RESUMO
In this work, the corn straw (CS) with concentrations of 3%, 6%, and 9% (w/v) were pretreated by rumen fluid (RF) and then used for batched mesophilic biogas production. The results showed that after a 6-day pretreatment, volatile fatty acid (VFAs) production of 3.78, 8.27, and 10.4 g/L could be found in 3%, 6%, and 9%, respectively. When concerning with biogas production, the highest accumulative methane production of 149.1 mL CH4/g volatile solid was achieved by 6% pretreated CS, which was 22% and 45% higher than 3% and 9%, respectively. Also, it was 3.6 times higher than the same concentration of unpretreated CS. The results of the microbial community structure analysis revealed that the 6% CS pretreatment not only maintained a microbial community with the highest richness and diversity, but also exhibited the highest relative abundance of Firmicutes (45%) and Euryarchaeota (3.9%). This high abundance was conducive to its elevated production of VFAs and methane. These findings provide scientific reference for the utilization of CS and support the development of agricultural waste resource utilization and environmental protection.
RESUMO
Although two-stage anaerobic digestion (TSAD) technology has been investigated, the mechanisms regarding the impact of acidogenic off-gas (AOG) on successive methane production have not been well addressed. In this study, a novel TSAD system was designed. Food waste, as the main substrate, was co-digested with chicken manure and corn straw. The acidogenic gas beyond atmospheric pressure was introduced into the bottom of the methanogenesis reactor through a stainless steel diffuser. Results showed the addition of AOG increased the methane yield from 435.2 to 597.1 mL/g VSin in successive methanogenesis stage, improved by 37.2 %, and increased the energy yield from 9.0 to 11.3 kJ/g VSsubstrate. However, the theoretical contribution of hydrogenotrophic methanogenesis using H2 contained in AOG was only 15.2 % of the increased methane yield. After the addition of AOG, the decreased levels of ammonia nitrogen and butyrate indicate that the stability of the AD system was improved. The electron transfer system and co-enzyme F420 activity were enhanced; however, the decrease in acetate kinase activity indicates aceticlastic methanogenesis may have been weakened. The microbial diversity and species richness were improved by the added AOG. Methanosarcina was more competitive than Methanothermobacter, enhancing the syntrophic effect. The relative abundance of protein degradation bacteria norank_f_Anaerolineaceae and lipid degradation bacteria Syntrophomonas was increased. Metabolite analysis confirmed that the addition of AOG promoted amino acid metabolism, the biosynthesis of other secondary metabolism and lipid metabolism. The improved degradation of recalcitrant organic components (lipids and proteins) in food waste was responsible for the increased methane yield. This study provides an in-depth understanding of the impact of AOG utilization on successive methane production and has practical implications for the treatment of food waste.
Assuntos
Biocombustíveis , Reatores Biológicos , Metano , Anaerobiose , Metano/metabolismo , Microbiota , EstercoRESUMO
The objective of this review is to encourage the technical development of biochar-assisted microbial fermentation. To this end, recent advances in biochar applications for microbial fermentation processes (i.e., non-methane products of hydrogen, acids, alcohols, and biofertilizer) have been critically reviewed, including process performance, enhanced mechanisms, and current research gaps. Key findings of enhanced mechanisms by biochar applications in biochemical conversion platforms are summarized, including supportive microbial habitats due to the immobilization effect, pH buffering due to alkalinity, nutrition supply due to being rich in nutrient elements, promoting electron transfer by acting as electron carriers, and detoxification of inhibitors due to high adsorption capacity. The current technical limitations and biochar's industrial applications in microbial fermentation processes are also discussed. Finally, suggestions like exploring functionalized biochar materials, biochar's automatic addition and pilot-scale demonstration are proposed. This review would further promote biochar applications in microbial fermentation processes for the production of non-methane products.
Assuntos
Reatores Biológicos , Carvão Vegetal , Fermentação , EcossistemaRESUMO
Slurry reflux is a low-cost slurry reduction technology, which can solve the problem that a large amount of slurry cannot be completely consumed in a biogas plant. Anaerobic digestion (AD) of corn stalks with slurry reflux and non-reflux was compared and evaluated in continuous anaerobic digestion to clarify the effects of slurry reflux on AD with organic loading rate (OLR) variation. It was found that slurry reflux increased cumulative methane production and improved system stability. The average methane yield of the slurry reflux group was 224.19 mL/gVS, which was 41.35% higher than that of the non-reflux group. High-throughput sequencing results showed that slurry reflux increased the microbial community richness. The dominant microorganisms in the reflux group were in phylum Bacteroidetes, which have the capacity to degrade polymers, and Methanothrix, which is an aceticlastic methanogen. The relative abundances of Bacteroidetes and Methanothrix were 32.41% and 41.75%, respectively. Clostridium III and Saccharofermentans, which are related to syntrophic acetate oxidation and hydrolysis, were increased in relative abundance in the slurry reflux system. The increase of the OLR altered the main methane-producing pathway from the acetoclastic methanogenic pathway to the hydrogenotrophic methanogenic pathway in the AD system, and the slurry reflux can delay this trend. This study provided an effective way for the reduction and utilization of slurry in a biogas plant.
Assuntos
Reatores Biológicos , Microbiota , Anaerobiose , Zea mays , Biocombustíveis , MetanoRESUMO
High impurity concentration of biogas limits its wide commercial utilization. Therefore, the integration of two-stage anaerobic digestion process with in situ biogas upgrading technologies is reviewed, with emphasis on their principles, main influencing factors, research success, and technical challenges. The crucial factors that influence these technologies are pH, alkalinity, and hydrogenotrophic methanogenesis. Hence, pH fluctuation and low gas-liquid mass transfer of H2 are some major technical challenges limiting the full-scale application of in situ upgrading techniques. Two-stage anaerobic digestion integration with various in situ upgrading techniques to form a hybrid system is proposed to overcome the constraints and systematically guide future research design and advance the development and commercialization of these techniques. This review intends to provide the current state of in situ biogas upgrading technologies and identify knowledge gaps that warrant further investigation to advance their development and practical implementation.
Assuntos
Biocombustíveis , Reatores Biológicos , Anaerobiose , Metano , Tecnologia , Dióxido de Carbono , HidrogênioRESUMO
Py-GC/MS and thermogravimetric analysis were carried out to systematically explore product selectivity and kinetics of poplar sawdust catalytic pyrolysis over bi-metallic Fe-Ni/ZSM-5. The results showed that the Fe-Ni/ZSM-5 exhibited an additive effect on the production of monocyclic aromatic hydrocarbons compared to mono-metallic catalysts (Fe/ZSM-5 or Ni/ZSM-5). Fe-Ni/ZSM-5 further increased the yield of toluene (17.28 mg g-1), which was 41.4% and 80.9% higher than Fe/ZSM-5 and Ni/ZSM-5, respectively. According to the kinetic analysis, the average activation energy obtained from catalytic pyrolysis with Fe-Ni/ZSM-5 using the methods of Friedman, Starink, Flynn-Wall-Ozawa, and Kissinger-Akahira-Sunose was 156.19, 152.39, 154.30, and 152.11 kJ mol-1, respectively. Fe-Ni/ZSM-5 addition lowered the activation energy compared to non-catalytic pyrolysis at the conversion rate of 0.15-0.75. The overall catalytic pyrolysis process of poplar sawdust follows the diffusion and nucleation models. The thermodynamic parameters (enthalpy and entropy) showed positive and negative values, respectively, indicating non-spontaneous reactions during the catalytic pyrolysis process.
Assuntos
Níquel , Pirólise , Biomassa , Catálise , Ferro , Cinética , TermogravimetriaRESUMO
Co-digestion is known to effectively alleviate trace elements (TEs) deficiency in mono-substrates; however, the bioavailability of TEs is crucial for the stability of anaerobic digestion. Therefore, this study investigated the effects of co-digestion of food waste (FW), corn straw (CS) and chicken manure (CM) in two-stage anaerobic digestion on TEs bioavailability and microbial community composition. Various VSFW:(VSCS:VSCM) ratios of 8:2, 7:3, 4:6, and 2:8 were evaluated in two-stage (group A, B, C, D) anaerobic digestion in which the VSCS:VSCM ratio was fixed at 3:1. Results showed that the highest hydrogen production of 106 mL/g VS and methane production co-efficiency of 125.3% was obtained in group A. Group A has a high close range of easily bioavailable TEs (32-64%) compared to other groups, especially the mono-substrate, where almost all TEs ranged between 10 and 36%. The increased relative abundance of the obligate hydrogenotrophic methanogens reflected a positive two-stage methane co-digestion efficiency.
Assuntos
Microbiota , Eliminação de Resíduos , Oligoelementos , Anaerobiose , Animais , Biocombustíveis , Disponibilidade Biológica , Reatores Biológicos , Galinhas , Digestão , Esterco , Metano , Zea maysRESUMO
Char-based catalyst has a promising application for biomass thermal conversion technology. In this work, Fe-Ni/Activated Char (AC) catalyst was prepared by impregnation method and used for the catalytic gasification of pine wood to obtain syngas. Further, the catalytic performance of Fe-Ni/AC was established by doing a comparative study of catalytic gasification of different biomass feedstocks. The results showed that under the catalysis of Fe-Ni/AC, the increase of gasification temperature was beneficial to increase gas yield, but not conducive to regulate the H2/CO ratio of syngas. The steam flow rate was directly related to the catalytic effect of Fe-Ni. The H2/CO ratio of syngas could reach 1.97 under the optimal conditions. Fe-Ni/AC had different catalytic effects on different biomass feedstocks, with the best for pine wood and the worst for cotton stalk, indicating that gasification intermediates of pine wood were difficult to decompose and depended more on catalyst.
Assuntos
Gases , Pinus , Biomassa , Catálise , VaporRESUMO
The synergistic effect of the cotton stalk (CS) and the high-ash coal (HAC) on the gas production in the co-pyrolysis/gasification processes was studied using the newly designed quartz boat in this work. The gas yield and the concentrations of main gas components were quantitatively compared between the co-pyrolysis/gasification and the individual pyrolysis/gasification. The results showed that the gas yield during the co-pyrolysis was promoted at 950â. There was almost no interaction between CS and HAC, since the co-pyrolytic gas yield exhibited a linear relationship with CS mixing ratio of 20% to 60%. The catalytic effect of alkali metals and alkaline earth metals that existed in CS, was enhanced by the addition of steam, and the synergistic effect was reduced while gas yield was enhanced with CS blending ratio increasing during co-gasification. The results provided a method to enhance synergistic effect between biomass and coal during co-pyrolysis/gasification in this study.
Assuntos
Carvão Mineral , Pirólise , Biomassa , Catálise , VaporRESUMO
The pretreatment effects and synergistic effects of anaerobic co-digestion of pretreated corn stover (CS) with chicken manure (CM) were studied. Results showed that the NaOH-H2O2 pretreatment effect on CS was better than urea pretreatment in terms of anaerobic digestion promotion. The highest cumulative methane yield of 332.7 mL/g VS added was obtained from the CS (NaOH-H2O2 pretreated)/CM ratio of 1:3, and the highest cumulative methane yield of 319.7 mL/g VS added was obtained from the CS (urea pretreated)/CM ratio of 1:2. Synergistic effects were found in CS (NaOH-H2O2 pretreated)/CM ratios of 2:1, 1:2, 1:3 and CS (urea pretreated)/CM ratios of 1:1, 1:2. Synergistic effect was not found at CS (unpretreated)/CM ratios of 1:2 and 1:3. Pretreatment of CS can produce synergistic effect on anaerobic co-digestion and increase cumulative methane yield by 6.54-24.65%. Among the four kinetic models, modified Gompertz model was best fitted in describing the methane production during anaerobic co-digestion (R2 = 0.9845-0.9988).
Assuntos
Biocombustíveis , Reatores Biológicos , Esterco , Metano/metabolismo , Zea mays/química , Anaerobiose , Animais , GalinhasRESUMO
The performance of biochar mediated anaerobic co-digestion (co-AD) of corn stover (CS) and chicken manure (CM) using continuous stirred tank reactor (CSTR) was studied. Results showed that urea pretreated CS (UPCS) and biochar addition in anaerobic digestion (AD) system can improve co-AD. The effect of urea pretreatment is similar to that of biochar addition, and their synergistic effect was apparent under medium and high OLR conditions. When the OLR was 4.2 and 6.3 g VS/L/d, the biochar mediated UPCS/CM co-AD operated stably with the VMP of 2.160 and 1.616 L/L/d, and VMP of the biochar mediated UPCS /CM were 32.8%-89.6% and 27.8%-96.4% higher than other reactors, respectively. The results reveal that urea pretreatment and biochar addition promoted AD process through strengthening the buffer capacity system established by ammonia nitrogen and volatile fatty acids and improving the degradation of lignocellulosic biomass.
Assuntos
Esterco , Zea mays , Anaerobiose , Animais , Biocombustíveis , Reatores Biológicos , Carvão Vegetal , Galinhas , Metano , UreiaRESUMO
In this work, a 30-days batched mesophilic assay on pretreated food waste (PFW) under different inoculum/substrate (I/S) ratios (1:5, 1:2, 1:1, 2:1, 4:1 and 1:0) was carried out, to target the most important parameters in AD matrix on regulating iron (Fe) chemical speciation. Correlation coefficients were calculated within four Fe chemical forms and AD parameters of pH, volatile fatty acids (VFAs), inorganic acid radicals (IARs), and alkalinity. Results showed that IARs were not key factors on regulating Fe speciation. Without acidification, IARs showed weak correlations (coefficientsâ¯<â¯0.40) with Fe chemical dynamics while other parameters showed stronger correlations (coefficientsâ¯≥â¯0.60). Under acidification, VFAs initiated the conversion of exchangeable Fe into water soluble fraction. Residual fraction might play important role in regulating Fe shifting to more bioavailable states.
Assuntos
Ácidos Graxos Voláteis , Ferro , Anaerobiose , Reatores Biológicos , AlimentosRESUMO
The different physicochemical properties of various agro-waste biomasses require a diversity of bioenergy utilization patterns. This study investigated the characteristics of a total of 74 manures and 78 crop straw samples from East China to identify the primary characteristic indicators that are essential to distinguish specific agro-wastes from others. Principal component analysis was applied, to discover critical features of biomass for the decision-making regarding the bioenergy production mode. The results identified the following four principal components of manures: "organic nutrients", "metals", "bioavailability of nutrients", and "toxic potential". For crop straws these were "lignocellulose/plant strength elements", "organics/inorganic metals for chlorophyll", "C/N", and "Na/Zn/fixed C". Considering the practical application significance of anaerobic digestion (AD) in the ecological civilization construction in rural China, the theoretical bio-methane potential was calculated based on the average values of different agro-biomasses from different areas. The results were 335.5-620.4 STPâ¯mL/g VS for manures and 434.0-540.3 STPâ¯mL/g VS for crop straws.
Assuntos
Esterco , Metano , Biomassa , ChinaRESUMO
The synergetic effects during co-pyrolysis of biomass and waste tire (WT) were investigated concerning the product distribution and reaction kinetics. Two biomass feedstocks were separately mixed with WT at different effective hydrogen/carbon ratio (H/Ceff), and analytical co-pyrolysis of mixtures was conducted using pyrolysis gas chromatography/mass spectroscopy at 500⯰C. Product distributions were similar between different biomass feedstocks but varied significantly at different H/Ceff values. The percentage of hydrocarbons increased significantly when increasing H/Ceff, and the optimal H/Ceff was determined considering the correspondingly higher yield of polycyclic aromatic hydrocarbons and char residuals at higher percentage of WT. The experimental derivative thermogravimetric curves of mixtures at the optimal H/Ceff were compared with the calculated results based on kinetic analysis of three individual components using the distributed activation energy model. Significant synergetic effects were observed at the initial and final stages of the pyrolysis process.
Assuntos
Eliminação de Resíduos , Biomassa , Carbono , Temperatura Alta , Hidrogênio , Cinética , TermogravimetriaRESUMO
The physicochemical properties and adsorption capacities of yak manure biochar (SP350-YMB) and modified yak manure biochar by H2O2 (AC-YMB) were investigated. Results showed the oxygen content and the carboxyl group content of manure biochar increased by 63.4% and 101%, and the ash content decreased 42% after modification, respectively. Compared to SP350-YMB, the adsorption capacities of heavy metal ions (Pb2+, Cu2+, Cd2+ and Zn2+) were enhanced by AC-YMB in single-metal and multi-metal solutions. The maximum adsorption capacity of Pb2+ increased from 76.41mgg-1 by SP350-YMB to 169.57mgg-1 by AC-YMB based on Langmuir-Freundlich model in single-metal solutions. Pseudo-first and Pseudo-second-order model were used to predict the Pb2+ adsorption kinetics by AC-YMB. H2O2 modification reduced ash content and increased carboxyl content resulting in the major mechanism of heavy metal sorption shifting from precipitation with carbonate/phosphate to complexation with carboxyl. Results from this study indicated that H2O2 modified biochar could act as effective surface sorbent to remove heavy metals, but its ability to remove multi-metal ions needs to be carefully evaluated on an individual basis.
RESUMO
The feasibility of co-digestion of chicken manure (CM) and maize silage (MS) without water dilution was investigated in 5-L digesters. Specific methane production (SMP) of 0.309LCH4g(-1) volatile solids (VS) was achieved but only at lower %CM. Above a critical threshold for total ammonia nitrogen (TAN), estimated at 7gNL(-1), VFA accumulated with a characteristic increase in acetic acid followed by its reduction and an increase in propionic acid. During this transition the predominant methanogenic pathway was hydrogenotrophic. Methanogenesis was completely inhibited at TAN of 9gNL(-1). The low digestibility of the mixed feedstock led to a rise in digestate TS and a reduction in SMP over the 297-day experimental period. Methanogenesis appeared to be failing in one digester but was recovered by reducing the %CM. Co-digestion was feasible with CM ⩽20% of feedstock VS, and the main limiting factor was ammonia inhibition.
Assuntos
Biocombustíveis , Reatores Biológicos , Esterco , Silagem , Zea mays , Amônia , Anaerobiose , Animais , Biocombustíveis/análise , Galinhas , Digestão , Metano/biossíntese , Gerenciamento de Resíduos/métodos , ResíduosRESUMO
Anaerobic digestions of pig manure (PM), dairy manure (DM), chicken manure (CM) and rabbit manure (RM) at initial volatile solid loading (VSL) of 8 g VS/L, 16 g VS/L, 32 g VS/L, 64 g VS/L were investigated under mesophilic conditions. The maximum methane yields of 410, 270, 377 and 323 mL CH4/g VSadded for PM, DM, CM and RM were all obtained at initial VSL of 8 g VS/L, respectively. The improvement of substrate concentration to 64 g VS/L not only decreased the methane yield and biodegradability both by 22.4%, 37.3%, 49.1% and 34.6% for PM, DM, CM and RM respectively, but also reduced the methane content in final biogas production. The Cone model (R(2): 0.9910-0.9974) showed a better fit to the experiment data and the calculated parameters indicated that anaerobic digestion of manures at higher loading has longer lag phase and lower hydrolysis rate.
Assuntos
Digestão , Gado , Esterco/análise , Anaerobiose , Animais , Biodegradação Ambiental , Biocombustíveis , Galinhas , Hidrólise , Cinética , Metano/biossíntese , Modelos Teóricos , Coelhos , SuínosRESUMO
The degradation kinetics of swine and buffalo manure for methane production was investigated. Six kinetic models were employed to describe the corresponding experimental data. These models were evaluated by two statistical measurements, which were root mean square prediction error (RMSPE) and Akaike's information criterion (AIC). The results showed that the logistic and Fitzhugh models could predict the experimental data very well for the digestion of swine and buffalo manure, respectively. The predicted methane yield potential for swine and buffalo manure was 487.9 and 340.4 mL CH4/g volatile solid (VS), respectively, which was close to experimental values, when the digestion temperature was 36 ± 1 °C in the biochemical methane potential assays. Besides, the rate constant revealed that swine manure had a much faster methane production rate than buffalo manure.
Assuntos
Búfalos , Esterco/microbiologia , Metano/biossíntese , Suínos , Animais , Cinética , Dinâmica não LinearRESUMO
The three-parallel-DAEM-reaction model was used to study the slow pyrolysis kinetics of rice straw based on thermogravimetric analysis (TGA) data. The kinetic parameters of the model were calculated using the pattern search method. A comparison between the predicted DTG data and experimental values showed good agreement. The influences of the kinetic parameters on the model for describing the experimental data of rice straw were analyzed by means of local parametric sensitivity analysis. The results indicated that the frequency factor and the mean value of the activation distribution for cellulose decomposition affect the model more strongly than other parameters, followed by the corresponding parameters for hemicellulose and lignin. The sensitivity of the model to the standard deviations of the activation energy distributions for all pseudocomponents is very slight.
Assuntos
Biocombustíveis , Temperatura Alta , Lignina/química , Modelos Químicos , Oryza/química , Caules de Planta/química , Biomassa , China , Cinética , Sensibilidade e Especificidade , TermogravimetriaRESUMO
The effect of particle size on the gasification performance of a pilot-scale (25 kg/h) downdraft fixed bed gasification system was investigated using prunings from peach trees at five different size fractions (below 1, 1-2, 2-4, 4-6 and 6-8 cm). The gas and hydrocarbon compositions were analyzed by gas chromatography (GC) and gas chromatography/mass spectrometry (GC-MS), respectively. With increasing particle size, gas yield increased while tar and dust content decreased. The lower heating value of the gas decreased slightly with particle size. At a smaller particle size, more hydrocarbons were detected in the producer gas. Hydrogen and carbon dioxide contents increased with the decrease in particle size, reaching 16.09% and 14.36% at particle size below 1cm, respectively. Prunings with a particle size of 1-2 cm were favorable for gasification in the downdraft gasifier used in this study.