Carriers based on dairy by-products and dehumidified-air spray drying as a novel multiple approach towards improved retention of phenolics in powders: sour cherry juice concentrate case study.

BACKGROUND: Sour cherry juice concentrate powder can serve as a modern, easy-to-handle, phenolics-rich merchandise; however, its transformation into powdered form requires the addition of carriers. In line with the latest trends in food technology, this study valorizes the use of dairy by-products (whey protein concentrate, whey, buttermilk, and mixes with maltodextrin) as carriers. A new multiple approach for higher drying yield, phenolics retention (phenolic acids, flavonols and anthocyanins) and antioxidant capacity of powders were tested as an effect of simultaneous decrease of drying temperature due to the drying air dehumidification and lower carrier content. RESULTS: Dairy-based carriers were effective for spray drying of sour cherry-juice concentrate. The drying yield was increased and retention of phenolics was higher when compared with maltodextrin. The application of dehumidified air, which enabled the drying temperature to be reduced, affected drying yield positively, and also affected particle morphology and retention of phenolics (the phenolic content was approximately 30% higher than with spray drying). CONCLUSIONS: The study proved that it is possible to apply dairy-based by-products to produce sour cherry juice concentrate powders profitably, lowering the spray-drying temperature and changing the carrier content. Dehumidified air spray drying can be recommended for the production of fruit juice concentrate powders with improved physicochemical properties. © 2023 Society of Chemical Industry.

Polyphenol Profiling by LC QTOF/ESI-MS and Biological Activity of Purple Passion Fruit Epicarp Extract.

A polyphenolic preparation in the form of the passion fruit epicarp extract was analyzed to identify and quantify the polyphenolic compounds using LC QTOF/ESI-MS and UPLC-PDA-FL. The analyzed parameters included antidiabetic activity (α-amylase, α-glucosidase, and pancreatic lipase), inhibitory activity toward cholinesterase (AChE, BuChE), anti-inflammatory activity (COX-1, COX-2, 15-LOX) and antioxidant activity based on ORAC and ABTS. The polyphenolic preparation of the passion fruit epicarp extract contained 51 polyphenolic compounds representing five groups-flavones (25 compounds; 52% of total polyphenolic), flavonols (8; 16%), flavan-3-ols (6; 7%), phenolic acids (4; 3%), and anthocyanins (7; 21%), with derivatives of luteolin (13 derivatives) and apigenin (8 derivatives) as dominant compounds. The preparation was characterized by an antioxidant activity of 160.7 (ORAC) and 1004.4 mmol Trolox/100 mL (ABTS+o). The inhibitory activity toward α-amylase, α-glucosidase, and pancreatic lipase reached IC50 of 7.99, 12.80, and 0.42, respectively. The inhibition of cholinesterases (IC50) was 18.29 for AChE and 14.22 for BuChE. Anti-inflammatory activity as IC50 was 6.0 for COX-1, 0.9 for COX-2, and 4.9 for 15-LOX. Food enriched with passion fruit epicarp extract has a potentially therapeutic effect.

The Effect of Nonthermal Pretreatment on the Drying Kinetics and Quality of Black Garlic.

Black garlic is obtained from regular garlic (Allium sativum L.) through the aging process and consequently gains many health-promoting properties, including antidiabetic and antioxidant. However, the material is still prone to microbiological deterioration and requires a long time to dry due to its properties. Therefore, this study aimed to investigate the effect of various drying methods on the quality of black garlic as well as determine the influence of selected nonthermal pretreatments on the drying kinetics and quality of black garlic, which is especially important in the case of the materials that are difficult to dry. The Weibull model was chosen to describe drying kinetics. Additionally, color, water activity together with antioxidant activity, phenolic compounds, and antidiabetic potential were determined. This study found that the application of a pulsed electric field (PEF), a constant electric field (CEF) as well as a magnetic field (MF) significantly reduced the time of drying (by 32, 40, and 24 min for a PEF, a CEF, and a MF, respectively, compared to combined drying without the pretreatment), and resulted in high antidiabetic potential. However, the highest content of phenolic compounds (1123.54 and 1125.36 mg/100 g dm for VMD125 and CD3h-VMD, respectively) and antioxidant capacity (ABTS = 6.05 and 5.06 mmol Trolox/100 g dm for VMD500 and CD6h-VMD, respectively) were reported for black garlic treated by vacuum-microwave drying and combined convective pre-drying followed by vacuum-microwave drying. Overall, the nonthermal pretreatment decreased the time of drying and showed very good efficiency in maintaining the antidiabetic potential of black garlic, especially in the case of the materials pretreated by a constant electric field (IC50 = 99 and 56 mg/mL, for α-amylase and α-glucosidase, respectively).

Possibility to use the different sizes and colors of carrots for the production of juices - comparison of bioactive compounds, nutritional quality, pro-health properties, and sensory evaluation.

BACKGROUND: Carrot is a popular vegetable consumed by people of all age groups and is used in various food products because of its high nutritional content, especially vitamin A. RESULTS: In the present study, colorful fresh carrot juices of 12 carrot varieties were investigated for in vitro antidiabetic, anti-aging, and anti-obesity activities with antioxidant potential by ABTS (2,2'-azino-bis(3-ethylbenzothiazoline-6-sulfonic acid) and FRAP (ferric reducing ability of plasma) assays. The studied juices were also compared for physicochemical characteristics: titratable acidity, pH, pectin content, total soluble solids, dry mass, ash, viscosity, turbidity, osmolality, and color. The results of the study showed that normal purple carrot juice exhibited the best activities in all biological and antioxidant tests, except for anti-α-glucosidase activity. Normal purple carrot juice also had the highest total mineral content with elevated results for titratable acidity, pH, total soluble solids, dry mass, ash, viscosity, and osmolality. CONCLUSION: Purple carrot juices demonstrated elevated health-promoting activities and could be used in blended beverage recipes to attract children's attention. The results of sensorial characteristics (appearance, color, and taste) of juices, however, showed that people are more familiar with orange carrot products. © 2022 Society of Chemical Industry.

Fruit tree leaves as valuable new source of tocopherol and tocotrienol compounds.

BACKGROUND: Nowadays it is highly important to find new, cheap and widely available sources of tocopherol and tocotrienol compounds, and leaves are promising unconventional sources. The main goal of this study was to extend the currently limited knowledge concerning tocopherol and tocotrienol isomers composition determined using ultra-high performance liquid chromatography with fluorescence detection analysis for various fruit tree leaves such as apple, pear, quince, apricot, peach, plum, sour cherry and sweet cherry. The leaves were collected 2 weeks after tree blooming and after fruit collection. Tocopherol and tocotrienol isomers were identified and quantified for the first time in all fruit tree leaves. RESULTS: The total tocopherol content ranged from 203.34 to 260.86 µg g-1 dry weight for spring leaves and from 23.83 to 235.62 µg g-1 dry weight for autumn leaves and consisted mainly of α-tocopherol. The rest of the isomers of tocopherol and tocotrienols were also found, but in trace amounts. A significantly lower content of tocopherols and tocotrienols was detected in leaves after autumn collection of fruits compared to leaves collected after blooming. Among the analyzed leaves, time collected and species were significantly more important than their cultivars. Regarding quantification analysis, apricot > peach > > plums > apples leaves were identified as the best sources of tocopherols, and sweet and sour cherry leaves exhibited a lower content. CONCLUSION: Fruit tree leaves are a novel significant source and good material for isolation of α-tocopherol for application in cosmetics, pharmaceuticals or in the food industry - for example, production of beverages or other functional foods. © 2021 Society of Chemical Industry.

Phytoprostanes, phytofurans, tocopherols, tocotrienols, carotenoids and free amino acids and biological potential of sea buckthorn juices.

BACKGROUND: Juices are currently a fast-growing segment in the fruit and vegetable industry sector. However, there are still no reports on the diversity of the phytochemical profile and health-promoting properties of commercial sea buckthorn (Hippophaë rhamnoides) juices. This study aimed to identify and quantify phytoprostanes, phytofurans by ultra high-performance liquid chromatography coupled with triple quadrupole mass spectrometry (UHPLC-QqQ-MS/MS), tocopherols, tocotrienols by ultra-performance liquid chromatography coupled with a fluorescence detector (UPLC-FL), carotenoids, and free amino acids by ultra-performance liquid chromatography coupled with a photodiode detector-quadrupole and tandem time-of-flight mass spectrometry (UPLC-PDA-Q/TOF-MS), and assess their anti-cholinergic, anti-diabetic, anti-obesity, anti-inflammatory, and antioxidant potential by in vitro assays of commercial sea buckthorn juices. RESULTS: Phytoprostanes (PhytoPs) and phytofurans (PhytoFs) in sea buckthorn juices were identified for the first time. Juices contained eight F1 -, D1 -, B1 - and L1 -phytoprostanes and one phytofuran (32.31-1523.51 ng and up to 101.47 µg/100 g dry weight (DW)), four tocopherol congeners (22.23-94.08 mg 100 g-1 DW) and three tocotrienols (5.93-25.34 mg 100 g-1 DW). Eighteen carotenoids were identified, including ten xanthophylls, seven carotenes and phytofluene, at a concentration of 133.65 to 839.89 mg 100 g-1 DW. Among the 20 amino acids (175.92-1822.60 mg 100 g-1 DW), asparagine was dominant, and essential and conditionally essential amino acids constituted 11 to 41% of the total. The anti-enzyme and antioxidant potential of juices correlated selectively with the composition. CONCLUSION: Sea buckthorn juice can be a valuable dietary source of vitamins E and A, oxylipins and amino acids, used in the prevention of metabolic syndrome, inflammation, and neurodegenerative processes. The differentiation of the composition and the bioactive potential of commercial juices indicate that, for the consumer, it should be important to choose juices from the declared berry cultivars and crops. © 2021 Society of Chemical Industry.

Microalgae as a Potential Functional Ingredient: Evaluation of the Phytochemical Profile, Antioxidant Activity and In-Vitro Enzymatic Inhibitory Effect of Different Species.

The functional food market has been in a state of constant expansion due to the increasing awareness of the impact of the diet on human health. In the search for new natural resources that could act as a functional ingredient for the food industry, microalgae represent a promising alternative, considering their high nutritional value and biosynthesis of numerous bioactive compounds with reported biological properties. In the present work, the phytochemical profile, antioxidant activity, and enzymatic inhibitory effect aiming at different metabolic disorders (Alzheimer's disease, Type 2 diabetes, and obesity) were evaluated for the species Porphyridium purpureum, Chlorella vulgaris, Arthorspira platensis, and Nannochloropsis oculata. All the species presented bioactive diversity and important antioxidant activity, demonstrating the potential to be used as functional ingredients. Particularly, P. purpureum and N. oculata exhibited higher carotenoid and polyphenol content, which was reflected in their superior biological effects. Moreover, the species P. purpureum exhibited remarkable enzymatic inhibition for all the analyses.

Correlation between water stress and phenolic compounds of hydroSOStainable almonds.

BACKGROUND: Water scarcity is currently affecting many areas of the world, reaching worrying levels in drought areas such as southern Spain. To cope with this issue, researchers in the agricultural sector have implemented deficit irrigation strategies intended to reduce water consumption by increasing fruit quality. Almond is among the most popular tree nuts worldwide and also the most nut cultivated in Spain. Almond consumption, together with other nuts, has been widely associated with improvements in cardiovascular health, metabolic syndrome and diabetes owing to their bioactive compounds such as polyphenols. Water deficit strategies generate hydroSOStainable almonds, raised under water stress conditions, with high content of bioactive compounds. The aim of this work was to study the relationship between water stress, color and polyphenols in hydroSOStainable almonds. For this, instrumental color, total phenolic content and phenolic compounds were measured and correlated using Pearson's correlation. RESULTS: The results showed a strong relationship between water stress, color and polyphenols of almonds, showing that increasing water stress in plants up to ~100 MPa × day values of stress integral increase the polyphenols in almonds, leading to a reddish color. CONCLUSION: Finally, this research demonstrated that implementing water-saving strategies help to improve the phenolic content and color of hydroSOStainable almonds and also that isorhamnetin-3-O-rutinoside, isorhamnetin-3-O-glucoside and kaempferol-3-O-glucoside could be important markers of hydroSOStainable almonds (cv. Vairo). Besides, hydroSOStainable almonds could be an important source of phenols, providing 25% of the estimated total polyphenolic daily intake. © 2020 Society of Chemical Industry.

Inhibition of enzymes associated with metabolic and neurological disorder by dried pomegranate sheets as a function of pomegranate cultivar and fruit puree.

BACKGROUND: Obesity and type 2 diabetes mellitus are the most extended current chronic diseases and also Alzheimer pathology which is a progressive degenerative neurological disorder. Therefore, finding effective enzyme inhibitors responsible for the development of these diseases are essential. Therefore, the aim of this study was to investigate the impact of fruit purée (Cydonia oblonga, Ziziphus jujube and Malus domestica) and pomegranate juice cultivar ('Mollar de Elche' and 'Wonderful') of dried pomegranate sheets (DS) on the inhibition of enzymes associated with metabolic (α-amylase, α-glucosidase, and pancreatic lipase activity), and neurological disorder (acetylcholinesterase and butyrylcholinesterase activity). Quality properties (colour coordinates, texture properties and sensory characteristics) of DS were also studied. In addition, it was researched the effect of storage conditions (4 months at 4 and 20 °C) on phenolic content. RESULTS: DS from jujube had the highest antioxidant capacity and were characterized by the highest storage stability with respect to phenolic compounds. The α-amylase and α-glucosidase half maximal inhibitory concentration (IC50 , in mg mL-1 ) inhibition of DS ranged from 107 to 216 and from 55.2 to values indicating no effect, respectively. The inhibition toward pancreatic lipase (IC50 < 5 mg mL-1 ), acetylcholinesterase (ranged 9.15-22.2%) and butyrylcholinesterase (ranged 20.6-48.6%) was increased with the presence of total flavonoids and hydroxycinnamic acids content (identifying mainly in DS from quinces). It is noteworthy that none of the samples presented off-flavour notes, supporting the high quality of the products. CONCLUSION: DS can be an innovative supplement to a diet as a snack used in the prevention of neurological changes and disorders of carbohydrate and lipid metabolism. © 2020 Society of Chemical Industry.

Effects of Different Drying Methods on the Retention of Bioactive Compounds, On-Line Antioxidant Capacity and Color of the Novel Snack from Red-Fleshed Apples.

The aim of this study was to determine the effect of different drying methods: convective (at 50, 60, 70 °C), vacuum-microwave (at 120, 240, 360, 480 W and 360 W with reduction to 120 W) and hybrid (convective pre-drying at 50, 60, 70 °C followed by vacuum-microwave drying at 120 W) on the quality parameters of novel red-fleshed apple fruit snacks (RFAs), such as phenolics, on-line antioxidant capacity, water activity and color. Drying kinetics, including a temperature profile of dried material, and modified Page model were determined. Freeze-drying was used as a control method. The highest content of bioactive compounds in the samples was retained following freeze-drying, then hybrid, vacuum-microwave and finally convection drying. The antioxidant capacity measured by on-line 2,2'-azino-bis(3-ethylbenzothiazoline-6-sulfonic acid) diammonium salt (ABTS), identified anthocyanins, flavan-3-ols and phenolic acid as the main compounds responsible for this activity. Unfavorable changes in color, formation of hydroxymethylfurfural (HMF) and degradation of polyphenolics were noted along with increasing drying temperature and magnetron power. The red-fleshed apple snacks are a promising high-quality dehydrated food product belonging to functional foods category.

Sprouts vs. Microgreens as Novel Functional Foods: Variation of Nutritional and Phytochemical Profiles and Their In Vitro Bioactive Properties.

The aim of the study was to analyze potential health-promoting and nutritional components (polyphenols, L-ascorbic acid, carotenoids, chlorophylls, amino acids, organic acid, sugars, ash and pectins) of selected sprouts (radish, lentil, black medick, broccoli, sunflower, leek, beetroot, mung beans) and microgreens (kale, radish, beetroot, green peas, amaranth). Moreover, antioxidant capacity (2,2'-azino-bis(3-ethylbenzothiazoline-6-sulphonic acid) (ABTS), ferric reducing ability of plasma (FRAP), and oxygen radical absorbance capacity (ORAC)), in vitro anti-diabetic potential (inhibition of α-amylase and α-glucosidase), and anti-obesity (pancreatic lipase) and anti-cholinergic (acetylcholinesterase and butyrylcholinesterase) activity were evaluated. The results of this study show that sprouts are effective in antioxidant capacity as a result of a high content of polyphenols and L-ascorbic acid. Additionally, sprouts are better sources of amino acids, pectins and sugars than microgreens. Microgreens were characterized by high content of carotenoids and chlorophylls, and organic acid, without any sugars, exhibiting higher anti-diabetic and anti-cholinergic activity than sprouts. Some selected sprouts (broccoli, radish, lentil) and microgreens (radish, amaranths, kale) should be used daily as superfoods or functional food.

Influence Carrier Agents, Drying Methods, Storage Time on Physico-Chemical Properties and Bioactive Potential of Encapsulated Sea Buckthorn Juice Powders.

Sea buckthorn (Hippophaë rhamnoides L.) juice with inulin, maltodextrin, and inulin:maltodextrin (1:2 and 2:1) were spray-, freeze- and vacuum-dried at 50, 70 and 90 °C. The study aimed to assess the impact of drying methods and carrier agents on physical properties (moisture content, water activity, true and bulk density, porosity, color parameters, browning index), chemical components (hydroxymethylfurfural and phenolic compounds) and antioxidant capacity of sea buckthorn juice powders. Storage of powders was carried out for six months. Inulin caused stronger water retention in powders than maltodextrin. Vacuum drying provided powders with the highest bulk density. Maltodextrin did not promote browning and HMF formation as strongly as inulin. More phenolic compounds were found in powders with maltodextrin. Storage increased the antioxidant capacity of powders. The results obtained will be useful in optimizing the powders production on an industrial scale, designing attractive food ingredients.

The Effect of Filtration on Physical and Chemical Properties of Osmo-Dehydrated Material.

Osmotic dehydration (OD) performed in concentrated fruit juices used as osmotic solution (OS) comes with some limitations resulting from the material cell structure and is not entirely recognized at the moment. Filtration of the juice could provide some insight into the phenomena occurring throughout the OD. Therefore, the main aim of the study was to recognize the mechanism of selective penetration during OD and evaluate the effect of filtration on physical and chemical properties of osmo-dehydrated material. For this purpose, OD of pumpkin in non-filtrated and filtrated (filters 0.2, 0.45, 0.8, 1.2, 3, 5 and 8 µm) concentrated chokeberry juice was carried out in the study. Moreover, scanning electron microscope (SEM) images were provided. Total phenolic content (TPC) and antioxidant capacity measured by Ferric Reducing Antioxidant Potential (FRAP) and Trolox Equivalent Antioxidant Capacity (TEAC ABTS) of OS and the material were determined. It was found that even though filtration of osmotic solution had a moderate influence on the mass transfer, it greatly affected the chemical composition of dehydrated material. The best option, considering both chemical and physical properties of the dehydrated material, is the use of non-filtrated solution. However, when shorter time of OD is considered, much better results are obtained for filtrated solutions.

Hydroxycinnamic Acids and Carotenoids of Dried Loquat Fruit cv. 'Algar' Affected by Freeze-, Convective-, Vacuum-Microwave- and Combined-Drying Methods.

The effect of different drying techniques (freeze, convective, vacuum-microwave and combined drying) on the drying kinetics, the phytochemical compounds and sensory characteristics in loquat cultivar 'Algar' was studied. The convective drying resulted in the highest amount of total hydroxycinnamic acids (5077 mg/kg wet weight (ww)), with 3-caffeoyl quinic acid and 5-caffeoyl quinic acid being the greatest carotenoids. The highest values of total carotenoids were obtained by the freeze-drying technique (2601 mg/kg ww), followed by all convective treatments and vacuum-microwave at 360 W. The highest carotenoid was ß-carotene. The ABTS+• (2,2'-azino-bis(3-ethylbenzothiazoline-6-sulfonic acid)) and FRAP (Ferric Ion Reducing Antioxidant Power) values ranged from 2.04 up to 3.27 mmol Trolox/100 g ww, and from 1.89 up to 2.29 mmol Trolox/100 g ww, respectively. As expected, the color difference of freeze-dried samples was the lowest (7.06), similar to combined drying conditions (9.63), whilst the highest value was found after convective drying (37.0). All treatments were sensory acceptable (no off-flavors). However, still, further research is needed to fully optimize these studied drying treatments because the freeze-dried sample still had higher carotenoid content and better instrumental color parameters. Although recently the impact of microwave drying has been studied, this is the first work comparing phytochemical composition of loquat fruit under the different drying methods mentioned above.

The Influence of Inulin on the Retention of Polyphenolic Compounds during the Drying of Blackcurrant Juice.

In blackcurrant juice powders made using freeze-, vacuum-, and spray-drying methods, 19 polyphenolic compounds were identified: anthocyanins (6), (+)-catechin, flavonols (8), and phenolic acids (4). The highest content of identified polyphenols was noted after vacuum drying at 90 °C, which was connected with the thermally induced release of (+)-catechin. Drying at this temperature also increased the formation of the Maillard reaction/caramelization product, hydroxymethyl-l-furfural, when inulin was added. The higher the vacuum drying temperature was, the stronger the degradation of anthocyanins was. Inulin was a better protectant of anthocyanins than maltodextrin, except during vacuum drying at 90 °C, which probably triggered inulin's participation in the formation of hydroxymethyl-l-furfural (HMF), thus limiting its capability to protect anthocyanins. Flavonols and phenolic acids were best retained after vacuum drying at 50 °C. Carrier selection affected only slightly, whereas carrier concentration did not affect, the content of flavonols and phenolic acids. The quality of fruit juice powders should be considered taking into account a broad spectrum of factors, including the initial composition of the material subjected to drying, the drying parameters, the carrier type and concentration, and the interactions that occur during the thermal treatment of fruit juices.

Qualitative and Quantitative Evaluation of Heat-Induced Changes in Polyphenols and Antioxidant Capacity in Prunus domestica L. By-products.

Plum pomace, an agro-industrial waste product has received attention due to the worldwide popularity of plums. During convection, the content of flavan-3-ols decrease, except drying at 90 °C, whereas the content of i.e., chlorogenic, 3-p- and 4-p-coumaroylquinic acids, quercetin rutinoside, and galactoside was observed to increase along with the increase in process temperature. The highest content of all identified polyphenols was found in plum pomace powders obtained using a combination of convective at 90 °C and microwave vacuum drying (MVD) at 120 W, whereas the highest retention of the group consisted of phenolic acids, flavonols, and anthocyanins was noted when CD 70 °C/MVD 120 W was used, pointing to a strong influence of the type of polyphenols on their changes caused by drying. The correlations between TEAC ABTS and the sum of flavonoids (r = 0.634) and anthocyanins (r = 0.704) were established. The multiple regression analysis showed that polyphenol content was more strongly affected by drying time than by maximum temperature, whereas antioxidant capacity was more influenced by maximum temperature of sample than by drying time.

Antidiabetic, Anticholinesterase and Antioxidant Activity vs. Terpenoids and Phenolic Compounds in Selected New Cultivars and Hybrids of Artichoke Cynara scolymus L.

The aim of the study was to analyze the chemical composition of new artichoke cultivars and hybrids and to assess their potential health-promoting properties. Polyphenols, carotenoids and chlorophylls were identified by liquid chromatography-photodiode detector-mass spectrometry/quadrupole time of flight (LC-PDA-MS/QTof) and quantified by ultra performance liquid chromatography-photodiode detector (UPLC-PDA). Sugar and organic acid profiles were prepared, and antioxidant capacity (ABTS, FRAP and ORAC) and in vitro antidiabetic (inhibition of α-amylase and α-glucosidase) and anticholinesterase (inhibition of acetylcholinesterase (AChE) and butyrylcholinesterase (BuChE)) potentials were evaluated. The analyses revealed a highly varied content of bioactive compounds and great health-promoting potential significantly depending on a cultivar. The content of polyphenolic compounds ranged from 1681.49 ("Sambo") to 3638.91 ("Symphony") mg/100 g of dry weight (DW). "Blanca de Tudela" contained the highest amounts of carotenoids and chlorophylls (3761.91 mg/100 g DW) and exhibited high ABTS and ORAC capacity. Inhibition of antidiabetic enzymes was significant in cvs. "Symphony" and "Calico". Additionally, all tested cultivars and hybrids turned out to be effective inhibitors of neurodegenerative enzymes.

Influence of Different Drying Techniques on Phenolic Compounds, Antioxidant Capacity and Colour of Ziziphus jujube Mill. Fruits.

This study was to present the effect of different parameters of combined methods of drying such as vacuum-microwave (VMD: 480, 120 W), hot air (CDD: 70, 60, 50 °C) and combined methods as pre-drying by CD and finish drying by VMD (CD-VMD: 60 °C + 480/120W) in order to avoid a rapid increase in temperature at the critical moisture content of ca. 1 kg/kg dm (dry mass). Control samples were prepared by freeze-drying (FD). Drying kinetics, including the temperature profile of dried material, as well as on some quality factors of the finished product as phenolic compounds, antioxidant capacity, and color were evaluated. The increase in air temperature during CD as well as the increase in material temperature during VMD deteriorated dried product quality in terms of the content of phenolic compounds, antioxidant activity and color. Dried jujube fruits have a long shelf life and therefore may be a fine alternative to fresh fruit all year round.

Antioxidant Activity, and Volatile and Phytosterol Contents of Strobilanthes crispus Dehydrated Using Conventional and Vacuum Microwave Drying Methods.

The preservation of active constituents in fresh herbs is affected by drying methods. An effective drying method for Strobilanthes crispus which is increasingly marketed as an important herbal tea remains to be reported. This study evaluated the effects of conventional and new drying technologies, namely vacuum microwave drying methods, on the antioxidant activity and yield of essential oil volatiles and phytosterols. These drying methods included convective drying (CD) at 40 °C, 50 °C, and 60 °C; vacuum microwave drying (VMD) at 6, 9, and 12 W/g; convective pre-drying and vacuum microwave finish drying (CPD-VMFD) at 50 °C and 9 W/g; and freeze-drying (FD). GC­MS revealed 33 volatiles, and 2-hexen-1-ol, 2-hexenal, 1-octen-3-ol, linalool, and benzaldehyde were major constituents. The compounds ß-sitosterol and α-linolenic acid were the most abundant phytosterol and fatty acid, respectively, in fresh S. crispus. The highest phenolic content was achieved with CD at 60 °C. The highest antioxidant activity was obtained with CD at 40 °C and VMD at 9 W/g. On the contrary, the highest total volatiles and phytosterols were detected with CD at 50 °C and VMD at 9 W/g, respectively. This study showed that CD and VMD were effective in producing highly bioactive S. crispus. A suitable drying parameter level, irrespective of the drying method used, was an important influencing factor.

Characterisation of the Convective Hot-Air Drying and Vacuum Microwave Drying of Cassia alata: Antioxidant Activity, Essential Oil Volatile Composition and Quality Studies.

The preservation of active constituents in Cassia alata through the removal of moisture is crucial in producing a final product with high antioxidant activity. This study aims to determine the influences of various drying methods and drying conditions on the antioxidant activity, volatiles and phytosterols content of C. alata. The drying methods used were convective drying (CD) at 40 °C, 50 °C and 60 °C; freeze drying; vacuum microwave drying (VMD) at 6, 9 and 12 W/g; and two-stage convective pre-drying followed by vacuum microwave finish drying (CPD-VMFD) at 50 °C and 9 W/g. The drying kinetics of C. alata are best described by the thin-layer model (modified Page model). The highest antioxidant activity, TPC and volatile concentration were achieved with CD at 40 °C. GC-MS analysis identified the presence of 51 volatiles, which were mostly present in all samples but with quantitative variation. The dominant volatiles in fresh C. alata are 2-hexenal (60.28 mg 100 g-1 db), 1-hexanol (18.70 mg 100 g-1 db) and salicylic acid (15.05 mg 100 g-1 db). The concentration of phytosterols in fresh sample was 3647.48 mg 100 g-1 db, and the major phytosterols present in fresh and dried samples were ß-sitosterol (1162.24 mg 100 g-1 db). CPD-VMFD was effective in ensuring the preservation of higher phytosterol content in comparison with CD at 50 °C. The final recommendation of a suitable drying method to dehydrate C. alata leaves is CD at 40 °C.