Inducer-free recombinant protein production in Trichoderma reesei: secretory production of endogenous enzymes and heterologous nanobodies using glucose as the sole carbon source.

BACKGROUND: The filamentous fungus Trichoderma reesei has been used as a host organism for the production of lignocellulosic biomass-degrading enzymes. Although this microorganism has high potential for protein production, it has not yet been widely used for heterologous recombinant protein production. Transcriptional induction of the cellulase genes is essential for high-level protein production in T. reesei; however, glucose represses this transcriptional induction. Therefore, cellulose is commonly used as a carbon source for providing its degraded sugars such as cellobiose, which act as inducers to activate the strong promoters of the major cellulase (cellobiohydrolase 1 and 2 (cbh1 and cbh2) genes. However, replacement of cbh1 and/or cbh2 with a gene encoding the protein of interest (POI) for high productivity and occupancy of recombinant proteins remarkably impairs the ability to release soluble inducers from cellulose, consequently reducing the production of POI. To overcome this challenge, we first used an inducer-free biomass-degrading enzyme expression system, previously developed to produce cellulases and hemicellulases using glucose as the sole carbon source, for recombinant protein production using T. reesei. RESULTS: We chose endogenous secretory enzymes and heterologous camelid small antibodies (nanobody) as model proteins. By using the inducer-free strain as a parent, replacement of cbh1 with genes encoding two intrinsic enzymes (aspartic protease and glucoamylase) and three different nanobodies (1ZVH, caplacizumab, and ozoralizumab) resulted in their high secretory productions using glucose medium without inducers such as cellulose. Based on signal sequences (carrier polypeptides) and protease inhibitors, additional replacement of cbh2 with the nanobody gene increased the percentage of POI to about 20% of total secreted proteins in T. reesei. This allowed the production of caplacizumab, a bivalent nanobody, to be increased to 9.49-fold (508 mg/L) compared to the initial inducer-free strain. CONCLUSIONS: In general, whereas the replacement of major cellulase genes leads to extreme decrease in the degradation capacity of cellulose, our inducer-free system enabled it and achieved high secretory production of POI with increased occupancy in glucose medium. This system would be a novel platform for heterologous recombinant protein production in T. reesei.

Use of FDG-PET to detect a chronic odontogenic infection as a possible source of the brain abscess.

This study describes the use of (18)F-fluoro-2-deoxyglucose positron emission tomography (FDG-PET) to detect a chronic odontogenic infection as the possible origin of a brain abscess (BA). A 74-year-old man with esophageal carcinoma was referred to our department to determine the origin of a BA in his oral cavity. He had no acute odontogenic infections. The BA was drained, and bacteria of the Staphylococcus milleri group were detected. Whole body FDG-PET revealed that the only sites of definite uptake of FDG were the esophageal carcinoma and the left upper maxillary region (SUVmax: 4.5). These findings suggested that the BA may have originated from a chronic periodontal infection. Six teeth with progressive chronic periodontal disease were extracted to remove the possible source of BA. These findings excluded the possibility of direct spread of bacteria from the odontogenic infectious lesion to the intracranial cavity. After extraction, there was no relapse of BA.

Anti-BP180-type mucous membrane pemphigoid: report of two cases.

We describe two patients with anti-BP180-type mucous membrane pemphigoid (MMP), who were correctly diagnosed and treated in early stages through the cooperation of dentists and dermatologists. Patient 1 was a 74-year-old woman who visited our dental department due to blisters over the oral mucosa and eruptions on the skin. She had also experienced bleeding of the gingiva and palate mucosa. Biopsy specimens from the oral mucosa revealed detachment of epithelial basement membrane and subepithelial lamina propria with slight chronic inflammation. Direct immunofluorescence (DIF) revealed linear IgG and IgA deposits along the basement membrane zone (BMZ). Indirect immunofluorescence (IIF) using 1 M-NaCl split normal human skin showed binding of IgG and IgA on the epidermal side. On immunoblot analysis, IgG and IgA autoantibodies reacted with the C-terminal protein of BP180. These findings indicated a diagnosis of anti-BP180-type MMP. Patient 2 was a 59-year-old woman who was referred to our dental department with a history of blisters and large erosions on the gingiva. Biopsy specimens from the oral mucosa revealed partial junctional separation at the level of the basement membrane. DIF showed linear depositions of IgG and C3 along the BMZ. IIF, using 1 M-NaCl split normal human skin, revealed circulating anti-BMZ-IgG antibodies bound to the epidermal side. These findings indicated a diagnosis of anti-BP180-type MMP. Both patients were treated successfully with systemic or topical steroids and oral health care. In conclusion, appropriate clinical examination and cooperation among medical specialists are important for the early diagnosis and treatment of patients with recurrent and chronic stomatitis and for their good prognosis.

Isolation and characterization of a thermotolerant ene reductase from Geobacillus sp. 30 and its heterologous expression in Rhodococcus opacus.

Rhodococcus opacus B-4 cells are adhesive to and even dispersible in water-immiscible hydrocarbons owing to their highly lipophilic nature. In this study, we focused on the high operational stability of thermophilic enzymes and applied them to a biocatalytic conversion in an organic reaction medium using R. opacus B-4 as a lipophilic capsule of enzymes to deliver them into the organic medium. A novel thermo- and organic-solvent-tolerant ene reductase, which can catalyze the enantioselective reduction of ketoisophorone to (6R)-levodione, was isolated from Geobacillus sp. 30, and the gene encoding the enzyme was heterologously expressed in R. opacus B-4. Another thermophilic enzyme which catalyzes NAD(+)-dependent dehydrogenation of cyclohexanol was identified from the gene-expression library of Thermus thermophilus and the gene was coexpressed in R. opacus B-4 for cofactor regeneration. While the recombinant cells were not viable in the mixture due to high reaction temperature, 634 mM of (6R)-levodione could be produced with an enantiopurity of 89.2 % ee by directly mixing the wet cells of the recombinant R. opacus with a mixture of ketoisophorone and cyclohexanol at 50 °C. The conversion rate observed with the heat-killed recombinant cells was considerably higher than that obtained with a cell-free enzyme solution, demonstrating that the accessibility between the substrates and enzymes could be improved by employing R. opacus cells as a lipophilic enzyme capsule. These results imply that a combination of thermophilic enzymes and lipophilic cells can be a promising approach for the biocatalytic production of water-insoluble chemicals.

Near-infrared spectroscopic study on the effects of chewing on short-term memory.

Using near-infrared spectroscopy, we examined whether chewing gum improves performance in a short-term memory task - immediate recall of random eight-digit numbers - by assessing cerebral hemodynamic response in the prefrontal cortex. We found that the oxyhemoglobin concentration during and after chewing gum was higher than that before chewing; further, the concentration increased during the task, and this increase was reduced with chewing, although non-significantly. Chewing did not improve task performance. Therefore, chewing-induced hemodynamic responses were unrelated to the performance in short-term memory tasks.

G-CSF producing oral carcinoma with diffuse uptake of FDG in the bone marrow: A case report.

A 78-year-old male patient was referred to the Department of Oral Surgery, Hokuto Hospital (Obihiro, Japan) for painless swelling on the left neck and tongue. Histopathological examination of a biopsy specimen resulted in a diagnosis of squamous cell carcinoma of the tongue. Imaging examinations revealed cervical lymph node metastases on both sides, along with diffuse uptake of 18F-fluorodeoxyglucose (FDG) in the bone marrow of the spine and pelvis. Hematologic tests revealed an increased white blood cell (WBC) count and serum concentrations of granulocyte colony stimulating factor (G-CSF). These findings suggested a G-CSF producing tumor, with fluctuations of WBC count, serum G-CSF concentration, and FDG uptake in the bone marrow, associated with tumor shrinkage and enlargement, an indicator of tumor status.

Autoantibody Profile Differentiates between Inflammatory and Noninflammatory Bullous Pemphigoid.

Bullous pemphigoid (BP) is a major autoimmune blistering skin disorder, in which a majority of the autoantibodies (autoAbs) target the juxtamembranous extracellular noncollagenous 16A domain (NC16A) domain of hemidesmosomal collagen XVII. BP-autoAbs may target regions of collagen XVII other than the NC16A domain; however, correlations between epitopes of BP-autoAbs and clinical features have not been fully elucidated. To address correlations between the clinical features and specific epitopes of BP-autoAbs, we evaluated the epitope profiles of BP-autoAbs in 121 patients. A total of 87 patients showed a typical inflammatory phenotype with erythema and autoAbs targeting the anti-NC16A domain, whereas 14 patients showed a distinct noninflammatory phenotype, in which autoAbs specifically targeted the midportion of collagen XVII, but not NC16A. Interestingly, this group clinically showed significantly reduced erythema associated with scant lesional infiltration of eosinophils. Surprisingly, 7 of the 14 cases (50.0%) received dipeptidyl peptidase-IV inhibitors for the treatment of diabetes. Dipeptidyl peptidase-IV inhibitors were used in 3 of 76 (3.9%) typical cases of BP with autoAbs targeting NC16A; thus, dipeptidyl peptidase-IV inhibitors are thought to be involved in the development of atypical noninflammatory BP. This study shows that the autoAb profile differentiates between inflammatory and noninflammatory BP, and that noninflammatory BP may be associated with dipeptidyl peptidase-IV inhibitors.

Epitope-Dependent Pathogenicity of Antibodies Targeting a Major Bullous Pemphigoid Autoantigen Collagen XVII/BP180.

In bullous pemphigoid, the common autoimmune blistering disorder, IgG autoantibodies target various epitopes on hemidesmosomal transmembrane collagen XVII (COL17)/BP180. Antibodies (Abs) targeting the extracellular noncollagenous 16th A domain of COL17 may be pathogenic; however, the pathogenic roles of Abs targeting non-noncollagenous 16th A regions are poorly understood. In this study using a pathogenic and a nonpathogenic monoclonal antibody (mAb) targeting the noncollagenous 16th A domain (mAb TS39-3) and the C-terminus domain (mAb C17-C1), respectively, we show that endocytosis of immune complexes after binding of Abs to cell surface COL17 is a key phenomenon that induces skin fragility. Passive transfer of IgG1 mouse mAb TS39-3 but not mAb C17-C1 induces dermal-epidermal separation in neonatal human COL17-expressing transgenic mice. Interestingly, mAb C17-C1 strongly binds with the dermal-epidermal junction of the recipient mice skin, suggesting that binding of Abs with COL17 is insufficient to induce skin fragility. In cultured normal human epidermal keratinocytes treated with these mAbs, mAb TS39-3 but not mAb C17-C1 internalizes immune complexes after binding with cell surface COL17 via macropinocytosis, resulting in reduced COL17 expression. This study shows that pathogenicity of Abs targeting COL17 is epitope dependent, which is associated with macropinocytosis-mediated endocytosis of immune complexes and finally results in the depletion of COL17 expression in basal keratinocytes.

Differences in sequential posttreatment salivary IL-6 levels between patients with and patients without locoregional recurrences of oral squamous cell carcinoma: Part III of a cohort study.

OBJECTIVE: Sequential postoperative salivary interleukin-6 (IL-6) concentrations were examined in patients with oral squamous cell carcinoma (OSCC) who had early or late locoregional recurrences or those who did not. STUDY DESIGN: Twenty-seven consecutive patients with OSCC were originally included in the study. All patients underwent radical surgery. Four saliva samples were collected before (periods I and II) and after (periods III and IV) surgery, and IL-6 concentrations were measured. RESULTS: Although postoperative (period III: at the time of discharge) salivary IL-6 level was significantly higher in patients with early locoregional recurrence (P = .02) than in those without, no such relationships were observed for preoperative IL-6 concentrations (periods I and II). Postoperative (period IV: 24 months after surgery) IL-6 level was significantly higher in patients with late locoregional recurrence (P = .03) than in those without, but no such relationships were observed for IL-6 concentrations in periods I, II, and III. CONCLUSIONS: Sequential postoperative salivary IL-6 concentration may be a useful marker for diagnosis of early and late locoregional recurrence in OSCC.

Drug interaction between gefitinib and warfarin.

Gefitinib is a synthetic, oral anilinoquinazoline specifically designed to inhibit the epidermal growth factor receptor tyrosine kinase, and is the first targeted drug to demonstrate reproducible activity in non-small cell lung cancer patients who do not respond to platinum-based chemotherapy. In this report, we present two cases of an interaction between gefitinib and warfarin which has not been reported previously. Because of the potentially serious consequences of this interaction, close monitoring of the International Normalized Ratio and warfarin dosage adjustment are recommended for patients receiving warfarin together with gefitinib.