Adenovirus E1A/E1B Transformed Amniotic Fluid Cells Support Human Cytomegalovirus Replication.

The human cytomegalovirus (HCMV) replicates to high titers in primary human fibroblast cell cultures. A variety of primary human cells and some tumor-derived cell lines do also support permissive HCMV replication, yet at low levels. Cell lines established by transfection of the transforming functions of adenoviruses have been notoriously resistant to HCMV replication and progeny production. Here, we provide first-time evidence that a permanent cell line immortalized by adenovirus type 5 E1A and E1B (CAP) is supporting the full HCMV replication cycle and is releasing infectious progeny. The CAP cell line had previously been established from amniotic fluid cells which were likely derived from membranes of the developing fetus. These cells can be grown under serum-free conditions. HCMV efficiently penetrated CAP cells, expressed its immediate-early proteins and dispersed restrictive PML-bodies. Viral DNA replication was initiated and viral progeny became detectable by electron microscopy in CAP cells. Furthermore, infectious virus was released from CAP cells, yet to lower levels compared to fibroblasts. Subviral dense bodies were also secreted from CAP cells. The results show that E1A/E1B expression in transformed cells is not generally repressive to HCMV replication and that CAP cells may be a good substrate for dense body based vaccine production.

High cell density cultivations by alternating tangential flow (ATF) perfusion for influenza A virus production using suspension cells.

High cell densities in animal cell culture can be obtained by continuous perfusion of fresh culture medium across hollow fiber membranes that retain the cells. Careful selection of the membrane type and cut-off allows to control accumulation of target molecules and removal of low molecular weight compounds. In this report, perfusion with the scalable ATF (alternating tangential filtration, Refine Technology) system was evaluated for two suspension cell lines, the avian cell line AGE1.CR and the human cell line CAP. Both were cultivated in chemically defined media optimized for batch cell growth in a 1L stirred tank bioreactor connected to the smallest ATF unit (ATF2) and infected with cell line-adapted human influenza A virus (A/PR/8/34 (H1N1), typical diameter: 80-100 nm). At concentrations of about 25 million cells/mL three different membrane cut-offs (50 kDa, 0.2 µm and 0.5 µm) were tested and compared to batch cultivations performed at 5 million cells/mL. For medium and large cut-offs no cell-density effect could be observed with cell-specific virus yields of 1428-1708 virions/AGE1.CR cell (infected with moi 0.001) and 1883-4086 virions/CAP cell (moi of 0.025) compared to 1292 virions/AGE1.CR cell and 3883 virions/CAP cell in batch cultures. Even at a concentration of 48 million AGE1.CR cells/mL (cut-off: 0.2 µm) a cell-specific yield of 1266 virions/cell was reached. Only for the small cut-off (50 kDa) used with AGE1.CR cells a decrease in cell-specific yield was measured with 518 virions/cell. Surprisingly, the ratio of infectious to total virions seemed to be increased in ATF compared to batch cultures. AGE1.CR cell-derived virus particles were present in the permeate (0.2 and 0.5 µm cut-off), whereas CAP cell-derived virions were not, suggesting possible differences in morphology, aggregation or membrane properties of the virions released by the two cell lines. To our knowledge, this is the first study that illustrates the potential of ATF-based perfusion of chemically defined media across cell-retaining membranes for production of an influenza A vaccine.

CAP, a new human suspension cell line for influenza virus production.

Forced by major drawbacks of egg-based influenza virus production, several studies focused on the establishment and optimization of cell-based production systems. Among numerous possible host cell lines from duck, monkey, canine, chicken, mouse, and human origin, only a few will meet regulatory requirements, accomplish industrial standards, and result in high virus titers. From primary virus isolation up to large-scale manufacturing of human vaccines, however, the most logical choice seems to be the use of human cell lines. For this reason, we evaluated the recently established CAP cell line derived from human amniocytes for its potential in influenza virus production in suspension culture in small scale shaker flask and stirred tank bioreactor experiments. Different human and animal influenza viruses could be adapted to produce hemagglutination (HA) titers of at least 2.0 log(10) HA units/100 µL without further process optimization. Adjusting trypsin activity as well as infection conditions (multiplicity of infection, infection medium) resulted in HA titers of up to 3.2 log(10) HA units/100 µL and maximum cell-specific virus productivities of 6,400 virions/cell (for human influenza A/PR/8/34 as a reference). Surface membrane expression of sialyloligosaccharides as well as HA N-glycosylation patterns were characterized. Overall, experimental results clearly demonstrate the potential of CAP cells for achieving high virus yields for different influenza strains and the option to introduce a highly attractive fully characterized human cell line compliant with regulatory and industrial requirements as an alternative for influenza virus vaccine production.

Transient recombinant protein expression in a human amniocyte cell line: the CAP-T® cell system.

The impact of transient gene expression approaches (TGE) on the rapid production of recombinant proteins is undisputed, despite that all efforts are currently relying on two host cell families only, namely HEK293 derivatives and CHO cell line(s). Yet, the increasing complexity of biological targets calls for more than two host cell types to meet the challenges of difficult-to-express proteins. For this reason, we evaluated the more recently established novel CAP-T® cell line derived from human amniocytes for its performance and potential in transient gene expression. Upon careful analyses and adaptation of all process parameters we show here that indeed the CAP-T® cells are extremely amenable to transient gene expression and recombinant protein production. Additionally, they possess inherent capabilities to express and secrete complex and difficult target molecules, thus adding an attractive alternative to the repertoire of existing host cell lines used in transient production processes.

Genomic integration of adenoviral gene transfer vectors following transduction of fertilized mouse oocytes.

Adenoviral vectors (AdV) are popular tools to deliver foreign genes into a wide range of cells. They have also been used in clinical gene therapy trials. Studies on AdV-mediated gene transfer to mammalian oocytes and transmission through the germ line have been reported controversially. In the present study we investigated whether AdV sequences integrate into the mouse genome by microinjecting AdV into the perivitelline space of fertilized oocytes. We applied a newly developed PCR technique (HiLo-PCR) for identification of chromosomal junctions next to the integrated AdV. We demonstrate that mouse oocytes can be transduced by different recombinant adenoviral vectors (first generation and gutless). In one transgenic mouse line using the first generation adenoviral vector, the genome has integrated into a highly repetitive cluster located on the Y chromosome. While the transgene (GFP) was expressed in early embryos, no expression was detected in adult transgenic mice. The use of gutless AdV resulted in expression of the transgene, albeit the vector was not transmitted to progeny. These results indicate that under optimized conditions fertilized mouse oocytes are transduced by AdV and give rise to transgenic founder animals. Therefore, adequate precautions should be taken in gene therapy protocols of reproductive patients since transduction of oocytes or early embryos and subsequent chromosomal integration cannot be ruled out entirely.

Efficient and reproducible generation of high-expressing, stable human cell lines without need for antibiotic selection.

BACKGROUND: Human cell lines are the most innovative choice of host cell for production of biopharmaceuticals since they allow for authentic posttranslational modification of therapeutic proteins. We present a new method for generating high and stable protein expressing cell lines based on human amniocytes without the requirement of antibiotic selection. RESULTS: Primary amniocytes from routine amniocentesis samples can be efficiently transformed with adenoviral functions resulting in stable human cell lines. Cotransfection of the primary human amniocytes with a plasmid expressing adenoviral E1 functions plus a second plasmid containing a gene of interest resulted in permanent cell lines expressing up to 30 pg/cell/day of a fully glycosylated and sialylated protein. Expression of the gene of interest is very stable for more than 90 passages and, importantly, was achieved in the absence of any antibiotic selection. CONCLUSION: We describe an improved method for developing high protein expressing stable human cell lines. These cell lines are of non-tumor origin, they are immortalized by a function not oncogenic in human and they are from an ethically accepted and easily accessible cell source. Since the cell can be easily adapted to growth in serum-free and chemically defined medium they fulfill the requirements of biopharmaceutical production processes.

Sustained muscle expression of dystrophin from a high-capacity adenoviral vector with systemic gene transfer of T cell costimulatory blockade.

Adenoviral vector (Ad)-mediated gene delivery of normal, full-length dystrophin to skeletal muscle provides a promising strategy for the treatment of Duchenne muscular dystrophy (DMD). However, cellular and humoral immune responses induced by vector gene transfer limit the application of this approach. Blockade of the costimulatory interaction between naïve T cells and antigen-presenting cells has proven to be a successful means to diminish immunity induced by gene transfer. In this study we explore the potential of supplementing dystrophin gene delivery to dystrophin-deficient Dmd mouse skeletal muscle with systemic gene delivery of CTLA4Ig and CD40Ig molecules to effect costimulatory blockade. We found that systemic administration of a high-capacity Ad (HC-Ad) vector carrying murine CTLA4Ig (AdmCTLA4Ig) either alone or codelivered with an HC-Ad vector carrying murine CD40Ig (AdmCD40Ig) provided sustained expression of recombinant full-length murine dystrophin from an HC-Ad vector carrying the dystrophin cDNA (AdmDys). The level of AdmDys vector genomes remained stable in animals cotreated with systemic delivery of vectors carrying molecules to block costimulation. In addition, muscle CD4(+) and CD8(+) T cell infiltrates and Th1 cytokine production by splenocytes were reduced. The production of neutralizing antibody against Ad vector was significantly inhibited in mice receiving systemic codelivery of both AdmCTLA4Ig and AdmCD40Ig, but not in the mice treated with AdmCTLA4Ig alone. The results suggested that coblockade of both CD28/B7 and CD40L/CD40 costimulatory pathways is required for effective inhibition of the Ad vector-induced humoral immune response in Dmd mice, whereas blockade of CD28/B7 alone by murine CTLA4Ig would be sufficient for prolonged dystrophin expression in treated muscle.

A hemodynamic response to intravenous adenovirus vector particles is caused by systemic Kupffer cell-mediated activation of endothelial cells.

Intravascular injection of adenoviral vectors may result in a toxic and potentially lethal reaction, the mechanism of which is poorly understood. We noted that mice demonstrated a transient change in behavior that was characterized by inactivity and lethargy within minutes after intravenous injection of relatively low doses of adenoviral vectors (including high-capacity gutless vectors). Moreover, immediately after vector injection a significant drop in blood pressure was measured that most probably was caused by the systemic activation of endothelial cells as monitored by detection of phosphorylated Akt/PKB kinase, activated endothelial nitric oxide synthase (eNOS), and nitrotyrosine. The activation of the endothelium was the result of the interaction of viral particles with Kupffer cells, which are resident macrophages of the liver representing the first line of defense of the innate immune system. Surprisingly, the uptake of vector particles by Kupffer cells not only resulted in their strong activation, but also in their nearly complete disappearance from the liver. Our results suggest that the toxicity of intravenously injected adenoviral vectors may be directly linked to the activation and destruction of Kupffer cells.

Selective depletion or blockade of Kupffer cells leads to enhanced and prolonged hepatic transgene expression using high-capacity adenoviral vectors.

Tissue macrophages, in particular hepatic Kupffer cells (KCs), contribute to early inflammatory responses following adenoviral vector administration. This study evaluates the effect of selective and transient (3 days) depletion of KCs by a single injection of clodronate liposomes on the in vivo performance of high-capacity adenoviral (HC-Ad) vectors. In KC-depleted C57BL/6 and C3H mice increased and stabilized hAAT levels were observed following intravenous injection of HC-Ad vectors expressing human alpha-1 anti-trypsin (hAAT) either from the hAAT promoter or from the human cytomegalovirus promoter. Comparable increases in hAAT levels were obtained in mice preinjected with a transcriptionally silent HC-Ad vector. Interestingly, in the majority of animals of both strains depletion of KCs was sufficient to prevent the generation of anti-hAAT antibodies, resulting in prolonged transgene expression. Thus, short-term and selective depletion of hepatic macrophages at the same time significantly increased hepatic transgene expression and reduced the humoral immune response to the transgenic protein.

Therapeutic factor VIII levels and negligible toxicity in mouse and dog models of hemophilia A following gene therapy with high-capacity adenoviral vectors.

High-capacity adenoviral (HC-Ad) vectors expressing B-domain-deleted human or canine factor VIII from different liver-specific promoters were evaluated for gene therapy of hemophilia A. Intravenous administration of these vectors into hemophilic FVIII-deficient immunodeficient SCID mice (FVIIIKO-SCID) at a dose of 5 x 10(9) infectious units (IU) resulted in efficient hepatic gene delivery and long-term expression of supraphysiologic FVIII levels (exceeding 15 000 mU/mL), correcting the bleeding diathesis. Injection of only 5 x 10(7) IU still resulted in therapeutic FVIII levels. In immunocompetent hemophilic FVIII-deficient mice (FVIIIKO), FVIII expression levels peaked at 75 000 mU/mL but declined thereafter because of neutralizing anti-FVIII antibodies and a cellular immune response. Vector administration did not result in thrombocytopenia, anemia, or elevation of the proinflammatory cytokine interleukin-6 (IL-6) and caused no or only transient elevations in serum transaminases. Following transient in vivo depletion of macrophages before gene transfer, significantly higher and stable FVIII expression levels were observed. Injection of only 5 x 10(6) HC-Ad vectors after macrophage depletion resulted in long-term therapeutic FVIII levels in the FVIIIKO and FVIIIKO-SCID mice. Intravenous injection of an HC-Ad vector into a hemophilia A dog at a dose of 4.3 x 10(9) IU/kg led to transient therapeutic canine FVIII levels that partially corrected whole-blood clotting time. Inhibitory antibodies to canine FVIII could not be detected, and there were no signs of hepatotoxicity or of hematologic abnormalities. These results contribute to a better understanding of the safety and efficacy of HC-Ad vectors and suggest that the therapeutic window of HC-Ad vectors could be improved by minimizing the interaction between HC-Ad vectors and the innate immune system.

Efficient in vitro and in vivo excision of floxed sequences with a high-capacity adenoviral vector expressing Cre recombinase.

Conditional gene expression or gene disruption using Cre/loxP- or FLP/frt-based recombination systems are valuable tools for studying gene function in development and disease. Recombinant adenoviral vectors expressing Cre recombinase have been suggested as an alternative for deletion of floxed sequences. To further improve this approach we generated a high-capacity adenoviral (HC-Ad) vector expressing Cre (HC-Adcre). In this vector all viral coding sequences are deleted resulting in decreased toxicity. In the present study HC-Adcre efficiently mediated recombination between two loxP sites located in the genome of a reporter cell line. When intravenously injected into ROSA26 reporter mice, a floxed sequence was excised in hepatocytes resulting in expression of the beta-gal reporter. Our data indicate that HC-Ad vectors expressing Cre effectively delete floxed sequences in vivo and have a significant potential as a tool for functional studies in mice.

A DNA-based method to assay total and infectious particle contents and helper virus contamination in high-capacity adenoviral vector preparations.

High-capacity adenoviral (HC-Ad) vectors are devoid of all viral genes. Therefore, these vectors feature reduced toxicity, immunogenicity, and increased capacity for foreign DNA. HC-Ad vectors are produced in E1-transformed cell lines in the presence of an E1-deleted helper virus that provides in trans all viral functions necessary for vector production. By cre/loxP- or FLPe/Frt-mediated recombination the packaging signal of the helper virus is excised during vector production resulting in nonpackagable helper virus genomes. Although recombinase-mediated excision of the packaging signal from the helper virus genome is highly efficient, a small number of helper virus genomes with retained packaging signals are still packaged into capsids. For clinical trials, HC-Ad vector preparations have to be characterized accurately with respect to the number of (1) total HC-Ad vector particles, (2) infectious HC-Ad vector particles, and (3) the number of contaminating helper virus particles. We describe a fast and versatile DNA-based biologic assay for determination of these three parameters by standard laboratory methods. This assay is a useful tool for determining bioactivity data of adenoviral vector preparations and, importantly, allows their comparison among different studies.

Variables affecting in vivo performance of high-capacity adenovirus vectors.

In high-capacity adenovirus (HC-Ad) vectors the size and/or composition of the vector genome influences vector stability during production and the expression profile following gene transfer. Typically, an HC-Ad vector will contain both a gene or an expression cassette and stuffer DNA that is required to balance the final vector genome to a size of between 27 and 36 kb. To gain an improved understanding of factors that may influence gene expression from HC-Ad vectors, we have generated a series of vectors that carry different combinations of human alpha-1 antitrypsin (hAAT) expression constructs and stuffer DNAs. Expression in vitro did not predict in vivo performance: all vectors expressed hAAT at similar levels when tested in cell culture. Hepatic expression was evaluated following in vivo gene transfer in C57BL/6J mice. hAAT levels obtained from genomic DNA were significantly higher than levels achieved with small cDNA expression cassettes. Expression was independent of the orientation and only marginally influenced by the location of the expression cassette within the vector genome. The use of lambda stuffer DNA resulted in low-level but stable expression for at least 3 months when higher doses were applied. A potential matrix attachment region element was identified within the hAAT gene and caused a 10-fold increase in expression when introduced in an HC-Ad vector genome carrying a phosphoglycerate kinase (pgk) hAAT cDNA construct. We also illustrate the influence of the promoter on anti-hAAT antibody formation in C57BL/6J mice: a human cytomegalovirus but not a pgk promoter resulted in an anti-hAAT antibody response. Thus, the overall design of HC-Ad vectors may significantly influence amounts and duration of gene expression at different levels.