RESUMO
Ethanol production has increased over the years, and Brazil ranking second in the world using sugarcane as the main raw material. However, 10-15 L of vinasse are generated per liter of ethanol produced. Besides large volumes, this wastewater has high polluting potential due to its low pH and high concentrations of organic matter and nutrients. Given the high biodegradability of the organic matter, the treatment of this effluent by anaerobic digestion and membrane separation processes results in the generation of high value-added byproducts such as volatile fatty acids (VFAs), biohydrogen and biogas. Membrane bioreactors have been widely evaluated due to the high efficiency achieved in vinasse treatment. In recent years, high retention membrane bioreactors, in which high retention membranes (nanofiltration, reverse osmosis, forward osmosis and membrane distillation) are combined with biological processes, have gained increasing attention. This paper presents a critical review focused on high retention membrane bioreactors and the challenges associated with the proposed configurations. For nanofiltration membrane bioreactor (NF-MBR), the main drawback is the higher fouling propensity due to the hydraulic driving force. Nonetheless, the development of membranes with high permeability and anti-fouling properties is uprising. Regarding osmotic membrane bioreactor (OMBR), special attention is needed for the selection of a proper draw solution, which desirably should be low cost, have high osmolality, reduce reverse salt flux, and can be easily reconcentrated. Membrane distillation bioreactor (MDBR) also exhibit some shortcomings, with emphasis on energy demand, that can be solved with the use of low-grade and residual heat, or renewable energies. Among the configurations, MDBR seems to be more advantageous for sugarcane vinasse treatment due to the lower energy consumption provided by the use of waste heat from the effluent, and due to the VFAs recovery, which has high added value.
Assuntos
Saccharum , Purificação da Água , Águas Residuárias , Membranas Artificiais , Reatores Biológicos , Osmose , Biocombustíveis , Etanol , Purificação da Água/métodosRESUMO
The increase in biofuel production by 2030, driven by the targets set at the 21st United Nations Framework Convention on Climate Change (COP21), will promote an increase in ethanol production, and consequently more vinasse generation. Sugarcane vinasse, despite having a high polluting potential due to its high concentration of organic matter and nutrients, has the potential to produce value-added resources such as volatile fatty acids (VFA), biohydrogen (bioH2) and biomethane (bioCH4) from anaerobic digestion. The objective of this paper is to present a critical review on the vinasse treatment by anaerobic digestion focusing on the final products. Effects of operational parameters on production and recovery of these resources, such as pH, temperature, retention time and type of inoculum were addressed. Given the importance of treating sugarcane vinasse due to its complex composition and high volume generated in the ethanol production process, this is the first review that evaluates the production of VFAs, bioH2 and bioCH4 in the treatment of this organic residue. Also, the challenges of the simultaneous production of VFA, bioH2 and bioCH4 and resources recovery in the wastewater streams generated in flex-fuel plants, using sugarcane and corn as raw material in ethanol production, are presented. The installation of flex-fuel plants was briefly discussed, with the main impacts on the treatment process of these effluents either jointly or simultaneously, depending on the harvest season.
Assuntos
Saccharum , Anaerobiose , Biocombustíveis , Reatores Biológicos , Etanol , Ácidos Graxos VoláteisRESUMO
Anaerobic sludge granulation was evaluated in an expanded granular sludge bed (EGSB) reactor based on the increases in the specific organic loading rate (SOLR). The effect of precursor substances (calcium chloride, sodium chloride, and tannin) on the development of granular sludge was also investigated in batch reactors. The reactors were fed with synthetic sewage and operated in mesophilic conditions. The EGSB was operated with a variable hydraulic retention time (HRT) and the batch reactors, with cycles of 8â¯h and 16â¯h. The increase of SOLR from 17.4⯱â¯7.4 to 104.6⯱â¯66.7 mgCOD gVSS-1 d-1 in the EGSB resulted in an increase on the average granules diameter from 344.3 to 1583.3⯵m. These conditions also favored the reduction rates of chemical oxygen demand (COD) and volatile fatty acids (VFAs) concentration in the reactor. When the upflow velocity suffered an abrupt increase (from 0.06â¯Lâ¯h-1 to 0.25â¯Lâ¯h-1), the granules size began to decrease and lose their settleability characteristics. Considering this, it is proposed to start the biomass granulation process without effluent recirculation, and, after the granules reach the desired size and settleability capacity, the normal operation of EGSB reactor starts. The results showed that calcium chloride was more efficient for granulation. CaCl2 addition can be performed only during the reactor's start-up, improving granulation and reducing start-up time. Thus, these results have practical implications as granules maintenance is the key to the proper EGSB operation.
Assuntos
Esgotos , Eliminação de Resíduos Líquidos , Anaerobiose , Análise da Demanda Biológica de Oxigênio , Reatores BiológicosRESUMO
This paper describes a promising method to treat stabilized landfill leachate. Such method consists of a combination of chemical precipitation processes, a cost-effective technique with high potential to remove contaminants with foulant nature, microfiltration aimed at removing the produced precipitate and nanofiltration (NF) for final polishing. This study was carried out on a bench unit comprising a precipitation reactor associated with a submerged hollow-fiber microfiltration membrane module and a flat NF membrane cell operated in batch and continuous mode with a treating capacity of 0.1 L h(-1). Combining these processes yielded a clear and colorless permeate and proved to be very efficient at removing organic and inorganic matter. The results showed the importance of membrane processes to ensure treated landfill leachate quality. Also the precipitation associated with microfiltration as a pretreatment process is able to guarantee low membrane fouling due to the significant retention of humic substances which are known for their high potential to cause NF membrane fouling.
Assuntos
Recuperação e Remediação Ambiental/métodos , Filtração/métodos , Poluentes Químicos da Água/química , Precipitação Química , Recuperação e Remediação Ambiental/instrumentação , Filtração/instrumentação , Substâncias Húmicas/análiseRESUMO
Fertigation using sugarcane vinasse is expected in the sugar and alcohol industries; however, its indiscriminate practice can trigger soil salinization and contamination of water sources. This review article appraises the vinasse use as a precursor material in producing organo-mineral fertilizers. Vinasse use could be an alternative for the increased demand for organo-mineral fertilizers. In that case, the vinasse reuse would be maintained but through controlled practices and lower environmental impact. The state-of-art points to possible advantages associated with the vinasse conversion into organo-mineral fertilizers, such as ease of transport and handling, low variability in its composition, and lower risks of soil and water resources contamination. It has been summarized and critically discussed the past ten years (2011-2021, total number papers revised: 175) of research data about vinasse composition, along with the limitations to be overcome in the near future to enable the application of organo-mineral fertilizers. Possible nutrients supplementation beyond those already present in vinasse composition would depend on the crop requirement, and the impact on the soil biota and integrity should be better understood. The aspects discussed along the manuscript would be aligned with circular economy principles, converting a residue (vinasse) into a potential resource for agricultural activities, including sugar and alcohol industries. After all, although promising, obtaining organo-mineral fertilizers from vinasse must be empirically validated and its feasibility proven by comparative studies between fertigation and the use of organo-mineral fertilizers.
Assuntos
Fertilizantes , Saccharum , Agricultura , Fertilizantes/análise , Minerais , Saccharum/química , Solo/química , AçúcaresRESUMO
The aim of this study was to evaluate the nanofiltration process as a polishing step of a membrane bioreactor inoculated with commercial baker yeast (Saccharomyces cerevisiae) used to treat sanitary landfill leachate. The contaminants retention and influence of concentration polarization and fouling phenomena on the permeate flux decline (FD) at different operating pressures were analysed. The greatest total flux reductions of 63.57% and 70.83% were observed for the lowest and the highest pressures, respectively, being this reduction attributed mainly to the concentration polarization. Membrane itself and concentration polarization phenomena were the main resistances to the nanofiltration process. Hermia model adjustment to the experimental data revealed that cake formation was the main mechanism that explained the FD at pressures of 8, 10 and 12 bar. At recovery rates above 40%, there was a significant decrease in permeate quality, so this value was chosen as the viable value for the proposed system. Integrated MBR-nanofiltration system led to the high removal of pollutants and made the treated effluent feasible for reuse in the landfill itself.
Assuntos
Poluentes Químicos da Água , Reatores Biológicos , Filtração , Membranas Artificiais , Saccharomyces cerevisiaeRESUMO
This study compares the performance of the membrane bioreactor (MBR) inoculated with commercial baker's yeast (Saccharomyces cerevisiae) (MBRy) versus one inoculated with bacterial sludge (MBRb) for treatment of landfill leachate. The MBRb and MBRy were operated with a hydraulic retention time of 48â h, solids retention time of 60â d, and specific air demand based on membrane area of 0.6â m3â h-1â m-2. The MBRy was more efficient in removing chemical oxygen demand (COD) (68 ± 12%), color (79 ± 8%), ammoniacal nitrogen (58 ± 18%), and phosphorus (62 ± 19%) compared to MBRb, which showed removal efficiencies of 44 ± 18%, 46 ± 20%, 45 ± 17%, and 29 ± 15% for COD, color, ammoniacal nitrogen, and phosphorus. Furthermore, the MBRy had lower production of soluble microbial products, which are the main cause of membrane fouling, and so a lower membrane fouling potential. The average hydraulic permeability of the MBRy (32.23â Lâ m-2â h-1â bar-1) was about four times higher than that of the MBRb (8.34â Lâ m-2â h-1â bar-1). Thus using commercial baker's yeasts as a MBR inoculum can enhance pollutants' removal and membrane performance.
Assuntos
Reatores Biológicos , Saccharomyces cerevisiae , Purificação da Água , Bactérias , Análise da Demanda Biológica de Oxigênio , Membranas Artificiais , Nitrogênio , Poluentes Químicos da ÁguaRESUMO
Vinasse is the main liquid waste from ethanol production, and it has a considerable pollution potential. Biological treatment is a promising alternative to reduce its organic load. The aim of this study was to analyze the biodegradation of sugarcane juice vinasse in aerobic and anaerobic conditions. The content of carbohydrates, proteins and volatile fatty acids was evaluated. Vinasse samples showed a high biodegradability (>96.5 %) and low percentage of inert chemical oxygen demand (COD) (<3.2 %) in both aerobic and anaerobic conditions. The rates of substrate utilization were slightly higher in aerobic reactors, but COD stabilization occurred simultaneously in the anaerobic reactors, confirming its suitability for anaerobic digestion. Inert COD in anaerobic conditions was lower than in aerobic conditions. On the other hand, COD from metabolic products in the anaerobic reactors was higher than in the aerobic ones, indicating an increased release of soluble microbial products (SMPs) by anaerobic microorganisms. The results indicated that carbohydrates were satisfactorily degraded and protein-like substances were the major components remaining after biological degradation of vinasse.