RESUMO
The aim of the present study is to investigate the effect of κ-casein B content in milk on the yield of high-moisture mozzarella cheese. The study was carried out by monitoring the production of eight mozzarella cheese batches at four cheese making factories. At each factory, two cheese making trials were performed in parallel: one using bulk milk from Italian Brown cattle and the other using bulk milk from Italian Friesian cattle. The average κ-casein B content was 0.04 g per 100 g in the Italian Friesian cows' milk, whereas it was four time higher in the Italian Brown cows' milk, reaching values of 0.16 g per 100 g. Both the κ-casein content and κ-casein B to casein ratio were positively correlated with actual cheese yield. Both parameters showed correlation coefficient values over 0.9, higher than for any other protein fraction. The influence of the level of κ-casein on the increase of the yield is probably due to smaller and more homogeneous micelles, with more efficient rennet coagulation. Consequently, milk with higher κ-casein B content produces a more elastic curd that withstands better the technological treatments and limits losses during curd mincing and stretching. In conclusion, the Italian Brown cows' milk used, characterized by higher κ-casein content than the Italian Friesian's one, allowed a yield increase of about 2.65%, which is a very relevant result for both farms and cheese making factories.
RESUMO
Italian hard cooked types of cheese, like Parmigiano Reggiano and Grana Padano, are characterised by positive nutritional qualities. In fact, they contain substances that have particular biological activities, and therefore they can be fully considered, according to the definition given by the European Unit, as 'functional' foods. This short review concisely describes these components and the beneficial effects related to their activities. The description of the biologically active components has been organised in the following paragraphs: protein and peptides, fat and lipids, carbohydrates and prebiotics, probiotic bacteria, vitamins, mineral salts, and components of dairy products active in disease prevention. In particular, several known bioactive peptides were found in Parmigiano Reggiano cheese samples: for example, phosphopeptides, which are known for their mineral-binding capacity and vehiculation activity, peptides with immunomodulatory activity, and angiotensin-converting enzyme-inhibitory peptides with anti-hypertensive effects. Among lipids, the role of conjugated linoleic acid and other fatty acids present in these cheese types was taken into consideration. The presence of oligosaccharides with prebiotic properties and probiotic bacteria was also described. Finally, particular emphasis was given to highly available calcium and its impact on bone health.
RESUMO
The aim of this study was to determine the influence of the somatic cell content (SCC) of milk on Parmigiano-Reggiano cheese yield, produced in commercial cheese factories under field conditions. The study was carried out following the production of 56 batches of Parmigiano-Reggiano in 13 commercial cheese factories by processing milk collected from Italian Friesian cattle herds. The vat-milk (V-milk) used for making each cheese batch was obtained by mixing evening milk (partially skimmed following spontaneous separation of fat overnight, natural creaming) and morning milk. The batches of cheese produced were divided into 5 classes according to the SCC value of the evening milk determined prior to natural creaming (class 1, from 0 to 200,000; 2, 201,000-300,000; 3, 301,000-400,000; 4, 401,000-500,000; 5, over 501,000 cells/ml). The cheese yield was calculated as the amount of 24-h cheese, expressed in kilograms, obtained from 100 kg of V-milk (24 h ACY). The values of fat, crude protein, true protein, casein and 24 h ACY of V-milk were negatively correlated with the somatic cell score (SCS) of the evening milk. Conversely, a positive correlation was observed between chloride and SCS. Fat, protein fractions (crude protein, casein and whey proteins), P and titratable acidity of V-milk were positively correlated with its 24 h ACY, while chloride, pH and SCS showed a negative correlation. A significant drop in 24 h ACY was observed in classes 3, 4 and 5, therefore when the SCC of the evening milk exceeded 300,000 cells/ml. Finally a lower recovery of milk fat in cheese was observed as SCC of evening milk increase.
Assuntos
Bovinos , Queijo/análise , Leite/citologia , Animais , Feminino , Manipulação de AlimentosRESUMO
The main requirement for milk processed in most cheese typologies is its rennet coagulation ability. Despite the increasing number of studies, the causes for abnormal coagulation of milk are not fully understood. The aim of this study was to ascertain relationships between milk characteristics and its rennet coagulation ability, focusing on the influence of calcium (Ca) and phosphorus (P). Ca and P are essential constituents of the micelles. Micellar P can be present as part of colloidal calcium phosphate (inorganic-P) or covalently bound to caseins as phosphate groups (casein-P). Eighty one herd milk samples (SCC<400 000 cell/ml) were classified as Optimal (8), Suboptimal (39) Poor (29) and Non-coagulating milk (5), according to their rennet coagulation parameters as assessed by lactodynamographic test. Samples were analysed for their chemical composition (basic composition, protein fractions, minerals and salt equilibria), physicochemical parameters (pH and titratable acidity) and rheological properties. Optimal milk was characterised by the highest contents of major constituents, protein fractions and minerals, lowest content of chloride and highest values of titratable acidity. Non-coagulating milk was characterised by the highest values of pH and the lowest of titratable acidity. At micellar level, Optimal milk showed the highest values of colloidal Ca, casein-P and colloidal Mg (g/100 g casein), while Non-coagulating milk showed the lowest values. Interestingly, there was no statistical difference regarding the content of colloidal inorganic-P (g/100 g casein) between Optimal and Non-coagulating milks. Overall, high mineralisation of the micelle (expressed as g inorganic-P/100 g casein) positively affect its rennetability. However, excessive mineralisation could lead to a reduction of the phosphate groups (g casein-P/100 g casein) available for curd formation.
Assuntos
Cálcio/análise , Quimosina/metabolismo , Leite/efeitos dos fármacos , Leite/enzimologia , Fósforo/análise , Animais , Cálcio/fisiologia , Fosfatos de Cálcio/análise , Fosfatos de Cálcio/química , Caseínas/análise , Caseínas/química , Bovinos , Queijo , Fenômenos Químicos , Coloides/química , Concentração de Íons de Hidrogênio , Magnésio/análise , Micelas , Leite/química , Proteínas do Leite/análise , Fósforo/fisiologia , ReologiaRESUMO
The dairy industry is confronting a major challenge that could profoundly affect its future and its long-standing role as a cornerstone of human nutrition [...].
RESUMO
Mare milk is consumed by approximatively 30 million people in the world. In countries in Asia and East Europe, mare milk is mainly consumed as source of fermented products, called koumiss, airag or chigee, alcoholic beverages obtained by means of a culture of bacteria and lactose-fermenting yeasts. Recent research concerning mare milk and its derivatives deals mainly with their potential employment for human health. Studies about the isolation and characterization of Lactobacillus spp. and yeasts from koumiss have been aimed at assessing the potential functional properties of these micro-organisms and to find their employment for the industrial processing of mare milk. The aim of this literature review is to summarize recent research about microorganisms in fermented mare milk products and their potential functional properties.
RESUMO
This research was aimed to assess the distribution of calcium, phosphorus and magnesium within the casein micelles of yak milk. To this aim, nine bulk yak milk samples (Y-milk), collected in three yak farms located in the Chinese province of Qinghai, were compared to nine bulk cow milk samples used as a reference. A quite similar content of colloidal calcium (0.80 vs. 0.77 mmol/g of casein; p > 0.05), a higher content of magnesium (0.05 vs. 0.04 mmol/g of casein; p ≤ 0.01) and a lower content of colloidal phosphorus (0.48 vs. 0.56 mmol/g of casein; p ≤ 0.01) between yak and cow casein micelles were found. Moreover, the yak casein micelles showed a lower value of prosthetic phosphorus (0.20 vs. 0.26 mmol/g of casein; p ≤ 0.05) compared to the cow micelles. The lower values of colloidal and prosthetic phosphorus in yak casein micelles suggest that the yak casein is less phosphorylated than the cow one.
RESUMO
OBJECTIVE: The aim was to study the influence of cooling milk at 9°C at the farm versus keeping it at 20°C on Parmigiano Reggiano cheese lipolysis. METHODS: A total of six cheesemaking trials (3 in winter and 3 in summer) were performed. In each trial, milk was divided continuously into two identical aliquots, one of which was kept at 9°C (MC9) and the other at 20°C (MC20). For each trial and milk temperature, vat milk (V-milk) and the resulting 21 month ripened cheese were analysed. RESULTS: Fat and dry matter and fat/casein ratio were lower in MC9 V-milk (p≤0.05) than in MC20. Total bacteria, mesophilic lactic acid and psychrotrophic and lipolytic bacteria showed significant differences (p≤0.05) between the two V-milks. Regarding cheese, fat content resulted lower and crude protein higher (p≤0.05) both in outer (OZ) and in inner zone (IZ) of the MC9 cheese wheels. Concerning total fatty acids, the MC9 OZ had a lower concentration of butyric, capric (p≤0.05) and medium chain fatty acids (p≤0.05), while the MC9 IZ had lower content of butyric (p≤0.05), caproic (p≤0.01) and short chain fatty acids (p≤0.05). The levels of short chain and medium chain free fatty acids (p≤0.05) were lower and that of long chain fatty acids (p≤0.05) was higher in MC9 OZ cheese. The principal component analysis of total and free fatty acids resulted in a clear separation among samples by seasons, whereas slight differences were observed between the two different milk temperatures. CONCLUSION: Storing milk at 9°C at the herd affects the chemical composition of Parmigiano Reggiano, with repercussion on lipolysis. However, the changes are not very relevant, and since the cheese can present a high variability among the different cheese factories, such changes should be considered within the "normal variations" of Parmigiano Reggiano chemical characteristics.
RESUMO
Parmigiano Reggiano is a Protected Designation of Origin (PDO) cheese whose official production protocol provides that milk cannot be stored at less than 18 °C at the farm. The possibility of refrigerating milk at the farm is highly debated, since it should allow for the limiting of bacterial growth, thus improving the quality of the cheese. The present research aimed to study the influence of storing the milk at 9 °C on the chemical composition and proteolysis during the ripening of Parmigiano Reggiano cheese. The experimentation considered six cheese-making trials, in which both evening and morning milks were subdivided into two parts that were maintained at 9 and 20 °C. After Parmigiano Reggiano cheese-making, one of the twin wheels obtained was analyzed after 21 months of ripening. From each cheese, two different samples were taken, one from the inner zone, and the other from the outer zone. The results of the chemical analyses evidenced that milk storage at 9 °C significantly (p ≤ 0.05) influenced fat, crude protein, soluble nitrogen and peptone nitrogen contents. Nevertheless, the differences observed with respect to the cheese obtained with milk stored under standard condition were very small and should be considered within the "normal variations" of Parmigiano Reggiano chemical characteristics.
RESUMO
Parmigiano Reggiano is a hard PDO cheese made from bovine raw milk, whose microbiological characteristics have important repercussions on cheese quality. According to the EU official production protocol, milk temperature at the farm must not drop below 18 °C. The present research aimed to study the effect of cooling milk at the farm at 9 °C on the characteristics of milk and on the cheesemaking process and losses during manufacture. Six cheesemaking trials were performed in two different dairies. In each of them, two cheesemakings were made in parallel: one with milk kept at 9 °C (TM9) and the other with milk kept at 20 °C (TM20). TM9 milk, in comparison with TM20, showed after the creaming process a significant reduction not only of total bacterial count but also of psychrotrophic and lipolytic bacteria. At the same time, TM9 milk showed a higher creaming capacity and, consequently, a lower fat content than TM20. TM9 vat milk had worst coagulation properties than TM20, which caused slightly higher loss of fat and curd fines into the whey. Nevertheless, these changes were too small to influence the efficiency of the cheesemaking process; conversely, maintaining milk at the farm at 9 °C led to a reduction of the number of spoilage bacteria.
RESUMO
Milk from different cattle breeds can present different casein and fat contents, which are reflected in different cheese yields (CY). However, CY is also related to some breed-related molecular characteristics. The aim of the present work was to quantify the effect of these characteristics by comparing a series of Parmigiano Reggiano (PR) cheese-making trials made with milks from Italian Brown (IB) and Italian Friesian (IF) cattle herds. Twelve trials were carried out in a cheese factory in one year (one trial per month), each one consisting of four vats processed in parallel: three vats contained milk from three different IF cattle herds (IF1, IF2 and IF3) and one contained milk from a single IB cattle herd. A 24-h CY prediction formula was developed with data from IF1, IF2 and IF3 trials (calibration) and successively validated by applying it to 12 PR trials made with IF milk in six different cheese factories (external validation). The predicted values of 24-h CY were no different to the actual ones in both calibration and external validation. Finally, the formula was tested on trials made with IB milk. In this case, the predicted values were lower than the actual ones. The quantity of IF milk casein necessary to give the same CY of IB milk was 0.20 g/100 g.
RESUMO
The mammary gland inflammation process is responsible for an increased number of somatic cells in milk, and transfers into the milk of some blood components; this causes alterations in the chemical composition and physico-chemical properties of milk. For this reason, somatic cell count (SCC) is one of the most important parameters of milk quality; therefore, European Union (EU) Regulation no 853/2004 has stated that it must not exceed the limit value of 400,000 cells/mL. The research aimed to compare chemical composition, cheese yield, and cheesemaking losses of two groups of vat milks used for Parmigiano Reggiano production, characterized by different SCC levels. During two years, ten cheesemaking trials were performed in ten different cheese factories. In each trial, two cheesemaking processes were conducted in parallel: one with low SCC milk (below 400,000 cells/mL; Low Cell Count (LCC)) and the other with high SCC milk (400,000-1,000,000 cells/mL; High Cell Count (HCC)). For each trial, vat milk and cooked whey were analyzed; after 24 months of ripening, cheeses were weighed to calculate cheese yield. The HCC group had lower casein content (2.43 vs. 2.57 g/100 g; p ≤ 0.05) and number (77.03% vs. 77.80%; p ≤ 0.05), lower phosphorus (88.37 vs. 92.46 mg/100g; p ≤ 0.05) and titratable acidity (3.16 vs. 3.34 °SH/50 mL; p ≤ 0.05) compared to LCC. However, chloride (111.88 vs. 104.12 mg/100 g; p ≤ 0.05) and pH (6.77 vs. 6.71; p ≤ 0.05) were higher. Fat losses during cheesemaking were higher (20.16 vs. 16.13%). After 24 months of ripening, cheese yield was 8.79% lower for HCC milk than LCC (6.74 vs. 7.39 kg/100 kg; p ≤ 0.05).
RESUMO
An important problem in mountain areas is the abandonment of pasture. This trend can be combated by the valorisation of typical dairy products, such as "Formaggella della Valle di Scalve", a semi-cooked traditional cheese made from whole milk in a mountain area in Italy. The aim of the present research was to compare the fatty acid (FA) profile and the sensory properties of this cheese as manufactured under different conditions: i) from the milk of cows grazing on mountain or valley pasture or fed indoors; ii) from the milk of cows fed hay or fed silage. In the first case, five cheesemaking trials were conducted during two years for each of the following situations: mountain pasture (A); pasture at the bottom of the valley (P) (about 1000m asl); stall (S). In the second case, three cheesemaking trials were conducted for each of the following situations: cows fed silage (I); cows fed hay (F). S cheese was richer in medium-chain FAs, while long-chain FAs were higher in P and A cheeses. On the other hand, long chain fatty acids (LCFA) were more abundant in P and A cheeses than in S. In general, MUFA, PUFA and, consequently, total unsaturated FA (UFA), were significantly higher in the P and A cheeses than S (UFA: 36.55 and 38.34, respectively, vs 31.13; p < 0.001), while SFA showed higher values in S (68.85 vs 63.41 and 61.68 in P and A, respectively; p < 0.001). Conjugated linoleic acid isomers (CLA) were more represented in the P and A samples (1.86 in P and 1.52 in A, vs 0.80 in S; p < 0.001); Omega 3 fatty acids, and in particular α-linolenic acid, were more abundant in P than in S cheese. In winter, the I sample (silage) presented higher percentages of myristic (C14), myristoleic (C14:1) and omega 6 acids, whereas F cheese (hay) contained higher concentrations of CLA. The triangular test of sensory analysis showed that, in general, F cheeses were judged as "sweeter" than I, with aromatic profiles characterized by higher content of 2- butanol and ethyl capronate.
RESUMO
The assessment of the efficiency of the cheese-making process (ECMP) is crucial for the profitability of cheese-factories. A simple way to estimate the ECMP is the measure of the estimated cheese-making losses (ECL), expressed by the ratio between the concentration of each constituent in the residual whey and in the processed milk. The aim of this research was to evaluate the influence of the season and cheese factory on the efficiency of the cheese-making process in Parmigiano Reggiano cheese manufacture. The study followed the production of 288 Parmigiano Reggiano cheese on 12 batches in three commercial cheese factories. For each batch, samples of the processed milk and whey were collected. Protein, casein, and fat ECL resulted in an average of 27.01%, 0.72%, and 16.93%, respectively. Both milk crude protein and casein contents were negatively correlated with protein ECL, r = -0.141 (p ≤ 0.05), and r = -0.223 (p ≤ 0.001), respectively. The same parameters resulted in a negative correlation with casein ECL (p ≤ 0.001) (r = -0.227 and -0.212, respectively). Moreover, fat ECL was correlated with worse milk coagulation properties and negatively correlated with casein content (r = -0.120; p ≤ 0.05). In conclusion, ECLs depend on both milk characteristics and season.
RESUMO
Donkey milk is increasingly being proposed as a natural alternative milk for various categories of consumers, especially infants and the elderly population. However, its potential production, gross, and mineral composition have not been deeply investigated yet. Sixty-two individual milk samples were collected monthly from nine Ragusano donkeys reared in a specialized dairy farm. Milk yield as well as chemical and mineral composition, including macro and micro elements, were investigated over an entire lactation, from the second to the ninth month of milking. Milk yield averaged 1.64 kg/day, which highlights good aptitude of the Ragusano breed for the production of milk. Gross composition was characterized by low content of dry matter (8.19%), a high amount of lactose (6.07%), low protein (1.34%), and very low-fat content (0.16%). Whey proteins represented 58% of the total protein, and proteose-peptones accounted for 0.35 ± 0.07 g per 100 g. Total ash content was 0.36 g per 100 g and represented 4.40% of the dry matter. The most abundant element was K, which was followed by Ca, Na, and P. As expected, the micro elements Fe, Zn, and Cu were found in low amounts or in traces. Dry matter, fat, whey proteins. The total ash, Ca, P, Mg, and mineral ratios were significantly affected by the lactation stage.
RESUMO
The aim of this research was to study the effects of dairy maturation on the physico-chemical characteristics and technological properties of milk used for Parmigiano-Reggiano cheese manufacture. Three different operating conditions (CF1, CF2 and CF3) were considered. Full cream milk from the evening milking was stored on the farm and delivered to the cheese factory in churns (CF1) or in thermoregulated tanks at a temperature not lower than 18 degrees C (CF2 and CF3). The natural creaming (10-12 h overnight) was performed in a traditional large flat vat containing 10-12 hl (CF1 and CF2) or in thermoregulated large flat vats containing 60 hl at about 15 degrees C (CF3). Twenty-four, 24 and 22 maturation trials were performed in CF1, CF2, and CF3, respectively, during 2 consecutive years. A significant increase (PAssuntos
Queijo/análise
, Quimosina/química
, Leite/química
, Animais
, Bovinos
, Indústria de Laticínios
, Manipulação de Alimentos/métodos
, Concentração de Íons de Hidrogênio
, Minerais/química
, Nitrogênio/química
, Reologia
, Fatores de Tempo
RESUMO
The authors report the results of a study aimed at the comparison of the basic chemical composition, the main protein fractions distribution, rennet coagulation properties and Parmigiano-Reggiano cheese yield of vat milk from Italian Brown and Italian Friesian herds. Parmigiano-Reggiano cheese factories which manufacture milk separately from Italian Brown herds and Italian Friesian herds were used in the study. Thirteen cheesemaking trials were performed at 10 different commercial cheese factories. The study was carried out from March to October 2003. For each cheesemaking trial in each factory, approximately 1100 kg milk from Italian Brown cows and from Italian Friesian cows were processed in parallel. The animals involved in the study came from farms with comparable management practices, size, location, number of lactation and days in milking. Each vat contained milk obtained by combining milk collected during the evening milking (partially skimmed milk by natural creaming) and the following morning milking (full-cream milk), from at least 2 dairy herds. Milk from Italian Brown cows is characterised by a higher casein content (27.1 v. 23.7 g/kg; P < or = 0.0001) than Italian Friesian cows' milk. Curd firming time (k20) of Italian Brown cows' milk was markedly lower than that of Italian Friesian cows' milk (6.6 v. 10.0 min; P < or = 0.001). This implies a higher rate of aggregation of para-casein micelles for Italian Brown cows' milk. The coagulum of Italian Brown cows' milk had better rheological properties and lower losses of fat in the cheese whey. Parmigiano-Reggiano cheese yield at 24 h was also higher for Italian Brown cows' milk, + 0.99 kg cheese for every 100 kg vat milk.