[Analysis of Free Pantothenic Acid in Foods by HPLC and LC-MS/MS].

A simple and reliable analytical method has been developed for the determination of pantothenic acid in food. For the high-protein food, 20 mL of water was added to 2 g of sample, and after homogenization extraction, 1 mL of 15% zinc sulfate solution was added, mixed well, centrifuged, and the supernatant was filtered to make the test solution. For the low-protein food, 20 mL of 1% formic acid solution was added to 2 g of sample, homogenized, extracted, centrifuged, and the supernatant was filtered to make the test solution. The HPLC separation was carried out on a L-column2 ODS column with 0.02 mol/L phosphate solution (pH 3.0)- acetonitrile (95 : 5) as the mobile phase, and detected at 200 nm. The LC-MS/MS conditions were L-column2 ODS as the separation column, 5 mmol/L ammonium formate (containing 0.01% formic acid)-methanol (85 : 15) as the mobile phase, and multiple reaction monitoring (MRM) was used for detection. The recoveries of pantothenic acid in milk powder and nutritional food products were more than 88% with high precision. As a result of analyzing commetrcially available foods labeled as containing pantothenic acid, analytical values almost identical to the labeled values were obtained, and a high correlation was observed between the values obtained by HPLC and LC-MS/MS.

[Suitability of Culture Broth and Conditions for Escherichia coli Growth and Gas Production as a Test for Food Additives in EC Broth].

The growth and gas production test for Escherichia coli in the microbiological examination of food additives is stipulated in the ninth edition of Japan's Specifications and Standards for Food Additives (JSFA) and described as a part of the "Confirmation Test for Escherichia coli" in "Microbial Limit Tests" in the same manuscript. The growth and gas production test for E. coli indicated that the positive or negative of "gas production and/or turbidity" in EC broth should be confirmed after incubating at 45.5±0.2℃ for 24±2 h. If both gas production and turbidity are negative, the culture is additionally incubated up to 48±2 h to determine E. coli contamination. The internationally referenced Bacteriological Analytical Manual of the U.S. FDA had revised the incubation temperature in tests for coliforms and E. coli from 45.5±0.2℃ to 44.5±0.2℃ in 2017. Therefore, we conducted research in anticipation of this temperature change being reflected in the microbiological examination of the JSFA. We used seven EC broth products and six food additives across eight products that are available in Japan in order to compare the growth and gas production at temperatures of 45.5±0.2℃ and 44.5±0.2℃ of E. coli NBRC 3972, which is designated as the test strain in JSFA. Both with/without food additives, the number of EC broth products in which medium turbidity and gas production by the strain were positive in three out of three tubes at all test times was greater at 44.5±0.2℃ than at 45.5±0.2℃. These results suggest that the growth and gas production test for E. coli could be more appropriately conducted by incubation at 44.5±0.2℃ in the "Confirmation Test for Escherichia coli" for E. coli in the JSFA in comparison to 45.5±0.2℃. Furthermore, there were differences in the growth and gas production of E. coli NBRC 3972 depending on the EC broth product used. Therefore, the importance of "Media growth promotion test" and "Method suitability test" in the ninth edition of the JSFA should be emphasized.

[Validation of Method for Nitrite Determination in Foods].

In general, nitrite in food is extracted under slightly alkaline conditions, deproteinized, and analyzed by a colorimetric method using color development by diazotization. However, depending on the sample, the sample solution may become cloudy and difficult to filter by the deproteinization treatment of the analytical method. Recently, an improved analytical method that solves these problems has been reported. Therefore, a validation study was performed on the improved analytical method was performed. The concentrations of sodium nitrite added to cod roe, fish sausage, and ham, which were not labeled with sodium nitrite, were set at the upper limits of the standards for use. We set the target values of 70-120% for trueness, less than 15% for intralaboratory reproducibility, and less than intralaboratory reproducibility for repeatability. As a result, the target values were met for the three samples verified: 88-92% for trueness, 2.0-3.0% for repeatability, and 3.2-4.3% for intralaboratory reproducibility. In addition, an interlaboratory study was conducted by eight institutes on the improved analytical method for nitrite. At each institution, sodium nitrite was added to the same three samples as in the validation study, at concentrations equivalent to twice the lower limit of quantification and the upper limit of the standards for use and analyzed in triplicate. The estimated trueness from the obtained analyses ranged from 82 to 95%, the repeatability ranged from 2.3 to 5.8%, and the inter-room reproducibility ranged from 3.5 to 11%. Thus, the improved analytical method could be useful for determining nitrite in foods.

[Method Verification for Vitamin D Analysis in Processed Foods Based on the Analytical Manual for the Standard Tables of Food Composition in Japan 2015 (Seventh Revised Edition)].

Considerable amounts of processed foods contain vitamin D (ergocalciferol (D2) and cholecalciferol (D3)) as food additives. For field surveys on food additives, the analytical method for vitamin D should be well-validated. However, the current official method in Japan cannot separately determine the concentrations of D2 and D3, whereas the method for the Standard Tables of Food Composition in Japan 2015 (STFC method) can. Therefore, in this study, we verified the applicability of the STFC method to processed foods. During the course of this research, we added some improvements to the original method. Spike and recovery experiments using vegetable juice, soymilk, and corn flakes as food matrices showed that the recovery rates (relative standard deviation) of D2 and D3 were 103-112% (4.7-12.6%) and 102-109% (2.4-21.8%), respectively, at the estimated method limit of quantification (EMLOQ) level; and 100-110% (4.0-7.4%) and 102-105% (3.8-4.8%), respectively, at 10 times the EMLOQ level. These results indicated that accuracy and precision of the modified STFC method were enough to determine dietary D2 and D3 as endogenous nutrients and/or food additives, and suggested that this method is appropriate for analyzing vitamin D concentrations in processed foods.

Identification of Characteristic Phenolic Constituents in Mousouchiku Extract Used as Food Additives.

Mousouchiku extract is prepared from the bamboo-sheath of Phyllostachys heterocycla MITF. (Poaceae), and is registered as a food manufacturing agent in the List of Existing Food Additives in Japan. This study describes the chromatographic evaluation of characteristic components of this extract to obtain the chemical data needed for standardized specifications. We isolated 12 known compounds from this extract: 5-hydroxymethyl-2-furfural, 4-hydroxybenzoic acid, trans-p-coumaric acid, trans-ferulic acid, N,N'-diferuloylputrescine, 4'-hydroxypropiophenone, ß-arbutin, tachioside, isotachioside, 3,4'-dihydroxypropiophenone 3-O-glucoside, koaburaside, and (+)-lyoniresinol 9'-O-glucoside. Moreover, a new propiophenone glycoside, propiophenone 4'-O-(6-ß-D-xylosyl)-ß-D-glucoside (propiophenone 4'-O-primeveroside), was isolated. The structure of each isolated compound was elucidated based on NMR and MS data or direct HPLC comparisons with authentic samples. Among the isolates, (+)-lyoniresinol 9'-O-glucoside was found to be the major ingredients of the extract as observed using HPLC analysis. However, 2,6-dimethoxy-1,4-benzoquinone, which is considered the main constituent of mousouchiku extract, was only detected as a trace constituent and not isolated in this study.

An IC-MS/MS Method for the Determination of 1-Hydroxyethylidene-1,1-diphosphonic Acid on Uncooked Foods Treated with Peracetic Acid-Based Sanitizers.

A rapid, sensitive, and specific analytical method for the determination of 1-hydroxyethylidene-1,1-diphosphonic acid (HEDP) on uncooked foods after treatment with a peracetic acid-based sanitizer (PAS) was developed. The method involves simple sample preparation steps and analysis using ion chromatography (IC) coupled with tandem mass spectrometry (MS/MS). The quantification limits of HEDP on uncooked foods are 0.007 mg/kg for vegetables and fruits and 0.2 mg/kg for meats. The recovery and relative standard deviation (RSD) of HEDP analyses of uncooked foods ranged from 73.9 to 103.8% and 1.9 to 12.6%, respectively. The method's accuracy and precision were evaluated by inter-day recovery tests. The recovery for all samples ranged from 93.6 to 101.2%, and the within-laboratory repeatability and reproducibility were evaluated based on RSD values, which were less than 6.9 and 11.5%, respectively. Analyses of PAS-treated fruits and vegetables using the developed method indicated levels of HEDP ranging from 0.008 to 0.351 mg/kg. Therefore, the results of the present study suggest that the proposed method is an accurate, precise, and reliable way to determine residual HEDP levels on PAS-treated uncooked foods.

Chromatographic Evaluation and Characterization of Components of Gentian Root Extract Used as Food Additives.

Gentian root extract is used as a bitter food additive in Japan. We investigated the constituents of this extract to acquire the chemical data needed for standardized specifications. Fourteen known compounds were isolated in addition to a mixture of gentisin and isogentisin: anofinic acid, 2-methoxyanofinic acid, furan-2-carboxylic acid, 5-hydroxymethyl-2-furfural, 2,3-dihydroxybenzoic acid, isovitexin, gentiopicroside, loganic acid, sweroside, vanillic acid, gentisin 7-O-primeveroside, isogentisin 3-O-primeveroside, 6'-O-glucosylgentiopicroside, and swertiajaposide D. Moreover, a new compound, loganic acid 7-(2'-hydroxy-3'-O-ß-D-glucopyranosyl)benzoate (1), was also isolated. HPLC was used to analyze gentiopicroside and amarogentin, defined as the main constituents of gentian root extract in the List of Existing Food Additives in Japan.

Evaluation of gardenia yellow using crocetin from alkaline hydrolysis based on ultra high performance liquid chromatography and high-speed countercurrent chromatography.

Gardenia yellow is globally the most valuable spice and food color. It is generally a mixture of water-soluble carotenoid glycosyl esters which consist of crocetin bis(gentiobiosyl) ester as the main component. Crocetin is a natural carotenoid dicarboxylic acid that may be a candidate drug for pharmaceutical development, however, it is either present in trace amounts or is absent in natural gardenia yellow products. We here propose that crocetin produced by alkaline hydrolysis can be used to qualitatively evaluate gardenia yellow products using an ultra high performance liquid chromatographic assay. A useful and efficient isolation technique for isolating high-purity crocetin from gardenia yellow using high-speed countercurrent chromatography is described. High-speed countercurrent chromatographic fractionation followed by an ultra high performance liquid chromatographic assay showed that trans-crocetin is easily converted to about 15% cis-crocetin (85% trans-crocetin). Crocetin in gardenia yellow was quantitatively evaluated. Our approach is based on the hydrolysis process for converting crocetin glycosyl esters to crocetin before evaluation and isolation using the ultra high performance liquid chromatographic and high-speed countercurrent chromatographic methods. The combination of hydrolysis and chromatographic methods allows evaluation of the purity and quantity of crocetin in gardenia yellow.

Absolute quantitation of stevioside and rebaudioside A in commercial standards by quantitative NMR.

The extract prepared from the leaves of Stevia rebaudiana BERTONI (Asteraceae) contains sweet steviol glycosides, mainly stevioside and rebaudioside A. Highly purified stevia extracts have become popular worldwide as a natural, low-calorie sweetener. They contain various types of steviol glycosides, and their main components are stevioside and rebaudioside A. The content of each steviol glycoside is quantified by comparing the ratios of the molecular weights and the chromatographic peak areas of the samples to those of stevioside or rebaudioside A standards of the Food and Agriculture Organization of the United Nations (FAO)/World Health Organization (WHO) Joint Expert Committee on Food Additives (JECFA) and other specifications. However, various commercial standard reagents of stevioside and rebaudioside A are available. Their purities are different and their exact purities are not indicated. Therefore, the measured values of stevioside and rebaudioside A contained in a sample vary according to the standard used for the quantification. In this study, we utilized an accurate method, quantitative NMR (qNMR), for determining the contents of stevioside and rebaudioside A in standards, with traceability to the International System of Units (SI units). The purities of several commercial standards were determined to confirm their actual values.

Estimation of daily intake of food additives by Japanese young children using the market basket method in 2018.

To estimate the daily intake of food additives by young children aged 1-6 years in Japan, an intake survey was conducted in 2018 using the market basket method for food additives, including twelve types of colourants, three kinds of preservatives, three kinds of sweeteners and two kinds of food manufacturing agents. A list of the daily consumption of processed foods was prepared based on a special survey (MHLW 2011) and used for the estimation. The results of the survey showed that the food additives with the highest daily intake were phosphorus compounds (phosphoric acid and its salts; 11.2 mg/kg bw/day, expressed as phosphorus), followed by propylene glycol (0.80 mg/kg bw/day). The daily intake of other food additives ranged from 0 to 0.20 mg/kg bw/day. The estimated daily intake of each food additives by young children was compared with the acceptable daily intake (ADI) or maximum tolerable daily intake (MTDI). The highest ratio of the estimated daily intake to ADI was 3.2% for propylene glycol, whereas the ratios of the estimated daily intake to ADI for colourants, preservatives and sweeteners ranged from 0 to 1.1% (benzoic acid). The ratio of the estimated daily intake to MTDI for phosphorus compounds was 16%.

Isolation and identification of a novel aromatic amine mutagen produced by the Maillard reaction.

To clarify the formation of mutagens in the Maillard reaction of glucose and amino acids, 20 amino acids were separately incubated with glucose in the presence or absence of hydroxyl radicals produced by the Fenton reaction. After 1 week at 37 degrees C and pH 7.4, the reaction mixtures of glucose and tryptophan with and without the Fenton reagent showed mutagenicity toward Salmonella typhimurium YG1024 in the presence of a mammalian metabolic system (S9 mix). To identify mutagens in the reaction mixture, blue rayon-adsorbed material from a mixture of glucose, tryptophan, and the Fenton reagent was separated by column chromatography using various solid and mobile phases, and one mutagen, which accounted for 18% of the total mutagenicity of the reaction mixture, was isolated. The chemical structure of the mutagen was determined to be 5-amino-6-hydroxy-8H-benzo[6,7]azepino[5,4,3-de]quinolin-7-one (ABAQ) on the basis of ESI mass, high-resolution APCI mass, (1)H NMR, (13)C NMR, and IR spectral analyses and chemical synthesis of the mutagen. The novel aromatic amine showed high mutagenicity toward S. typhimurium TA98 and YG1024 with S9 mix, inducing 857 revertants of TA98 and 6007 revertants of YG1024/microg, respectively. The mutagenicity of ABAQ was comparable to that of 2-amino-1-methyl-6-phenylimidazo[4,5-b]pyridine, which is a mutagenic and carcinogenic hetrocyclic amine in cooked meat and fish formed through the Maillard reaction at high temperature.

Relative molar sensitivities of carnosol and carnosic acid with respect to diphenylamine allow accurate quantification of antioxidants in rosemary extract.

We have been developing a high-performance liquid chromatography/photodiode array (HPLC/PDA) employing relative molar sensitivities (RMSs) and adopted it to the accurate quantification of carnosol (CL) and carnosic acid (CA) which are the antioxidants in rosemary extract. The method requires no references of CL or CA and instead uses RMSs with respect to diphenylamine (DPA) whose certified reference material is available from a reagent manufacturer. The molar and response ratios of the analytes to the reference in an artificial mixture of them were determined using 1H-quantitative nuclear magnetic resonance spectroscopy (1H-qNMR) and HPLC/PDA at a wavelength of 284 nm under isocratic condition, respectively, and then RMSs were calculated to be 0.111 for CL/DPA and 0.0809 for CA/DPA as averaged values in three HPLC-PDA instruments. The RMS values varied by up to 1.1% as relative standard deviation. To evaluate the performance of HPLC/PDA with the RMSs, the CL and CA contents in rosemary extracts were determined using DPA as a reference. The CL and CA contents were compared with those determined using calibration curves of CL and CA obtained by HPLC measurement of standard solutions prepared from their reagents whose absolute purities were determined using 1H-qNMR. The differences between the two methods for CL and CA were ≤3% as relative error. This chromatographic method with RMSs allows a simple and reliable quantification when reference of the analyte is unavailable.

[Survey of synthetic disinfectants in grapefruit seed extract and its compounded products].

Grapefruit seed extract (GSE), derived from the seeds of grapefruit (Citrus paradisi MCAF.), is listed as a natural food additive in Japan. Products containing GSE are used as disinfectants made from only natural sources, especially after Japanese researchers found that GSE prevents the growth of norovirus. On the other hand, recent overseas studies indicated that synthetic disinfectants, such as benzalkonium and benzethonium chlorides, were present in some commercial GSE products. To confirm the quality of commercial GSE products available in Japanese markets, we carried out comprehensive research to identify the major constituents of commercial GSE products which are used as food additives (13 products from 6 manufacturers), dietary supplements (5 products from 4 manufacturers), cosmetic materials (16 products from 10 manufacturers) and disinfectant or deodorant sprays (7 products from 7 manufacturers). By means of NMR and LC/MS analysis, synthetic disinfectants such as benzethonium or benzalkonium salts were detected in most of the commercial GSE products.

[Antimicrobial activity and constituents in rumput roman extract as a natural food preservative].

Rumput roman extract is used as a natural food preservative. Its antimicrobial activity and constituents were investigated as part of an ongoing study to evaluate its quality and safety as a food additive. The constituents were analyzed by GC/MS, and 5 major constituents were isolated and identified as capillin, capillene, caryophyllene oxide, alpha-curcumene and methyleugenol using NMR analysis. The antimicrobial activities against E. coli, S. cerevisiae and A. niger were measured by means of the halo test. Based on the results, we confirmed that capillin was the major active constituent. The concentrations of capillin and capillene were determined to 17.9 mg/mL and 36.1 mg/mL, respectively, from standard curves of authentic compounds on HPLC.

[Analysis of constituents of ester-type gum bases used as natural food additives].

The differences in the constituents of ten ester-type gum bases used as natural food additives in Japan (urushi wax, carnauba wax, candelilla wax, rice bran wax, shellac wax, jojoba wax, bees wax, Japan wax, montan wax, and lanolin) were investigated. Several kinds of gum bases showed characteristic TLC patterns of lipids. In addition, compositions of fatty acid and alcohol moieties of esters in the gum bases were analyzed by GC/MS after methanolysis and hydrolysis, respectively. The results indicated that the varieties of fatty acids and alcohols and their compositions were characteristic for each gum base. These results will be useful for identification and discrimination of the ester-type gum bases.

Determination of starting materials, intermediates, and subsidiary colors in the color additive Food Red No. 106 (Sulforhodamine B) using high-performance liquid chromatography.

The main subsidiary color of structure in Food Red No. 106 (R106) was identified to be a desethyl derivative (R106-SubA). High-performance liquid chromatography (HPLC) was performed for the quantitative determination of benzaldehyde-2,4-disulfonic acid, N,N-diethyl-m-aminophenol, leuco acid, pyrone acid, R106-SubA, etc. in R106. An ammonium acetate solution (20mM) and acetonitrile:water (7:3) were used to stabilize the retention time of the HPLC analytes. The linearity of the calibration curves was in the range of 0.05-10µg/mL, with good correlation coefficients (R2>0.9983). The recoveries of impurities at levels 0.1%, 0.5% and 1% ranged from 94.2% to 106.6% with relative standard deviations of 0.1%-1.0%. While surveying commercial R106, the amounts obtained by area% determination were similar to those obtained by the calibration-curve determination. The area% determination by HPLC for the determinations of impurities in R106 is a simple and reliable method and can be applied in routine analysis.

Identification of the main constituents in sandarac resin, a natural gum base.

Sandarac resin, a natural gum base, is described as "a substance composed mainly of sandaracopimaric acid obtained from the secretion of sandarac trees" in the List of Existing Food Additives in Japan. To evaluate its quality as a food additive, the main constituents in a sandarac resin product were investigated. Three constituents were isolated and identified as sandaracopimaric acid, sandaracopimarinol and 4-epidehydroabietic acid by MS and 2D-NMR. Quantification of the main constituent, sandaracopimaric acid, was performed by HPLC and its content in the product was determined to be 11.6%.

[Analysis of constituents in urushi wax, a natural food additive].

Urushi wax is a natural gum base used as a food additive. In order to evaluate the quality of urushi wax as a food additive and to obtain information useful for setting official standards, we investigated the constituents and their concentrations in urushi wax, using the same sample as scheduled for toxicity testing. After methanolysis of urushi wax, the composition of fatty acids was analyzed by GC/MS. The results indicated that the main fatty acids were palmitic acid, oleic acid and stearic acid. LC/MS analysis of urushi wax provided molecular-related ions of the main constituents. The main constituents were identified as triglycerides, namely glyceryl tripalmitate (30.7%), glyceryl dipalmitate monooleate (21.2%), glyceryl dioleate monopalmitate (2.1%), glyceryl monooleate monopalmitate monostearate (2.6%), glyceryl dipalmitate monostearate (5.6%), glyceryl distearate monopalmitate (1.4%). Glyceryl dipalmitate monooleate isomers differing in the binding sites of each constituent fatty acid could be separately determined by LC/MS/MS.

Preparation of a Ammonia-Treated Lac Dye and Structure Elucidation of Its Main Component.

Lac dye and cochineal extract contain laccaic acids and carminic acid as the main pigments, respectively. Both laccaic acids and carminic acid are anthraquinone derivatives. 4-Aminocarminic acid (acid-stable carmine), an illegal colorant, has been detected in several processed foods. 4-Aminocarminic acid is obtained by heating cochineal extract (carminic acid) in ammonia solution. We attempted to prepare ammonia-treated lac dye and to identify the structures of the main pigment components. Ammonia-treated lac dye showed acid stability similar to that of 4-aminocarminic acid. The structures of the main pigments in ammonia-treated lac dye were analyzed using LC/MS. One of the main pigments was isolated and identified as 4-aminolaccaic acid C using various NMR techniques, including 2D-INADEQUATE. These results indicated that ammonia-treatment of lac dye results in the generation of 4-aminolaccaic acids.

Analysis of the constituents in jojoba wax used as a food additive by LC/MS/MS.

Jojoba wax is a natural gum base used as a food additive in Japan, and is obtained from jojoba oil with a characteristically high melting point. Although the constituents of jojoba oil have been reported, the quality of jojoba wax used as a food additive has not yet been clarified. In order to evaluate its quality as a food additive and to obtain basic information useful for setting official standards, we investigated the constituents and their concentrations in jojoba wax. LC/MS analysis of the jojoba wax showed six peaks with [M+H]+ ions in the range from m/z 533.6 to 673.7 at intervals of m/z 28. After isolation of the components of the four main peaks by preparative LC/MS, the fatty acid and long chain alcohol moieties of the wax esters were analyzed by methanolysis and hydrolysis, followed by GC/MS. The results indicated that the main constituents in jojoba wax were various kinds of wax esters, namely eicosenyl octadecenoate (C20:1-C18:1) (1), eicosenyl eicosenoate (C20:1-C20:1) (II), docosenyl eicosenoate (C22:1-C20:1) (III), eicosenyl docosenoate (C20:1-C22:1) (IV) and tetracosenyl eiosenoate (C24:1-C20:1) (V). To confirm and quantify the wax esters in jojoba wax directly, LC/MS/MS analysis was performed. The product ions corresponding to the fatty acid moieties of the wax esters were observed, and by using the product ions derived from the protonated molecular ions of wax esters the fatty acid moieties were identified by MRM analysis. The concentrations of the wax esters I, II and III, in jojoba wax were 5.5, 21.4 and 37.8%, respectively. In summary, we clarified the main constituents of jojoba wax and quantified the molecular species of the wax esters without hydrolysis by monitoring their product ions, using a LC/MS/MS system.