A galactopoiesis accordant yield of functional recombinant human factor IX from homozygous transgenic pigs requires a large amount of vitamin K supplementation.

Transgenic pigs failed to accord milk yield curve to lactate rhFIX-a vitamin K (VK) dependent protein even fed with VK enriched to 8 times higher than nutritional requirement. A further higher VK supplementation may be required. Homozygous transgenic sows (n = 4, 200 kg) at their 3rd nursing were divided into control and treatment groups and respectively received VK enriched and further menadione (soluble VK) supplemented diet (220 mg/kg VK enriched diet) for 33 days. At next lactation, control sows than received treatment and previous treated were fed on control diet. Results revealed that menadione treatment increased milk bioactivity of rhFIX from the 7th day of 73 to the 21st day of 153 IU/mL; it gradually decreased to 96 IU/mL on 35th day of lactation. Under control feeding, bioactivity remained relatively unchanged. However, milk rhFIX concentration and ratio of activated rhFIX responded little to the treatment. The menadione-induced bioactivity curve agrees with the known lactation pattern of sow means rhFIX secretion is still galactopoietic but requires high VK intake to show. The ineffectual VK spend on lactational carboxylation might be common in other mammary VK dependent expression system but can be effectively overcome by a high supplementation of menadione with a 5-folds improvement in quality.

A novel method for separation of caseins from milk by phosphates precipitation.

Milk protein of farm animals is difficult to isolate because of the presence of casein micelles, which are hard to separate from whey by using centrifugation or filtration. Insoluble casein micelles also create an obstacle for purification instruments to operate efficiently. The conventional method, to precipitate caseins by lowering pH to 4.6 and then recover the whey fraction for further purification using chromatography techniques, is not applicable to proteins having an isoelectric point similar to caseins. In addition, the acid condition used for casein removal usually leads to significantly poor yields and reduced biological activities. In this study, a novel method of precipitating caseins under neutral or weak acidic conditions is presented. The method employs a phosphate salt and a freeze-thaw procedure to obtain a casein-free whey protein fraction. This fraction contains more than 90% yield with little loss of bioactivity of the target protein, and is readily available for further chromatographic purification. This method was successfully applied to purify recombinant human factor IX and recombinant hirudin from the milk of transgenic pigs in the presented study. It is an efficient pretreatment approach prior to chromatographic purification of milk protein from farm animals and particularly of great value to collect those recombinants secreted from transgenic livestock.

Recombinant human factor IX produced from transgenic porcine milk.

Production of biopharmaceuticals from transgenic animal milk is a cost-effective method for highly complex proteins that cannot be efficiently produced using conventional systems such as microorganisms or animal cells. Yields of recombinant human factor IX (rhFIX) produced from transgenic porcine milk under the control of the bovine α-lactalbumin promoter reached 0.25 mg/mL. The rhFIX protein was purified from transgenic porcine milk using a three-column purification scheme after a precipitation step to remove casein. The purified protein had high specific activity and a low ratio of the active form (FIXa). The purified rhFIX had 11.9 γ-carboxyglutamic acid (Gla) residues/mol protein, which approached full occupancy of the 12 potential sites in the Gla domain. The rhFIX was shown to have a higher isoelectric point and lower sialic acid content than plasma-derived FIX (pdFIX). The rhFIX had the same N-glycosylation sites and phosphorylation sites as pdFIX, but had a higher specific activity. These results suggest that rhFIX produced from porcine milk is physiologically active and they support the use of transgenic animals as bioreactors for industrial scale production in milk.

Pilot production of recombinant human clotting factor IX from transgenic sow milk.

Valuable pharmaceutical proteins produced from the mammary glands of transgenic livestock have potential use in the biomedical industry. In this study, recombinant human clotting factor IX (rhFIX) produced from transgenic sow milk for preclinical animal studies have been established. The transgenic sow milk was skimmed and treated with sodium phosphate buffer to remove abundant casein protein. Then, the γ-carboxylated rhFIX fraction was segregated through the Q Sepharose chromatography from uncarboxylated one. For safety issue, the process included virus inactivation by solvent/detergent (S/D) treatment. Subsequently, the S/D treated sample was loaded into the Heparin Sepharose column to recover the rhFIX fraction, which was then reapplied to the Heparin Sepharose column to enhance rhFIX purity and lower the ratio of activated form rhFIX (rhFIXa) easily. This was possible due to the higher affinity of the Heparin affinity sorbent for rhFIXa than for the rhFIX zymogen. Furthermore, an IgA removal column was used to eliminate porcine IgA in purified rhFIX. Finally, nanofiltration was performed for viral clearance. Consequently, a high-quality rhFIX product was produced (approximately 700 mg per batch). Other values for final rhFIX preparation were as follows: purity, >99%; average specific activity, 415.6±57.7 IU/mL and total milk impurity, <0.5 ng/mg. This is the first report that described the whole process and stable production of bioactive rhFIX from transgenic sow milk. The overall manufacturing process presented here has the potential for industrial production of rhFIX for treatment of hemophilia B patients.

Expression of recombinant Hirudin in transgenic mice milk driven by the goat beta-casein promoter.

Hirudin, isolated from the leech Hirudo medicinalis, inhibits thrombin directly and several expression systems have been used to produce recombinant Hirudin (rHirudin) for pharmaceutical purposes. A DNA fragment containing the Hirudin coding sequence and goat beta-casein secretion signal was chemically synthesized in this study. The synthetic DNA then was further constructed into a goat beta-casein expression vector for mouse transgenesis. Four lines of transgenic mice were successfully developed and one line showed a meaningful anti-thrombin activity of 40,000 anti-thrombin units (ATU)/mL in their milk. In this animal line, Hirudin mRNA was found in samples of uterus and kidney with insignificant anti-thrombin activity (