Spanlastics gel-A novel drug carrier for transdermal delivery of glimepiride.

Glimepiride (3rd-generation sulfonylurea) is used for treatment of type 2 diabetes, but its oral administration has been associated with severe gastric disturbances such as nausea, vomiting, heartburn, anorexia, haemolytic anaemia. Accordingly, the transdermal route may represent a potentially suitable alternative. This work investigates the usefulness of a novel drug carrier system for transdermal application. The system investigated were called spanlastics gels and constituted span 60 with edge activator (tween 60 or tween 80). Spanlastics gel has been introduced as a stable form alternative to the liquid formulations of spanlastics. Spanlastics gels were prepared by coacervation phase separation method. Entrapment efficiency and size of spanlastics vesicles produced from the hydration of spanlastics gels were characterised. In vitro release and skin permeation of glimepiride from various spanlastics gel formulations were investigated across mixed cellulose membrane and excised rabbit skin. The obtained results indicated that the maximum entrapment efficiency was 65.36% when the tween 60 content was 30%. The drug release and permeation were increase as the concentration of edge activator increased. Spanlastics gel prepared with Tween 80 at concentration 50% showed higher permeability and flux value (248.69 µg/cm2and 8.31 µg/cm2.h, respectively) through rabbit skin.

Transethosome as a versatile nano vehicle for various indications and its regulatory insights.

Transethosomes, classified as 3rd generation nanocarriers, have gained global acclaim due to their profound potential in addressing diverse medical conditions. Their superior dermal penetration, attributed to essential constituents, such as edge activators and alcohol, sets them apart from other nanoformulations. The current review article embarks with an introduction followed by a comprehensive exploration of transethosome structures, differentiating them from fellow nanocarriers. A detailed analysis of characteristics and the spectrum of marketed products of various nanocarriers is also provided. Furthermore, the article offers a taxonomy of preparation methods of transethosomes and reports the frequently employed methods. It briefly surveys research studies encompassing various drug categories, spanning a wide range of medical conditions. In summary, this review article is dedicated to achieving several pivotal aims and objectives. We aim to substantiate the superior attributes of transethosomes when compared to conventional commercial products and other nanoformulations, demonstrating their clinical promise in addressing various human medical conditions. Additionally, we seek to elucidate the regulatory pathway required to secure approvals for transethosomes from relevant regulatory authorities and shine a light on their innovative potential as revealed in patent literature. Collectively, these objectives contribute to a comprehensive understanding of the significance and potential of transethosomes in the field of pharmaceutical nanotechnology.

Structural Changes in Liposomal Vesicles in Association with Sodium Taurodeoxycholate.

Liposomes composed of soy lecithin (SL) have been studied widely for drug delivery applications. The stability and elasticity of liposomal vesicles are improved by incorporating additives, including edge activators. In this study, we report the effect of sodium taurodeoxycholate (STDC, a bile salt) upon the microstructural characteristics of SL vesicles. Liposomes, prepared by the thin film hydration method, were characterized by dynamic light scattering (DLS), small-angle neutron scattering (SANS), electron microscopy, and rheological techniques. We noticed a reduction in the size of vesicles with the incremental addition of STDC. Initial changes in the size of spherical vesicles were ascribed to the edge-activating action of STDC (0.05 to 0.17 µM). At higher concentrations (0.23 to 0.27 µM), these vesicles transformed into cylindrical structures. Morphological transitions at higher STDC concentrations would have occurred due to its hydrophobic interaction with SL molecules in the bilayer. This was ascertained from nuclear magnetic resonance observations. Whereas shape transitions underscored the deformability of vesicles in the presence of STDC, the consistency of bilayer thickness ruled out any dissociative effect. It was interesting to notice that SL-STDC mixed structures could survive high thermal stress, electrolyte addition, and dilution.

Spanlastics nanovesicular ocular insert as a novel ocular delivery of travoprost: optimization using Box-Behnken design and in vivo evaluation.

Currently, travoprost is a synthetic prostaglandin F2α analogue used in the treatment of glaucoma, it is delivered by eye drop solution. Due to its very low bioavailability and patient non-compliance, the objective of the current study was to enhance its bioavailability, and prolong its release Spanlastic nano-vesicles gels were designed and optimized using Box-Behnken design. The optimized spanlastic nano-vesicles gel exhibited the lowest particle size (PS), polydispersity index (PDI) and the highest zeta potential (ZP), encapsulation efficiency (EE) and mucoadhesive strength was fabricated into spanlastic nano-vesicles ocular insert by solvent casting. In vivo studies showed enhanced bioavailability of travoprost spanlastic nano-vesicles gel and ocular insert compared to the marketed eye drops (travoswix®), as proven by their higher Cmax and AUC0-∞, in addition to being nonirritant to ocular surfaces. However, spanlastic nano-vesicles ocular insert showed more prolonged effect than spanlastic nano-vesicles gel. According to our study, it can be suggested that travoprost spanlastic nano-vesicles ocular insert is a novel ocular delivery system for glaucoma treatment.

Spanlastics a Novel Nanovesicular Carrier: Its Potential Application and Emerging Trends in Therapeutic Delivery.

Nanotechnology-based drug delivery system has played a very crucial role in overpowering the tasks allied with the conventional dosage form. Spanlastics, an elastic nanovesicle with an ability to carry wide range of drug molecules, make it a potential drug delivery carrier. Spanlastics have extended rising curiosity for diverse sort of route of administration. They can squeeze themselves through the skin pore due to elastic and deformable nature which makes them favorable for transdermal delivery. Spanlastics consist of non-ionic surfactant or blend of surfactants. Many researchers proved that spanlastics have been significantly augment therapeutic efficacy, enhanced drug bioavailability, and reduced drug toxicity. This review summarizes various vesicular systems, composition and structure of spanlastics, advantages of spanlastics over other drug delivery systems, and mechanism of drug penetration through skin. It also gives a brief on different types of drug encapsulated in spanlastics vesicles for the treatment of various diseases.

Deformable liposomes as enhancer of caffeine penetration through human skin in a Franz diffusion cell test.

OBJECTIVE: The permeation of hydrophilic molecules through the skin is still a challenge due to the barrier posed by stratum corneum, the outermost layer of the skin. Liposomes have frequently been used as carriers for different types of drugs and may also function as permeation enhancers. Propylene glycol has also been used as an edge activator in liposomes to increase the permeation. The aim of this work was to prepare liposomes containing an edge activator and loaded with caffeine to evaluate the potential of caffeine reaching the deeper layers in the skin. METHODS: The formulations were prepared by a top-down process using high-pressure homogenization at 200 00 psi for 10 min. They were characterized by size, polydispersity index (PI), zeta potential (ZP), pH, caffeine content and encapsulation efficiency (EE%) on preparation (time zero) and after 30 days. Cytotoxicity of blank and loaded liposomes was assessed by MTT proliferation assay with a normal keratinocyte cell line (HaCaT). In vitro permeation tests were performed with human skin in Franz cells over 24 h, and caffeine concentration was determined in the skin surface, stratum corneum, dermo-epidermal fraction and receptor medium by HPLC. RESULTS: The caffeine liposomes with (DL-Caf) or without propylene glycol (CL-Caf) showed, respectively, mean size 94.5 and 95.4 nm, PI 0.48 and 0.42, ZP + 1.3 and + 18.1 mV and caffeine content of 78.57 and 80.13%. IC50 values of caffeine in DL-Caf (3.59 v/v %) and CL-Caf (3.65 v/v %) were not significantly different from conventional blank liposome (3.27 v/v %). The DL-Caf formulation presented the best capability to enhance the caffeine permeation through the skin, resulting 1.94-folds higher than caffeine solution. Furthermore, the caffeine flux from DL-Caf was 1.56- and 3.05-folds higher than caffeine solution and CL-Caf, respectively. On the other hand, CL-Caf showed the lowest caffeine penetration revealing the importance of edge activator to aid hydrophilic drug penetration to all skin layers. CONCLUSION: The DL-Caf formulation tested was able to improve the permeation of caffeine through the stratum corneum and dermo-epidermal layers, suggesting that this delivery system may be effective for deep skin delivery of hydrophilic drugs.

OBJECTIF: La perm´eation de mol´ecules hydrophiles `a travers lapeau reste un d´efi en raison de la barri`ere oppos´ee par la couchecorn´ee, la couche la plus externe de la peau. Les liposomes ontfr´equemment ´et´e utilis´es comme supports pour diff´erents types dem´edicaments et peuvent ´egalement fonctionner comme des amplificateursde perm´eation. Le propyl`ene glycol a ´egalement ´et´e utilis´ecomme activateur dans les liposomes pour augmenter la perm´eation.Le but de ce travail ´etait de pr´eparer des liposomes contenantun activateur et charg´es de caf´eine pour ´evaluer le potentiel de lacaf´eine atteignant les couches les plus profondes de la peau. MÉTHODES: Les formulations sont pr´epar´ees par homog´en´eisationhaute pression `a 200 00 psi pendant 10 min. Elles sontcaract´eris´es par la taille des liposomes, l'indice de polydispersit´e(PI), le potentiel zˆeta (ZP), le pH, la teneur en caf´eine et l'efficacit´ed'encapsulation (EE%) `a la pr´eparation (temps z´ero) et apr`es 30jours. La cytotoxicit´e des liposomes `a blanc et charg´es est ´evalu´eepar un test de prolif´eration MTT avec une lign´ee cellulaire de k´eratinocytesnormale (HaCaT). Des tests de perm´eation in vitro sontr´ealis´es avec de la peau humaine dans des cellules de Franz pendant24 h, et la concentration de caf´eine est d´etermin´ee `a la surfacede la peau, dans la couche corn´ee, la fraction dermo-´epidermique et le milieu r´ecepteur par HPLC. RÉSULTATS: Les liposomes contenant de la caf´eine avec (DL-Caf)ou sans propyl`ene glycol (CL-Caf) pr´esentent respectivement unetaille moyenne de 94,5 et 95,4 nm, PI 0,48 et 0,42, ZP + 1,3 et +18,1 mV et une teneur en caf´eine de 78,57 et 80,13%. Les valeursIC50 de la caf´eine dans DL - Caf (3,59 %v/v) et CL - Caf (3,65 %v/v) ne sont pas significativement diff´erentes de celles du liposome `ablanc conventionnel (3,27 %v/v). La formulation DL-Caf est cellequi permet la meilleure perm´eation de la caf´eine, avec une quantit´ede caf´eine dans la peau 1,94 fois plus ´elev´ee que la solution decaf´eine. De plus, le flux de caf´eine de DL-Caf est 1,56 et 3,05 foisplus ´elev´e que la solution de caf´eine et CL-Caf, respectivement.D'autre part, CL-Caf montre la plus faible p´en´etration de caf´eine,r´ev´elant l'importance de l'activateur pour aider `a la p´en´etration dela mol´ecule hydrophile dans toutes les couches de la peau. CONCLUSION: La formulation DL-Caf test´ee am´eliore la perm´eationde la caf´eine `a travers la couche corn´ee et les couches dermo-´epidermiques, ce qui sugg`ere que ce syst`eme d'administration peutˆetre efficace pour l'administration cutan´ee profonde de mol´eculeshydrophiles.

Potential role of resveratrol-loaded elastic sorbitan monostearate nanovesicles for the prevention of UV-induced skin damage.

This study was aiming to improve the effect of the water-insoluble drug, resveratrol, by encapsulating it in surfactant-based elastic vesicles (spanlastics). Spanlastics (SLs) were prepared by thin film hydration method using different ratios of Span 60 (S60) and edge activators (EAs). The prepared SLs were subjected to full in-vitro evaluation. All the SLs showed improved properties compared to the drug suspension (p < 0.05). SL5 composed of S60: Brij 35 (7:3) attained the highest drug entrapment efficiency (79.10%±5.56), the smallest particle size (201.30 nm ± 2.45), the best in-vitro anti-oxidant effect and a fast drug release pattern, thus was selected for further investigation. Based on the Draize test, the selected spanlastics (SL5), as well as the drug suspension, showed to be safe to be applied on the skin (PII <2). In-vivo studies were done to test the photoprotective effect of the designed nanovesicles compared to the drug suspension. Evaluation was done based on visual examination and analysis of some anti-oxidant markers (CAT, GSH and SOD), anti-inflammatory markers (IL-6, IL-8 and NF-κB) and anti-wrinkling markers (MMP-1 and GM-CSF) after UVB-irradiation. The drug showed a good prophylactic effect, however, that of SL5 was superior compared to that of the drug suspension as recorded by the level of all biochemical markers (p < 0.05). These results were also confirmed by histopathological examination. This study proves that elastic nanovesicles seem to be a promising approach to overcome the low drug solubility and to improve its efficacy.

Phospholipid Vesicles for Dermal/Transdermal and Nasal Administration of Active Molecules: The Effect of Surfactants and Alcohols on the Fluidity of Their Lipid Bilayers and Penetration Enhancement Properties.

This is a comprehensive review on the use of phospholipid nanovesicles for dermal/transdermal and nasal drug administration. Phospholipid-based vesicular carriers have been widely investigated for enhanced drug delivery via dermal/transdermal routes. Classic phospholipid vesicles, liposomes, do not penetrate the deep layers of the skin, but remain confined to the upper stratum corneum. The literature describes several approaches with the aim of altering the properties of these vesicles to improve their penetration properties. Transfersomes and ethosomes are the most investigated penetration-enhancing phospholipid nanovesicles, obtained by the incorporation of surfactant edge activators and high concentrations of ethanol, respectively. These two types of vesicles differ in terms of their structure, characteristics, mechanism of action and mode of application on the skin. Edge activators contribute to the deformability and elasticity of transfersomes, enabling them to penetrate through pores much smaller than their own size. The ethanol high concentration in ethosomes generates a soft vesicle by fluidizing the phospholipid bilayers, allowing the vesicle to penetrate deeper into the skin. Glycerosomes and transethosomes, phospholipid vesicles containing glycerol or a mixture of ethanol and edge activators, respectively, are also covered. This review discusses the effects of edge activators, ethanol and glycerol on the phospholipid vesicle, emphasizing the differences between a soft and an elastic nanovesicle, and presents their different preparation methods. To date, these differences have not been comparatively discussed. The review presents a large number of active molecules incorporated in these carriers and investigated in vitro, in vivo or in clinical human tests.

Enhanced Permeation of Methotrexate via Loading into Ultra-permeable Niosomal Vesicles: Fabrication, Statistical Optimization, Ex Vivo Studies, and In Vivo Skin Deposition and Tolerability.

The aim of this study was to incorporate methotrexate (MTX) into ultra-permeable niosomal vesicles, containing cremophor RH40 as an edge activator (EA) and polyvinyl alcohol (PVA) as a stabilizer to enhance the drug permeation. Formulae were prepared by ethanol injection method following a Box-Behnken design in order to optimize the formulation variables (EA%, stabilizer %, and sonication time). To investigate the role of both cremophor RH40 and PVA, conventional MTX niosomes and MTX niosomes containing PVA only were fabricated. Drug entrapment efficiency percent (EE%), particle size (PS) analysis, zeta potential (ZP) measurements, and transmission electron microscopy (TEM) were conducted to characterize the vesicles. Cell viability studies and ex vivo permeation experiments of the optimized formula were conducted. Lastly, in vivo skin deposition of MTX from both the optimized formula and MTX solution was performed in rats. Besides, histopathological changes in rat skin were assessed. The optimized MTX ultra-permeable niosomal formula demonstrated spherical morphology, with an EE% of 65.16% and a PS of 453.6 nm. The optimized formula showed better physical stability in comparison with that of the same composition but lacking PVA. The cell viability studies verified the superior cytotoxicity of the optimized formula, and the ex vivo permeation studies revealed its ability to improve the drug permeation. The optimized formula demonstrated a significant deposition of MTX in rat dorsal skin, and histopathological evaluation confirmed the tolerability of the optimized formula in rats upon topical application. Accordingly, ultra-permeable noisomes, as a stable nanosystem, could be promising for effective delivery of MTX.

Development and optimization of a novel drug free nanolipid vesicular system for treatment of osteoarthritis.

OBJECTIVE: The goal of this study is to improve the transdermal delivery of phosphatidylcholine (PC) via constructing a novel nanolipid vesicular system (NLVS) with high level of permeability through the stratum corneum (SC). SIGNIFICANCE: In our study, a novel drug free NLVS was developed. The system depends on PC boundary cartilage lubrication to relieve osteoarthritic pain without developing gastrointestinal problems associated with anti-inflammatory drug. MATERIALS AND METHODS: A full two-level (23) factorial design is applied to optimize the quality of the prepared NLVS. The selected independent variables are the concentration of PC, the concentration of edge activator (EA), and EA type. The developed NLVS was evaluated for in-vitro, ex-vivo as well as in-vivo efficacy in rat animal model. RESULTS: Based on the factorial design, the selected formulation variables significantly affect the tested responses. The prepared NLV formulations have a particle size (PS)in the range of 10.34 to 496.3 nm, polydispersity index (PdI) values less than one, and negative zeta potential (ZP) range of -1.42 to -32.01 mV. In-vitro and ex-vivo study results reveal that the designed NLVS is effective in sustaining PC release and enhancing its transdermal permeation over 24 h. The optimal permeation flux through ex-vivo study is 0.415 mg/cm2/h following zero-order kinetics. Moreover, in-vivo study of the optimized formulations demonstrated remarkable reduction in inflammatory mediators associated with osteoarthritis (OA). CONCLUSION: The results indicate that the optimized drug free NLVS significantly augment transdermal delivery of PC and have a potential role in treatment of OA without the risk of systemic side effects.

Topical Delivery of Fenoprofen Calcium via Elastic Nano-vesicular Spanlastics: Optimization Using Experimental Design and In Vivo Evaluation.

The aim of this study was to investigate the potential of surfactant-based nanovesicular system (spanlastics) for topical delivery of fenoprofen calcium (FPCa) to eliminate its oral gastrointestinal adverse effects. FPCa-loaded spanlastics were prepared by thin film hydration (TFH) technique according to a full factorial design to investigate the influence of formulation variables on the drug entrapment efficiency (%EE), particle size (PS), deformability index (DI), and the % drug released after 24 h through the cellulose membrane (Q24h) using Design-Expert® software. The optimized formula (composed of Span 60 and Tween 60 as an edge activator at weight ratio of 8: 2 in presence of Transcutol P as a cosolvent in the hydration media) exhibited the highest %EE (49.91 ± 2.60%), PS of 536.1 ± 17.14 nm, DI of 5.07 ± 0.06 g, and Q24h of 61.11 ± 2.70%; it was also characterized for morphology and physical stability. In vitro release study of FPCa-loaded spanlastic gel and conventional FPCa gel through a synthetic membrane and hairless rat skin were evaluated. The skin permeation study revealed that spanlastic gel exhibited both consistent and prolonged action. Finally, the % inhibition of carrageenan-induced rat paw edema of spanlastic gel was three times higher than the conventional FPCa gel after 24 h. In conclusion, spanlastic-based gel could be a great approach for improving topical delivery of fenoprofen calcium, providing both prolonged and enhanced anti-inflammatory activity in the treatment of arthritis.

Quality by design for Niosome-Based nanocarriers to improve transdermal drug delivery from lab to industry.

Niosomes are essentially multilamellar or unilamellar vesicles based on non-ionic surfactants. They consist of surfactant macromolecules arranged in a bilayer, which surrounds an aqueous solute solution. Amphiphilic, biodegradable, biocompatible, and environmentally friendly materials are utilized for encapsulating the drugs in vesicles that enhance the bioavailability, therapeutic efficacy, penetration of drug via the skin, and drug release in a controlled or sustained manner, and are employed to target the anticipated area via modifying composition that acts to minimize undesirable effects. With cholesterol as the lipid, Tween 20, Span 60, and Tween 60 are mostly employed as surfactants. Many medications, including Glibenclamide for diabetic kidney disease and anti-cancer medications including gemcitabine, cisplatin, and nintedanib, have been effectively encapsulated into niosomes. The traditional approach for creating niosomes at the lab scale is a thin film hydration process. The ideal ratio between primary components as well as critical manufacturing process parameters is key component in creating the best niosomal formulations with substantial drug loading and nanometric form. Utilizing the Design of Experiments (DoE) and Response Surface Methodology (RSM) in conjunction with Quality by design (QbD) is essential for comprehending how these variables interact both during lab preparation and during the scale-up process. Research on the development of anti-aging cosmetics is being done by Loreal. Niosomal preparations like Lancome are sold in stores. An overview of niosomes, penetration mechanisms, and quality by design from laboratory to industrial scale is provided in this article.

Transfersomes: Recent Advances, Mechanisms, Exhaustive Applications, Clinical Trials, and Patents

A feasible nano transdermal delivery system generally intends to have specific ideal and distinct characteristics primarily for safety, clinical efficacy, and boosted therapeutic index. The delivery of drugs, particularly macromolecules, across the skin is one of the most strenuous obstacles in front of pharmaceutical scientists. Technology advancement has provided some opportunities to overcome this difficulty by utilising microneedle arrays, ablation, laser methods etc. However, associated uneasiness, painful sensation, and higher cost of therapies limit their day-to-day use. Therefore, researchers have focused on developing alternate carriers like ultra-deformable liposomes, also termed transfersomes. Transfersomes are composed of a lipid bilayer containing phospholipids and an edge activator to facilitate drug delivery via transdermal route to deeper layers of skin and for higher systemic bioavailability. The bilayer structure of transfersomes allows ease of encapsulation of both hydrophilic and lipophilic drugs with higher permeability than typical liposomes. Therefore, among various vesicular systems, transfersomes have developed much interest in targeted and sustained drug delivery. The current review primarily emphasizes critical aspects of transfersomes, including their applications, clinical trial studies, and patents found in various literature sources.

An overview of phospholipid enriched-edge activator-based vesicle nanocarriers: New paradigms to treat skin cancer.

Skin cancer poses a significant global health concern necessitating innovative treatment approaches. This review explores the potential of vesicle nanoformulation incorporating EA (edge activators) to overcome barriers in skin cancer management. The skin's inherent protective mechanisms, specifically the outermost layer called the stratum corneum and the network of blood arteries, impede the permeation of drugs. Phospholipid-enriched EA based nanoformulation offer a promising solution by enhancing drug penetration through skin barriers. EAs like Span 80, Span 20, Tween 20, and sodium cholate etc., enhance vesicles deformability, influencing drug permeation. This review discusses topical application of drugs treat skin cancer, highlighting challenges connected with the conventional liposome and the significance of using EA-based nanoformulation in overcoming these challenges. Furthermore, it provides insights into various EA characteristics, critical insights, clinical trials, and patents. The review also offers a concise overview of composition, preparation techniques, and the application of EA-based nanoformulation such as transfersomes, transliposomes, transethosomes, and transniosomes for delivering drugs to treat skin cancer. Overall, this review intends to accelerate the development of formulations that incorporate EA, which would further improve topical drug delivery and enhance therapeutic outcomes in skin cancer treatment.

Overcoming Skin Barrier with Transfersomes: Opportunities, Challenges, and Applications.

BACKGROUND: Transdermal drug delivery systems (TDDS) offer several advantages over traditional methods like injections and oral administration, including preventing first-pass metabolism, providing consistent and sustained activity, reducing side effects, enabling the use of short halflife drugs, improving physiological response, and enhancing patient convenience. However, the permeability of skin poses a challenge for TDDS, as it is impermeable to large molecules and hydrophilic drugs but permeable to small molecules and lipophilic medications. To overcome this barrier, researchers have investigated vesicular systems, such as transfersomes, liposomes, niosomes, and ethosomes. Among these vesicular systems, transfersomes are particularly promising for non-invasive drug administration due to their deformability and flexible membrane. They have been extensively studied for delivering anticancer drugs, insulin, corticosteroids, herbal medicines, and NSAIDs through the skin. Transfersomes have demonstrated efficacy in treating skin cancer, improving insulin delivery, enhancing site-specific corticosteroid delivery, and increasing the permeation and therapeutic effects of herbal medicines. They have also been effective in delivering pain relief with minimal side effects using NSAIDs and opioids. Transfersomes have been used for transdermal immunization and targeted drug delivery, offering site-specific release and minimizing adverse effects. Overall, transfersomes are a promising approach for transdermal drug delivery in various therapeutic applications. OBJECTIVES: The aim of the present review is to discuss the various advantages and limitations of transfersomes and their mechanism to penetration across the skin, as well as their application for the delivery of various drugs like anticancer, antidiabetic, NSAIDs, herbal drugs, and transdermal immunization. METHODS: Data we searched from PubMed, Google Scholar, and ScienceDirect. RESULTS: In this review, we have explored the various methods of preparation of transferosomes and their application for the delivery of various drugs like anticancer, antidiabetic, NSAIDs, herbal drugs, and transdermal immunization. CONCLUSION: In comparison to other vesicular systems, transfersomes are more flexible, have greater skin penetration capability, can transport systemic medicines, and are more stable. Transfersomes are capable of delivering both hydrophilic and hydrophobic drugs, making them suitable for transdermal drug delivery. The developed transfersomal gel could be used to improve medicine delivery through the skin.

Improved skin permeation of transferosomes containing Eulophia macrobulbon extract.

Eulophia macrobulbon (EM) extract-loaded transferosomes represent an advanced approach for enhancing skin permeation of bioactive compounds. The formulations improving skin permeation and characterizations of transferosomes were studied, including morphology, entrapment efficiency (EE), vesicle size, polydispersity index (PDI), zeta potential, and skin permeation in the Strat-M® synthetic membrane. Vesicle size increased with increasing transition temperature (Tm) of phosphatidylcholine and the hydrophilic-lipophilic balance (HLB) of the surfactant used as an edge activator. EM extract-loaded transferosomes with varying amounts of phosphatidylcholine, surfactants, and EM extract showed non-significant differences in EE, PDI, and zeta potential. The results demonstrated that the EM extract-loaded transferosomes improved membrane permeability better than the EM solution. The EM solution exhibited a shorter lag time. Considering the advantages of the EM extract-loaded transferosomes and EM solutions, a combination of both formulations was developed in this study. The results showed that the lag time decreased and membrane permeation increased. This study highlights a novel system combining EM extract-loaded transferosomes and an EM solution, exhibiting considerable improvement in skin permeation and presenting the potential for an efficient transdermal drug delivery system for natural bioactive compounds.

Novel Luliconazole Spanlastic Nanocarriers: Development and Characterisation.

BACKGROUND: The formulation of spanlastic vesicles of luliconazole can be used to overcome its poor skin permeation and improve its antifungal efficacy. OBJECTIVE: In this study, we aimed to enhance the dermal delivery of luliconazole, an antifungal drug, through spanlastic vesicles. METHODS: A 23 regular factorial design was employed, using the Design Expert® software for optimization. The independent variables chosen were Span: Edge activator ratio, type of edge activator, and sonication intensity and their effect on the dependent variables, i.e., entrapment efficiency, particle size, and percentage of drug release after 8h were determined. Spanlastics were formulated by ethanol injection method using Tween 80 as an edge activator. RESULTS: Spanlastics were found to possess sizes in the nano range with entrapment efficiencies between 77 - 88% with optimum zeta potential and polydispersity index indicating a stable formulation. Differential scanning calorimetry, X-ray diffraction, and Fourier transform infrared studies revealed complete encapsulation of the drug within the elastic carriers. The optimized spanlastic formulation was further incorporated into a gel base and was found to be sufficiently viscous, spreadable, homogenous, showed a prolonged release for up to 8h and was also found to be non-irritant. The in-vitro permeation study revealed that the flux value obtained for luliconazole entrapped in the vesicular spanlastics (0.2292 mg/cm2.h) was also found to be higher than that of the marketed (0.1302 mg/cm2.h) and conventional gel (0.1122 mg/cm2.h). The optimized gel formulation was also evaluated for its antimycotic activity. Moreover, the optimized gel formulation also possessed a greater antimycotic activity against Candida albicans. The spanlastics loaded hydrogel formulation was found to have a greater zone of inhibition in comparison to the marketed formulation, thus proving to have optimum antifungal activity against Candida albicans. CONCLUSION: Collectively, the results revealed that spanlastics could be a potential nanocarrier for wellcontrolled delivery and for targeting deeper skin layers, thus providing new opportunities for dermal treatment.

Neutral Oil-Incorporated Liposomal Nanocarrier for Increased Skin Delivery of Ascorbic Acid.

In this study, a neutral oil-incorporated liposomal system (lipo-oil-some, LOS) was designed to improve the skin absorption of ascorbic acid (Vit C), and the effects of an edge activator and neutral oil on the skin absorption of Vit C were evaluated. As components of the LOS system, sodium deoxycholate, polysorbate 80, and cholesterol were screened as edge activators, and camellia oil, tricaprylin, and grapeseed oil were employed as neutral oils. The LOS systems prepared by the ethanol injection method were spherical in shape, 130-350 nm in size, and had 4-27% Vit C loading efficiency (%). In a skin absorption study using a Franz diffusion cell mounted with porcine skin, the LOS system prepared with sodium deoxycholate (10 w/w% of phospholipid) exhibited 1.2-and 2.9-fold higher absorption than those prepared with polysorbate 80 and cholesterol, respectively. Moreover, the type of neutral oil had a marked effect on the absorption of Vit C; the liposomal system containing camellia oil provided 1.3 to 1.8 times higher flux (45.4 µg/cm2∙h) than vesicles with tricaprylin or grapeseed oil, respectively. The optimized lipid nanocarrier is expected to be a promising tool for promoting the skin absorption of Vit C and improving its dermatological functions.

The effect of surfactant type on characteristics, skin penetration and anti-aging effectiveness of transfersomes containing amniotic mesenchymal stem cells metabolite products in UV-aging induced mice.

Transfersome has been developed to enhance dermal delivery of amniotic mesenchymal stem cell metabolite products (AMSC-MP). AMSC-MP contains many growth factors for managing skin aging, thus improving the quality of an adjusted life year. This study aims to determine the effect of surfactant types acting as the edge activator on transfersome-loading AMSC-MP. Transfersome was prepared by thin-layer hydration method and composed of l-α-phosphatidylcholine as a phospholipid and three types of surfactants, namely; cationic (stearylamine), anionic (sodium cholate), and nonionic surfactant (Tween 80) at a weight ratio of 85:15, respectively. Transfersomes were evaluated for physical characteristics, penetration, effectiveness, and safety. The results showed that sodium cholate, an anionic surfactant, produced the smallest transfersome particle size, i.e., 144.2 ± 3.2 nm, among all formulas. Trans-SA containing stearylamine had a positive charge of 41.53 ± 6.03 mV compared to Trans-SC and Trans-TW, whose respective charges were -56.9 ± 0.55 mV and -41.73 ± 0.86 mV. The small particle size and low negative value of zeta potential enabled high dermal penetration by transfersomes containing AMSC-MP, while the positive charge of stearylamine hindered its penetration of deeper skin layers. Trans-SC and Trans-TW produced higher collagen density values at 77.11 ± of 4.15% and 70.05 ± of 6.95%, than that of Trans-SA. All the AMSC-MP transfersomes were relatively safe with 0.5-1.0 macrophage cell numbers invaded the dermis per field of view. In conclusion, sodium cholate, an anionic surfactant, demonstrated considerable capacity as the edge activator of transfersome-loading AMSC-MP for skin anti-aging therapy.

Optimizing and Evaluating the Transdermal Permeation of Hydrocortisone Transfersomes Formulation Based on Digital Analysis of the In Vitro Drug Release and Ex Vivo Studies.

BACKGROUND: Transfersomes can be used to enhance transdermal drug delivery due to their flexibility and ability to incorporate various molecules. For example, hydrocortisone (HC), a corticosteroid, is taken by different routes and serves as immunosuppressive, anticancer, and antiallergenic; however, it is poorly absorbed by the skin. OBJECTIVE: Therefore, the current study suggested HC-loaded transfersomes as an alternative route of administration for reaching deeper skin layers or systemic circulation, to reduce the side effects of HC and improve its bioavailability. METHODS: HC transfersomes were prepared by the thin-film hydration method and characterized for their vesicular size, zeta potential, drug entrapment efficiency, elasticity, FTIR spectroscopy, in vitro drug release, ex vivo permeation, and irritancy in rabbits. The optimized formulation, F15 (containing HC 20 mg, egg phosphatidylcholine (EPC) 400 mg, and 75 mg of Span 80), was chosen because it showed the highest (p< 0.05) EE% (60.4±0.80) and optimized sustained in vitro drug release (Q8 = 87.9±0.6%). RESULTS: Extensive analysis of the drug release data from all formulas was performed using the DDSolver software which quantitatively confirmed the successful formulation. The Weibull equation was the best model to fit the release data compared to others, and the release mechanism was Fickian diffusion. CONCLUSION: The simulated pharmacokinetic parameters showed that F15 had the highest AUC, MDT, and DE. Furthermore, F15 significantly enhanced HC permeation by 12-folds compared to the control through the excised rat's skin. The skin irritancy test has proven F15 safety and skin compatibility.