Sensory Lexicons and Formation Pathways of Off-Aromas in Dairy Ingredients: A Review.

Consumers are becoming increasingly aware of the health benefits of dairy ingredients. However, products fortified with dairy proteins are experiencing considerable aroma challenges. Practices to improve the flavor quality of dairy proteins require a comprehensive understanding of the nature and origins of off-aroma. Unfortunately, existing information from the literature is fragmentary. This review presents sensory lexicons and chemical structures of off-aromas from major dairy ingredients, and it explores their possible precursors and formation mechanisms. It was found that similar chemical structures often contributed to similar off-aroma descriptors. Lipid degradation and Maillard reaction are two primary pathways that commonly cause aroma dissatisfaction. Traditional and novel flavor chemistry tools are usually adopted for off-aroma measurements in dairy ingredients. Strategies for improving aroma quality in dairy derived products include carefully selecting starting materials for formulations, and actively monitoring and optimizing processing and storage conditions.

Efficacy of Peracetic Acid and Chlorine on the Reduction of Shiga Toxin-producing Escherichia coli and a Nonpathogenic E. coli Strain in Preharvest Agricultural Water.

Produce-borne outbreaks of Shiga toxin-producing Escherichia coli (STEC) linked to preharvest water emphasize the need for efficacious water treatment options. This study quantified reductions of STEC and generic E. coli in preharvest agricultural water using commercially available sanitizers. Water was collected from two sources in Virginia (pond, river) and inoculated with either a seven-strain STEC panel or environmental generic E. coli strain TVS 353 (∼9 log10 CFU/100 mL). Triplicate inoculated water samples were equilibrated to 12 or 32°C and treated with peracetic acid (PAA) or chlorine (Cl) [low (PAA:6ppm, Cl:2-4 ppm) or high (PAA:10 ppm, Cl:10-12 ppm) residual concentrations] for an allotted contact time (1, 5, or 10 min). Strains were enumerated, and a log-linear model was used to characterize how treatment combinations influenced reductions. All Cl treatment combinations achieved a ≥3 log10 CFU/100 mL reduction, regardless of strain (3.43 ± 0.25 to 7.05 ± 0.00 log10 CFU/100 mL). Approximately 80% (19/24) and 67% (16/24) of PAA treatment combinations achieved a ≥3 log10 CFU/100 mL for STEC and E. coli TVS 353, respectively. The log-linear model showed contact time (10 > 5 > 1 min) and sanitizer type (Cl > PAA) had the greatest impact on STEC and E. coli TVS 353 reductions (p < 0.001). E. coli TVS 353 in water samples was more resistant to sanitizer treatment (p < 0.001) indicating applicability as a good surrogate. Results demonstrated Cl and PAA can be effective agricultural water treatment strategies when sanitizer chemistry is managed. These data will assist with the development of in-field validation studies and may identify suitable candidates for the registration of antimicrobial pesticide products for use against foodborne pathogens in preharvest agricultural water treatment.

Sanitizer Type and Contact Time Influence Salmonella Reductions in Preharvest Agricultural Water Used on Virginia Farms.

No Environmental Protection Agency (EPA) chemical treatments for preharvest agricultural water are currently labeled to reduce human health pathogens. The goal of this study was to examine the efficacy of peracetic acid- (PAA) and chlorine (Cl)-based sanitizers against Salmonella in Virginia irrigation water. Water samples (100 mL) were collected at three time points during the growing season (May, July, September) and inoculated with either the 7-strain EPA/FDA-prescribed cocktail or a 5-strain Salmonella produce-borne outbreak cocktail. Experiments were conducted in triplicate for 288 unique combinations of time point, residual sanitizer concentration (low: PAA, 6 ppm; Cl, 2-4 ppm or high: PAA, 10 ppm; Cl, 10-12 ppm), water type (pond, river), water temperature (12°C, 32°C), and contact time (1, 5, 10 min). Salmonella were enumerated after each treatment combination and reductions were calculated. A log-linear model was used to characterize how treatment combinations influenced Salmonella reductions. Salmonella reductions by PAA and Cl ranged from 0.0 ± 0.1 to 5.6 ± 1.3 log10 CFU/100 mL and 2.1 ± 0.2 to 7.1 ± 0.2 log10 CFU/100 mL, respectively. Physicochemical parameters significantly varied by untreated water type; however, Salmonella reductions did not (p = 0.14), likely due to adjusting the sanitizer amounts needed to achieve the target residual concentrations regardless of source water quality. Significant differences (p < 0.05) in Salmonella reductions were observed for treatment combinations, with sanitizer (Cl > PAA) and contact time (10 > 5 > 1 min) having the greatest effects. The log-linear model also revealed that outbreak strains were more treatment-resistant. Results demonstrate that certain treatment combinations with PAA- and Cl-based sanitizers were effective at reducing Salmonella populations in preharvest agricultural water. Awareness and monitoring of water quality parameters are essential for ensuring adequate dosing for the effective treatment of preharvest agricultural water.

Evaluation of Listeria monocytogenes and Staphylococcus aureus Survival and Growth during Cooling of Hams Cured with Natural-Source Nitrite.

ABSTRACT: Growing consumer demand for clean-label "natural" products has encouraged more meat processors to cure meat products with natural sources of nitrate or nitrite such as celery juice powder. One challenge for these producers is to identify safe cooling rates in products cured with celery juice powder where extended cooling could allow growth of pathogens. The Food Safety and Inspection Service of the U.S. Department of Agriculture recently added guidelines for stabilization of meat products cured using naturally occurring nitrites based on control of Clostridium spp. However, a knowledge gap exists for safe cooling rates that prevent the growth of Listeria monocytogenes and Staphylococcus aureus, potential postlethality contaminants, in naturally cured ham. The study was conducted to investigate the temperature profiles of naturally cured hams of typical sizes during refrigerator cooling and to determine the behavior of S. aureus and L. monocytogenes on ham during these cooling periods. Whole hams (14 lb [6,300 g]), half hams (6 lb [2,700 g]), and quarter hams (3 lb [1,400 g]) were slowly cooked in a smokehouse until internal temperatures reached a minimum of 140°F (60°C) and then were immediately transferred into a walk-in cooler (38°F [3.3°C]). Cooling times for hams of all sizes were within the requirements for cured products but not for uncured products. Worst-case scenarios of postprocessing surface contamination were simulated by inoculating small naturally cured ham samples with S. aureus or L. monocytogenes. These inoculated hams were then cooled under controlled conditions of 130 to 45°F (54.4 to 7.2°C) for 720 to 900 min. By the end of cooling, small decreases (0.5 to 0.6 log CFU/g) were found for each inoculum. These findings may help small ham processors evaluating production and quality control methods to determine whether recommended concentrations of natural curing agents used to prevent growth of clostridial pathogens may also prevent growth of other pathogens during meat cooling.

Thermal Resistance of Single Strains of Shiga Toxin-Producing Escherichia coli O121:H19 and O157:H7 Based on Culture Preparation Method and Osmolyte-Reduced Water Activity.

ABSTRACT: Bacterial exposure to stress, such as reduced water activity (aw), can increase thermal resistance. Pathogen thermal resistance studies on low-aw foods use a variety of methods to inoculate food, as well as strategies to reduce aw, which can influence observations. This study investigated effects of culture preparation method and osmolyte-induced aw on thermal resistance of two Shiga toxin-producing Escherichia coli (STEC) strains (O121:H19 and O157:H7) challenged with isothermal conditions, determining D- and z-values for each isolate (56, 59, and 62°C). Tryptic soy broth (TSB) and agar (lawn cultures) were compared. D-values of broth cultures were significantly and consistently larger than those of lawn cultures, and O121 was significantly more resistant than O157, but only at 56°C (P < 0.05). To compare potential effects of aw on STEC thermal resistance, cells were suspended in osmolyte solutions with varying aw: high (TSB, aw 0.99), intermediate (61% glycerol or 26% NaCl, aw 0.75), and low (82% glycerol, aw 0.5). In most instances, STEC strains in high-aw broth exhibited greater heat resistance compared to reduced-aw solutions, with the exception of the glycerol intermediate-aw solution (aw 0.75). Magnitudes varied with strain and temperature. The z-values of lawn cultures were significantly lower than those of broth cultures (P < 0.05), but there were few differences between high-aw and reduced-aw samples. There were no significant differences of z-values based on strain type. These results highlight that thermal resistance can be affected by culture preparation and that osmolyte-induced changes to aw influence thermal inactivation of STEC by varying magnitudes. These results emphasize the challenges of extrapolating results from laboratory inactivation kinetic experiments to determine the inactivation of low-aw foods, especially those considered dry in nature.

Thermal inactivation of Salmonella, Shiga toxin-producing Escherichia coli, Listeria monocytogenes, and a surrogate (Pediococcus acidilactici) on raisins, apricot halves, and macadamia nuts using vacuum-steam pasteurization.

Salmonella, Shiga toxin-producing Escherichia coli (STEC), and Listeria monocytogenes have been isolated from low water activity foods (LWAF), where they may survive for extended periods. The ready-to-eat nature of many LWAF, such as dried fruits and nuts, warrants effective post-harvest thermal treatment for the reduction of pathogens such as low-temperature, saturated steam, also known as vacuum-assisted steam pasteurization. The objective of this study was to determine reductions of Salmonella, STEC, L. monocytogenes, and a possible surrogate (Pediococcus acidilactici) on dried apricot halves, whole macadamia nuts, and raisins after treatment with vacuum-assisted steam at three temperatures (62 °C, 72 °C, or 82 °C) and multiple time intervals. Bacterial inactivation was variable between commodities, with higher temperatures and longer times necessary to achieve comparable reductions of pathogens on apricot halves and macadamia nuts compared to raisins. Reductions of the tested pathogens were comparable; therefore, one species was not more resistant than the others. Pathogens were reduced by 5-log CFU/g on apricot halves after 20 min at 72 °C and after 5 min at 82 °C. Longer treatment times were necessary to achieve reductions of each pathogen on macadamia nuts. Pathogens were reduced by nearly 5 log CFU/g on macadamia nuts after 38 min at 72 °C (4.6-6.5 log CFU/g) and after 12 min at 82 °C (4.9-5.7 log CFU/g). Reductions of pathogens on raisins were achieved at lower temperatures than necessary for the other foods. A 5-log reduction for each of the pathogens (CFU/g) on raisins occurred after 20 min at 62 °C and after 5 min at 72 °C. Overall, the reductions of the pathogens exceeded those of P. acidilactici on both the dried fruits and macadamia nuts. Statistically significant differences, indicating greater confidence as a conservative surrogate, were observed at lower treatment temperatures. Inactivation kinetics were modeled for each pathogen on each food type and temperature. Bacterial survival was best described by the Weibull model for raisins and macadamia nuts, while the Gompertz model best described reductions on apricot halves according to Akaike information criterion (AIC) and root-mean-square error (RMSE) evaluations. Water activity and moisture content were increased due to the treatments, which could be addressed through implementation of drying steps. Thermal inactivation kinetic models and 5-log reduction parameters can help food processors design and evaluate similar vacuum-assisted steam interventions to comply with FSMA regulations and preventive control plans. However, results or model predictions should not be extrapolated to assume the safety of other types of foods.

Inoculation Preparation Affects Survival of Salmonella enterica on Whole Black Peppercorns and Cumin Seeds Stored at Low Water Activity.

Salmonellosis has been increasingly associated with contaminated spices. Identifying inoculation and stabilization methods for Salmonella on whole spices is important for development of validated inactivation processes. The objective of this study was to examine the effects of inoculation preparation on the recoverability of Salmonella enterica from dried whole peppercorns and cumin seeds. Whole black peppercorns and cumin seeds were inoculated with S. enterica using one dry transfer method and various wet inoculation methods: immersion of spice seeds in tryptic soy broth (TSB) plus Salmonella for 24 h (likely leading to inclusion of Salmonella in native microbiota biofilms formed around the seeds), application of cells grown in TSB, and/or application of cells scraped from tryptic soy agar (TSA). Postinoculation seeds were dried to a water activity of 0.3 within 24 h and held for 28 days. Seeds were sampled after drying (time 0) and periodically during the 28 days of storage. Salmonella cells were enumerated by serial dilution and plated onto xylose lysine Tergitol (XLT4) agar and TSA. Recovery of Salmonella was high after 28 days of storage but was dependent on inoculation method, with 4.05 to 6.22 and 3.75 to 8.38 log CFU/g recovered from peppercorns and cumin seeds, respectively, on XLT4 agar. The changes in surviving Salmonella (log CFU per gram) from initial inoculation levels after 28 days were significantly smaller for the biofilm inclusion method (+0.142pepper, +0.186cumin) than for the other inoculation methods (-0.425pepper, -2.029cumin for cells grown on TSA; -0.641pepper, -0.718cumin for dry transfer; -1.998pepper for cells grown in TSB). In most cases, trends for reductions of total aerobic bacteria were similar to those of Salmonella. The inoculation method influenced the recoverability of Salmonella from whole peppercorns and cumin seeds after drying. The most stable inoculum strategies were dry transfer, 24-h incubation of Salmonella and spices in TSB (i.e., potential inclusion of Salmonella within native microbiota biofilms), and inoculation of Salmonella cells grown on TSA subsequent to drying. However, with the dry transfer method it was difficult to obtain the large amount of inoculum needed for inactivation studies.

Influence of emulsifying component composition on creams formulated with fractionated milkfat.

Dairy systems formulated with fractionated milkfat and milk-derived components have compositional differences that may affect functionality and nutritional aspects as compared to natural dairy products. The composition of 20% milkfat creams formulated with emulsifying components (skim milk, sweet buttermilk, and butter-derived aqueous phase) and low- or medium-melt fractionated butteroil was compared with natural cream. Cream separation temperatures (49 and 55 degrees C) and processing conditions (commercial and pilot plant) in obtaining emulsifying components were examined for effect on content of surface active agents. Individual fatty acids, lipids, cholesterol, phospholipids, protein levels, and types varied with components. Separation temperature influenced the cholesterol level in the aqueous phase. A commercially produced aqueous phase contained less total lipid, protein, cholesterol, and phospholipid than aqueous phase obtained in the pilot plant. Milkfat globule membrane concentration of emulsifying components affected phospholipid and cholesterol content of formulated creams. Butteroil type affected cholesterol levels and cream formulations.