The virucidal spectrum of a high concentration alcohol mixture.

The virucidal spectrum of a high concentration alcohol mixture (80% ethanol and 5% isopropanol) was determined for a broad series of lipid-enveloped (LE) and non-lipid-enveloped (NLE) viruses covering all relevant blood-borne viruses. LE viruses were represented by human immunodeficiency virus (HIV), bovine viral diarrhoea virus (BVDV), a specific model virus for hepatitis C virus (HCV), pseudorabies virus (PRV), and vaccinia virus. For the NLE viruses hepatitis A virus, canine parvovirus (a model for human parvovirus B19), and reovirus type 3 (Reo-3) were used. PRV, vaccinia, and Reo-3 served as general model viruses. The alcohol mixture was spiked with 5% (v/v) virus, mixed and tested for residual virus after 5 min treatment. Complete clearance (reduction by a factor of >10(6)) was observed for LE viruses, whereas incomplete to insignificant clearance (ranging from no reduction up to a maximum factor of 10(4)) was found for NLE viruses. In a second series of spiking experiments using the LE viruses BVDV, HIV, and PRV, complete clearance (reduction by a factor of >10(6)) was found after 20 s treatment. These data strongly suggest that treatment with a high concentration alcohol mixture has a high virucidal potential in particular for the blood-borne LE-viruses HIV, hepatitis B virus, and HCV. Such mixtures are well suited for rapid and frequent disinfection in dental practice being non-hazardous and non-toxic.

Virulence and immunogenicity in calves of thymidine kinase- and glycoprotein E-negative bovine herpesvirus 1 mutants.

A deletion was introduced into the thymidine kinase (TK) gene of the BHV1 strain Lam and, or, the complete coding region of the glycoprotein E (gE) gene was deleted to reduce virulence and to make serological differentiation possible. The virulence and immunogenicity of these three BHV1 mutants (TK-, gE- and TK-/gE) were studied in specific-pathogen-free calves. Although inactivation of TK strongly reduced the virulence of the Lam strain, deletion of the gE gene alone sufficed to yield complete attenuation of the Lam strain for seven-week-old calves. The three mutants induced protective immunity against disease after challenge with a virulent BHV1 strain. The reduction of virus shedding after challenge was related to the virulence of the various strains. The immunogenicity of the mutants was also evidenced by the reduction of challenge virus shedding after dexamethasone treatment. None of the mutant viruses could be isolated after dexamethasone treatment. The results demonstrate that the gE- and TK-/gE- mutants are good candidates for incorporation in a BHV1 marker vaccine.

A polymerase chain reaction (PCR) assay for the detection of bovine herpesvirus 1 (BHV1) in selectively digested whole bovine semen.

A PCR assay for the detection of bovine herpesvirus type 1 (BHV1) DNA in selectively digested whole bovine semen was developed and evaluated. A brief treatment with proteinase-K was used to lyse free virus, virus present in non-sperm cells and virus adhering to the spermatozoa. Genomic bovine DNA was not released by this treatment. Primers and probes were based on the nucleotide sequence of the gD gene. BHV1 virus-spiked split samples were used as positive controls and the PCR products were detected by eye in ethidium bromide-stained agarose gels. Sequentially collected non-extended semen samples from experimentally infected bulls were used to compare this assay with virus isolation. Of a total of 162 ejaculates, 51 were found positive by virus isolation, whereas PCR detected BHV1 DNA in 73. PCR detected BHV1 DNA for a longer period after infection and reactivation. Apart from its superior sensitivity, this PCR assay also has the advantage of being a relatively simple procedure, providing results within 24 h.

Viral safety of C1-inhibitor NF.

We studied the efficacy of virus reduction by three process steps (polyethylene glycol 4000 (PEG) precipitation, pasteurization, and 15nm virus filtration) in the manufacturing of C1-inhibitor NF. The potential prion removing capacity in this process was estimated based on data from the literature. Virus studies were performed using hepatitis A virus (HAV) and human immunodeficiency virus (HIV) as relevant viruses and bovine viral diarrhea virus (BVDV), canine parvovirus (CPV) and pseudorabies virus (PRV) as model viruses, respectively. In the PEG precipitation step, an average reduction in infectious titer of 4.5log(10) was obtained for all five viruses tested. Pasteurization resulted in reduction of infectious virus of >6log(10) for BVDV, HIV, and PRV; for HAV the reduction factor was limited to 2.8log(10) and for CPV it was zero. Virus filtration (15nm) reduced the infectious titer of all viruses by more than 4.5log(10). The overall virus reducing capacity was >16log(10) for the LE viruses. For the NLE viruses CPV and HAV, the overall virus reducing capacities were >8.7 and >10.5log(10), respectively. Based on literature and theoretical assumptions, the prion reducing capacity of the C1-inhibitor NF process was estimated to be >9log(10).

Viral safety of Nanogam, a new 15 nm-filtered liquid immunoglobulin product.

BACKGROUND AND OBJECTIVES: Producers of plasma derivatives continuously improve the viral safety of their products by, for example, introducing additional virus-reducing steps into the manufacturing process. Here we present virus-elimination studies undertaken for a number of steps employed in a new manufacturing process for liquid intravenous immunoglobulin (Nanogam) that comprises two specific virus-reducing steps: a 15-nm filtration step combined with pepsin treatment at pH 4.4 (pH 4.4/15NF); and solvent-detergent (SD) treatment. The manufacturing process also includes precipitation of Cohn fraction III and viral neutralization, which contribute to the total virus-reducing capacity of the manufacturing process. In addition, the mechanism and robustness of the virus-reducing steps were studied. MATERIALS AND METHODS: Selected process steps were studied with spiking experiments using a range of lipid enveloped (LE) and non-lipid-enveloped (NLE) viruses. The LE viruses used were bovine viral diarrhoea virus (BVDV), human immunodeficiency virus (HIV) and pseudorabies virus (PRV); the NLE viruses used were parvovirus B19 (B19), canine parvovirus (CPV) and encephalomyocarditis virus (EMC). After spiking, samples were collected and tested for residual infectivity, and the reduction factors were calculated. For B19, however, removal of B19 DNA was measured, not residual infectivity. To reveal the contribution of viral neutralization, bovine parvovirus (BPV) and hepatitis A virus (HAV) were used. RESULTS: For the pH 4.4/15NF step, complete reduction (> 6 log(10)) was demonstrated for all viruses, including B19, but not for CPV (> 3.4 but < or = 4.2 log(10)). Robustness studies of the pH 4.4/15NF step with CPV showed that pH was the dominant process parameter. SD treatment for 10 min resulted in complete inactivation (> 6 log(10)) of all LE viruses tested. Precipitation of Cohn fraction III resulted in the significant removal (3-4 log(10)) of both LE and NLE viruses. Virus-neutralization assays of final product revealed significant reduction (> or = 3 log(10)) of both BPV and HAV. CONCLUSIONS: The manufacturing process of Nanogam comprises two effective steps for the reduction of LE viruses and one for NLE viruses. In addition, the precipitation of Cohn fraction III and the presence of neutralizing antibodies contribute to the total virus-reducing capacity of Nanogam. The overall virus-reducing capacity was > 15 log(10) for LE viruses. For the NLE viruses B19, CPV and EMC, the overall virus-reducing capacities were > 10, > 7 and > 9 log(10), respectively. Including the contribution of immune neutralization, the overall virus-reducing capacity for B19 and HAV is estimated to be > 10 log(10).

Differential sensitivities of pathogens in red cell concentrates to Tri-P(4)-photoinactivation.

BACKGROUND AND OBJECTIVES: Photodynamic treatment (PDT) with the cationic porphyrin, mono-phenyl-tri-(N-methyl-4-pyridyl)-porphyrin chloride [Tri-P(4)], has previously been shown to be effective at inactivating vesicle stomatitis virus (VSV) in red cell concentrates (RCC) with limited damage to red blood cells (RBC). The aim of this study was to determine the pathogen-inactivating capacity of PDT with Tri-P(4) for a broader range of pathogens and to establish the associated effect on in vitro RBC quality. MATERIALS AND METHODS: A series of viruses and bacteria was spiked into 60% RCC. Pathogen inactivation was determined after PDT with 25 microm Tri-P(4) and red light up to 360 kJ/m2. Human immunodeficiency virus (HIV)-infected cells were evaluated for cell death induction, and RCC were analysed for the induction of haemolysis and ATP content. RESULTS: For the lipid-enveloped viruses bovine viral diarrhoea virus, HIV and pseudorabies virus, and for the Gram positive bacterium, Staphylococcus aureus, and the Gram-negative bacteria, Pseudomonas aeruginosa and Yersinia enterolitica, inactivation of > or = 5 log10 was measured after 60 min of PDT with Tri-P(4). The required treatment time to achieve this level of inactivation was four times longer than required for VSV. For cell-associated HIV, only 1.7 log10 of inactivation was found, despite clear induction of cell death of HIV-infected cells. The non-enveloped virus, canine parvovirus, was completely resistant to the treatment. PDT of RCC with Tri-P(4) for 60 min, and subsequent storage in AS-3, resulted in 4% haemolysis after 35 days of storage. The ATP content of untreated and treated RBC declined with similar kinetics during storage. CONCLUSION: PDT of RCC with Tri-P(4) for 60 min inactivates a wide range of pathogens, but not cell-associated HIV and a non-enveloped virus, and compromises RBC quality. This reduces the suitability of PDT with Tri-P(4) for red cell sterilization. Therefore, further improvements in the treatment procedures to potentiate pathogen inactivation and to preserve RBC integrity will be required to generate an effective treatment for sterilizing RCC.

Development of a rapid and sensitive polymerase chain reaction assay for detection of bovine herpesvirus type 1 in bovine semen.

We developed a polymerase chain reaction (PCR) assay to detect bovine herpesvirus type 1 (BHV-1) in bovine semen. Since bovine semen contains components that inhibit PCR amplification, a protocol was developed to purify BHV-1 DNA from bovine semen. To identify failures of PCR amplification, we used an internal control template that was coamplified by the same PCR primers. When separated fractions of BHV-1-contaminated semen were analyzed by the PCR, we found that more than 90% of the BHV-1 DNA was present in a pooled fraction consisting of seminal fluid, nonsperm cells, and virus adsorbed to spermatozoa. By using this fraction, three to five molecules of BHV-1 DNA in 50 microliters of bovine semen could be detected. A pilot study to compare this PCR assay with the routinely used virus isolation method showed that this PCR assay is 2- to 100-fold more sensitive. In addition, the results of the PCR assay are available in 1 day, whereas the virus isolation method takes 7 days. Therefore, the PCR assay may be a good alternative to the virus isolation method.

A glycoprotein E deletion mutant of bovine herpesvirus 1 infects the same limited number of tissues in calves as wild-type virus, but for a shorter period.

To gain insight into the role of glycoprotein E of bovine herpesvirus 1 (BHV-1), we compared the distribution of wild-type (wt) BHV-1 with that of a gE deletion mutant (gE-) in calves after intranasal inoculation. The wt-infected calves had severe clinical signs, but the gE(-)-infected calves were virtually free of clinical signs. At 3, 4, 7, 8, 44, 45, 50 and 51 days post-infection (p.i.), one calf from each group was killed and tissues were collected for virus isolation and PCR analysis. At 3, 4, 7 and 8 days p.i., infectious virus could be isolated only from the nasopharyngeal mucosa, parotid gland and nearby lymphoid tissues for both the wt- and gE(-)-infected calves. At 3 and 4 days p.i., virus titres in these tissues were comparable in both the wt- and gE(-)-infected calves. However, the virus titres were significantly reduced at 7 and 8 days p.i. in the gE(-)-infected calves, but not in the wt-infected calves. Semi-quantitative PCR analysis revealed that for the entire infection period (3 to 51 days p.i.) significantly more BHV-1 DNA was detected in the trigeminal ganglia (TG) of the wt-infected calves than in those of the gE(-)-infected calves. We conclude that the gE- mutant infects the same limited number of tissues as wt BHV-1, but for a shorter period.

Excretion of bovine herpesvirus 1 in semen is detected much longer by PCR than by virus isolation.

To compare the sensitivities of PCR and virus isolation and to examine the course of virus excretion in semen, we intrapreputially inoculated eight bulls with bovine herpesvirus 1 (BHV1) and used two bulls as sentinels. From these bulls, we collected a large panel of semen samples during 65 days postinfection (dpi). At 44 dpi the bulls received dexamethasone to reactivate putatively latent virus. We analyzed the semen samples by virus isolation on egg yolk-extended semen (VIE test), by virus isolation on fresh semen (VIF test), and by a PCR test on egg yolk-extended semen. Of the 162 semen samples that were collected, the VIE test scored 24 positive, the VIF test scored 51 positive, and the PCR test scored 118 positive. At 6 dpi all samples from the inoculated bulls were found to be positive by all three tests. From 9 to 44 dpi most samples were found to be negative by both virus isolation tests but positive by the PCR test. From 48 to 55 dpi the dexamethasone treatment induced virus reactivation, which was evidenced by an increase in the number of positive VIE, VIF, or PCR tests. From 58 to 65 dpi all samples were found to be negative in both virus isolation tests, but several samples were still found to be positive by the PCR test. To determine whether BHV1 DNA was present in the dorsal root ganglia of the infected bulls, we analyzed by PCR several thoracic, lumbar, and sacral ganglia collected at 65 dpi. BHV1 DNA was frequently present in the third, fourth, and fifth sacral ganglia, and semiquantitative PCR analysis showed that the highest amounts of BHV1 DNA (10 to 30 molecules of BHV1 DNA per 10(5) cells) were present in the third sacral ganglion, The results demonstrate that the PCR test detected five times as many positive semen samples as the VIE test. Hence, intrapreputially infected bulls excrete BHV1 in semen much longer than recognized until now.

Virus validation of pH 4-treated human immunoglobulin products produced by the Cohn fractionation process.

To assess the virus reducing capacity of Cohn's cold ethanol fractionation process for the production of intravenous (IVIg) and intramuscular (IMIg) immunoglobulin products, and treatment of these products at pH 4, a validation study of virus removal and/or inactivation was performed using both lipid-enveloped viruses [human immunodeficiency virus (HIV), bovine viral diarrhoea virus (BVDV) and pseudorabies virus (PSR)], and non-lipid-enveloped viruses [(simian virus 40 (SV40) and encephalomyocarditis virus (EMC)]. For the cold ethanol fractionation process, overall reduction factors of 3.0 logs, > or = 2.6 (< 5.5) logs, 4.6 logs, 5.8 logs and > or = 2.6 (< 6.2) logs were found for HIV, BVDV, PSR, SV40 and EMC, respectively. For all tested viruses the precipitation of fraction III from fraction II + III was the most effective step. From the overall reduction factors it appears that cold ethanol fractionation, although capable of reducing viral infectivity to a significant extent, is not sufficient to meet the requirements of regulatory bodies for viral safety of immunoglobulin products. However, pH 4 treatment contributes effectively to the viral safety of the final products. Treatment at pH 4.05 and 37 degrees C for 16 h, as is applied to IVIg, yields reduction factors of > or = 8.4 logs, > or = 4.0 logs, > or = 7.1 logs, 4.8 logs and 1.4 logs for HIV, BVDV, PSR, SV40 and EMC, respectively. The effectiveness of this process step could be enhanced by extending incubation to 40 h at pH 4.25 compared to 16 h at pH 4.05. The extended incubation, as applied in the production of IMIg, yields a reduction of infectivity of SV40 by > or = 5.5 (< 8.0) logs and of EMC by > or = 4.1 (< 7.1) logs. Storage of IMIg, which is formulated as a solution, at 2-8 degrees C also contributes to virus safety. For storage periods of 8 weeks or longer, reduction factors of 2 to 6 logs were found for all viruses, except for BVDV which remained unaffected. These data indicate that the production processes for IVIg and IMIg as described here have sufficient virus reducing capacity to achieve a high margin of virus safety.

A glycoprotein E deletion mutant of bovine herpesvirus 1 is avirulent in calves.

A marker vaccine elicits an antibody response in the host that can be distinguished from the antibody response induced by a wild-type strain. To obtain a bovine herpesvirus 1 (BHV-1) marker vaccine, we constructed a glycoprotein E (gE) deletion mutant. This was obtained by removing the complete gE coding region from the BHV-1 genome. To attenuate the gE deletion mutant further, we also introduced a small deletion in the thymidine kinase (TK) gene. We selected three mutants: the gE deletion mutant, a TK deletion mutant and a gE/TK double deletion mutant, and examined their virulence and immunogenicity in calves. After intranasal inoculation, the TK deletion mutant showed some residual virulence, whereas the gE and gE/TK deletion mutants were avirulent. The calves inoculated with the deletion mutants were protected against disease after challenge exposure and shed significantly less virus than control calves. Deleting the gE gene, therefore, has little effect on the immunogenicity of BHV-1, but is sufficient to reduce the virulence of BHV-1 in calves. These findings led us to conclude that the gE deletion mutant is a good candidate for a modified live BHV-1 marker vaccine.

Additive effects of dipyridamole and Trolox in protecting human red cells during photodynamic treatment.

BACKGROUND AND OBJECTIVES: Photodynamic treatment (PDT) of red blood cell (RBC) suspensions has been reported to result in virus inactivation, but also in deterioration of cell quality. Recently, we have demonstrated the potential usefulness of the reactive oxygen species scavenger dipyridamole in selectively protecting RBCs against the harmful side-effects of PDT. Unfortunately, dipyridamole-conferred protection against long-term photohaemolysis was incomplete. In the present study, dipyridamole was applied in combination with Trolox (a hydrophilic vitamin E analogue) in order to augment RBC protection. MATERIALS AND METHODS: Leucodepleted RBC suspensions (30% haematocrit) were treated with 1,9-dimethylmethylene blue (DMMB) and red light, and the effect of inclusion of dipyridamole and Trolox was assessed on potassium leakage as well as on short-term and long-term photohaemolysis. Possible interference of the scavenger cocktail with virus inactivation was examined using extracellular pseudorabies virus (PRV). RESULTS: Treatment of RBC with DMMB and red light resulted in enhanced potassium leakage and both short- and long-term haemolysis. Dipyridamole and Trolox showed additive protective effects against induction of potassium leakage and photohaemolysis, suggesting different protection mechanisms for the two scavengers. Combined inclusion of dipyridamole and Trolox did not interfere with efficacy of PRV inactivation. CONCLUSIONS: Combined inclusion of dipyridamole and Trolox results in substantially improved selectivity of photodynamic treatment of RBC suspensions.

The band III ligand dipyridamole protects human RBCs during photodynamic treatment while extracellular virus inactivation is not affected.

BACKGROUND: Recently, the potential usefulness of dipyridamole (DIP) in protecting RBCs against the harmful side effects of photodynamic sterilization was demonstrated. In the present study, the use of DIP for selective protection of RBCs was investigated under conditions more relevant for blood bank practice. STUDY DESIGN AND METHODS: WBC-reduced RBC suspensions (30% Hct) were treated with 1,9-dimethylmethylene blue and red light, and the influence of the inclusion of DIP on photohemolysis was assessed as a function of sensitizer concentration, light dose, and storage time. Furthermore, the possible interference of DIP with inactivation of extracellular virus by use of a panel of different viruses (HIV-1, pseudorabies virus [PRV], bovine viral diarrhea virus [BVDV], VSV, encephalomyocarditis, and canine parvovirus) was investigated. RESULTS: In WBC-reduced RBC suspensions (30% Hct), DIP exerted a clear protective effect against photohemolysis. Part of this protection was achieved with concentrations near the dissociation constant for band III binding. Importantly, efficiency of inactivation of extracellular HIV-1, PRV, BVDV, and VSV was not significantly impaired by the inclusion of DIP. Phototreatment conditions, resulting in a 4 to 5 log inactivation of extracellular HIV-1 and PRV, resulted in a high level of hemolysis after 28 days of storage. This long-term hemolysis could be decreased, but not completely prevented, by the inclusion of DIP. CONCLUSION: Photohemolysis in RBC concentrates can be reduced substantially by the application of DIP, while the efficacy of inactivation of HIV-1 and other viruses remains unchanged.