Purification of rabies virus glycoprotein produced in Drosophila melanogaster S2 cells: An efficient immunoaffinity method.

Most rabies vaccines are based on inactivated virus, which production process demands a high level of biosafety structures. In the past decades, recombinant rabies virus glycoprotein (RVGP) produced in several expression systems has been extensively studied to be used as an alternative vaccine. The immunogenic characteristics of this protein depend on its correct conformation, which is present only after the correct post-translational modifications, typically performed by animal cells. The main challenge of using this protein as a vaccine candidate is to keep its trimeric conformation after the purification process. We describe here a new immunoaffinity chromatography method using a monoclonal antibody for RVGP Site II for purification of recombinant rabies virus glycoprotein expressed on the membrane of Drosophila melanogaster S2 cells. RVGP recovery achieved at least 93%, and characterization analysis showed that the main antigenic proprieties were preserved after purification.

DROSOPHILA S2 cell culture in a WAVE Bioreactor: potential for scaling up the production of the recombinant rabies virus glycoprotein.

The transmembrane rabies virus glycoprotein (RVGP) is the main antigen of vaccine formulations used around the world to prevent rabies, the most lethal preventable infectious disease known. The objective of this work was to evaluate the potential of a bioreactor using wave-induced agitation in the initial steps of scaling up the rRVGP production process by a Drosophila melanogaster S2 cell line to produce rRVGP in sufficient quantities for immunization and characterization studies. Taking advantage of some remarkable features recognized in Drosophila S2 cells for scaling the culture process, a robust recombinant lineage (S2MtRVGPH-His) engineered by our group for the expression of rRVGP using a copper-inducible promoter was used in the bioreactor cultures. The WAVE Bioreactor was chosen because it represents an innovative approach to the cultivation of animal cells using single-use technology. For that purpose, we firstly established a procedure for culturing the S2MtRVGPH-His lineage in 100 mL Schott flasks. Using an inoculum of 5 × 105 cells/mL in culture medium (Sf900-III) induced with solution of CuSO4 (0.7 mM) and a convenient pH range (6.2-7.0), optimal parameter values such as time of induction (72 h) and temperature (28 °C) to increase rRVGP production could be defined. This procedure was reproduced in culture experiments conducted in a WAVE Bioreactor™ 2/10 using a 2 L Cellbag. The results in Schott flasks and in WAVE Bioreactor™ were very similar, yielding a maximum titer of rRVGP above of 1 mg.L-1. The immunization study showed that the rRVGP produced in the bioreactor was of high immunogenic quality.

Infection of mice with oocysts of Toxoplasma gondii by oral route showed differences of virulence from Brazilian RFLP genotypes BrI and BrIII.

South American strains of Toxoplasma gondii present higher genetic diversity than classical European strains. We compared the virulence of two non-archetypal Brazilian genotypes of T. gondii to mice. Oocysts of four isolates, two genotype BrI (TgCatBr71 and TgShBr11) and two BrIII (TgCatBr74 and TgCatBr60) were obtained from cats fed experimentally infected mice. After sporulation, 5.0×10(1) and 1.0×10(2) oocysts were orally administrated to Swiss albine mice in Experiments #1 and #2, respectively (4-10 mice/group). Humoral response from dead and surviving mice was analyzed on days 9 to 35 post-infection. Microscopic observations of lungs and brains were performed for tachyzoites and cysts visualization in fresh preparations. Negative results were tested by PCR. Virulence after infection with oocysts is dose dependent for genotype BrIII isolates, but not for BrI. Differences in mortality were observed among isolates from genotype BrIII on Experiment #1. Intra-genotype phenotypic variation related to the parasite stage of infection was demonstrated and this characteristic should be further studied and may influence future work regarding the role of virulence amid hosts.