Optimization of cold plasma combined treatment process and its effect on the quality of Asian sea bass (Lates calcarifer) during refrigerated storage.

BACKGROUND: Cold plasma exhibits broad applicability in the realm of fish sterilization and preservation. The combination process of plasma-activated water and dielectric barrier discharge (PAW-DBD) was optimized, and its disinfection effects on bass fillets were studied. RESULTS: The best conditions for disinfection of PAW-DBD were as follows. Bass fillets were soaked in PAW for 150 s, and then treated by DBD system at 160 kV for 180 s. The total viable count (TVC) reduced by 1.68 log CFU g-1 . On the 15th day of refrigerated storage, TVC of PAW-DBD group was 7.01 log CFU g-1 , while the PAW and DBD group exhibited a TVC of 7.02 and 7.01 log CFU g-1 on day 12; the TVC of the control group was 7.13 log CFU g-1 on day 6. The sensory score, water-holding capacity, and 2-thiobarbituric acid reactive substance values of the PAW-DBD group were significantly higher than those of PAW and DBD group (P < 0.05), whereas the TVC, Pseudomonas spp. count, and pH of the group were significantly lower (P < 0.05) during refrigerated storage. CONCLUSION: PAW-DBD treatment can enhance the disinfection effect, maintain good quality, and extend the storage period of bass fillets. © 2023 Society of Chemical Industry.

Effects of Gas Composition on the Lipid Oxidation and Fatty Acid Concentration of Tilapia Fillets Treated with In-Package Atmospheric Cold Plasma.

Cold plasma (CP) is a non-thermal preservation technology that has been successfully used to decontaminate and extend the shelf life of aquatic products. However, the preservation effect of CP treatment is determined by several factors, including voltage, time, and gas compositions. Therefore, this study aimed to investigate the effects of gas composition (GasA: 10% O2, 50% N2, 40% CO2; GasB: air; GasC: 30% O2, 30% N2, 40% CO2) on the lipid oxidation of tilapia fillets treated after CP treatment. Changes in the lipid oxidation values, the percentages of fatty acids, and sensory scores were studied during 8 d of refrigerator storage. The results showed that the CP treatment significantly increased all the primary and secondary lipid oxidation values measured in this study, as well as the percentages of saturated fatty acids, but decreased the percentages of unsaturated fatty acids, especially polyunsaturated fatty acids. The lipid oxidation values were significantly increased in the GasC-CP group. After 8 d, clearly increased percentages of saturated fatty acids, a low level of major polyunsaturated fatty acids (especially linoleic (C18:2n-6)), and a decrease in the percentages of eicosapentaenoic acid (C20:5n-3) and docosahexaenoic acid (C22:6n-3) were found in GasC-CP; that is, the serious oxidation of lipids was found in the high O2 concentration group. In addition, the sensory score was also lower than that of the hypoxia CP group. Therefore, high O2 concentrations can enhance lipid oxidation and the changes in the fatty acid concentration. Controlling the O2 concentration is reasonable to limit the degree to which lipids are oxidized in tilapia after the in-package CP treatment.

Interfacial properties of ultrahigh methoxylated pectin.

The interfacial properties of ultrahigh methoxylated pectin (UHMP) prepared via esterification of citrus pectin (CP) were investigated. The intrinsic viscosity ([η]) of pectin was significantly decreased from 1211.5 mL/g to 294.9 mL/g as the degree of methylation (DM) increased from 63.18 ± 0.08% to 91.52 ± 0.11%. Surface tension (γ) analysis indicated that UHMP had a critical micelle concentration (CMC) of 0.8 g/L, which was slightly smaller than that of sugar beet pectin (SBP) (1.0 g/L). The morphology of the UHMP aggregation presented a network structure and irregular clusters at 10 µg/mL and 1 µg/mL based on atomic force microscopy (AFM). Transmission electron microscopy (TEM) observations further confirmed the self-aggregation behaviours and rod-like micelles of UHMP. The surface excess (Γ) was 1.69 ± 0.17 µmol/m2 for UHMP, which was lower than the values of SBP (1.88 ± 0.21 µmol/m2) and CP (2.91 ± 0.57 µmol/m2). Correspondingly, UHMP possessed the highest molecular area (A) of 0.99 ± 0.10 nm2. Thus, UHMP was proposed to be more flexible and extendable at the interface. The interfacial shear rheology study suggested that UHMP was able to form an elastic-dominant interfacial film to stabilize the oil/water interface.

Preclinical safety of ginsenoside compound K: Acute, and 26-week oral toxicity studies in mice and rats.

Ginsenoside compound K (CK) is a hydrolysate of ginsenosides in the soil bacteria. This study evaluated the toxicity of CK as acute and the 26-week repeated-dose. The results of acute toxicity show that CK administered orally to rats and mice did not cause mortality or toxicity at the maximum dosage of 8 g/kg and 10 g/kg, respectively. In the toxicity study for 26-week, rats were administered with CK at doses of 13, 40, or 120 mg/kg, and were observed for 26 weeks and recovery periods of four weeks. Under the conditions, asthenia, hypoactivity, loss of fur and body weight reduction were transiently noticed in males of 120 mg/kg group. Hepatotoxicity and nephrotoxicity also were evident including the elevation of liver and kidney relative weight, along with focal liver necrosis as well as the increase in plasma enzymes (ALT and ALP) in male rats receiving CK (120 mg/kg), but this toxicity might be reversible. For 13 and 40 mg/kg CK groups, there was no significant variation in food habits, clinical signs, urine analysis, body weight, biochemical and hematological values, organ coefficient and histopathology examination. The NOAEL for male and female rats were observed to be 40 and 120 mg/kg, respectively.

Ultrasound-assisted heating extraction of pectin from grapefruit peel: optimization and comparison with the conventional method.

The extraction of pectin from grapefruit peel by ultrasound-assisted heating extraction (UAHE) was investigated using response surface methodology and compared with the conventional heating extraction (CHE). The optimized conditions were power intensity of 12.56 W/cm(2), extraction temperature of 66.71°C, and sonication time of 27.95 min. The experimental optimized yield was 27.34%, which was well matched with the predicted value (27.46%). Compared with CHE, UAHE provided higher yield increased by 16.34% at the temperature lowered by 13.3°C and the time shortened by 37.78%. Image studies showed that pectin extracted by UAHE showed better color and more loosen microstructure compared to that extracted by CHE, although Fourier Transform Infrared Analysis indicated insignificant difference in their chemical structures. Furthermore, UAHE pectin possessed lower viscosity, molecular weight and degree of esterification, but higher degree of branching and purity than CHE pectin, indicating that the former was preliminarily modified during the extraction process.