Troubleshooting high laboratory pasteurization counts in organic raw milk requires characterization of dominant thermoduric bacteria, which includes nonsporeformers as well as sporeformers.

Laboratory pasteurization count (LPC) enumerates thermoduric bacteria and is one parameter used to assess raw milk quality. No regulatory limit has presently been set for LPC, but LPC data are used by some dairy processors and cooperatives to designate raw milk quality premiums paid to farmers and may also be used for troubleshooting bacterial contamination issues. Although it is occasionally used as a proxy for levels of bacterial spores in raw milk, limited knowledge is available on the types of organisms that are enumerated by LPC in contemporary raw milk supplies. Although historical studies have reported that thermoduric bacteria quantified by LPC may predominantly represent gram-positive cocci, updated knowledge on microbial populations enumerated by LPC in contemporary organic raw milk supplies is needed. To address this gap, organic raw milk samples from across the United States (n = 94) were assessed using LPC, and bacterial isolates were characterized. LPC ranged from below detection (<0.70 log cfu/mL) to 4.07 log cfu/mL, with a geometric mean of 1.48 log cfu/mL. Among 380 isolates characterized by 16S rDNA sequencing, 52.6%, 44.5%, and 2.4% were identified as gram-positive sporeformers, gram-positive nonsporeformers, and gram-negatives, respectively; 0.5% could not be categorized into those groups because they could only be assigned a higher level of taxonomy. Isolates identified as gram-positive sporeformers were predominantly Bacillus (168/200), and gram-positive nonsporeformers were predominantly Brachybacterium (56/169) and Kocuria (47/169). To elucidate if the LPC level can be an indicator of the type of thermoduric (e.g., sporeforming bacteria) present in raw milk, we evaluated the proportion of sporeformers in raw milk samples with LPC of ≤100 cfu/mL, 100 to 200 cfu/mL, and ≥200 cfu/mL (51%, 67%, and 35%), showing a trend for sporeformers to represent a smaller proportion of the total thermoduric population when LPC increases, although overall linear regression showed no significant association between the proportion of sporeformers and the LPC concentration. Hence, LPC level alone provides no insight into the makeup of the thermoduric population in raw milk, and further characterization is needed to elucidate the bacterial drivers of elevated LPC in raw milk. We therefore further characterized the isolates from this study using MALDI-TOF mass spectrometry (MALDI-TOF MS), a rapid microbial identification tool that is more readily available to dairy producers than 16S rDNA PCR and sequencing. Although our data indicated agreement between 16S rDNA sequencing and MALDI-TOF MS for 66.6% of isolates at the genus level, 24.2% and 9.2% could not be reliably identified or were mischaracterized using MALDI-TOF MS, respectively. This suggests that further optimization of this method is needed to allow for accurate characterization of thermoduric organisms commonly found in raw milk. Ultimately, our study provides a contemporary perspective on thermoduric bacteria selected by the LPC method and establishes that the LPC alone is not sufficient for identifying the bacterial drivers of LPC levels. Further development of rapid characterization methods that are accessible to producers, cooperatives, and processors will support milk quality troubleshooting efforts and ultimately improve outcomes for dairy industry community members.

Low-cost, on-farm intervention to reduce spores in bulk tank raw milk benefits producers, processors, and consumers.

Bacterial spores, which are found in raw milk, can survive harsh processing conditions encountered in dairy manufacturing, including pasteurization and drying. Low-spore raw milk is desirable for dairy industry stakeholders, especially those who want to extend the shelf life of their product, expand their distribution channels, or reduce product spoilage. A recent previous study showed that an on-farm intervention that included washing towels with chlorine bleach and drying them completely, as well as training milking parlor employees to focus on teat end cleaning, significantly reduced spore levels in bulk tank raw milk. As a follow up to that previous study, here we calculate the costs associated with that previously described intervention as ranging from $9.49 to $13.35 per cow per year, depending on farm size. A Monte Carlo model was used to predict the shelf life of high temperature, short time fluid milk processed from raw milk before and after this low-cost intervention was applied, based on experimental data collected in a previous study. The model predicted that 18.24% of half-gallon containers of fluid milk processed from raw milk receiving no spore intervention would exceed the pasteurized milk ordinance limit of 20,000 cfu/mL by 17 d after pasteurization, while only 16.99% of containers processed from raw milk receiving the spore intervention would reach this level 17 d after pasteurization (a reduction of 1.25 percentage points and a 6.85% reduction). Finally, a survey of consumer milk use was conducted to determine how many consumers regularly consume fluid milk near or past the date printed on the package (i.e., code date), which revealed that over 50% of fluid milk consumers surveyed continue to consume fluid milk after this date, indicating that a considerable proportion of consumers are exposed to fluid milk that is likely to have high levels spore-forming bacterial growth and possibly associated quality defects (e.g., flavor or odor defects). This further highlights the importance of reducing spore levels in raw milk to extend pasteurized fluid milk shelf life and thereby reducing the risk of adverse consumer experiences. Processors who are interested in extending fluid milk shelf life by controlling the levels of spores in the raw milk supply should consider incentivizing low-spore raw milk through premium payments to producers.

Milking time hygiene interventions on dairy farms reduce spore counts in raw milk.

Spore-forming bacteria, such as Paenibacillus spp. and Bacillus spp., can survive HTST pasteurization in spore form and affect the quality of dairy products (e.g., spoilage in fluid milk). With the demand for higher quality finished products that have longer shelf lives and that can be distributed further and to new markets, dairy processors are becoming interested in obtaining low-spore raw milk supplies. One method to reduce spores in the dairy system will require disrupting the transmission of spores from environmental locations, where they are often found at high concentrations (e.g., manure, bedding), into bulk tank raw milk. Previous research has suggested that cow hygiene factors (e.g., udder hygiene, level of spores in milk from individual cows) are important for the transmission of spores into bulk tank raw milk, suggesting that one potential strategy to reduce spores in bulk tank milk should target cow hygiene in the parlor. To that end, we conducted a study on 5 New York dairy farms over a 15-mo period to evaluate the effect of a combination of intervention strategies, applied together, on the levels of aerobic spores in bulk tank raw milk. The combination of interventions included (1) training milking staff to focus on teat-end cleaning during milking preparation, and (2) implementing changes in laundered towel preparation (i.e., use of detergent, chlorine bleach, and drying). Study design involved collecting bulk tank raw milk samples for a week before and a week after initiating the combination of interventions (i.e., training on the importance of teat-end cleaning and towel treatment). Observations on teat-end condition, udder hygiene scores, and number of kickoffs during milking were also collected for 24 h before and after implementation of the interventions. A total of 355 bulk tank raw milk samples were collected with mean mesophilic and thermophilic spore counts of 2.1 and 2.4 cfu/mL, respectively, before interventions were applied, and 1.6 and 1.5 cfu/mL, respectively, after the interventions were applied. These reductions represent decreases of 37 and 40% in bulk tank raw milk mesophilic spores and thermophilic spores, respectively. Importantly, spore reductions were observed during each of the 3 visits once the interventions were applied, and the largest reduction in spores was recorded for the first sampling after training the milking staff. Further, when a higher proportion of very rough teat ends was observed, bulk tank milk thermophilic spore counts were significantly higher. The intervention strategies tested here represent easy-to-execute cleaning strategies (e.g., focusing on teat-end hygiene and towel washing procedures) that can reduce bulk tank raw milk spore levels. Future studies should validate the effect of on-farm interventions for reduced spore raw milk on corresponding processed product quality and will need to verify the effects of these small changes on product shelf life.

Bacterial spore levels in bulk tank raw milk are influenced by environmental and cow hygiene factors.

Sporeforming bacteria are responsible for the spoilage of several dairy products including fluid milk, cheese, and products manufactured using dried dairy powders as ingredients. Sporeforming bacteria represent a considerable challenge for the dairy industry because they primarily enter the dairy product continuum at the farm, survive processing hurdles, and subsequently grow in finished products. As such, strategies to reduce spoilage due to this group of bacterial contaminants have focused on understanding the effect of farm level factors on the presence of spores in bulk tank raw milk with the goal of reducing spore levels in raw milk, as well as understanding processing contributions to spore levels and outgrowth in finished products. The goal of the current study was to investigate sources of spores in the farm environment and survey farm management practices to identify variables using multimodel inference, a model averaging approach that eliminates the uncertainty of traditional model selection approaches, that affect the presence and levels of spores in bulk tank raw milk. To this end, environmental samples including feed, bedding, manure, soil, water, and so on, and bulk tank raw milk were collected twice from 17 upstate New York dairy farms over a 19-mo period and the presence and levels of various spore types (e.g., psychrotolerant, mesophilic, thermophilic, highly heat resistant thermophilic, specially thermoresistant thermophilic, and anaerobic butyric acid bacteria) were assessed. Manure had the highest level of spores for 4 out of 5 aerobic spore types with mean counts of 5.87, 5.22, 4.35, and 3.68 log cfu/g of mesophilic, thermophilic, highly heat resistant thermophilic, and specially thermoresistant thermophilic spores, respectively. In contrast, bulk tank raw milk had mean spore levels below 1 log cfu/mL across spore types. Multimodel inference was used to determine variables (i.e., management factors, environmental spore levels, and meteorological data from each sampling) that were important for presence or levels of each spore type in bulk tank raw milk. Analyses indicated that variables of importance for more than one spore type included the residual level of spores in milk from individual cows after thorough teat cleaning and forestripping, udder hygiene, clipping or flaming of udders, spore level in feed commodities, spore level in parlor air, how often bedding was topped up or changed, the use of recycled manure bedding, and the use of sawdust bedding. These results improve our understanding of how spores transfer from environmental sources into bulk tank raw milk and provide information that can be used to design intervention trials aimed at reducing spore levels in raw milk.

A century of gray: A genomic locus found in 2 distinct Pseudomonas spp. is associated with historical and contemporary color defects in dairy products worldwide.

Some gram-negative bacteria, including Pseudomonas spp., can grow at refrigeration temperatures and cause flavor, odor, and texture defects in fluid milk. Historical and modern cases exist of gray and blue color defects in fluid milk due to Pseudomonas, and several recent reports have detailed fresh cheese spoilage associated with blue-pigment-forming Pseudomonas. Our goal was to investigate the genomes of pigmented Pseudomonas isolates responsible for historical and modern pigmented spoilage of dairy products in the United States to determine the genetic basis of pigment-forming phenotypes. We performed whole genome sequencing of 9 Pseudomonas isolates: 3 from recent incidents of gray-pigmented fluid milk (Pseudomonas fluorescens group), 1 from blue-pigmented cheese (P. fluorescens group), 2 from a historical blue milk spoilage incident (Pseudomonas putida group), and 3 with no evidence for blue or gray pigment formation (2 from P. fluorescens group and 1 from Pseudomonas chlororaphis group). All 6 isolates collected from products with a gray or blue pigment defect were confirmed to produce pigment using potato dextrose agar or pasteurized milk. A subset of 2 isolates was selected for inoculation into milk and onto the surface of a model cheese for subsequent color measurement. These isolates produced different colors on potato dextrose agar, but produced nearly identical color defects in milk and on model cheese. For the same subset of 2 isolates, the gray color defect in milk was produced only in containers with ample headspace and not in full containers, suggesting that oxygen is vital for pigment formation. This work also demonstrated that a Pseudomonas isolate from cheese can produce a pigment defect in milk, and vice versa. Comparative genomics identified an accessory locus encoding tryptophan biosynthesis genes that was present in all isolates that produced gray or blue pigment under laboratory conditions and was only previously reported in 2 P. fluorescens isolates responsible for blue mozzarella in Italy. Because this locus was found in genetically distant isolates belonging to different Pseudomonas species groups, it may have been acquired via horizontal gene transfer. These data suggest that several past and present gray- or blue-pigmented dairy spoilage events share a common genetic etiology that transcends species-level identification and merits further investigation to determine mechanistic details and modes of prevention.

Short communication: Pseudomonas azotoformans causes gray discoloration in HTST fluid milk.

Pseudomonas species are well recognized as dairy product spoilage organisms, particularly due to their ability to grow at refrigeration temperatures. Although Pseudomonas-related spoilage usually manifests itself in flavor, odor, and texture defects, which are typically due to production of bacterial enzymes, Pseudomonas is also reported to cause color defects. Because of consumer complaints, a commercial dairy company shipped 4 samples of high temperature, short time (HTST)-pasteurized milk with distinctly gray colors to our laboratory. Bacterial isolates from all 4 samples were identified as Pseudomonas azotoformans. All isolates shared the same partial 16S rDNA sequence and showed black pigmentation on Dichloran Rose Bengal Chloramphenicol agar. Inoculation of one pigment-producing P. azotoformans isolate into HTST-pasteurized fluid milk led to development of gray milk after 14 d of storage at 6°C, but only in containers that had half of the total volume filled with milk (∼500 mL of milk in ∼1,000-mL bottles). We conclusively demonstrate that Pseudomonas can cause a color defect in fluid milk that manifests in gray discoloration, adding to the palette of color defects known to be caused by Pseudomonas. This information is of considerable interest to the dairy industry, because dairy processors and others may not typically associate black or gray colors in fluid milk with the presence of microbial contaminants but rather with product tampering (e.g., addition of ink) or other inadvertent chemical contamination.