Plasma transfusion-transmission of Zika virus in mice and macaques.

BACKGROUND: Zika virus (ZIKV) epidemics with infections in pregnant women are associated with severe neurological disease in newborns. Although an arbovirus, ZIKV is also blood transfusion-transmitted (TT). Greater knowledge of the efficiency of ZIKV TT would aid decisions on testing and pathogen reduction technologies (PRT). STUDY DESIGN AND METHODS: Plasma units from ZIKV RNA-reactive blood donors were used to study infectivity in vitro, in mice, and in macaques. Furthermore, plasma units were subjected to PRT using amotosalen/ultraviolet light A (A/UVA) before transfusion. RESULTS: In vitro infectivity of ZIKV RNA-reactive plasma varied between 100 and 1000 international units (IU) of ZIKV RNA. Immunodeficient mice were more sensitive with as low as 32 IU sufficient to infect 50% of mice. 50-5500 IU of RNA led to TT in macaques using dose escalation of three different RNA-positive, seronegative plasma units. In contrast, RNA-reactive units collected postseroconversion were not infectious in macaques, even at a dose of 9 million IU RNA. After A/UVA PRT, transfusion of plasma containing up to 18 million IU was no longer infectious in vitro and did not result in ZIKV TT in macaques. CONCLUSION: Significant risks of ZIKV TT are likely confined to a relatively short viremic window before seroconversion, and that sensitive nucleic acid amplification testing likely identifies the majority of infectious plasma. PRT was demonstrated to be effective at preventing ZIKV TT. Considering that there is no approved ZIKV vaccine, these data are relevant to mitigate the risk of TT during the future ZIKV outbreaks.

Inactivation of SARS-CoV-2 in All Blood Components Using Amotosalen/Ultraviolet A Light and Amustaline/Glutathione Pathogen Reduction Technologies.

No cases of severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) transfusion-transmitted infections (TTI) have been reported. The detection of viral RNA in peripheral blood from infected patients and blood components from infected asymptomatic blood donors is, however, concerning. This study investigated the efficacy of the amotosalen/UVA light (A/UVA) and amustaline (S-303)/glutathione (GSH) pathogen reduction technologies (PRT) to inactivate SARS-CoV-2 in plasma and platelet concentrates (PC), or red blood cells (RBC), respectively. Plasma, PC prepared in platelet additive solution (PC-PAS) or 100% plasma (PC-100), and RBC prepared in AS-1 additive solution were spiked with SARS-CoV-2 and PR treated. Infectious viral titers were determined by plaque assay and log reduction factors (LRF) were determined by comparing titers before and after treatment. PR treatment of SARS-CoV-2-contaminated blood components resulted in inactivation of the infectious virus to the limit of detection with A/UVA LRF of >3.3 for plasma, >3.2 for PC-PAS-plasma, and >3.5 for PC-plasma and S-303/GSH LRF > 4.2 for RBC. These data confirm the susceptibility of coronaviruses, including SARS-CoV-2 to A/UVA treatment. This study demonstrates the effectiveness of the S-303/GSH treatment to inactivate SARS-CoV-2, and that PRT can reduce the risk of SARS-CoV-2 TTI in all blood components.

Inactivation of a broad spectrum of viruses and parasites by photochemical treatment of plasma and platelets using amotosalen and ultraviolet A light.

BACKGROUND: The INTERCEPT Blood System pathogen reduction technology (PRT), which uses amotosalen and ultraviolet A light treatment (amotosalen/UV-PRT), inactivates pathogens in plasma and platelet components (PCs). This review summarizes data describing the inactivation efficacy of amotosalen/UVA-PRT for a broad spectrum of viruses and parasites. METHODS: Twenty-five enveloped viruses, six nonenveloped viruses (NEVs), and four parasites species were evaluated for sensitivity to amotosalen/UVA-PRT. Pathogens were spiked into plasma and PC at high titers. Samples were collected before and after PRT and assessed for infectivity with cell cultures or animal models. Log reduction factors (LRFs) were defined as the difference in infectious titers before and after amotosalen/UV-PRT. RESULTS: LRFs of ≥4.0 log were reported for 19 pathogens in plasma (range, ≥4.0 to ≥7.6), 28 pathogens in PC in platelet additive solution (PC-PAS; ≥4.1-≥7.8), and 14 pathogens in PC in 100% plasma (PC-100%; (≥4.3->8.4). Twenty-five enveloped viruses and two NEVs were sensitive to amotosalen/UV-PRT; LRF ranged from >2.9 to ≥7.6 in plasma, 2.4 or greater to greater than 6.9 in PC-PAS and >3.5 to >6.5 in PC-100%. Infectious titers for four parasites were reduced by >4.0 log in all PC and plasma (≥4.9 to >8.4). CONCLUSION: Amotosalen/UVA-PRT demonstrated effective infectious titer reduction for a broad spectrum of viruses and parasites. This confirms the capacity of this system to reduce the risk of viral and parasitic transfusion-transmitted infections by plasma and PCs in various geographies.

Inactivation of yellow fever virus with amotosalen and ultraviolet A light pathogen-reduction technology.

BACKGROUND: The reemergence of yellow fever virus (YFV) in Africa and Brazil, and massive vaccine campaigns triggered to contain the outbreaks, have raised concerns over blood transfusion safety and availability with increased risk of YFV transfusion-transmitted infections (TTIs) by native and vaccine-acquired YFV. Blood donor deferral for 2 to 4 weeks following live attenuated YFV vaccination, and deferral for travel to endemic/epidemic areas, may result in blood donor loss and impact platelet component (PC) stocks. This study investigated the efficacy of INTERCEPT Blood System pathogen reduction (PR) with use of amotosalen and ultraviolet A (UVA) light to inactivate high levels of YFV in PCs. MATERIALS: Four units of apheresis platelets prepared in 35% plasma/65% platelet additive solution (PC-PAS) and 4 units of PC in 100% human plasma (PC-Plasma) were spiked with high infectious titers of YFV (YFV-17D vaccine strain). YFV-17D infectious titers were measured by plaque assay and expressed as plaque-forming units (PFU) before and after amotosalen/UVA treatment to determine log reduction. RESULTS: The mean YFV-17D infectious titers in PC before inactivation were 5.5 ± 0.1 log PFU/mL in PC-PAS and 5.3 ± 0.1 log PFU/mL in PC-Plasma. No infectivity was detected immediately after amotosalen/UVA treatment. CONCLUSION: The amotosalen/UVA PR system inactivated high titers of infectious YFV-17D in PC. This PR technology could reduce the risk of YFV TTI and help secure PC supplies in areas experiencing YFV outbreaks where massive vaccination campaigns are required.

Pathogen inactivation of Dengue virus in red blood cells using amustaline and glutathione.

BACKGROUND: Dengue virus (DENV) is an arbovirus primarily transmitted through mosquito bite; however, DENV transfusion-transmitted infections (TTIs) have been reported and asymptomatic DENV RNA-positive blood donors have been identified in endemic countries. DENV is considered a high-risk pathogen for blood safety. One of the mitigation strategies to prevent arbovirus TTIs is pathogen inactivation. In this study we demonstrate that the amustaline and glutathione (S-303/GSH) treatment previously found effective against Zika virus in red blood cells (RBCs) is also effective in inactivating DENV. STUDY DESIGN AND METHODS: Red blood cells were spiked with high levels of DENV. Viral RNA loads and infectious titers were measured in the untreated control and before and after pathogen inactivation treatment of RBC samples. DENV infectivity was also assessed over five successive cell culture passages to detect any potential residual replicative virus. RESULTS: The mean ± SD DENV titer in RBCs before inactivation was 6.61 ± 0.19 log 50% tissue culture infectious dose (TCID50 )/mL and the mean viral RNA load was 8.42 log genome equivalents/mL. No replicative DENV was detected either immediately after completion of treatment using S-303/GSH or after cell culture passages. CONCLUSION: Treatment using S-303/GSH inactivated high levels of DENV in RBCs to the limit of detection. In combination with previous studies showing the effective inactivation of DENV in plasma and platelets using the licensed amotosalen/UVA system, this study demonstrates that high levels of DENV can be inactivated in all blood components.

Inactivation of Zika virus in platelet components using amotosalen and ultraviolet A illumination.

BACKGROUND: Concerned over the risk of Zika virus (ZIKV) transfusion transmission, public health agencies recommended the implementation of mitigation strategies for its prevention. Those strategies included the use of pathogen inactivation for the treatment of plasma and platelets. The efficacy of amotosalen/ultraviolet A to inactivate ZIKV in plasma had been previously demonstrated, and the efficacy of inactivation in platelets with the same technology was assumed. These studies quantify ZIKV inactivation in platelet components using amotosalen/ultraviolet A. STUDY DESIGN AND METHODS: Platelet components were spiked with ZIKV, and ZIKV infectious titers and RNA loads were measured by cell culture-based assays and real-time polymerase chain reaction in spiked platelet components before and after photochemical treatment using amotosalen/ultraviolet A. RESULTS: The mean ZIKV infectivity titers and RNA loads in platelet components before inactivation were either 4.9 log10 plaque forming units per milliliter, or 4.4 log10 50% tissue culture infective dose per milliliter and 7.5 log10 genome equivalents per milliliter, respectively. No infectivity was detected immediately after amotosalen/ultraviolet A treatment. No replicative virus remained after treatment, as demonstrated by multiple passages on Vero cell cultures; and ZIKV RNA was not detected from the first passage after inactivation. Additional experiments in this study demonstrated efficient inactivation to the limit of detection in platelets manufactured in 65% platelet additive solution, 35% plasma, or 100% plasma. CONCLUSION: As previously demonstrated for plasma, robust levels of ZIKV inactivation were achieved in platelet components. With inactivation of higher levels of ZIKV than those reported in asymptomatic, RNA-reactive blood donors, the pathogen-inactivation system using amotosalen/ultraviolet A offers the potential to mitigate the risk of ZIKV transmission by plasma and platelet transfusion.

Amustaline (S-303) treatment inactivates high levels of Zika virus in red blood cell components.

BACKGROUND: The potential for Zika virus (ZIKV) transfusion-transmission (TT) has been demonstrated in French Polynesia and Brazil. Pathogen inactivation (PI) of blood products is a proactive strategy to inactivate TT pathogens including arboviruses. Inactivation of West Nile, dengue, Zika, and chikungunya viruses was previously demonstrated by photochemical treatment with amotosalen and ultraviolet A (UVA) illumination. In this study, we evaluated ZIKV inactivation in red blood cell (RBC) components by a chemical approach that uses amustaline (S-303) and glutathione (GSH). STUDY DESIGN AND METHODS: RBC components were spiked with a high titer of ZIKV. Viral titers (infectivity) and ZIKV RNA loads (reverse transcription-polymerase chain reaction) were measured in spiked RBCs before and after S-303 and GSH treatment and confirmed using repetitive passages in cell culture. A mock-treated arm validated the approach by demonstrating stability of the virus (infectivity and RNA load) during the process. RESULTS: The mean ZIKV infectivity titer and RNA load in RBCs were 5.99 ± 0.2 log 50% tissue culture infectious dose (TCID50 )/mL and 7.75 ± 0.16 log genomic equivalents/mL before inactivation. No infectivity was detected immediately after S-303 and GSH treatment and after five serial passages in cell culture. CONCLUSION: Complete ZIKV inactivation of more than 5.99 log TCID50 /mL in RBCs was achieved using S-303 and GSH at levels higher than those found in asymptomatic ZIKV-infected blood donors. Therefore, the S-303 and GSH PI system is promising for mitigating the risk of ZIKV TT.

PKR Transduces MDA5-Dependent Signals for Type I IFN Induction.

Sensing invading pathogens early in infection is critical for establishing host defense. Two cytosolic RIG-like RNA helicases, RIG-I and MDA5, are key to type I interferon (IFN) induction in response to viral infection. Mounting evidence suggests that another viral RNA sensor, protein kinase R (PKR), may also be critical for IFN induction during infection, although its exact contribution and mechanism of action are not completely understood. Using PKR-deficient cells, we found that PKR was required for type I IFN induction in response to infection by vaccinia virus lacking the PKR antagonist E3L (VVΔE3L), but not by Sendai virus or influenza A virus lacking the IFN-antagonist NS1 (FluΔNS1). IFN induction required the catalytic activity of PKR, but not the phosphorylation of its principal substrate, eIF2α, or the resulting inhibition of host translation. In the absence of PKR, IRF3 nuclear translocation was impaired in response to MDA5 activators, VVΔE3L and encephalomyocarditis virus, but not during infection with a RIG-I-activating virus. Interestingly, PKR interacted with both RIG-I and MDA5; however, PKR was only required for MDA5-mediated, but not RIG-I-mediated, IFN production. Using an artificially activated form of PKR, we showed that PKR activity alone was sufficient for IFN induction. This effect required MAVS and correlated with IRF3 activation, but no longer required MDA5. Nonetheless, PKR activation during viral infection was enhanced by MDA5, as virus-stimulated catalytic activity was impaired in MDA5-null cells. Taken together, our data describe a critical and non-redundant role for PKR following MDA5, but not RIG-I, activation to mediate MAVS-dependent induction of type I IFN through a kinase-dependent mechanism.