Effect of chitosan type on protein and water recovery efficiency from surimi wash water treated with chitosan-alginate complexes.

Previous research has shown that soluble protein recovery by chitosan (Chi) complexes with polyanions such as alginate (Alg) is more effective than using chitosan alone. In this study, Chi-Alg complexes were used to recover soluble proteins from surimi wash water (SWW) slightly acidified to pH 6. Six Chi samples differing in molecular weight (MW) and degree of deacetylation (DD) were used at 20, 40 and 100mg/L SWW Chi-Alg complexes prepared with a Chi:Alg mixing ratio previously optimized (MR=0.2). FTIR analysis of the solids recovered revealed the three characteristic amide bands observed in the same region for untreated SWW confirming protein adsorption by Chi-Alg. The superior effectiveness of Chi complexes was confirmed but differences among chitosan types could not be correlated to MW and DD. Experimental Chi samples with 94%, 93%, 75% and 93% DD and 22, 47, 225 and 3404 x 10(3)Da, respectively, showed 73-76% protein adsorption while a commercial chitosan sample with 84% DD and 3832 x 10(3)Da had 74-83% protein adsorption. An experimental chitosan, SY-1000 with 94% DD and 1.5 x 10(6)Da, showed the highest protein adsorption (79-86%) and turbidity reduction (85-92%) when used at 20mg/L SWW.

Surimi wash water treatment for protein recovery: effect of chitosan-alginate complex concentration and treatment time on protein adsorption.

Chitosan (Chi), a protein recovery agent for the treatment of aqueous food processing streams, appears to work by mechanical entrapment and electrostatic interaction of chitosan amino groups with anionic groups on proteins. Chitosan effectiveness for recovering soluble proteins from surimi wash water (SWW) is increased by complexation with alginate (Alg) and by adjusting complex concentration and treatment time. Flocculation at 20 degrees C with Chi-Alg at a 0.2 mixing ratio added as 20, 40, 100 and 150 mg/L SWW was aided by 5 min agitation at 130 rpm and then held at the same temperature for 30 min, 1 and 24 h. Turbidity measurements, protein determinations and qualitative FTIR analysis confirmed SWW protein adsorption which depended on Chi-Alg concentration and reaction time while turbidity reduction was affected by concentration only. No differences (p < 0.05) in protein adsorption were found between 1 and 24 h. Using 100 mg Chi-Alg complex/L SWW for 1 h achieved 83% protein adsorption and 97% turbidity reduction.

A feeding study to assess nutritional quality and safety of surimi wash water proteins recovered by a chitosan-alginate complex.

Soluble proteins from surimi wash water (SWW) precipitated using a chitosan-alginate (Chi-Alg) complex and recovered by centrifugation were freeze-dried. Analysis showed that SWW proteins (SWWP) had a crude protein content of 73.1% and a high concentration of essential amino acids, for example, 3% histidine, 9.4% lysine, 3.7% methionine, and 5.1% phenylalanine. In a rat-feeding trial, SWWP as a single protein source showed higher (P < 0.05) modified protein efficiency ratio and net protein ratio than the casein control. Blood chemistry analysis revealed no deleterious effect from the full protein substitution or the chitosan in SWWP. Therefore, this preliminary study revealed that proteins recovered from SWW using the Chi-Alg complex could be used in feed formulations. They could be used for food production in countries where regulatory agencies allow the use of chitosan in the production of food ingredients.