Optimization of Vi capsular polysaccharide production during growth of Salmonella enterica serotype Typhi Ty2 in a bioreactor.

Vi capsular polysaccharide is synthesized during growth of Salmonella typhi Ty2 and is spontaneously released from the bacterial cells into the culture medium during culture. Vi production was dependent on cell growth and the greater the cell mass the greater the production of Vi. Using fed batch culture to optimize bacterial growth resulted is an increase in cell mass and consequently Vi production. The yield of Vi obtained in fed batch culture was 415 mgl(-1), which was over three times that, obtained in batch culture. A proportion of the Vi remained cell associated in the form of a capsule and at least part of this was released from the bacterial surface by sonication. The size of the Vi polysaccharide produced was consistently high and did not change during the different phases of bacterial growth. The synthesis of Vi was also dependent upon the media components and the fermentation conditions. The presence of high concentrations of glucose at the beginning of growth inhibited the production of Vi, particularly during the stationary phase. At a concentration of 400 mM sodium phosphate the synthesis of Vi was strongly inhibited.

Synthesis and immunogenicity evaluation of Salmonella enterica serovar Paratyphi A O-specific polysaccharide conjugated to diphtheria toxoid.

Salmonella enterica serovar Paratyphi A (S. Paratyphi A) is a human restricted pathogen that can cause systemic infection (paratyphoid fever) with recently increased incidence particularly in developing countries. Currently there is no licensed vaccine for prevention of infection from S. Paratyphi A. In this study the O-specific polysaccharide (OSP) of S. Paratyphi A was conjugated to diphtheria toxoid (DT) with and without adipic acid dihydrazide (ADH) as a linker. Binding of the OSP to a carrier protein was intended to convert a T-cell independent OSP response to a T-cell dependent response inducing higher levels of anti-OSP antibodies and immunological memory. These conjugates (OSP-AH-DT and OSP-DT) were evaluated for their immunogenicity in mice. The S. Paratyphi A OSP-DT conjugate induced a poor anti-OSP response less than that observed with LPS while the OSP-AH-DT conjugate induced a significantly higher antibody titer compared with LPS alone. The study also demonstrated diphtheria toxoid as a potential carrier protein for conjugate vaccine candidates using S. Paratyphi A OSP.

Preparation and evaluation of immunogenic conjugates of Salmonella enterica serovar Typhi O-specific polysaccharides with diphtheria toxoid.

Typhoid fever, caused by Salmonella enterica serovar Typhi (S. Typhi), is a major health problem particularly in developing countries. The available vaccines have certain limitations regarding their efficacy, and inability to induce an immune response especially in individuals under 2 years of age. Conjugate vaccines which consist of a bacteria-specific polysaccharide chemically bound to a carrier protein overcome these problems by inducing a T-cell dependent immune response characterized by enhanced immunogenicity in all ages. In this study, O-specific polysaccharides (OSP) of S. Typhi were conjugated to diphtheria toxoid (DT) using adipic acid dihydrazide (ADH) as a linker. These conjugates (OSP-AH-DT) were then evaluated for their immunogenicity using mice as a model and showed significantly higher levels of IgG ELISA titers (P = 0.0241 and 0.0245) than lipopolysaccharides alone. Different immunization  schedules were compared and it was found that schedule-B (three injections with 4-weeks interval) induced higher immune responses than schedule-A (three injections with 2-weeks interval). We showed that diphtheria toxoid can be successfully employed as a carrier protein for conjugation with Salmonella OSP and play an important role in facilitating adequate immune response.

Physical and chemical characterization and immunologic properties of Salmonella enterica serovar typhi capsular polysaccharide-diphtheria toxoid conjugates.

Typhoid fever remains a serious public health problem in developing countries, especially among young children. Recent studies showed more than 50% of typhoid cases are in children under 5 years old. Licensed vaccines, such as Salmonella enterica serovar Typhi capsular Vi, did not confer protection against typhoid fever for this age group. Vi conjugate, prepared by binding Vi to Pseudomonas aeruginosa recombinant exoprotein A (rEPA), induces protective levels of antibody at as young as 2 years old. Because of the lack of regulatory precedent for rEPA in licensing vaccines, we employed diphtheria toxoid (DT) as the carrier protein to accommodate accessibility in developing countries. Five lots of Vi-DT conjugates were prepared using adipic acid dihydrazide (ADH) as the linker. All 5 lots showed consistency in their physical and chemical characteristics and final yields. These Vi-DT conjugates elicited levels of IgG anti-Vi in young mice significantly higher than those in mice injected with Vi alone and induced a booster response upon reinjection. This booster effect was absent if the Vi replaced one of the two conjugate injections. Vi-DT was stable under repeated freeze-thaw (20 cycles). We plan to perform clinical evaluation of the safety and immunogenicity of Vi-DT when added to the infant combination vaccines.