Delmopinol hydrochloride inhibits Campylobacter jejuni on skinless poultry meat, stainless steel, and high-density polyethylene food contact surfaces.

Delmopinol hydrochloride (delmopinol) is a cationic surfactant that is effective for treating and preventing gingivitis and periodontitis. This study evaluated the effectiveness of delmopinol for reducing attachment of Campylobacter jejuni to chicken meat, stainless steel, and high-density polyethylene (HDPE). These test materials were spot-inoculated with a C. jejuni culture. After 10 min, samples were sprayed with 0.5% or 1.0% delmopinol, 0.01% sodium hypochlorite, or distilled water. After a 1, 10, or 20 min contact time, samples were rinsed, which were serially diluted onto Campy-Cefex Agar. For additional samples, solutions were applied before inoculation with C. jejuni. Cultures remained undisturbed for 1, 10, or 20 min. Samples were then rinsed and plated as above. When C. jejuni was inoculated before treatments, 1% delmopinol application led to mean log reductions of 1.26, 3.70, and 3.72 log cfu ml-1, greater than distilled water alone, for chicken, steel and HDPE, respectively. When C. jejuni was inoculated after spray treatments, 1% delmopinol reduced C. jejuni by 2.72, 3.20, and 3.99 mean log cfu ml-1 more than distilled water for chicken, steel and HDPE, respectively. Application of 1% delmopinol, resulted in a significantly (P < .05) greater log reduction than a 0.01% sodium hypochlorite or distilled water application.

Anaerobic soil disinfestation, amendment-type, and irrigation regimen influence Salmonella survival and die-off in agricultural soils.

AIMS: This study investigated Salmonella concentrations following combinations of horticultural practices including anaerobic soil disinfestation (ASD), soil amendment type and irrigation regimen. METHODS AND RESULTS: Sandy-loam soil was inoculated with a five-serovar Salmonella cocktail (5.5 ± 0.2 log CFU per gram) and subjected to one of six treatments: (i) no soil amendment, ASD (ASD control), (ii) no soil amendment, no-ASD (non-ASD control) and (iii-vi) soil amended with pelletized poultry litter, rye, rapeseed or hairy vetch with ASD. The effect of irrigation regimen was determined by collecting samples 3 and 7 days after irrigation. Twenty-five-gram soil samples were collected pre-ASD, post-soil saturation (i.e. ASD-process), and at 14 time-points post-ASD, and Salmonella levels enumerated. Log-linear models examined the effect of amendment type and irrigation regimen on Salmonella die-off during and post-ASD. During ASD, Salmonella concentrations significantly decreased in all treatments (range: -0.2 to -2.7 log CFU per gram), albeit the smallest decrease (-0.2 log CFU per gram observed in the pelletized poultry litter) was of negligible magnitude. Salmonella die-off rates varied by amendment with an average post-ASD rate of -0.05 log CFU per gram day (CI = -0.05, -0.04). Salmonella concentrations remained highest over the 42 days post-ASD in pelletized poultry litter, followed by rapeseed, and hairy vetch treatments. Findings suggested ASD was not able to eliminate Salmonella in soil, and certain soil amendments facilitated enhanced Salmonella survival. Salmonella serovar distribution differed by treatment with pelletized poultry litter supporting S. Newport survival, compared with other serovars. Irrigation appeared to assist Salmonella survival with concentrations being 0.14 log CFU per gram (CI = 0.05, 0.23) greater 3 days, compared with 7 days post-irrigation. CONCLUSIONS: ASD does not eliminate Salmonella in soil, and may in fact, depending on the soil amendment used, facilitate Salmonella survival. SIGNIFICANCE AND IMPACT OF THE STUDY: Synergistic and antagonistic effects on food safety hazards of implementing horticultural practices should be considered.

Modulation of innate immunity in Nile tilapia (Oreochromis niloticus) by dietary supplementation of Bacillus subtilis endospores.

Dietary supplementation of probiotics is growing as a scientifically valid alternative to antibiotics for enhancement of overall animal health and productivity in aquaculture. Strains of Bacillus subtilis are regarded as attractive probiotic candidates to the fish farming industry; however, there is a limited number of studies focused on the use of specific strains probiotics in tilapia, and therefore complicating replication. The objective of this study was to examine the effect of the strains NZ86 (NRRL B-50136) and O14VRQ (NRRL B-67221) of B. subtilis on various parameters of the innate immunity in Nile tilapia (Oreochromis niloticus) in a 51-day feeding trial. Supplementation of tilapia with either strain resulted in significant increases (p < 0.05) in plasma lysozyme concentration of varying degrees throughout the trial. Meanwhile, alternative complement activity was significantly elevated (p < 0.05) only after feeding of the NZ86 strain after 14 and 51 days. Conversely, supplementation with O14VRQ resulted in a significant increase (p < 0.05) in the percent of neutrophils in the peripheral blood of tilapia by day 28. At the end of the trial, there was a trend towards increased phagocytic and respiratory burst activities observed in immune organ derived leukocytes. Feeding with either probiotic appeared to have an up-regulation on the gene expression of both pro-inflammatory cytokines in the intestine, yet only O14VRQ was significantly different than the control. Moreover, the occurrence of these results could be associated with supplementation of the probiotic strains, given that Bacillus bacteria were observed to populate the intestines of the dietary treatment groups. These results suggest the potential roles of these B. subtilis probiotic candidates to stimulate immune responses both locally and systemically in tilapia.

Survival of Tomato Outbreak Associated Salmonella Serotypes in Soil and Water and the Role of Biofilms in Abiotic Surface Attachment.

Salmonella serotypes linked to tomato-associated outbreaks were evaluated for survival in soil and water over a 40-day period. Salmonella enterica serotypes Anatum, Baildon, Braenderup, Montevideo, Newport, and Javiana were inoculated separately into sterile soil and water, followed by plating onto TSAYE and XLT4 at 10-day intervals. Biofilm production by Salmonella serotypes was measured on both quartz particles (soil surrogate) and glass coverslips, and was evaluated using a crystal violet dye assay. Salmonella populations in soil and water over 40 days indicated no significant differences between Salmonella serotypes tested (p > 0.05). Over a 40-day period, there was a 1.84 ± 0.22 log CFU/g and 1.56 ± 0.54 CFU/mL decrease in populations of Salmonella in soil and water, respectively. Enumeration indicated that Salmonella population fluctuated in water but decreased linearly in soil. All serotypes tested produced the "red dry and rough" morphotype on Congo Red agar. Biofilm produced by all the Salmonella serotypes tested was significantly different on quartz particles than on glass coverslips (p < 0.0001), indicating that material and surface characteristics could affect biofilm development. The ability of Salmonella serotypes to persist in soil or water and attach to abiotic surfaces through biofilm formation affirms that contact surfaces, soil, water, and sediment should be considered as possible sources of cross-contamination in the farm environment.

Cetylpyridinium chloride direct spray treatments reduce Salmonella on cantaloupe rough surfaces.

Cetylpyridinium chloride (CPC) solutions (0, 0.5, or 1.0%) were applied to cantaloupe ("Athena" and "Hale's Best Jumbo" cultivars) rind plugs, either before or after inoculation with a broth culture of Salmonella Michigan (109 CFU/mL) and held at 37°C for 1 or 24 hr. Rind plugs were diluted, shaken, and sonicated, and solutions were enumerated. Texture quality and color were evaluated over 14 days storage at 4°C after 0 and 1% CPC spray applications. A 0.5 or 1.0% (vol/vol) application of CPC after Salmonella reduced the pathogen levels between 2.34 log CFU/mL and 5.16 log CFU/mL in comparison to the control (p < .01). No differences were observed in the firmness and color of 1% CPC treated cantaloupes. Salmonella concentrations on cantaloupes, treated with 1.0% CPC, were lower after 1 hr storage as compared to 24 hr. And, Salmonella on "Athena" surfaces were more susceptible to CPC spray treatments than on "Hale's Best Jumbo." PRACTICAL APPLICATIONS: Cetylpyridinium chloride (CPC) is the active ingredient of some antiseptic oral mouth rinses, and has a broad antimicrobial spectrum with a rapid bactericidal effect on gram-positive pathogens. The spray application of CPC solutions to cantaloupe may reduce the level of Salmonella surface contamination during production from irrigation water and manure fertilizers and, during food processing by contaminated equipment and food handlers. Since the surfaces of cantaloupes are highly rough or irregular, bacteria can easily attach to these surfaces and become difficult to remove. Appropriate postharvest washing and sanitizing procedures are needed that can help control Salmonella and other pathogens on melons, especially on cantaloupes with nested surfaces. A direct surface spray application of CPC may be an alternative antimicrobial postharvest treatment to reduce pathogen contamination of cantaloupe melons, while providing an alternative to chlorine-based solutions.

Association of Campylobacter spp. levels between chicken grow-out environmental samples and processed carcasses.

Campylobacter spp. have been isolated from live poultry, production environments, processing facilities, and raw poultry products. Environmental sampling in a poultry grow-out house, combined with carcass rinse sampling from the same flock, may provide a relative relationship between pre- and postharvest Campylobacter contamination. Air samples, fecal/litter samples, and feed/drink line samples were collected from 4 commercial chicken grow-out houses in western Virginia between September 2011 and January 2012. Birds from each sampled house were the first flock slaughtered the following day and were then sampled by postchill carcass rinses. Campylobacter, from postenrichment samples, was detected in 27% (32/120) of house environmental samples and 37.5% (45/120) of carcass rinse samples. All environmental sample types from each house included at least one positive sample except the house 2 air samples. The sponge sample method was found to have a significantly higher (P < 0.05) proportion of Campylobacter-positive samples (45%) than the fecal/litter samples (20%) and air samples (15%) when sample types of all the houses were compared. The proportion positive for the fecal/litter samples postenrichment, for each flock, had the highest correlation (0.85) to the proportion of positive carcass rinse samples for each flock. Environmental samples from house 1 and associated carcass rinses accounted for the largest number of Campylobacter positives (29/60). The fewest number of Campylobacter positives, based on both house environmental (4/30) and carcass rinse samples (8/30), was detected from flock B. The results of this study suggest that environmental sampling in a poultry grow-out house, combined with carcass rinse sampling from the same flock, have the potential to provide an indication of Campylobacter contamination and transmission. Campylobacter qualitative levels from house and processing plant samples may enable the scheduled processing of flocks with lower pathogen incidence or concentrations, as a way to reduce postslaughter pathogen transmission.

Survival of Inoculated Campylobacter jejuni and Escherichia coli O157:H7 on Kale During Refrigerated Storage.

Campylobacter and pathogenic Escherichia coliillnesses have been attributed to the consumption of fresh produce. The leafy green, kale, is increasingly consumed raw. In comparison to other leafy greens, kale has a longer shelf-life. Due to the extended shelf-life of kale, it is warranted to examine the survival of pathogenic Campylobacter jejuni and E. coli O157:H7 inoculated on the surface of kale stored in a controlled environment at 4 ± 1.4°C, and average humidity of 95 ± 1.9% over a 23-day period. At predetermined time points (days 0, 1, 2, 3, 5, 7, 9, 11, 13, 15, 17, 19, and 21), inoculated kale was destructively sampled and the surviving bacteria determined by serial dilution and plating onto Tryptic soy agar, Charcoal cefoperozone deoxycholate agar, and Eosin methylene blue for total aerobic bacteria, C. jejuni, and E. coli O157:H7, respectively. Enrichment and PCR were used for detection when pathogens were not detected using serial dilution and plating. Aerobic heterotrophic bacteria increased over the 23-day period, in contrast, significant declines in the inoculated pathogens were observed. Inoculated E. coli O157:H7 survived longer on kale (up to 19 d); in comparison, C. jejuni was undetectable by day 13 using enrichment and PCR or plating. In conclusion, C. jejuni and E. coli O157:H7 declined on fresh kale over time when held at refrigerated temperatures but were still detected during the majority of the time when the kale would likely still be considered edible by consumers.

Microbubbles Remove Listeria monocytogenes from the Surface of Stainless Steel, Cucumber, and Avocado.

Fresh produce may be contaminated by bacterial pathogens, including Listeria monocytogenes, during harvesting, packaging, or transporting. A low-intensity cavitation process with air being injected into water was studied to determine the microbubbles' efficiency when detaching L. monocytogenes from stainless steel and the surface of fresh cucumber and avocado. Stainless steel coupons (1″ × 2″), cucumber, and avocado surfaces were inoculated with L. monocytogenes (LCDC strain). After 1, 24 or 48 h, loosely attached cells were washed off, and inoculated areas were targeted by microbubbles (~0.1-0.5 mm dia.) through a bubble diffuser (1.0 L air/min) for 1, 2, 5, or 10 min. For steel, L. monocytogenes (48 h drying) detachment peaked at 2.95 mean log reduction after 10 min of microbubbles when compared to a no-bubble treatment. After 48 h pathogen drying, cucumbers treated for 10 min showed a 1.78 mean log reduction of L. monocytogenes. For avocados, L. monocytogenes (24 h drying) detachment peaked at 1.65 log reduction after 10 min of microbubbles. Microbubble applications may be an effective, economical, and environmentally friendly way to remove L. monocytogenes, and possibly other bacterial pathogens, from food contact surfaces and the surfaces of whole, intact fresh produce.

Influence of drying time on prewetted disinfectant towelettes to disinfect glass surfaces.

The use of prewetted disinfectant towelettes in health care settings proves challenging because they may dry quickly, reducing disinfection. This study examined the drying time of various commercial disinfectant towelettes and the efficacy of these towelettes over time to eliminate Staphylococcus aureus from glass surfaces. This study confirms that these disinfectants dry quickly. Further disinfection after drying time on glass is minimal, but dependent on the type of disinfectant.

Dose of UV light required to inactivate Listeria monocytogenes in distilled water, fresh brine, and spent brine.

The purpose of this research was to establish the dose of UV light (253.7 nm) needed to inactivate Listeria monocytogenes in distilled water, fresh brine (9% NaCl), spent brine, and diluted (5, 35, and 55%) spent brine, using uridine as a chemical actinometer. Strains N1-227 (isolated from hot dog batter), N3-031 (isolated from turkey franks), and R2-499 (isolated from meat) were mixed in equal proportions and suspended in each solution prepared so as to contain 10(-4) M uridine. Samples were irradiated in sterile quartz cells for 0, 5, 10, 15, 20, 25, or 30 min. Inactivation was evaluated by serially diluting samples in 0.1% peptone, by surface plating in duplicate onto modified Oxford agar and Trypticase soy agar with yeast extract, and by enrichment in brain heart infusion broth, followed by incubation at 37 degrees C for 24 to 48 h. For dose measurements, the absorbance (262 nm) was measured before and after irradiation. Differences were observed in population estimates depending on the solution (P < or = 0.05). Reductions were as follows from greatest to least: water > fresh brine > 5% spent brine > 35% spent brine > 55% spent brine > undiluted spent brine. UV light did not significantly reduce populations suspended in spent brine solutions. L. monocytogenes decreased to below the detection limit (1 log CFU/ml) at doses greater than 33.2 mJ/cm(2) in water and at doses greater than 10.3 mJ/cm(2) in fresh brine. Knowledge of UV dosing required to control L. monocytogenes in brines similar to those used for ready-to-eat meat processing will aid manufacturers in establishing appropriate food safety interventions for these products.

Effect of acid stress, antibiotic resistance, and heat shock on the resistance of Listeria monocytogenes to UV light when suspended in distilled water and fresh brine.

Exposure to sublethal processing treatments can stimulate bacterial stress responses. The purpose of this research was to determine whether adaptation to common food processing stresses encountered during the preparation of ready-to-eat foods affects the dose of UV light required to significantly reduce Listeria monocytogenes populations in sterile distilled water and a 9% NaCl solution, using uridine as a chemical actinometer. L. monocytogenes strains N1-227 (from hot dog batter), N3-031 (from turkey franks), and R2-499 (from ready-to-eat meat) were acid stressed for 3 h at 35 degrees C in Trypticase soy broth with yeast extract acidified to pH 5.0, heat shocked for 1 h at 48 degrees C in brain heart infusion broth (BHIB), and selected for sulfanilamide resistance (512 microg/ml). These strains were then mixed in equal proportions and suspended in water and 9% NaCl solution, each containing 10(-4) M uridine. Samples were exposed to UV light (253.7 nm) for 0, 5, 10, 15, 20, 25, or 30 min. Inactivation was evaluated by surface plating onto modified Oxford agar and Trypticase soy agar with yeast extract and by enrichment in BHIB followed by incubation at 37 degrees C for 24 h. The absorbance of each sample was measured before and after irradiation to calculate the dose of UV light. There were no significant differences between population estimates based on medium or suspension solution. There were no population differences between acid-stressed and antibiotic-resistant or unstressed and heat-shocked L. monocytogenes strains. However, acid-stressed and antibiotic-resistant strains were significantly more resistant to UV light than were unstressed and heat-shocked strains (P < or = 0.05).

Evaluation of disinfectants and wiping substrates combinations to inactivate Staphylococcus aureus on Formica coupons.

Effective disinfection in healthcare facilities prevents healthcare-associated infections. This study evaluated the ability of Environmental Protection Agency-approved disinfectants (quaternary ammonium compound, QAC; sodium hypochlorite, and hydrogen peroxide) applied with 3 wiping substrates (microfiber, nonwoven, and cotton) to remove Staphylococcus aureus from Formica surfaces. All treatments reduced S aureus on Formica squares with the exception of QAC applied with cotton and QAC, nondisinfectant, and control applied with a nonwoven cloth. Sodium hypochlorite or hydrogen peroxide applied with cotton or microfiber, respectively, may be the best choice for disinfection of Formica surfaces in healthcare settings.

High pressures in combination with antimicrobials to reduce Escherichia coli O157:H7 and Salmonella Agona in apple juice and orange juice.

The effect of high pressure processing in conjunction with the chemical antimicrobials, dimethyl dicarbonate (DMDC), hydrogen peroxide, cinnamic acid, potassium sorbate, and sodium benzoate (NaB) on E. coli O157:H7 strain E009 and Salmonella enterica serovar Agona was investigated in apple juice and orange juice, respectively. Juices were inoculated with approximately 10(6) CFU/ml and subjected to pressures of 550 MPa (E. coli O157:H7 samples) and 400 MPa (Salmonella Agona samples) for 2 min at 6 degrees C (initial temperature). Populations of each pathogen were determined before pressurization, immediately after pressurization, and after samples had been held after treatment for 24 h at 4 degrees C. The most effective treatment for E. coli O157:H7, as determined by plating immediately after pressurization, was 125 ppm of DMDC, which caused a >4.98-log reduction. Other treatments that were significantly different from the sample with no added antimicrobial were 62.5 ppm of DMDC, 300 ppm of hydrogen peroxide, and 500 ppm of NaB, which produced 4.97-, 5.79-, and 3.91-log total reductions, respectively. After 24 h at 4 degrees C, E. coli O157:H7 was undetectable in all treatment groups (and controls). In samples inoculated with Salmonella, the most effective treatment was 62.5 ppm of DMDC, which produced a 5.96-log decrease immediately after pressure treatment. The results for 1,000 ppm of NaB, which produced a 3.26-log decrease, also were significantly different from those for the sample containing no antimicrobials. After 24 h at 4 degrees C, all samples with added antimicrobials had near or more than a 5-log total reduction of Salmonella Agona.

Delmopinol hydrochloride reduces Salmonella on cantaloupe surfaces.

Since the surfaces of cantaloupes are highly rough or irregular, bacteria can easily attach and become difficult to remove. Appropriate postharvest washing and sanitizing procedures can help control Salmonella and other pathogens on cantaloupe or other melons during postharvest operations. Delmopinol hydrochloride (delmopinol) is a cationic surfactant that is effective for treating and preventing gingivitis and periodontitis. The application of delmopinol to two cantaloupe cultivars was evaluated for reducing the level of inoculated Salmonella. Athena and Hale's Best Jumbo (HBJ) cantaloupe rind plugs (2.5 cm. dia.) were inoculated with nalidixic acid-resistant Salmonella Michigan (approx. 1.0 × 109 CFU/ml). After 15 min, rind plugs were sprayed with 10 ml of a delmopinol spray solution (0% or 1.0% vol/vol) and held at 35°C for 1 hr or 24 hr. Rind plugs were diluted with Butterfield's phosphate buffer, shaken and sonicated, and solutions were enumerated on 50 ppm nalidixic acid-tryptic soy agar. The texture quality and color of additional cantaloupes were evaluated, after 1% delmopinol spray treatment, over 14-day storage at 4°C. A 1.0% application of delmopinol after 1 hr reduced Salmonella concentration by ~3.1 log CFU/ml for both "HBJ" skin rind plugs and "Athena" stem scar rind plugs in comparison to the control (p < .05). No differences were observed in the texture and color (L*, a*, b* values) of 1% delmopinol-treated cantaloupes as compared to control. Storage of cantaloupes treated with 1.0% delmopinol solution for 1 hr had a greater effect on reducing concentration of Salmonella compared to 24-hr treatment. A surface spray application of 1% delmopinol on cantaloupes could be an alternative antimicrobial postharvest treatment that could make surface bacteria more susceptible to sanitizers or physical removal.

Incidence of Listeria spp. in Ready-to-Eat Food Processing Plant Environments Regulated by the U.S. Food Safety and Inspection Service and the U.S. Food and Drug Administration.

A multiyear survey of 31 ready-to-eat (RTE) food processing plants in the United States was conducted to determine the incidence of Listeria spp. in various RTE production environments. Samples were collected from 22 RTE plants regulated by the U.S. Department of Agriculture's Food Safety and Inspection Service (FSIS) and from 9 RTE food plants regulated by the U.S. Department of Health and Human Services' Food and Drug Administration (FDA). Only nonfood contact surfaces in the RTE manufacturing areas with exposed RTE product were sampled. Each sample was individually analyzed for the presence of Listeria spp. by using a PCR-based rapid assay. In total, 4,829 samples were collected from various locations, including freezers, equipment framework, floors, walls, wall-floor junctures, drains, floor mats, doors, and cleaning tools. Nine (29%) of the facilities had zero samples positive for Listeria spp. in the production environment, whereas 22 (71%) had one or more samples positive for Listeria spp. The total incidence of Listeria spp. in all RTE food plants was 4.5%. The positive rate in plants regulated by the FSIS ranged from 0 to 9.7%, whereas the positive rate in plants regulated by the FDA ranged from 1.2 to 36%.

High-pressure resistance variation of Escherichia coli O157:H7 strains and Salmonella serovars in tryptic soy broth, distilled water, and fruit juice.

The effect of high pressure on the log reduction of six strains of Escherichia coli O157:H7 and five serovars of Salmonella enterica was investigated in tryptic soy broth, sterile distilled water, and commercially sterile orange juice (for Salmonella) and apple cider (for E. coli). Samples were subjected to high-pressure processing treatment at 300 and 550 MPa for 2 min at 6 degrees C. Samples were plated onto tryptic soy agar directly after pressurization and after being held for 24 h at 4 degrees C. At 300 MPa, little effect was seen on E. coli O157:H7 strains, while Salmonella serovars varied in resistance, showing reductions between 0.26 and 3.95 log CFU/ml. At 550 MPa, E. coli O157:H7 strains exhibited a range of reductions (0.28 to 4.39 log CFU/ml), while most Salmonella populations decreased beyond the detection limit (> 5-log CFU/ml reduction). The most resistant strains tested were E. coli E009 and Salmonella Agona. Generally, bacterial populations in fruit juices showed larger decreases than did populations in tryptic soy broth and distilled water. E. coli O157:H7 cultures held for 24 h at 4 degrees C after treatment at 550 MPa showed a significant log decrease as compared with cultures directly after treatment (P < or = 0.05), while Salmonella serovars did not show this significant decrease (P > 0.05). All Salmonella serovars tested in orange juice treated at 550 MPa for 2 min at 6 degrees C and held for 24 h showed a > 5-log decrease, while E. coli O157:H7 strains require a higher pressure, higher temperature, longer pressurization, or a chemical additive to achieve a 5-log decrease.

Effects of modified atmosphere packaging on toxin production by Clostridium botulinum in raw aquacultured summer flounder fillets (Paralichthys dentatus).

Packaging fishery products under vacuum atmosphere packaging (VAC) and modified atmosphere packaging (MAP) conditions can significantly extend the shelf life of raw, refrigerated fish products. There is considerable commercial interest in marketing VAC and MAP refrigerated (never frozen) raw fish fillets. The objective of this study was to determine if Clostridium botulinum toxin development precedes microbiological spoilage in raw, refrigerated flounder fillets. Aquacultured flounder (Paralichthys dentatus) individual fish fillets either were packed with a film having an oxygen transmission rate (OTR) of 3000 cm3 m(-2) 24 h(-1) at 22.8 degrees C or were vacuum packaged or packaged under 100% CO2 with a film having an OTR of 7.8 cm3 m(-2) 24 h(-1) at 21.1 degrees C and were stored at 4 and 10 degrees C. Samples were analyzed by aerobic plate count (APC) for spoilage and qualitatively for botulinum toxin with a mouse bioassay. The results demonstrate that flounder fillets (4 degrees C) packaged with a film having an OTR of 3,000 were microbiologically spoiled (APC, > 10(7) CFU/g) on day 15, but there was no toxin formation, even after 35 days of storage. However, at 10 degrees C, toxin production occurred (day 8), but it was after microbial spoilage and absolute sensory rejection (day 5). Vacuum-packaged fillets and 100% CO2 fillets (4 degrees C) packaged with a film having an OTR of 7.8 were toxic on days 20 and 25, respectively, with microbial spoilage (APC, >10(7) CFU/g) not occurring during the tested storage period (i.e., >35 days). At 10 degrees C, in vacuum-packaged flounder, toxin formation coincided with microbiological spoilage (days 8 to 9). In the 100% CO2-packaged fillets, toxin formation occurred on day 9, with microbial spoilage occurring on day 15. This study indicates that films with an OTR of 3,000 can be used for refrigerated fish fillets and still maintain the safety of the product.

Evaluation of quantitative recovery methods for Listeria monocytogenes applied to stainless steel.

The ability of Listeria monocytogenes to attach to various food contact surfaces, such as stainless steel, polypropylene, and rubber compounds, is well documented. The retention of these or other pathogenic bacteria on food contact surfaces increases the risk of transmission to food products. The objective of this study was to compare several methods for quantitative recovery of Listeria monocytogenes from stainless steel surfaces. A cocktail of 4 serotypes of Listeria monocytogenes mixed in equivalent concentrations was inoculated onto type 304 stainless steel coupons in a 2 x 2 cm area. After 1 h exposure, coupons were sampled by one of the following methods: (1) swabbing with a premoistened Dacron swab; (2) rinsing with phosphate-buffered saline; (3) direct contact onto tryptic soy agar containing 0.6% yeast extract (TSA + YE) plates for 10 s; (4) sonication in an ultrasonic water bath (40 kHz); (5) contact with the bristles of a sonicating brush head for 1 min; and (6) indirect contact (2-4 mm distance) with a sonicating brush head for 1 min. The 3 sonication methods yielded higher recovery than the other 3 methods (P < 0.05). Brushing the coupons with the sonicating brush head (contact or noncontact) yielded a recovery level of about 60%. The lowest cell recovery (about 20%) was observed with the swab and direct agar contact methods. After a 12 h exposure, recoveries ranged from 17.4 (brush contact method) to 2% (swab method).

Quantitative recovery of Listeria monocytogenes and select salmonella serotypes from environmental sample media.

Environmental sampling has become increasingly important in the food industry for monitoring the presence of specific pathogens such as Listeria monocytogenes and Salmonella enterica. Several microbiological media are available for storage and transport of environmental samples from the processing plant to the test laboratory. In this study, we quantified the survival of L. monocytogenes, S. Typhimurium, S. Enteritidis, and S. Typhi in environmental sampling media over several time and temperature combinations to determine optimum conditions for transport and storage. A cocktail of L. monocytogenes strains and Salmonella serotypes was separately added to tubes of Dey-Engley (D/E) Neutralizing Broth, Copan SRK solution, and Neutralizing Buffer and incubated at either -4, 4, 10, or 15 degree C. Counts were made of the bacterial load after 0, 12, 24, and 48 h. Neutralizing Buffer and Copan SRK solution were best at maintaining bacterial concentrations at all temperatures. D/E Neutralizing Broth, at 10 and 15 degrees C, allowed significant bacterial growth. This study helped validate the use of these 3 media for environmental sample transport and storage at cold holding temperatures and demonstrated that, at elevated temperatures (>4 degrees C), it is preferable to use Neutralizing Buffer or Copan SRK solution for quantifying microbial recovery.