Lactiplantibacillus plantarum OL5 biosurfactants as alternative to chemical surfactants for application in eco-friendly cosmetics and skincare products.

Cosmetics have been extremely popular throughout history and continue to be so today. Cosmetic and personal care products, including toothpaste, shampoo, lotions, and makeup, are typically made with petroleum-based surfactants. Currently, there is an increasing demand to enhance the sustainability of surface-active compounds in dermal formulations. Biosurfactants, derived from living cells, are considered more environmentally friendly than synthetic surfactants. Thus, the use of biosurfactants is a promising strategy for formulating more environmentally friendly and sustainable dermal products. Biosurfactants have the potential to replace chemical surface-active agents in the cosmetic sector due to their multifunctional qualities, such as foaming, emulsifying, and skin-moisturizing activities.In this study, two glycolipopeptide biosurfactants derived from Lactiplantibacillus plantarum OL5 were used as stabilizing factors in oil-in-water emulsions in the presence of coconut oils. Both biosurfactants increased emulsion stability, particularly in the 1:3 ratio, dispersion, and droplet size. Moreover, the cytotoxicity of the two Lactiplantibacillus plantarum biosurfactants was assessed on B lymphocytes and MCF-7 cells. Overall, the results gathered herein are very promising for the development of new green cosmetic formulations.

Complete genome sequences of two Bacillus thuringiensis serovar kurstaki strains isolated from Lebanon and Tunisia, highly toxic against lepidopteran larvae.

Bacillus thuringiensis-based products are key in the biopesticides market. Bacillus thuringiensis kurstaki strains Lip and BLB1 were isolated from Lebanese and Tunisian soils, respectively. These strains are highly toxic against lepidopteran larvae, Ephestia kuehniella. Here, we report Lip and BLB1 complete genomes, including their plasmid and toxin contents.

Influence of Ephestia kuehniella stage larvae on the potency of Bacillus thuringiensis Cry1Aa delta-endotoxin.

The economically important crop pest Ephestia kuehniella was tested at two stages of larval development for susceptibility to Bacillus thuringiensis Cry1Aa toxin. Bioassays showed that toxicity decreased during the development of larvae stage. In fact, Cry1Aa toxins from BNS3-Cry- (pHT-cry1Aa) showed low toxicity against the first-instar larvae (L1) with a LC50 value of about 421.02µg/g of diet and was not toxic against the fifth-instar (L5), comparing to the BLB1 toxins used as positive control which represent a LC50 value of about 56.96 and 84.21µg/g of diet against L1 and L5 instars larvae, respectively. Effects of Cry1Aa toxins were reflected in histopathological observations by the weak destruction of midgut epithelium, slight hypertrophy of epithelial cells, and minor alteration of brush border membrane (BBM) detected mainly in L1 larvae stage comparing to the more extensive damage caused by BLB1 toxins. Interestingly, in vitro proteolysis of Cry1Aa toxins was found to correlate with the difference of toxicity during larval stage development. In fact, the weak proteinase activity detected inside the L1 midgut has led to the persistence of the Cry1Aa active forms (65 and 58kDa) during prolonged incubations, causing the alterations described previously. Three subfamilies of aminopeptidase (APN) receptors were detected in both larvae instars with different intensities and molecular weights (150kDa and 55kDa for APN1, and 90kDa for APN2 and APN4). Remarkably, binding assay using Cry1Aa toxin seems to have no direct correlation with larval stages toxicity differences, since same putative receptors were detected. Understanding the reasons for the clear differences in the effectiveness of Cry1Aa toxins during larval development stages of E. kuehniella is very important for the design of future improvement insecticidal approaches and for the accomplishment of resistance prevention strategies.

Ephestia kuehniella tolerance to Bacillus thuringiensis Cry1Aa is associated with reduced oligomer formation.

The basis of the different susceptibility of Ephestia kuehniella to the Cry1Aa and Cry1Ac δ-endotoxins from Bacillus thuringiensis kurstaki BNS3 was studied. Both toxins bound specifically to the BBMV of E. kuehniella. The result of the ligand blot showed that Cry1Ac bound to three putative receptors of about 100, 65 and 80 kDa and Cry1Aa interacted only with a 100 kDa protein. Pronase digestion of the BBMV-bound toxins was used to analyze the toxin insertion. Both toxins inserted into the BBMV as monomers however, a 14 kDa peptide of α4-α5 which correspond to the oligomeric form of this peptide was detected in case of Cry1Ac only. Analysis of the in vitro oligomerisation of these toxins in the presence of the BBMV of E. kuehniella showed reduced oligomer formation in case of Cry1Aa in comparison with Cry1Ac. Taken together, these results strongly suggest that the difference of toxicity between Cry1Aa and Cry1Ac to E. kuehniella is due to a deficient oligomerisation of Cry1Aa.

Molecular characterisation of Bacillus thuringiensis strain MEB4 highly toxic to the Mediterranean flour moth Ephestia kuehniella Zeller (Lepidoptera: Pyralidae).

BACKGROUND: Cry2 proteins play an essential role in current Bacillus thuringiensis (Bt) applications and in the prevention of insect resistance to Cry1A toxins. This paper reports on the screening and characterisation of novel Bt strains harbouring effective cry2A-type genes and higher insecticidal activity to Ephestia kuehniella. RESULTS: A total of 29 native Bt strains were screened to search for the potent strain against E. kuehniella. The plasmid pattern of the selected strains showed interesting variability. PCR-RFLP analysis of two amplified regions showed high sequence identity within the selected cry2A-type genes. SDS-PAGE and western blot analysis revealed the presence of Cry2Aa toxin only in the MEB4 and BLB240 strains. The activation of Cry2Aa protoxins by larval midgut juice, trypsin or chymotrypsin enzymes revealed significant differences in terms of proteolysis profiles. Interestingly, a 49 kDa band was detected in the proteolysis pattern of BLB240, suggesting the presence of a chymotrypsin cleavage site that might have affected its insecticidal activity. Further, bioassays demonstrated that MEB4 (103.08 ± 36 µg g(-1)) was more active than BLB240 (153.77 ± 45.65 µg g(-1)) against E. kuehniella. CONCLUSION: Based on its potent insecticidal activity, the MEB4 strain could be considered to be an effective alternative agent for the control of E. kuehniella.

Investigation of the steps involved in the difference of susceptibility of Ephestia kuehniella and Spodoptera littoralis to the Bacillus thuringiensis Vip3Aa16 toxin.

BUPM95 is a Bacillus thuringiensis subsp. kurstaki strain producing the Vip3Aa16 toxin with an interesting insecticidal activity against the Lepidopteran larvae Ephestia kuehniella. Study of different steps in the mode of action of this Vegetative Insecticidal Protein on the Mediterranean flour moth (E. kuehniella) was carried out in the aim to investigate the origin of the higher susceptibility of this insect to Vip3Aa16 toxin compared to that of the Egyptian cotton leaf worm Spodoptera littoralis. Using E. kuehniella gut juice, protoxin proteolysis generated a major band corresponding to the active toxin and another band of about 22kDa, whereas the activation of Vip3Aa16 by S. littoralis gut juice proteases generated less amount of the 62kDa active form and three other proteolysis products. As demonstrated by zymogram analysis, the difference in proteolysis products was due to the variability of proteases in the two gut juices larvae. The study of the interaction of E. kuehniella BBMV with biotinylated Vip3Aa16 showed that this toxin bound to a putative receptor of 65kDa compared to the 55 and 100kDa receptors recognized in S. littoralis BBMV. The histopathological observations demonstrated similar damage caused by the toxin in the two larvae midguts. These results demonstrate that the step of activation, mainly, is at the origin of the difference of susceptibility of these two larvae towards B. thuringiensis Vip3Aa16 toxin.

Integration of a recombinant chitinase into Bacillus thuringiensis parasporal insecticidal crystal.

Chitinases have been successfully used in combination with Bacillus thuringiensis delta-endotoxins forming crystals in order to enhance their insecticidal activities. In this context, we opted for promoting the chitinase integration into these crystals. Thus, we engineered, for the first time, a fusion protein (CDF) consisting of the chitinase Chi255 and the carboxy-terminal half of Cry1Ac, both from B. thuringiensis subsp. kurstaki. The constructed transcriptional fusion (chi255Δsp-CTcry1Ac) was cloned into a shuttle vector (Escherichia coli/B. thuringiensis) downstream the sporulation-dependent promoters BtI-BtII and upstream the cry1Ac transcription terminator. The resulting plasmid, named pF, was transferred by electroporation to crystalliferous B. thuringiensis strain BNS3 and acrystalliferous strain BNS3Cry-. The functionality of the chimerical chitinase was demonstrated by an improvement of the relative chitinolytic activity of the recombinant strain BNS3/pF by 2.5 folds. Western blot analyses showed that, despite of the instability of CDF when expressed in the acrystalliferous strain, the C-terminal half of Cry1Ac succeeded to allow the integration of the chimerical chitinase into the crystal of BNS3. The recombinant strain BNS3/pF (LC(50) = 144.06 µg g(-1)) was 1.5 times more active against Ephestia kuehniella larvae than the wild strain (LC(50) = 212.10 µg g(-1)).

Mutations in LAMA2 and CAPN3 genes associated with genetic and phenotypic heterogeneities within a single consanguineous family involving both congenital and progressive muscular dystrophies.

LGMD (limb-girdle muscular dystrophy) and CMD (congenital muscular dystrophy) are two common forms of neuromuscular disorders which are distinguishable by their age of onset but with probably a similar underlying pathway. In the present study, we report immunohistochemical, Western-blot and genetic analyses in a large consanguineous Tunisian family with two branches, including seven patients sharing similar LGMD2 phenotype in one branch and one CMD patient in the other branch. Linkage analyses were compatible with the LGMD2A locus in one branch and the MDC1A (muscular dystrophy congenital type 1A) locus in the other branch. This result was supported by deficiency in merosin and calpain3 in the CMD patient and LGMD patients respectively. Mutation analysis revealed two distinct mutations: a c.8005delT frameshift deletion in exon 56 of the LAMA2 (laminin-α2) gene (MDC1A) was found in the CMD patient and a new homozygous mutation c.1536+1G>T in the donor splice site of intron 12 of the CAPN3 (calpain3) gene (LGMD2A) was found in the LGMD patients. RT-PCR (reverse transcription-PCR) performed on total RNA from a LGMD2A patient's muscle biopsy showed complete retention of intron 12 in CAPN3 cDNA, generating a PTC (premature termination codon) that potentially elicits degradation of the nonsense mRNA by NMD (nonsense-mediated mRNA decay). Our results indicate that mRNA analysis is necessary to clarify the primary effect of genomic mutations on splicing efficiency that alters mRNA processing and expression level.

Characterization of Tunisian Bacillus thuringiensis strains with abundance of kurstaki subspecies harbouring insecticidal activities against the lepidopteran insect Ephestia kuehniella.

The study of 257 crystal-producing Bacillus thuringiensis isolates from bioinsecticide free soil samples collected from different sites in Tunisia, was performed by PCR amplification, using six primer pairs specific for cry1, cry2, cry3, cry4, and vip3A genes, by the investigation of strain plasmid pattern, crystal morphology and delta-endotoxin content and by the assessment of insecticidal activities against the lepidopteran insect Ephestia kuehniella. Based on plasmid pattern study, 11 representative strains of the different classes were subjected to morphological and molecular analyses. The comparison of the PFGE fingerprints confirmed the heterogeneity of these strains. B. thuringiensis kurstaki strains, harbouring at the same time the genes cry1A, cry2, cry1Ia, and vip3A, were the most abundant (65.4%). 33.34% of the new isolates showed particular delta-endotoxin profiles but no PCR products with the used primer sets. B. thuringiensis israelensis was shown to be also very rare among the Tunisian B. thuringiensis isolates diversity. These findings could have considerable impacts for the set up of new pest control biological agents.

Comparative study of Bacillus thuringiensis Cry1Ia and Cry1Aa delta-endotoxins: activation process and toxicity against Prays oleae.

Cry1Ia and Cry1Aa proteins exhibited toxicities against Prays oleae with LC(50) of 189 and 116 ng/cm(2), respectively. The ability to process Cry1Ia11 protoxin by trypsin, chymotrypsin and P. oleae larvae proteases was studied and compared to that of Cry1Aa11. After solubilization under high alkaline condition (50mM NaOH), Cry1Aa11 was converted into a major fragment of 65 kDa, whereas Cry1Ia11 protoxin was completely degraded by P. oleae larvae proteases and trypsin and converted into a major fragment of 70 kDa by chymotrypsin. Using less proteases of P. oleae juice, the degradation of Cry1Ia11 was attenuated. When the solubilization (in 50mM Na(2)CO(3) pH 10.5 buffer) and activation were combined, Cry1Ia11 was converted into a proteolytic product of 70 kDa after 3h of incubation with trypsin, chymotrypsin and P. oleae juice. These results suggest that the in vivo solubilization of Cry1Ia11 was assured by larval proteases after a swelling of the corresponding inclusion due to the alkalinity of the larval midgut.

Prays oleae midgut putative receptor of Bacillus thuringiensis vegetative insecticidal protein Vip3LB differs from that of Cry1Ac toxin.

Vegetative insecticidal protein (Vip) is a class of insecticidal proteins produced by many Bacillus thuringiensis strains during their vegetative growth stage. The vip3LB gene of B. thuringiensis strain BUPM95, which encodes a protein active against the Lepidoptera olive tree pathogenic insect Prays oleae, was cloned into pET-14b vector and overexpressed in Escherichia coli. The expressed Vip3LB protein, found in the E. coli cytoplasmic fraction, was purified and used to produce anti-Vip3LB antibodies. Using the midgut extract of P. oleae, the purified Vip3LB bound to a 65-kDa protein, whereas Cry1Ac toxin bound to a 210-kDa midgut putative receptor. This result justifies the importance of the biological pest control agent Vip3LB that could be used as another alternative particularly in case of resistance to Cry toxins.

A new Tunisian strain of Bacillus thuringiensis kurstaki having high insecticidal activity and delta-endotoxin yield.

BLB1 is a new Bacillus thuringiensis kurstaki strain, isolated from a Tunisian soil sample. Assay of toxicity of BLB1 crystal proteins resulted in an LC50 of 70.32 ng of toxin per mg of flour against third instar Ephestia kuehniella with confidence limits of (31.6-109.04 ng). This LC50 is less than that of the commercial strains HD1 used as a reference. The characterization of this strain by scanning transmission electron microscopy, analysis of its cry genes content by PCR-sequencing, and analysis of its delta-endotoxin patterns demonstrate that it belongs to the same subgroup than HD1, but ruled out the involvement of cry gene content or protoxin activation in the hypertoxicity of this strain. Taking into account the delta-endotoxin/spore ratio for each strain, and by allowing the estimation of the production level per spore, it might be concluded that BLB1 production is the highest, when compared with that of HD1. On the basis of its toxicity, BLB1 could be considered as a strain of great interest and would allow the production of quantities of bioinsecticides at low cost.

A stable cytosolic expression of VH antibody fragment directed against PVY NIa protein in transgenic potato plant confers partial protection against the virus.

The expression of recombinant antibodies in transgenic plants has been proved to be an efficient approach for large-scale production. However, the stability of these molecules and their accumulation level depend on their molecular properties and cellular targeting. The expression of single-domain antibody fragment (VH) can be advantageous since it offers small length, high expression, solubility and stability. It can therefore be preferred to other antibody derivatives avoiding the expression difficulties related to immunoglobulin domain folding via the formation of disulfide bridge. This report describes the production of transgenic potato plants expressing a VH antibody directed against the NIa protease of potato virus Y. The antibody was driven by the constitutive CaMV 35S RNA promoter. The expression cassette was transferred into potato plants via Agrobacterium tumefaciens mediated transformation. All transgenic lines showed detectable levels of VH protein confirming the efficient translation and stability of this protein. The cellular localisation of the VH antibody was investigated. Transgenic and control plants were transferred in the greenhouse and mechanically inoculated by PVY(o) suspension. Some of the transgenic lines showed delayed symptoms at the first period post inoculation and then displayed a recovery phenomenon while the virions were still detected in the leaves.

Comparative study of Bacillus thuringiensis Cry1Aa and Cry1Ac delta-endotoxin activation, inactivation and in situ histopathological effect in Ephestia kuehniella (Lepidoptera: Pyralidae).

A comparative study of different steps in the mode of action of the individual Bacillus thuringiensis kurstaki BNS3 Cry1Aa and Cry1Ac delta-endotoxins on E. kuehniella larvae was performed in order to investigate the origin of the difference in the response of this larvae to each of the latter. Proteolytic activation was shown to be one of the main steps impaired in E. kuehniella tolerance to Cry1Aa. The absence of two proteinase activities as well as an altered activity level observed in the case of Cry1Aa would be the consequence of proteinase-mediated tolerance of E. kuehniella to this toxin. In situ binding and histopathological effect analyses allowed concluding that the binding of the toxin to BBMV receptors is the key step in E. kuehniella tolerance to Cry1Aa toxin. The latter was slightly bound to apical membranes of epithelial cells that remained intact, whereas Cry1Ac was tightly bound to completely damaged cells basal membranes.

Differentiation between Bacillus thuringiensis strains by gyrB PCR-Sau3AI fingerprinting.

gyrB DNA fragments of seven Bacillus thuringiensis local collection family representatives were amplified by PCR and sequenced. Several differences in their corresponding sequences were evidenced. Both in silico and in vitro restriction maps of gyrB sequences and fragments respectively confirmed that EcoRI and Sau3AI could be used to differentiate between B. thuringiensis strains. However, the phylogeny analysis showed that only the gyrB PCR-Sau3AI allows a strains classification that correlates very well with that obtained on the basis of the sequences analysis. Thus, these finds show that gyrB PCR- Sau3AI digestion could be considered as an efficient, rapid, and easy method to make a distinction, not only between strains belonging to the Bacillus cereus group, but also between those belonging to B. thuringiensis.

Scorpion digestive lipase: a member of a new invertebrate's lipase group presenting novel characteristics.

Unlike classical digestive lipases, the scorpion digestive lipase (SDL) has a strong basic character. The SDL activity's optimal pH, when using tributyrin or olive oil as substrate, was 9.0. Added to that, the estimated isoelectric point of the native SDL using the electrofocusing technique, was found to be higher than 9.6. To our knowledge, this is the first report of an animal digestive lipase having such a basic character. When olive oil was used as substrate, SDL was shown to be insensitive to the presence of amphiphilic proteins such as bovine serum albumin (BSA). Furthermore, the hydrolysis was found to be specifically dependent on the presence of Ca(2+) ions, since no significant SDL activity was detected in the presence of ions chelator such as EDTA. Nevertheless, the SDL does not require Ca(2+) to trigger the hydrolysis of tributyrin emulsion. Interestingly Zn(2+) and Cu(2+) ions act as strong inhibitors of SDL activity when using tributyrin as substrate. An internal chymotryptic cleavage of SDL generated two fragments of 28 and 25 kDa having the same N-terminal sequence. This sequence of 19 residues does not share any homology with known animal and microbial lipases. Polyclonal antibodies directed against SDL (pAbs anti-SDL) failed to recognise ostrich pancreatic and dog gastric lipases (OPL and rDGL). Moreover, both pAbs anti-OPL and anti-rDGL failed to immunoreact with SDL. These immunological as well as distinct biochemical properties strengthen the idea that SDL appears to belong to a new invertebrate's lipase group.

Cloning and expression of functional single-chain Fv antibodies directed against NIa and coat proteins of potato virus Y.

Three single-chain variable fragment (scFv) antibodies recognizing the nuclear inclusion a (NIa) and capsid proteins of potato virus Y were obtained from two mouse derived hybridoma clones secreting, respectively, an anti-NIa (22-1) and an anti-coat protein (136-13) monoclonal antibodies. The first monoclonal antibody was able to inhibit in vitro the PVY polyprotein cleavage by blocking the NIa protease activity. The amplified scFv cDNAs were first inserted into the TOPO vector and then sequenced. Several recombinant E. coli clones carrying the accurate scFv sequences were selected and the corresponding cDNAs were subcloned in pHEN phagemid and transferred in E. coli strain. The expressed scFv fragments showed an antibody activity that recognized the viral target proteins in infected tissues. Their activity was comparable to the parental monoclonal antibodies.

Immunocytochemical localization of scorpion digestive lipase.

The scorpion hepatopancreas consists of digestive diverticula and interstitial tissue. A digestive diverticulum is composed of two differentiated cell types: the secretory zymogene-like cells and the digestive cells which are the most abundant. The scorpion digestive lipase (SDL) has been previously purified from scorpion hepatopancreas, but its cellular localization has not yet been established. Polyclonal antibodies specific to SDL were prepared and used in immunofluorescence and immunogold techniques to determine the cellular location of SDL. Our results clearly established that SDL was detected intracellularly in specific vesicles tentatively named (SDL+) granules of the digestive cells. No immunolabelling was observed in secretory zymogene-like cells. This immunocytolocalization indicates that lipid digestion might occur in specific granules inside the digestive cells, as suggested by previous studies on the scorpion digestive process.

PVY-resistant transgenic potato plants expressing an anti-NIa protein scFv antibody.

A synthetic gene encoding a single chain Fv fragment of an antibody directed against the nuclear inclusion a (NIa) protein of potato virus Y (PVY) was used to transform two commercial potato cultivars (Claustar and BF15). The NIa protease forms the nuclear inclusion body A and acts as the major protease in the cleavage of the viral polyprotein into functional proteins. Immunoblot analysis showed that most of the resulting transgenic plants accumulate high levels of the transgenic protein. Furthermore, a majority of the selected transgenic lines showed an efficient and complete protection against the challenge virus after mechanical inoculation with PVYO strain. Two transgenic lines showed an incomplete resistance with delayed appearance of symptoms accompanied by low virus titers, whereas one line developed symptoms during the first days after inoculation but recovered rapidly, leading to a low virus accumulation rate. These results confirm that expression of scFv antibody is able to inhibit a crucial step in the virus multiplication, such as polyprotein cleavage is a powerful strategy for engineered virus resistance. It can lead to a complete resistance that was not obtained previously by expression of scFv directed against the viral coat protein.