The Impact of Fermented Scald on Rye and Hull-Less Barley Dough and Bread Structure Formation.

In wholemeal bread production, scalding and fermentation contribute to the improvement of the structural characteristics of the dough and bread. The influence of fermented scald on rye and barley dough and bread structure formation was specified in this study. The microstructural analysis performed using a scanning electron microscope revealed the separation of phases during the fermentation of scalds. According to the storage G' and loss G″ moduli, both scalds exhibited elastic character over viscous. The fermentation of barley scald increased both moduli and complex viscosity, while no substantial changes were observed in the fermented rye scald. The addition of fermented scald containing partially hydrolyzed starch and a fraction of water-soluble compounds contributed positively to the formation of a well-organized structure of dough fermented for 4 h. Fermentation substantially reduced the dough's complex viscosity and moduli values, confirming the partial structure alteration leading to the viscous portion increase. The dough with fermented scald showed a significantly lower loss factor than the dough without fermented scald, indicating enhanced mechanical process ability. The most substantial weakening of the structure was observed for dough without scald. The addition of rye scald to the rye dough promoted the formation of fewer pores with relatively smaller specific volumes.

Development and Characteristics of Plant-Based Product Prototypes for Oro-Pharyngeal Dysphagia Diet.

Patients with dysphagia diseases require food with acceptable textural characteristics. Additionally, due to the consumption of smaller portions, these patients receive insufficient amounts of nutrients. Therefore, this study aimed to develop plant-based purée as a meal for an oro-pharyngeal dysphagia (OD) diet, enriched with proteins, fiber and antioxidant vitamins. The suitability of three protein sources-soy protein isolate, whey protein isolate and brown pea protein concentrate-was tested through evaluation of their effect on the rheological properties of protein-enriched plant-based purées for OD diets. Based on the rheological analysis, whey protein was selected for incorporation into the new product formulations. Two prototypes of soups and two prototypes of desserts produced in this study demonstrated acceptable textural properties and high nutritional value.

Effects of Lactobionic Acid on Pig Growth Performance and Chemical Composition of Pork.

Lactobionic acid is an innovative product obtained in the fermentation process of cheese or curd whey, and it has several beneficial properties. Therefore, it may have potential application in animal feeding. Currently, lactobionic acid is not widely used yet in feeding farm animals. Therefore, the aim of our study was to evaluate the effect of lactobionic acid (LBA) on pig growth performance and pork quality. Two groups of pigs (control and trial, 26 piglets each) were completed. The control group received compound feed, whereas the trial group's feed was supplemented with LBA (0.17 kg per 100 kg of feed). Carcass weight and meat pH were determined. The subcutaneous fat layer S (mm) was measured. Lean meat content was determined using the SEUROP classification. Amino acids and fatty acids in pork were evaluated. The addition of LBA to pig feed significantly increased the live weight gain and slaughter yield of pigs, but the samples had a slightly thicker backfat layer. Results obtained showed higher concentration of amino acids in the trial group but slightly lower pork fat quality in the same group. Lactobionic acid has the potential for applications in pig feeding.

Composition of Polysaccharides in Hull-Less Barley Sourdough Bread and Their Impact on Physical Properties of Bread.

The complex of polysaccharides of the grain transforms during processing and modifies the physical and chemical characteristics of bread. The aim of the research was to characterize the changes of glucans, mannans and fructans in hull-less barley and wholegrain wheat breads fermented with spontaneous hull-less barley sourdough, germinated hull-less barley sourdough and yeast, as well as to analyze the impact of polysaccharides on the physical parameters of bread. By using the barley sourdoughs for wholegrain wheat bread dough fermentation, the specific volume and porosity was reduced; the hardness was not significantly increased, but the content of ß-glucans was doubled. Principal component analysis indicates a higher content of ß-glucans and a lower content of starch, total glucans, fructans and mannans for hull-less barley breads, but wholegrain wheat breads fermented with sourdoughs have a higher amount of starch, total glucans, fructans and mannans, and a lower content of ß-glucans. The composition of polysaccharides was affected by the type of flour and fermentation method used.

Effect of Die Configuration on the Physico-Chemical Properties, Anti-Nutritional Compounds, and Sensory Features of Legume-Based Extruded Snacks.

Legumes are not valued by all consumers, mostly due to the prolonged soaking and cooking process they require. This problem could be solved by preparing legume-based ready-to-eat snacks. In this study, the effect of two different dies (circular and star-shaped, with cross-sections of 19.6 and 35.9 mm2, respectively) on the physico-chemical properties, anti-nutritional compounds, and sensory features of extruded breakfast snacks was determined. Extruded products were obtained from 100% legume flours of red lentil, faba bean, brown pea, and common bean. The extrusion-cooking conditions were 2.5 g/s feed rate; 160 ± 1 °C die temperature; 16 ± 1 g/100 g feed moisture, and 230 rpm screw speed. Star-shaped extrudates showed a lower expansion ratio, degree of starch gelatinization, and water solubility index, as well as higher bulk density, hardness, crunchiness, and lightness (L*) values. The oligosaccharides showed non univocal variations by changing the die, whereas phytates did not vary at all. The extrudates from lentil flour (richer in fiber) were the least preferred by sensory panelists, due to their hard texture. However, the spherical extrudates were preferred over the star-shaped product. These results emphasize the possibility of improving the physico-chemical and sensory properties of legume extrudates by selecting a proper die.

Dynamics of Volatile Compounds in Triticale Bread with Sourdough: From Flour to Bread.

Triticale has been suggested for human consumption due to its valuable nutritional composition. The aim of this study was to evaluate volatile compound dynamics in the technological processes of triticale bread and triticale bread with sourdough prepared using Lactobacillus sanfranciscensis based cultures. Two types of sourdough ready-to-use sourdough and two-stage sourdough were used for bread making. Triticale bread without sourdough was used as a control. Volatile compounds from a headspace of flour blend, sourdough, as well as mixed dough, fermented dough, bread crumb and crust were extracted using solid-phase microextraction (SPME) in combination with gas chromatography/mass spectrometry. Alcohols, mainly 1-hexanol, were the main volatiles in the triticale flour blend, whereas in the headspace of sourdough samples ethyl-acetate, ethanol and acetic acid dominated. Two-stage sourdough after 30 min fermentation showed the highest sum of peak areas formed by 14 volatile compounds, resulting in substrates for further aroma development in bread. A total of 29 compounds were identified in the bread: in the crumb the dominant volatile compounds were alcohols, ketones, acids, but in the crust-alcohols, aldehydes, furans dominated. The use of two-stage sourdough provided a more diverse spectrum of volatile compounds. Such volatile compounds as ethanol, 3-methyl-1-butanol, 2-methyl-1-propanol, 2-hydroxy-2-butanone, 2-methylpropanoic acid, and acetic acid were identified in all the analysed samples in all stages of bread making.

Microencapsulation of Horseradish (Armoracia rusticana L.) Juice Using Spray-Drying.

Horseradish contains many bioactive compounds with antioxidant activity. The current study aimed to evaluate the effect of various wall materials and their ratios on the physical properties and bioactive-compound retention and stability in microencapsulated horseradish leaf and root juices. Horseradish juice was microencapsulated using maltodextrin, maltodextrin/gum Arabic, soy protein isolate, and starch with three different core-to-wall ratios. The total phenolic, total flavonoid, total flavan-3-ol, and total phenolic-acid contents, as well as antioxidant activity, were determined using spectrophotometric methods, whereas individual phenol profiles were determined by high-performance liquid chromatography (HPLC). Multivariate analysis of variance showed that plant material, wall material, and core-to-wall ratio had a significant effect on the bioactive-compound retention and antioxidant-activity preservation. Microcapsules produced from horseradish leaf juice had a significantly higher content of phenolic compounds and antioxidant activity compared to root-juice microcapsules. However, better retention was observed for microencapsulated horseradish root juice. Maltodextrin and maltodextrin/gum Arabic were the most effective wall materials for the retention of bioactive compounds, while they also had a smaller particle size and better solubility. The horseradish-juice microcapsules possess a high content of rutin. The highest stability of bioactive compounds after storage was found at a core-to-wall ratio of 20:80.