Production of Fucoxanthin from Phaeodactylum tricornutum Using High Performance Countercurrent Chromatography Retaining Its FOXO3 Nuclear Translocation-Inducing Effect.

Phaeodactylum tricornutum is a rich source of fucoxanthin, a carotenoid with several health benefits. In the present study, high performance countercurrent chromatography (HPCCC) was used to isolate fucoxanthin from an extract of P. tricornutum. A multiple sequential injection HPCCC method was developed combining two elution modes (reverse phase and extrusion). The lower phase of a biphasic solvent system (n-heptane, ethyl acetate, ethanol and water, ratio 5/5/6/3, v/v/v/v) was used as the mobile phase, while the upper phase was the stationary phase. Ten consecutive sample injections (240 mg of extract each) were performed leading to the separation of 38 mg fucoxanthin with purity of 97% and a recovery of 98%. The process throughput was 0.189 g/h, while the efficiency per gram of fucoxanthin was 0.003 g/h. Environmental risk and general process evaluation factors were used for assessment of the developed separation method and compared with existing fucoxanthin liquid-liquid isolation methods. The isolated fucoxanthin retained its well-described ability to induce nuclear translocation of transcription factor FOXO3. Overall, the developed isolation method may represent a useful model to produce biologically active fucoxanthin from diatom biomass.

Application of HPCCC Combined with Polymeric Resins and HPLC for the Separation of Cyclic Lipopeptides Muscotoxins A⁻C and Their Antimicrobial Activity.

Muscotoxins are cyanobacterial cyclic lipopeptides with potential applications in biomedicine and biotechnology. In this study, Desmonostoc muscorum CCALA125 strain extracts were enriched by polymeric resin treatment, and subjected to HPCCC affording three cyclic lipopeptides (1⁻3), which were further repurified by semi-preparative HPLC, affording 1, 2, and 3, with a purity of 86%, 92%, and 90%, respectively. The chemical identities of 2⁻3 were determined as muscotoxins A and B, respectively, by comparison with previously reported ESI-HRMS/MS data, whereas 1 was determined as a novel muscotoxin variant (muscotoxin C) using NMR and ESI-HRMS/MS data. Owing to the high yield (50 mg), compound 2 was broadly screened for its antimicrobial potential exhibiting a strong antifungal activity against Alternaria alternata, Monographella cucumerina, and Aspergillus fumigatus, with minimum inhibitory concentration (MIC) values of 0.58, 2.34, and 2.34 µg/mL; respectively, and weak antibacterial activity against Bacillus subtilis with a MIC value of 37.5 µg/mL. Compounds 1 and 3 were tested only against the plant pathogenic fungus Sclerotinia sclerotiorum due to their low yield, displaying a moderate antifungal activity. The developed chromatographic method proved to be an efficient tool for obtaining muscotoxins with potent antifungal properties.

Flavonoids from the flowers of Impatiens glandulifera Royle isolated by high performance countercurrent chromatography.

INTRODUCTION: Impatiens glandulifera Royle (Balsaminaceae) is an annual herb from the Himalaya region, currently widespread along European river systems and one of the most important neophyte invading plants in Germany. Exploring the effects of allelopathic plant chemicals is important for the understanding of its ecological impacts in the process of suppression of indigenous plant species. OBJECTIVE: To investigate the chemical composition of Impatiens glandulifera flowers (IGFs) using high performance countercurrent chromatography (HPCCC). METHODS: The flowers of Impatiens glandulifera were manually separated and extracted with ethanol. LC-ESI-MS/MS was used to characterise the crude extract of IGF. The various flavonoids detected were isolated by HPCCC using of methyl tert-butyl ether-acetonitrile-water (2:2:3, v/v/v). The combination of the data provided by preparative ESI-MS/MS metabolite profiling, LC-ESI-MS/MS, UV-vis and 1D/2D-NMR spectroscopic analysis was used to elucidate the structures of the isolated compounds. RESULTS: HPCCC runs led to the direct isolation of pure dihydromyricetin (ampelopsin), eriodictyol-7-O-glucoside, kaempferol-3-O-glucoside (astragalin) and kaempferol-3-O-6"-malonyl-glucoside, as well as the pre-purification of kaempferol-3-O-rhamno-rhamnosyldiglucoside, quercetin-3-O-galactoside (hyperoside), quercetin and kaempferol in a single step. CONCLUSION: This is the first report on the flavonoid composition of the species Impatiens glandulifera. The developed protocol was successfully used to isolate the main flavonoids from the crude extract of IGFs. This combined HPCCC and HPLC procedure could be applied to the fast fractionation and recovery of flavonoid derivatives of other plant extracts.

[Preparation of brazilein from Caesalpinia sappan by high performance countercurrent chromatography].

Brazilein is among the main chemical constituents of Caesalpinia sappan. It has diverse pharmacological activities. Modern pharmacological studies have shown that the compound has antitumor, anti-inflammatory, antibacterial, antioxidant, immunomodulatory, and other pharmacological activities. Brazilein is often used as a stain in various industries. The separation of brazilein by traditional column chromatography will not only result in contamination of the chromatographic column materials, but also lead to loss of the active ingredient. Countercurrent chromatography is an advanced liquid-liquid chromatographic separation technique. It has been widely used for natural product separation and isolation as it offers several advantages, such as low solvent consumption, a highly selective solvent system, and high recoveries. Typical countercurrent chromatography techniques include centrifugal partition chromatography (CPC), high-speed countercurrent chromatography (HSCCC), and high performance countercurrent chromatography (HPCCC). It is well known that choosing a suitable solvent system is vital in countercurrent separation. Therefore, two methods were introduced for choosing a suitable solvent system. One is the generally useful estimation of solvent systems (GUESS) method, which employs thin-layer chromatography (TLC) to identify a suitable solvent system with minimal labor for the rapid purification of target compounds, and another is the Shake-Flash method. The solvent system could be determined by observing the distribution of the sample in the upper and lower phases. Two kinds of solvent systems were screened using the TLC-GUESS and Shake-Flash methods, and tested through the analysis mode of the HPCCC instrument. The results showed that chloroform-methanol-water (4:3:2, v/v/v) was the optimal solvent system for HPCCC separation. A total of 15.2 mg of brazilein and 5.7 mg of caesappanin C were obtained from an ethyl acetate extract with high purities (95.6% and 89.0%, analyzed by HPLC) in one step using the preparation mode of HPCCC, the reversed-phase liquid chromatography mode with the apparatus rotated at 1600 r/min, a flow rate of 10 mL/min, separation temperature of 25℃, and detection wavelength of 285 nm. Their structures were determined by spectroscopic and spectrometric analyses. Brazilein stained the solid packing material in the column and was difficult to elute. The results showed that the use of HPCCC for the separation of brazilein can not only prevent the loss of target active ingredients in Caesalpinia sappan, but also shorten the separation and purification times and improve the operating efficiency. Therefore, HPCCC can be used for the separation and preparation of other pigment compounds in Caesalpinia sappan and other dye plants.

Simultaneous separation of six pure polymethoxyflavones from sweet orange peel extract by high performance counter current chromatography.

Successful isolation of polymethoxyflavones (PMFs) from citrus peels has led to numerous evaluations of PMFs in a broad spectrum of biological activities, such as inhibition of chronic inflammation, cancer prevention and anti-atherogenic properties. Recent reports associated with the health promoting properties of PMFs in citrus fruits have dramatically increased. However, the limiting factor in animal and human study of PMFs is still the supply of pure PMFs, such as tangeretin, nobiletin, sinensetin and 3,5,6,7,3',4'-hexamethoxyflavone. Herein, we introduce the newly developed efficient separation method using high-performance counter-current chromatography (HPCCC) in isolating multiple pure single PMFs simultaneously in one cycle process. With the smallest preparation loop on the semi-preparative HPCCC instrument, the optimized solvent system of hexanes/ethyl acetate/methanol/water resulted in the isolation of pure sinensetin, tangeretin, nobiletin, 3,5,6,7,3',4'-hexamethoxyflavone, 5,6,7,4'-tetramethoxyflavone and 3,5,6,7,8,3',4'-heptamethoxyflavone directly from crude sweet orange peel extract in one cycle of separation process by HPCCC in the mode of reverse phase. The purity of each of the six isolated PMFs is greater than 96.6% analyzed by high-performance liquid chromatography and proton nuclear magnetic resonance. Scale-up and high purity of individual PMFs can be separated by using a large separation loop in preparative HPCCC model. The renovated HPCCC methodology can be practically used in natural product isolation and consequent biological property evaluation.

Activity-Guided Fractionation of Red Fruit Extracts for the Identification of Compounds Influencing Glucose Metabolism.

An activity-guided search for compounds influencing glucose metabolism in extracts from aronia (Aronia melanocarpa, A.), pomegranate (Punica granatum L., P.), and red grape (Vitis vinifera, RG) was carried out. The three extracts were fractionated by means of membrane chromatography to separate the anthocyanins from other noncolored phenolic compounds (copigments). In addition, precipitation with hexane was performed to isolate the polymers (PF). The anthocyanin and copigment fractions (AF, CF) of aronia, pomegranate, and red grape were furthermore fractionated with high-performance countercurrent chromatography (HPCCC) and the subfractions were characterized by HPLC-PDA-MS/MS analyses. Each of the (sub-)fractions was examined by in vitro-tests, i.e., the inhibition of the activity of α-amylase and α-glucosidase. On the basis of this screening, several potent inhibitors of the two enzymes could be identified, which included flavonols (e.g., quercetin), ellagitannins (e.g., pedunculagin), and anthocyanins (e.g., delphinidin-3-glucoside and petunidin-3-glucoside). In the α-glucosidase assay all of the examined fractions and subfractions of the fruit extracts were more active than the positive control acarbose.