Establishment of an equine tetanus antitoxin reference standard for veterinary use in Japan.

To establish the first National Veterinary Assay Laboratory (NVAL) equine tetanus antitoxin reference standard for veterinary use, we manufactured vials of a candidate antitoxin. These were quality tested for moisture content, vacuum, colour, clarity, and the presence of foreign objects. Ultimately, 115 quality-controlled vials were prepared. To estimate the antitoxin potency of the candidate standard, three different laboratories conducted parallel line assays alongside the existing antitoxin standard. These potency estimates ranged from 38 to 42 IU. This activity was maintained for two years after manufacture, as compared with a fresh vial. No statistically significant non-linearity or non-parallelism of the regression lines was observed (p > 0.05). Statistical assessment of inter- and intra-laboratory variability revealed acceptable coefficients of variation of 3.2% and 2.4-3.1%, respectively. Based on these results, the potency of the potential reference standard was calculated at 40 units of antitoxin activity per 1-mL vial. Vials of this preparation were distributed for use as the first equine tetanus antitoxin reference standard for veterinary use in September 2015.

A comparison of the antibody responses between specific pathogen-free and commercial layers immunized with an influenza vaccine prepared from inactivated non-pathogenic H5N1 virus by single shot.

It is known that antibody responses in chickens against invading organisms or antigens are considerably different among different lines. Thus, an avian influenza vaccine was prepared from inactivated whole particles of the virus of non-pathogenic strain A/duck/Hokkaido/Vac-1/04 (H5N1) using an oil adjuvant containing anhydromannitol-octadecenoate-ether and injected intramuscularly into each ten 10-week-old specific pathogen-free (SPF) white leghorn chickens and commercial layers of Julia and Boris-Brown to obtain comparative data for antibody responses until 6 weeks after vaccination. Despite significant partial differences of antibody titer between the chicken lines, this study clearly showed that the vaccine induced good and sufficient antibody response in both SPF chickens and commercial layers.

Safety test and field study of an inactivated oil-adjuvanted H5N1 avian influenza vaccine.

We previously reported the development of an inactivated oil-adjuvanted avian influenza vaccine using an apathogenic H5N1 strain of the same lineage as the Eurasian lineage viruses currently epidemic in Asia. In this study, we confirmed the safety and evaluated the efficacy of this vaccine in layer chicken farms by field trials. No problematic adverse reactions occurred in the safety test. In addition, no adverse effects were observed in the field trial, and the antibody titer exceeded a protective level (hemagglutination inhibition (HI) antibody titer of 16) at 3 weeks after a single injection. Based on the above findings, this vaccine was confirmed to be safe and induced a protective level of antibody titer with a single injection in the chickens at the farms.

Evaluation of the potency, optimal antigen level and lasting immunity of inactivated avian influenza vaccine prepared from H5N1 virus.

Test vaccines comprised of inactivated water-in-oil emulsions containing various antigen levels were prepared using a non-pathogenic H5N1 avian influenza (AI) virus, Alduck/Hokkaidol Vac-1/04 (H5N1). The potencies of these test vaccines were evaluated by two experiments. In the first experiment, the triangular relationship among the antigen levels of test vaccines, the hemagglutination inhibition (HI) antibody response, and the protective effect against challenge with a highly pathogenic avian influenza (HPAI) virus, A/chicken/Yamaguchi/7/04 (H5N1), was confirmed. Then lasting immunity of chickens after a single-shot vaccination was confirmed in the second experiment. As a result, complete protection after the challenge was observed in chickens immunized by test vaccines with an antigen level of 160 HA units/dose or higher. Thus, it was ascertained that the minimum antigen level in the AI vaccine was 160 HA units/dose, and the minimum HI antibody titer that could protect chickens from HPAI virus infection-related death was considered to be 1:16. Dose-dependent HI antibody responses were observed in chickens after the vaccination. Thus, 640 HA units/dose was thought to be similar to the optimal antigen level. Alternatively, the HI antibody titers of chickens, injected with the vaccine containing 640 HA units/dose, were maintained at 1:181 or higher for 100 weeks after the single-shot vaccination.

Method for estimation of toxic endotoxin in inactivated salmonella vaccine in D-galactosamine-sensitized mice.

We developed a method to estimate the content of the toxic endotoxin in inactivated Salmonella vaccine in D-galactosamine-sensitized mice. Ten-fold serially diluted vaccines were injected intraperitoneally into D-galactosamine-sensitized mice. Lethality in the mice was judged 3 days after the injection. The best result was obtained when C3H/HeN mice were used for the test. Correlation was observed between the endotoxin content measured by Limulus amoebocyte lysate assay and the LD50 in the mouse safety test (r=0.81). These results suggested that this test could be applied to the estimation of endotoxin content in inactivated vaccines of Salmonella.

Detection of highly pathogenic avian influenza virus infection in vaccinated chicken flocks by monitoring antibodies against non-structural protein 1 (NS1).

H5 and H7 highly pathogenic avian influenza virus (HPAIV) represent a major global concern in poultries and human health. Avian influenza (AI) vaccines are available but not preferred for field applications, primarily because vaccination interferes with sero-surveillances of AIV infection. To overcome the problem, ELISA systems using non-structural protein 1 (NS1) of AIV as antigens (NS1-ELISA) have been developed to measure anti-NS1 antibodies that are raised in AIV-infected but not in vaccinated chickens. However, some AI-vaccinated chickens having a weak anti-virus immune response may subsequently be infected with AIV and spread the virus. This raises a concern for the validity of NS1-ELISA to detect AIV infection in previously vaccinated chickens. In this study, we developed NS1-ELISA and assessed its feasibility to detect HPAIV infection in chickens previously immunized with H5 or H7 AI vaccines. The results indicated that the NS1-ELISA could identify HPAIV infection in both unvaccinated and vaccinated chickens at 1 week after infection in correlation with results from time-consuming virus isolation tests. Taken together, the NS1-ELISA system would be valuable tool to define HPAIV infection when AI vaccine program is in place.

Potency of an inactivated avian influenza vaccine prepared from a non-pathogenic H5N1 reassortant virus generated between isolates from migratory ducks in Asia.

A reassortant influenza virus, A/duck/Hokkaido/Vac-1/2004 (H5N1) (Dk/Vac-1/04), was generated between non-pathogenic avian influenza viruses isolated from migratory ducks in Asia. Dk/Vac-1/04 (H5N1) virus particles propagated in embryonated chicken eggs were inactivated with formalin and adjuvanted with mineral oil to form a water-in-oil emulsion. The resulting vaccine was injected intramuscularly into chickens. The chickens were challenged with either of the highly pathogenic avian influenza virus strains A/chicken/Yamaguchi/7/2004 (H5N1) or A/swan/Mongolia/3/2005 (H5N1) at 21 days post-vaccination (p. v.), when the geometric mean serum HI titers of the birds was 64 with the challenge virus strains. The vaccinated chickens were protected from manifestation of disease signs upon challenge with either of the highly pathogenic avian influenza viruses. However, challenge virus was recovered at low titers from the birds at 2 and 4 days post-challenge (p.c.). All 3 chickens challenged at 6 days p.v. died, whereas 3 chickens challenged at 8 days p.v. survived. These results indicate that the present vaccine confers clinical protection and reduction of virus shedding against highly pathogenic avian influenza virus challenge and should be useful as an optional tool in emergency cases.

A vaccine prepared from a non-pathogenic H7N7 virus isolated from natural reservoir conferred protective immunity against the challenge with lethal dose of highly pathogenic avian influenza virus in chickens.

During 2001-2004, 41 H7 influenza viruses (2 H7N1 and 39 H7N7 strains) were isolated from fecal samples of migratory ducks that flew from Siberia in the autumn of each year to Japan and Mongolia. A phylogenetic analysis of the hemagglutinin (HA) genes of the nine representative isolates revealed that they belonged to the Eurasian lineage and the deduced amino acid sequence at the cleavage site of the HAs represented apathogenic profiles. One of the H7 isolates A/duck/Mongolia/736/02 (H7N7) was chosen from these H7 isolates for the preparation of the test vaccine. To improve the growth potential of A/duck/Mongolia/736/02 (H7N7) in chicken embryos, A/duck/Hokkaido/Vac-2/04 (H7N7) was generated by genetic reassortment between A/duck/Mongolia/736/02 (H7N7) as the donor of the PB2, PB1, PA, HA, NA, and NS genes and A/duck/Hokkaido/49/98 (H9N2) as that of NP and M genes. The test vaccine was prepared as follows; A/duck/Hokkaido/Vac-2/04 (H7N7) was propagated in chicken embryos and the virus in the allantoic fluid was inactivated and adjuvanted to form an oil-in-water emulsion. The test vaccine conferred immunity to chickens, completely protecting the manifestation of clinical signs against the challenge with lethal dose of H7 highly pathogenic avian influenza virus. These results indicate that influenza viruses isolated from natural reservoirs are useful for vaccine strains.