Quality attributes of pistachio nuts as affected by rootstock and deficit irrigation.

BACKGROUND: In this work, the influence of two regulated deficit irrigation (RDI) treatments and three different rootstocks on the quality of pistachios was evaluated by analyzing different parameters: morphological analysis, physicochemical analysis and sensory analysis. RESULTS: The results obtained in terms of the choice of rootstock revealed that Pistacia atlantica had increased production yields, nut weight, mineral content, higher intensities of characteristic sensory attributes and a higher degree of consumer satisfaction, than the other rootstocks studied. Moreover, the results established that the application of RDI on pistachio cultivation had no significant influence on production yield, weight, size, colour, water activity or mineral composition. Furthermore, T1 treatment (stem water potential < -1.3 MPa) resulted in higher intensities of characteristic sensory attributes and a greater level of satisfaction among international consumers. CONCLUSION: These results confirm that the application of deficit irrigation (T1) contributes to an increase in overall product quality. Furthermore, Pistacia atlantica rootstock provided better yield and quality than the other rootstocks studied.

Accumulation of lipofuscin-like pigments of walnuts (Carya cathayensis) during storage: potential roles of lipid oxidation and non-enzymatic glycosylation.

BACKGROUND: Lipofuscin-like pigments (LFLP) are considered a hallmark of aging. The intracellular LFLP formation rate is negatively correlated with the life expectancy of cell. In food quality, increase of LFLP not only affects the appearance but also causes loss of nutritional value. RESULTS: The accumulation of LFLP increased during storage of all walnuts. LFLP fluorescent intensities of walnuts with 4%, 6%, 12% and 16% moisture at the end of storage were 8.1, 4.8, 4.3 and 2.8 times those at the beginning, respectively. The LFLP accumulation of walnuts with high moisture was found to be negatively correlated with soluble sugars and 1,1-diphenyl-2-picrylhydrazyl (DPPH) radical quenching rate, but positively correlated with the content of hydroxymethylfuraldehyde (HMF). While the LFLP accumulation of walnuts with low moisture had a strong positive correlation with anisidine value, it exhibited high negative correlations with acid phosphatase activity, DPPH(•) quenching rate and tocopherol content. CONCLUSION: In walnuts with low initial moisture, lipoxidation products increased markedly during storage and these products might provide the source for LFLP accumulation. On the other hand, in walnuts with high initial moisture, reducing sugars derived from the hydrolysis of soluble sugars might play an important role in initiating the Maillard-like reaction, leading to LFLP accumulation.

Critical points of Brazil nuts: a beginning for food safety, quality control and Amazon sustainability.

BACKGROUND: One difficulty of self-sustainability is the quality assurance of native products. This research was designed to study the risks and critical control points in the collection, handling and marketing of Brazil nuts from native forests and urban fairs in the Brazilian Amazon by characterisation of morphological aspects of fungi and posterior identification by molecular biology and determination of aflatoxins by high-performance liquid chromatography. RESULTS: Several corrective actions to improve product quality were found to be necessary in both sites. Growth of fungi was observed in 95% of fragments of Brazil nuts from both sites during the between-harvest period. Aflatoxin levels indicated that, although fungal growth was observed in both sites, only Brazil nuts from the native forest showed a high risk to human health (total aflatoxin level of 471.69 µg kg(-1)). CONCLUSION: This study has shown the main issues related to the process design of Brazil nuts, supporting the necessity for research on new strategies to improve the quality of nuts. Also, the habit of eating Brazil nuts stored throughout the year may represent a risk to farmers.

Quality changes in macadamia kernel between harvest and farm-gate.

BACKGROUND: Macadamia integrifolia, Macadamia tetraphylla and their hybrids are cultivated for their edible kernels. After harvest, nuts-in-shell are partially dried on-farm and sorted to eliminate poor-quality kernels before consignment to a processor. During these operations, kernel quality may be lost. In this study, macadamia nuts-in-shell were sampled at five points of an on-farm postharvest handling chain from dehusking to the final storage silo to assess quality loss prior to consignment. Shoulder damage, weight of pieces and unsound kernel were assessed for raw kernels, and colour, mottled colour and surface damage for roasted kernels. RESULTS: Shoulder damage, weight of pieces and unsound kernel for raw kernels increased significantly between the dehusker and the final silo. Roasted kernels displayed a significant increase in dark colour, mottled colour and surface damage during on-farm handling. CONCLUSION: Significant loss of macadamia kernel quality occurred on a commercial farm during sorting and storage of nuts-in-shell before nuts were consigned to a processor. Nuts-in-shell should be dried as quickly as possible and on-farm handling minimised to maintain optimum kernel quality.

Effect of irradiation, active and modified atmosphere packaging, container oxygen barrier and storage conditions on the physicochemical and sensory properties of raw unpeeled almond kernels (Prunus dulcis).

BACKGROUND: The present study investigated the effect of irradiation, active and modified atmosphere packaging, and storage conditions on quality retention of raw, whole, unpeeled almonds. Almond kernels were packaged in barrier and high-barrier pouches, under N(2) or with an O(2) absorber and stored either under fluorescent lighting or in the dark at 20 °C for 12 months. Quality parameters monitored were peroxide value, hexanal content, colour, fatty acid composition and volatile compounds. Of the sensory attributes colour, texture, odour and taste were evaluated. RESULTS: Peroxide value and hexanal increased with dose of irradiation and storage time. Irradiation resulted in a decrease of polyunsaturated and monounsaturated fatty acids during storage with a parallel increase of saturated fatty acids. Volatile compounds were not affected by irradiation but increased with storage time indicating enhanced lipid oxidation. Colour parameters of samples remained unaffected immediately after irradiation. For samples packaged under a N(2) , atmosphere L and b values decreased during storage with a parallel increase of value a resulting to gradual product darkening especially in irradiated samples. CONCLUSION: Non-irradiated almonds retained acceptable quality for ca. 12 months stored at 20 °C with the O(2) absorber irrespective of lighting conditions and packaging material oxygen barrier. The respective shelf life for samples irradiated at 1.0 kGy was 12 months packaged in PET-SiOx//LDPE irrespective of lighting conditions and 12 months for samples irradiated at 3 kGy packaged in PET-SiOx//LDPE stored in the dark.

Characterisation of selected hazelnut cultivars: phenology, growing and yielding capacity, market quality and nutraceutical value.

BACKGROUND: Sixteen hazelnut cultivars growing in the continental climate of Slovenia were analysed over 15 years for their phenology, growth habit, yield potential, susceptibility to hazelnut weevil and the pomological traits and phenolic content of their nuts in order to obtain a complex value of these cultivars for growers, the confectionary industry and consumers. RESULTS: Blooming occurred over an interval of 10-23 days for female (pistillate) flowers and 11-22 days for male (staminate) flowers. Nocchione, Romai, Pauetet, ID and Daria were the most productive cultivars, with a nine-year cumulative yield ranging from 31.8 to 44.7 kg per plant. Pauetet, F. Coutard, Nocchione and Segorbe were less susceptible to unfavourable weather conditions during blooming and fertilisation, in terms of maintaining acceptable yields with limited blank production. Under integrated pest management, less than 2% of the nuts of Romai, Daria, TGDL and Nocchione were affected by hazelnut weevil, compared with an average of 5.5% for the other cultivars. Daria, Pauetet and T. Giffoni performed best with regard to kernel percentage and blanching ratio. The results suggest that raw kernels are a good source of the natural antioxidants gallic acid and epicatechin. CONCLUSION: The results of this study provide direction when choosing hazelnut cultivars for planting, consuming or processing. They can be applied not only in Slovenia and nearby countries but also in other parts of central and northern European countries with similar climates and growing conditions.

Acquisition of the physiological quality of peanut (Arachis hypogaea L.) seeds during maturation under the influence of the maternal environment.

The scarcity of information on the maturation physiology of the peanut seed (Arachis hypogaea L.; Virgínia group) makes harvesting high quality seeds a challenge for the seed industry. During two consecutive crop seasons, we studied the acquisition of physiological quality of peanut seeds during maturation in tropical conditions. We bring new insights about the period of late maturation of seeds and the influence of the maternal environment on physiological quality. We monitored water content, dry weight, ability of germination, desiccation tolerance, vigor and longevity. In addition, we monitored temperature and precipitation throughout plant growth. We demonstrate that the physiological quality of peanut seeds is acquired during development, with a maximum between 57 and 76 days after flowering in the late stage of maturation. This final period represents about 25% of the development, considered the best time to harvest peanut seeds with the highest quality. Our findings also support the idea that the adequate proportion of rainfall and thermal sum in the maternal environment are factors that favor the acquisition of peanut seed longevity.

Authentication of an Italian PDO hazelnut ("Nocciola Romana") by NIR spectroscopy.

Common hazelnuts are widely present in human diet all over the world, and their beneficial effects on the health have been extensively investigated and demonstrated. Different in-depth researches have highlighted that the harvesting area can define small variations in the chemical composition of the fruits, affecting their quality. As a consequence, it has become relevant to develop methodologies which would allow authenticating and tracing hazelnuts. In the light of this, the present work aims to develop a non-destructive method for the authentication of a specific high-quality Italian hazelnut, "Nocciola Romana," registered with a protected designation of origin (PDO). Thus, different samples of this fruit have been analyzed by near-infrared (NIR) spectroscopy and then classification models have been built, in order to distinguish between the PDO fruits and the hazelnuts not coming from the designated region. In particular, two different classification approaches have been tested, a discriminant one, partial least squares-discriminant analysis, and a class-modeling one, soft independent modeling of class analogies. Both methods led to very high prediction capability in external validation on a test set (classification accuracy in one case, and sensitivity and specificity in the other, all higher than 92%), suggesting that the proposed methodologies are suitable for a rapid and non-destructive authentication of the product.

Effect of micro-encapsulated antioxidant formulations on mycobiota, residual levels, sensory analyses and insect pest attack in stored peanuts.

The in situ effect of microencapsulated 2(3)-tert-butyl-4 hydroxyanisole (BHA) on stored peanuts (Arachis hipogaea) intended for human consumption was evaluated. Peanut were stored unshelled in flexible containers called "big bags" that were made of polypropylene raffia. 100 kg of peanuts were used in each big bag and stored in refrigerated cells (<18 °C) for about 5 months in two different peanut processing companies during 2015/2016 period. Fungal populations, aflatoxin accumulation, BHA residues, acidity and fatty acid profile, sensory analyses, insect damage and environmental factors variation, were evaluated. At the end of the storage period, significant (p < 0.05) fungitoxic effects of the BHA formulation were observed in the order of 30 and 15% for the first and second company, respectively. Cladosporium, yeasts, Penicillium, Fusarium, Alternaria and Aspergillus were the main fungal isolates. No aflatoxins were found for both companies and years evaluated. In addition, taste of the peanuts was not significantly affected (p < 0.05) by formulation used and insect damage was always lower than 3%. However, different levels of BHA were detected throughout the experiment in the two companies, with final levels of 2.5 for the C1 and 275 ng BHA/g peanuts in C2. Formulation did not affect acidity and organoleptic properties of peanuts. These results show that BHA formulation could be used as part of alternative strategy for control of fungal contamination storage period.

Phytopatological problems and solutions in the walnut orchards along Lake Balaton.

European or Persian Walnut (Juglans regia) is an important and healthy food as well as base material of timber industry. Several pests (pathogens and insect pests) may cause serious damages on walnut. These are less known on the crop land of the tree. Results of some years of our experiments including bacteriological and mycological studies, are presented in this paper. The optimum time of chemical protection against the walnut blight (Xanthomonas arboricola pv. juglandis) was determined. Occurrences of pathogenic fungi were surveyed in an orchard and on home garden trees in Hungary (18 fungus species were identified). The following experimental results are reported on the pathogenic fungi: cultivar resistance to walnut anthracnose (Gnomonia leptostyla), dying of wood parts in the cultivar collection, application of the spore trap, in vitro fungicide testing against Phomopsis juglandina.

Sensory Quality Preservation of Coated Walnuts.

The objective of this study was to evaluate the sensory stability of coated walnuts during storage. Four walnut samples were prepared: uncoated (NC), and samples coated with carboxymethyl cellulose (NCMC), methyl cellulose (NMC), or whey protein (NPS). The samples were stored at room temperature for 210 d and were periodically removed from storage to perform a sensory descriptive analysis. A consumer acceptance test was carried out on the fresh product (storage day 0) to evaluate flavor. All samples exhibited significant differences in their sensory attributes initially and after storage. Intensity ratings for oxidized and cardboard flavors increased during storage. NC showed the highest oxidized and cardboard intensity ratings (39 and 22, respectively) and NMC exhibited the lowest intensity ratings for these negative attributes (8 and 17, respectively) after 210 d of storage. Alternatively, the intensity ratings for sweetness and walnut flavors were decreased for all samples. NMC had the lowest decrease at the end of storage for these positive attributes (75.86 in walnut flavor and 12.09 in sweetness). The results of this study suggest a protective effect of the use of an edible coating to preserve sensory attributes during storage, especially for samples coated with MC. The results of the acceptance test showed that addition of the coating negatively affected the flavor acceptance for NMC and NCMC coated walnuts. Edible coatings help to preserve sensory attributes in walnuts, improving their shelf-life, however, these coatings may affect consumer acceptance in some cases.

Quality Evaluation of Shelled and Unshelled Macadamia Nuts by Means of Near-Infrared Spectroscopy (NIR).

The quality of shelled and unshelled macadamia nuts was assessed by means of Fourier transformed near-infrared (FT-NIR) spectroscopy. Shelled macadamia nuts were sorted as sound nuts; nuts infected by Ecdytolopha aurantiana and Leucopteara coffeella; and cracked nuts caused by germination. Unshelled nuts were sorted as intact nuts (<10% half nuts, 2014); half nuts (March, 2013; November, 2013); and crushed nuts (2014). Peroxide value (PV) and acidity index (AI) were determined according to AOAC. PCA-LDA shelled macadamia nuts classification resulted in 93.2% accurate classification. PLS PV prediction model resulted in a square error of prediction (SEP) of 3.45 meq/kg, and a prediction coefficient determination value (Rp (2) ) of 0.72. The AI PLS prediction model was better (SEP = 0.14%, Rp (2) = 0.80). Although adequate classification was possible (93.2%), shelled nuts must not contain live insects, therefore the classification accuracy was not satisfactory. FT-NIR spectroscopy can be successfully used to predict PV and AI in unshelled macadamia nuts, though.

Detecting internal quality of peanuts during storage using electronic nose responses combined with physicochemical methods.

In this study, the changes in the quality of unshelled peanuts and peanut kernels during storage were analyzed using an electronic nose (e-nose). The physicochemical indexes (acid and peroxide values) of peanut kernels were tested by traditional method as a reference. The storage time of peanut kernels increases from left to right in the cluster analysis plot based on the physicochemical indexes. The "maximum values", "area values", and "70th s values" methods were applied to extract the feature data from the e-nose responses. Principal component analysis (PCA) results indicated that the "70th s values" method produced the most accurate results, furthermore, unshelled peanut and peanut kernel samples presented similar characteristics in the PCA plots; the partial least squares regression (PLSR) results showed that the features of unshelled peanuts and peanut kernels are highly correlated with acid and peroxide values, respectively.

Distribution of aflatoxin in pistachios. 6. Seller's and buyer's risk.

The seller's risk-the probability of a set of samples exceeding an agreed upon aflatoxin level when the lot mean does not-and the buyer's risk-the probability of a lot exceeding this level when a set of samples do not-have been computed using a parametrized experimental aflatoxin distribution and Monte Carlo simulation. The calculations are exemplified using the proposed EC standards (three 10 kg samples, 4 ng/g of total aflatoxin, basis kernels only) as well as for samples up to 250 kg and for varied lot aflatoxin levels. It is found that within this sample size range the seller's risk is as high as 42% at 10 kg and increases with increasing sample size to 80% at 250 kg. Only by reducing lot levels to 0.2 ng/g of total aflatoxin, basis kernels, can the risk be brought down to 2.5%, independent of sample size. The buyer's risk is as high as 58% at 10 kg but falls to 11% at 250 kg samples. The implications for both seller and buyer strategies are discussed.

Analysis of different European hazelnut (Corylus avellana L.) cultivars: authentication, phenotypic features, and phenolic profiles.

Hazelnuts exhibit functional properties due to their content in fatty acids and phenolic compounds that could positively affect human health. The food industry requires precise traits for morphological, chemical, and physical kernel features so that some cultivars could be more suitable for specific industrial processing. In this study, agronomical and morphological features of 29 hazelnut cultivars were evaluated and a detailed structural characterization of kernel polyphenols was performed, confirming the presence of protocatechuic acid, flavan-3-ols such as catechin, procyanidin B2, six procyanidin oligomers, flavonols, and one dihydrochalcone in all the analyzed cultivars. In addition, an innovative methodology based on the MALDI-TOF mass spectrometric analysis of peptide/protein components extracted from kernels was developed for the authentication of the most valuable cultivars. The proposed method is rapid, simple, and reliable and holds the potential to be applied in quality control processes. These results could be useful in hazelnut cultivar evaluation and choice for growers, breeders, and food industry.

Aflatoxin evaluation in ready-to-eat brazil nuts using reversed-phase liquid chromatography and post-column derivatisation.

A high-performance liquid chromatography-fluorescence (HPLC-FD) method for aflatoxin quantification in brazil nuts was developed. Samples of brazil nuts collected in Brazilian markets were extracted with methanol:water and cleaned using an immunoaffinity column. Aflatoxins were eluted with methanol and a post-column derivatisation was performed with bromine, using a Kobra Cell system. The optimised method for total aflatoxins was sensitive, with detection and quantification limits of 0.05 and 0.25 µg kg⁻¹, respectively. The method was accurate, with recovery values of 87.6%; 85.3% and 85.0% for 0.5, 5.0 and 14.6 µg kg⁻¹ spiked levels, respectively. It was shown that the method was applicable to brazil nuts. From a total of 95 brazil nut samples analysed from 21 São Paulo supermarket samples and 51 Manaus and 23 Belém street markets samples, 37.9% showed detectable levels of aflatoxins and three exceeded the recommended Codex Alimentarius limit of 10 µg kg⁻¹ for ready-to-eat brazil nuts.

Determination of ochratoxins in nuts and grain samples by in-tube solid-phase microextraction coupled with liquid chromatography-mass spectrometry.

A simple and sensitive method for the determination of ochratoxins A and B in nuts and grain samples was developed using an automated in-tube solid-phase microextraction (SPME) coupled with liquid chromatography-mass spectrometry (LC-MS). Ochratoxins were separated within 5 min by high-performance liquid chromatography using an Inertsil ODS-3 column with 5mM anmonium acetate/acetonitrile (65/35, v/v) as the mobile phase. Electrospray ionization conditions in the positive ion mode were optimized for mass spectrometric detection of ochratoxins. The pseudo molecular ion [M+H](+) was used to detect ochratoxins with selected ion monitoring (SIM) mode. The optimum in-tube SPME conditions were 20 draw/eject cycles of 40 µL of sample using a Carboxen-1006 PLOT capillary column as an extraction device. The extracted ochratoxins were easily desorbed from the capillary by passage of the mobile phase, and no carryover was observed. Using the in-tube SPME/LC-MS with SIM method, good linearities of the calibration curves (r=0.9993 for ochratoxin A and r=0.9989 for ochratoxin B) were obtained in the concentration range from 0.5 to 20 ng/mL. The detection limits (S/N=3) for ochratoxins A and B were 92 and 89 pg/mL, respectively. The in-tube SPME method showed above 15-19-fold greater sensitivity than the direct injection method (10 µL injection). The within-day and between-day precisions (relative standard deviations) were below 5.1% and 7.7% (n=6), respectively. This method was applied successfully to analysis of nuts and grain samples without interference peaks. The recoveries of ochratoxins spiked into extraction solution from nut samples were above 88%. Ochratoxins were detected at 0.7-8.8 ng/g levels in various nuts and grain samples.

Characterization of pine nuts in the U.S. market, including those associated with "pine mouth", by GC-FID.

Taste disturbances following consumption of pine nuts, referred to as "pine mouth", have been reported by consumers in the United States and Europe. Nuts of Pinus armandii have been associated with pine mouth, and a diagnostic index (DI) measuring the content of Δ5-unsaturated fatty acids relative to that of their fatty acid precursors has been proposed for identifying nuts from this species. A 100 m SLB-IL 111 GC column was used to improve fatty acid separations, and 45 pine nut samples were analyzed, including pine mouth-associated samples. This study examined the use of a DI for the identification of mixtures of pine nut species and showed the limitation of morphological characteristics for species identification. DI values for many commercial samples did not match those of known reference species, indicating that the majority of pine nuts collected in the U.S. market, including those associated with pine mouth, are mixtures of nuts from different Pinus species.