RESUMO
BACKGROUND: A pilot scale process consisting of ultrasound-assisted extraction, ammonium sulfate precipitation, cross-flow ultrafiltration and AB-8 macroporous resins purification aiming to recover anthocyanins and zein from purple corn (PC) was optimized and scaled-up. The effects of five independent variables (ethanol concentration, liquid to solid ratio, ultrasound temperature, time and power) were discussed and the most influential factors were optimized. RESULTS: The highest total anthocyanin (0.45 ± 0.01 g kg-1 ) and zein (17.14 ± 1.73 g kg-1 ) contents from purple corn were obtained using an ultrasound power of 105 W, an extraction time of 90 min, an ethanol concentration of 74% and a liquid to solid ratio of 26:1, at 70 °C, and this was consistent with the predicted values (0.46 and 17.36 g kg-1 , for anthocyanin and zein, respectively). Subsequently, ammonium sulfate precipitation was used to isolate anthocyanins and zein. After cross-flow ultrafiltration, zein (6.30 g) was obtained with 80% purity. Anthocyanins were purified by AB-8 macroporous resins, resulting in 1.60 g of anthocyanins. High-performance liquid chromatography-electrospray ionization-mass spectrometry analysis revealed eight different anthocyanins in purple corn extracts. CONCLUSION: From the results obtained in the present study, it can be concluded that the proposed extraction-separation-filtration-purification method applied under the optimal conditions could be scaled-up to recover anthocyanins and zein simultaneously. Moreover, under the selected conditions, no significant degradation of anthocyanins was observed. © 2018 Society of Chemical Industry.
Assuntos
Antocianinas/isolamento & purificação , Química Verde/métodos , Extratos Vegetais/isolamento & purificação , Ultrafiltração/métodos , Zea mays/química , Zeína/isolamento & purificação , Antocianinas/análise , Antioxidantes/análise , Cromatografia Líquida de Alta Pressão , Extratos Vegetais/análise , Espectrometria de Massas por Ionização por Electrospray , Zeína/análiseRESUMO
The potential effects of three modern extraction technologies (cold-pressing, microwaves and subcritical fluids) on the recovery of oil from Chaenomelessinensis (Thouin) Koehne seeds have been evaluated and compared to those of conventional chemical extraction methods (Soxhlet extraction). This oil contains unsaturated fatty acids and polyphenols. Subcritical fluid extraction (SbFE) provided the highest yield-25.79 g oil/100 g dry seeds-of the three methods. Moreover, the fatty acid composition in the oil samples was analysed using gas chromatography-mass spectrometry. This analysis showed that the percentages of monounsaturated (46.61%), and polyunsaturated fatty acids (42.14%), after applying SbFE were higher than those obtained by Soxhlet, cold-pressing or microwave-assisted extraction. In addition, the oil obtained under optimized SbFE conditions (35 min extraction at 35 °C with four extraction cycles), showed significant polyphenol (527.36 mg GAE/kg oil), and flavonoid (15.32 mg RE/kg oil), content, had a good appearance and was of high quality.
Assuntos
Ácidos Graxos Insaturados/isolamento & purificação , Óleos de Plantas/isolamento & purificação , Polifenóis/isolamento & purificação , Rosaceae/química , Ácidos Graxos Insaturados/química , Cromatografia Gasosa-Espectrometria de Massas , Micro-Ondas , Polifenóis/químicaRESUMO
Clinically, Chaenomeles sinensis (Thouin) Koehne (C. sinensis) has been used to treat hyperuricemia and gout. However, the exact mechanism of action is still unknown. In the present study, the ethyl acetate fraction of C. sinensis fruit extract (CSF-E) was separated. Potassium oxonate (PO)-induced hyperuricemic mice and normal mice were administered with CSF-E at 60, 120 and 180 mg kg-1, respectively for 7 days. Serum uric acid, creatinine and BUN levels, liver oxidative damage, and serum and hepatic XOD activities were primarily measured using assay kits. The evaluation of its nephroprotective effects was carried out by renal histopathological analysis. Simultaneously, renal protein levels of organic anion transporters, such as mURAT1 and mOAT1, were detected using western blotting to elucidate the possible mechanisms. The results showed that CSF-E could significantly inhibit XOD activities in both serum and liver (p < 0.05), decreasing uric acid, creatinine and BUN levels in serum, and increasing levels in the excretion of uric acid by down-regulated of mURAT1 and up-regulated mOAT1 protein expression of kidney in hyperuricemic mice. Moreover, PO-induced alterations in the levels of MDA, hepatic SOD and GSH-Px activities and renal inflammation damage in hyperuricemic mice were effectively recovered by CSF-E at 120 mg kg-1. CSF-E possessed anti-hyperuricemic and nephroprotective effects by suppressing XOD activity, improving renal function and regulating renal mURAT1 and mOAT1 protein expression, which resulted in beneficial effects on hyperuricemia and gout prevention.