Environmental hazard and risk assessment of thiochemicals. Application of integrated testing and intelligent assessment strategies (ITS) to fulfil the REACH requirements for aquatic toxicity.

REACH requires information on hazardous properties of substances to be generated avoiding animal testing where possible. It is the objective of the present case study with thiochemicals to extract as much information as possible from available experimental data with fish, daphnia and algae and to fill data gaps for analogues to be registered under REACH in 2018. Based on considerations of chemical similarity and common mode of action (MOA) the data gaps regarding the aquatic toxicity of the thiochemicals were largely closed by trend analysis ("category approach") and read-across within the same group, for example, thioglycolates or mercaptopropionates. Among 16 thiochemicals to be registered by 2018 there are only 2 substances with sufficient data. 36 data gaps for 14 thiochemicals were identified. Most of the required data (>60%) could be estimated by in silico methods. Only 14 tests (6 algae, 6 daphnia, 1 limit fish test and 1 acute fish test) were proposed. When the results of these tests are available it has to be discussed whether 2 further fish (limit) tests are required. For two substances (exposure-based) waiving was suggested. The relatively high toxicity of the thiochemicals is manifested in low predicted no-effect concentrations (PNECs). Only preliminary predicted environmental concentrations (PECs) could be derived for the thiochemicals for which a risk assessment has to be performed (production rate >10 t/y). The preliminary PEC/PNEC ratios indicate no risk for the aquatic compartment at the production site. PECs due to down-stream use must not exceed the estimated PNECs.

Biodegradation tests of mercaptocarboxylic acids, their esters, related divalent sulfur compounds and mercaptans.

Mercaptocarboxylic acids and their esters, a class of difunctional compounds bearing both a mercapto and a carboxylic acid or ester functional group, are industrial chemicals of potential environmental concern. Biodegradation of such compounds was systematically investigated here, both by literature search and by experiments (Closed Bottle Test OECD 301D and Manometric Respirometry Test OECD 301F). These compounds were found either readily biodegradable or at least biodegradable to a significant extent. Some related compounds of divalent sulfur were tested for comparison (mercaptans, sulfides, disulfides). For the two relevant monofunctional compound classes, carboxylic acids/esters and mercaptans, literature data were compiled, and by comparison with structurally similar compounds without these functional groups, the influence of COOH/COOR' and SH groups on biodegradability was evaluated. Thereby, an existing rule of thumb for biodegradation of carboxylic acids/esters was supported by experimental data, and a rule of thumb could be formulated for mercaptans. Concurrent to biodegradation, abiotic processes were observed in the experiments, rapid oxidative formation of disulfides (dimerisation of monomercaptans and cyclisation of dimercaptans) and hydrolysis of esters. Some problems that compromise the reproducibility of biodegradation test results were discussed.

Development of cultivation strategies for friulimicin production in Actinoplanes friuliensis.

Actinoplanes friuliensis is a rare actinomycete which produces the highly potent lipopeptide antibiotic friulimicin. This lipopeptide antibiotic is active against a broad range of multi-resistant gram-positive bacteria such as methicillin-resistant Enterococcus sp. and Staphylococcus aureus (MRE, MRSA) strains. Antibiotic biosynthesis and regulation in actinomycetes is very complex. In order to study the biosynthesis of these species and to develop efficient production processes, standardized cultivation conditions are a prerequisite. For this reason a chemically defined production medium for A. friuliensis was developed. With this chemically defined medium it was possible to analyze the influence of medium components on growth and antibiotic biosynthesis. These findings were used to develop process strategies for friulimicin production. The focus of the project presented here was to develop cultivation strategies which included fed-batch and continuous cultivation processes. In fed-batch processes, volumetric productivities for friulimicin of 1-2 mg/l h were achieved. In a perfusion process, a very simple cell retention system, which works via sedimentation of the mycelial cell pellets, was used. With this system, stable continuous cultivations with cell retention were dependent on the dilution rate. With a dilution rate of 0.05 h(-1), cell retention worked well and volumetric productivity of friulimicin was enhanced to 3-5 mg/l h. With a higher dilution rate of 0.1 h(-1), friulimicin production ceased because cell retention was not possible any longer with this simple cell retention system. In order to support process development, cultivation data were used to characterize metabolic fluxes in the developed friulimicin production processes.

Complete genome sequence of the actinobacterium Actinoplanes friuliensis HAG 010964, producer of the lipopeptide antibiotic friulimycin.

Actinoplanes friuliensis HAG 010964 (DSM 7358) was isolated from a soil sample from the Friuli region in Italy and characterized as a producer of the antibiotic friulimycin. The complete genome sequence includes genomic information of secondary metabolite biosynthesis and of its lifestyle. Genbank/EMBL/DDBJ Accession Nr: CP006272 (chromosome).

Guidance for the classification of carcinogens under the Globally Harmonised System of Classification and Labelling of Chemicals (GHS).

The United Nations Conference on Environment and Development (UNCED) has developed criteria for a globally harmonised system of classification and labelling of chemicals (GHS). With regard to carcinogenicity, GHS distinguishes between Category 1 ('known or presumed human carcinogens') and Category 2 ('suspected human carcinogens'). Category 1 carcinogens are divided into Category 1A ('known to have carcinogenic potential for humans'), based largely on human evidence, and 1B ('presumed to have carcinogenic potential for humans'), based largely on experimental animal data. Concerns have been raised that the criteria for applying these carcinogenicity classifications are not sufficiently well defined and potentially allow different conclusions to be drawn. The current document describes an attempt to reduce the potential for diverse conclusions resulting from the GHS classification system through the application of a series of questions during the evaluation of data from experiments with rodents; epidemiological data, which could lead to Category 1A, have not been considered. Answers to each question can lead either to a classification decision or to the next question, but this process should only be implemented in an environment of informed scientific opinion. The scheme is illustrated with five case studies. These questions are: (1) Has a relevant form of the substance been tested? (2) Is the study design relevant to human exposure? (3) Is there a substance-related response? (4) Is the target tissue exposure relevant to humans? (5) Can a mode of action be established? (6) Is the mode of action relevant to humans? (7) What is the potency?

Comparative analysis of transcriptional activities of heterologous promoters in the rare actinomycete Actinoplanes friuliensis.

Manipulation of secondary metabolite production in the rare actinomycete Actinoplanes friuliensis, the producer of the lipopeptide antibiotic friulimicin, is hampered by the lack of sophisticated genetic tools. Since no expression vectors have been developed from endogenous Actinoplanes plasmids and expression signals, engineering of antibiotic biosynthesis relies on the use of vector systems derived from Streptomyces. While PhiC31 derived vectors were shown to integrate efficiently into the chromosome of Actinoplanes, information on promoter activity is missing. The manuscript describes the investigation of several different promoter systems which are widely used in Streptomyces in A. friuliensis by promoter probe experiments using eGFP as a reporter. These experiments indicated that promoter strength in A. friuliensis did not correlate to activity in Streptomyces lividans. The ermE* promoter regarded as one of the strongest promoter in Streptomyces has only low activity in A. friuliensis. In contrast, the promoter of the apramycin resistance gene aac(3)IV, originating from the Gram-negative Escherichia coli had the highest activity. By real-time RT-PCR experiments the transcription activity of ermE* promoter in comparison to a native promoter of the friulimicin biosynthetic gene cluster was analysed. This confirmed the results of the promoter probe experiments that indicated quite weak promoter activity of P-ermE* in Actinoplanes.

Analysis of RegA, a pathway-specific regulator of the friulimicin biosynthesis in Actinoplanes friuliensis.

The rare actinomycete Actinoplanes friuliensis is the producer of the lipopeptide antibiotic friulimicin, which is active against a broad range of Gram-positive bacteria such as methicillin-resistant Enterococcus spec. and Staphylococcus aureus (MRE, MRSA) strains. Friulimicin consists of a decapeptide core and an acyl residue linked to an exocyclic amino acid. The complete biosynthetic gene cluster consisting of 24 open reading frames was characterized by sequence analysis and the transcription units were subsequently determined by RT-PCR experiments. In addition to several genes for biosynthesis, self-resistance and transport four different regulatory genes (regA, regB, regC and regD) were identified within the cluster. To analyse the role of the pathway-specific regulatory protein RegA in the friulimicin biosynthesis, the corresponding gene was inactivated resulting in friulimicin non-producing mutants. Furthermore, several protein-binding sites within the friulimicin gene cluster were identified by gel retardation assays. By real-time RT-PCR experiments, it was shown that the majority of the friulimicin biosynthetic genes is positively regulated by RegA.

Natural feline coronavirus infection: differences in cytokine patterns in association with the outcome of infection.

Natural and experimental feline coronavirus (FCoV) infection leads to systemic viral spread via monocyte-associated viraemia and induces systemic proliferation of monocytes/macrophages. In the majority of naturally infected animals, FCoV infection remains subclinical and is associated with generalised B and T cell hyperplasia, but no other pathological findings. A minority of cats, however, develop feline infectious peritonitis (FIP), a fatal systemic granulomatous disease. This is generally accompanied by B and T cell depletion. The obvious functional differences of lymphatic tissues in FCoV-infected cats with and without FIP suggest that they contribute to the outcome of FCoV infection. This study attempted to evaluate the functional changes in haemolymphatic tissues after natural FCoV infection, with special emphasis on the magnitude, phenotype and function of the monocyte/macrophage population. The spleen, mesenteric lymph nodes and bone marrow from naturally FCoV-infected cats with and without FIP and specific pathogen-free (SPF) control cats were examined for the quantity and activation state of monocytes/macrophages both by immunohistology and by quantitative real time PCR for the transcription of interleukin (IL)-1beta, IL-6, IL-10, IL-12 p40, tumour necrosis factor (TNF), granulocyte colony stimulating factor (G-CSF), macrophage-CSF (M-CSF) and GM-CSF. Compared to cats with FIP, FCoV-infected cats without FIP exhibited significantly higher IL-10 levels in the spleen and significantly lower levels of IL-6, G- and M-CSF in mesenteric lymph nodes. In cats with FIP, however, IL-12 p40 levels were significantly lower in lymphatic tissues in comparison to both SPF cats and FCoV-infected cats without FIP. In comparison to SPF cats, FIP cats had significantly higher IL-1beta levels and lower TNF levels in mesenteric lymph nodes and lower M-CSF levels in the spleen. Findings indicate that FCoV-infected cats which do not develop FIP are able to mount an effective FCoV-specific immune response and can avoid excessive macrophage activation and FIP, possibly by upregulation of IL-10 production. Development of FIP, however, might be due to a lack of IL-12 which inhibits an effective cellular immune response and allows for monocyte/macrophage activation and the development of FIP.

Phosphinothricin tripeptide synthetases in Streptomyces viridochromogenes Tü494.

The tripeptide backbone of phosphinothricin (PT) tripeptide (PTT), a compound with herbicidal activity from Streptomyces viridochromogenes, is assembled by three stand-alone peptide synthetase modules. The enzyme PhsA (66 kDa) recruits the PT-precursor N-acetyl-demethylphosphinothricin (N-Ac-DMPT), whereas the two alanine residues of PTT are assembled by the enzymes PhsB and PhsC (129 and 119 kDa, respectively). During or after assembly, the N-Ac-DMPT residue in the peptide is converted to PT by methylation and deacetylation. Both phsB and phsC appear to be cotranscribed together with two other genes from a single promoter and they are located at a distance of 20 kb from the gene phsA, encoding PhsA, in the PTT biosynthesis gene cluster of S. viridochromogenes. PhsB and PhsC represent single nonribosomal peptide synthetase elongation modules lacking a thioesterase domain. Gene inactivations, genetic complementations, determinations of substrate specificity of the heterologously produced proteins, and comparison of PhsC sequence with the amino terminus of the alanine-activating nonribosomal peptide synthetase PTTSII from S. viridochromogenes confirmed the role of the two genes in the bialanylation of Ac-DMPT. The lack of an integral thioesterase domain in the PTT assembly system points to product release possibly involving two type II thioesterase genes (the1 and the2) located in the PTT gene cluster alone or in conjunction with an as yet unknown mechanism of product release.

An acyl-CoA dehydrogenase is involved in the formation of the Delta cis3 double bond in the acyl residue of the lipopeptide antibiotic friulimicin in Actinoplanes friuliensis.

The lipopeptide antibiotic friulimicin, produced by Actinoplanes friuliensis, is an effective drug against Gram-positive bacteria, such as methicillin-resistant Staphylococcus epidermidis and Staphylococcus aureus strains. Friulimicin consists of a cyclic peptide core of ten amino acids and an acyl residue linked to an exocyclic amino acid. The acyl residue is essential for antibiotic activity, varies in length from C13 to C15, and carries a characteristic double bond at position Delta cis3. Sequencing of a DNA fragment adjacent to a previously described fragment encoding some of the friulimicin biosynthetic genes revealed several genes whose gene products resemble enzymes of lipid metabolism. One of these genes, lipB, encodes an acyl-CoA dehydrogenase homologue. To elucidate the function of the LipB protein, a lipB insertion mutant was generated and the friulimicin derivative (FR242) produced by the mutant was purified. FR242 had antibiotic activity lower than friulimicin in a bioassay. Gas chromatography showed that the acyl residue of wild-type friulimicin contains a double bond, whereas a saturated bond was present in FR242. These results were confirmed by the heterologous expression of lipB in Streptomyces lividans T7, which led to the production of unsaturated fatty acids not found in the S. lividans T7 parent strain. These results indicate that the acyl-CoA dehydrogenase LipB is involved in the introduction of the unusual Delta cis3 double bond into the acyl residue of friulimicin.

Biosynthetic gene cluster of the herbicide phosphinothricin tripeptide from Streptomyces viridochromogenes Tü494.

The antibiotic phosphinothricin tripeptide (PTT) consists of two molecules of L-alanine and one molecule of the unusual amino acid phosphinothricin (PT) which are nonribosomally combined. The bioactive compound PT has bactericidal, fungicidal, and herbicidal properties and possesses a C-P-C bond, which is very rare in natural compounds. Previously uncharacterized flanking and middle regions of the PTT biosynthetic gene cluster from Streptomyces viridochromogenes Tü494 were isolated and sequenced. The boundaries of the gene cluster were identified by gene inactivation studies. Sequence analysis and homology searches led to the completion of the gene cluster, which consists of 24 genes. Four of these were identified as undescribed genes coding for proteins that are probably involved in uncharacterized early steps of antibiotic biosynthesis or in providing precursors of PTT biosynthesis (phosphoenolpyruvate, acetyl-coenzyme A, or L-alanine). The involvement of the genes orfM and trs and of the regulatory gene prpA in PTT biosynthesis was analyzed by gene inactivation and overexpression, respectively. Insight into the regulation of PTT was gained by determining the transcriptional start sites of the pmi and prpA genes. A previously undescribed regulatory gene involved in morphological differentiation in streptomycetes was identified outside of the left boundary of the PTT biosynthetic gene cluster.

Tricarboxylic acid cycle aconitase activity during the life cycle of Streptomyces viridochromogenesTü494.

Previously, it was shown that inactivation of the tricarboxylic acid cycle aconitase gene acnA impairs the morphological and physiological differentiation of Streptomyces viridochromogenes Tü494, which produces the herbicide phosphinothricin tripeptide (PTT). In order to further characterize the role of the aconitase in the Streptomyces life cycle, aconitase activity was analyzed during growth of S. viridochromogenes in liquid culture. Two prominent maxima were measured in cell-free crude extracts. The first maximum was found at an early stage of growth, which is correlated with a decrease in pH when rapid glucose consumption is initiated. The second, lower maximum was detected at the beginning of the expression of the PTT-specific biosynthetic gene phsA,implying the onset of secondary metabolism. These results were confirmed by examining transcription of the acnA promoter in time-course experiments. The highest transcription rate was found during the early growth phases. In order to identify putative regulatory mechanisms, the transcriptional start site of the acnA transcript and subsequently the promoter were identified. Several putative, regulatory protein binding sites (e.g. regulators of oxygen stress or iron metabolism) were detected in the promoter region of acnA, which suggested complex regulation of acnA.