CH4 Synthesis from CO2 and H2O of an Electron Source over Rh-Ru Cocatalysts Loaded on NaTaO3:Sr Photocatalysts.

CO2 reduction as an artificial photosynthetic system is a promising technology to produce green energies and chemicals because it uses light energy to convert H2O and CO2 into valuable products such as CO, HCOOH, CH3OH, CH4, and preferably higher hydrocarbons. In photocatalytic reduction, water should be used as hydrogen and electron sources for CO2 reduction. Moreover, CH4 formation is an attractive and challenging topic because of the eight-electron-reducing product of CO2. Herein, we report the development of a new Rh-Ru cocatalyst decorated on an alkaline earth-doped NaTaO3 surface for the photocatalytic CO2 reduction to form CH4 using water as an electron donor. CH4 was obtained by a photocatalytic "uphill" reaction of CO2 reduction using Rh-Ru cocatalyst-loaded NaTaO3:Sr, water, and CO2 in an aqueous suspension system. About 10% of a selectivity (electronic efficiency) was obtained for CH4 formation under ambient conditions accompanied with O2 evolution of the oxidation product of H2O.

CO2 Reduction Using Water as an Electron Donor over Heterogeneous Photocatalysts Aiming at Artificial Photosynthesis.

Photocatalytic and photoelectrochemical CO2 reduction of artificial photosynthesis is a promising chemical process to solve resource, energy, and environmental problems. An advantage of artificial photosynthesis is that solar energy is converted to chemical products using abundant water as electron and proton sources. It can be operated under ambient temperature and pressure. Especially, photocatalytic CO2 reduction employing a powdered material would be a low-cost and scalable system for practical use because of simplicity of the total system and simple mass-production of a photocatalyst material.In this Account, single particulate photocatalysts, Z-scheme photocatalysts, and photoelectrodes are introduced for artificial photosynthetic CO2 reduction. It is indispensable to use water as an electron donor (i.e., reasonable O2 evolution) but not to use a sacrificial reagent of a strong electron donor, for achievement of the artificial photosynthetic CO2 reduction accompanied by ΔG > 0. Confirmations of O2 evolution, a ratio of reacted e- to h+ estimated from obtained products, a turnover number, and a carbon source of a CO2 reduction product are discussed as the key points for evaluation of photocatalytic and photoelectrochemical CO2 reduction.Various metal oxide photocatalysts with wide band gaps have been developed for water splitting under UV light irradiation. However, these bare metal oxide photocatalysts without a cocatalyst do not show high photocatalytic CO2 reduction activity in an aqueous solution. The issue comes from lack of a reaction site for CO2 reduction and competitive reaction between water and CO2 reduction. This raises a key issue to find a cocatalyst and optimize reaction conditions defining this research field. Loading a Ag cocatalyst as a CO2 reduction site and NaHCO3 addition for a smooth supply of hydrated CO2 molecules as reactant are beneficial for efficient photocatalytic CO2 reduction. Ag/BaLa4Ti4O15 and Ag/NaTaO3:Ba reduce CO2 to CO as a main reduction reaction using water as an electron donor even in just water and an aqueous NaHCO3 solution. A Rh-Ru cocatalyst on NaTaO3:Sr gives CH4 with 10% selectivity (Faradaic efficiency) based on the number of reacted electrons in the photocatalytic CO2 reduction accompanied by O2 evolution by water oxidation.Visible-light-responsive photocatalyst systems are indispensable for efficient sunlight utilization. Z-scheme systems using CuGaS2, (CuGa)1-xZn2xS2, CuGa1-xInxS2, and SrTiO3:Rh as CO2-reducing photocatalyst, BiVO4 as O2-evolving photocatalyst, and reduced graphene oxide (RGO) and Co-complex as electron mediator or without an electron mediator are active for CO2 reduction using water as an electron donor under visible light irradiation. These metal sulfide photocatalysts have the potential to take part in Z-scheme systems for artificial photosynthetic CO2 reduction, even though their ability to extract electrons from water is insufficient.A photoelectrochemical system using a photocathode is also attractive for CO2 reduction under visible light irradiation. For example, p-type CuGaS2, (CuGa)1-xZn2xS2, Cu1-xAgxGaS2, and SrTiO3:Rh function as photocathodes for CO2 reduction under visible light irradiation. Moreover, introducing a conducting polymer as a hole transporter and surface modification with Ag and ZnS improve photoelectrochemical performance.

Surface defect healing in annealing from nanoporous carbons to nanoporous graphenes.

Nanoporous graphene (NPG) materials have the pronounced electrochemical stability of the seamless graphene structures developed over the 3D space. We revisited the Raman spectra of nanoporous carbons (NPCs) synthesized using θ-/γ-Al2O3 templates and NPGs converted from NPCs by annealing at 1800 °C to identify the type and density of defects. We found that both the NPCs and NPGs mostly consist of single-layered graphene with a few single vacancies and Stone-Wales defects. The density of vacancy defect per hexagon in the graphene sheet is estimated to be 10-2 for NPCs, while the annealing reduced the value to 10-3-10-4 for NPGs. This supports the outstanding chemical and electrochemical stability of the novel porous carbon materials.

Photocatalytic CO2 Reduction Using Water as an Electron Donor under Visible Light Irradiation by Z-Scheme and Photoelectrochemical Systems over (CuGa)0.5ZnS2 in the Presence of Basic Additives.

We demonstrated photocatalytic CO2 reduction using water as an electron donor under visible light irradiation by a Z-scheme photocatalyst and a photoelectrochemical cell using bare (CuGa)0.5ZnS2 prepared by a flux method as a CO2-reducing photocatalyst. The Z-scheme system employing the bare (CuGa)0.5ZnS2 photocatalyst and RGO-(CoOx/BiVO4) as an O2-evolving photocatalyst produced CO of a CO2 reduction product accompanied by H2 and O2 in a simple suspension system without any additives under visible light irradiation and 1 atm of CO2. When a basic salt (i.e., NaHCO3, NaOH, etc.) was added into the reactant solution (H2O + CO2), the CO formation rate and the CO selectivity increased. The same effect of the basic salt was observed for sacrificial CO2 reduction using SO32- as an electron donor over the bare (CuGa)0.5ZnS2 photocatalyst. The selectivity for the CO formation of the Z-schematic CO2 reduction reached 10-20% in the presence of the basic salt even in an aqueous solution and without loading any cocatalysts on the (CuGa)0.5ZnS2 metal sulfide photocatalyst. It is notable that CO was obtained accompanied by reasonable O2 evolution, indicating that water was an electron donor for the CO2 reduction. Moreover, the present Z-scheme system also showed activity for solar CO2 reduction using water as an electron donor. The bare (CuGa)0.5ZnS2 powder loaded on an FTO glass was also used as a photocathode for CO2 reduction under visible light irradiation. CO and H2 were obtained on the photocathode with 20% and 80% Faradaic efficiencies at 0.1 V vs RHE, respectively.

Z-scheme photocatalyst systems employing Rh- and Ir-doped metal oxide materials for water splitting under visible light irradiation.

Various types of Z-scheme systems for water splitting under visible light irradiation were successfully developed by employing Rh- and Ir-doped metal oxide powdered materials with relatively narrow energy gaps (EG): BaTa2O6:Ir,La (EG: 1.9-2.0 eV), NaTaO3:Ir,La (EG: 2.1-2.3 eV), SrTiO3:Ir (EG: 1.6-1.8 eV), NaNbO3:Rh,Ba (EG: 2.5 eV) and TiO2:Rh,Sb (EG: 2.1 eV), with conventional SrTiO3:Rh (an H2-evolving photocatalyst) or BiVO4 (an O2-evolving photocatalyst), and suitable electron mediators. The Z-scheme systems were classified into three groups depending on the combination of H2- and O2-evolving photocatalysts and electron mediator. The Z-scheme systems combining BaTa2O6:Ir,La with BiVO4, and NaTaO3:Ir,La with BiVO4 were active when a [Co(bpy)3]3+/2+ redox couple was used rather than an Fe3+/2+ one. The combination of SrTiO3:Ir with SrTiO3:Rh gave an activity when the [Co(bpy)3]3+/2+ and Fe3+/2+ redox couple ionic mediators were used. The Z-scheme systems combining NaNbO3:Rh,Ba and TiO2:Rh,Sb with SrTiO3:Rh showed activities by using the [Co(bpy)3]3+/2+ and Fe3+/2+ redox couples and also via interparticle electron transfer by just contact with/without reduced graphene oxide (RGO). These suitable combinations can be explained based on the impurity levels of doped Rh3+ and Ir3+ toward the redox potentials of the ionic mediators for the Z-scheme systems employing ionic mediators, and p-/n-type and onset potentials of the photocurrent in the photoelectrochemical properties of those photocatalyst materials for the Z-scheme systems working via interparticle electron transfer.

Water Splitting and CO2 Reduction under Visible Light Irradiation Using Z-Scheme Systems Consisting of Metal Sulfides, CoOx-Loaded BiVO4, and a Reduced Graphene Oxide Electron Mediator.

Metal sulfides are highly active photocatalysts for water reduction to form H2 under visible light irradiation, whereas they are unfavorable for water oxidation to form O2 because of severe self-photooxidation (i.e., photocorrosion). Construction of a Z-scheme system is a useful strategy to split water into H2 and O2 using such photocorrosive metal sulfides because the photogenerated holes in metal sulfides are efficiently transported away. Here, we demonstrate powdered Z-schematic water splitting under visible light and simulated sunlight irradiation by combining metal sulfides as an H2-evolving photocatalyst, reduced graphene oxide (RGO) as an electron mediator, and a visible-light-driven BiVO4 as an O2-evolving photocatalyst. This Z-schematic photocatalyst composite is also active in CO2 reduction using water as the sole electron donor under visible light.

Z-Schematic and visible-light-driven CO2 reduction using H2O as an electron donor by a particulate mixture of a Ru-complex/(CuGa)1-xZn2xS2 hybrid catalyst, BiVO4 and an electron mediator.

Visible-light-driven Z-schematic CO2 reduction using H2O as an electron donor was achieved using a simple mixture of a metal-sulfide/molecular hybrid photocatalyst for CO2 reduction, a water oxidation photocatalyst and a redox-shuttle electron mediator. This is the first demonstration of a highly selective particulate CO2 reduction system accompanying O2 generation utilizing a semiconductor/molecular hybrid photocatalyst.