

Isolation and purification of prodigiosin from Vibrio psychroerythrus.

The red pigment of Vibrio psychroerythrus (formerly marine psychrophile NRC 1004) was identified as prodigiosin by comparison of its mass spectrum, absorption spectrum in the visible range, and chromatographic behavior with prodigiosin isolated from Serratia marcescens. The properties of the V. psychroerythrus pigment were clearly distinguishable from five other prodigiosin-like compounds isolated from three different microorganisms.

Biosynthesis of prodigiosin, a secondary metabolite of Serratia marcescens.

Prodigiosenes (prodigiosin and prodigiosin-like pigments) are known to be synthesized by only one genus of Eubacteriales and by two genera of Actinomycetales. Biosynthesis by Serratia marcescens occurs over a relatively narrow range of temperatures, although the bacteria grow over a broad range. When cultures of S. marcescens were incubated at 27 C in 1.0% casein hydrolysate, viable count and protein attained maximal values within 24 to 48 h, whereas prodigiosin did not reach a maximum until 96 h. The greatest amount of pigment was synthesized when cultures were in the senescent phase of growth. Suspensions of nonproliferating bacteria incubated at 27 C in only L-alanine also synthesized prodigiosin, although at a slower rate than growing cultures. Kinetics of growth for the wild-type, red S. marcescens and a white mutant were identical when incubated at 27 C, but the wild type produced abundant pigment. These results plus other data obtained from the literature suggest that prodigiosin is a secondary metabolite. The importance of this proposal to understanding the function of prodigiosin in S. marcescens is discussed.

Separation of prodigiosenes and identification as prodigiosin syntrophic pigment from mutant pairs of Serratia marcescens.

Countercurrent distribution is capable of resolving mixtures of closely related prodigiosene pigments. Syntrophic pigment produced by several pairs of Serratia marcescens color mutants was identified as prodigiosin (2-methyl-3-amyl-6-methoxyprodigiosene) by countercurrent distribution, soda lime pyrolysis, and other techniques. The metabolic block of mutant strain H-462, derived from parent strain HY, was located between the blocks of mutant strains OF and WF, both derived from parent strain Nima.

Pigmentation and acriflavine resistance in Serratia marcescens.

Stable, orange, acriflavine-resistant variants were selected by treatment of a wild-type, red, acriflavine-sensitive strain of Serratia marcescens with acriflavine. Visible, ultraviolet, infrared, and nuclear magnetic resonance spectra of purified pigment from the red strain were identical to those of the pigment from the orange strain, and the orange mutant was not due to a mutation affecting the structure of the pigment, prodigiosin. The color of the red strain was not affected by variations in pH between 5.0 and 8.0, whereas the color of the orange mutant changed from pink to orange over the same pH range. This variation was mimicked by the pH-induced variation in color of prodigiosin purified from either the red, wild-type or the orange, mutant strains. Density-gradient centrifugation of cell fragments after ultrasonic disintegration resulted in characteristic pigmented bands. Biochemical characterization of these pigmented bands showed that they contained pigment and a protein component, but no lipids, polysaccharides, sugars, glucosamine, or phosphates were detected. Further fractionation of these pigmented bands by zone electrophoresis on a sucrose density gradient indicated that some pigment in S. marcescens was specifically attached to protein components.