Exposure of cryopreserved red cell concentrates to real-world transient warming events has a negligible impact on quality.

BACKGROUND: Red cell concentrates (RCCs) may be cryopreserved at Canadian Blood Services (CBS) for up to 10 years; however, inadvertent warming of these units over the prescribed storage temperature (≤ -65°C) may occur. These units may be discarded from inventory to avoid potential adverse transfusion outcomes. This study aimed to assess the quality of RCCs that experienced unintentional transient warming events (TWEs) related to freezer failures. STUDY DESIGN: Thirty cryopreserved RCCs with known TWEs were selected for this study and classified into three different experimental groups (Event 1 (n = 5) TWE > -65°C for 34 min; Event 2 (n = 23) TWE > -65°C for 48 h; and both Event 1 and Event 2 (n = 2) TWE > -65°C for 34 min and 48 h). Ten additional RCCs with no known TWEs, cryopreserved over the same period, were selected as controls. Thawed RCCs were deglycerolized using the Haemonetics ACP 215, and in vitro quality was assessed throughout hypothermic storage. RESULTS: RCCs from the control and all three experimental groups met the Canadian Standards Association (CSA) guidelines for hematocrit, total hemoglobin, and hemolysis at expiry. RCCs experiencing a singular TWE had similar in vitro quality to control RCCs. DISCUSSION: This study's findings revealed that single exposures to specific documented TWEs did not significantly impact the quality of RCCs post-deglycerolization. While units should still be assessed on a case-by-case basis upon TWE, our work provides the first-ever evidence that supports a broader policy of unit retention by blood centers.

Shipment of Glycerolized RBC Segments for Red Cell Concentrate Compatibility Testing.

Background: Red cell concentrate (RCC) cryopreservation allows for long-term storage of RCCs with rare phenotypes. Currently, tubing segments are not produced for these frozen units. Pre-transfusion compatibility testing therefore requires thawing and deglycerolization of the whole unit. A study was conducted to demonstrate the feasibility of using segments for compatibility testing, including circumstances where segments would require shipment to a reference laboratory. Study Design and Methods: RCCs produced using the red cell filtration method from citrate-phosphate-dextrose whole blood collections were glycerolized (40%) at day 21 post-collection and segments were generated prior to freezing. Room temperature (RT, 18°C-20°C) or water bath (WB, 37°C) thawing of segments was performed prior to storage at RT or at refrigerated temperatures (cold, 1°C -6°C) for 0, 24, 48, or 72 hours followed by deglycerolization and hemolysis testing. Additional segments were thawed and shipped in temperature-controlled containers at either RT or 1°C -10°C for antibody screening. Results: Hemolysis and RBC recovery results did not show significant differences over the storage period or between thawing and storage conditions. RBC recovery ranged from 46% to 64%. Hemoglobin (Hb) recovery ranged from 56% to 96%; for RT-thawed segments, recovery was significantly higher at 24 hours and lower at 72 hours for RT storage compared with cold storage. WB-thawed, cold-stored segments had higher Hb recoveries at 48 hours. Phenotype assessment was successful for all segments regardless of thawing method or shipping condition. Discussion: The shipment of thawed segments containing glycerolized red cells is feasible for the purpose of conducting pretransfusion phenotype evaluations or pretransfusion compatibility checks.

Modification of deglycerolization procedure improves processing and post-thaw quality of cryopreserved sickle trait red cell concentrates.

Red blood cell (RBC) transfusion is a critical therapy for those with sickle cell disease (SCD). Alloimmunization is frequent for those with SCD and may limit the availability of matched RBC. Cryopreserved RBCs, from family members or donors with a similar RBC antigen profile could provide a viable alternative to avoid further alloimmunization and prevent hemolytic transfusion-related events. However, cryopreserved SCD and Sickle Cell trait (S-trait) donor RBC units suffer from reduced recovery following deglycerolization. This study proposes and tests a modified deglycerolization protocol using an automated cell processor to mitigate RBC loss. Six red cell concentrates (RCC) from donors with S-trait and six control RCCs were glycerolized, frozen (<-65 °C) and deglycerolized on the ACP 215 using modified parameters (decreased hypertonic solution flow rate (100 mL/min) and hypertonic equilibration delay (120 s), and increased NaCl dilution volumes (500 mL). Quality testing included: hematocrit (HCT), hemolysis, indices, extracellular potassium, morphology, osmotic fragility, osmotic gradient ektacytometry, hemoglobin (HGB), and recovery. Canadian standards (CS) indicate that acceptable deglycerolized units for transfusion require a HCT ≤0.80 L/L, HGB ≥35 g/unit, and hemolysis <0.8 % in 90 % of units tested. No significant differences in HGB or RBC recovery were observed between study groups. Significant differences between study groups were identified in osmotic fragility and osmotic gradient ektacytometry parameters. Of the 6 S-trait RCCs, 3/6 units were within the HCT, HGB and hemolysis thresholds set by the CS. The modified deglycerolization protocol provides a path for the routine cryopreservation of S-trait RBCs.

Estimated median density identifies donor age and sex differences in red blood cell biological age.

BACKGROUND: Donors possess heterogeneous red cell concentrates (RCCs) in terms of the biological age of their red blood cells (RBCs) as a direct result of various donor-dependent factors influencing rates of erythropoiesis. This study aimed to estimate the median biological age of RBCs in RCCs based on donor age and sex to investigate inherent differences in blood products' biological ages over hypothermic storage using estimated median densities (EMDs). STUDY DESIGN: Sixty RCCs were collected from four donor groups; male and female teenagers (17-19 years old) and seniors (75+ years old). A Percoll density-based separation approach was used to quantify the EMDs indicative of biological age. EMD and mean corpuscular hemoglobin (MCHC) were compared by correlation analyses. RESULTS: Differences in the median biological age of RCC units were observed with male donors having significantly higher EMDs compared to females (p < .001). Teen male donors possessed the highest EMDs with significantly elevated levels of biologically aged RBCs compared to both female donor groups, regardless of storage duration (p < .05). Throughout most of the 42-day storage period, senior donors, particularly senior females, demonstrated the strongest correlation between EMD and MCHC (R2 > 0.5). CONCLUSIONS: This study provides further evidence that there are inherent differences between the biological age profiles of RBCs between blood donors of different sex and age. Our findings further highlight that biological age may contribute to RBC quality during storage and that donor characteristics need to be considered when evaluating transfusion safety and efficacy.

Red cell concentrates from teen male donors contain poor-quality biologically older cells.

BACKGROUND AND OBJECTIVES: Donor factors influence the quality characteristics of red cell concentrates (RCCs) and the lesions that develop in these heterogeneous blood products during hypothermic storage. Teen male donors' RCCs contain elevated levels of biologically old red blood cells (RBCs). The aim of this study was to interrogate the quality of units of different donor ages and sexes to unravel the complex interplay between donor characteristics, long-term cold storage and, for the first time, RBC biological age. MATERIALS AND METHODS: RCCs from teen males, teen females, senior males and senior females were density-separated into less-dense/young (Y-RBCs) and dense/old RBCs (O-RBCs) throughout hypothermic storage for testing. The unseparated and density-separated cells were tested for haematological parameters, stress (oxidative and osmotic) haemolysis and oxygen affinity (p50). RESULTS: The O-RBCs obtained from teen donor samples, particularly males, had smaller mean corpuscular volumes and higher mean corpuscular haemoglobin concentrations. While biological age did not significantly affect oxygen affinity, biologically aged O-RBCs from stored RCCs exhibited increased oxidative haemolysis and decreased osmotic fragility, with teenage male RCCs exhibiting the highest propensity to haemolyse. CONCLUSION: Previously, donor age and sex were shown to have an impact on the biological age distribution of RBCs within RCCs. Herein, we demonstrated that RBC biological age, particularly O-RBCs, which are found more prevalently in male teens, to be a driving factor of several aspects of poor blood product quality. This study emphasizes that donor factors should continue to be considered for their potential impacts on transfusion outcomes.

Risk factors for T-cell lymphopenia in frequent platelet donors: The BEST collaborative study.

BACKGROUND: Severe T-cell lymphopenia of uncertain clinical significance has been observed in frequent apheresis platelet donors. Two commonly used plateletpheresis instruments are the Trima Accel, which uses a leukoreduction system (LRS) chamber to trap leukocytes and the Fenwal Amicus, which does not use an LRS chamber. STUDY DESIGN AND METHODS: We performed an international, multicenter, observational study comparing T-cell populations in frequent platelet donors collected exclusively using the Trima instrument (n = 131) or the Amicus instrument (n = 77). Age- and sex-matched whole blood donors (n = 126) served as controls. RESULTS: CD4+ T-cell counts <200 cells/µL were found in 9.9% of frequent Trima (LRS+) platelet donors, 4.4% of frequent Amicus (LRS-) platelet donors, and 0 whole blood donors (p < .0001). CD4+ T-cell counts <200 cells/µL were only seen in platelet donors with ≥200 lifetime donations. In multivariable analysis, age, lifetime donations, and instrument (Trima vs. Amicus) were independent risk factors for lymphopenia. In 40 Trima platelet donors, a plasma rinseback procedure was routinely performed following platelet collections. No Trima platelet donors receiving plasma rinseback had a CD4+ T-cell count <200 cells/µL versus 13/91 Trima platelet donors not receiving plasma rinseback (p = .01). DISCUSSION: Recurrent bulk lymphocyte removal appears to contribute to the development of T-cell lymphopenia in frequent, long-term platelet donors. Lymphopenia is more common when an LRS chamber is used during platelet collection but can occur without an LRS chamber. Blood centers using LRS chambers can mitigate donor lymphopenia by performing plasma rinseback.

Comparing two extracellular additives to facilitate extended storage of red blood cells in a supercooled state.

Background: Adenosine triphosphate (ATP) levels guide many aspects of the red blood cell (RBC) hypothermic storage lesions. As a result, efforts to improve the quality of hypothermic-stored red cell concentrates (RCCs) have largely centered around designing storage solutions to promote ATP retention. Considering reduced temperatures alone would diminish metabolism, and thereby enhance ATP retention, we evaluated: (a) whether the quality of stored blood is improved at -4°C relative to conventional 4°C storage, and (b) whether the addition of trehalose and PEG400 can enhance these improvements. Study Design and Methods: Ten CPD/SAGM leukoreduced RCCs were pooled, split, and resuspended in a next-generation storage solution (i.e., PAG3M) supplemented with 0-165 mM of trehalose or 0-165 mM of PEG400. In a separate subset of samples, mannitol was removed at equimolar concentrations to achieve a fixed osmolarity between the additive and non-additive groups. All samples were stored at both 4°C and -4°C under a layer of paraffin oil to prevent ice formation. Results: PEG400 reduced hemolysis and increased deformability in -4°C-stored samples when used at a concentration of 110 mM. Reduced temperatures did indeed enhance ATP retention; however, in the absence of an additive, the characteristic storage-dependent decline in deformability and increase in hemolysis was exacerbated. The addition of trehalose enhanced this decline in deformability and hemolysis at -4°C; although, this was marginally alleviated by the osmolarity-adjustments. In contrast, outcomes with PEG400 were worsened by these osmolarity adjustments, but at no concentration, in the absence of these adjustments, was damage greater than the control. Discussion: Supercooled temperatures can allow for improved ATP retention; however, this does not translate into improved storage success. Additional work is necessary to further elucidate the mechanism of injury that progresses at these temperatures such that storage solutions can be designed which allow RBCs to benefit from this diminished rate of metabolic deterioration. The present study suggests that PEG400 could be an ideal component in these solutions.

Model of Acute Liver Failure in an Isolated Perfused Porcine Liver-Challenges and Lessons Learned.

Acute liver failure (ALF) is a rare but devastating disease associated with substantial morbidity and a mortality rate of almost 45%. Medical treatments, apart from supportive care, are limited and liver transplantation may be the only rescue option. Large animal models, which most closely represent human disease, can be logistically and technically cumbersome, expensive and pose ethical challenges. The development of isolated organ perfusion technologies, originally intended for preservation before transplantation, offers a new platform for experimental models of liver disease, such as ALF. In this study, female domestic swine underwent hepatectomy, followed by perfusion of the isolated liver on a normothermic machine perfusion device. Five control livers were perfused for 24 h at 37 °C, while receiving supplemental oxygen and nutrition. Six livers received toxic doses of acetaminophen given over 12 h, titrated to methemoglobin levels. Perfusate was sampled every 4 h for measurement of biochemical markers of injury (e.g., aspartate aminotransferase [AST], alanine aminotransferase [ALT]). Liver biopsies were taken at the beginning, middle, and end of perfusion for histological assessment. Acetaminophen-treated livers received a median dose of 8.93 g (8.21-9.75 g) of acetaminophen, achieving a peak acetaminophen level of 3780 µmol/L (3189-3913 µmol/L). Peak values of ALT (76 vs. 105 U/L; p = 0.429) and AST (3576 vs. 4712 U/L; p = 0.429) were not significantly different between groups. However, by the end of perfusion, histology scores were significantly worse in the acetaminophen treated group (p = 0.016). All acetaminophen treated livers developed significant methemoglobinemia, with a peak methemoglobin level of 19.3%, compared to 2.0% for control livers (p = 0.004). The development of a model of ALF in the ex vivo setting was confounded by the development of toxic methemoglobinemia. Further attempts using alternative agents or dosing strategies may be warranted to explore this setting as a model of liver disease.

The evaluation of constant coronary artery flow versus constant coronary perfusion pressure during normothermic ex situ heart perfusion.

BACKGROUND: Evidence suggests that hearts that are perfused under ex-situ conditions lose normal coronary vasomotor tone and experience contractile failure over a few hours. We aimed to evaluate the effect of different coronary perfusion strategies during ex situ heart perfusion on cardiac function and coronary vascular tone. METHODS: Porcine hearts (n = 6 each group) were perfused in working mode for 6 hours with either constant aortic diastolic pressure (40 mmHg) or constant coronary flow rate (500 mL/min). Functional and metabolic parameters, cytokine profiles, cardiac and vascular injury, coronary artery function and oxidative stress were compared between groups. RESULTS: Constant coronary flow perfusion demonstrated better functional preservation and less edema formation (Cardiac index: flow control = 8.33 vs pressure control = 6.46 mL·min-1·g-1, p = 0.016; edema formation: 7.92% vs 19.80%, p < 0.0001). Pro-inflammatory cytokines, platelet activation as well as endothelial activation were lower in the flow control group. Similarly, less cardiac and endothelial injury was observed in the constant coronary flow group. Evaluation of coronary artery function showed there was loss of coronary autoregulation in both groups. Oxidative stress was induced in the coronary arteries and was relatively lower in the flow control group. CONCLUSIONS: A strategy of controlled coronary flow during ex situ heart perfusion provides superior functional preservation and less edema formation, together with less myocardial damage, leukocyte, platelet, endothelial activation, and oxidative stress. There was loss of coronary autoregulation and decrease of coronary vascular resistance during ESHP irrespective of coronary flow control strategy. Inflammation and oxidative stress state in the coronary vasculature may play a role.

Preparing small-dose red cell concentrates (RCCs) for neonatal and pediatric transfusions: Impact of RCC volume, storage, and irradiation.

BACKGROUND: Preparing small-dose red cell concentrates (RCCs) is a common practice for pediatric and neonatal transfusions. However, there is a lack of quality monitoring data to indicate that both the preparation and storage of small-dose RCCs does not alter in vitro red cell quality. The present study seeks to provide data to support this practice. MATERIALS AND METHODS: To evaluate quality of stored small aliquots, six ABO/Rh matched leukoreduced citrate phosphate-dextrose/saline-adenine-glucose-mannitol (LR CPD/SAGM) RCCs were pooled and split into 30 ml aliquots, 80 ml aliquots, and a standard 290 ml unit, with testing performed for up to 43 days post-collection. To evaluate the impact of irradiation on small-dose RCC preparation, a total of 48 independent LR CPD/SAGM RCCs were used (non-irradiated: n = 24; irradiated: n = 24). Aliquoting with/without irradiation was performed within 7 days of collection and baseline testing was performed within 24 h of aliquot production. RESULTS: Limited variability in hemolysis, mean cell volume, and extracellular potassium concentrations were seen between the different aliquot sizes throughout the 43-day storage period. Aliquot production did not accentuate damage based on any of these tested parameters in both the non-irradiated and irradiated subsets. A significant increase was seen in the potassium concentrations in the irradiated parent and aliquot samples relative to their non-irradiated counterparts. CONCLUSIONS: Non-irradiated small-aliquot dose RCCs meet in vitro quality criteria required for safe transfusion throughout the 42-day storage period. The same can be said for aliquots derived from irradiated units and tested within 24 h of aliquot production.

Hypothermic storage of leukoreduced red blood cells for greater than 21 days is a safe alternative to irradiation.

BACKGROUND: Irradiation of red blood cells (RBCs) inactivates residual donor T lymphocytes to prevent transfusion-associated graft-vs-host disease (TA-GVHD) but can have adverse effects on recipients and inventory management. Reported incidence of TA-GVHD is lower when leukoreduced RBCs and older blood products are transfused; therefore, the impact of leukoreduction and storage was evaluated as an alternative prevention strategy. STUDY DESIGN AND METHODS: Effectiveness of leukoreduction filters on white blood cell (WBC) proliferation was evaluated by filtering buffy coat (BC) products and isolating residual WBCs. Additionally, leukoreduced RBCs were spiked with 5 × 106 WBCs on Day 21 of hypothermic storage, then stored and processed on Days 7, 14, and 21 to obtain residual WBCs to investigate the impact of hypothermic storage on their viability and proliferative ability. Viability of residual WBCs was assessed by staining with annexin V and an antibody cocktail for flow cytometry analysis. Proliferative ability was assessed by placing carboxyfluorescein diacetate succinimidyl ester-labeled residual WBCs into culture for 6 days with phytohemagglutinin before flow cytometry assessment. RESULTS: Filtration of BC units depleted WBCs, particularly T lymphocytes, to 0.001% ± 0.003% cells/unit, although proliferative activity remained consistent with prefiltration levels of WBCs. WBCs in stored RBCs remained viable even on Day 21 of storage; however, the proliferative activity decreased to 0.24% ± 0.41%. CONCLUSIONS: Hypothermic storage of RBCs for 21 days or more is sufficient to inactivate T lymphocytes, which may help prevent TA-GVHD when irradiated RBCs are not available.

Donor-dependent aging of young and old red blood cell subpopulations: Metabolic and functional heterogeneity.

BACKGROUND: Characteristics of red blood cells (RBCs) are influenced by donor variability. This study assessed quality and metabolomic variables of RBC subpopulations of varied biologic age in red blood cell concentrates (RCCs) from male and female donors to evaluate their contribution to the storage lesion. STUDY DESIGN AND METHODS: Red blood cell concentrates from healthy male (n = 6) and female (n = 4) donors were Percoll separated into less dense ("young", Y-RCCs) and dense ("old", O-RCCs) subpopulations, which were assessed weekly for 28 days for changes in hemolysis, mean cell volume (MCV), hemoglobin concentration (MCHC), hemoglobin autofluorescence (HGB), morphology index (MI), oxygen affinity (p50), rigidity, intracellular reactive oxygen species (ROS), calcium ([Ca2+ ]), and mass spectrometry-based metabolomics. RESULTS: Young RCCs having disc-to-discoid morphology showed higher MCV and MI, but lower MCHC, HGB, and rigidity than O-RCCs, having discoid-to-spheroid shape. By Day 14, Y-RCCs retained lower hemolysis and rigidity and higher p50 compared to O-RCCs. Donor sex analyses indicated that females had higher MCV, HGB, ROS, and [Ca2+ ] and lower hemolysis than male RBCs, in addition to having a decreased rate of change in hemolysis by Day 28. Metabolic profiling indicated a significant sex-related signature across all groups with increased markers of high membrane lipid remodeling and antioxidant capacity in Y-RCCs, whereas O-RCCs had increased markers of oxidative stress and decreased coping capability. CONCLUSION: The structural, functional, and metabolic dissimilarities of Y-RCCs and O-RCCs from female and male donors demonstrate RCC heterogeneity, where RBCs from females contribute less to the storage lesion and age slower than males.

Development of a Novel, Low-Cost, Disposable Wooden Pencil Graphite Electrode for Use in the Determination of Antioxidants and Other Biological Compounds.

The development of portable sensors that can be used outside the lab is an active area of research in the electroanalytical field. A major focus of such research is the development of low-cost electrodes for use in these sensors. Current electrodes, such as glassy-carbon electrodes (GCEs), are costly and require time-consuming preparation. Alternatives have been proposed, including mechanical pencil-lead electrodes (MPEs). However, MPEs themselves possess numerous drawbacks, particularly structural fragility. In this paper, we present a novel pencil-graphite electrode (PGE) fabricated from a regular HB#2 pencil. This PGE is a simple, disposable, extremely low-cost alternative to GCEs ($0.30 per PGE, vs. $190 + per GCE), and possesses the structural stability that MPEs lack. PGEs were characterized by square-wave voltammetry of ferricyanide, gallic acid, uric acid, dopamine, and several foodstuffs. In all cases, PGEs demonstrated sensitivities comparable or superior to those of the GCE and MPE (LOD = 5.62 × 10(-4) M PGE, 4.80 × 10(-4) M GCE, 2.93 × 10(-4) M MPE). Signal areas and peak heights were typically four to ten times larger for the PGE relative to the GCE.