Feed form and nutritional level for rearing growing broilers in thermoneutral or heat stress environments.

The present study aimed to investigate the effects of different physical forms of feed and feeding programs on nutrient digestibility and performance of grower-finisher broilers under thermoneutrality or thermal stress. Three experiments were conducted using male broiler chickens (n = 720) aged 19-42 d. The design of two of the experiments was fully randomized in a 2 × 2 factorial arrangement with two forms of feed (mash and pellet) and two nutritional levels (13.19 MJ/kg and 194.8 g/kg CP - normal level and 13.61 MJ/kg and 210.3 g/kg CP - high level). The experiments took place in a climate-controlled room: Experiment 1 at thermoneutrality (21-23 °C and 58-60% relative humidity) for 24 h/day; Experiment 2 under thermal stress cycle (31-32 °C and 63-65% relative humidity), for 6h/day and thermoneutrality (21-23 °C, 58-60% relative humidity) for 18h/day. The nutrient digestibility and performance was analyzed. The design of the third experiment was fully randomized with two ambient condition treatments (thermoneutral and thermal stress) on heat production, caloric increment and net energy. Pellet feed obtained higher digestibility of dry matter, digestibility of crude protein, AME and AMEn (P < 0.05) than mash feed for broilers reared in the thermoneutral environment. At the high nutritional level there was no effect of treatments on the coefficient of dry matter and crude protein (DCCP) (P > 0.05), while the highest digestibility of AME and AMEn were obtained by the high nutritional level diet (P < 0.05). Pellet feed had higher DCCP (P < 0.05) than mash feed for broilers reared under cyclic heat stress. Broiler chickens under cyclic stress experienced increased caloric increment, rectal temperature and respiratory rate. The appropriate strategy to minimize these effects in both ambient conditions is to pellet feed.

Increased Likelihood of Detecting Ebola Virus RNA in Semen by Using Sample Pelleting.

Ebola virus RNA can reside for months or years in semen of survivors of Ebola virus disease and is probably associated with increased risk for cryptic sexual transmission of the virus. A modified protocol resulted in increased detection of Ebola virus RNA in semen and improved disease surveillance.

Effects of feeding intact, ground and/or pelleted rapeseed on nutrient digestibility and growth performance of broiler chickens.

In this study, the effect of grinding or pelleting of rapeseed on the digestibility, apparent metabolisable energy (AMEN), growth performance and gizzard weight of broiler chickens was evaluated. In Exp. 1, four treatments were tested (240 broiler chickens, 20 replications, 3 birds per cage). Birds received either a basal diet or were fed with rapeseed of different sized particles (fine, medium and coarse ground, respectively). In Exp. 2, 10 treatments were assessed (360 chickens, 12 replications, 3 birds per cage), where five different diets (a basal diet and four diets with intact rapeseed, fine ground, medium ground or coarse ground rapeseed, respectively) were fed non-pelleted or pelleted. In Exp. 3, two treatments were compared (224 broiler chickens, 14 replications, 8 birds per floor pen): fine ground rapeseed (FG) and intact rapeseed (IS). Compared with medium and coarse ground rapeseed, fine grinding increased in Exp. 1 the AMEN of rapeseed and the precaecal digestibility (PD) of dry matter and ether extract (EE) (p < 0.05). In Exp. 2, the content of AMEN and the PD of EE and crude protein (CP) increased as the degree of grinding increased when diets were not pelleted (p < 0.01). In contrast, the significantly highest values for these parameters were measured after pelleting without effect of grinding, resulting in a significant interaction between pelleting and grinding (p < 0.001). In Exp. 3, performance of chickens was not affected by dietary treatments, but gizzard weight and the PD of CP were higher when IS were included in the diet (p < 0.05). The results suggested that fine grinding may be used to increase the feeding value of full-fat rapeseed for broiler chickens. Nevertheless, pelleting of diets with rapeseed seemed to be much more effective in the reduction of particle size than grinding.

Effects of processing methods (rolling vs. pelleting vs. steam-flaking) of cool-season adapted oats on dairy cattle production performance and metabolic characteristics compared with barley.

Several processing techniques can be used to slow the degradation rate in the rumen and thus provide more bypass crude protein (CP) and starch to the small intestine. The aim of this study was to evaluate the effects of processing methods on cool-season adapted oat grain compared with dry-rolled barley grain, when fed as total mixed ration (TMR) for lactating dairy cows. Eight lactating Holstein cows were used in a replicated 4 × 4 Latin square design with 21-d periods and fed TMR with 1 of 4 treatments: dry-rolled oats, steam-flaked oats, pelleted oats, or dry-rolled barley. Dry matter intake (DMI) ranged from 28.19 to 31.61 kg/d and was lower for rolled oats compared with pelleted oats. Despite the nutrient intake being higher for cows fed pelleted oats, those fed rolled oats had the highest milk production and milk fat percentage (49.23 kg/d and 4%, respectively). Ruminal fermentation characteristics were similar across treatments, with only significant differences in concentrations of acetate (lowest for pelleted oats) and total short-chain fatty acids (highest value for rolled barley) and a lower pH for flaked oats at the 9-h and 12-h points. Dietary treatments did not affect total-tract digestibility of dry matter, organic matter, or CP; digestibility of starch was the lowest for rolled barley (89.04%). Measured blood metabolites, urea, glucose, and ß-hydroxybutyrate, were not affected by dietary treatment. Purine derivatives and microbial N supply were also unaffected by dietary treatments. Cows fed flaked oat-based TMR showed the lowest N excretion in milk; however, the lack of difference between diets with regard to urinary N and fecal N excretion resulted in no significant changes in N balance between diets. Therefore, rolled oats allow cows to have higher milk production with lower DMI compared with all other treatments in this study.

Effects of two commercial diets and technical feed treatment on stomach lesions and immune system of fattening pigs.

The impact of technical feed treatment and diet on stomach lesions and traits of the local and systemic immune system were investigated in fattening pigs. Feeding groups differed in technical feed treatment (standard ground meal vs. finely ground and pelleted feed) and diet (soya bean meal vs. rapeseed meal/DDGS/soya beans). Pigs were fattened approximately 10 weeks by ad libitum feeding and slaughtered subsequently. Gastric alterations were assessed by a macroscopic scoring system [macroscopic stomach score (MSC) 0 =  normal to 4 =  severe lesions]. For immunological investigations, lymphocytes from blood and jejunal tissues were isolated. T-cell phenotyping was carried out by staining intestinal lymphocytes with monoclonal antibodies for CD4 and CD8 and flow cytometric measurements. MSC was higher in animals fed finely ground and pelleted feed compared with their counterparts. Significant interactions between diet and feed treatment considering the MSC were observed (p = 0.027). There was no effect of diet or technical feed treatment on T cells of blood, Lymphonodi gastrici or lamina propria (LP) and intraepithelial cells. However, technical feed treatment significantly affected subsets of CD4+ , CD8+ , CD8low , CD4/CD8 double-positive T cells, the mean fluorescence intensity of CD4+ T cells and the ratio of CD8low /CD8high T cells in Peyer's patches (PP). All named parameters were reduced in PP of animals fed finely ground and pelleted feed compared with animals fed standard ground meal. Furthermore, significant differences between T cells of lymph nodes and LP were observed between animals with middle MSC (MSC = 1-2.5) and animals with high MSC (MSC = 3-4). Significant alterations in T cells of PP were observed between animals of low (MSC = 0-0.5) and high MSC. The observed effects provide the evidence that the impact of technical feed treatment is not limited on the stomach lesions. Possible stimuli and consequences of the immune system should be studied in more detail.

Effects of exogenous phytase and xylanase, individually or in combination, and pelleting on nutrient digestibility, available energy content of wheat and performance of growing pigs fed wheat-based diets.

OBJECTIVE: Two experiments were conducted to determine the effects of adding exogenous phytase and xylanase, individually or in combination, as well as pelleting on nutrient digestibility, available energy content of wheat and the performance of growing pigs fed wheat-based diets. METHODS: In Experiment 1, forty-eight barrows with an initial body weight of 35.9±0.6 kg were randomly assigned to a 2×4 factorial experiment with the main effects being feed form (pellet vs meal) and enzyme supplementation (none, 10,000 U/kg phytase, 4,000 U/kg xylanase or 10,000 U/kg phytase plus 4,000 U/kg xylanase). The basal diet contained 97.8% wheat. Pigs were placed in metabolic cages for a 7-d adaptation period followed by a 5-d total collection of feces and urine. Nutrient digestibility and available energy content were determined. Experiment 2 was conducted to evaluate the effects of pelleting and enzymes on performance of wheat for growing pigs. In this experiment, 180 growing pigs (35.2±9.0 kg BW) were allocated to 1 of 6 treatments according to a 2×3 factorial treatment arrangement with the main effects being feed form (meal vs pellet) and enzyme supplementation (0, 2,500 or 5,000 U/kg xylanase). RESULTS: In Experiment 1, there were no interactions between feed form and enzyme supplementation. Pelleting reduced the digestibility of acid detergent fiber (ADF) by 6.4 percentage units (p<0.01), increased the digestibility of energy by 0.6 percentage units (p<0.05), and tended to improve the digestibility of crude protein by 0.5 percentage units (p = 0.07) compared with diets in mash form. The addition of phytase improved the digestibility of phosphorus (p<0.01) and calcium (p<0.01) by 6.9 and 7.6 percentage units respectively compared with control group. Adding xylanase tended to increase the digestibility of crude protein by 1.0 percentage units (p = 0.09) and increased the digestibility of neutral detergent fiber (NDF) (p<0.01) compared with control group. Supplementation of the xylanase-phytase combination improved the digestibility of phosphorus (p<0.01) but impaired NDF digestibility (p<0.05) compared with adding xylanase alone. In Experiment 2, adding xylanase increased average daily gain (p<0.01) and linearly improved the feed:gain ratio (p<0.01) compared with control group. CONCLUSION: Pelleting improved energy digestibility but decreased ADF digestibility. Adding xylanase increased crude protein digestibility and pig performance. Phytase increased the apparent total tract digestibility of phosphorus and calcium. The combination of phytase-xylanase supplementation impaired the effects of xylanase on NDF digestibility.

[Recognition and use of Aconitum carmichaeli from the pre-Qin period to Tang Dynasty-Also on rules in evolution of traditional Chinese medicine].

The recognition and use of Aconitum carmichaeli have undergone various changes from the pre-Qin period to Tang dynasty. From "the drug of evil" to "the leader of hundreds of medicine ", people's understanding of A. carmichaeli is more and more deep and specific. The medicinal values of A. Carmichaeli have been excavated, and it is widely used in brewing skill, agricultural production, Taoism, Buddhism and festival customs. Its function is becoming more and more diversified and routinized. By studying it, we can glimpse some rules in the evolution of traditional Chinese medicine, for instance relationships between drugs and poisons, drugs and non-drug; the inheritance and integration of medical books' recording; the generalization and routinization of Chinese medicinal medicines' functions, and so on.

Effect of seed pelleting with biocontrol agents on growth and colonisation of roots of mungbean by root-infecting fungi.

BACKGROUND: Mungbean (Vigna radiata (L.) Wilczek) is a leguminous pulse crop that is a major source of proteins, vitamins and minerals. Root-infecting fungi produce severe plant diseases like root rot, charcoal rot, damping-off and stem rot. The soil-borne pathogens can be controlled by chemicals, but these chemicals have several negative effects. Use of microbial antagonist such as fungi and bacteria is a safe, effective and eco-friendly method for the control of many soil-borne pathogens. Biological control agents promote plant growth and develop disease resistance. Application of bacteria and fungi as seed dressing suppressed the root-infecting fungi on leguminous crops. RESULTS: Seeds of mungbean were pelleted with different biocontrol agents to determine their effect on plant growth and colonisation of roots by root-infecting fungi, viz. Fusarium solani, Macrophomina phaseolina, Pythium aphanidermatum, Rhizoctonia solani and Sclerotium rolfsii. Treatment of mungbean seeds with fungal antagonists showed more shoot and root length as compared to bacterial antagonists, whereas seed treated with bacterial antagonists showed maximum shoot and root weight. Trichoderma harzianum and Bacillus subtilis were the best among all the biocontrol agents since they provided the highest plant growth and greater reduction in root colonisation by all root-infecting fungi. Bacillus cereus, Trichoderma virens, Pseudomonas fluorescens and Micrococcus varians were also effective against root-infecting fungi but to a lesser extent. T. harzianum, T. virens, B. subtilis and P. fluorescens were found to be best among all biocontrol agents. CONCLUSION: The root-infecting fungi can be controlled by pelleting seeds with biocontrol agents as it is safe and effective method. Additionally, plant growth was promoted more by this method. © 2015 Society of Chemical Industry.

Effects of diets differing in protein source and technical treatment on digestibility, performance and visceral and biochemical parameters of fattening pigs.

The aim of the experiment on 100 cross-bred barrows was to compare commercial diets for fattening pigs based on either soya bean meal (SBM) imported from non-European countries with diets based on a mixture of locally produced rape seed meal, distillers' dried grains with solubles and soya beans as main protein sources. In addition, these both types of diets were processed by two different technical feed treatments, i.e. coarse grinding without hydrothermal treatment or fine grinding and pelleting. With only few exceptions, nutrients of the diet without SBM were more digestible (p < 0.05) resulting in a higher metabolisable energy (ME) content. Fine grinding and pelleting increased also the ME content and the nutrient digestibility with the exception of crude fibre. Higher feed intake of animals that fed diets without SBM (p < 0.01) resulted in higher average daily gain (p < 0.01). However feeding this diet, the higher digestibility was not reflected in a decreased feed-to-gain ratio (FGR), but fine grinding and pelleting reduced FGR (p < 0.001). A higher pH value and a lower DM content of caecal chymus were detected in animals that received coarsely ground feed (p < 0.05). Animals that fed finely ground and pelleted feed had higher slaughter and relative liver weights and higher blood cholesterol concentrations (p = 0.040). The urea concentrations of blood were lower (p = 0.019) after feeding diets without SBM. In conclusion, SBM imported from non-European countries can be replaced by alternative local protein sources without compromising digestibility or performances of animals. Although fine grinding and thermal treatment particularly seemed to be advantageous for digestibility and performance, the possible risk of development of stomach lesions should be considered.

Effects of conditioning temperature and time during the pelleting process on feed molecular structure, pellet durability index, and metabolic features of co-products from bio-oil processing in dairy cows.

The objectives of this study were to systematically determine effects of conditioning temperature (70, 80, and 90°C), time (50 and 75 s), and interaction (temperature × time) during the pelleting process on co-products from bio-oil processing (canola meal) in terms of processing-induced changes on (1) protein molecular structure, (2) pellet durability index, (3) detailed chemical profile, (4) metabolic features and fractions of protein and carbohydrate, (5) total digestible nutrients and energy values, and (6) rumen degradable and undegradable content. Pellet durability was increased with increasing conditioning time. Chemical and carbohydrate profiles of co-products were not altered by pelleting process under different conditioning temperatures and times. With regard to protein fraction profiles, pellets conditioned for 50 s had higher soluble crude protein (SCP) and lower neutral detergent insoluble crude protein (NDICP) contents than those conditioned for 75 s (21.7 vs. 20.1% SCP, 16.0 vs. 16.5% NDICP, respectively). Total digestible nutrients and energy values were not altered by processing. Samples conditioned for 50 s had a higher content of rapidly degradable protein fraction (PA2) than those conditioned for 75 s (21.7 vs. 21.1% crude protein). In addition, the slowly degradable true protein fraction (PB2) was affected by the interaction of conditioning temperature and time. However, carbohydrate fractions did not differ with different conditioning temperatures and time. Different temperatures and time of conditioning during pelleting process greatly affect protein profiles without altering carbohydrate profiles. Molecular structure analyses also showed that pelleting altered inherent protein molecular structures of the co-products from bio-oil processing. Future study is needed to detect how molecular structure changes affect nutrient availability in dairy cattle.

Effects of canola meal pellet conditioning temperature and time on ruminal and intestinal digestion, hourly effective degradation ratio, and potential nitrogen to energy synchronization in dairy cows.

The increase in bio-oil production in North America has resulted in millions of tonnes of co-products: canola meal and carinata meal. Little research has been conducted to determine the effect of pellet conditioning temperature, time, and their interaction on processing-induced changes in nutrient digestibility in the rumen and intestine (in vitro) of dairy cattle. The objectives of this study were to investigate the effects of conditioning temperature (70, 80, and 90°C), time (50 and 75 s), and their interaction (temperature × time) during the pelleting of canola meal on (1) rumen degradation kinetics and effective rumen degradability of dry matter, crude protein (CP), and neutral detergent fiber; (2) intestinal digestibility of rumen-undegradable protein (RUP); and (3) hourly effective rumen degradation ratio and potential N to energy synchronization in dairy cattle. The results showed that the temperature and duration of pellet conditioning significantly altered the degradation characteristics of nutrients in the rumen. Pelleting increased CP degradation in the rumen, and CP digestion site was shifted to the rumen rather than to the small intestine. When conditioning temperature was set 80°C, the rumen degradation of CP and neutral detergent fiber was highest, but postrumen digestion was lowest. With respect to intestinal digestion, the available CP for intestinal digestion became less because of reduced RUP supply to the small intestine. The pelleting process tended to significantly affect the intestinal digestibility of RUP. However, the total digestible CP content of canola meal was not affected. In conclusion, pelleting induced changes in rumen and intestinal digestion profiles, and altered the potential N to energy synchronization and hourly effective rumen degradation ratio of canola meal in dairy cattle.

Effects of particle size and hydro-thermal treatment of feed on performance and stomach health in fattening pigs.

Effects of grinding and hydro-thermal treatment of feed on growth performance, slaughter traits, nutrient digestibility, stomach content and stomach health were examined by using 96 crossbred fattening pigs. Pigs were fed a grain-soybean meal-based diet processed by various technical treatments. Feeding groups differed in particle size after grinding (finely vs. coarsely ground feed) and hydro-thermal treatment (without hydro-thermal treatment, pelleting, expanding, expanding and pelleting). Fine grinding and hydro-thermal treatment showed significant improvements on the digestibility of crude nutrients and content of metabolisable energy. Hydro-thermal treatment influenced average daily gain (ADG) and average daily feed intake (DFI) significantly. Finely ground pelleted feed without expanding enhanced performances by increasing ADG and decreasing feed-to-gain ratio (FGR) of fattening pigs. Coarsely ground feed without hydro-thermal treatment resulted in the highest ADG and DFI, however also in the highest FGR. Expanded feed decreased DFI and ADG. Slaughter traits were not affected by treatments. Coarsely ground feed without hydro-thermal treatment had protective effects on the health of gastric pars nonglandularis, however, pelleting increased gastric lesions. Hydro-thermal treatment, especially expanding, resulted in clumping of stomach content which possibly induced satiety by slower ingesta passage rate and thus decreased feed intake. Pigs fed pelleted feed showed less pronounced development of clumps in stomach content compared with expanded feed.

The effects of different thermal treatments and organic acid levels on nutrient digestibility in broilers.

Poultry feed is a potential vector for pathogens. Heat processing and organic acid treatments may decontaminate feed and can affect bird performance as well as feed digestibility. The present study was performed to investigate the effect of different thermal treatments including pelleting (P), long-term conditioning at 85°C for 3 min (L), or expanding at 110°C (E110) and 130°C for 3 to 5 s (E130) without or with 0.75 and 1.5% organic acid supplementation (63.75% formic acid, 25.00% propionic acid, and 11.25% water) on performance, nutrient digestibility, and organ weights of broilers. In total, 960 one-day-old broiler chicks were randomly assigned to 8 replicates using a 3 × 4 factorial arrangement. Performance variables were determined, and the relative organ weights and ileal and total amino acid (AA) digestibilities were measured at d 35. The organic acid inclusion linearly improved feed efficiency in the first week (P ≤ 0.05). The acid inclusion levels and thermal treatments had no significant effect on the performance variables at later intervals of the growing period of the birds. The L group showed the lowest ileal AA and CP digestibility. The inclusion of organic acids had a quadratic effect on total and ileal digestibility of isoleucine (P ≤ 0.05), whereas it had no significant effect on the ileal digestibility of other AA and nutrients. The relative weights of the jejunum and small intestine were significantly higher in the E130 group compared with P and L (P ≤ 0.05). In conclusion, our study demonstrated that long-term heat conditioning can decrease ileal nutrient digestibility, whereas pelleting and expansion, independently of organic acid addition, seemed to have no negative impact on broiler performance and nutrient digestibilities. Moreover, adding a blend of organic acids to broiler diets had neither positive nor negative effects on nutrient digestibility and final broiler performance. This indicates the feasibility of short-term thermal treatment and acid supplementation for hygienization of broiler feed without negatively influencing performance.

Impact of thermal and organic acid treatment of feed on apparent ileal mineral absorption, tibial and liver mineral concentration, and tibia quality in broilers.

Minerals play an important role for growth and bone stability in broilers. Thermal treatment and inclusion of organic acids in feed may affect the mineral absorption and tibial quality in broilers. The study was conducted to investigate the effect of thermal processing of feed including pelleting (P), long-term conditioning at 85°C (L), and expanding at 130°C (E) without and with 1.5% of an acid mixture containing 64% formic and 25% propionic acid on the apparent ileal absorption (AIA) of calcium, phosphorus, magnesium, potassium, sodium, iron, copper, manganese, and zinc, their concentrations in liver and tibia, as well as various tibial quality parameters in broilers. In total, 480 one-day-old Cobb broiler chicks were assigned using a completely randomized design with a 3 × 2 factorial arrangement. The ileal digesta, liver, and tibia were collected at d 35. The AIA of calcium and sodium was improved in group E compared with L (P ≤ 0.02 and P ≤ 0.01). Group P and E showed higher AIA for potassium than L (P ≤ 0.01). Bone ash content was increased in group E compared with L (P ≤ 0.04). The BW to bone weight ratio was lower and tibial zinc content was higher in group P compared with E (P ≤ 0.05). Tibial iron content was higher in group L than E (P ≤ 0.03). Acid addition did not affect AIA, mineral content in tibia, or tibial quality parameters. Thermal and acid treatment did not affect mineral concentrations in the liver, except an inconsistent interaction effect for DM content and sodium (P ≤ 0.03 and P ≤ 0.04, respectively). In conclusion, long-term thermal treatment reduced AIA of some minerals compared with short-term thermal treatments, but had no impact on tibia composition. Acid inclusion had no effect on AIA of minerals and tibia quality. Thermal treatment and the use of organic acids can therefore be considered as safe with regard to their impact on bone development in broilers.

The effects of different thermal treatments and organic acid levels in feed on microbial composition and activity in gastrointestinal tract of broilers.

Thermal treatments of feed and organic acids are known to affect the gastrointestinal microbiota in chickens. The present study evaluated the effect of different thermal processes including pelleting (P), long-term conditioning at 85°C for 3 min (L), expanding at 110°C (E110), and 130°C for 3 to 5 s (E130) as well as organic acid (63.75% formic acid, 25.00% propionic acid, and 11.25% water) inclusion levels (0, 0.75, and 1.5%) on gastrointestinal microbiota in broilers. In total, 960 one-day-old chicks were randomly assigned to 8 replicates using a 3 × 4 factorial arrangement. At d 35, bacterial cell numbers in the crop, ileum, and cecum, and bacterial metabolites in the crop, gizzard, ileum, and cecum were determined. The inclusion of 1.5% organic acids increased cell numbers of all clostridial clusters in the crop. The organic acid supplementation increased the propionic acid concentration in the crop and gizzard and there was a decrease in lactic acid concentration. In the ileum, the 0% organic acid group had the highest numbers of Lactobacillus spp. and enterobacteria. Inclusion of 1.5% organic acids increased ileal acetate concentration. Increasing the feed processing temperature led to an increase of lactobacilli in the crop and ileum, whereas clostridia and enterobacteria seemed unaffected. Similarly, lactate concentrations increased in the ileum, but short-chain fatty acids remained identical. In the crop, an increase for acetate was found for the E130 group compared with all other thermal treatments. In conclusion, our study demonstrated that thermal treatments and organic acid supplementation to broiler diets more markedly influenced the bacterial status of the crop compared with the downstream segments and their effects decreased along the length of gastrointestinal tract. Whereas organic acids markedly modified bacterial composition and activity in the crop, expansion increased lactobacilli and lactate in the crop and ileum.

Effect of Replacing Corn Meal with Winged Bean Tuber (Psophocarpus tetragonolobus) Pellet on Gas Production, Ruminal Fermentation, and Degradability Using In Vitro Gas Technique.

The objective of this study is to evaluate the effects of replacing corn meal in ruminant diets with winged bean (Psophocarpus tetragonolobus) tubers (WBT) on ruminal fermentation, gas production parameters, and in vitro degradability. The study employed a completely random design (CRD) in its execution. The experimental design employed was a completely randomized design (CRD), featuring eleven levels of corn meal substitution with winged bean tubers pellet (WBTP) at 0%, 10%, 20%, 30%, 40%, 50%, 60%, 70%, 80%, 90%, and 100%. The levels were grouped into four categories of replacement: control (0% in the diet), low levels (10%, 20%, and 30% in the diet), medium levels (40%, 50%, 60%, and 70% in the diet), and high levels (80%, 90%, and 100% in the diet). The experimental results indicated that substituting corn meal with WBTP at moderate and high levels in the diet could improve the performance of the fermentation process by increasing the gas production rate constant from the insoluble fraction (p < 0.01). The IVDMD exhibited a higher degree of in vitro degradation after 12 h (h), with the mean value being higher in the high group compared to the medium until the high group (p < 0.05). At the 4 h mark, the groups that substituted corn meal with WBTP exhibited a decrease in pH value (p < 0.05) in comparison to the control group. The substitution of corn meal with WBTP resulted in the lowest protozoal count after 8 h in the median group (p < 0.05). A significant difference in the effect of WBTP on total volatile fatty acid (TVFA) concentration was observed at 8 h after incubation (p < 0.05). The medium and high levels of WBTP replacement resulted in the lowest TVFA concentration at 8 h (p < 0.05). The mean proportion of acetic acid (C2) linearly declined and was lowest when a high level of WBTP replaced cornmeal (p < 0.05). The concentration of propionic acid (C3) at 8 h after incubation and average values were linearly significantly different when various levels of WBTP were utilized. Replacing corn meal with WBTP at a high level showed the highest concentration of C3. Moreover, substituting medium and high concentrations of WBTP for corn meal resulted in a significant reduction in both the C2:C3 ratio at 8 h and the mean value (p < 0.05). In conclusion, WBTP exhibits a nutritional composition that is advantageous and may be an energetic substitute for corn meal.

Pelleting and particle size reduction of corn increase net energy and digestibility of fiber, protein, and fat in corn-soybean meal diets fed to group-housed pigs.

BACKGROUND: Reduction of the particle size of corn increases energy digestibility and concentrations of digestible and metabolizable energy. Pelleting may also reduce particle size of grain, but it is not known if there are interactions between particle size reduction and pelleting. The objective of this experiment was to test the hypothesis that particle size reduction and pelleting, separately or in combination, increase N balance, apparent total tract digestibility (ATTD) of fiber and fat, and net energy (NE) in corn-soybean meal diets fed to group-housed pigs. METHODS: Six corn-soybean meal-based diets were used in a 3 × 2 factorial design with 3 particle sizes of corn (i.e., 700, 500, or 300 µm) and 2 diet forms (i.e., meal or pelleted). Pigs were allowed ad libitum access to feed and water. Twenty-four castrated male pigs (initial weight: 29.52 kg; standard diviation: 1.40) were allotted to the 6 diets using a 6 × 6 Latin square design with 6 calorimeter chambers (i.e., 4 pigs/chamber) and 6 periods. Oxygen consumption and CO2 and CH4 productions were measured during fed and fasting states and fecal and urine samples were collected. RESULTS: Regardless of particle size of corn, the ATTD of gross energy (GE), N, and acid-hydrolyzed ether extract (AEE), and the concentration of NE were greater (P < 0.05) in pelleted diets than in meal diets. Regardless of diet form, the ATTD of GE, N, and AEE, and the concentration of NE were increased (linear; P < 0.05) by reducing the particle size of corn, but the increase was greater in meal diets than in pelleted diets (interaction; P < 0.05). CONCLUSIONS: Both pelleting and reduction of corn particle size increased nutrient digestibility and NE, but increases were greater in meal diets than in pelleted diets.

Effect of the pelleting process on diet formulations with varying levels of crystalline amino acids and reducing sugars on digestibility in growing pigs.

The objective of this experiment was to determine the effects of pelleting on the standardized ileal digestibility (SID) of amino acids (AA) and crude protein (CP) in diets with or without increased concentrations of free AA and reducing sugars (RS). Eight individually housed, ileal cannulated barrows (initially 31.4 kg) were allotted to an 8 × 8 Latin square with eight diets and eight 7-d periods with ileal digesta collected on days 6 and 7. Treatments were arranged in a 2 × 2 × 2 factorial with the main effects of diet form (mash or pellet), crystalline AA (low or high), or RS (low or high), provided by distillers dried grains with solubles and bakery meal. Diets were pelleted to achieve a hot pellet temperature of 85 to 88 °C. Data were analyzed as a Latin square design using the GLIMMIX procedure of SAS 9.4. A feed form × RS interaction (P < 0.026) for SID of tryptophan was observed. Feeding pelleted low RS diets increased SID of tryptophan compared with mash high and low RS diets, and pelleted high RS diets. For the main effects of feed form, the SID of total AA, CP, and indispensable AA was greater (P < 0.042) in pelleted diets compared with mash diets. For the main effects of crystalline AA, pigs fed high crystalline AA had increased (P = 0.007) SID of tryptophan and decreased (P = 0.050) SID of histidine compared with those fed low crystalline AA diets. For the main effects of RS, high RS diets had decreased (P < 0.05) SID of total AA, CP, and indispensable AA compared with low RS diets. In conclusion, pelleting diets increased AA digestibility, and pelleting diets with increased crystalline AA or RS did not affect the improvement in AA digestibility from pelleting. Diets formulated with high crystalline AA had increased SID of tryptophan. Formulating diets with high RS resulted in decreased AA digestibility compared with corn-soybean meal-based diets.

The objective of this study was to determine the effects of pelleting on the standardized ileal digestibility (SID) of amino acids (AA) in diets with or without increased concentrations of free AA and reducing sugars (RS). Treatments were arranged in a 2 × 2 × 2 factorial with the main effects of diet form (mash or pellet), crystalline AA (low or high), or RS (low or high), provided by dried distillers grains with solubles and bakery meal. A total of 8 illeal cannulated barrows were fed treatments in an 8 × 8 Latin square design. Results indicated that there was no evidence of interactions between diet types and diet form, indicating that increasing amounts of crystalline AA and RS did not reduce amino acid digestibility when pelleting diets. Additionally, pelleting diets resulted in increased amino acid digestibility compared to mash diets. Diets formulated with 20% dried distillers grains with solubles and 15% bakery resulted in decreased amino acid digestibility compared with the corn­soybean meal-based diets. Crystalline amino acid concentration did not influence amino acid digestibility of indispensable AA, except for SID of tryptophan which was increased in diets with higher concentrations of crystalline AA.

Processing of corn-based dog foods through pelleting, baking and extrusion and their effect on apparent total tract digestibility and colonic health of adult dogs.

Different food processing parameters may alter starch granule structure and its cooking degree. With lower thermomechanical energy, more resistant starch (RS) is retained in the food, which may benefit gastrointestinal (GI) health. The objective of this study was to determine the effect of food processing on dietary utilization and dog gut health. Experimental diets containing 56% corn as the sole starch source were produced through pelleting, baking, and extrusion and compared to a baked control diet in which the corn was replaced with dextrose. The extruded diet resulted in the highest level (P < 0.05) of in vitro starch cook and lowest RS, while baked was intermediate and pelleted had the lowest starch cook and highest RS. To evaluate the in vivo effects of these treatments, 12 dogs were adapted to foods for 9 d, and feces were collected for 5 d in a replicated 4 × 4 Latin square design. Feces were scored for consistency using an ordinal scale, and parametric data included apparent digestibility (ATTD), parameters indicative of gut health, and the microbial composition, which was centered log-ratio transformed before operational taxonomic unit (OTU) analyses. Fecal scores were analyzed by ordinal logistic regression, and parametric data were analyzed as mixed models. Overall ATTD was greater (P < 0.05) in extruded, followed by baked and pelleted. Dogs fed the control had osmotic diarrhea, whereas dogs fed the other treatments had mostly acceptable fecal scores, with extrusion leading to the best fecal quality. The control also led to high fecal pH and low SCFAs, indicating dysbiosis. All corn foods had similar (P > 0.05) fecal SCFAs and extruded tended (P = 0.055) to promote higher fecal butyrate than baked and pelleted. The microbiome of dogs fed the corn foods had similar α diversity indices, and OTUs at the species and phyla levels were mostly alike and different from the control. In conclusion, the higher levels of in vitro RS did not translate into a better in vivo fermentation profile, and extruded kibble performed best regarding fecal quality, ATTD, and fecal SCFAs.

Dog foods were produced via extrusion, baking, and pelleting to yield increasing amounts of starch resistant to digestion (resistant starch [RS]). The foods were compared to a negative dextrose control that contained dextrose in place of starch. Amounts of cooked starch and RS were confirmed by in vitro methodologies. These foods were fed to healthy adult dogs in a Latin square design. Feces were scored for quality and collected to calculate apparent digestibility. Fresh feces were also collected for fecal short-chain fatty acids and microbiome evaluations. The corn-based extruded kibble was more digestible, followed by the baked and pelleted treatments. The extruded treatment produced stools closest to the ideal, but dogs fed the pelleted and baked also produced acceptable feces. The SCFA composition in the feces of dogs fed extruded was like the pelleted treatment, with a higher tendency to produce butyrate. Changes in fermentation were not a consequence of differences in microbiome composition among dogs fed corn-based foods. Dogs fed the control had osmotic diarrhea, with a higher fecal pH and higher proportions of branched-chain fatty acids, which was undesirable. The extruded food performed better overall than baked and pelleted, but they were all acceptable as food forms for dogs.

In Vitro Study of the Effect of Ensiling Length and Processing on the Nutritive Value of Maize Silages.

The effect of the ensiling length (3, 6, or 9 months), and the processing by dehydration (D) or dehydration and pelleting (P) with respect to the fresh silages (F) were studied in vitro on three maize cultivars in three incubation runs to study the effect of these factors on the nutritive value of maize silage. Gas production pattern, in vitro true digestibility (IVTD), methane concentration (6 and 12 h), ammonia, and volatile fatty acid concentration (VFA) at 12 h were measured. The moisture and pH of F averaged 676 g/kg and 4.09, respectively, and were not affected by the ensiling length, but moisture was reduced, and the pH increased in D and P with respect to F (p < 0.05). The ensiling length did not affect the chemical composition, but differences among the processing forms were detected in a higher acid detergent insoluble nitrogen (ADIN) proportion in P than D, and D than F (p < 0.001). Silages opened at 9 months showed the lowest gas production (p < 0.05), and those that opened after 3 months showed the highest IVTD. The effects of processing on nutrient utilisation only manifested on 3 month silages, with the volume of gas production and IVTD being lower in D than F. However, processing tended (p = 0.064) to reduce the methane proportion at 12 h, indicating both a more efficient fermentation and a lower potential of greenhouse gas emissions compared to the fresh silages. Extending the length of ensiling to 9 months reduced the fermentation of maize silage. The processing increased the dry matter and buffered the feed as well as contributed to an increase in fermentation in 3 month silages.