RESUMO
To enhance the dissolution and oral bioavailability of telmisartan (TMS), a poorly water-soluble anti-hypertensive drug, a supersaturable self-microemulsifying drug delivery system (SuSMEDDS) was developed. Amorphous alkalinized TMS (AAT) was formulated into a SMEDDS, composed of Capmul® MCM (oil), Cremophor® RH40 (surfactant), and tetraglycol (co-surfactant). Although the SMEDDS was rapidly dissolved (>80% within 5 min) in a limited condition (500 mL, pH 6.8), drug precipitation was observed over time, resulting in a decrease in dissolution levels. The precipitation was due to drug recrystallization, as determined by differential scanning calorimetry and powder X-ray diffraction analyses. Several polymers, including Soluplus® (SOL), were screened as precipitation inhibitors; ultimately, SuSMEDDS-SOL was prepared by admixing SOL and the SMEDDS at a 5:100 (w/w) ratio. SuSMEDDS-SOL was superior in terms of dissolution efficiency (>90% over 2 h) and dissolution-retaining time (no precipitation over 2 h). An in vivo pharmacokinetic study in rats revealed that the oral bioavailability of SuSMEDDS-SOL was 4.8-, 1.3-, and 1.2-fold greater than those of the TMS suspension, AAT solution, and SMEDDS, respectively. Therefore, SuSMEDDS-SOL is a promising candidate to enhance the dissolution and oral bioavailability of TMS.
Assuntos
Anti-Hipertensivos/sangue , Anti-Hipertensivos/síntese química , Sistemas de Liberação de Medicamentos/métodos , Emulsificantes/sangue , Emulsificantes/síntese química , Telmisartan/sangue , Telmisartan/síntese química , Administração Oral , Animais , Anti-Hipertensivos/administração & dosagem , Disponibilidade Biológica , Emulsificantes/administração & dosagem , Masculino , Ratos , Ratos Sprague-Dawley , Solubilidade , Telmisartan/administração & dosagemRESUMO
Valsartan (VST) is a poorly water-soluble drug and a P-glycoprotein (P-gp) substrate. To enhance the dissolution and oral absorption of VST, a novel supersaturable self-microemulsifying drug delivery system (Su-SMEDDS) was formulated. Based on the previously reported Su-SMEDDS composed of Capmul® MCM (oil), Tween® 20 (T20; surfactant), Transcutol® P (cosurfactant), and Poloxamer 407 (supersaturating agent), P-gp inhibitory surfactants including Tween® 80 (T80) and Cremophor® EL (CR) were newly introduced to replace T20. All Su-SMEDDS formulations had a droplet size of <200 nm and showed rapid (>90% within 5 min) and pH-independent dissolution characteristics. The effective permeability coefficient (Peff) in rat jejunum was obtained using an in situ single-pass intestinal perfusion study: Peff values of Su-SMEDDS-T20, Su-SMEDDS-T80, and Su-SMEDDS-CR were 2.3, 4.1, and 3.4 times greater, respectively, than that of the VST solution. After oral administration of various formulations to rats (equivalent dose of VST 10 mg/kg), plasma drug levels were measured by liquid chromatography-tandem mass spectrometry. The relative bioavailabilities of Su-SMEDDS-T20, Su-SMEDDS-T80, and Su-SMEDDS-CR were 262%, 470%, and 458%, respectively, compared with the VST suspension. Thus, we propose that the Su-SMEDDS-T80 formulation is a good candidate for improving the oral absorption of poorly water-soluble and P-gp substrate drugs such as VST.
Assuntos
Membro 1 da Subfamília B de Cassetes de Ligação de ATP/antagonistas & inibidores , Valsartana/química , Administração Oral , Animais , Disponibilidade Biológica , Química Farmacêutica/métodos , Sistemas de Liberação de Medicamentos/métodos , Emulsões/química , Masculino , Tamanho da Partícula , Ratos , Ratos Sprague-Dawley , Solubilidade/efeitos dos fármacos , Tensoativos/química , Valsartana/farmacologiaRESUMO
To overcome the poor dissolution of telmisartan (TMS) at weak acidic pH, amorphous alkalinized TMS (AAT) was prepared by introducing sodium hydroxide as a selective alkalizer. AAT-containing polymeric solid dispersions were prepared by a solvent evaporation method; these solid dispersions were AAT-PEG, AAT-PVP, AAT-POL, and AAT-SOL for the polymers of PEG 6000, PVP K30, Poloxamer 407, and Soluplus, respectively. The characteristics of the different formulations were observed by differential scanning calorimetry, powder X-ray diffraction, Fourier transform infrared spectroscopy, and scanning electron microscopy. To compare the supersaturation behavior, a dissolution test was performed at 37 ± 0.5 °C either in 900 ml (plain condition) or 500 ml (limited condition) of pH 6.8-simulated intestinal fluid used as a medium. AAT-SOL exhibited enhanced dissolution, indicating the probability of extended supersaturation in the limited condition. AAT-SOL was further formulated into a tablet by introducing other excipients, Vivapur 105 and Croscarmellose, as a binder and superdisintegrant, respectively, using a direct compression method. The selected AAT-SOL tablet was superior to Micardis (the reference product) in the aspect of supersaturation maintenance during dissolution in the limited condition, suggesting that it is a promising candidate for practical development that can replace the commercial product in the future.
Assuntos
Antiácidos/química , Composição de Medicamentos/métodos , Telmisartan/química , Antiácidos/metabolismo , Anti-Hipertensivos/química , Anti-Hipertensivos/metabolismo , Varredura Diferencial de Calorimetria/métodos , Excipientes/química , Excipientes/metabolismo , Microscopia Eletrônica de Varredura/métodos , Polímeros/química , Polímeros/metabolismo , Solventes/química , Solventes/metabolismo , Espectroscopia de Infravermelho com Transformada de Fourier/métodos , Comprimidos , Telmisartan/metabolismo , Difração de Raios X/métodosRESUMO
Pelubiprofen (PEL), which is a commercialized non-steroidal anti-inflammatory drug (NSAID), is associated with the risk of gastrointestinal (GI) adverse events following long-term exposure and has poor water-soluble properties. Here, a new pelubiprofen tromethamine (PEL-T) with improved solubility, permeability, GI safety, and absorption, compared to PEL, has been developed. The nuclear magnetic resonance spectroscopy (NMR), differential scanning calorimetry (DSC), and Fourier transform infrared spectroscopy (FT-IR) results confirmed that the PEL-T was well formed. The powder of PEL-T showed the presence of additional 6H protons at δ 3.66-3.61 in the 1H NMR spectrum, and shifted the sharp endothermic peaks at 129 °C in DSC, and the spectrum of distinct absorption peaks in FT-IR. In addition, compared with PEL, PEL-T showed a significantly improved solubility in various media and an increased permeability coefficient (Kp) in Caco-2 cells. Furthermore, compared to PEL oral administration, PEL-T was found to significantly reduce the damaged area in an acute gastric damage rat model. The pharmacokinetic study of the PEL-T powder showed higher maximum plasma concentration (Cmax) and area under the plasma concentration-time curve from 0 h to the last time point (AUCt) than those of the PEL powder. Taken together, our data suggest that PEL-T is a recommendable candidate with enhanced gastrointestinal safety and better absorption compared with commercial PEL.
RESUMO
A novel solid self-dispersing micelle (S-SDM) was developed to enhance the oral bioavailability of valsartan (VST) and to reduce the total mass of solidified supersaturable self-microemulsifying drug delivery system (S-SuSMEDDS), composed of Capmul MCM, Tween 80 (T80), Gelucire 44/14 (G44), Poloxamer 407, Florite PS-10 (FLO), and low-substituted hydroxypropyl cellulose B1 (HPC). Excluding oil component from S-SuSMEDDS, S-SDM was optimized using a Box-Behnken design with three independent variables: X1 (T80/G44, 0.63), X2 (FLO/HPC, 0.41), and X3 (solid carrier, 177.6 mg); and three response factors: Y1 (droplet size, 191.9 nm), Y2 (dissolution efficiency at 15 min, 55.0%), and Y3 (angle of repose, 32.4°). The desirability function was 0.636, showing an excellent agreement between the predicted and experimental values. With approximately 75% weight of S-SuSMEDDS, no distinct crystallinity of VST was observed in S-SDM, resulting in critical micelle concentration value of 32 µg/mL. Optimized S-SDM showed an approximate 4-fold improved dissolution (pH 1.2, 500 mL) compared with raw VST. Following oral administration in rats, optimized S-SDM improved relative bioavailability by approximately 235%, 216%, and 127% versus raw VST, Diovan® (commercial reference), and S-SuSMEDDS, respectively. Thus, optimized S-SDM could be a selectable candidate for developing water-insoluble drugs in reduced quantity.
Assuntos
Anti-Hipertensivos/sangue , Anti-Hipertensivos/síntese química , Desenho de Fármacos , Micelas , Valsartana/sangue , Valsartana/síntese química , Administração Oral , Animais , Anti-Hipertensivos/administração & dosagem , Disponibilidade Biológica , Química Farmacêutica/métodos , Masculino , Ratos , Ratos Sprague-Dawley , Solubilidade , Valsartana/administração & dosagemRESUMO
To improve the dissolution and oral bioavailability of valsartan (VST), we previously formulated a supersaturable self-microemulsifying drug delivery system (SuSMED) composed of Capmul® MCM (oil), Tween® 80 (surfactant), Transcutol® P (cosurfactant), and Poloxamer 407 (precipitation inhibitor) but encountered a stability problem (Transcutol® P-induced weight loss in storage) after solidification. In the present study, replacing Transcutol® P with Gelucire® 44/14 resulted in a novel SuSMED formulation, wherein the total amount of surfactant/cosurfactant was less than that of the previous formulation. Solidified SuSMED (S-SuSMED) granules were prepared by blending VST-containing SuSMED with selective solid carriers, L-HPC and Florite® PS-10, wherein VST existed in an amorphous state. S-SuSMED tablets fabricated by direct compression with additional excipients were sufficiently stable in terms of drug content and impurity changes after 6 months of storage at accelerated conditions (40 ± 2 °C and 75 ± 5% relative humidity). Consequently, enhanced dissolution was obtained (pH 1.2, 2 h): 6-fold for S-SuSMED granules against raw VST; 2.3-fold for S-SuSMED tablets against Diovan® (reference tablet). S-SuSMED tablets increased oral bioavailability in rats (10 mg/kg VST dose): approximately 177â»198% versus raw VST and Diovan®. Therefore, VST-loaded S-SuSMED formulations might be good candidates for practical development in the pharmaceutical industry.
RESUMO
To improve the dissolution behavior of telmisartan (TMS), a poorly water-soluble angiotensin II receptor blocker, TMS-phospholipid complex (TPC) was prepared by solvent evaporation method and characterized by differential scanning calorimetry and powder X-ray diffractometry. The crystalline structure of TMS was transited into an amorphous state by TPC formation. The equilibrium solubility of TPC (1.3-6.1 mg/mL) in various vehicles was about 100 times higher than that of TMS (0.009-0.058 mg/mL). TPC-loaded self-microemulsifying drug delivery system (SMEDDS) formulation was optimized using the D-optimal mixture design with the composition of 14% Capryol 90 (oil; X1), 59.9% tween 80 (surfactant; X2), and 26.1% tetraglycol (cosurfactant; X3) as independent variables, which resulted in a droplet size of 22.17 nm (Y1), TMS solubilization of 4.06 mg/mL (Y2), and 99.4% drug release in 15 min (Y3) as response factors. The desirability function value was 0.854, indicating the reliability and accuracy of optimization; in addition, good agreement was found between the model prediction and experimental values of Y1, Y2, and Y3. Dissolution of raw TMS was poor and pH-dependent, where it had extremely low dissolution (< 1% for 2 h) in water, pH 4, and pH 6.8 media; however, it showed fast and high dissolution (> 90% in 5 min) in pH 1.2 medium. In contrast, the dissolution of the optimized TPC-loaded SMEDDS was pH-independent and reached over 90% within 5 min in all the media tested. Thus, we suggested that phospholipid complex formation and SMEDDS formulation using the experimental design method might be a promising approach to enhance the dissolution of poorly soluble drugs.
Assuntos
Sistemas de Liberação de Medicamentos/métodos , Emulsões/química , Fosfolipídeos/química , Telmisartan/química , Varredura Diferencial de Calorimetria , Concentração de Íons de HidrogênioRESUMO
A novel, supersaturable self-microemulsifying drug delivery system (S-SMEDDS) was successfully formulated to enhance the dissolution and oral absorption of valsartan (VST), a poorly water-soluble drug, while reducing the total quantity for administration. Poloxamer 407 is a selectable, supersaturating agent for VST-containing SMEDDS composed of 10% Capmul® MCM, 45% Tween® 20, and 45% Transcutol® P. The amounts of SMEDDS and Poloxamer 407 were chosen as formulation variables for a 3-level factorial design. Further optimization was established by weighting different levels of importance on response variables for dissolution and total quantity, resulting in an optimal S-SMEDDS in large quantity (S-SMEDDS_LQ; 352 mg in total) and S-SMEDDS in reduced quantity (S-SMEDDS_RQ; 144.6 mg in total). Good agreement was observed between predicted and experimental values for response variables. Consequently, compared with VST powder or suspension and SMEDDS, both S-SMEDDS_LQ and S-SMEDDS_RQ showed excellent in vitro dissolution and in vivo oral bioavailability in rats. The magnitude of dissolution and absorption-enhancing capacities using quantity-based comparisons was in the order S-SMEDDS_RQ > S-SMEDDS_LQ > SMEDDS > VST powder or suspension. Thus, we concluded that, in terms of developing an effective SMEDDS preparation with minimal total quantity, S-SMEDDS_RQ is a promising candidate.
Assuntos
Emulsões/administração & dosagem , Valsartana/farmacocinética , Administração Oral , Animais , Disponibilidade Biológica , Caprilatos/química , Sistemas de Liberação de Medicamentos/métodos , Emulsões/química , Emulsões/farmacocinética , Etilenoglicóis/química , Glicerídeos/química , Masculino , Polímeros , Polissorbatos/química , Ratos Sprague-Dawley , Solubilidade , Valsartana/administração & dosagemRESUMO
In order to improve the dissolution and oral bioavailability of valsartan (VST), and reduce the required volume for treatment, we previously formulated a supersaturable self-microemulsifying drug delivery system (SuSMEDDS) composed of VST (80 mg), Capmul® MCM (13.2 mg), Tween® 80 (59.2 mg), Transcutol® P (59.2 mg), and Poloxamer 407 (13.2 mg). In the present study, by using Florite® PS-10 (119.1 mg) and Vivapur® 105 (105.6 mg) as solid carriers, VST-loaded solidified SuSMEDDS (S-SuSMEDDS) granules were successfully developed, which possessed good flow properties and rapid drug dissolution. By introducing croscarmellose sodium (31 mg) as a superdisintegrant, S-SuSMEDDS tablets were also successfully formulated, which showed fast disintegration and high dissolution efficiency. Preparation of granules and tablets was successfully optimized using D-optimal mixture design and 3-level factorial design, respectively, resulting in percentage prediction errors of <10%. In pharmacokinetic studies in rats, the relative bioavailability of the optimized granules was 107% and 222% of values obtained for SuSMEDDS and Diovan® powder, respectively. Therefore, we conclude that novel S-SuSMEDDS formulations offer great potential for developing solid dosage forms of a liquefied formulation such as SuSMEDDS, while improving oral absorption of drugs with poor water solubility.
RESUMO
To improve the dissolution and oral bioavailability (BA) of atorvastatin calcium (ATV), we previously introduced an optimized self-microemulsifying drug delivery system (SMEDDS) using Capmul(®) MCM (oil), Tween(®) 20 (surfactant), and tetraglycol (cosurfactant). In this study, various solid carriers were employed to develop a solidified SMEDDS (S-SMEDDS): mannitol (M) and lactose (L) as water-soluble carriers, and Sylysia(®) 350 (S) and Aerosil(®) 200 (A) as water-insoluble carriers. Maximum solidifying capacities (SCmax) of water-insoluble carriers were significantly greater than those of water-soluble carriers were. The resultant powders were free flowing with an angle of repose <40° and Carr's index 5-20%, regardless of the solid carrier types. S-SMEDDS with mannitol (S(M)-SMEDDS) or lactose (S(L)-SMEDDS) had a smaller droplet size and greater dissolution than S-SMEDDS with Sylysia(®) 350 (S(S)-SMEDDS) or Aerosil(®) 200 (S(A)-SMEDDS). Following oral administration of various formulations to rats at a dose equivalent to 25mg/kg of ATV, plasma drug levels were measured by LC-MS/MS. The relative BAs (RBAs) of SMEDDS, S(M)-SMEDDS, and S(S)-SMEDDS were 345%, 216%, and 160%, respectively, compared to that of ATV suspension. Additionally, at a reduced dose of ATV equivalent to 5mg/kg, the RBAs of S(M)-SMEDDS and S(S)-SMEDDS compared to that of SMEDDS were 101% and 65%, respectively. These results suggest that S(M)-SEMDDS offers great potential for the development of solid dosage forms with improved oral absorption of drugs with poor water solubility.
Assuntos
Anticolesterolemiantes/administração & dosagem , Atorvastatina/administração & dosagem , Sistemas de Liberação de Medicamentos , Administração Oral , Animais , Anticolesterolemiantes/química , Anticolesterolemiantes/farmacocinética , Atorvastatina/química , Atorvastatina/farmacocinética , Disponibilidade Biológica , Química Farmacêutica/métodos , Cromatografia Líquida , Relação Dose-Resposta a Droga , Portadores de Fármacos/química , Emulsões , Excipientes/química , Masculino , Tamanho da Partícula , Ratos , Ratos Sprague-Dawley , Solubilidade , Tensoativos/química , Espectrometria de Massas em TandemRESUMO
To develop a matrix-type, controlled-release tablet formulation of pelubiprofen (PLB), a recently developed non-steroidal anti-inflammatory drug, polymeric excipients including hypromellose, hydroxypropylcellulose, Eudragit(®) RS PO, and Kollidon(®) SR were screened. A formulation containing 12.4% w/w Kollidon(®) SR (K2 tablet) was found to be the most promising and stable for 6 months in an accelerated stability test. PLB release from K2 tablet was limited at pH 1.2, but gradually increased at pH 6.8 with a surface-erosion, resulting in the best fit to Hixson-Crowell equation. Comparative human PK studies were performed using a randomized, 2-way crossover design. LC-MS/MS assay revealed that the plasma level of PLB-transOH, an active metabolite, was significantly higher than that of PLB. After multiple dosing of immediate-release tablet (R) and K2 tablet (T), the T/R ratios of AUC were 1.02 and 1.04 for PLB and PLB-transOH, respectively. Level A in vitro-in vivo correlation was established for the K2 tablet-administered group. PK profile of PLB-transOH was not influenced by food intake, while that of PLB was altered. We suggest that K2 tablet could be administered twice a day without being affected by food intake, thereby enhancing patient compliance.
Assuntos
Fenilpropionatos/farmacocinética , Adulto , Preparações de Ação Retardada/química , Preparações de Ação Retardada/farmacocinética , Liberação Controlada de Fármacos , Estabilidade de Medicamentos , Ingestão de Alimentos , Excipientes/química , Excipientes/farmacocinética , Humanos , Fenilpropionatos/sangue , Fenilpropionatos/química , Solubilidade , Comprimidos/química , Comprimidos/farmacocinética , Adulto JovemRESUMO
In order to characterize the in situ intestinal permeability and in vivo oral bioavailability of celecoxib (CXB), a poorly water-soluble cyclooxygenase (COX)-2 inhibitor, various formulations including the self-emulsifying drug delivery system (SEDDS) and supersaturating SEDDS (S-SEDDS) were compared. The S-SEDDS formulation was obtained by adding Soluplus as a precipitation inhibitor to SEDDS, composed of Capryol 90 as oil, Tween 20 as surfactant, and Tetraglycol as cosurfactant (1:4.5:4.5 in volume ratio). An in situ single pass intestinal perfusion study in rats was performed with CXB-dissolved solutions at a concentration of 40 µg/mL. The effective permeability (Peff) of CXB in the control solution (2.5 v/v% Tween 20-containing PBS) was 6.39 × 10(-5) cm/s. The Peff value was significantly increased (P < 0.05) by the lipid-based formulation, yielding 1.5- and 2.9-fold increases for the SEDDS and S-SEDDS solutions, respectively, compared to the control solution. After oral administration of various formulations to rats at the equivalent dose of 100 mg/kg of CXB, the plasma drug level was measured by LC-MS/MS. The relative bioavailabilities of SEDDS and S-SEDDS were 263 and 355 %, respectively, compared to the CXB suspension as a reference. In particular, S-SEDDS revealed the highest Cmax and the smallest Tmax, indicating rapid and enhanced absorption with this formulation. This study illustrates the potential use of the S-SEDDS formulation in the oral delivery of poorly water-soluble compounds.