Abundance, distribution, and expression of nematicidal crystal protein genes in Bacillus thuringiensis strains from diverse habitats.

Bacillus thuringiensis (Bt) is a Gram-positive bacterium that accumulates pesticidal proteins (Cry and Cyt) in parasporal crystals. Proteins from the Cry5, App6 (formerly Cry6), Cry12, Cry13, Cry14, Cry21, and Xpp55 (formerly Cry55) families have been identified as toxic to nematodes. In this study, a total of 846 Bt strains belonging to four collections were analyzed to determine the diversity and distribution of the Bt Cry nematicidal protein genes. We analyzed their presence by PCR, and positives were confirmed by sequencing. As a result, 164 Bt isolates (20%) contained at least one gene coding for nematicidal Cry proteins. The cry5 and cry21 genes were enriched in collection 1 and were often found together in the same strain. Differently, in collection 4, obtained from similar habitats but after 10 years, cry14 was the gene most frequently found. In collection 2, cry5 and app6 were the most abundant genes, and collection 3 had a low incidence of any of these genes. The results point to high variability in the frequencies of the studied genes depending on the timing, geographical origins, and sources. The occurrence of cry1A, cry2, and cry3 genes was also analyzed and showed that the nematicidal Cry protein genes were frequently accompanied by cry1A + cry2. The expression of the genes was assessed by mass spectrometry showing that only 14% of the positive strains produced nematicidal proteins. To our knowledge, this is the first comprehensive screening that examines the presence and expression of genes from the seven known Bt Cry nematicidal families.

Enhancing insecticidal efficacy of Bacillus thuringiensis Cry1Ab through pH-sensitive encapsulation.

Nanotechnology is a promising way to enhance the stability of Bacillus thuringiensis (Bt) insecticidal proteins under environmental conditions. In this work, two emulsions were prepared through the Pickering emulsion technique, stabilized by Cu2+-SQDs/S-CN nanocomposites and by GO nanosheets. In addition, a pH-sensitive polymer was incorporated into these emulsions, allowing the Bt protein, Cry1Ab, to be released in an alkaline pH environment, as it occurs in the lepidopteran pests' gut. The effectiveness of these two nanomaterials in protecting Cry1Ab from degradation, and therefore enhancing its pesticidal activity, was assessed by exposing samples of the purified unprotected protein and encapsulated protein to high-intensity UV light and 40°C temperature treatments. The UV treatment results were evaluated using SDS-PAGE analysis and pointed out that Cry1Ab could be structurally protected by the emulsions. The bioassays with first instar larvae of the lepidopteran pest Ostrinia nubilalis confirm the nanomaterial protection to UV and temperature treatments, i.e., decreasing about half the degradation rate and increasing up to 12-fold the residual activity after UV treatment. Our results indicate that encapsulation could be an effective strategy to improve the effectiveness of Cry1Ab under environmental conditions. KEY POINTS: • Pickering emulsions are effective for solubilized Cry1Ab encapsulation. • Structural and toxicity Cry1Ab properties are enhanced by pH-sensitive encapsulation. • Cu2+-SQDs/S-CN and GO nanomaterials improve the efficacy of Bt insecticides.

Activation of Bacillus thuringiensis Cry1I to a 50 kDa stable core impairs its full toxicity to Ostrinia nubilalis.

Bacillus thuringiensis Cry1I insecticidal proteins are structurally similar to other three-domain Cry proteins, although their size, activity spectrum, and expression at the stationary phase are unique among other members of the Cry1 family. The mode of action of Cry1 proteins is not completely understood but the existence of an activation step prior to specific binding is widely accepted. In this study, we attempted to characterize and determine the importance of the activation process in the mode of action of Cry1I, as Cry1Ia protoxin or its partially processed form showed significantly higher toxicity to Ostrinia nubilalis than the fully processed protein either activated with trypsin or with O. nubilalis midgut juice. Oligomerization studies showed that Cry1Ia protoxin, in solution, formed dimers spontaneously, and the incubation of Cry1Ia protoxin with O. nubilalis brush border membrane vesicles (BBMV) promoted the formation of dimers of the partially processed form. While no oligomerization of fully activated proteins after incubation with BBMV was detected. The results of the in vitro competition assays showed that both the Cry1Ia protoxin and the approx. 50 kDa activated proteins bind specifically to the O. nubilalis BBMV and compete for the same binding sites. Accordingly, the in vivo binding competition assays show a decrease in toxicity following the addition of an excess of 50 kDa activated protein. Consequently, as full activation of Cry1I protein diminishes its toxicity against lepidopterans, preventing or decelerating proteolysis might increase the efficacy of this protein in Bt-based products. KEY POINTS: • Processing Cry1I to a 50 kDa stable core impairs its full toxicity to O. nubilalis • Partially processed Cry1Ia protoxin retains the toxicity of protoxin vs O. nubilalis • Protoxin and its final processed forms compete for the same functional binding sites.

Toxicity of five Cry proteins against the insect pest Acanthoscelides obtectus (Coleoptera: Chrisomelidae: Bruchinae).

The beetle Acanthoscelides obtectus (Say) causes severe post-harvest losses in the common bean (Phaseolus vulgaris). Under laboratory conditions, the susceptibility of A. obtectus to five coleopteran-specific Cry toxic proteins from Bacillus thuringiensis (Cry1Ba, Cry1Ia, Cry3Aa, Cry7Ab, and Cry23/37) was evaluated. After 30 days exposure, Cry proteins demonstrated high activity against A. obtectus adults (100% mortality). Proteins showed statistical differences in toxicity parameters compared to the control treatment, but the parameters were similar among them, and indicated that the final toxic effects can be observed after the 24th day. The toxic effects on A. obtectus larvae were evaluated indirectly by allowing adults to oviposit on treated beans and recording the emergence of F1 adults. All treatments resulted in a lower rate of successful emergence compared to the control treatment, ranging from 60% (Cry23/37) to 10% (Cry1Ia) reduction in eclosion. Finally, to evaluate the ability of Cry proteins to protect the beans against A. obtectus; the number of beans infested, the number of holes in each bean and bean weight loss were determined 45 days after the treatment. The parameters showed significant bean protection by all Cry proteins analyzed compared to control treatment. Cry23/37 showed the best results, however, results for the other proteins were similar. The proteins belong to different Cry protein families, which suggest that they could be used in combination to increase plant protection without compromising resistance management. Moreover, adult emergence and bean protection results indicate differences among the proteins, which may suggest different modes of action. Our results indicate that the studied Cry proteins can be applied for the control of A. obtectus larvae and adults.

Toxicity and Binding Studies of Bacillus thuringiensis Cry1Ac, Cry1F, Cry1C, and Cry2A Proteins in the Soybean Pests Anticarsia gemmatalis and Chrysodeixis (Pseudoplusia) includens.

Anticarsia gemmatalis (velvetbean caterpillar) and Chrysodeixis includens (soybean looper, formerly named Pseudoplusia includens) are two important defoliating insects of soybeans. Both lepidopteran pests are controlled mainly with synthetic insecticides. Alternative control strategies, such as biopesticides based on the Bacillus thuringiensis (Bt) toxins or transgenic plants expressing Bt toxins, can be used and are increasingly being adopted. Studies on the insect susceptibilities and modes of action of the different Bt toxins are crucial to determine management strategies to control the pests and to delay outbreaks of insect resistance. In the present study, the susceptibilities of both soybean pests to the Bt toxins Cry1Ac, Cry1Fa, Cry1Ca, and Cry2Aa have been investigated. Bioassays performed in first-instar larvae showed that both insects are susceptible to all these toxins. Competition-binding studies carried out with Cry1Ac and Cry1Fa 125-iodine labeled proteins demonstrated the presence of specific binding sites for both of them on the midgut brush border membrane vesicles (BBMVs) of both A. gemmatalis and C. includens Competition-binding experiments and specific-binding inhibition studies performed with selected sugars and lectins indicated that Cry1Ac and Cry1Fa share some, but not all, binding sites in the midguts of both insects. Also, the Cry1Ac- or Cry1Fa-binding sites were not shared with Cry1Ca or Cry2Aa in either soybean pest. This study contributes to the knowledge of Bt toxicity and midgut toxin binding sites in A. gemmatalis and C. includens and sheds light on the cross-resistance potential of Cry1Ac, Cry1Fa, Cry1Ca, and Cry2Aa Bt proteins as candidate proteins for Bt-pyramided crops.IMPORTANCE In the present study, the toxicity and the mode of action of the Bacillus thuringiensis (Bt) toxins Cry1Ac, Cry1Fa, Cry1Ca, and Cry2Aa in Anticarsia gemmatalis and Chrysodeixis includens (important defoliating pests of soybeans) have been investigated. These studies are crucial for determining management strategies for pest control. Bioassays showed that both insects were susceptible to the toxins. Competition-binding studies demonstrated the presence of Cry1Fa- and Cry1Ac-specific binding sites in the midguts of both pests. These results, together with the results from binding inhibition studies performed with sugars and lectins, indicated that Cry1Ac and Cry1Fa share some, but not all, binding sites, and that they were not shared with Cry1Ca or Cry2Aa in either soybean pest. This study contributes to the knowledge of Bt toxicity in A. gemmatalis and C. includens and sheds light on the cross-resistance potential of Cry1Ac, Cry1Fa, Cry1Ca, and Cry2Aa Bt proteins as candidate proteins for Bt-pyramided crops.

Insecticidal spectrum and mode of action of the Bacillus thuringiensis Vip3Ca insecticidal protein.

The Vip3Ca protein, discovered in a screening of Spanish collections of Bacillus thuringiensis, was known to be toxic to Chrysodeixis chalcites, Mamestra brassicae and Trichoplusia ni. In the present study, its activity has been tested with additional insect species and we found that Cydia pomonella is moderately susceptible to this protein. Vip3Ca (of approximately 90kDa) was processed to an approximately 70kDa protein when incubated with midgut juice in all tested species. The kinetics of proteolysis correlated with the susceptibility of the insect species to Vip3Ca. The activation was faster to slower in the following order: M. brassicae (susceptible), Spodoptera littoralis (moderately susceptible), Agrotis ipsilon and Ostrinia nubilalis (slightly susceptible). Processing Vip3Ca by O. nubilalis or M. brassicae midgut juice did not significantly changed its toxicity to either insect species, indicating that the low susceptibility of O. nubilalis is not due to a problem in the midgut processing of the toxin. M. brassicae larvae fed with Vip3Ca showed binding of this toxin to the apical membrane of the midgut epithelial cells. Histopathological inspection showed sloughing of the epithelial cells with further disruption, which suggests that the mode of action of Vip3Ca is similar to that described for Vip3Aa. Biotin-labeled Vip3Ca and Vip3Aa bound specifically to M. brassicae brush border membrane vesicles and both toxins competed for binding sites. This result suggests that insects resistant to Vip3A may also be cross-resistant to Vip3C, which has implications for Insect Resistance Management (IRM).

Binding analysis of Bacillus thuringiensis Cry1 proteins in the sugarcane borer, Diatraea saccharalis (Lepidoptera: Crambidae).

Sugarcane borer (Diatraea saccharalis, F.) is an important corn pest in South America and United States. The aim of the present study was to analyze the susceptibility and binding interactions of three Cry1A proteins and Cry1Fa in a Brazilian D. saccharalis population. The results showed that Cry1Ab was the most active, followed by Cry1Ac, Cry1Fa and Cry1Aa. All Cry1-biotinylated proteins tested bound specifically to the D. saccharalis brush border membrane vesicles (BBMV). Heterologous competition assays showed shared binding sites for all Cry1A proteins and another one shared by Cry1Fa and Cry1Ab. Thus, pyramiding Cry1Aa/Cry1Ac and Cry1F proteins would be a recommended strategy for managing this pest.

Shared binding sites for the Bacillus thuringiensis proteins Cry3Bb, Cry3Ca, and Cry7Aa in the African sweet potato pest Cylas puncticollis (Brentidae).

Bacillus thuringiensis Cry3Bb, Cry3Ca, and Cry7Aa have been reported to be toxic against larvae of the genus Cylas, which are important pests of sweet potato worldwide and particularly in sub-Saharan Africa. However, relatively little is known about the processing and binding interactions of these coleopteran-specific Cry proteins. The aim of the present study was to determine whether Cry3Bb, Cry3Ca, and Cry7Aa proteins have shared binding sites in Cylas puncticollis to orient the pest resistance strategy by genetic transformation. Interestingly, processing of the 129-kDa Cry7Aa protoxin using commercial trypsin or chymotrypsin rendered two fragments of about 70 kDa and 65 kDa. N-terminal sequencing of the trypsin-activated Cry7Aa fragments revealed that processing occurs at Glu(47) for the 70-kDa form or Ile(88) for the 65-kDa form. Homologous binding assays showed specific binding of the two Cry3 proteins and the 65-kDa Cry7Aa fragment to brush border membrane vesicles (BBMV) from C. puncticollis larvae. The 70-kDa fragment did not bind to BBMV. Heterologous-competition assays showed that Cry3Bb, Cry3Ca, and Cry7Aa (65-kDa fragment) competed for the same binding sites. Hence, our results suggest that pest resistance mediated by the alteration of a shared Cry receptor binding site might render all three Cry toxins ineffective.

Different binding sites for Bacillus thuringiensis Cry1Ba and Cry9Ca proteins in the European corn borer, Ostrinia nubilalis (Hübner).

Binding studies using (125)I-Cry9Ca and biotinylated-Cry1Ba proteins showed the occurrence of independent binding sites for these proteins in Ostrinia nubilalis. Our results, along with previously available binding data, indicate that combinations of Cry1A or Cry1Fa proteins with Cry1Ba and/or Cry9Ca could be a good strategy for the resistance management of O. nubilalis.

A screening of five Bacillus thuringiensis Vip3A proteins for their activity against lepidopteran pests.

Five Bacillus thuringiensis Vip3A proteins (Vip3Aa, Vip3Ab, Vip3Ad, Vip3Ae and Vip3Af) and their corresponding trypsin-activated toxins were tested for their toxicity against eight lepidopteran pests: Agrotis ipsilon, Helicoverpa armigera, Mamestra brassicae, Spodoptera exigua, Spodoptera frugiperda, Spodoptera littoralis, Ostrinia nubilalis and Lobesia botrana. Toxicity was first tested at a high dose at 7 and 10 days. No major differences were found when comparing protoxins vs. trypsin-activated toxins. The proteins that were active against most of the insect species were Vip3Aa, Vip3Ae and Vip3Af, followed by Vip3Ab. Vip3Ad was non-toxic to any of the species tested. Considering the results by insect species, A. ipsilon, S. frugiperda and S. littoralis were susceptible to Vip3Aa, Vip3Ab, Vip3Ae and Vip3Af; S. exigua was susceptible to Vip3Aa and Vip3Ae, and moderately susceptible to Vip3Ab; M. brassicae and L. botrana were susceptible to Vip3Aa, Vip3Ae and Vip3Af; H. armigera was moderately susceptible to Vip3Aa, Vip3Ae and Vip3Af, and O. nubilalis was tolerant to all Vip3 proteins tested, although it showed some susceptibility to Vip3Af. The results obtained will help to design new combinations of insecticidal protein genes in transgenic crops or in recombinant bacteria for the control of insect pests.

Draft genome sequence of Bacillus thuringiensis strain V-AB8.18, a novel isolate with potential nematicidal activity.

We report the draft genome of Bacillus thuringiensis strain V-AB8.18, comprising 308 contigs totaling 6,182,614 bp, with 35% G + C content. It contains 6,151 putative protein-coding genes, including App6 and Cry5-like crystal proteins, exhibiting 99% pairwise identity to nematicidal proteins App6Aa2 and Cry5Ba2, active against Meloidogyne incognita and Meloidogyne hapla.

Quantitative genetic analysis of Cry1Ab tolerance in Ostrinia nubilalis Spanish populations.

Tolerance to Bacillus thuringiensis Cry1Ab toxin in Spanish Ostrinia nubilalis populations was analyzed by quantitative genetic techniques, using isolines established from field-derived insects. F1 offspring was tested for susceptibility to trypsin activated Cry1Ab using a concentration that caused a mean larval mortality of 87% (±17% SD). The progeny of the most tolerant isolines (that had shown mortalities lower than 60%) was crossed to obtain the F2 generation that was exposed to the same Cry1Ab concentration. A clear reduction in mortality (62±17% SD) was observed. The upper limit for heritability was estimated to range between 0.82 and 0.90, suggesting that a high part of phenotypic variation in tolerance to Cry1Ab was attributable to genetic differences. An estimate of the minimum number of segregating factors indicated that the loci involved in tolerance to Cry1Ab were at least two. The role of the cadherin gene, which is a B. thuringiensis resistance gene in Lepidoptera, was assessed in the most tolerant isolines by using an EPIC-PCR marker specifically developed for this study. Association between cadherin and tolerance was obtained in one tolerant isoline; however it could be not confirmed by segregation analysis in the F2 progeny because F2 offspring was not viable. Our results indicate that the tolerance trait is common in Spanish field populations. Quantitative genetic techniques may be helpful for estimating the influence of genetic factors to Cry1Ab tolerance in O. nubilalis.

Insecticidal activity of Vip3Aa, Vip3Ad, Vip3Ae, and Vip3Af from Bacillus thuringiensis against lepidopteran corn pests.

Vip3Aa, Vip3Ad, Vip3Ae, and Vip3Af proteins from Bacillus thuringiensis were tested for their toxicity against Spodoptera frugiperda and Agrotis ipsilon. Vip3Ad was non-toxic to the two species. Vip3Ae and Vip3Af were significantly more toxic than Vip3Aa against S. frugiperda, both as protoxins and as toxins. Against A. ipsilon, Vip3Ae protoxin was more toxic than Vip3Aa and Vip3Af protoxins. Purification by metal-chelate affinity chromatography significantly affected Vip3Ae toxicity against the two insect species.

Mpp23Aa/Xpp37Aa Insecticidal Proteins from Bacillus thuringiensis (Bacillales: Bacillaceae) Are Highly Toxic to Anthonomus grandis (Coleoptera: Curculionidae) Larvae.

The beetle Anthonomus grandis Boheman, 1843, is the main cotton pest, causing enormous losses in cotton. The breeding of genetically modified plants with A. grandis resistance is seen as an important control strategy. However, the identification of molecules with high toxicity to this insect remains a challenge. The susceptibility of A. grandis larvae to proteins (Cry1Ba, Cry7Ab, and Mpp23Aa/Xpp37Aa) from Bacillus thuringiensis Berliner, 1915, with toxicity reported against Coleopteran, has been evaluated. The ingestion of different protein concentrations (which were incorporated into an artificial diet) by the larvae was tested in the laboratory, and mortality was evaluated after one week. All Cry proteins tested exhibited higher toxicity than that the untreated artificial diet. These Cry proteins showed similar results to the control Cry1Ac, with low toxicity to A. grandis, since it killed less than 50% of larvae, even at the highest concentration applied (100 µg·g-1). Mpp/Xpp proteins provided the highest toxicity with a 0.18 µg·g-1 value for the 50% lethal concentration. Importantly, this parameter is the lowest ever reported for this insect species tested with B. thuringiensis proteins. This result highlights the potential of Mpp23Aa/Xpp37Aa for the development of a biotechnological tool aiming at the field control of A. grandis.

Specific binding of radiolabeled Cry1Fa insecticidal protein from Bacillus thuringiensis to midgut sites in lepidopteran species.

Cry1Fa insecticidal protein was successfully radiolabeled with (125)I-Na. Specific binding to brush border membrane vesicles was shown for the lepidopteran species Ostrinia nubilalis, Spodoptera frugiperda, Spodoptera exigua, Helicoverpa armigera, Heliothis virescens, and Plutella xylostella. Homologous competition assays were performed to obtain equilibrium binding parameters (K(d) [dissociation constant] and R(t) [concentration of binding sites]) for these six insect species.

Lack of Cry1Fa binding to the midgut brush border membrane in a resistant colony of Plutella xylostella moths with a mutation in the ABCC2 locus.

Previous studies reported "mode 1" Bacillus thuringiensis resistance in a colony of diamondback moths (NO-QA), and recently, this resistance has been mapped to an ABC transporter (ABCC2) locus. We report the lack of binding of Cry1Fa to insects derived from this colony and compare our data with those from other insects with ABCC2-associated resistance.

Vip3C, a novel class of vegetative insecticidal proteins from Bacillus thuringiensis.

Three vip3 genes were identified in two Bacillus thuringiensis Spanish collections. Sequence analysis revealed a novel Vip3 protein class (Vip3C). Preliminary bioassays of larvae from 10 different lepidopteran species indicated that Vip3Ca3 caused more than 70% mortality in four species after 10 days at 4 µg/cm(2).

Susceptibility of Spodoptera frugiperda and S. exigua to Bacillus thuringiensis Vip3Aa insecticidal protein.

The Vip3Aa protein is an insecticidal protein secreted by Bacillus thuringiensis during the vegetative stage of growth. The activity of this protein has been tested after different steps/protocols of purification using Spodoptera frugiperda as a control insect. The results showed that the Vip3Aa protoxin was stable and retained full toxicity after being subjected to common biochemical steps used in protein purification. Bioassays with the protoxin in S. frugiperda and S. exigua showed pronounced differences in LC(50) values when mortality was measured at 7 vs. 10d. At 7d most live larvae were arrested in their development. LC(50) values of "functional mortality" (dead larvae plus larvae remaining in the first instar), measured at 7d, were similar or even lower than the LC(50) values of mortality at 10d. This strong growth inhibition was not observed when testing the trypsin-activated protein (62 kDa) in either species. S. exigua was less susceptible than S. frugiperda to the protoxin form, with LC(50) values around 10-fold higher. However, both species were equally susceptible to the trypsin-activated form. Processing of Vip3Aa protoxin to the activated form was faster with S. frugiperda midgut juice than with S. exigua midgut juice. The results strongly suggest that the differences in the rate of activation of the Vip3Aa protoxin between both species are the basis for the differences in susceptibility towards the protoxin form.

Effect of Cry Toxins on Xylotrechus arvicola (Coleoptera: Cerambycidae) Larvae.

The beetle Xylotrechus arvicola is a destructive pest in vineyards (Vitis vinifera) in the main wine-producing areas of the Iberian Peninsula. X. arvicola larvae bore into the grapevine wood-making galleries, thus damaging the plant both directly and indirectly; the latter through the proliferation of wood fungi, which can invade the inside of the plant, decreasing the quality and quantity of its production. The susceptibility of X. arvicola larvae to five coleopteran toxic Cry proteins (Cry1B, Cry1I, Cry3A, Cry7A, and Cry23/37) was evaluated under laboratory conditions in order to deepen the knowledge of the effect of these proteins on this insect throughout its biological development. Cry7Ab and Cry1Ba were the most effective in controlling X. arvicola larvae due to the significant reduction in larvae survival (32.9 and 25.9 days, respectively), and by causing serious alterations in the larvae during the remaining months of their development. The developmental stage of the prepupal and pupal stages was not affected by the previous ingestion of Cry proteins. The Cry proteins tested could be applied to control X. arvicola larvae since they were able to kill them and cause serious alterations in the larvae during the remaining months of development that followed. The data presented suggest that these Cry proteins can be used as bioinsecticides against the larvae of this insect, applying them only at the moment when the larvae hatch from the egg outside the grapevine wood (this would only be useful and justified if the economic threshold is exceeded) in order to avoid the rapid evolution of resistance against these toxins since not all of the larvae were killed and thus increase vine wood protection.

Increase in midgut microbiota load induces an apparent immune priming and increases tolerance to Bacillus thuringiensis.

The insect immune system is comprised of both humoral and cellular components that are mobilized in response to parasitic or pathogenic infections. Activation of the immune response implies a considerable expenditure of energy and that is why insects rely on inducible pathways that are activated after coming into contact with the pathogenic agent. Known as immune priming, insects can prolong the activation of the immune response and transmit their immune status to the next generation. Starting from a laboratory colony of the lepidopteran Spodoptera exigua and using the lytic zone assay as a measure of the immune status, we selected for a sub-colony with high levels of immune activity in the absence of external challenging with bacteria. Immune-activated insect showed characteristics that are typical reported for immune primed insects, such as increased tolerance to pathogens (Bacillus thuringiensis in our case), fitness-cost associated to the immune status, and maternal transmission of the immune status. However, additional analysis revealed that the selection for the immune-activated insects was based on the selection of insects carrying a higher bacterial load in the midgut. Our results suggest that activation of the immune system in S. exigua may not only occur as consequence of the immune priming but also from an increase in midgut microbiota load.