Expression of cytokine-induced neutrophil chemoattractant in rat lungs following an intratracheal instillation of micron-sized nickel oxide nanoparticle agglomerates.

OBJECTIVE: In our previous study, we reported that the micron-sized nickel oxide nanoparticle agglomerates induced neutrophil infiltration and the gene expression of the cytokine-induced neutrophil chemoattractant (CINC)-2αß in a rat lung. In this study, we examined the expression of the CINCs family in the lung using the same rat model exposed to micron-sized nickel oxide nanoparticle agglomerates. METHODS: The count median diameter of nickel oxide nanoparticle agglomerates suspended in saline was 1.34 µm (primary diameter: 8.41 nm). Male Wistar rats received an intratracheal instillation of 1 mg (3.3 mg/kg) of nickel oxide nanoparticles and were dissected at 3 days, 1 week, 1 month, 3 months, and 6 months after the instillation. The negative control group received an instillation of saline. The concentration of CINC-1 in the lung and the bronchoalveolar lavage fluid (BALF), CINC-2αß in the BALF, and CINC-3 in the lung and the BALF was examined. RESULTS: The concentration of CINC-1 was elevated at 3 days, 3 months, and 6 months in the lung tissue and from 3 days to 6 months in the BALF. The concentration of CINC-2αß was elevated from 3 days to 3 months in the BALF. The concentration of CINC-3 was also elevated at 3 days, 1 week, 3 months, and 6 months in the lung tissue. Infiltration of neutrophil and alveolar macrophage was observed mainly in the alveoli during the observed time period. CONCLUSION: These results suggest that CINC-1 to -3 were totally involved in the lung injury caused by micron-sized nickel oxide nanoparticle agglomerates.

Analysis of pulmonary surfactant in rat lungs after intratracheal instillation of short and long multi-walled carbon nanotubes.

Multi-walled carbon nanotubes (MWCNTs) are interesting new materials, but there is some concern about their harmfulness due to their fibrous nature. To determine the difference in the biological effects of MWCMTs by fiber length, we prepared two MWCNT samples from one bulk sample. One consisted of cut up short fibers (Short; average length=0.94 µm) and the other was just dispersed (Long; average length=3.4 µm). The samples were administered to male Wistar rats by intratracheal instillation at doses of 0.2 mg and 1 mg/animal (Short) and 0.2 mg and 0.6 mg/animal (Long). The animals were sacrificed at time points from 3 d to 12 months after administration. Bronchoalveolar lavage fluid (BALF) was taken from the lungs and pathological specimens were prepared. The concentrations of phospholipids, total protein and surfactant protein D (SP-D) in the pulmonary surfactant of the BALF were determined, the surface tension of BALF was measured, and the inflammation score was determined by the point-counting method to assess pulmonary tissue inflammation. The present study suggests that inflammatory response in the lung was slightly higher for long MWCNTs than for short MWCNTs when compared at the same mass dose. The correlation between pulmonary surfactant components and BALF surface tension was also evaluated. The Spearman's rank correlation coefficients obtained for the phospholipid, total protein and SP-D concentrations were -0.068 (p=0.605), -0.360 (p=0.005) and -0.673 (p=0.000), respectively. Surface tension, measured by a simple method, should be reflected in the change of a surfactant protein, such as SP-D.

Comparison of dose-response relations between 4-week inhalation and intratracheal instillation of NiO nanoparticles using polimorphonuclear neutrophils in bronchoalveolar lavage fluid as a biomarker of pulmonary inflammation.

Inhalation studies and intratracheal instillation studies using laboratory animals are commonly conducted for pulmonary toxicity tests of nanomaterials. In our study, male Wister rats were exposed to nickel oxide (NiO) particles including a nano-scale, even for aerosols and suspensions, in a 4-week inhalation and intratracheal instillation. Using polymorphonuclear neutrophils (PMNs) in bronchoalveolar lavage fluid as a biomarker of inflammation, we attempted to quantify the relationship between responses to inhalation and intratracheal instillation of the nanoparticles, based on surface area doses. Four kinds of NiO suspension samples with different specific surface areas were singly injected via the tracheas of the rats. The relationship between the instilled doses and PMN production was examined 3 days and 1 month after the instillation. In parallel, 4-week inhalation studies, using two of the suspensions, were conducted for aerosols generated by a pressurized nebulizer. NiO samples induced PMN responses 3 days after instillation according to the surface area doses, but not the mass doses, as has been reported in many studies. When the same NiO samples were tested in a 4-week inhalation and intratracheal instillation, the amount of pulmonary deposition of the sample after the 4-week inhalation, and an intratracheally instilled dose about ten-times higher, induced similar PMN responses 3 days after termination of inhalation and instillation. Using the relationship between these responses to 4-week inhalation and intratracheal instillation, it may be possible to estimate what aerosol concentrations of other nanomaterials might cause the same responses of PMN production as intratracheal instillation tests.

Biopersistence of potassium hexatitanate in inhalation and intratracheal instillation studies.

An inhalation study and an intratracheal instillation study were conducted to evaluate the biological effects of the new chemical, potassium hexatitanate (PH). For the inhalation study, Wistar male rats were exposed to PH for 6 h a day, 5 days a week for a period of 3 months. The mass median aerodynamic diameter of PH in the exposure chamber was 4.9 µm (1.8) and the mean concentration during the exposure was 2.3 ± 0.1 mg/m(3). After the 3-month inhalation period, rats were dissected at 3 days, 1 month, 3 months, 6 months, and 12 months. The initial PH burden was 0.17 ± 0.03 mg/lung, and this decreased exponentially up to 6 months after inhalation. After 6 months, the rate at which the burden decreased slowed. The biological halftime up to 6 months after exposure was 2.3 months. No difference was found in the dimension of PH fibers in the lung during the observation period and the histopathological examination found no remarkable inflammation or fibrosis. For the intratracheal instillation study, the rats were given a single 2-mg dose of PH suspended in a 0.4 ml saline solution. The geometric mean diameter was 4.3 µm (2.3). After instillation, the rats were dissected at 3 days to 12 months. The PH burden in the lungs decreased exponentially and the biological halftime was 3.1 months. The results of the dimension of PH and histopathological findings were the same as those for the inhalation study. These data suggest that the toxicity of PH in the lung is low in these doses.

Pathological features of rat lung following inhalation and intratracheal instillation of C(60) fullerene.

We evaluated the pulmonary pathological features of rats that received a single intratracheal instillation and a 4-week inhalation of a fullerene. We used fullerene C(60) (nanom purple; Frontier Carbon Co. Ltd, Japan) in this study. Male Wistar rats received intratracheal dose of 0.1, 0.2, or 1 mg of C(60), and were sacrificed at 3 days, 1 week, 1 month, 3 months, 6 months, and 12 months. In the inhalation study, Wistar rats received C(60) or nickel oxide by whole-body inhalation for 6 h/day, 5 days/week, 4 weeks, and were sacrificed at 3 days, 1 month, and 3 months after the end of exposure. During the observation period, no tumors or granulomas were observed in either study. Histopathological evaluation by the point counting method (PCM) showed that a high dose of C(60) (1 mg) instillation led to a significant increase of areas of inflammation in the early phase (until 1 week). In the inhalation study of the C(60)-exposed group, PCM evaluation showed significant changes in the C(60)-exposed group only at 3 days after exposure; after 1 month, no significant changes were observed. The present study demonstrated that the pulmonary inflammation pattern after exposure to well-characterized C(60) via both intratracheal and inhalation instillation was slight and transient. These results support our previous studies that showed C(60) has no significant adverse effects in intratracheal and inhalation instillation studies.

Biopersistence of inhaled MWCNT in rat lungs in a 4-week well-characterized exposure.

It is important to conduct a risk assessment that includes hazard assessment and exposure assessment for the safe production and handling of newly developed nanomaterials. We conducted an inhalation study of a multi-wall carbon nanotube (MWCNT) as a hazard assessment. Male Wistar rats were exposed to well-dispersed MWCNT for 4 weeks by whole body inhalation. The exposure concentration in the chamber was 0.37 ± 0.18 mg/m³. About 70% of the MWCNTs in the chamber were single fiber. The geometric mean diameter (geometric standard deviation, GSD) and geometric mean length (GSD) of the aerosolized MWCNTs in the chamber were 63 nm (1.5) and 1.1 µm (2.7), respectively. The amounts of MWCNT deposited in the rat lungs were determined by the X-ray diffraction method and elemental carbon analysis. The average deposited amounts at 3 days after the inhalation were 68 µg/lung by the X-ray diffraction method and 76 µg/lung by elemental carbon analysis. The calculated deposition fractions were 18% and 20% in each analysis. The amount of retained MWCNT in the lungs until 3 months after the inhalation decreased exponentially and the calculated biological half times of MWCNT were 51 days and 54 days, respectively. The clearance was not delayed, but a slight increase in lung weight at 3 days after the inhalation was observed.

Inflammogenic effect of well-characterized fullerenes in inhalation and intratracheal instillation studies.

BACKGROUND: We used fullerenes, whose dispersion at the nano-level was stabilized by grinding in nitrogen gas in an agitation mill, to conduct an intratracheal instillation study and an inhalation exposure study. Fullerenes were individually dispersed in distilled water including 0.1% Tween 80, and the diameter of the fullerenes was 33 nm. These suspensions were directly injected as a solution in the intratracheal instillation study. The reference material was nickel oxide in distilled water. Wistar male rats intratracheally received a dose of 0.1 mg, 0.2 mg, or 1 mg of fullerenes and were sacrificed after 3 days, 1 week, 1 month, 3 months, and 6 months. In the inhalation study, Wistar rats were exposed to fullerene agglomerates (diameter: 96 +/- 5 nm; 0.12 +/- 0.03 mg/m3; 6 hours/days for 5 days/week) for 4 weeks and were sacrificed at 3 days, 1 month, and 3 months after the end of exposure. The inflammatory responses and gene expression of cytokine-induced neutrophil chemoattractants (CINCs) were examined in rat lungs in both studies. RESULTS: In the intratracheal instillation study, both the 0.1 mg and 0.2 mg fullerene groups did not show a significant increase of the total cell and neutrophil count in BALF or in the expression of CINC-1,-2alphabeta and-3 in the lung, while the high-dose, 1 mg group only showed a transient significant increase of neutrophils and expression of CINC-1,-2alphabeta and -3. In the inhalation study, there were no increases of total cell and neutrophil count in BALF, CINC-1,-2alphabeta and-3 in the fullerene group. CONCLUSION: These data in intratracheal instillation and inhalation studies suggested that well-dispersed fullerenes do not have strong potential of neutrophil inflammation.

Gene expression profiles in rat lung after inhalation exposure to C60 fullerene particles.

Concern over the influence of nanoparticles on human health has risen due to advances in the development of nanotechnology. We are interested in the influence of nanoparticles on the pulmonary system at a molecular level. In this study, gene expression profiling of the rat lung after whole-body inhalation exposure to C(60) fullerene (0.12mg/m(3); 4.1x10(4) particles/cm(3), 96nm diameter) and ultrafine nickel oxide (Uf-NiO) particles (0.2mg/m(3); 9.2x10(4) particles/cm(3), 59nm diameter) as a positive control were employed to gain insights into these molecular events. In response to C(60) fullerene exposure for 6h a day, for 4 weeks (5 days a week), C(60) fullerene particles were located in alveolar epithelial cells at 3 days post-exposure and engulfed by macrophages at both 3 days and 1 month post-exposures. Gene expression profiles revealed that few genes involved in the inflammatory response, oxidative stress, apoptosis, and metalloendopeptidase activity were up-regulated at both 3 days and 1 month post-exposure. Only some genes associated with the immune system process, including major histocompatibility complex (MHC)-mediated immunity were up-regulated. These results were significantly different from those of Uf-NiO particles which induced high expression of genes associated with chemokines, oxidative stress, and matrix metalloproteinase 12 (Mmp12), suggesting that Uf-NiO particles lead to acute inflammation for the inhalation exposure period, and the damaged tissues were repaired in the post-exposure period. We suggest that C(60) fullerene might not have a severe pulmonary toxicity under the inhalation exposure condition.

Biological effect of carbon graphite whisker in rat lung by long-term Inhalation.

Carbon graphite whisker (CGW) was used in a 1-year inhalation study in male Wistar rats and its biological effect was observed until the 1-year clearance period. The inhalation study was conducted at 2.6 +/- 0.5 mg/m(3) (equivalent to 44.5 +/- 15.0 fibers/mL) for 6 hours a day, 5 days a week for 1 year. There were no differences in survival rate between the exposure and control groups during this examination; however, the body weights were significantly different at the end of the 1-year clearance. The lung weight at 3 days and 1 year after the end of exposure was not significantly different in both groups. The deposited amount of CGW was 6.83 +/- 0.75 mg at 3 days post-exposure; the deposition rate was 17.6%. Only around 30% of the total deposited CGW was cleared during the 1-year clearance period. The geometric means of CGW in the lung, i.e. CMD (count median diameter) and CML (count median length), hardly changed, and the clearance was delayed. In the histopathological examination, there was mild fibrosis in all exposed rats irrespective of the clearance period. One adenoma was observed in a single animal at 3 days post-exposure, while no adenomas were observed in the exposure group after the 1-year clearance. Epithelial hyperplasia was found in some animals.

Pathological features of different sizes of nickel oxide following intratracheal instillation in rats.

Focusing on the "size" impact of particles, the objective of this study was to analyze morphological and qualitative changes over time in the development of inflammation and collagen deposition in lung tissue after intratracheal instillation of two sizes of nickel oxide in rats, in comparison with the results of instillation of crystalline silica and titanium dioxide. The fine-sized nickel oxide sample (nNiOm: median diameter of agglomerated particles 0.8 microm) was prepared from crude particles of nickel oxide (median diameter of primary particle 27 nm) by liquid-phase separation. Another samples of micrometer-sized nickel oxide (NiO: median diameter of particles 4.8 microm), crystalline silica (Min-U-SIL-5; geometric mean diameter 1.6 microm, geometric standard deviation [GSD] 2.0), and TiO(2) (geometric mean diameter 1.5 microm, GSD 1.8) were also used. Well-sonicated samples of 2 mg per 0.4 ml saline or saline alone (control) were intratracheally instilled into Wistar rats (males, 10 wk old). Bronchoalveolar lavage fluid (BAL)F and lung tissue were examined at 3 days, 1 wk, 1 mo, 3 mo, and 6 mo after instillation, from 5 rats of each group. Histopathological findings showed that the infiltration of macrophages or polymorphonuclear cells and the alveolitis in rats treated with nNiOm were remarkable over time and similar to the effects of crystalline silica. The numbers of total cells in BALF and the percentage of plymorphonuclear leukocytes (PMNs) also increased in the nNiOm group and silica group. The point counting method (PCM) showed a significant increase of inflammatory area, with the peak at 3 mo after instillation in the nNiOm group. In contrast, NiO treatment showed only a slight inflammatory change. Collagen deposition in two regions in the lung tissue (alveolar duct and pleura) showed an increasing collagen deposition rate in nNiOm at 6 mo. Our results suggest that submicrometer nano-nickel oxide is associated with greater toxicity, as for crystalline silica, than micrometer-sized nickel oxide. Biological effects of factors of particle size reduction, when dealing with finer particles such as nanoparticles, were reconfirmed to be important in the evaluation of respirable particle toxicity.

Effect of polymerized toner on rat lung in chronic inhalation study.

In order to evaluate the chronic effect of polymerized toner particles on the lung, inflammation- and fibrosis-related genes were analyzed and 8-hydroxydeoxyguanosine (8-OHdG) was examined by using the lung tissue of rats subjected to 24 months of toner inhalation exposure. Wistar female rats were divided into four groups (5 weeks old, 30 rats in each): the high concentration exposure group (16.3 +/- 0.6 mg/m(3)), the medium concentration exposure group (4.4 +/- 0.3 mg/m(3)), the low concentration exposure group (1.6 +/- 0.2 mg/m(3)), and the control group (clean air). The material used was black toner, and its aerodynamic diameter in the exposure chamber was 3.0 microm. The rats were exposed to the material for 24 months (6 hours/day, 5 days/week) and dissected after the exposure period. RNA was extracted from one lung and the gene expression related to inflammation and fibrosis. Matrix metalloproteinase-2 (MMP-2), tissue inhibitor of metalloproteinase-2 (TIMP-2), and type I collagen were analyzed according to the ratio of each gene/beta-actin. Also, 8-OHdG level in the lung tissue was measured by HPLC with an electrochemical detector. Small fibrotic foci were found in the toner exposed groups; however, progressive or irreversible fibrosis was not found. The incidence of small fibrotic foci and cell aggregation increased in a dose-dependent manner. There were no significant differences of expression of MMP-2, TIMP-2, and type I collagen between the control group and each exposed group. Lung tumors did not develop in each group. A significant production of 8-OHdG was not observed in the toner exposed groups. In conclusion, toner produced by polymerization was not associated with evidence of carcinogenesis in this experiment.

Expression of cytokine-induced neutrophil chemoattractant in rat lungs by intratracheal instillation of nickel oxide nanoparticles.

Since nanoparticles easily agglomerate to form larger particles, it is important to maintain the size of their agglomerates at the nano-level to evaluate the harmful effect of the nanoparticles. We prevented agglomeration of nickel oxide nanoparticles by ultrasound diffusion and filtration, established an acute exposure model using animals, and examined inflammation and chemokine expression. The mass median diameter of nickel oxide nanoparticle agglomerates suspended in distilled water for intratracheal instillation was 26 nm (8.41 nm weighted average surface primary diameter). Male Wistar rats received intratracheal instillation of nickel oxide nanoparticles at 0.1 mg (0.33 mg/kg) or 0.2 mg (0.66 mg/kg), and were dissected 3 days, 1 week, 1 month, 3 months, and 6 months after the instillation. The control group received intratracheal instillation of distilled water. Three chemokines (cytokine-induced neutrophil chemoattractant-1 (CINC-1), CINC-2alphabeta, and CINC-3) in the lung tissue and bronchoalveolar lavage fluid (BALF) were determined by quantitative measurement of protein by ELISA. Both CINC-1 and CINC-2alphabeta concentration was elevated from day 3 to 3 months in lung tissue and from day 3 to 6 months in BALF. On the other hand, CINC-3 was elevated on day 3 in both lung tissue and BALF, and then decreased. The total cell and neutrophil counts in BALF were increased from day 3 to 3 months. In lung tissue, infiltration of mainly neutrophils and alveolar macrophages was observed from day 3 to 6 months in alveoli. These results suggest that CINC was involved in lung injury by nickel oxide nanoparticles.

Chrysotile asbestos causes AEC apoptosis via the caspase activation in vitro and in vivo.

To determine whether alveolar epithelial cell (AEC) apoptosis via caspase activation is involved in asbestos-induced lung injury, we examined apoptosis, caspase-3 and-9 activation using chrysotile asbestos exposure models in vitro and in vivo. Apoptotic cells were assessed in A549 cells with terminal deoxynucleotidyl transferase-mediated dUTP-biotin nick end labeling (TUNEL) method after 48 hours exposure of chrysotile asbestos (5 to 100 ug/cm2). Asbestos exposure induced a dose-dependent increase of apoptotic cells, and both pretreatment with Z-LEHD-FMK (caspase-3 inhibitor) or Z-DEMK-FMK (caspase-9 inhibitor) significantly suppressed asbestos-induced apoptosis. Expression of cleaved caspase-3 and-9 increased significantly from 18 to at least 48 hours after asbestos exposure. In vivo study, either 1 or 2 mg of chrysotile asbestos were administered into rat lungs intratracheally, and the lungs were obtained 3 days, 1 and 2 weeks, 1, 3 and 6 months after the administration. Asbestos exposure increased the number of apoptotic cells and the activation of cleaved caspase-3 and -9 most at 3 days in a dose dependent manner, and continued to increase them until at least 6 months after asbestos exposure. Apoptotic cells and cleaved caspase-3 and -9 positive cells were mainly observed in AECs. These findings suggest that AEC apoptosis via caspase-3 and -9 activation is involved in asbestos-induced lung injury.

[Effects of nanoparticles on humans].

Methods and end-points used in assessing the hazards of fibrous materials, whose hazards have been assessed, are often employed in studies on the hazards of nanoparticles. Since a possible route of exposure to nanoparticles in work environments is inhalation, data from animal inhalation and intratracheal instillation studies are thought to provide useful insights for assessing the hazards of such particles. Persistent inflammation and fibrosis in the chronic phase and their related factors are particularly important indicators of lung injury. On the other hand, there are some differences in the results of hazard assessment studies due mainly to a lack of detailed physiochemical characterizations of the nanoparticles evaluated. Dispersion properties in the chambers just before exposure in inhalation studies and those in the suspension to be injected in intratracheal instillation studies need to be determined. The number of hazard assessment studies in which characterization of nanoparticles is conducted, while small at present, is increasing and this could consequently yield reliable hazard assessment and risk assessment.

Pulmonary effects and biopersistence of deposited silicon carbide whisker after 1-year inhalation in rats.

Silicon carbide whisker (SiCW) is a durable asbestos substitute. To clarify the biopersistence, the changes of geometrical configurations of deposited whiskers, and potential carcinogenicity and fibrogenicity, 42 Wistar male rats were exposed to SiCW for 6 h/day, 5 days/wk for 1 yr by inhalation. The mass median aerodynamic diameter (geometric standard deviation, GSD), the geometric mean fiber diameter (GSD), and the geometric mean fiber length (GSD) were 2.4 microm (2.4), 0.5 microm (1.5) and 2.8 microm (2.3), respectively. The daily average exposure concentrations were 2.6 +/- 0.4 mg/m3 (98 +/- 19 fibers/ml) and the rats were sacrificed at 6 days and 3, 6, and 12 mo after the exposure. The SiCW amount deposited in each rat lung at 6 days after the exposure, determined by an x-ray diffraction method, was 5.3 +/- 1.4 mg. The biological half-time (BHT) was 16 mo calculated from the deposited SiCW at 6 days and 3, 6, and 12 mo. The BHT was more prolonged than normal physiological clearance. The diameter of SiCW in the lung at each sacrificed time during 12 mo of clearance after the inhalation did not change. However, as for the length of SiCW in the lung, longer SiCW tended to be retained in the lung as the clearance time increased, especially after 6 mo. The histopathological examination revealed bronchoalveolar hyperplasia (BAH) in 2 rats at 1 yr after the exposure and severe fibrotic changes around aggregated SiCW.

Histopathological changes in rat lung following intratracheal instillation of silicon carbide whiskers and potassium octatitanate whiskers.

We evaluated the pattern of pulmonary inflammation for the assessment of the biological hazards of two man-made mineral fibers. Rats were exposed by intratracheal instillation to a 2 mg dose of each of two kinds of man-made mineral fibers (PT1, potassium octatitanate whisker; and SiCW, silicon carbide whisker), or three kinds of comparable respirable particles (crystalline silica, crocidolite asbestos, and titanium dioxide, TiO(2)). The lung tissue was evaluated at 3 day, 1 wk, and 1, 3 and 6 mo after exposure. Digital images taken of the lung sections were examined by morphometric point counting method (PCM). PT1 and SiCW showed a similar inflammatory pattern, which contains temporal inflammation such as moderate alveolitis within 1 wk after the exposure, and in later phase aggregation foci of instilled fibers. Differences in repair patterns of these two man-made mineral fibers showed that the toxicity of these two fibers is less toxic than for crocidolite or crystalline silica. Although SiCW showed a higher inflammation score than TiO(2) within 1 mo after instillation, the inflammation scores and fibrotic changes of PT1 and SiCW were not significant as TiO(2) at 3 mo and 6 mo in this study. Careful use should be recommended when these materials are used in the workplace.

Change of heme oxygenase-1 expression in lung injury induced by chrysotile asbestos in vivo and in vitro.

Oxidative stress is thought to be the pathogenesis of pulmonary fibrosis induced by asbestos, and heme oxygenase-1 (HO-1) protects lung tissue against oxidative stress. We hypothesized that HO-1 is also associated with oxidative lung injury caused by exposure to chrysotile asbestos. This study was conducted to investigate the HO-1 expression of lungs in lung injury by chrysotile asbestos in vivo and in vitro. Male Wistar rats were administered 1 mg or 2 mg chrysotile suspended in saline by a single intratracheal instillation and were sacrificed at 3 days, 1 wk, 1 mo, 3 mo, and 6 mo of recovery time. The expression of HO-1 was observed by Western blot analysis, reverse-transcription polymerase chain reaction, and immunostaining. Protein levels of HO-1 increased at from 3 days to 6 mo following intratracheal instillation of 1 or 2 mg chrysotile. The mRNA levels of HO-1 increased at 3 mo and 6 mo following intratracheal instillation of 1 or 2 mg chrysotile. HO-1-positive cells were mainly found in the alveolar macrophages during immunostaining. We then examined HO-1 protein expression in human alveolar epithelial cells (A549). A549 cells were incubated with chrysotile at concentrations of 0, 12.5, 25, 50, and 100 microg/ml over 24 h. Increased expression of HO-1 protein was found following exposure to 25 or 50 microg/ml of chrysotile. Increased expression of HO-1 was also found at 6, 12, 24, and 48 h after exposure to 50 microg/ml of chrysotile with a peak at 24 h. These findings suggest that HO-1 is related to lung injury arising from exposure to chrysotile asbestos in vivo and in vitro.

Calcitonin gene-related peptide (CGRP) as hazard marker for lung injury induced by dusts.

Calcitonin gene-related peptide (CGRP), which has a function as a growth factor of epithelial cells, is thought to play a role in pulmonary epithelium repair. In order to establish whether or not CGRP is associated with repair in lung damaged by dust, we examined gene expression of CGRP in the lungs of animal models exposed to different dusts. Male Wistar rats were administered 2 mg of crystalline silica, crocidolite, potassium octatitanate whisker (PT-1), and silicon carbide whisker (SiCW) suspended in saline by a single intratracheal instillation and were sacrificed at 3 d, 1 wk, 1 mo, 3 mo, and 6 mo of recovery time. Pathological findings of advanced pulmonary fibrosis were present in the rats exposed to crystalline silica and crocidolite through the experiment, whereas findings of mild or reversible pulmonary fibrosis were present in those exposed to SiCW and PT-1. The expression of CGRP in rat lung was observed by reverse-transcription polymerase chain reaction (RT-PCR) and enzyme immunometric assay (EIA). In RT-PCR, CGRP gene expression was decreased at the interval of 3 d and 1 wk in the case of crystalline silica and crocidolite; on the other hand, it was increased at 3 d and 1 wk in SiCW and at 3 d, 1 wk, and 3 mo in PT-1-exposed rats. CGRP protein level in lungs exposed to PT-1 and SiCW was also higher than that to silica and crocidolite at 3 d of recovery time. These data suggest that CGRP is associated with repair in lung damaged by different dusts, and that CGRP could be used as a sensitive biomarker to indicate the pathogenicity of dusts.

Effect of particle size of intratracheally instilled crystalline silica on pulmonary inflammation.

Crystalline silica, known as a causal substance of silicosis, has been carefully evaluated for its carcinogenicity and fibrogenicity. In this study, we instilled crystalline silica of two different size (S(1.8) :1.80 microm (S.D. 2.0), S(0.7) :0.74 microm (S.D. 1.5)) into the trachea of rats to evaluate the size effects of the particles on pulmonary inflammation. S(1.8) and S(0.7) samples were administered to rats by a single intratracheal instillation (2 mg/ 0.4 ml saline). At three days, 1 wk and 1, 3 and 6 months after the instillation, the blood, bronchoalveolar lavage fluid (BALF), and pulmonary tissues were analyzed. Six images per HE-stained section were digitally captured and examined by the point counting method (PCM). Polymorphonuclear leukocyte (PMN)-in-blood specimens and cytospin specimens from BALF were stained immunohistochemically with BrdU. At six months after the instillation, the effects on inflammatory cells in the pulmonary tissues and BALF tended to be more marked in the rats instilled with S(1.8) than those instilled with S(0.7). Particularly, clear differences were observed in the number of inflammatory cells in BALF. Even if the particles are of the same chemical composition, the results suggest that, their biological effects vary depending on their particle size. Therefore, when such particles are used in workplaces, strict control systems should be established according to the risks present by different sizes of particles.

Differential expression of EC-SOD, Mn-SOD and CuZn-SOD in rat lung exposed to crystalline silica.

Superoxide dismutases (SODs) are antioxidant enzymes that catalyze the dismutation of superoxide into hydrogen peroxide. There are 3 kinds of isozymes: extracellular superoxide dismutase (EC-SOD), manganese-containing superoxide dismutase (Mn-SOD) and copper- and zinc-containing superoxide dismutase (CuZn-SOD). To examine the expression of SOD isozymes in lungs injured by crystalline silica, we intratracheally instilled male Wistar rats with 2 mg (8 mg/kg) of crystalline silica and investigated the mRNA, protein level and distribution of SOD isozymes in the rat lungs using RT-PCR, western blot analysis and immunostaining, respectively at from 3 d to 180 d of recovery following the exposure. EC-SOD mRNA levels significantly increased from 3 d to 90 d and the EC-SOD protein level was significantly higher after 90 and 180 d recovery in the crystalline silica exposed groups than in the control groups. Mn-SOD increased in silica treated rat lungs at both mRNA and protein levels, peaking at 30 d post-exposure. CuZn-SOD mRNA levels were decreased at 3, 7 and 30 d, and CuZn-SOD protein levels were also significantly lower than the control group at 90 and 180 d recovery. There was prominent EC-SOD immunostaining mainly in the plasma and alveolar macrophages and strong Mn-SOD staining in alveolar macrophages and interstitial cells of the proximal and distal portions of the alveolar duct following crystalline silica exposure. There was less CuZn-SOD staining in epithelial cells at terminal bronchioles in the crystalline silica-exposed group. These findings suggest that these SOD isozymes may be related to lung injury induced by crystalline silica.