Ethyl acrylate: influence of sex or atopy on perceptual ratings and eye blink frequency.

Occupational exposure limits (OELs) are derived for protection from health hazards, assuming that exposed subjects are healthy adult workers. Whether differences in susceptibility to sensory irritation effects from airborne chemicals have to be taken into account is currently under discussion. Thus, we chose atopics as a healthy but possibly susceptible subpopulation that can be identified with a clinical test. To investigate the influence of sex or atopy on sensitivity to airborne chemicals, 22 subjects were exposed for 4 h to ethyl acrylate at three concentrations: 0.05 ppm (odor threshold; sham), 5 ppm (constant), and varying exposure between 0 and 10 ppm. Odor intensity decreased and eye irritation ratings increased in a dose-dependent manner, reflecting the time course of the exposure scenarios. The reports of moderate-to-strong eye irritation were verified by significant increases in eye blink frequency. Our results show that women reported subjective eye irritation to an increasing degree. However, these sex-related differences in ratings could not be verified by objective assessment of eye blink frequency. Atopic subjects reported higher odor intensity than non-atopic subjects, but only during the sham (odorous but not irritating) exposure condition. Differences in ratings on annoyance, and eye or nose irritation were not found. Furthermore, the study revealed that atopic subjects might belong to a group of subjects with frequent eye blink activity. Although the relative increase in blink rates was more pronounced in non-atopic subjects, atopic subjects had significant higher blink rates at the end of the exposure to varying ethyl acrylate concentrations. Our results do not support that atopy enhances chemosensory effects if only the increase of blink rates and not the absolute height are considered as adverse effect. Nevertheless, the results indicate that individuals with frequent eye blink activity should be distinguished from those with normal eye blink activity while investigating blink rates as objective parameter of eye irritation.

Exposure assessment of potash miners at elevated CO2 levels.

PURPOSE: In a potash mine in the center of Germany, stationary measurements 40 cm above ground level have revealed occasional increases in the carbon dioxide (CO2) levels that exceed the 0.5 vol.% German occupational exposure limit (OEL). This study, therefore, aimed to examine the individual exposures of potash miners to CO2 at their underground workplaces. METHODS: 119 miners were equipped with personal CO2 detectors to log the individual CO2 exposures during underground work. We decided to use electrochemical monitors due to their compactness and minimal mass. Furthermore, generated CO2 measurements with precipitated overshooting and false positive CO2 values were studied using diverse CO2 test gases and different fumigation times. RESULTS: The personal detectors showed short-term CO2 peak exposures at very high concentrations in a limited number of workers. Twenty-two threshold limit value violations were observed according to the present OEL, and the personal CO2 monitoring allowed categorization into three exposure groups, low (n = 83), moderate (n = 26) and high burdens (n = 10) of CO2. CONCLUSIONS: The electrochemical sensors used have numerous properties that can potentially influence the assessment of exposures. The current findings suggest that assessing similar exposure scenarios, with respect to elevated and strongly fluctuating CO2 concentrations, the behavior of electrochemical sensors should be taken into consideration.

Relationship of pulmonary function response to ozone exposure and capsaicin cough sensitivity.

CONTEXT: Challenge studies in humans have shown considerable interindividual variability in pulmonary impairment across ozone exposure. OBJECTIVE: Since previous results suggested effect modulation by neural mechanism, we investigated sensory C-fiber reactivity in relationship to ozone-triggered response pattern. METHODS: Cough reflex thresholds reflecting C-fiber sensitivity were evaluated by capsaicin single breath dose-response method. Capsaicin concentrations triggering, respectively, two and five or more coughs (C2, C5) were recorded. Sixteen healthy subjects were randomly exposed in an intermittent exercise protocol to ozone concentrations of 240 and 40 ppb (sham exposure). Ozone responsiveness was defined by a decrease in forced expiratory volume in 1 s (FEV(1)) of more than 5%. RESULTS: Based on a dichotomous classification, subjects with enhanced reactivity to ozone had lower cough thresholds than non-responders (C2, p = 0.035; C5, p = 0.086). Over all, we could demonstrate relationships between capsaicin sensitivity and ozone-triggered changes in FEV(1), peak expiratory flow and maximal expiratory flow at 50% vital capacity but not in specific airway resistance. CONCLUSION: Our results suggest that capsaicin challenge tests might be useful to characterize subjects with enhanced pulmonary function response towards inhalant irritants.

Reproducibility of sensitivity to capsaicin assessed by single breath inhalation methodology.

The hallmark of sensory hyperreactivity is an enhanced capsaicin induced cough reflex. The cough reflex can be modified by activation of nociceptive (capsaicin-sensitive) nerve terminals. The aim of our study was to assess the influence of exposure to CO(2) concentrations up to 2.0 vol% on capsaicin induced cough reflex on four different occasions. Sixteen healthy volunteers were exposed to CO(2) concentrations of 0.5, 1.0, and 2.0 vol% for 4 h and to clean air in a repeated measures cross-over design. After exposure the capsaicin induced cough reflex was assessed by the single breath dose-response method according to ERS 2007 guidelines. After blank solutions, capsaicin doses (n=12, range 0.49 to 1000 µM) were administrated from a nebulizer combined with a provocation system (Masterscope, software APS version 5.02). Doses were doubled every minute and the concentration causing five or more coughs (C5) was fixed as the end point. The inter-individual C5 capsaicin responsiveness reflected a representative range (0.95-1000 µM). On an intra-individual basis, a good reproducibility could be demonstrated for four tests within 3 weeks. There was no influence of CO(2) challenge on the cough reflex. The first capsaicin test demonstrated a lower C5 threshold independent of the CO(2) concentration applied. In conclusion, assessing the capsaicin cough reflex by single breath inhalation is reliable. However, the at cough sensitivity might be overestimated at the first test occasion. Exposure to CO(2) in concentrations of up to 2.0 vol% has no effect on sensory reactivity.

ATS/ ERS spirometry quality criteria in real life. Results of two occupational field studies.

Spirometry is a widely used test and the American Thoracic Society and the European Respiratory Society (ATS/ERS) provide standardised recommendations. However, detailed information on test quality is often incomplete in publications. In light of the 2005 ATS/ERS recommendations, we investigated the acceptability and repeatability criteria of spirometry performed under occupational field conditions in 242 practicing welders (WELDOX study, median age 41.5 years, all male) and 312 first-year veterinary students (AllergoVet study, median age 20.0 years, 84.3% female). At least three acceptable or usable measurements could be identified for 233 welders and 305 students. The repeatability for welders was 96.1% for the forced expiratory volume in the first second (FEV1) and 97.0% for forced vital capacity (FVC). The corresponding results for students were 95.7% and 95.4%, respectively. The overall repeatability of test sessions at the 150-mL level was 90.5% (219/242) for welders and 90.1% (281/312) for students. Spirometry can be performed with reliable quality in an occupational field setting.

Influence of face masks on the subjective impairment at different physical workloads.

To quantify the subjective and cognitive impairment caused by wearing face masks at work, 20 men and 20 women (median age 47 years, range 19-65) were tested under different ergometer workloads while wearing surgical mask, community mask, FFP2 respirator or no mask in a randomized and partially double-blinded design. Masks were worn also at the workplace for four hours. Subjective impairment was recorded by questionnaires. Cognitive performance was tested before and after the workplace examination. Subjective feeling of heat, humidity, and difficult breathing increased with rising physical exertion and wearing time for all three mask types, most notably for FFP2. Even when blinded, participants with FFP2 reported difficult breathing already at rest. During physical exertion, individuals with low tolerance to discomfort reported significantly stronger impairment (OR 1.14, 95% CI 1.02-1.27). Regarding light work, older subjects (OR 0.95, 95% CI 0.92-0.98) and women (OR 0.84, 95% CI 0.72-0.99) showed significantly lower and atopic subjects stronger impairment (OR 1.16, 95% CI 1.06-1.27). No significant influence of mask wearing was detected on cognitive performance. Wearing a mask had no effect on cognitive performance, but led to discomfort which increased with physical exertion and wearing time. Individuals who tolerate discomfort poorly felt more impaired by wearing a mask during physical exertion.

Effects of wearing different face masks on cardiopulmonary performance at rest and exercise in a partially double-blinded randomized cross-over study.

The use of face masks became mandatory during SARS-CoV-2 pandemic. Wearing masks may lead to complaints about laboured breathing and stress. The influence of different masks on cardiopulmonary performance was investigated in a partially double-blinded randomized cross-over design. Forty subjects (19-65 years) underwent body plethysmography, ergometry, cardiopulmonary exercise test and a 4-h wearing period without a mask, with a surgical mask (SM), a community mask (CM), and an FFP2 respirator (FFP2). Cardiopulmonary, physical, capnometric, and blood gas related parameters were recorded. Breathing resistance and work of breathing were significantly increased while wearing a mask. During exercise the increase in minute ventilation tended to be lower and breathing time was significantly longer with mask than without mask. Wearing a mask caused significant minimal decreases in blood oxygen pressure, oxygen saturation, an initial increase in blood and inspiratory carbon dioxide pressure, and a higher perceived physical exertion and temperature and humidity behind the mask under very heavy exercise. All effects were stronger when wearing an FFP2. Wearing face masks at rest and under exercise, changed breathing patterns in the sense of physiological compensation without representing a health risk. Wearing a mask for 4-h during light work had no effect on blood gases.

Impact of different welding techniques on biological effect markers in exhaled breath condensate of 58 mild steel welders.

Total mass and composition of welding fumes are predominantly dependent on the welding technique and welding wire applied. The objective of this study was to investigate the impact of welding techniques on biological effect markers in exhaled breath condensate (EBC) of 58 healthy welders. The welding techniques applied were gas metal arc welding with solid wire (GMAW) (n=29) or flux cored wire (FCAW) (n=29). Welding fume particles were collected with personal samplers in the breathing zone inside the helmets. Levels of leukotriene B(4) (LTB(4)), prostaglandin E(2) (PGE(2)), and 8-isoprostane (8-iso-PGF(2α)) were measured with immunoassay kits and the EBC pH was measured after deaeration. Significantly higher 8-iso-PGF(2α) concentrations and a less acid pH were detected in EBC of welders using the FCAW than in EBC of welders using the GMAW technique. The lowest LTB(4) concentrations were measured in nonsmoking welders applying a solid wire. No significant influences were found in EBC concentrations of PGE(2) based upon smoking status or type of welding technique. This study suggests an enhanced irritative effect in the lower airways of mild steel welders due to the application of FCAW compared to GMAW, most likely associated with a higher emission of welding fumes.

Considerations for the design and technical setup of a human whole-body exposure chamber.

Exposures to air contaminants, such as chemical vapors and particulate matter, pose important health hazards at workplaces. Short-term experimental exposures to chemical vapors and particles in humans are a promising attempt to investigate acute effects of such hazards. However, a significant challenge in this field is the determination of effects of co-exposures to more than one chemical or mixtures of chemical vapors and/or particles. To overcome such a challenge, studies have to be conducted under standardized exposure characterization and real time measurements, if possible. A new exposure laboratory (ExpoLab) was installed at IPA, combining sophisticated engineering designs with new analytical techniques, to fulfill these requirements. Low-dose as well as high-dose exposure scenarios are achieved by means of a calibration-gas-generator. Exposure monitoring can be carried out with a high performance real time mass spectrometer and other suitable analyzers (e.g. gas chromatograph). Numerous automated security facilities guarantee the physical integrity of the volunteers, and the waste atmosphere is removed using either charcoal filtration or catalytic post-combustion. Measurements of sulfur hexafluoride, carbon dioxide, aniline and carbon black are presented to demonstrate the performance of the exposure unit with respect to the temporal and spatial stability of generated atmospheres. The variations of generated contents in the atmospheres at steady state are slightly higher than the measurement precision of the analyzers (the typical standard deviation of generated atmospheres is < 2%). The technical components of ExpoLab and its monitoring systems ensure high quality standards in validity and reliability of generating and measuring exposure atmospheres.

Increased metal concentrations in exhaled breath condensate of industrial welders.

It was the aim of this study to evaluate the effect of different devices on the metal concentration in exhaled breath condensate (EBC) and to prove whether working conditions in different welding companies result in diverse composition of metallic elements. The influence of two collection devices (ECoScreen, ECoScreen2) on detection of metallic elements in EBC was evaluated in 24 control subjects. Properties of ECoScreen and a frequent use can alter EBC metal content due to contamination from metallic components. ECoScreen2 turned out to be favourable for metal assessment. Concentrations of iron, nickel and chromium in EBC sampled with ECoScreen2 were compared between non-exposed controls and industrial welders. Metal concentrations in EBC were higher in 36 welders recruited from three companies. Exposure to welding fumes could be demonstrated predominantly for increased iron concentrations. Concentrations of iron and nickel differed by working conditions, but chromium could not be detected in EBC.

Use of a calibration gas generator for irritation threshold assessment and as supplement of dynamic dilution olfactometry.

Human odor and mucosal membrane irritation thresholds are used as criteria for assessing air quality in occupational and environmental settings. Unfortunately, reported threshold values still differ by several orders of magnitude rendering most standard compilations of little practical utility. Thus, in view of the need to repeat odor threshold measurements with a reliable methodology, a new technical approach based on original equipment manufacturer integrated solutions is presented. To test applicability, a calibration gas generator was used to continuously generate a fixed odor vapor concentration. Different dilution steps were realized by coupling to a purchasable olfactometer. Comparison with the "standard," that is, odor stimulus supply via sample bags revealed good correspondence. As a second step, the calibration gas generator was used to generate rapid changes in stimulus concentration between consecutive trials. Irritation thresholds were measured with an ascending series of ammonia concentrations generated from an aqueous solution. The obtained thresholds lay within the range previously reported. The introduced technology enables quick and reliable odor stimulus generation and provides flexibility in choosing the optimal start concentration, the step-size between dilutions, and the range of stimulus concentrations. Errors from usage of rotameters or sample bags can be avoided.

Chemosensory function and psychological profile in patients with multiple chemical sensitivity: comparison with odor-sensitive and asymptomatic controls.

OBJECTIVE: We addressed the question if patients with multiple chemical sensitivity (MCS) differ from participants with self-reported odor sensitivity without MCS and asymptomatic controls in terms of chemosensory, cognitive, and clinical psychological endpoints. METHODS: In a clinical study 23 MCS patients, 21 participants with self-reported odor sensitivity, and 23 controls were investigated using electrophysiological and psychophysical olfactometric tests [chemosensory-event-related potentials (CSERP), olfactory thresholds, odor identification, trigeminal sensitivity]. The participants filled in a mood list, a list of complaints (BL), a Symptom Check List, a State-Trait Anxiety Inventory (STAI), and an MCS questionnaire. RESULTS: The olfactometric investigations revealed no significant differences between the groups. The MCS group reached significantly higher scores on negative mood states following odorant exposure, on health complaints, global indices, and the somatization subscale of the Symptom Check List, trait and state anxiety and symptoms, and triggering matters of the MCS questionnaire. CONCLUSIONS: Our findings reveal that neither olfactory functions, nor chemosensory or cognitive olfactory information processing are impaired in MCS patients. They rather support findings of altered psychological profile and moderate psychopathology.

The Influence of Humidity on Assessing Irritation Threshold of Ammonia.

A large number of occupational exposure limit values (OELs) are based on avoiding of sensory irritation of the eyes and the upper respiratory tract. In order to investigate the chemosensory effect range of a chemical, odor and sensory irritation thresholds (lateralization thresholds, LTs) can be assessed. Humidity affects olfactory function and thus influences odor thresholds; however, a similar effect has not been shown for sensory irritation thresholds. The purpose of the present study was to explore whether LTs for ammonia vapor vary depending on the water vapor content of the inspired stimulus. Eight healthy nonsmoking volunteers were simultaneously exposed to ammonia vapor through one nostril and clean air through the other and were asked to determine which nostril received the chemical. Within experimental runs, ascending ammonia concentrations (60-350 ppm) that were either dry or humidified were administered at fixed time intervals. Geometric mean LTs obtained at wet (181 ppm) or dry (172 ppm) conditions did not differ significantly (P = 0.19) and were within the range of those reported by previous studies. These results suggest that humidity is not a critical factor in determining sensory irritation thresholds for ammonia, and future studies will examine if these findings are transferable to sensory irritation thresholds for other chemicals.

Classical conditioning and conditionability of insulin and glucose effects in healthy humans.

We examined whether the effects of intravenously injected insulin and glucose (the physiological endogenous insulin production stimulus) could be classically conditioned in healthy humans. We expected a conditioned blood glucose decrease to a conditioned stimulus (CS) previously paired with insulin and an, albeit lower, blood glucose decrease to a CS paired with glucose injection. In addition, we analyzed glucoregulatory hormone and symptom conditionability. Thirty healthy males were divided into three groups and were given the CS and an intravenous injection of either insulin (0.05 IU/kg) in Group 1, glucose (15%, 0.5 g/kg) in Group 2, or placebo [physiological saline (0.9%)] in Group 3 during the acquisition phase on 4 days. All participants were given the olfactory CS (rosewood-peppermint smell) and placebo injection on Day 5 (test). On Day 5, the total blood glucose decrease tended to be higher in Group 1 than in Group 3 (P<.10), especially at CS presentation (P<.10) and previous unconditioned hypoglycemia time-point (P<.05). The conditioned blood glucose decrease was statistically nonsignificant in Group 2, but shortly after CS presentation, insulin level and blood glucose changes were negatively correlated in Groups 1 and 2 in contrast to positive correlation in Group 3. Furthermore, Group 1 showed an increase in noradrenaline (P<.05), a temporarily delayed increase in growth hormone (GH; P<.05), and an increase of autonomic and neuroglycopenic symptoms, reaching a medium and small effect size, respectively. Group 2 responded with an increase in cortisol (P<.01) and neuroglycopenic symptoms (P<.05) at the time-point of the previous unconditioned blood glucose minimum. To conclude, the effects of exogenously applied insulin can be conditioned in a reliable way. In correspondence with the lower intensity of the unconditioned stimulus (US), conditioning effects with glucose-and, thus, endogenously produced insulin-are weaker but also reflect the actions of central insulin. Future studies will examine the diverse actions of insulin within the brain further.

From chemosensory thresholds to whole body exposures-experimental approaches evaluating chemosensory effects of chemicals.

OBJECTIVES: To ensure safety and health the avoidance of adverse chemosensory effects is essential at workplaces where volatile chemicals are used. The present study describes psychophysical approaches that provide information for the evaluation of such effects. METHODS: By means of a modified staircase procedure the odor (OT) and irritation thresholds (IT) of 15 irritants were determined. These basic chemosensory properties, confining the chemosensory effect range, were investigated in a random sample of 144 persons stratified for gender and age. Those irritants exhibiting high chemosensory potency were selected for the second psychophysical part of the study. Forty-eight persons, again stratified for gender and age, rated the intensity of 13 trigeminal and olfactory perceptions elicited by nine ascending concentrations of the irritants, ranging from the odor to the irritation threshold of the respective substances. RESULTS: Across the investigated chemicals the transition from concentrations eliciting pure olfactory stimulation (OT) to trigeminal stimulation (IT) differed markedly. The carboxylic acids yielded narrow ranges from odor to irritation thresholds, while for the amines (cyclohexylamine, dimethylamine, and trimethylamine) and the esters (ethyl formate and ethyl acetate) these ranges were somewhat wider. The two chemosensory thresholds of ethyl acrylate and ammonia were farthest from each other. Gender and age had only weak impact on the chemosensory thresholds. At present, the results of the intensity ratings could be given for six substances. Among them, the rated pungency for cyclohexylamine, formic acid, and ethyl acetate increased strongest across the nine applied concentrations. CONCLUSIONS: By means of these psychophysical approaches a diverse class of chemicals can be described and compared with respect to their chemosensory potency. This information can be used twofold (a) for the evaluation of existing studies reporting sensory irritations and (b) for the design of experimental exposure studies.