In-situ methane enrichment in anaerobic digestion of food waste slurry by nano zero-valent iron: Long-term performance and microbial community succession.

In this work, nano zero-valent iron (nZVI) was added to a lab-scale continuous stirring tank reactor (CSTR) for food waste slurry treatment, and the effect of dosing rate and dosage of nZVI were attempted to be changed. The results showed that anaerobic digestion (AD) efficiency and biomethanation stability were optimum under the daily dosing and dosage of 0.48 g/gTCOD. The average daily methane (CH4) yield reached 495.38 mL/gTCOD, which was 43.65% higher than that at control stage, and the maximum CH4 content reached 95%. However, under single dosing rate conditions, high nZVI concentrations caused microbial cell rupture and loosely bound extracellular polymeric substances (LB-EPS) precipitation degradation. The daily dosing rate promoted the hydrogenotrophic methanogenesis pathway, and the activity of coenzyme F420 increased by 400.29%. The microbial analysis indicated that daily addition of nZVI could promote the growth of acid-producing bacteria (Firmicutes and Bacteroidetes) and methanogens (Methanothrix).

Insight into the effect of rice-straw ash on enhancing the anaerobic digestion performance of high salinity organic wastewater.

Anaerobic digestion is an economic method for treating high salinity organic wastewater (HSOW), but performance enhancement is needed because of the inhibitory effect of high salinity. In this study, rice-straw ash (RSA) was applied to alleviate the inhibitory effect during HSOW anaerobic digestion. The results showed that, when the NaCl content increased from 0% to 3.0%, the methane production decreased by 87.35%, and the TOC removal rate decreased to 34.12%. As a K+ and alkalinity source, RSA addition enhanced the anaerobic digestion performance, and the optimal dosage was 0.88 g/L. Under this dosage, the methane production increased by 221.60%, and TOC removal rate reached 66.42% at 3.0% salinity. The addition of RSA increased the proportion of living cells in the high salinity environment, and enhanced the activity of key enzymes and electron transfer efficiency in the anaerobic digestion process. The addition of RSA with a dosage of 0.88 g/L promoted the accumulation of acetoclastic methanogen Methanothrix. The abundance of substrate transporters, ion transporters and electron transfer related functional genes were enriched, which might be key for promoting HSOW anaerobic digestion performance. The results also showed that RSA addition played an important role in maintaining the stability of the anaerobic digestion system, and it could be a potential strategy for enhancing the anaerobic digestion performance under high salinity conditions.

Enhancement of methane production in anaerobic digestion of high salinity organic wastewater: The synergistic effect of nano-magnetite and potassium ions.

During high salinity organic wastewater (HSOW) anaerobic digestion treatment, the process of methanogenesis can be severely inhibited in the high salinity environment, and the accumulation of volatile organic acids (VFAs) leads to failure of the anaerobic reaction. In this study, nano-magnetite and KCl were adopted to alleviate the inhibitory effect of high salinity and enhance the HSOW anaerobic digestion performance. The result showed that, under the optimal dosage of 200 mg/L, nano-magnetite addition promoted the anaerobic digestion performance, and the methane production increased by 11.06%. When KCl was added with a dosage of 0.174%, the methane production increased by 98.37%. The simultaneous addition of nano-magnetite (200 mg/L) and KCl showed a synergistic effect on enhancing HSOW anaerobic digestion performance, and the methane production increased by 124.85%. The addition of nano-magnetite and KCl promoted the conversion of VFAs, especially accelerated the degradation of propionic acid and butyric acid, also it promoted the activity of acetate kinase, dehydrogenase and F420, and thereby enhanced the methanogenesis process. This study could provide a new method for enhancing the anaerobic digestion of HSOW.

Enhanced chloride-free snow-melting agent generation from organic wastewater by integrating bioconversion and synthesis.

In this study, a new process for producing chloride-free snow-melting agents (CSAs) was proposed. Organic wastewater was converted to total volatile fatty acids (TVFA) by anaerobic acidogenic fermentation. The experiments for acid generation showed that the maximum TVFA concentration of 45.9 g/L was obtained at an organic loading rate of 5 g chemical oxygen demand /(L·d), and the proportion of acetic acid reached 78.8 %. Forward osmosis was used for concentrating the TVFA solution. The obtained CSAs, after evaporation and crystallization, had a better ice-melting capacity and less corrosion on metal and concrete than NaCl and CaCl2. Additionally, the damage caused by CSAs to the germination of plant seeds was significantly lesser than that caused by chloride salts. This study proposed a feasible method for the high-value conversion of organic wastewater, providing a new direction for the reuse of organic wastewater.

Coagulation removal of dissolved organic matter (DOM) in nanofiltration concentrate of biologically treated landfill leachate by ZrCl4: Performance, mechanism and coagulant recycling.

Coagulation treatment is often applied for removing the residual refractory dissolved organic matter (DOM) in biologically treated landfill leachate nanofiltration concentrate (LLNC) before discharge or further desalination treatment. However, the DOM removal efficiency by traditional coagulant needs to be improved, and two problems including the coagulant loss and difficulty in disposal of coagulation sludge need to be resolved. Based on this practical demand, a new coagulant ZrCl4 was adopted for LLNC treatment for the first time. The results showed that, ZrCl4 was better than the traditional coagulants (FeCl3 and AlCl3) for DOM removal. Under the optimal condition of pH 6.0 and ZrCl4 dosage of 5.0 mM, the DOC content, UV254 and chromaticity of the LLNC reduced by 73.32%, 83.17% and 93.59%, respectively. All of the coagulants tested in this study could efficiently remove the hydrophobic and high molecular organics. There was an obvious difference between them for removal of hydrophobic, and small or medium molecular organics, and ZrCl4 was more effective. This might be due to the stronger negative charge neutralization capacity and larger floc size of ZrCl4, which was beneficial for DOM combination and adsorption. The loss of zirconium was only 2.11%, which was much lower than that of iron and aluminum. Furthermore, being recycled for 3 times after coagulant regeneration, the recovered zirconium coagulant showed no obvious difference with the original ZrCl4 for DOM removal, indicating the disposal problem of the produced coagulation sludge can be resolved. This study could provide a promising method for LLNC treatment.

Wild Heterotrophic Nitrifying Strain Pseudomonas BT1 Isolated from Kitchen Waste Sludge Restores Ammonia Nitrogen Removal in a Sewage Treatment Plant Shocked by Thiourea.

Thiourea is used in agriculture and industry as a metal scavenger, synthetic intermediate, and nitrification inhibitor. However, in wastewater, it can inhibit the nitrification process and induce the collapse of the nitrification system. In such a case, ammonia-oxidizing bacteria (AOB) lose their ability to remove ammonia. We investigated the nitrification system of a 60,000-t/d municipal sewage treatment plant in Nanjing, which collapsed after receiving 5-15 ppm (5-15 mg/L) thiourea. Ammonia nitrogen removal quickly recovered to more than 95% after inoculation with 10 t high-efficiency nitrification sludge, which was collected from a kitchen waste treatment plant. A heterotrophic nitrification strain was isolated from the inoculated sludge and identified as wild Pseudomonas by 16S rDNA sequencing and named "BT1." Based on thiourea tolerance tests, BT1 can tolerate a thiourea content of more than 500 ppm. For comparison, the in situ process was imitated by the simulation system, and the wastewater shocked by 10 ppm thiourea could still meet the emission standard after adding 1% (V/V) BT1. High-throughput sequencing analysis was applied to study microbial succession during thiourea shock loading. The results showed that Hydrogenophaga and Thiobacillus grew with the growth of BT1. Pseudomonas BT1 was used for a 6,000-t/d printed circuit board (PCB) wastewater treatment system, the nitrification system returned to normal in 15 days, and the degradation rate stabilized at more than 95%.

Enhanced biogas biological upgrading from kitchen wastewater by in-situ hydrogen supply through nano zero-valent iron corrosion.

The in-situ hydrogen supply by nano zero-valent iron (nZVI, nFe0) corrosion provided a feasible way to improve the efficiency of biogas biological upgrading. This work studied the effects of nZVI at different dosages (0, 2, 4, 6, 8 and 10 g/L) on anaerobic digestion of kitchen wastewater by two buffer systems 2-[4-(2-hydroxyethyl) piperazin-1-yl] ethanesulfonic acid (HEPES) and sodium hydrogen carbonate (NaHCO3). The addition of nZVI improved the content of methane (CH4) and stability of anaerobic digestion process. In HEPES buffer system, the CH4 was all increased and the maximum reached 90.51% with 10 g/L nZVI, higher than 32.25% compared to the control. The maximum hydrogen enrichment (HE) was 113 ppb after nZVI addition, indicating the mass transfer efficiency of hydrogen (H2) was improved. Microbial community analysis showed that the total relative abundance of Methanobacterium and Methanolinea at 10 g/L nZVI was 53.72%, which was 1.62 times of the control group. However, in the NaHCO3 buffer system with 10 g/L nZVI addition, the content of CH4 and the loosely bound extracellular polymeric substances (LB-EPS) was lower than the control. The results indicated that the addition of nZVI was feasible for biogas upgrading, and the bidirectional effect of nZVI on the promotion or inhibition of bio-methanation might be related to the buffer system of the anaerobic process.

Preparation of spiramycin fermentation residue derived biochar for effective adsorption of spiramycin from wastewater.

Spiramycin (SPI) fermentation residue (SFR) is classified as hazardous waste in China because of the residual antibiotics in it. SFR disposal in the traditional way is costly and wasteful of resources. In this study, pyrolysis method was adopted to covert SFR to biochar for SPI removal from wastewater, and the SPI adsorption performance was investigated. The results showed that the optimal pyrolysis temperature was 700 °C as the prepared biochar BC700 exhibited the highest SPI removal efficiency. The specific surface area of BC700 was 451.68 m2/g, and the maximum adsorption capacity was 147.28 mg/g. The adsorption mechanism involved electrostatic interaction, pore filling, π-π interaction, hydrogen bonding, and the participation of C-C and O-CO functional groups in the adsorption. No residual SPI was detected in BC700 indicating the detoxification of SFR was achieved. Moreover, after recycling for 5 times, the SPI removal efficiency was still higher than 80.0%. Therefore, this study could provide a promising method for SFR disposal.

Polytetrafluoroethylene (PTFE) hollow fiber AnMBR performance in the treatment of organic wastewater with varying salinity and membrane cleaning behavior.

PTFE hollow fiber anaerobic membrane bio-reactor (AnMBR) performance was investigated in the treatment of organic wastewater, with varying salinity and PTFE membrane cleaning behavior. The AnMBR was operated for 226 days, with a total and biological COD removal efficiency of 97.2% and 89.9% respectively, at a NaCl concentration of 35 g L-1. A high number of Proteobacteria (38.2%) and Bacteroidetes (25.9%) were present in the system, with an increase in membrane fouling rate from 1.88 × 1011 to 2.63 × 1011 m-1 d-1 with higher salinity. The effects of soluble microbial products (SMP), extracellular polymeric substances (EPS), low molecular-weight (LMW) carbohydrates, sludge particle size and inorganic element accumulation, were evaluated on membrane fouling. Flux recovery of fouled PTFE membranes reached 91.6% with offline cleaning. Overall, results indicate that PTFE hollow fiber AnMBR provides a promising method for the treatment of saline organic wastewater.

[Transformation of Protein in Sludge During High Solids Anaerobic Digestion].

Dewatered waste sludge with a total solid (TS) concentration of 12% was used for mesophilic (37℃) anaerobic digestion (AD). The biotransformation mechanism of protein and the reason for the low conversion efficiency of protein under high solids AD was investigated by analyzing the variation of protein composition in the sludge before and after AD. The results showed that the conversion rate of protein in the sludge was 34.26% after 45 days of AD. The reason for the low efficiency of protein conversion was the poor mass transfer efficiency under the condition of high solids content and the large amount of ammonia nitrogen produced with the hydrolysis. After 45 days of AD, the total ammonia nitrogen (TAN) concentration reached 1201 mg·L-1, which resulted in the inhibition of the AD process, especially the decomposition of protein. Some of the protein converted to humic acid-like and fulvic acid-like substances, which are more difficult to decompose based on the three-dimensional fluorescence spectroscopy (3D-EEM) analysis. Two-dimensional electrophoresis (2-DE)- mass spectrometry (MS) was adopted for identifying the composition of protein in sludge before and after AD. It showed that the relative molecular weight and the isoelectric point (pI) of the protein in the sludge decreased after AD and most of the proteins left in the digested sludge came from the micro-organisms. These proteins cannot be further decomposed by the microbes because of the decreased microbial metabolic capacity at the end of the AD process or lack of specific enzymes for the hydrolysis of these proteins. This ultimately resulted in the low decomposition efficiency of the total protein in the sludge.

Evaluation of potassium as promoter on anaerobic digestion of saline organic wastewater.

In this work, the effect of potassium on mesophilic anaerobic digestion (AD) of saline organic wastewater, which consisted of simulated effluents obtained from heparin sodium production, was studied. The results showed that the addition of potassium chloride (KCl) to saline organic wastewater enhanced the AD efficiency. The optimal dosage was found to be 0.174% when the salt (NaCl) content was 2.0%. Under this condition, the chemical oxygen demand (COD) removal efficiency, dehydrogenase activities, and the viability of microorganisms reached 62.7%, 55.7 TF µL-1, and 78.4%, respectively, which were 115.4%, 77.2%, and 20.3% higher than those without the addition of potassium chloride. The consumption of volatile fatty acids (VFAs) was enhanced during the AD process. Moreover, less humic-like and protein-like residues appeared in the wastewater after AD. Potassium could maintain the morphology of anaerobic microorganism under high salinity and showed a long-term effect.

Enriching ruminal polysaccharide-degrading consortia via co-inoculation with methanogenic sludge and microbial mechanisms of acidification across lignocellulose loading gradients.

Using lignocellulosic materials as substrates, ruminal microbiota were co-inoculated with anaerobic sludge at different loading rates (LR) to study the microbial community in the semi-continuous mode. The results indicated that the highest CH4 yield reached 0.22 L/g volatile solid at LR of 4 g/L/day, which obtained 56-58% of the theoretical value. In the steady stage with LR of 2-4 g/L/day and slurry recirculation, copies of total archaea increased. Especially the Methanobacteriales increased significantly (p < 0.05) to 3.30 × 108 copies/mL. The microbial communities were examined by MiSeq 16S rRNA sequencing. Enriched hydrolytic bacteria mainly belonged to Clostridiales, including Ruminococcus, Ruminiclostridium, and Ruminofilibacter settled in the rumen. High-active cellulase and xylanase were excreted in the co-inoculated system. Acid-producing bacteria by fermentation were affiliated with Lachnospiraceae and Bacteroidales. The acidogen members were mainly Spirochaetaceae and Clostridiales. Syntrophic oxidation bacteria mainly consisted of Synergistetes, propionate oxidizers (Syntrophobacter and Pelotomaculum), and butyrate oxidizers (Syntrophus and Syntrophomonas). There had no volatile fatty acid (VFA) accumulation and the pH values varied between 6.94 and 7.35. At LR of 6 g/L/day and a recirculation ratio of 1:1, the hardly degradable components and total VFA concentrations obviously increased. The total archaea and Methanobacteriales then deceased significantly to 8.56 × 105 copies/mL and 4.14 × 103 copies/mL respectively (p < 0.05), which resulted in the inhibition of methanogenic activities. Subsequently, microbial diversity dropped, and the hydrolytic bacteria and syntrophic oxidizers obviously decreased. In contrast, the abundances of Bacteroidales increased significantly (p < 0.05). Acetate, propionate, and butyrate concentrations reached 2.02, 6.54, and 0.53 g/L, respectively, which indicated "acidification" in the anaerobic reactor. Our study illustrated that co-inoculated anaerobic sludge enriched the ruminal function consortia and hydrogenotrophic methanogens played an important role in anaerobic digestion of lignocelluloses.

A model based on feature objects aided strategy to evaluate the methane generation from food waste by anaerobic digestion.

A model based on feature objects (FOs) aided strategy was used to evaluate the methane generation from food waste by anaerobic digestion. The kinetics of feature objects was tested by the modified Gompertz model and the first-order kinetic model, and the first-order kinetic hydrolysis constants were used to estimate the reaction rate of homemade and actual food waste. The results showed that the methane yields of four feature objects were significantly different. The anaerobic digestion of homemade food waste and actual food waste had various methane yields and kinetic constants due to the different contents of FOs in food waste. Combining the kinetic equations with the multiple linear regression equation could well express the methane yield of food waste, as the R2 of food waste was more than 0.9. The predictive methane yields of the two actual food waste were 528.22 mL g-1 TS and 545.29 mL g-1 TS with the model, while the experimental values were 527.47 mL g-1 TS and 522.1 mL g-1 TS, respectively. The relative error between the experimental cumulative methane yields and the predicted cumulative methane yields were both less than 5%.

[Construction of a High Efficiency Anaerobic Digestion System for Vinegar Residue].

The model of high solid anaerobic digestion was used by improving the degree of homogeneity of the reaction system and biogas slurry reflux to gradually increase the material load. The vinegar residue-efficient anaerobic digestion system was successfully constructed without pretreatment.The optimum anaerobic digestibility was observed when the material loading of the reaction system reached 6.15 g·(L·d)-1, when the amount of biogas produced per unit of dry material was 396 mL·g-1, and the amount of methane produced per unit of dry material was 211 mL·g-1. The degradation rate of hemicellulose reached 63.66%, which was the main reason for the improvement of anaerobic digestion performance. The degradation rates of cellulose and lignin were 21.46% and 24.43%, respectively. The lower degradation efficiency was mainly due to the complicated degradation of the benzene ring structure in lignin and hindered hydrolysis of cellulose, which had a shielding effect on cellulose degradation.

Nanog RNA-binding proteins YBX1 and ILF3 affect pluripotency of embryonic stem cells.

Nanog is a well-known transcription factor that plays a fundamental role in stem cell self-renewal and the maintenance of their pluripotent cell identity. There remains a large data gap with respect to the spectrum of the key pluripotency transcription factors' interaction partners. Limited information is available concerning Nanog-associated RNA-binding proteins (RBPs), and the intrinsic protein-RNA interactions characteristic of the regulatory activities of Nanog. Herein, we used an improved affinity protocol to purify Nanog-interacting RBPs from mouse embryonic stem cells (ESCs), and 49 RBPs of Nanog were identified. Among them, the interaction of YBX1 and ILF3 with Nanog mRNA was further confirmed by in vitro assays, such as Western blot, RNA immunoprecipitation (RIP), and ex vivo methods, such as immunofluorescence staining and fluorescent in situ hybridization (FISH), MS2 in vivo biotin-tagged RNA affinity purification (MS2-BioTRAP). Interestingly, RNAi studies revealed that YBX1 and ILF3 positively affected the expression of Nanog and other pluripotency-related genes. Particularly, downregulation of YBX1 or ILF3 resulted in high expression of mesoderm markers. Thus, a reduction in the expression of YBX1 and ILF3 controls the expression of pluripotency-related genes in ESCs, suggesting their roles in further regulation of the pluripotent state of ESCs.

Use low direct current electric field to augment nitrification and structural stability of aerobic granular sludge when treating low COD/NH4-N wastewater.

This study explored the effect of low direct current (DC, ⩽5 V) electric field on aerobic granules by using two identical square sequencing batch reactors (SBRs) when influent chemical oxygen demand to ammonia nitrogen (COD/NH4-N) ratio decreased from 6 to 1.2 (with COD fixed at 600 mg/L). Results showed that the granules from the electro-augmentation SBR had a more compact and dense microbial structure with enriched Actinobacteria, Bacteroidia, Betaproteobacteria, and Nitrospira. Compared to the control, these granules produced 17.4% and 21.5% more proteins and polysaccharides respectively in the extracellular polymeric substances (EPS), with their integrity coefficient stabilized at 3.3-5.2% during 120 days' operation. Interestingly, more di- and tri-valent metals were accumulated in the electro-augmented granules. In addition, greater than 99% nitrification especially with stably high nitratation efficiency was realized in this new system.

Therapeutic effects of induced pluripotent stem cells in chimeric mice with ß-thalassemia.

Although ß-thalassemia is one of the most common human genetic diseases, there is still no effective treatment other than bone marrow transplantation. Induced pluripotent stem cells have been considered good candidates for the future repair or replacement of malfunctioning organs. As a basis for developing transgenic induced pluripotent stem cell therapies for thalassemia, ß(654) induced pluripotent stem cells from a ß(654) -thalassemia mouse transduced with the normal human ß-globin gene, and the induced pluripotent stem cells with an erythroid-expressing reporter GFP were used to produce chimeric mice. Using these chimera models, we investigated changes in various pathological indices including hematologic parameters and tissue pathology. Our data showed that when the chimerism of ß(654) induced pluripotent stem cells with the normal human ß-globin gene in ß(654) mice is over 30%, the pathology of anemia appeared to be reversed, while chimerism ranging from 8% to 16% provided little improvement in the typical ß-thalassemia phenotype. Effective alleviation of thalassemia-related phenotypes was observed when chimerism with the induced pluripotent stem cells owning the erythroid-expressing reporter GFP in ß(654) mouse was greater than 10%. Thus, 10% or more expression of the exogenous normal ß-globin gene reduces the degree of anemia in our ß-thalassemia mouse model, whereas treatment with ß(654) induced pluripotent stem cells which had the normal human ß-globin gene had stable therapeutic effects but in a more dose-dependent manner.

Study on interaction between phosphorus and cadmium in sewage sludge during hydrothermal treatment by adding hydroxyapatite.

This study focused on the behavior of phosphorus (P) and its effect on cadmium (Cd) immobilization in sludge during hydrothermal treatment (HTT). The results showed that, after HTT other forms of P in sludge were almost completely converted into apatite P (AP) and the eco-toxicity and leachability of Cd was sharply decreased, signaling the immobilization effect of HTT on Cd in the sludge. Hydroxyapatite (HAP) addition showed a synergetic effect with HTT on Cd risk reduction, implying the immobilization effect of HTT on Cd could be partly attributed to the strong binding capacity of phosphorus with Cd. P content was found to have a strong relationship with the existing forms of Cd during HTT. The present results suggest that HTT with HAP addition could be a promising method for the safe disposal of Cd-contaminated sludge.

Improvement of methane production from waste activated sludge by on-site photocatalytic pretreatment in a photocatalytic anaerobic fermenter.

This paper reports a new technology that using on-site TiO2-photocatalytic pretreatment in the anaerobic digestion of waste activated sludge (WAS) can enhance WAS degradation and methane production in a novel photocatalytic anaerobic fermenter. The fermenter consists of a photocatalytic unit and a digestion unit. The photocatalytic unit can constantly supply soluble organics and has less negative effect on the activity of methanogens at the optimal photocatalytic time of 4h per day. After anaerobic digestion for 35days, 1266.7ml/l-sludge of methane, 67.4% of volatile solid (VS) reduction and 60.5% of total chemical oxygen demand (TCOD) removal were achieved in the photocatalytic anaerobic fermenter, compared with 923.2ml/l-sludge of methane, 48.9% of VS reduction and 43.5% TCOD removal in the control fermenter. The results indicate that timely utilization of solubilized organics by methanogens could avoid further mineralization by TiO2-photocatalysis, which not only improves methane production but also enhances WAS degradation.

Synergistic effect of rice husk addition on hydrothermal treatment of sewage sludge: fate and environmental risk of heavy metals.

Hydrothermal treatment (HTT) at 200°C was applied to immobilize heavy metals (HMs) and the effect of rice husk (RH) addition was investigated based on total HMs concentration, fractionation and leaching tests. The results indicated that a synergistic effect of RH addition and HTT could be achieved on reducing the risk of HMs from medium and low risk to no risk. Metals were redistributed and transformed from weakly bounded state to stable state during the HTT process under RH addition. Notably at a RH/sludge ratio of 1/1.75 (d.w.), all the HMs showed no eco-toxicity and no leaching toxicity, with the concentrations of leachable Cr, Ni, Cu and Cd decreased by 17%, 89%, 95% and 93%, respectively. This synergistic effect of RH addition and HTT on the risk reduction of HMs implies that HTT process with RH addition could be a promising and safe disposal technology for sewage sludge treatment in practice.