QuickTox Kit for QuickScan Ochratoxin-A.

Quantitative, reader-based lateral flow technology is utilized for determination of ochratoxin contamination levels in wheat by the QuickTox Kit for QuickScan Ochratoxin-A. Naturally contaminated wheat samples were used to challenge the assay in the range of 0-100 ppb in linearity, selectivity, robustness, and stability, and in internal and external matrix studies. Performance was judged against criteria established by the AOAC Research Institute Performance Tested Method program prior to beginning the validation studies. All data produced during this work conformed to the acceptance criteria. Linear dose responses with R2 exceeding 0.97 and RSDr values between 6.22 and 17.10% for positive samples were observed in linearity and internal and external matrix studies. Ochratoxin A (OTA) and ochratoxin B (OTB) were detected by the assay. Assay sensitivity towards OTB was approximately 50% relative to OTA detection. Other common mycotoxins did not affect assay results. Variations in assay timing, temperature, and sample volume encompassed in the robustness study did not yield results outside the acceptable range. Determination of ochratoxin in wheat is facilitated using the QuickTox Kit for QuickScan Ochratoxin-A kit.

The Validation of Neogen Reveal® Q+ for DON.

BACKGROUND: Reveal® Q+ for DON is an immunochromatographic test for quantitative determination of deoxynivalenol (DON) in grains. OBJECTIVE: A study was conducted to validate performance of this method for determination of DON in naturally contaminated corn and wheat and in DON-spiked corn/soy blend, soybeans, barley, malted barley, buckwheat, brown rice, sorghum, and distillers dried grain. METHODS: In addition to matrix testing, LOD, linearity, selectivity, robustness, and stability/lot-to-lot consistency testing were performed. RESULTS: The LOD was determined to be 0.014 ppm in corn and 0.037 ppm in wheat, and the LOQ 0.042 ppm in corn and 0.11 ppm in wheat. Recovery ranged from 90 to 104% across a range of reference values of 0.5 to 34.5 ppm. Linearity calculation comparing test results with reference values produced R2 values of 0.999 in both matrixes. Internal results with corn and wheat were corroborated in independent laboratory testing. For DON-spiked commodities, mean recovery across a range of DON concentration from 0.5 to 30 ppm ranged from 90 to 109%. Results of selectivity testing showed no cross-reactivity with other mycotoxins and no interference in detection of DON. Reagent lot-to-lot consistency and stability studies showed consistent results across a range of DON levels and established expiration dating for the test of 18 months after manufacture when stored under specified conditions. Conclusions and Highlights: The Reveal Q+ for DON test offers reliable performance as well as the advantages of aqueous sample extraction, procedural simplicity, minimal labor and equipment requirements, and rapid results. CONCLUSIONS: The Reveal Q+ for DON test is validated as a Performace Tested Method in Corn, Wheat, and a variety of other grains. HIGHLIGHTS: The test provides rapid results from a simple aqueous extraction and requires minimal labor and equipment.

Modification and Matrix Extension of the Bio-Rad iQ-Check E. coli O157:H7, STEC VirX, and STEC SerO Test Kits for the Detection of Shiga Toxin-Producing Escherichia coli (STEC) and Escherichia coli O157 From a Single Enrichment.

BACKGROUND: The iQ-Check Real-Time PCR kits use PCR technology based on gene amplification and detection by a real-time PCR thermalcycler for the detection of target analytes in select food matrices. The iQ-Check E. coli O157:H7 [Performance Tested MethodSM (PTM) 020801] and STEC VirX and STEC SerO (combined PTM 121203) methods were previously validated for different matrices under different enrichment schemes. OBJECTIVE: To modify the current iQ-Check E. coli O157:H7 Kit for the detection of Escherichia coli O157:H7 from 25 to 375 g for raw ground beef (17% fat), raw beef trim, and fresh spinach. In addition, a matrix extension was validated for iQ-Check E. coli O157:H7 for raw chicken breast without skin (25 g), raw chicken thigh with skin (25 g), mechanically separated chicken (25 g), and raw ground pork (25 g). The study also included the modification of the iQ-Check STEC VirX and SerO Kits for the detection of non-O157 Shiga toxin-producing E. coli (STEC) for raw ground beef (375 g), raw beef trim (375 g), and fresh spinach (375 g) from STEC Enrichment Broth to buffered peptone water (BPW). All tests were carried out at 8-22 h (10-22 h for fresh spinach). METHODS: Ground beef, beef trim, and spinach were co-inoculated with E. coli O157:H7, non-O157 STECs, and Salmonella spp. and analyzed for E. coli O157:H7 and non-O157 STECs after an 8-22 h enrichment in BPW for the beef matrices and after a 10-22 h enrichment in BPW for spinach. The chicken matrices were inoculated with E. coli O157:H7 only and analyzed after an 8-22 h enrichment in BPW. The iQ-Check Free DNA Removal Solution workflow was utilized for all matrices. Confirmations at the 22 h time point and method comparisons were conducted with the appropriate reference method as outlined in the U.S. Food and Drug Administration Bacteriological Analytical Manual Chapter 4A or the U.S. Department of Agriculture Food Safety and Inspection Service Microbiology Laboratory Guidebook Chapters 5.09 and 5B.05. For the iQ-Check STEC VirX and STEC SerO Kits, inclusivity and exclusivity were also performed. RESULTS: The two inclusivity and exclusivity evaluations indicated that the test methods can accurately detect the target analytes and correctly excluded nontarget organisms after 8 h of enrichment. In the method comparison study, the iQ-Check E. coli O157:H7 and STEC VirX and STEC SerO test kits demonstrated no statistically significant differences between candidate and reference method results or between presumptive and confirmed results for all food matrices analyzed and the two time points (8 or 10 and 22 h). Both time points produced the same results, with no discrepancies. CONCLUSIONS: The iQ-Check real-time PCR kits are effective methods for the detection of E. coli O157 and non-O157 STECs (both the virulence factors and the O groups) from raw ground beef, raw beef trim, and fresh spinach in 375 g samples enriched in BPW for 8-22 h (10-22 h for fresh spinach). In addition, the iQ-Check E. coli O157 Kit is effective in detecting E. coli O157 in 25 g samples of raw chicken breast without skin, raw chicken thigh with skin, mechanically separated chicken, and raw ground pork. The iQ-Check test kits allow the end user to pair enrichments for multiple target analytes, allowing the user to prepare a single enrichment and perform a single DNA extraction. The Free DNA Removal Solution removes free DNA from samples prior to PCR analysis, protecting DNA from intact and living cells. HIGHLIGHTS: The method modifications were granted based on the data collected.

Comparative Validation Study to Demonstrate the Equivalence of an Alternate Next-Day Enrichment Protocol for VIP® Gold for Salmonella Method to Culture Methods for the Detection of Salmonella in Selected Foods and Environmental Surfaces.

Background: VIP® Gold for Salmonella is a lateral flow immunodetection device that was validated by AOAC in 1999 as Official Method of Analysis 999.09. It was improved upon in 2009 by introducing gold colloid as the detection method. Objective: A simple next-day enrichment protocol using modified enterohemorrhagic Escherichia coli media was developed for the VIP Gold for Salmonella to improve the time-to-results and laboratory work flow. Methods: We tested 128 Salmonella strains, representing all serotypes from A to Z and 51 to 66 as well as 50 non-Salmonella strains for inclusivity/exclusivity. Performance of the VIP using the new enrichment protocol was compared with the U.S. Department of Agriculture (USDA) Microbiology Laboratory Guidebook reference culture procedure for the detection of Salmonella in ready-to-eat poultry, roast beef, and chicken carcass rinsate. VIP performance was also compared with the U.S. Food and Drug Administration (FDA) Bacteriological Analytical Manual (BAM) for the detection of Salmonella from raw spinach, raw almonds, raw pasta, and environmental surfaces (stainless steel, rubber, and plastic). Results: The VIP detected all 128 of Salmonella strains and none of the 50 non-Salmonella strains. There was no statistically significant difference in the numbers of positive results with VIP Gold for Salmonella protocol compared with appropriate USDA-Food Safety and Inspection Service or FDA-BAM reference methods for any of these matrixes. Conclusions: This new enrichment protocol has met all the requirements to be approved as a Performance Tested MethodSM. Highlights: The new enrichment protocol will improve the time-to-results and allow quicker decisions about the contamination of food products.

Reveal Q+ MAX® for Detection of Total Af latoxin in Corn, Almonds, Pistachios, Walnuts, and Peanuts.

Background: The Reveal Q+ MAX for Aflatoxin is a lateral flow immunochromatographic test intended for quantitative analysis within 6 min after aqueous extraction. Objective: Work was conducted to validate the performance of the Reveal Q+ MAX for Aflatoxin method in selected corn and nut matrixes. Methods: This method was validated under the requirements of the AOAC Research Institute Performance Tested MethodSM program. Five matrixes, including corn naturally contaminated with aflatoxin at 0, 5.2, 21.0, 51.6, 103.6, and 282 ppb as well as peanuts, pistachios, walnuts, and almonds spiked at 0, 5, 20, 50, and 300 ppb were analyzed. Results: Average percentage recoveries of the added aflatoxin from the matrixes ranged from 80.8 to 116.9%. Average LOD for all matrixes is 2 ppb and LOQ is 7 ppb. With the exception of sample size for almonds, robustness trials demonstrated that deliberate changes to the assay parameters minimally affected the Reveal Q+ MAX assay performance. Finally, stability results from three independently manufactured lots support Reveal Q+ MAX for Aflatoxin performance consistency and shelf-life of 18 months when stored at room temperature. Conclusions: This study appropriately validates the Performance Tested MethodSM claim for corn and selected nut matrixes on Reveal Q+ MAX for Aflatoxin, an aqueous lateral flow test kit. Highlights: Aqueous lateral flow test kit detects total aflatoxin between 80 to 120% yield with an LOD of 2 ppb.

Comparative Validation Study to Demonstrate the Equivalence of an Alternate Next-Day Enrichment Protocol for the TRANSIA® PLATE Salmonella Gold Method to Culture Methods for the Detection of Salmonella in Selected Foods and Environmental Surfaces.

TRANSIA® PLATE Salmonella Gold is an ELISA that was validated by Association Française de Normalisation (AFNOR) in 2001 and as a Performance Tested MethodSM (PTM) by AOAC in 2006 (PTM No. 010602) as a two-step enrichment protocol requiring 48 h. A simple next-day enrichment protocol using modified Enterohemorrhagic Escherichia coli media was developed for the TRANSIA PLATE Salmonella Gold to improve the time-to-results and laboratory work flow. We tested 128 Salmonella strains, representing all serotypes from A though Z and 51-66. TRANSIA PLATE Salmonella Gold detected all 128 of these strains. None of the 50 non-Salmonella strains were detected by TRANSIA PLATE Salmonella Gold. Performance of TRANSIA PLATE Salmonella Gold using the new enrichment protocol was compared with U.S. Department of Agriculture Microbiology Laboratory Guidebook reference culture procedure for the detection of Salmonella in ready-to-eat poultry, ready-to-eat beef, and chicken carcass rinsate. In addition, TRANSIA PLATE Salmonella Gold performance was compared with U.S. Food and Drug Administration (FDA) Bacteriological Analytical Manual (BAM) for the detection of Salmonella from raw spinach, raw almonds, raw pasta, and environmental surfaces (stainless steel, rubber, and plastic). There was no statistically significant difference in the numbers of positive results TRANSIA PLATE Salmonella Gold protocol compared with the appropriate U.S. Department of Agriculture Food Safety and Inspection Service or FDA-BAM reference methods for any of these matrixes. Robustness testing demonstrated that the introduction of small changes in the normal assay parameters had no impact on the method performance. This new enrichment protocol has been approved as a Third Level modification to Performance Tested Method 010602.

Validation of the Listeria Right NowTM Test for Detection of Listeria spp. from Selected Environmental Surfaces Without Enrichment.

Background: Listeria Right NowTM is a novel, enrichment-free molecular method for detection of Listeria spp. in swab samples from environmental surfaces. The test provides results in real time, indicating the current or recent presence of Listeria spp. in the environment. After sampling, the entire contents of the swab are subject to sample processing, releasing large quantities of target ribosomal RNA molecules into the lysate. A portion of the lysate is then tested using the ANSR® for Listeria isothermal nucleic acid amplification assay. Objective: A Performance Tested MethodSM study was conducted to validate the method for detection of Listeria spp. in swab samples from stainless steel and sealed concrete surfaces. Methods and Results: In inclusivity testing, 60 of 60 Listeria spp. strains tested positive. In exclusivity testing, 31 of 31 nontarget bacterial strains tested negative. In LOD testing, the test was able to detect as few as 2 CFU of L. monocytogenes applied to a stainless steel surface. In matrix testing of inoculated stainless steel and sealed concrete surfaces, there were no statistically significant differences in method performance comparing the Listeria Right Now and U.S. Food and Drug Administration Bacteriological Analytical Manual reference culture procedures as determined by probability of detection analysis. In robustness testing, modest changes to three assay operating parameters simultaneously did not significantly affect performance of the test. Conclusions and Highlights: Results can be obtained in less than 1 h using the Listeria Right Now test, allowing food industry personnel to take immediate corrective action in the case of Listeria contamination incidents.

Validation of Workflow Changes, Phage Concentration and Reformatted Detection Threshold for the Sample6 DETECT/L™ Test: Level 3 Modification.

The AOAC Research Institute Performance Tested MethodsSM Program certified Sample6 DETECT/L™ in April 2014 (Certification No. 041401) for the detection of Listeria species (L. monocytogenes, L. innocua, L. ivanovii, L. seeligeri, L. marthii, L. welshimeri) on stainless steel environmental surfaces. A modification was approved in January 2016, increasing the concentration of sanitizer-neutralizing reagents in detection reagents, increasing the number of phage in the detection solution, and increasing the sample test volume. Moreover, changes to reduce the number of negative controls and add compatibility with polyurethane sponges were also approved. In this modification, to ensure that DETECT/L continues to meet performance expectations, Sample6 evaluated workflow changes to enhance sensitivity and the ease-of-use of the assay. Changes to the phage concentration and detection threshold, plus the inclusion of a confirmation step (DETECT Check), were validated to obtain better accuracy and optimize assay performance. Inclusivity, exclusivity, and robustness testing were conducted by Sample6 to evaluate the changes. A third-party laboratory compared the DETECT/L assay and the U.S. Department of Agriculture reference method in a stainless steel environmental surface matrix study. The data presented in this report demonstrate that the changes proposed to the DETECT/L assay meet or exceed the performance in the current configuration.

Validation of FoodChek™ - Salmonella for Rapid Detection of Salmonella in Eggs, Derivative Products, and the Environment.

The FoodChek™ - Salmonella assay is an immunomagnetic lateral flow assay for the rapid detection (shorter than 24 h) of the most frequently isolated Salmonella (groups B-E) in eggs, egg-derivative products, and environmental surfaces. The FoodChek - Salmonella assay correctly identified 99.6% (239/240) of the samples tested in the matrix studied, and the statistical analysis of the method comparison study results demonstrated that it performs as well as U.S. culture-based reference methods. Ninety-nine percent of the 103 Salmonella strains tested belonging to serogroups B-E were detected during the inclusivity study. Concerning the exclusivity, 31 nontarget strains were tested. No cross-reactivity was observed in FoodChek - Salmonella assay enrichment conditions. In addition, the assay shows strong robustness, good stability, and consistency among lots. The present study proves that the assay is an effective tool for the rapid detection of Salmonella spp. in whole liquid eggs, liquid egg white (liquid egg albumen), shell eggs, dried whole eggs, dried egg yolks, and environmental surfaces as stainless steel, plastic, rubber, ceramic tiles, and sealed concrete.

Validation of the Peel Plate™ AC for Detection of Total Aerobic Bacteria in Dairy and Nondairy Products.

Peel Plate™ AC (aerobic count) is a low-profile plastic 47 mm culture dish with adhesive top that contains a dried standard plate count medium with oxidation/reduction indicator triphenyl tetrazolium chloride (TTC) that turns red with dehydrogenase enzyme activity of growing aerobic bacteria. The method provides a conventional quantitative count with simple rehydration and incubation for 48 ± 3 h at 35 ± 1°C for most food matrixes and 32 ± 1°C for 48 ± 3 h for dairy products. Dairy matrixes claimed and supported with total aerobic count data are whole milk, skim milk, chocolate milk (2% fat), light cream (20% fat), pasteurized whole goat milk, ultra-high temperature pasteurized milk, nonfat dried milk, lactose-reduced milk, strawberry milk, raw cow milk, raw goat milk, raw sheep milk, condensed skim milk, and vanilla ice cream. Food matrixes claimed for aerobic count detection are raw ground beef, environmental sponge of stainless steel, raw ground turkey, dry dog food, liquid whole pasteurized eggs, milk chocolate, poultry carcass rinse, and large animal carcass sponge. The method has been independently evaluated for aerobic count in dairy products: whole milk, skim milk, chocolate milk, and light cream. The method was also independently evaluated for aerobic count in food matrixes: ground beef and sponge rinse from stainless steel surfaces. In the matrix study, each matrix was assessed separately at each contamination level in comparison to an appropriate reference method. Colony counts were determined for each level and then log10-transformed. The transformed data were evaluated for repeatability, mean comparison between methods with 95% confidence interval (CI), and r(2). A CI range of (-0.5, 0.5) on the mean difference was used as the acceptance criterion to establish significant statistical differences between methods. The evaluations demonstrate that the Peel Plate AC provides no statistical differences across most of the matrixes with r(2) > 0.96. In the case of skim milk, there were significant differences that may be explained by a matrix-related stress on the spiked organisms but were not repeated in subsequent experiments. Within method repeatability of Peel Plate AC was similar to reference method with relative standard deviations in the ranges of 2 to 5% when log10 means were ≥1.5. Quality control data support that Peel Plate AC is stable for at least 1 year refrigerated. Incubation temperature ranges 30-36°C and times 45 -51 h were not significantly different.

Evaluation of Peel Plate™ EC for Determination of E. coli and Coliform or Total Coliform in Dairy Products.

Peel Plate™ EC is a low-profile plastic, 47 mm culture dish with an adhesive top that contains a dried medium with Gram-negative selective agents and with enzyme substrate indicators for ß-galactosidase (coliform) and ß-glucuronidase (Escherichia coli). The method provides a conventional quantitative coliform (red) and E. coli (blue/purple/black) count with simple rehydration and incubation for 24 ± 2 h at 35 ± 1°C, while providing a total coliform result, sum of E. coli, and coliform without color differential in dairy products at 32 ± 1°C for 24 ± 2 h. Dairy matrixes claimed and supported with total coliform data are whole milk, skim milk, chocolate milk (2% fat), heavy cream (35% fat), pasteurized whole goat milk, ultra-high-temperature pasteurized milk, powdered milk, lactose-reduced milk, strawberry milk, shredded cheddar cheese, raw cow milk, raw goat milk, raw sheep milk, sour cream, condensed milk, eggnog, vanilla ice cream, condensed whey, yogurt, and cottage cheese. Matrixes claimed for E. coli and total coliform detection are raw ground beef, mixed cellulose 0.45 µm filtered bottled water, environmental sponge of stainless steel, raw ground turkey, dry dog food, liquid whole pasteurized eggs, milk chocolate, leafy green (mixed greens) rinse/flume water, irrigation water, poultry carcass rinse, and large animal carcass sponge. The method has been independently evaluated for total coliform in whole milk, skim milk, chocolate milk, and heavy cream. The method was also independently evaluated for E. coli and coliform in ground beef, filtered bottled water, and sponge rinse from stainless steel surfaces. In inclusivity and exclusivity studies, the method detected 57 of 58 different strains of coliform and E. coli at 32 ± 1°C and 35 ± 1°C in and excluded 31 of 32 different noncoliform strains consisting of Gram-negative and Gram-positive bacteria. In the matrix study, each matrix was assessed separately at each contamination level in comparison to an appropriate reference method. Colony counts were determined for each level and then log10 transformed. The transformed data were evaluated for repeatability, log-mean comparison between methods with 95% confidence interval, and r(2). A 95% confidence interval range of -0.5 to 0.5 on the mean difference was used as the acceptance criterion to establish significant statistical difference between methods. The evaluations demonstrate that the Peel Plate EC method provides no statistical differences across most of the matrixes. The coliform r(2) values were greater than 0.9 except in the case of skim milk (r(2) = 0.77 and 0.69), sheep milk (0.84), and chocolate (0.81). In the case of skim milk, the three highest concentrations were significantly biased low compared with the reference method, whereas in the case of chocolate, the highest concentration was significantly biased high. The E. coli r(2) values were greater than 0.9 except in the case of hog rinse (0.89), flume water (0.82), and chocolate (0.77). The lower values were generally from only a 1 log difference between highest and lowest concentrations except in the case of chocolate, in which the highest concentration was biased high compared with the reference method. Within-method repeatability of Peel Plate EC was similar to the reference method, with relative SDs generally less than 5% when log10 means were ≥1.5. QC data support that the Peel Plate EC is stable for 1 year when refrigerated. Incubation temperature ranges, 30-36°C, and times, 22-26 and 48 h for yogurt, were not significantly different in paired t-test comparison. The method is selective without the need for confirmation, although confirmation of coliform and E. coli was performed as part of the validation work.

Validation of the ANSR® for Campylobacter Method for Detection of Thermophilic Campylobacter spp. in Chicken Carcass Rinse and Turkey Sponge Samples.

A performance validation of the ANSR® for Campylobacter method was conducted in selected matrixes. This assay used selective nicking enzyme amplification technology to amplify target genes. Samples were enriched for 20 to 24 h and then lysed. The assay was completed within 50 min using real-time detection in a combination incubator/fluorescence detector and software. When 50 distinct strains of Campylobacter jejuni, C. lari, or C. coli were tested for inclusivity, all 50 strains produced positive results. In exclusivity testing, 31 strains of related organisms, including seven nontarget Campylobacter strains and other common species, were evaluated. All 31 species generated negative ANSR assay results, including the nontarget Campylobacter strains. The ANSR for Campylobacter method was compared to the U.S. Department of Agriculture, Food Safety and Inspection Service Microbiology Laboratory Guidebook reference method using naturally contaminated chicken carcass rinse or turkey carcass sponge samples. ANSR method performance was not statistically different from the reference method using two different enrichment options. Equivalent results were observed at both time points (20 and 24 h) and in both atmospheres (microaerobic and aerobic) to reference methods. Method performance with chicken carcass rinse was confirmed in an independent laboratory study. Additionally, in robustness testing, small, deliberate changes to the assay parameters minimally affected ANSR method performance. Finally, accelerated stability results from three independently manufactured lots supported a shelf life of 6 months when stored at 4°C. The ANSR assay offered greater efficiency and flexibility when compared to the reference method with a 20-24 h single-step enrichment in a microaerobic or an aerobic atmosphere.