Bioavailability of Bioactive Compounds from Reconstituted Grapefruit Juice as Affected by the Obtention Process.

Much attention has been paid to the health benefits of including fruits and vegetables in the diet. However, for the compounds responsible for this beneficial effect to be effective at the level of the human organism, they must be available for absorption after digestion. In this sense, in vivo studies are needed to demonstrate the bioavailability of these compounds and their physiological activity. In order to provide information in this regard, this study collects data on the levels of vitamin C (VC) and naringenin (NAG) in the blood serum of the 11 volunteer participants in this trial, before and after consuming two different grapefruit juices. The juices were prepared by rehydrating the grapefruit powder obtained by freeze-drying (FD) the fruit puree or by spray-drying (SD) the liquefied grapefruit. No significant differences (p > 0.05) neither by juice nor by participant were observed in any case. The mean relative increase of VC, NAG and the radical scavenging ability (RSA) in blood serum due to grapefruit juices intake was 12%, 28% and 26%, respectively. Just VC showed a positive and significant Pearson's correlation with RSA. The mean bioavailability of VC was quantified as 1.529 ± 0.002 mg VC/L serum per 100 mg of VC ingested.

Composition of Powdered Freeze-Dried Orange Juice Co-Product as Related to Glucose Absorption In Vitro.

The reuse of food by-products is crucial for the well-being of the planet. Considering the high content of nutrients and other bioactive compounds in many of them, investigating their suitability for use as human food ingredients is an interesting challenge. In this study, in addition to the proximate composition, phenol content and antioxidant activity (AOA = 3.2 mmol Trolox equivalent (TE)/100 g, db) of orange juice powder by-product (CoP), different in vitro properties related to carbohydrate metabolism have been characterised. Specifically, the glycaemic index (GI), the glycaemic load (GL), the glucose dialysis retardation index (GDRI = 13.6%), the glucose adsorption capacity (GAC = 22.5 mM) and the inhibition capacity of α-amylase (α-A = 46.9%) and α-glucosidase (α-G = 93.3%) of powdered orange juice waste have been determined and related to fibre and phenolics composition. Taking advantage of the high fibre content of the by-product (36.67%), its GL was calculated for a CoP dose that allows labelling the food to which it is added as a source of fibre. The low GI value (24.4%) and the low GL (0.918 g available carbohydrates per serving) allowed us to conclude that the product studied could be an interesting opportunity for the food industry to offer it as a healthy food ingredient to be included in the diet, especially for those suffering from type 2 diabetes mellitus. Of the total phenolic compounds (TP = 509 mg equivalent of gallic acid (GAE)/100 g, db), 68% were found in free fraction (FP), and their contribution to the total AOA was 40.6%, while this was 54.9% for the 32% of phenols bound to plant tissues (BP).

In Vitro Bioaccessibility of Bioactive Compounds of Freeze-Dried Orange Juice Co-Product Formulated with Gum Arabic and Modified Starch.

The large amount of waste generated by the orange juice industry has sparked the interest of many researchers in incorporating recycling systems and following a much more sustainable circular economy model. This work proposes the valorization of the co-product generated in the orange juice extraction industry after freeze-drying for its subsequent reuse as a natural ingredient in the food industry. In addition, the possible protective effect of gum Arabic and corn starch esterified with octenyl succinic groups, in proportions optimised in previous studies 0.25 and 0.45 g/g orange co-product dry solutes, on the main bioactive compounds of orange peel during the freeze-drying process has been studied. The samples were characterised for their content of vitamin C (ascorbic and dehydroascorbic acids), flavonoids (hesperidin and narirutin), total phenols and total carotenoids, as well as their antioxidant capacity (DPPH and FRAP assays). In addition, samples were digested, mimicking the human enzymatic oral gastro-intestinal digestion process, and the bioaccessibility of the bioactive compounds was evaluated. It was observed that the addition of both biopolymers improved the stability of the hydrophilic compounds during freeze-drying. This conservative effect was more remarkable for higher biopolymer concentrations. However, no protective effect on carotenoid compounds was observed. This trend was reflected in the antioxidant activity of the different samples. In addition, the incorporation of biopolymers improved the bioaccessibility of the bioactive compounds studied. In conclusion, the results supported the feasibility of the freeze-dried orange juice co-product as a natural, sustainable source of health-promoting compounds.

Free and Bound Phenolic Compounds Present in Orange Juice By-Product Powder and Their Contribution to Antioxidant Activity.

Interest in fruit/vegetable consumption is not always linked to a particular diet but rather derives from their high antioxidant activity (AOA), with potential health benefits provided, in part, by polyphenols. Although phenols can be found in free form (FP) or bound to plant tissues (BP), the experimental methodology most frequently used for the quantification of total phenols (TP) is based on the extraction of a portion of FP, which may justify the lack of correlation often found between them and AOA. In this context, four successive extractions were performed to obtain FP and BP of powdered orange juice by-product, and their contribution to the AOA was studied. The first extract (MeOH, 30 °C) can be assumed to be one of the conventional methods for the quantification of TP. Re-extraction with MeOH (60 °C) afforded the FP. Two subsequent basic and acidic extractions yielded the BP. Although the FPs were the most abundant, the AOA (DPPH method) of the last fraction of BP was of the same order found in the first fraction of FP. This highlights the interest in extracting the BP from the by-product of orange juice if its antioxidant capacity is to be exploited.

Influence of formulation on the quality and stability of a freeze-dried Mandarin product.

Consumers demand products of high quality, healthy, safe, and easy to manage. A freeze-dried fruit snack can meet this demand, but this kind of product may collapse rapidly, becoming highly sticky. To avoid this, adding biopolymers can improve their stability. Nevertheless, these biopolymers can negatively affect other quality characteristics such as the color, texture, and flavor. Therefore, selecting the best biopolymer or combination of biopolymers is an indispensable task to offer freeze-dried fruit. The aim of this study was to know the impact of gum Arabic, starch modified with octenyl succinic anhydrous, bamboo fiber and milk protein isolate on the color, glass transition temperature, and stability of some textural related properties of a freeze-dried mandarin snack. The study showed the convenience of incorporate mixtures of the considered biopolymers to mandarin puree as to ensure the crispy character of the snack, associated with its glassy state, without this having a significant impact on the product color. The best formulation was that obtained with a mix of gum Arabic and bamboo fiber.

Characterization of the Orange Juice Powder Co-Product for Its Valorization as a Food Ingredient.

The citrus juice industry produces a large amount of fiber-rich waste and other bioactive compounds of great interest for their potential health benefits. This study focuses on the valorization of the co-product resulting from the extraction of orange juice to offer it as a versatile, healthy, high-quality, and stable natural food ingredient in powder form. To this end, the vitamin C (VC) content (ascorbic and dehydroascorbic acid, AA and DHAA), major flavonoids (hesperidin and narirutin, HES and NAT), and techno-functional properties (angle of repose, AoR; hygroscopicity and wettability; density and porosity; mean particle size, MPS; water retention capacity, WRC; oil holding capacity, ORC; emulsifying and foaming capacity, EC and FC; and emulsion and foam stability, ES and FS) have been characterized. In addition, considering that dehydrated foods with high sugar content require the incorporation of high molecular weight biopolymers for their physical stabilization, the influence of starch modified with octenyl succinic acid (OSA) and gum Arabic (GA) on these properties has been studied. The results obtained confirm the high quality of this co-product to be offered as a powdered food ingredient with nutraceutical potential. The addition of the studied biopolymers is recommended as it does not modify the flowability of the powder and favors both the encapsulation of the bioactive compounds, especially in the presence of GA, and the rehydration capacity.

Impact of the Freeze-Drying Conditions Applied to Obtain an Orange Snack on Energy Consumption.

Nowadays, the consumer is looking for healthier, more attractive, ready-to-eat, and safer foodstuffs than fresh products. Despite freeze drying being known for providing high added value products, it is a slow process which is conducted at low pressures, so, in terms of energy consumption, it turns out to be quite costly for the food industry. With the purpose of obtaining a freeze-dried orange puree, previously formulated with gum Arabic and bamboo fiber, which can be offered to consumers as a snack at a low economic cost, the impact of the process conditions on energy consumption has been considered. The product temperature evolution and the energy consumption were registered during the drying of frozen samples at different combinations of chamber pressures (5 and 100 Pa) and shelf temperatures (30, 40 and 50 °C). In each case, the time processing was adapted in order to obtain a product with a water content under 5 g water/100 g product. In this study, the secondary drying stage was considered to start when the product reached the shelf temperature and both the pressure and the temperature affected the duration of primary and secondary drying stages. The results obtained led to the conclusion that the shorter duration of the process when working at 50 °C results in significant energy saving. Working at a lower pressure also contributes to a shortening of the drying time, thus reducing the energy consumption: the lower the temperature, the more marked the effect of the pressure.

Quality of a powdered grapefruit product formulated with biopolymers obtained by freeze-drying and spray-drying.

Freeze-drying and spray-drying are two techniques used to produce dehydrated food products. Both techniques are easy to use and offer high sensory, nutritive value, and functional quality to foods. However, both processes become difficult for foods with high sugar and acid content, such as fruits. This is because these products, once dehydrated, moisten quickly, causing a change in their physical properties, mainly in the mechanical aspects related to the start of a caking phenomenon. Therefore, incorporating high molecular weight biopolymers that act as facilitators or processors, prevent the structural collapse of the product. The aim of this study was to select the best process, between freeze-drying or spray-drying, to obtain a powdered grapefruit product with the higher quality. The impact of the biopolymers used to stabilize the powdered product was also tested. The properties analyzed were the solubility, wettability, hygroscopicity, porosity, and color of the powder together with the flow behavior, both in air and water. The results of this study show that using the freeze-drying technique, products have a better flow behavior, greater porosity, and a color more like fresh grapefruit. Biopolymers, especially when in combination, have a positive effect on the quality parameters studied. PRACTICAL APPLICATION: The results of this study allow freeze-drying to be proposed as a process to obtain a grapefruit product with better properties, both powdered and rehydrated, than that obtained by spray-drying. On the other hand, although the incorporation of biopolymers is necessary to facilitate the process and stabilize the product, no significant differences have been found between the different formulations tested, although it seems that their combination favours some of the properties of the powder, such as solubility, hygroscopicity, wetting time and dispersibility.

Protective capacity of gum Arabic, maltodextrin, different starches, and fibers on the bioactive compounds and antioxidant activity of an orange puree (Citrus sinensis (L.) Osbeck) against freeze-drying and in vitro digestion.

Dehydrated fruit puree may be a convenient way to promote the healthy consumption of fruit based foods. Drying carriers, highly used by the food industry to stabilize dried fruit products, may show a potential encapsulating capacity of the biocompounds, that could also limit their bioaccesibility. This study analyzed the impact of gum Arabic (GA), bamboo fiber (BF), native corn starch, starch substituted with octenylsuccinic groups, pea fiber, and maltodextrin on the in vitro bioaccessibility of vitamin C (VC), total phenols (TP), and ß-carotene, as well as on the antioxidant capacity during the freeze-drying and in vitro digestion of an orange puree. Amongst the formulations studied, GA + BF was the most effective for phytochemicals protection of the freeze-dried orange puree during the intestinal stage of digestion, resulting in a higher TP and VC bioaccessibility (59% and 36%, respectively).

Impact of freeze-drying conditions on the sensory perception of a freeze-dried orange snack.

BACKGROUND: The health benefits provided by fruit mean that there is continuous interest in offering consumers new products to stimulate its consumption. To this end, dehydrated fruit snacks may be an interesting option. In this study, we evaluated the impact of freezing rate (slow and high), shelf temperature (40 and 50 °C), and working pressure (5 and 100 Pa) on the perception and acceptability of a freeze-dried orange snack obtained from an orange puree. RESULTS: Of the different freeze-drying conditions studied, working pressure was the variable with the greatest effect. The lowest working pressure (5 Pa) led to samples being obtained with a slightly lower water content, which was perceived with higher citrus flavor and crispiest. The highest pressure (100 Pa) led to samples with a greater water content, perceived with a more yellow intense color. Nevertheless, there is no significant consumer preference for any of the different processed samples. The number of force peaks, which is positively correlated with the crispness, shows a significant and negative correlation (r = -0.91) with the water content of the sample. CONCLUSION: The study revealed that considerations other than the sensory can determine the best conditions of the freeze-drying process with which to obtain an orange snack. The number of force peaks obtained from a penetration test may be proposed as a tool for instrumental analysis of the snack's crispness that supplies information closely resembling customer perception of this attribute. © 2021 Society of Chemical Industry.

Novel Ingredients Based on Grapefruit Freeze-Dried Formulations: Nutritional and Bioactive Value.

Grapefruit is a fruit with interesting nutritional value and functional properties, but a short life. Freeze-drying (FD) is a valuable technique as it produces high-quality dehydrated products. This study is aimed to obtain new food ingredients based on freeze-dried grapefruit formulated with high molecular weight solutes (gum arabic and bamboo fiber) in three different proportions (F1, F2, and F3). To improve the FD, a mild microwave drying pre-treatment was applied. Influence of the water content and the presence of high molecular weight solutes on freeze-drying kinetics was tested by Midilli-Kucuk and Page models. The best FD kinetic model fit on grapefruit powders were Midilli-Kucuk for F2 and F3, and Page for F1, and the adequate freeze-drying times for F1, F2, and F3 were 24, 16, and 18 h, respectively. Final samples were evaluated for nutritional and antioxidant capacity. Gum arabic and bamboo fiber present a protector effect, which results in a significant antioxidant capacity due to the protection of flavonoids and antioxidant vitamins. These novel food ingredients could be of great interest for the food industry in order to develop foods with improved antioxidant capacity as well as enriched in natural fibers and/or micronutrients.

Insights into the development of grapefruit nutraceutical powder by spray drying: physical characterization, chemical composition and 3D intestinal permeability.

BACKGROUND: The development of functional and nutraceutical foods comes from a greater awareness of the relationship between food and health by consumers. In recent years, the idea of purifying and encapsulating bioactive compounds through techniques such as spray drying has been well received by the food industry. The development and characterization of a grapefruit (Citrus paradisi) nutraceutical powder obtained by spray drying is of great interest owing to the different bioactive compounds and the potential health effects. RESULTS: The grapefruit powder was characterized by a low water amount (1.5 g water per 100 g powder) and a high porosity (75%). The color parameters were L* = 80.0 ± 1.8, hab * = 61.7 ± 0.4 and Cab * = 11.4 ± 0.6. The IC50 values determined for the freeze-dried oxalic acid extract (FDOA) and the freeze-dried methanol-water extract (FDMW) were 0.48 and 0.72 mg mL-1 respectively, while the total phenolic content (TPC) ranged between 1274 and 1294 mg gallic acid equivalent (GAE) per 100 g dry basis (d.b.). Regarding total flavonoid content (TFC), FDOA presented the highest amount (6592 mg quercetin equivalent (QE) per 100 g d.b.). For both extracts, the cell viability in Caco-2 and HT29-MTX was above 90% at 100 µg mL-1 . The bioavailability of the bioactive compounds was analyzed through a 3D intestinal model. Delphenidin-3-glucoside and hesperitin-7-O-glucoside presented a permeation higher than 50%, followed by hesperidin which was close to 30%. CONCLUSION: This work allows to establish that the formulation of grapefruit powder has great potential as a nutraceutical food, with spray drying being a good alternative technique in the food industry. © 2019 Society of Chemical Industry.

The Impact of Freeze-Drying Conditions on the Physico-Chemical Properties and Bioactive Compounds of a Freeze-Dried Orange Puree.

Fruits are essential for a healthy diet, as they contribute to the prevention of cardiovascular diseases and some cancers, which is attributed to their high bioactive compound content contributing to their antioxidant capacity. Nevertheless, fruits have a short shelf life due to their high-water content, and freeze-drying is a well-known technique to preserve their nutritive quality. However, it is an expensive technology, both due to the use of low pressure and long processing time. Therefore, an optimisation of variables such as the freezing rate, working pressure and shelf temperature during freeze-drying may preserve fruit quality while reducing the time and costs. The impact of these variables on colour, porosity, mechanical properties, water content, vitamin C, total phenols, ß-carotene, and antioxidant activity of a freeze-dried orange puree was evaluated. The results showed a great impact of pressure and shelf temperature on luminosity, chroma and water content. Vitamin C and ß-carotene were more preserved with higher shelf temperatures (shorter times of processing) and lower pressure, respectively. The optimum freeze-drying conditions preserving the nutrients, and with an interesting structural property, perceived as a crunchy product by consumers, are low pressure (5 Pa) and high shelf temperature (50 °C).

Sensory characterization of juice obtained via rehydration of freeze-dried and spray-dried grapefruit.

BACKGROUND: The acceptability of grapefruit juice obtained from rehydrated freeze-dried and spray-dried fruit was studied and compared with that of natural freshly squeezed juice and that of a commercial juice. The rheological properties, colour and solute concentration were determined. A sensory evaluation was developed to evaluate juice acceptability. Furthermore, a penalty analysis was used to determine the attributes with improvement potential as well as some CATA (check all that apply) questions, where consumers marked the most characteristic attributes of each sample. RESULTS: The rehydrated samples were different from the commercial and natural juices. When grapefruit is freeze-dried or spray-dried, gum arabic and bamboo fibre are added and part of the fruit pulp is present; this is not so in the other juices under study. This supposes greater viscosity, luminosity and chroma together with a reddish tone of the rehydrated juices, especially the freeze-dried ones. It also affects their acidity, astringency and sweetness. CONCLUSION: Rehydrating the freeze-dried or spray-dried powder to the level of the natural juice, instead of that of the crushed or liquidized grapefruit, and incorporating sugar at this stage would probably improve the quality of the samples. © 2018 Society of Chemical Industry.

Sanguinello and Tarocco (Citrus sinensis [L.] Osbeck): Bioactive compounds and colour appearance of blood oranges.

Sanguinello and Tarocco (Citrus sinensis [L.] Osbeck) are the most common and widespread blood oranges varieties in the Mediterranean climate area. Its interest is increasing mainly due to nutritional and organoleptic properties. In this work, three blood orange varieties cultivated in Spain (Sanguinelli, Tarocco Rosso and Tarocco Ippolito) were characterized in relation to physicochemical parameters and relevant bioactive compounds (vitamin C, organic acids, flavonoids and anthocyanins) as well as colour characterization. All samples showed important vitamin C values (higher than 54.9 mg/100 g of edible portion). Flavonoids represent the largest family of phenolic compounds, being hesperidin, the major flavonoid. Ten different anthocyanins were identified in blood oranges, seven cyanidin derivatives and three delphinidin derivatives, being the most abundant cyanidin 3-(6″-malonylglucoside) and cyanidin 3-glucoside. Blood oranges can show an intense reddish colour in peel whereas the pulp has a yellow-orange colour. Overall, these varieties are good sources of bioactive compounds.

Antioxidant and anti-inflammatory activities of freeze-dried grapefruit phenolics as affected by gum arabic and bamboo fibre addition and microwave pretreatment.

BACKGROUND: Recent epidemiological studies have suggested that phenolic compounds present in grapefruit play an important role in the bioactive properties of this fruit. However, the consumption of fresh grapefruit is low. Freeze-dried powdered grapefruit can be an alternative to promote this fruit consumption. To improve the quality and stability of the powdered fruit, encapsulating and anticaking agents can be added. In the present study, different grapefruit powders obtained by freeze-drying with the addition of gum arabic (1.27 g per 100 g) and bamboo fibre (0.76 g per 100 g) with and without a pre-drying microwave treatment were compared with the fresh and freeze-dried fruit with no carriers added, aiming to evaluate the effect of these preservation processes on phenolics content and on its antioxidant [1,1-diphenyl-2-picrylhydrazyl (DPPH), 2,2'-azinobis(3-ethylbenzothiazoline-6-sulphonic acid) (ABTS) and ferric reducing ability of plasma (FRAP)] and anti-inflamatory (evaluated in RAW 264.7 macrophages) capacities. RESULTS: Freeze-drying and gum arabic and bamboo fibre addition significantly increased total phenolics, as well as the antioxidant and anti-inflammatory activities (by inhibiting nitric oxide production of lipopolysaccharide activated RAW 264.7 macrophages), of grapefruit. An additional increase in these parameters was obtained with microwave pretreatment before freeze-drying. CONCLUSIONS: The combined addition of gum arabic and bamboo fibre to grapefruit puree and the application of a microwave pretreatment improve the functional properties of the fruit without showing cytotoxicity in vitro. © 2017 Society of Chemical Industry.

Physicochemical properties and structural characteristics of whole grain Oryza sativa L. with different treatments.

Physicochemical properties and structural characteristics of whole rice flours with different treatments (soaking, germination and extrusion cooking) were studied. Water solubility, water absorption, crystallinity, adsorption isotherms (BET and GAB models), and glass transition temperature of the samples were determined. Water solubility and water absorption were enhanced by extrusion cooking process (3.17-4.98 vs. 24.1-53.76 g/100 g and 2.77-3.05 vs. 4.46-7.04 ml/g, respectively), but crystallinity was decreased (30-33 vs. 4-16%). Adsorption isotherms showed that extruded samples exhibited higher equilibrium moisture content as compared with their corresponding non-extruded samples (5.0-19.2 vs. 4.0-16.1 g water/g solids). There were no changes in glass transition temperature values in the studied moisture range (3.8-16 g/100 g). These results allow the correct use of whole rice flours with different treatments in foods and also contributed to the knowledge of stabilization of the products.

Chlorophylls and carotenoids of kiwifruit puree are affected similarly or less by microwave than by conventional heat processing and storage.

The impact of microwave (1000 W - 340 s) and conventional heat (97 °C - 30s) pasteurisation and storage (4, 10, 22 °C for up to 63 d) on total and individual carotenoids and chlorophylls in kiwifruit puree was evaluated. Bioaccessibility of carotenoids, before and after pasteurisation and storage, was also studied. Microwaves and conventional heating led to marked changes in the chlorophyll (42-100% losses) and carotenoid (62-91% losses) content. First- and second-order kinetics appropriately explained the degradation of total carotenoids and chlorophylls over time, respectively. Pasteurised samples showed significantly (p < 0.05) enhanced stability of these pigments, with microwaves (k = 0.007-0.031100 g mg(-1) day(-1) at 4-22 °C) promoting chlorophyll stability to a greater extent than conventional heating (k = 0.0015-0.034100 g mg(-1) day(-1) at 4-22 °C). Bioaccessibility of carotenoids remained (p < 0.05) unaffected by processing and storage. These results highlighted that the pigment composition of microwaved kiwifruit was more similar to that of the fresh fruit and better preserved during storage.

Significance of osmotic temperature treatment and storage time on physical and chemical properties of a strawberry-gel product.

BACKGROUND: The development of fruit-based foods that maintain the nutritional and sensory properties of fresh fruit may help to stimulate fruit consumption by consumers. The possibility of formulating a fruit-gel product with osmodehydrated fruit and the reused osmotic solution (OS) obtained from the dehydration step has been demonstrated. However, the conditions of the osmotic process can significantly affect the properties of the obtained product. In this work an osmotic process at 22 °C for 6 h and at 30 °C for 3 h was employed to formulate a strawberry-gel product. RESULTS: Significant losses of ascorbic and citric acids and anthocyanins were observed and some relevant volatile compounds of the strawberry aroma profile were developed during the osmotic process. Changes in all analysed parameters occurred mainly during the first 2 days of storage. The flux of anthocyanins from the fruit to the gel gave an attractive appearance to the formulated product. These changes were more marked for samples obtained at 30 °C. CONCLUSION: Osmotic treatment at 30 °C was more suitable for formulation of the product, because the presence of nutritional/functional compounds in the OS, and consequently in the gel matrix, was higher and the aroma and colour were more stable and homogeneous during storage.