RESUMO
The emergence of severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) variants with greater transmissibility or immune evasion properties has jeopardized the existing vaccine and antibody-based countermeasures. Here, we evaluated the efficacy of boosting pre-immune hamsters with protein nanoparticle vaccines (Novavax, Inc.) containing recombinant Prototype (Wuhan-1) or BA.5 S proteins against a challenge with the Omicron BA.5 variant of SARS-CoV-2. Serum antibody binding and neutralization titers were quantified before challenge, and viral loads were measured 3 days after challenge. Boosting with Prototype or BA.5 vaccine induced similar antibody binding responses against ancestral Wuhan-1 or BA.5 S proteins, and neutralizing activity of Omicron BA.1 and BA.5 variants. One and three months after vaccine boosting, hamsters were challenged with the Omicron BA.5 variant. Prototype and BA.5 vaccine-boosted hamsters had reduced viral infection in the nasal washes, nasal turbinates, and lungs compared to unvaccinated animals. Although no significant differences in virus load were detected between the Prototype and BA.5 vaccine-boosted animals, fewer breakthrough infections were detected in the BA.5-vaccinated hamsters. Thus, immunity induced by Prototype or BA.5 S protein nanoparticle vaccine boosting can protect against the Omicron BA.5 variant in the Syrian hamster model. IMPORTANCE: As SARS-CoV-2 continues to evolve, there may be a need to update the vaccines to match the newly emerging variants. Here, we compared the protective efficacy of the updated BA.5 and the original Wuhan-1 COVID-19 vaccine against a challenge with the BA.5 Omicron variant of SARS-CoV-2 in hamsters. Both vaccines induced similar levels of neutralizing antibodies against multiple variants of SARS-CoV-2. One and three months after the final immunization, hamsters were challenged with BA.5. No differences in protection against the BA.5 variant virus were observed between the two vaccines, although fewer breakthrough infections were detected in the BA.5-vaccinated hamsters. Together, our data show that both protein nanoparticle vaccines are effective against the BA.5 variant of SARS-CoV-2 but given the increased number of breakthrough infections and continued evolution, it is important to update the COVID-19 vaccine for long-term protection.
Assuntos
Vacinas contra COVID-19 , Nanovacinas , SARS-CoV-2 , Animais , Cricetinae , Anticorpos Neutralizantes/imunologia , Anticorpos Antivirais/imunologia , Infecções Irruptivas/imunologia , Infecções Irruptivas/prevenção & controle , Infecções Irruptivas/virologia , COVID-19/imunologia , COVID-19/prevenção & controle , COVID-19/virologia , Vacinas contra COVID-19/imunologia , Mesocricetus/imunologia , Mesocricetus/virologia , Nanovacinas/imunologia , SARS-CoV-2/imunologia , Imunização Secundária , Carga ViralRESUMO
Pet golden hamsters were first identified being infected with the severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) delta variant of concern (VOC) and transmitted the virus back to humans in Hong Kong in January 2022. Here, we studied the binding of two hamster (golden hamster and Chinese hamster) angiotensin-converting enzyme 2 (ACE2) proteins to the spike protein receptor-binding domains (RBDs) of SARS-CoV-2 prototype and eight variants, including alpha, beta, gamma, delta, and four omicron sub-variants (BA.1, BA.2, BA.3, and BA.4/BA.5). We found that the two hamster ACE2s present slightly lower affinity for the RBDs of all nine SARS-CoV-2 viruses tested than human ACE2 (hACE2). Furthermore, the similar infectivity to host cells expressing hamster ACE2s and hACE2 was confirmed with the nine pseudotyped SARS-CoV-2 viruses. Additionally, we determined two cryo-electron microscopy (EM) complex structures of golden hamster ACE2 (ghACE2)/delta RBD and ghACE2/omicron BA.3 RBD. The residues Q34 and N82, which exist in many rodent ACE2s, are responsible for the lower binding affinity of ghACE2 compared to hACE2. These findings suggest that all SARS-CoV-2 VOCs may infect hamsters, highlighting the necessity of further surveillance of SARS-CoV-2 in these animals.IMPORTANCESARS-CoV-2 can infect many domestic animals, including hamsters. There is an urgent need to understand the binding mechanism of the severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) variants to hamster receptors. Herein, we showed that two hamster angiotensin-converting enzyme 2s (ACE2s) (golden hamster ACE2 and Chinese hamster ACE2) can bind to the spike protein receptor-binding domains (RBDs) of SARS-CoV-2 prototype and eight variants and that pseudotyped SARS-CoV-2 viruses can infect hamster ACE2-expressing cells. The binding pattern of golden hamster ACE2 to SARS-CoV-2 RBDs is similar to that of Chinese hamster ACE2. The two hamster ACE2s present slightly lower affinity for the RBDs of all nine SARS-CoV-2 viruses tested than human ACE2. We solved the cryo-electron microscopy (EM) structures of golden hamster ACE2 in complex with delta RBD and omicron BA.3 RBD and found that residues Q34 and N82 are responsible for the lower binding affinity of ghACE2 compared to hACE2. Our work provides valuable information for understanding the cross-species transmission mechanism of SARS-CoV-2.
Assuntos
Enzima de Conversão de Angiotensina 2 , Cricetulus , Microscopia Crioeletrônica , Especificidade de Hospedeiro , Mesocricetus , Animais , Cricetinae , Humanos , Enzima de Conversão de Angiotensina 2/química , Enzima de Conversão de Angiotensina 2/metabolismo , Enzima de Conversão de Angiotensina 2/ultraestrutura , Linhagem Celular , COVID-19/virologia , Cricetulus/metabolismo , Cricetulus/virologia , Mesocricetus/metabolismo , Mesocricetus/virologia , Mutação , Animais de Estimação/metabolismo , Animais de Estimação/virologia , Ligação Proteica , SARS-CoV-2/química , SARS-CoV-2/genética , SARS-CoV-2/metabolismo , SARS-CoV-2/ultraestrutura , Glicoproteína da Espícula de Coronavírus/química , Glicoproteína da Espícula de Coronavírus/genética , Glicoproteína da Espícula de Coronavírus/metabolismo , Glicoproteína da Espícula de Coronavírus/ultraestruturaRESUMO
Oxygen as a key element has a high impact on cellular processes. Infection with a pathogen such as SARS-CoV-2 and following inflammation may lead to hypoxic conditions in tissue that impact cellular responses. To develop optimized translational in vitro models for a better understanding of physiologic and pathophysiologic oxygen conditions, it is a prerequisite to determine oxygen levels generated in vivo. Our study objective was the establishment of an invasive method for oxygen measurements using a luminescence-based microsensor to determine the dissolved oxygen in the lung tissue of ferrets as animal models for SARS-CoV-2 research. In analogy to humans, aged ferrets are more likely to show clinical signs after SARS-CoV-2 infection compared to young animals. To investigate oxygen levels during a respiratory viral infection, we intratracheally infected nine aged (3-year-old) ferrets with SARS-CoV-2. The aged SARS-CoV-2 infected ferrets showed mild to moderate clinical signs associated with prolonged viral RNA shedding until 14 days post infection (dpi). SARS-CoV-2 infected ferrets showed histopathologic lung lesion scores that significantly negatively correlated with oxygen levels in lung tissue. At 4 dpi, oxygen levels in lung tissue were significantly lower (mean %O2 of 3.89 â ≈ 27.78 mmHg) compared to the negative control group (mean %O2 of 8.65 â ≈ 61.4 mmHg). In summary, we succeeded in determining the pathophysiologic oxygen conditions in the lung tissue of aged SARS-CoV-2-infected ferrets. This article is open access and distributed under the terms of the Creative Commons Attribution Non-Commercial No Derivatives License 4.0 (http://creativecommons.org/licenses/by-nc-nd/4.0/). .
RESUMO
Myalgia is a common symptom of Leptospira infection in humans. Autopsies have reported that muscle tissue shows degeneration and necrosis of the myofibers and infiltration of inflammatory cells composed mainly of macrophages and lymphocytes. It remains unclear whether Leptospira directly infects the muscle and how the infiltrating inflammatory cells are involved in muscle fiber destruction. This study evaluated the relationship between histopathological changes and leptospiral localization in the muscle tissue of a hamster model. The influence of macrophages in skeletal muscle injury was also investigated, using selective depletion of macrophages by administration of liposomal clodronate. Hamsters infected subcutaneously with Leptospira interrogans serovar Manilae strain UP-MMC-SM showed myositis of the thighs adjacent to the inoculated area beginning at 6 days post-infection. The myositis was non-purulent and showed sporadic degeneration and necrosis of muscle fibers. The degeneration of myofibers was accompanied by aggregations of macrophages. Immunofluorescence staining revealed leptospires surrounding the damaged muscle fibers. Subcutaneous injection of formalin-killed Leptospira or intraperitoneal injection of live Leptospira caused no myositis in hamster thighs. Liposomal clodronate treatment in infected hamsters reduced macrophage infiltration in muscle tissue without impacting bacterial clearance. Muscle necrosis was still observed in the infected hamsters treated with liposomal clodronate, and there was no significant change in serum creatine kinase levels compared to those in animals treated with liposomes alone. Our findings suggest that leptospiral invasion of muscle tissue from an inoculation site leads to the destruction of muscle fibers and causes non-purulent myositis, whereas the infiltrating macrophages contribute less to muscle destruction.
Assuntos
Leptospira interrogans , Leptospira , Leptospirose , Miosite , Cricetinae , Humanos , Animais , Ácido Clodrônico , Leptospirose/microbiologia , Músculo Esquelético/patologia , NecroseRESUMO
Cold and ischemia/reperfusion (IR)-associated injuries are seemingly inevitable during liver transplantation and hepatectomy. Because Syrian hamsters demonstrate intrinsic tolerance to transplantation-like stimuli, cross-species comparative metabolomic analyses were conducted with hamster, rat, and donor liver samples to seek hepatic cold and IR-adaptive mechanisms. Lower hepatic phosphocholine contents were found in recipients with early graft-dysfunction and with virus-caused cirrhosis or high model for end-stage liver disease scores (≥30). Choline/phosphocholine deficiency in cultured human THLE-2 hepatocytes and animal models weakened hepatocellular cold tolerance and recovery of glutathione and ATP production, which was rescued by phosphocholine supplements. Among the biological processes impacted by choline/phosphocholine deficiency, 3 lipid-related metabolic processes were downregulated, whereas phosphocholine elevated the expression of genes in methylation processes. Consistently, in THLE-2, phosphocholine enhanced the overall RNA m6A methylation, among which the transcript stability of fatty acid desaturase 6 (FADS6) was improved. FADS6 functioned as a key phosphocholine effector in the production of polyunsaturated fatty acids, which may facilitate the hepatocellular recovery of energy and redox homeostasis. Thus, our study reveals the choline-phosphocholine metabolism and its downstream FADS6 functions in hepatic adaptation to cold and IR, which may inspire new strategies to monitor donor liver quality and improve recipient recovery from the liver transplantation process.
RESUMO
XRCC8 is a member of the X-ray cross-complementing (XRCC) family, whose responsible gene has not been identified. Previous studies suggested ATM and other genes were potential candidates for XRCC8, but this was not confirmed. In this study, we characterized three V79-derived XRCC8 mutant cells: V-C4, V-E5, and V-G8. Western blot analysis showed reduced expression of the ATM protein in three XRCC8 mutants, and radiation-induced phosphorylated ATM foci were not detected by fluorescence immunocytochemistry. Both ATM knockout cells and XRCC8 mutants exhibited hypersensitivity to camptothecin. Through a cell fusion-based complementation test, we found that XRCC8 mutants were complemented by ATM-proficient cells, but not by ATM knockout cells, in terms of camptothecin sensitivity. Comprehensive sequencing of the ATM genome in XRCC8 mutants revealed unique mutations in each mutant. These results suggest that XRCC8 mutants carry ATM mutations, and their ATM is not properly functional, despite protein expression being detected. This is similar to missense mutations in some Ataxia Telangiectasia patients.
RESUMO
Accumulating evidence suggests that various cellular stresses interfere with the end processing of mRNA synthesis and lead to the production of abnormally long transcripts, known as readthrough transcripts (RTTs), which extend beyond the termination sites. Small mammalian hibernators repeatedly enter a state referred to as deep torpor (DT), where the metabolic rate, respiration rate, and core body temperature become extremely low, which produces various types of cellular stresses and therefore induces RTTs. However, the types of stresses and processes around the DT that cause RTTs are unclear. In the present study, we showed that RTTs are produced from different gene loci in the livers of Syrian hamsters under DT and summer-like conditions. Moreover, in vitro analysis using hamster primary hepatocytes revealed that DT-specific RTTs are induced by a slow decline in temperature, as seen in body temperature in the entrance phase of DT, but not by rapid cold treatment or hypoxia. In addition, it was observed that RTTs were not elongated under a significantly cold temperature (4 °C). These results indicate that DT-specific RTTs are produced during the entrance phase of torpor by a slow decrease in body temperature.
Assuntos
Hibernação , Animais , Cricetinae , Hibernação/genética , Temperatura , Temperatura Corporal , Mamíferos , Fígado , MesocricetusRESUMO
Cysteine and cystine are essential amino acids present in mammalian cell cultures. While contributing to biomass synthesis, recombinant protein production, and antioxidant defense mechanisms, cysteine poses a major challenge in media formulations owing to its poor stability and oxidation to cystine, a cysteine dimer. Due to its poor solubility, cystine can cause precipitation of feed media, formation of undesired products, and consequently, reduce cysteine bioavailability. In this study, a highly soluble cysteine containing dipeptide dimer, Ala-Cys-Cys-Ala (ACCA), was evaluated as a suitable alternative to cysteine and cystine in CHO cell cultures. Replacing cysteine and cystine in basal medium with ACCA did not sustain cell growth. However, addition of ACCA at 4 mM and 8 mM to basal medium containing cysteine and cystine boosted cell growth up to 15% and 27% in CHO-GS and CHO-K1 batch cell cultures respectively and led to a proportionate increase in IgG titer. 13C-Metabolic flux analysis revealed that supplementation of ACCA reduced glycolytic fluxes by 20% leading to more efficient glucose metabolism in CHO-K1 cells. In fed-batch cultures, ACCA was able to replace cysteine and cystine in feed medium. Furthermore, supplementation of ACCA at high concentrations in basal medium eliminated the need for any cysteine equivalents in feed medium and increased cell densities and viabilities in fed-batch cultures without any significant impact on IgG charge variants. Taken together, this study demonstrates the potential of ACCA to improve CHO cell growth, productivity, and metabolism while also facilitating the formulation of cysteine- and cystine-free feed media. Such alternatives to cysteine and cystine will pave the way for enhanced biomanufacturing by increasing cell densities in culture and extending the storage of highly concentrated feed media as part of achieving intensified bioproduction processes.
RESUMO
Invasive Aspergillosis is a high-risk illness with a high death rate in immunocompromised people due to a lack of early detection and timely treatment. Based on immunology study, we achieved an efficient production of anti-galactomannan antibody by Chinese hamster ovary (CHO) cells and applied it to time-resolved fluoroimmunoassay for Aspergillus galactomannan detection. We first introduced dual promoter expression vector into CHO host cells, and then applied a two-step screening strategy to screen the stable cell line by methionine sulfoximine pressurization. After amplification and fermentation, antibody yield reached 4500 mg/L. Then we conjugated the antibodies with fluorescent microspheres to establish a double antibody sandwich time-resolved fluoroimmunoassay, which was compared with the commercial Platelia™ Aspergillus Ag by clinical serum samples. The preformed assay could obtain the results in less than 25 min, with a limit of detection for galactomannan of approximately 1 ng/mL. Clinical results of the two methods showed that the overall percent agreement was 97.7% (95% CI: 96.6%-98.4%) and Cohen's kappa coefficient was 0.94. Overall, the assay is highly consistent with commercial detection, providing a more sensitive and effective method for the rapid diagnosis of invasive aspergillosis.
Assuntos
Aspergilose , Aspergillus , Galactose/análogos & derivados , Animais , Cricetinae , Humanos , Células CHO , Cricetulus , Aspergilose/diagnóstico , Mananas , Fluorimunoensaio , Anticorpos MonoclonaisRESUMO
Traditional Chinese hamster ovary (CHO) cell line development is based on random integration (RI) of transgene that causes clonal variation and subsequent large-scale clone screening. Therefore, site-specific integration (SSI) of transgenes into genomic hot spots has recently emerged as an alternative method for cell line development. However, the specific mechanisms underlying hot spot site formation remain unclear. In this study, we aimed to generate landing pad (LP) cell lines via the RI of transgenes encoding fluorescent reporter proteins flanked by recombination sites to facilitate recombinase-mediated cassette exchange. The RI-based LP cell line expressing high reporter levels with spontaneous C12orf35 locus deletion exhibited similar reporter fluorescent protein levels compared to targeted integrants with an identical reporter LP construct at the CHO genome hot spot, the C12orf35 locus. Additionally, Resf1, a C12orf35 locus gene, knockout (KO) in the RI-based LP cell line with conserved C12orf35 increased reporter expression levels, comparable to those in cell lines with C12orf35 locus disruption. These results indicate that the effect of SSI into the C12orf35 locus, a genomic hot spot, on high-level transgene expression was caused by C12orf35 disruption. In contrast to C12orf35 KO, KO at other well-known hot spot sites at specific loci of genes, including Fer1L4, Hprt1, Adgrl4, Clcc1, Dop1b, and Ddc, did not increase transgene expression. Overall, our findings suggest that C12orf35 is a promising engineering target and a hot spot for SSI-based cell line development.
RESUMO
Mammalian cells are commonly used as hosts in cell culture for biologics production in the pharmaceutical industry. Structured mechanistic models of metabolism have been used to capture complex cellular mechanisms that contribute to varying metabolic shifts in different cell lines. However, little research has focused on the impact of temporal changes in enzyme abundance and activity on the modeling of cell metabolism. In this work, we present a framework for constructing mechanistic models of metabolism that integrate growth-signaling control of enzyme activity and transcript dynamics. The proposed approach is applied to build models for three Chinese hamster ovary (CHO) cell lines using fed-batch culture data and time-series transcript profiles. Leveraging information from the transcriptome data, we develop a parameter estimation approach based on multi-cell-line (MCL) learning, which combines data sets from different cell lines and trains the individual cell-line models jointly to improve model accuracy. The computational results demonstrate the important role of growth signaling and transcript variability in metabolic models as well as the virtue of the MCL approach for constructing cell-line models with a limited amount of data. The resulting models exhibit a high level of accuracy in predicting distinct metabolic behaviors in the different cell lines; these models can potentially be used to accelerate the process and cell-line development for the biomanufacturing of new protein therapeutics.
Assuntos
Cricetulus , Modelos Biológicos , Células CHO , Animais , Aprendizado de Máquina , Transcriptoma/genéticaRESUMO
The fast-growing Chinese hamster lung (CHL)-YN cell line was recently developed for monoclonal antibody production. In this study, we applied a serum-free fed-batch cultivation process to immunoglobulin (Ig)G1-producing CHL-YN cells, which were then used to design a dynamic glucose supply system to stabilize the extracellular glucose concentration based on glucose consumption. Glucose consumption of the cultures rapidly oscillated following three phases of glutamine metabolism: consumption, production, and re-consumption. Use of the dynamic glucose supply prolonged the viability of the CHL-YN-IgG1 cell cultures and increased IgG1 production. Liquid chromatography with tandem mass spectrometry-based target metabolomics analysis of the extracellular metabolites during the first glutamine shift was conducted to search for depleted compounds. The results suggest that the levels of four amino acids, namely arginine, aspartate, methionine, and serine, were sharply decreased in CHL-YN cells during glutamine production. Supporting evidence from metabolic and gene expression analyses also suggest that CHL-YN cells acquired ornithine- and cystathionine-production abilities that differed from those in Chinese hamster ovary-K1 cells, potentially leading to proline and cysteine biosynthesis.
Assuntos
Anticorpos Monoclonais , Cricetulus , Glucose , Animais , Glucose/metabolismo , Anticorpos Monoclonais/biossíntese , Anticorpos Monoclonais/metabolismo , Cricetinae , Linhagem Celular , Meios de Cultura Livres de Soro , Metabolômica/métodos , Pulmão/metabolismo , Pulmão/citologia , Metaboloma , Imunoglobulina G/metabolismo , Células CHO , Técnicas de Cultura Celular por Lotes/métodos , Glutamina/metabolismoRESUMO
Chinese hamster ovary (CHO) cells are widely used to manufacture biopharmaceuticals, most of all monoclonal antibodies (mAbs). Some CHO cell lines exhibit production instability, where the productivity of the cells decreases as a function of time in culture. To counter this, we designed a passaging strategy that, rather than maximizing the time spent in log-growth phase, mimics the first 7 days of a fed-batch production process. Cultures passaged using this method had lower net growth rates and were more oxidative throughout 6 weeks of passaging. Fed-batch cultures inoculated by cells passaged using this method had increased net growth rates, oxidative metabolism, and volumetric productivity compared to cells passaged using a conventional strategy. Cells from unstable cell lines passaged by this new method produced 80%-160% more mAbs per unit volume than cells passaged by a conventional method. This new method, named Super7, provides the ability to mitigate the impact of production instability in CHO-K1 cell lines without a need for further cell line creation, genetic engineering, or medium development.
RESUMO
Hollow fiber filter fouling is a common issue plaguing perfusion production process for biologics therapeutics, but the nature of filter foulant has been elusive. Here we studied cell culture materials especially Chinese hamster ovary (CHO) cell-derived extracellular vesicles in perfusion process to determine their role in filter fouling. We found that the decrease of CHO-derived small extracellular vesicles (sEVs) with 50-200 nm in diameter in perfusion permeates always preceded the increase in transmembrane pressure (TMP) and subsequent decrease in product sieving, suggesting that sEVs might have been retained inside filters and contributed to filter fouling. Using scanning electron microscopy and helium ion microscopy, we found sEV-like structures in pores and on foulant patches of hollow fiber tangential flow filtration filter (HF-TFF) membranes. We also observed that the Day 28 TMP of perfusion culture correlated positively with the percentage of foulant patch areas. In addition, energy dispersive X-ray spectroscopy-based elemental mapping microscopy and spectroscopy analysis suggests that foulant patches had enriched cellular materials but not antifoam. Fluorescent staining results further indicate that these cellular materials could be DNA, proteins, and even adherent CHO cells. Lastly, in a small-scale HF-TFF model, addition of CHO-specific sEVs in CHO culture simulated filter fouling behaviors in a concentration-dependent manner. Based on these results, we proposed a mechanism of HF-TFF fouling, in which filter pore constriction by CHO sEVs is followed by cake formation of cellular materials on filter membrane.
Assuntos
Anticorpos Monoclonais , Filtração , Cricetinae , Animais , Cricetulus , Células CHO , Perfusão , Filtração/métodos , Reatores Biológicos , Membranas ArtificiaisRESUMO
Host cell proteins (HCPs) are process-related impurities of therapeutic proteins produced in for example, Chinese hamster ovary (CHO) cells. Protein A affinity chromatography is the initial capture step to purify monoclonal antibodies or Fc-based proteins and is most effective for HCP removal. Previously proposed mechanisms that contribute to co-purification of HCPs with the therapeutic protein are either HCP-drug association or leaching from chromatin heteroaggregates. In this study, we analyzed protein A eluates of 23 Fc-based proteins by LC-MS/MS to determine their HCP content. The analysis revealed a high degree of heterogeneity in the number of HCPs identified in the different protein A eluates. Among all identified HCPs, the majority co-eluted with less than three Fc-based proteins indicating a drug-specific co-purification for most HCPs. Only ten HCPs co-purified with over 50% of the 23 Fc-based proteins. A correlation analysis of HCPs identified across multiple protein A eluates revealed their co-elution as HCP groups. Functional annotation and protein interaction analysis confirmed that some HCP groups are associated with protein-protein interaction networks. Here, we propose an additional mechanism for HCP co-elution involving protein-protein interactions within functional networks. Our findings may help to guide cell line development and to refine downstream purification strategies.
Assuntos
Proteína Estafilocócica A , Espectrometria de Massas em Tandem , Cricetinae , Animais , Cricetulus , Cromatografia Líquida , Células CHO , Proteína Estafilocócica A/química , Anticorpos Monoclonais/químicaRESUMO
Transient gene expression (TGE) in Chinese hamster ovary (CHO) cells offers a route to accelerate biologics development by delivering material weeks to months earlier than what is possible with conventional cell line development. However, low productivity, inconsistent product quality profiles, and scalability challenges have prevented its broader adoption. In this study, we develop a scalable CHO-based TGE system achieving 1.9 g/L of monoclonal antibody in an unmodified host. We integrated continuous flow-electroporation and alternate tangential flow (ATF) perfusion to enable an end-to-end closed system from N-1 perfusion to fed-batch 50-L bioreactor production. Optimization of both the ATF operation for three-in-one application-cell growth, buffer exchange, and cell mass concentration-and the flow-electroporation process, led to a platform for producing biotherapeutics using transiently transfected cells. We demonstrate scalability up to 50-L bioreactor, maintaining a titer over 1 g/L. We also show comparable quality between both transiently and stably produced material, and consistency across batches. The results confirm that purity, charge variants and N-glycan profiles are similar. Our study demonstrates the potential of CHO-based TGE platforms to accelerate biologics process development timelines and contributes evidence supporting its feasibility for manufacturing early clinical material, aiming to strengthen endorsement for TGE's wider implementation.
RESUMO
INTRODUCTION: The aim of this study was to compare two CRISPR/Cas9-based orthogonal strategies, paired-Cas9 nickase (paired-Cas9n) and RNA-guided FokI (RFN), in targeting 18S rDNA locus in Chinese hamster ovary (CHO) cells and precisely integrating a bicistronic anti-CD52 monoclonal antibody (mAb) expression cassette into this locus. METHODS: T7E1 and high-resolution melt (HRM) assays were used to compare the ability of mentioned systems in inducing double-strand break (DSB) at the target site. Moreover, 5'- and 3'-junction polymerase chain reactions (PCR) were used to verify the accuracy of the targeted integration of the mAb expression cassette into the 18S rDNA locus. Finally, anti-CD52 mAb gene copy number was measured and, its expression was analyzed using ELISA and western blot assays. RESULTS: Our results indicated that both paired-Cas9n and RFN induced DSB at the target site albeit RFN performance was slightly more efficient in HRM analysis. We also confirmed that the anti-CD52 mAb cassette was accurately integrated at the 18S rDNA locus and the mAb was expressed successfully in CHO cells. CONCLUSION: Taken together, our findings elucidated that both paired-Cas9n and RFN genome editing tools are promising in targeting the 18S rDNA locus. Site specific integration of the bicistronic anti-CD52 mAb expression cassette at this locus in the CHO-K1 cells was obtained, using RFN. Moreover, proper expression of the anti-CD52 mAb at the 18S rDNA target site can be achieved using the bicistronic internal ribosome entry site (IRES)-based vector system.
Assuntos
Sistemas CRISPR-Cas , Edição de Genes , Cricetinae , Animais , Edição de Genes/métodos , Cricetulus , Células CHO , Desoxirribonuclease I/genética , Desoxirribonuclease I/metabolismo , DNA Ribossômico , Anticorpos Monoclonais/genética , Anticorpos Monoclonais/metabolismoRESUMO
Hibernation is an extreme state of seasonal energy conservation, reducing metabolic rate to as little as 1% of the active state. During the hibernation season, many species of hibernating mammals cycle repeatedly between the active (aroused) and hibernating (torpid) states (T-A cycling), using brown adipose tissue (BAT) to drive cyclical rewarming. The regulatory mechanisms controlling this process remain undefined but are presumed to involve thermoregulatory centres in the hypothalamus. Here, we used the golden hamster (Mesocricetus auratus), and high-resolution monitoring of BAT, core body temperature and ventilation rate, to sample at precisely defined phases of the T-A cycle. Using c-fos as a marker of cellular activity, we show that although the dorsomedial hypothalamus is active during torpor entry, neither it nor the pre-optic area shows any significant changes during the earliest stages of spontaneous arousal. Contrastingly, in three non-neuronal sites previously linked to control of metabolic physiology over seasonal and daily time scales - the choroid plexus, pars tuberalis and third ventricle tanycytes - peak c-fos expression is seen at arousal initiation. We suggest that through their sensitivity to factors in the blood or cerebrospinal fluid, these sites may mediate metabolic feedback-based initiation of the spontaneous arousal process.
Assuntos
Nível de Alerta , Plexo Corióideo , Células Ependimogliais , Hibernação , Proteínas Proto-Oncogênicas c-fos , Torpor , Animais , Cricetinae , Masculino , Tecido Adiposo Marrom/metabolismo , Nível de Alerta/genética , Plexo Corióideo/metabolismo , Células Ependimogliais/metabolismo , Hibernação/genética , Mesocricetus , Proteínas Proto-Oncogênicas c-fos/genética , Proteínas Proto-Oncogênicas c-fos/metabolismo , Torpor/genéticaRESUMO
Microglia are the residential immune cells in the central nervous system. Their roles as innate immune cells and regulators of synaptic remodeling are critical to the development and the maintenance of the brain. Numerous studies have depleted microglia to elucidate their involvement in healthy and pathological conditions. PLX3397, a blocker of colony stimulating factor 1 receptor (CSF1R), is widely used to deplete mouse microglia due to its non-invasiveness and convenience. Recently, other small rodents, including Syrian hamsters (Mesocricetus auratus) and Mongolian gerbils (Meriones unguiculatus), have been recognized as valuable animal models for studying brain functions and diseases. However, whether microglia depletion via PLX3397 is feasible in these species remains unclear. Here, we administered PLX3397 orally via food pellets to hamsters and gerbils. PLX3397 successfully depleted gerbil microglia but had no effect on microglial density in hamsters. Comparative analysis of the CSF1R amino acid sequence in different species hints that amino acid substitutions in the juxtamembrane domain may potentially contribute to the inefficacy of PLX3397 in hamsters.
Assuntos
Aminopiridinas , Encéfalo , Gerbillinae , Microglia , Pirróis , Receptores de Fator Estimulador das Colônias de Granulócitos e Macrófagos , Animais , Cricetinae , Administração Oral , Aminopiridinas/farmacologia , Encéfalo/efeitos dos fármacos , Encéfalo/metabolismo , Encéfalo/citologia , Mesocricetus , Microglia/efeitos dos fármacos , Microglia/metabolismo , Modelos Animais , Pirróis/farmacologia , Pirrolidinas/farmacologia , Receptores de Fator Estimulador das Colônias de Granulócitos e Macrófagos/antagonistas & inibidores , Receptores de Fator Estimulador das Colônias de Granulócitos e Macrófagos/genética , Especificidade da EspécieRESUMO
Chinese hamster ovary (CHO) cells are popular in the pharmaceutical industry for their ability to produce high concentrations of antibodies and their resemblance to human cells in terms of protein glycosylation patterns. Current data indicate the relevance of CHO cells in the biopharmaceutical industry, with a high number of product commendations and a significant market share for monoclonal antibodies. To enhance the production capabilities of CHO cells, a deep understanding of their cellular and molecular composition is crucial. Genome sequencing and proteomic analysis have provided valuable insights into the impact of the bioprocessing conditions, productivity, and product quality. In our investigation, we conducted a comparative analysis of proteomic profiles in high and low monoclonal antibody-producing cell lines and studied the impact of tunicamycin (TM)-induced endoplasmic reticulum (ER) stress. We examined the expression levels of different proteins including unfolded protein response (UPR) target genes by using label-free quantification techniques for protein abundance. Our results show the upregulation of proteins associated with protein folding mechanisms in low producer vs. high producer cell line suggesting a form of ER stress related to specific protein production. Further, Hspa9 and Dnaja3 are notable candidates activated by the mitochondria UPR and play important roles in protein folding processes in mitochondria. We identified significant upregulation of Nedd8 and Lgmn proteins in similar levels which may contribute to UPR stress. Interestingly, the downregulation of Hspa5/Bip and Pdia4 in response to tunicamycin treatment suggests a low-level UPR activation. KEY POINTS: ⢠Proteome profiling of recombinant CHO cells under mild TM treatment. ⢠Identified protein clusters are associated with the unfolded protein response (UPR). ⢠The compared cell lines revealed noticeable disparities in protein expression levels.