Kinetic modeling and optimization of the mono- and diglycerides synthesis mediated by the lipase Lipozyme® TL 100 L immobilized on clayey support.

Mono- and diglycerides play a crucial role in the food industry as multifunctional food additives and emulsifiers. Their importance stems from their unique properties, which allow them to improve the quality, texture, and stability of various food products. Here, results of the kinetic modeling of the mono- and diglycerides synthesis mediated by the lipase Lipozyme® TL 100 L immobilized on the clayey support Spectrogel® type C are reported. The support was characterized by TEM, SEM, and FTIR. Firstly, the influence of pH and lipase load on the immobilization process was analyzed, resulting in an enzymatic activity of 93.2 ± 0.7 U g-1 under optimized conditions (170.9 U g-1 of lipase and pH of 7.1). Afterward, the effects of reaction temperature and concentration of immobilized biocatalyst in the feedstock conversion were evaluated. At optimized parameters, a triglycerides conversion of 97% was obtained at 36.5 °C, 7.9 vol.% of enzyme, a glycerol to feedstock molar ratio of 2:1, and 2 h. The optimized conditions were used to determine the kinetic constants of the elementary reactions involved in the glycerolysis, where a fit superior to 0.99 was achieved between experimental values and predicted data.

Enzymatic Synthesis of Eugenyl Acetate from Essential Oil of Clove Using Lipases in Liquid Formulation as Biocatalyst.

In this research, eugenyl acetate, a compound with flavoring, antioxidant, and antimicrobial properties, was obtained from essential oil of clove (Syzygium aromaticum) via liquid lipase-mediated acetylation. Clove essential oil was extracted by drag water vapor from dry flower buds and its physic-chemical characteristics were analyzed. For the enzymatic synthesis, an extensive evaluation of reaction parameters was accomplished through employment of distinct reaction temperatures, acetic anhydride to eugenol molar ratios, enzyme loads, and three different lipases (a lyophilized enzyme produced by solid-state fermentation of sunflower seed with Penicillium sumatrense microorganism and other two commercial lipases - Lipozyme TL 100L and CALB L). The product eugenyl acetate was confirmed by 1H-NMR, 13C-NMR Distortionless Enhancement by Polarization Transfer (DEPT 135), and Heteronuclear Multiple Bond Correlation (HMBC). Through optimized conditions (55 °C, acetic anhydride to eugenol molar ratio of 1:1, 10 wt% of Lipozyme TL 100L), 91.80% of conversion after 2 h was achieved to the eugenyl acetate production. With the results obtained, it was possible to conclude that the use of lipases in liquid formulation is a promising alternative for the synthesis of essential esters largely applied on food, cosmetic, and pharmaceutical industries.

Kinetics of ultrasound-assisted lipase-catalyzed glycerolysis of olive oil in solvent-free system.

This work reports experimental kinetic data of solvent-free glycerolysis of olive oil using a commercial immobilized lipase (Novozym 435) under the influence of ultrasound irradiation. The experiments were performed in a mechanically stirred reactor under ultrasound irradiation, evaluating the effects of temperature (50-70 °C), enzyme concentration (2.5-10 wt%) and glycerol to oil molar ratio (0.8:1-3:1). Results show that ultrasound-assisted lipase-catalyzed glycerolysis might be a potential alternative route to conventional methods, as high contents of reaction products, especially monoglycerides, were achieved at mild irradiation power supply (~130 W) and temperature, in a relatively short reaction time (2h) and low enzyme content (7.5 wt%). To completeness, two simplified kinetic modeling approaches, based on the ordered-sequential bi bi mechanism and reaction stoichiometry, were employed to represent the experimental data, thus allowing a better understanding of the reaction kinetics.

Ultrasound-assisted synthesis of aliphatic acid esters at room temperature.

This work describes the ultrasound-assisted synthesis of saturated aliphatic esters from synthetic aliphatic acids and either methanol or ethanol. The products were isolated in good yields after short reaction times under mild conditions.

Ultrasound irradiation promoted efficient solvent-free lipase-catalyzed production of mono- and diacylglycerols from olive oil.

This work reports the enzymatic production of mono- and diacylglycerols under the influence of ultrasound irradiation, in a solvent-free system, with and without the presence of surfactants at a constant temperature of 65°C, glycerol to oil molar ratio of 2:1 and a commercial immobilized lipase (Novozym 435) as catalyst. For this purpose, two operation modes were adopted: the use of a sonotrode (ultrasonic probe), without agitation, varying reaction time, irradiation amplitude (25-45% of the total power) and type of surfactant, and a mechanically stirred reactor (600 rpm) under ultrasound irradiation in a water bath, testing different surfactants. Results show that very satisfactory MAG and DAG yields, above 50 wt.%, can be obtained without the use of surfactant, at mild irradiation power supply (∼130 W), with no important enzyme activity losses verified, in a relatively short reaction time (2h), and low enzyme content (7.5 wt.%). Also, reaction kinetic results show that contents of MAG+DAG as high as ∼65 wt.% can be achieved at longer times (6h), indicating a promising route for producing MAG and DAG using ultrasound irradiation.

Low-pressure lipase-catalyzed production of mono- and diglycerides with and without N-butane and AOT surfactant.

The aim of this work is to report the production of mono- and diglycerides from olive oil at ambient condition and in pressurized n-butane as solvent medium. For this purpose, a commercial immobilized lipase (Novozym 435) was employed as catalyst and sodium (bis-2-ethyl-hexyl) sulfosuccinate (Aerosol-OT or AOT) as surfactant. The experiments were conducted in batch mode varying the temperature, pressure, and AOT concentration. Results showed that lipase-catalyzed glycerolysis either with compressed n-butane or in solvent-free system with AOT as surfactant might be a potential alternative route to conventional methods, as high contents of reaction products, especially monoglycerides ( approximately 60 wt.%), were achieved at mild temperature and pressure with a relatively low solvent to substrates mass ratio (4:1) in short reaction times (2 h).