RESUMO
In this work the anaerobic monodigestion for the treatment of turkey manure was evaluated, without its codigestion with another substrate. The effect of the organic loading rate (OLR) and the substrate concentration (high total solids (TS) concentration) or product concentration (high volatile fatty acids (VFA) and/or ammonia (NH(3)-N) concentrations) was studied. The results show that for a continuous stirred tank reactor (CSTR) operation, a maximum of 40 g/L of TS and 4.0 g/L of ammonium (NH(4)(+)) was required. In addition, the maximum organic loading rate (OLR) will not exceed 1.5 kg VS/m(3)d. Higher TS and NH(4)(+) concentrations and OLR lead to a reduction on the methane productivity and volatile solids (VS) removal. During the CSTR operation, a high alkalinity concentration (above 10 g/L CaCO(3)) was found; this situation allowed maintaining a constant and appropriate pH (close to 7.8), despite the VFA accumulation. In this sense, the alkalinity ratio (α) is a more appropriate control and monitoring parameter of the reactor operation compared to pH. Additionally, with this parameter a VS removal of 80% with a methane productivity of 0.50 m(3)(CH4)/m(3)(R)d is achieved.
Assuntos
Reatores Biológicos , Esterco , Esgotos , Criação de Animais Domésticos , Animais , Dióxido de Carbono/análise , Ácidos Graxos Voláteis/análise , Resíduos Industriais , Metano/análise , Compostos de Amônio Quaternário/análise , PerusRESUMO
One of the research areas is the agricultural use of treated wastewaters, because it represents a unique opportunity to solve the problem of water supply for irrigation and at the same time the disposal of treated water. Anaerobic digestion appears as an interesting alternative, since anaerobically treated wastewaters can be used for irrigation purposes. These considerations are applied to the Chilean pisco industry (a traditional alcoholic drink, prepared by distillation of wine made mainly from Muscatel grapes), where high concentrated wastewaters are produced: vinasses originate as a residue from the distillation operation. Two laboratory reactors fed with wine vinasses, a UASB and an EGSB, were used in order to study the anaerobic treatability of the wastewater. Then, a pilot reactor was built (60 m3 UASB digester) and treated water was used to irrigate eucalyptus trees. Finally a 300 m3 reactor, including biogas treatment for its reuse, was developed. Results showed, both at laboratory and full scale, that anaerobic treatment is suitable for pisco's wastewaters, and also that the nutrient content of treated water can be beneficial for plant growth, reducing the need for fertilizers. Another kind of investigation was carried out in order to study the stability of anaerobic granules and how it can be recovered. UASB and EGSB were fed with low, medium and high load wastewaters, in order to evaluate possible fluctuations in the productive process. From these results, it was possible to propose and to apply recovery techniques to the digesters when they are destabilized.
Assuntos
Anaerobiose , Reatores Biológicos/normas , Eliminação de Resíduos Líquidos/métodos , Vinho , Biodegradação Ambiental , Chile , Gases , Resíduos Industriais/prevenção & controle , Projetos Piloto , Abastecimento de ÁguaRESUMO
The operation of two different reactor configurations (UASB and EGSB), while treating medium and low concentrated wastewater (MCW and LCW, respectively), was studied. The MCW (5 g COD/l) was initially supplied for reactor start up and granule maturation, being subsequently changed to the LCW (0.5 g COD/I), with which led the reactors to an unstable state associated with the deterioration of granule characteristics, in terms of extracellular polymeric substances (EPS) content and composition. The addition of pectin as an exogenous EPS was considered as a way to directly act on granule characteristics and its effect was studied by monitoring the operational parameters as well as by following the EPS content and composition within granules and the dynamics of microbial populations. The effect of adding pectin led to a significant recuperation of the operational performance in both reactors, associated with the increase in Archaea relative abundance, this likely related to the major presence of Methanosaeta-like microorganisms in granules with higher activity and stability.
Assuntos
Recuperação e Remediação Ambiental , Polímeros/química , Microscopia Eletrônica de VarreduraRESUMO
A method is described which makes possible the release of immature forespores from sporulating cells at specific stages of development, from the completion of stage III through to mature spore formation. With the aid of zonal density gradient centrifugation, the method makes possible the recovery of quantities of forespores ample for biochemical and physical studies. With the capability to examine forespores and some mother cell components independently, we have established that several enzymes associated with the sporulation process are localized in the newly developed forespores. Studies showed that aspartate aminotransferase and alanine aminotransferase are associated with the forespores, whereas l-alanine dehydrogenase is found only in the mother cell cytoplasm.