Brachiaria brizantha Grass as a Feedstock for Ethanol Production

HIGHLIGHTS Brachiaria brizantha proved to be a promising biomass for ethanol production. Fermentation was not impaired by the inhibitors furfural and hydroxymethylfurfural.

Abstract Different lignocellulosic biomasses are found worldwide and each country has its own important industrial crop that can be converted into high-value products, such as ethanol. Therefore, evaluation of new biomasses to be used in biorefineries is important to decrease the dependence on non-renewable resources and to guarantee sustainable development. This work evaluated Brachiaria brizantha, a grass commonly used as animal forage, and the standard biomass for 2G-ethanol, sugarcane bagasse. The chemical compositions of both biomasses were determined and different times and temperature of acid pretreatment were tested. Morphological analysis via scanning electron microscopy showed more deconstructed fibers after harsher biomass pretreatments. Simultaneous saccharification and fermentation of pretreated Brachiaria brizantha presented higher efficiency than when using sugarcane bagasse as the carbon source. A biomass conversion of 46 % was achieved when Brachiaria brizantha grass was pretreated with 2% sulfuric acid for 60 minutes. Moreover, fermentation was not impaired by the inhibitors furfural and hydroxymethylfurfural. It was concluded that Brachiaria brizantha is a promising biomass for ethanol production.

The influence of pretreatment methods on saccharification of sugarcane bagasse by an enzyme extract from Chrysoporthe cubensis and commercial cocktails: A comparative study.

Biomass enzymatic hydrolysis depends on the pretreatment methods employed, the composition of initial feedstock and the enzyme cocktail used to release sugars for subsequent fermentation into ethanol. In this study, sugarcane bagasse was pretreated with 1% H2SO4 and 1% NaOH and the biomass saccharification was performed with 8% solids loading using 10 FPase units/g of bagasse of the enzymatic extract from Chrysoporthe cubensis and three commercial cocktails for a comparative study. Overall, the best glucose and xylose release was obtained from alkaline pretreated sugarcane bagasse. The C. cubensis extract promoted higher release of glucose (5.32 g/L) and xylose (9.00 g/L) than the commercial mixtures. Moreover, the C. cubensis extract presented high specific enzyme activities when compared to commercial cocktails mainly concerning to endoglucanase (331.84 U/mg of protein), ß-glucosidase (29.48 U/mg of protein), ß-xylosidase (2.95 U/mg of protein), pectinase (127.46 U/mg of protein) and laccase (2.49 U/mg of protein).

Increased enzymatic hydrolysis of sugarcane bagasse from enzyme recycling.

BACKGROUND: Development of efficient methods for production of renewable fuels from lignocellulosic biomass is necessary to maximize yields and reduce operating costs. One of the main challenges to industrial application of the lignocellulosic conversion process is the high costs of cellulolytic enzymes. Recycling of enzymes may present a potential solution to alleviate this problem. In the present study enzymes associated with the insoluble fraction were recycled after enzymatic hydrolysis of pretreated sugarcane bagasse, utilizing different processing conditions, enzyme loadings, and solid loadings. RESULTS: It was found that the enzyme blend from Chrysoporthe cubensis and Penicillium pinophilum was efficient for enzymatic hydrolysis and that a significant portion of enzyme activity could be recovered upon recycling of the insoluble fraction. Enzyme productivity values (g glucose/mg enzyme protein) over all recycle periods were 2.4 and 3.7 for application of 15 and 30 FPU/g of glucan, representing an increase in excess of ten times that obtained in a batch process with the same enzyme blend and an even greater increase compared to commercial cellulase enzymes. CONCLUSIONS: Contrary to what may be expected, increasing lignin concentrations throughout the recycle period did not negatively influence hydrolysis efficiency, but conversion efficiencies continuously improved. Recycling of the entire insoluble solids fraction was sufficient for recycling of adhered enzymes together with biomass, indicative of an effective method to increase enzyme productivity.

Production and application of an enzyme blend from Chrysoporthe cubensis and Penicillium pinophilum with potential for hydrolysis of sugarcane bagasse.

Blending of the enzyme extracts produced by different fungi can result in favorable synergetic enhancement of the enzyme blend with regards to the main cellulase activities, as well as the inclusion of accessory enzymes that may not be as abundant in enzyme extracts produced by predominantly cellulase producing fungi. The Chrysoporthe cubensis:Penicillium pinophilum 50:50 (v/v) blend produced herein presented good synergy, especially for FPase and endoglucanase activities which were 76% and 48% greater than theoretical, respectively. This enzyme blend was applied to sugarcane bagasse previously submitted to a simple alkali pretreatment. Glucan hydrolysis efficiency reached an excess of 60% and xylan conversion exceeded 90%. Increasing the hydrolysis temperature from 45 to 50°C also resulted in a 16-20% increase in conversion of both glucan and xylan fractions. The blended enzyme extract obtained therefore showed great potential for application in the lignocellulose hydrolysis process.

Simultaneous saccharification and fermentation (SSF) of Jatropha curcas shells: utilization of co-products from the biodiesel production process.

Jatropha curcas has great potential as an oil crop for use in biodiesel applications, and the outer shell is rich in lignocellulose that may be converted to ethanol, giving rise to the concept of a biorefinery. In this study, two dilute pretreatments of 0.5% H(2)SO(4) and 1.0% NaOH were performed on Jatropha shells with subsequent simultaneous saccharification and fermentation (SSF) of the pretreated water-insoluble solids (WIS) to evaluate the effect of inhibitors in the pretreatment slurry. A cellulase loading of 15 FPU/g WIS, complimented with an excess of cellobiase (19.25 U/g), was used for SSF of either the washed WIS or the original slurry to determine the effect of inhibitors. Ethanol and glucose were monitored during SSF of 20 g of pretreated biomass. The unwashed slurry showed to have a positive effect on SSF efficiency for the NaOH-pretreated biomass. Maximum efficiencies of glucan conversion to ethanol in the WIS were 40.43% and 41.03% for the H(2)SO(4)- and NaOH-pretreated biomasses, respectively.